2016 FORD EXPLORER Steering Problems

ON SEVERAL OCCASIONS WHEN I GO TO START THE VEHICLE I GET A MESSAGE ON THE LEFT SIDE OF THE DASH CLUSTER THAT SAYS " STEERING ASSIST FAULT FAILURE, SEEK SERVICE." THE VEHICLE WON'T START. AFTER I KEEP PRESSING THE START BUTTON IF WILL START. I CARRIED IT TO THE DEALER ( PARADISE FORD IN COCOA, FL) AND THEY SAID THERE WERE NO CODES IN THE SYSTEM BUT DID SAY THERE WERE A LOT OF PROBLEMS WITH THE STEERING FAILURE ON THAT MODEL AND WOULD COST AROUND $2,500.00 TO REPAIR OUT OF MY POCKET. THE VEHICLE ONLY HAS A LITTLE OVER 5,000 MILES ON IT AS OF 11/29/20.

WHEN BACKING OUT OF MY DRIVEWAY AND TURNING SLOWLY THERE IS A POPING NOISE AND MY STEERING WHEEL LOCKED UP MULTIPLE TIMES. BEFORE THIS I SPENT 1000 BUCKS TO GET THE WIRING HARNESS FOR AIR BAGS REPLACED. NONE OF THEM WORK FORD WOULD NOT COVER IT BECAUSE THERE IS NOT A RECALL.

WHEN I GO TO TURN, IT CONTINUES TO POP. THE TIE RODS HAVE BEEN REPLACED ALONG WITH RACK AND PINION BUT YOU COULD BE STOPPED AND APPLYING BRAKE AND TURN WHEEL AND IT POPS.

POWER STEERING LOCKED UP , WELL ITS ELECTRIC STEERING .AND THE WARRING LIGHTS CAME ON TERRAIN ASSIST AND HILL ASSIST DISABLED, SERVICE ADVANCE TRAC ,STEERING LOSS , I WAS TRAVELING ON THE FREEWAY DOING ABOUT 70 MILES AN HOUR WHEN THIS HAPPED I ALMOST LOSS CONTROL OF THE VEHICLE . THERE ARE SO MANY COMPLAINTS ABOUT THIS PROBLEM WITH THE FORD EXPLORE STEERING ISSUSE .

WHILE MOVING THE STEERING WHEEL THERE IS A WEIRD CLUNK/POP NOISE AND FEELS A BIT LOOSE. SO THIS IS CONCERNING 66,000 MILES ON MY VEHICLE. ALSO THE FRONT SUSPENSION IS VERY ROUGH AND I HAVE TAKEN VERY GOOD CARE. DEALERSHIP WAS NOT SURE WHAT IT WAS BUT STATED IT WAS SAFE

THE STEERING WHEEL LOCKED WHILE WE WERE DRIVING IN THE CAR. WE TURNED LEFT INTO THE GROCERY STORE AND THEN BACK RIGHT TO ENTER A PARKING SPOT AND THE STEERING LOCKED AND WE ALMOST RAN INTO A PARKED CAR. LUCKILY WE SLAMMED ON THE BRAKES IN TIME TO AVOID AN ACCIDENT. WE HAD TO CRANK THE STEERING WHEEL ALL THE WAY TO THE RIGHT TO ALLOW IT TO "RELEASE" AND GIVE US SOME STEERING BACK...BUT AFTER THAT THE STEERING NOW CLICKS WHILE YOU TURN LEFT OR RIGHT BADLY. WE TOOK IT INTO OUR DEALER...THEY SAID IT IS THE STEERING GEAR MOTOR. THE CAR WAS IN THE SAME DEALERSHIP 1 WEEK PRIOR TO THIS GETTING AN OIL CHANGE AND NO SIGNS OF MALFUNCTION OR WEAR/TEAR...WITHOUT WARNING THE STEERING LOCKED UP ON US...VERY FRIGHTENING...OUR CAR IS 4 YEARS OLD AND ONLY HAS 16,000 MILES ON IT. AND THEY CANNOT EXPLAIN EXACTLY WHY...

SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT FOR A WHILE THEN IT STARTED TO MAKE NOISE WHEN TURN THE WHEEL EITHER WAY. LOSING CONTROL DRIVING. READ ON THE NEWS, 1.2 MILLION EXPLORER RECALLED FOR THE STEERING ASSEMBLY RECALLED FOR SAME ISSUE BUT WHEN I CALL FORD THEY SAID THIS VIN WAS NOT PART OF RECALL. VERY DISAPPOINTED.

THE FIRST TIME MY STEERING GOT STIFF ON 09/13/2019 WHILE TRYING TO MAKE A LEFT TURN ON A CITY STREET. IN THE PROCESS OF MAKING THE LEFT TURN MY STEERING WHEEL GOT STIFF, AND THE STEERING FAULT HILL START AND TRAC LIGHT WENT ON. I WAS UNABLE TO CONTROL THE STEERING WHEEL WHICH CAUSE ME TO GET UP ONTO THE SIDE WALK AND ALMOST HITTING A TREE. I HAD TO SLAM ON MY BREAKS IN ORDER TO AVOID THE ACCIDENT. MY KIDS BODY JERK BACK AND FORTH REALLY HARD. I TURN MY CAR OFF AND BACK ON, AND THE STEERING WHEEL WAS WAS NO LONGER STIFF AND WORKING. I WAS ABLE TO DRIVE HOME. THE SECOND TIME STEERING WHEEL GOT STIFF WAS ON 10/05/2019. WHILE ON THE CURVE OF A RAMP TO GET OFF THE FREEWAY THE STEERING WHEEL GOT STIFF AGAIN AND THE STEERING FAULT, HILL START AND TRAC...

POWER STEERING FAILED COMPLETELY ON MY 2016 FORD EXPLORER WHILE DRIVING. DASHBOARD LIT UP WITH A STEERING ASSIST FAULT, AND THEN HILL ASSIST FAULT. STEERING THE VEHICLE TO SAFETY WAS VERY CHALLEGING. I WAS TURNING AT A LEFT TURN LIGHT AND ALMOST CRASHED INTO ANOTHER VEHICLE BECAUSE I COULD NOT STEER THE CAR. LOOKED IT UP ONLINE AND HAVE FOUND NUMEROUS OTHER ACCOUNTS OF THE SAME ISSUE WITH NO REPSONSE OR RECALL FROM FORD.

MY TIRE VALVE CORRODED AFTER 3 YEARS WITH THE CAR. WHICH CAUSED DAMAGE TO THE TIRE AND THE TIRE PRESSURE SENSOR. THE POWER STEERING WENT AT 67000 MILES. IT STOPPED WORKING COMPLETELY WHILE DRIVING, EXTREMELY SCARY. THE SERVICE DEPARTMENT AT THE DEALERSHIP SAID IT IS JUST SOMETHING THAT HAPPENS. $2400 FIX ON A 4 YEAR OLD CAR WITH 67000 MILES AND COULD HAVE CAUSED AN ACCIDENT.

STEERING WOULD LOCK UP AND YOU WOULD HAVE TO FORCE THE STEERING BACK TO DRIVE ABILITY. THE RACK AND PINION WAS WORN OUT, IN MY OPINION PREMATURELY. THIS HAPPENED WHILE THE VEHICLE WAS IN MOTION. THE FIRST TIME IT WAS NOTICE WAS ON HIGHWAY DRIVING IN A CONSTRUCTION ZONE. THE STEERING WOULD CATCH WHEN TURNING LEFT OR RIGHT AND YOU WOULD HAVE TO FORCE THE WHEEL TO STRAIGHTEN OUT THE VEHICLE.

STEERING WHEEL IS STIFF AND MAKES NOISE WHEN TURNING.

EVEN UNDER WARRANTY THERE WERE SPORADIC TIMES THE FRONT SUSPENSION/STEERING WOULD MAKE A LOAD THUMP NOISE. THIS USUALLY HAPPENED WHEN BACKING OUT OF THE DRIVEWAY AND SOMETIMES WHEN PULLING OUT OF A PARKING SPACE. THE DEALER COULD NEVER DUPLICATE THE NOISE SO THEY FOUND NOTHING WRONG WITH IT. NOW AT 48K MILES AND OUT OF WARRANTY THE SOUND HAPPENS MUCH MORE OFTEN. MY WIFE SAID ONCE THE STEERING APPEARED TO MOMENTARILY LOCK UP AND HAD TO PULL THE STEERING WHEEL PRETTY HARD TO FREE IT UP. I FOUND SEVERAL OTHER INTERNET SITES STATING THAT THE STEERING SYSTEM IS NEEDING REPLACED ON MANY EXPLORERS WITH RELATIVELY LOW MILES AT A COST TO THE OWNERS OF OVER $2000.

WHEN TURNING RIGHT AT A SLOW SPEED, HEAVY KNOCKING/THUMPING NOISE AND STEERING WAS JERKY. VEHICLE HAS 33,400 MILES. HAD IT REPAIRED AT THE FORD DEALERSHIP YESTERDAY AND THEY REPLACED THE RACK AND PINION AT A COST OF $1800. SINCE I READ THIS SEEMS TO BE A COMMON PROBLEM I ASKED IF THIS ISSUE HAS BEEN RECALLED AND WAS INFORMED IT WAS NOT.

STARTED HAVING ISSUES WITH THE STEERING AT 39,500 MILES. SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT. I TOOK IT TO FORD DEALERSHIP WHO INDICATED THE WHOLE STEERING ASSEMBLY NEEDED TO BE REPLACED. THIS CAR WAS BUILT AT THE CHICAGO PLANT LIKE ALL THE OTHER EXPLORERS THAT NEEDED THE STEERING ASSEMBLY REPLACED. FORD INDICATED THIS VIN WAS NOT PART OF RECALL.

STEERING STARTED MAKING A GRINDING NOISE TURNING LEFT OR RIGHT. INTERMITTENT SEVERE PULLING TO THE LEFT OR TURNING FROM LEFT TO RIGHT. HAPPENS AT LOW OR HIGH SPEED. STARTED ABOUT 58K MILES. CAR IS UNSAFE AND UN-DRIVABLE IN THIS CONDITION. ADVISED THE RACK AND PINION IS BAD AND NEEDS TO BE REPLACED AT APPROX $2000.

STARTED DRIVING AND RECEIVED A WARNING ON THE SCREEN SAYING "STEERING FAULT SERVICE NOW". LOTS POWER STEERING CONTROL. THANKFULLY WAS AT A LOW SPEED AND COULD STOP SAFELY BEFORE LEAVING OUR NEIGHBORHOOD. PUT VEHICLE IN PARK, POWERED OFF, POWERED BACK ON, AND WAS ABLE TO DRIVE AGAIN. VEHICLE HAS 56K MILES ON IT.

WHILE MAKING TURNS EITHER AT SLOW SPEEDS OR AT A COMPLETE STOP, THE STEERING MAKES POPPING SOUNDS. STEERING WHEEL ALSO LOCKS FOR HALF A SECOND. TOOK VEHICLE TO A SHOP AND WAS ADVISED IT WAS THE RACK AND PINION ON THE FRONT RIGHT TIRE AREA. THE VEHICLE IS A 2016 AND HAS 41K MILES. THIS ISSUE BEGAN MANIFESTING APPROXIMATELY TWO WEEKS PRIOR. ESTIMATED COST TO REPAIR IS $2500. ACCORDING TO VEHICLE FORUMS THIS IS A COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL.

MY WIFE WAS DRIVING DOWN THE ROAD WHEN THE STEERING QUIT. IT WAS PULLING FROM SIDE TO SIDE AND SHE ALMOST LOST CONTROL. STEERING FAILURE ALARMS WERE CONTINUING TO GO OFF. SHE WAS ABLE TO GET THE VEHICLE OFF THE ROADWAY AND AVOID A CRASH.

POWER STEERING WENT ON A 2016 FORD EXPLORER XLT WITH 57001 MILES ON IT. CHARGED FOR STEERING RACK/BOX REPLACEMENT PLUS OTHER ASTRONOMICAL FEES ASSOCIATED WITH IT OUT OF POCKET. THE VEHICLE IS SUPPOSED TO BE A FAMILY CAR. IT IS UNSAFE AND HASN'T BEEN THE SAME SINCE. CAR JUST GAVE OUT ON HIGHWAY WITH CHILDREN IN CAR. THE CAR STARTED TO ACTIVELY SWAY ALL OVER THE ROAD WITHOUT WARNING. NO CONTROL. HAD TO PULL OVER. CALLED FOR ASSISTANCE AND THAN RESTARTED THE CAR TO HAVE NO POWER STEERING WHAT SO EVER. IT WAS WORSE THAN TRYING TO DRIVE A HEAVY DUTY TRUCK. AS A FEMALE, I COULD NOT EVEN TURN THE STEERING WHEEL. NO CODES CAME UP PRIOR; UNTIL THE RESTART OF THE CAR. ???? DEALER TOOK WEEK TO GET IT IN PLUS A DAY FOR PART AND THOUSANDS OUT OF MY POCKET DURING A WORLD WIDE PANDEMIC. WITH MASSIVE...

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED TO THE FORD DEALER IN MY TOWN WHICH IS WAS 2 HOURS AWAY. FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY. COST OF REPAIR IS 2400.00 OF COURSE I HAVE A LIFETIME WARRANTY ON MOST PARTS INCLUDING FUEL PUMP, ENGINE ,TRANSMISSION BUT RACK AND PINION NOT CONSIDERED UNDER THIS WARRANTY. *TR

I WAS DRIVING HOME FROM DROPPING MY DAUGHTER OFF AT DAYCARE AND I LOST THE POWER STEERING ON MY VEHICLE WHILE THE VEHICLE WAS IN MOTION AND I WAS DRIVING A STEADY SPEED DOWN A STRAIGHT ROAD. MY DAUGHTER WAS NO LONGER IN THE CAR WITH ME AS THIS COULD HAVE RESULTED IN AN ACCIDENT BUT THANKFULLY SHE WAS NOT AND I WAS ABLE TO PULL OFF THE ROAD WITH A LOT OF EFFORT INVOLVED. MY CAR HAD TO BE TOWED TO THE FORD SHOP AND I HAD TO HAVE MY POWER STEERING CORE CHANGED. $2500. THIS CAR ONLY HAS 37,000 MILES AND IS A 2016 FORD EXPLORER. QUITE FRUSTRATING, DISAPPOINTING AND EXPENSIVE. THERE NEEDS TO BE A RECALL WITH THIS PROBLEM BECAUSE I AM NOT THE ONLY ONE THIS HAS HAPPENED TOO.

NOTICED PROBLEM WITH STEERING. WHEN I CHANGED LANES THE VEHICLE CONTINUED IN THAT DIRECTION UNTIL I CORRECTED IT. THIS HAPPENED SEVERAL TIMES WHILE DRIVING HOME FROM WORK SO I WENT STRAIGHT TO MATT BOWERS FORD IN METAIRIE. I WAS TOLD THE STEERING GEAR NEEDED TO BE REPLACED, THE MODULE REPROGRAMMED AND AN ALIGNMENT. I'VE SEEN QUITE A FEW RECALLS CONCERNING THIS BUT WAS NOT TOLD THAT MY VHEICLE VIN WAS NOT AFFECTED. I NOW SEE MANY PEOPLE ARE COMPLAINING OF THE SAME PROBLEMS. THIS SHOULD BE LOOKED AT CAREFULLY BEFORE SOMEONE GETS HURT.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED. LOCAL FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY.

I WAS TURNING INTO A GAS STATION AND THE POWER STEERING WENT OUT WITH NO PREVIOUS WARNINGS OR ISSUES.

LOSS OF STEERING WHILE DRIVING. NEARLY CAUSED A 4 CAR COLLISION. STEERING WHEEL LOCKED WHILE DRIVING 57 MPH. WAS BARELY ABLE TO SLOW DOWN AND PULL OFF TO THE SIDE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER AFTER THIS LAST TIME, THE STEERING WHEEL IS PERMANENTLY LOCKED. STEERING LOSS LIGHT CAME ON AFTERWARDS.

STEERING WAS GETTING DIFFICULT WHILE MAKING TURNS. TOOK IT TO A FORD DEALER AND WAS TOLD THE RACK & PINION NEED TO BE REPLACED FOR $2,560 AND IT IS UNSAFE TO DRIVE. FORD IS NOT COVERING THIS ISSUE EVEN THOUGH IT IS A FAULTY PART ON THEIR END AND SHOULD BE THEIR RESPONSIBILITY.

I WAS DRIVING ON THE HIGHWAY 65 IN HAM LAKE, MN SEVERAL WEEKS AGO WHEN I SUDDENLY LOST CONTROL OF THE STEERING. THE VEHICLE LUNGED TO THE LEFT TOWARDS THE DITCH. I WAS ABLE TO FISHTAIL IT BACK ONTO THE ROAD, ALMOST ROLLED THE VEHICLE AND BARELY KEPT IT UNDER CONTROL. I GOT OVER TO THE RIGHT SHOULDER AND CALL THE ANOKA COUNTY SHERIFF FOR ASSISTANCE. A DEPUTY ASSISTED BUT I DON'T BELIEVE A FORMAL POLICE REPORT WAS FILED. THIS WAS SUNDAY JULY 19TH. WE WERE ABLE TO GET TO LOCAL MECHANIC WHO LOOKED AT IT THE FOLLOW DAY AND DETERMINED THAT THE TOE CONTROL LINK HAD BROKEN. THEY REPAIRED IT WITH A NEW PART FROM THE LOCAL FORD DEALERSHIP AND THE VEHICLE SEEMED FINE. LAST NIGHT THE NEW PART THAT THEY INSTALLED BROKE AS WELL. I LOOKED ONLINE AND SEE THAT THERE IS A RECALL FOR THIS EXACT PART,...

I INITIALLY HAD 'STEERING FAULT' ALERT A FEW MONTHS AGO. JUST TODAY A 'TERRAIN MAINTENANCE FAULT' ALERT CAME UP WITH A FEW ALERTS ICONS ON THE DASHBOARD. THE STEERING FROZE TO THE POINT I COULD ONLY MOVE THE STEERING WHEEL AN INCH WHILE MUSCLING IT TO A STOP. APPARENTLY, ACCORDING TO THE DEALERSHIP, THIS IS A KNOW ISSUE. THEY HAD ME RESTART THE SUV AND THAT TEMPORARILY SOLVED THE ISSUE, BUT IT COULD HAPPEN AGAIN AT ANYTIME. THE DEALERSHIP SAID, IF THE ISSUE ISN'T OCCURRING WHEN I BRING THE SUV IN THEY CAN'T SPECIFICALLY DIAGNOSE THE PROBLEM, BUT MORE THAN LIKELY THE STEERING GEAR NEEDS TO BE REPLACE FOR ~$2K. AS I AM READING OTHERS, THIS IS AN ONGOING ISSUE THAT COULD PUT DRIVERS IN DANGER AND HAVE FOR OTHERS. I WAS IN MARSHFIELD, MA WHEN THIS HAPPENED, DRIVING 30 MPH APPROXIMATELY 2PM ON PLAIN STREET.

THE FLUIDITY OF THE STEERING IS DETERIORATING. WHEN TURNING THE WHEEL RIGHT OR LEFT THERE IS A GRINDING SOUND OF METAL ON METAL. INTERMITTENTLY I HAVE TO WRESTLE WITH THE STEERING WHEEL WHEN ACCELERATING THROUGH A TURN WHICH IS A MAJOR SAFETY CONCERN I HAVE AS I TYPICALLY AM TRAVELING WITH TWO YOUNG CHILDREN. THE PROBLEM HAS ARISEN IN THE PAST THREE MONTHS AND THE MECHANIC I UTILIZE, WHO DOES NOT REPAIR STEERING RACKS, REPORTED THAT THE COST OF ADDRESSING THE ISSUE COULD EXCEED $1000. THIS PROBLEM SHOULD NOT BE ASSOCIATED WITH A 2016 MODEL THAT JUST WENT OVER 50,000 MILES AND IS NOT SUBJECTED TO ROUGH, EXTENDED DRIVING BUT RATHER MOST DAYS ARE A 28 MILE ROUND TRIP FOR WORK.

49000 MILES, ELECTRONIC STEERING IS STARTING TO GO OUT. WHEN DRIVING MODERATE SPEEDS CAR MAKES LOUD AUDIBLE NOISES ESPECIALLY WHEN TURNING THE WHEEL. RACK AND PINION WILL NEED TO BE REPLACED. FORD TOLD ME IT WAS 100% SAFE TO DRIVE. TOOK TO INDEPENDENT MECHANIC WHO SAID THE EXACT OPPOSITE AND SHOULD BE REPLACED BEFORE IT GOES OUT HEAVEN FORBID AT HIGH SPEEDS.FAMILY OF 4 YOUNG KIDS, THIS IS SUPPOSED TO BE A SAFE, FAMILY CAR. FORD IS PUTTING A LOT OF FAMILIES AT RISK NOT RECALLING THIS. THIS CAR ONLY HAS 49K MILES. THEY ARE LOSING LOTS OF RETURN CUSTOMERS BY NOT HANDLING A SAFETY ISSUE PROPERLY. I HOPE NO DEATHS HAVE TO HAPPEN TO BRING MORE SEVERITY TO THIS PRESSING ISSUE. IF YOU HEAR A CLICK WHEN STEERING, GET THE CAR INSPECTED ASAP! CLICKING OCCURS WHEN STATIONARY AND IS MORE INTENSE WHEN DRIVING. IT COULD GO OUT AT ANY...

OUR 2016 FORD EXPLORER WITH ONLY 50K MILES STARTED TO HAVE VERY STICKY STEERING AND IT WOULD MAKE SOME CLUNKING NOISES WHEN TURNING. THIS PROGRESSIVELY GOT WORSE WHILE MY PREGNANT WIFE USED THE SUV AS A DAILY DRIVE UNTIL ONE DAY SHE SAID SHE NEARLY LOST CONTROL OF THE FORD AND HAD TO SWERVE OFF THE ROAD TO AVOID HITTING ONCOMING TRAFFIC. WE TOOK THE VEHICLE INTO HAROLD ZEIGLER FORD IN LOWELL, MI AND THEY SAID THAT THE ELECTRONIC STEERING GEAR HAD GONE BAD AND NEEDED TO BE REPLACED. THAT MEANS REPLACING THE ENTIRE STEERING ASSEMBLY WHICH IS A $2,200+ REPAIR. THAT IS WAY TO SERIOUS OF A REPAIR TO HAPPEN SO OFTEN AND THIS EARLY. BASED ON THE MANY SIMILAR ISSUES I HAVE READ ABOUT REGARDING THIS ISSUE AND THE FACT THAT FORD ALREADY HAD A SIMILAR RECALL FOR EARLIER YEARS OF THE EXPLORER, THIS NEEDS TO BE RECALLED....

WHILE DRIVING AT 75 MPH THE VEHICLE EXPERIENCED A LOSS OF POWER STEERING, THE WHEEL JERKED AND I ALMOST RAN OFF THE ROAD. THEN THE STEERING MADE GRINDING NOISES. THE DEALERSHIP WANTS $1500 FOR THE PART AND JUST AS MUCH OR MORE FOR THE LABOR, NOT COVERED UNDER WARRANTY AND THE VEHICLE ONLY HAS APPROXIMATELY 77000 MILES ON IT.

THE RACK & PINION MOTOR FAILED ON THIS VEHICLE AFTER ONLY APPROXIMATELY 40,000 MILES. IN THIS INSTANCE IT DID NOT CAUSE AN ACCIDENT. HOWEVER, I UNDERSTAND THAT THESE MOTORS ARE FAILING AT A RELATIVELY HIGH RATE AND STEERING COULD LOCK UP IN THESE VEHICLES WHILE DRIVING.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT AT START-UP OR WHILE DRIVING AND ATTEMPTING TO TURN IN EITHER DIRECTION, THERE WAS AN ABNORMAL KNOCKING SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO BOZARD FORD LINCOLN (540 OUTLET MALL BLVD, ST. AUGUSTINE, FL 32084, (904) 824-1641) TO BE DIAGNOSED. THE STRUT TOWER AND STEERING GEAR NEEDED TO REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE 78,105.

OUR 2016 FORD EXPLORER WITH 44K MILES IS MAKING KNOCKING SOUNDS WHILE TURNING. THE SOUND WAS INTERMITTENT AT TIMES SO NOT ALL TURNS MADE THE KNOCKING SOUND.WE HAD IT LOOKED AT BY A MECHANIC AND HE SAID THE RACK AND PINION STEERING IS GOING OUT. HE EXPLAINED IN MORE DETAIL, BUT THE GIST OF IT IS A REPAIR COST OF $2K ON A VEHICLE THAT'S NOT PAID OFF AND EXTREME HAZARD TO DRIVE. THIS IS A CRITICAL CONCERN FOR MANY FORD EXPLORER OWNERS THAT HAVE REPORTED THE SAME ISSUE. PLEASE INVESTIGATE.

STEERING FAULT LIGHT CAME ON TWICE IN TWO DAYS, BOTH INSTANCES HAPPENED AFTER TAKING OFF FROM A STOPLIGHT. TOOK THE VEHICLE IN THE DEALERSHIP WHERE THEY READ THE CODES AND IT CAME BACK THE STEERING ASSEMBLY WAS FAILING. THEY PROCEEDED TO TELL ME THAT THE STEERING COULD GO OUT ANY MINUTE. THE VEHICLE ONLY HAS 57K MILES ON IT BUT OF COURSE ISN'T COVERED UNDER POWER TRAIN WARRANTY. AFTER GOOGLING THE ISSUE, IT SEEMS AS THOUGH THIS IS A VERY COMMON PROBLEM AND THE DEALERSHIP CONVENIENTLY HAD THE A STEERING ASSEMBLY IN STOCK. NOT SURE WHAT THE HOLD UP IS FOR FORD TO ISSUE A RECALL! THIS COULD KILL SOMEONE.

WE OWN A 2016 FORD EXPLORER, AND HAVING MAJOR ISSUE WITH STEERING ASSIST FAULT SERVICE REQUIRED. WHICH MEANS NEW RACK SYSTEM AT $2,100 +. I'VE READ SO MANY OTHER PEOPLE WITH SAME PROBLEM, AND EVEN WITH PAST EXPLORERS WITH RECALLS. WHY HAS FORD NOT RECALLED THIS PROBLEM AS THEY DID WITH PAST EXPLORERS?? IT'S A DEATH TRAP, AND YOU WILL LIKELY WRECK WHEN THIS HAPPENS. I'M THE LUCKY ONE THIS TIME..

WHILE OPERATING THE VEHICLE WE NOTICED OVERTIME A CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE AS WE DROVE DOWN THE ROAD MAKING TURNS AND BACKING UP OUT OF A PARKING SPACE. WE HAVE READ ABOUT INSTANCES OF PEOPLE EXPERIENCING A PROBLEM DRIVING AND TRYING TO STEER THE CAR AND IT LOCKING PREVENTING STEERING OF THE VEHICLE. THIS HAPPENED TEMPORARILY TO US SO I AM REPORTING IT AS IT CAN BE WORSE DOWN THE ROAD AS A SAFETY HAZARD TO US AND OTHER PEOPLE ON THE ROAD. THE VEHICLE ONLY HAS 40,000 MILES AND SHOULD NOT BE EXPERIENCING THESE TYPES OF ISSUES SO EARLY AND OWNERSHIP. WE DRIVE THE VEHICLE LESS THAN 10000 MILES PER YEAR.

WHILE SITTING AT A STOP LIGHT MULTIPLE WARNING SENSORS WENT OFF AND WE LOST ALL POWER STEERING ONCE WE STARTED TO ACCELERATE THE CAR. WE TOOK THE CAR TO OUR MECHANIC WHO SAID THAT THE ENTIRE RACK AND PINION NEEDED TO BE REPLACED. THIS CAR HAS 53K MILES ON IT. I HAVE TWO SMALL CHILDREN AND HAD THIS HAPPENED ON A BUSY ROAD, IT WOULD HAVE PUT ALL OF US IN EXTREME DANGER. THERE WAS NO PREVIOUS WARNINGS, IT JUST WENT.

THIS IS A POLICE VEHICLE AND WHILE RESPONDING TO AN EMERGENCY CALL, THE STEERING FAULTED WITH A STEERING FAULT WARNING ON THE DASH. THE STEERING WHEEL LOCKED WITH VERY LITTLE CONTROL OF THE VEHICLE. THANKFULLY I WAS ABLE TO PLACE THE VEHICLE IN NEUTRAL AND SHUT DOWN AND RESTART THE VEHICLE AS I WAS ON A STRAIGHT AWAY! THIS RESET THE COMPUTER AND STEERING RETURNED. IT HAS HAPPENED AGAIN SINCE THIS OCCURRED, THIS IS GOING TO KILL SOMEONE!

WHILE DRIVING ON THE HIGHWAY (65 MPH SPEED LIMIT) MY POWER STEERING SUDDENLY STOPPED WORKING. AT THE HIGH SPEEDS I HAD VERY LITTLE CONTROL OF STEERING. I WOULD TURN THE CAR OFF & THE POWER STEERING WOULD COME BACK, THEN A FEW MINUTES LATER WOULD GO OUT AGAIN UNTIL THE POWER STEERING NO LONGER WORKED. HAD TO HAVE IT TAKEN TO THE GARAGE WHERE THEY SAID THE ENTIRE STEERING RACK NEEDS TO BE REPLACED. THIS IS OVER $2100 REPAIR ON A FAIRLY NEW VEHICLE AND SHOULD NEVER HAPPEN. THE GENTLEMAN AT THE GARAGE ALLUDED TO IT BEING A DEFECTIVE PART BUT FORD CUSTOMER SERVICE WILL DO NOTHING ABOUT IT. IT IS 100% ON ME TO GET REPAIRED. IT WAS VERY SCARY & LUCKY NO ACCIDENT OCCURRED WITH THE SUDDEN LOSS OF STEERING ABILITY. IT IS CURRENTLY AT THE GARAGE WAITING FOR THE PART TO BE SHIPPED. *TR

OUR STEERING WHEEL LOCKED UP WHILE TURNING IN AN INTERSECTION. THERE WAS ALSO A KNOCKING NOISE WHEN WE WOULD TURN THE WHEEL TO THE RIGHT. WHEN WE TOOK IT TO THE FORD DEALER THEY SAID THAT THE STEERING GEAR HAD GONE BAD AND WAS MOST LIKELY CAUSED BY A LEAK IN THE POWER TRANSFER UNIT OF POWER TRANSFER FLUID. THE SERVICE TECHNICIAN INDICATED THAT THERE WAS NOTHING THAT WE DID AS DRIVERS TO CAUSE THE PTU TO LEAK. WE HAVE SEEN MANY REPORTS ABOUT THE STEERING GEAR PROBLEMS IN THE YEAR AND MODEL OF OUR VEHICLE. THE COST TO REPAIR THE STEERING GEAR AND THE LEAK WAS OVER $5000.00.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE STEERING WHEEL CEASED WITH THE TRAC CONTROL WARNING LIGHT ILLUMINATED. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT DROVE THE VEHICLE TO HER RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. AN AUTHORIZED DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, INFORMED THE CONTACT THAT THE VIN WAS NOT SUBJECTED TO A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 81,000.

6/21/20 - STOPPED FOR GAS AFTER DRIVING APPROXIMATELY 150 MILES ON THE INTERSTATE. CRANKED CAR AND STEERING WOULD NOT WORK. DASH NOTICES: STEERING ASSIST FAULT SERVICE REQUIRED; SERVICE ADVANCETRAC; HILL START ASSIST NOT AVAILABLE; TRACTION LIGHT SHOWING OFF. DROVE CAR HOME WITH NO POWER STEERING. CALLED SELLING DEALERSHIP AND WAS TOLD PROBABLY COST AROUND $2000 TO REPAIR. SEARCHED ON LINE AND FOUND HUNDREDS OF COMPLAINTS ABOUT THIS BUT NO RECALL FROM FORD. PURCHASED NEW AND NOW HAS ONLY 61K MILES. RIDICULOUS! *TR

SATURDAY JUNE 20TH 2020 THE HILL ASSIST MESSAGE CAME ON AS DID THE ABS AND TRACTION CONTROL LIGHTS CAME ON. THERE IS NO POWER STEERING AND BOTH AXLES ARE MAKING A CLICKING NOISE. I HAVE LEARNED THAT THIS IS THE RACK AND PINION ELECTRONIC POWER ASSIST SYSTEM. EPAS UNIT HAS FAILED. LUCKILY IT WAS IN MY CUL DE SAC TURNING AROUND AND NOT ON THE FREEWAY. MY WIFE PREDOMINANTLY DRIVES THIS VEHICLE. THE STEERING IS VERY DIFFICULT TO MOVE. THE VEHICLE ONLY HAS 64,000 MILES ON IT. IS THIS A PRIVATE RECALL? I HAVE SPOKEN WITH A COUPLE OF OTHER EXPLORER OWNERS THAT FORD "TOOK CARE OF IT" FOR THEM. I HAVE ORDERED THE PART, BUT IT WILL NOT BE THERE FOR A WEEK. THIS CAR IS WELL TAKEN CARE OF AND IS NORMALLY DRIVEN ON CITY STREETS AND OCCASIONALLY ON THE HIGHWAY. *TR

I STARTED HEARING A KNOCKING IN THE FRONT END AND THE STEERING WAS VERY LOOSE, WHEN I TURNED RIGHT AT FIRST AND ON OCCASION TO THE LEFT MECHANIC SAID IF I HAD GONE MUCH FURTHER IT WOULD HAVE BROKEN ALL THE WAY AND I WOULD HAVE LOST ALL CONTROL OF THE SUV. *TR

I WOULD LIKE TO SHARE MY FORD EXPERIENCE WITH MY 2016 FORD EXPLORER LIMITED EDITION THAT WAS BOUGHT FROM HIGLEY FORD. AT 64,000 MILES... YES 4,000 OVER MY WARRANTY MY COMPUTER MODULE FRIED AND I HAD TO REPLACE THAT... $1500 OUT OF MY POCKET... THEN LAST SUMMER MY AC QUIT WORKING FOLLOWED BY MY DRIVERS SIDE SEAT HEATER AND MIRROR ON MY VISOR... THEN HERE RECENTLY I COULD SMELL SOMETHING LIKE BURNT RUBBER AND FOUND OUT SOME SEAL POPPED OFF SO OIL WAS LEAKING.... WHICH IS IN A SPOT THAT YOU CAN'T GET TO UNLESS YOU TAKE THINGS APART...THEN NOW JUST FOUND OUT MY RACK AND PINION WENT OUT... THE STEERING (PART ALONE COSTS $1500)!!! I WAS TOLD I SHOULD HAVE BOUGHT THE EXTENDED WARRANTY AND THAT WAS ALL I GOT. REALLY!!!!!!! ESPECIALLY THE RACK AND PINION! HOW THE HELL DOES THAT GO OUT...I'M A NIGHT NURSE THAT DRIVES TO...

I WAS DRIVING MY 2016 FORD EXPLORER ON MY LAST LEFT TURN TO MY HOUSE THE VEHICLE'S POWER STEERING COMPLETELY LOCKED UP I WASN'T ABLE TO STEER MY VEHICLE I HAD TO PUSH THE SUV BACK TO THE HOUSE.THERE WAS 3 LIGHTS CAME ON COME ON THE DASH BOARD WITH THESE MESSAGES.. 1 HILL START ASSIST NOT AVAILABLE..(I DON'T THINK THAT ITS EQUIPPED WITH THIS FUTURE) PRESS THE OK BOTTOM.SECOND LIGHT.. SERVICE ADVANCE TRACK THIRD LIGHT..STEERING ASSIST FAULT SERVICE REQUIRED.CANT DRIVE THE VEHICLE ANY MORE. NOW THERE ARE 203 COMPLAINS JUST ON STEERING MOST ARE ALL ABOUT STEERING WHEEL LOCKING UP.THIS IS SOMETHING WAY SERIOUS MOST OF THIS SUV'S ARE THE WIFE CAR ALWAYS PACK WITH CHILDREN. THE NHTSA AND FORD SHOULD REALLY LOOK N TO THIS JUST BEFORE ONE OF OUR LOVE ONES IS DRIVING ON THE FREEWAY AT 75 MPH AND IT LOCKS ON THEM IT WOULD BE...

THE 2016 EXPLORER EXPERIENCED A CLUCKING SOUND AND THE STEERING WOULD HITCH WHILE TURNING AT APPROX 50K MILES. VEHICLE WAS TAKEN TO DEALER BUT DEALER COULD NOT RECREATE. AT 60K MILES THERE WAS A CONSTANT CLUNKING AND STEERING STICKING WHILE TURNING THE WHEEL. VEHICLE WAS RETURNED TO DEALER FOR REVIEW, DEALER CONFIRMED THE RACK AND PINION WAS FAILING AND WAS A MAJOR SAFETY ISSUE. DEALER ALSO CONFIRMED THEY HAVE TO REPLACE MANY RACK AND PINIONS FOR EXPLORERS AND IT IS A PROBLEM BUT HEY CAN ONLY DO WHAT FORD INSTRUCTS. AFTER REVIEW ON THE NHTSA.GOV SITE, THERE ARE OVER 200 COMPLAINTS FOR THE SAME ISSUE WITH THE RACK AND PINION SYSTEM THAT OCCURS FROM 30K TO 60K MILES. THIS IS AN ISSUE THAT IS NOT BEING DEALT WITH BY THE MANUFACTURER AND NEEDS TO BE ADDRESSED SINCE MOST OF THESE VEHICLES ARE NOW HITTING THIS MILEAGE RANGE. *TR