2002 FORD EXPLORER Power Trainautomatic Transmissiontorque Converter Problems

2002 FORD EXPLORER - TRANSMISSION FAILED AT 65,000 MILES, IT WAS REBUILD AND FAILED AGAIN. MY REAR DIFFERENTIAL AND BEARING HAD TO BE REPLACED BECAUSE IT WAS GRINDING. *TR

AT 85K MILES, UNDER NORMAL DRIVING USE/CONDITION, THE TRANSMISSION AND REAR DIFFERENTIAL HAVE FAILED ON MY 2002 EXPLORER. THERE ARE FORD TSBS THAT IDENTIFY AND ACKNOWLEDGE THESE PROBLEMS AS EVIDENT IN MANY OF THEIR VEHICLES, YET REFUSE TO ABSORB ANY COST OF THE $3200 IT WILL TAKE TO REPAIR THEM. THE WHEEL BEARINGS ALSO CONTINUALLY FAIL AT A COST OF $500 EACH, AND HAVE BEEN REPAIRED AT LEAST 3 TIMES AT MY OWN EXPENSE. THE TORQUE CONVERTER AND BUSHINGS NEED REPLACED, AND THE TRANSMISSION COOLER IS WORN. MY MECHANIC EXPLAINED THESE SHOULD NOT WEAR AS QUICKLY AS 85K MILES, AND FROM THE CURRENT STATE OF ITS CONDITION, RECOMMENDED A COMPLETE TRANSMISSION REBUILD/REPLACE, ALONG WITH A NEW REAR DIFFERENTIAL GEAR SET. I HAVE COME INTO CONTACT WITH HUNDREDS OF FORD OWNERS, OF NEW AND USED VEHICLES ALIKE, WITH THE EXACT SAME PROBLEM AND AM SEEKING ALL RESOURCES AVAILABLE TO INITIATE A...

I HAVE BEEN DRIVING A 2002 EXPLORER FOR ABOUT 4 YEARS NOW. I AM CURRENTLY EXPERIENCING A MAJOR TRANSMISSION PROBLEM, AND JUST FOUND OUT LAST WEEKEND THAT THE REAR DIFFERENTIAL WAS GOING OUT. NOW, I DON'T KNOW MUCH ABOUT CARS SO I RELY ON OTHERS, BUT WHEN 3 DIFFERENT MECHANICS REPEATEDLY TOLD ME THAT THE REAR DIFFERENTIAL WAS GOING OUT, I THINK THAT MEANS SOMETHING IS WRONG. I WOULD NEVER HAVE GUESSED THAT A TRANSMISSION WOULD GO OUT AFTER JUST 5 YEARS, AND THE REAR DIFFERENTIAL IS JUST ICING ON THE CAKE. THE FACT THAT I HAVE READ SEVERAL OTHER COMPLAINTS REGARDING THIS SAME ISSUE AND YET FORD WANTS TO DO NOTHING ABOUT IT JUST TOTALLY DISGUSTS ME. MY FAMILY ARE VERY LOYAL TO FORD, EVEN HAVE A FEW RELATIVES THAT WORK FOR THEM. FORD NEEDS TO RECOGNIZE THAT THIS IS A MAJOR CONCERN AND DO SOMETHING ABOUT IT. HAVING...

FLASHING O/D INSTRUMENT LIGHT

FLASHING O/D INSTRUMENT LIGHT

TRANSMISSION BROKEN FORD DOESN T CARE BROUGHT IT TO SAM GALLOWAY FORD IN FORT MYERS AT LEAST 20 TIMES THEY FINALLY REFUSE TO TAKE VEHICLE INTO REPAIR WITH THE WORDS THERE IS NOTHING WRONG WITH IT TRANSMISSION SHIFTING HARD FROM 2-3 GEAR CAR IS SLOWER THEN A 4 CYLINDER NO POWER WHINING NOISE FROM UNDER THE HOOD IN THE MEAN TIME TRANSMISSION SLAMMING GEARS STILL NOTHING WRONG WITH IT HESITATING WHILE ACCELERATING GRINDING NOISES WHILE ACCELERATING WHINING FROM REAR END FORD STILL SAYS NOTHING WRONG TRANSMISSION WENT IN 1ST GEAR WHILE DRIVING 45 WIPED OUT ALOMST HIT A TREE STILL NOTHING WRONG CHECK ENGINE LIGHT IS ON FROM TIME TO TIME ERROR CODE SAYING FUEL SYSTEM BANK 2 HIGH VOLTAGE SYSTEM TOO RICH BROUGHT IT TO FORD ERROR CODES ERASED CAME BACK COUPLE DAYS LATER FORD SAYS THERE WHERE NO ERROR CODES

2002 FORD EXPLORER / TRASNMISSION FAILURE. *AK

TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE OVERDRIVE LIGHT WAS FLASHING ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO STATED THAT THE TRANSMISSION SHOULD BE REPLACED. THEY FURTHER STATED THAT THE FAILURE WAS CAUSED BY THE TORQUE CONVERTER CLUTCH OR THE SOLENOID PACK. THE CURRENT AND FAILURE MILEAGES WERE 88,000. *AK

ONGOING SHIFTING AND SLIPPING WITHIN THE TRANSMISSION. ALSO A LOUD SHRILL AT THE END OF THE ACCELERATION. THE TRANSMISSION CONVERTER HAS BEEN REPLACED MULTIPLE TIMES AND THE TRANSMISSION LEAKED OUT FLUID AT HIGHWAY SPEED. AFTER THE REPAIR OF A STRIPPED TRANSMISSION LINE CONNECTOR AND A PILE OF GLUE TO FIX A BROKEN ELECTRICAL CONNECTOR THE VEHICLE WAS RETURNED TO SERVICE BY THE DEALERSHIP AND THE WARRANTY COMPANY. THE CONVERTERS ARE "REMANUFACTURED" WHICH HAVE BEEN KNOWN TO FAIL. THE GLOB OF GLUE ON THE ELECTRICAL CONNECTOR WILL BE REVIEWED BY THE STATE AS TO THE PROPER REPAIR PROCEDURE. A LAW SUIT MAY FOLLOW DUE TO SEPARATE REPAIRS INCLUDING A TIRE WITH A NAIL, WHERE A NEW TIRE WAS PURCHASED AND A USED ON WAS INSTALLED (BF GOODRICH). THE TIRE WAS ALSO NOT BALANCED AND WAS OFF BY 1.5 OZ. THERE WAS ALSO A GASKET REMOVED FROM THE COOLING SYSTEM THAT CAUSED...

AUTOMATIC TRANSMISSION FAILURE (TORQUE CONVERTER?) *JB

ORIGINALLY INFORMED FORD DEALER OF LOUD SHUDDER IN VEHICLE UPON STARTING WHEN COLD AT ABOUT 11,000 MILES AND WAS TOLD THAT IS "NORMAL" FOR THIS TRANSMISSION AND THEY DO NOT KNOW WHAT CAUSES IT--"KEEP ON DRIVING IT." TRANSMISSION OVER-DRIVE LIGHT BEGAN TO FLICKER AT ABOUT 69,400 MILES. FORD SERVICE DEPARTMENT LOOKED INTO THE PROBLEM AND HAD THE VEHICLE FOR REPAIR FOR OVER THREE WEEKS. REPORTED BROKEN SEAL IN TRANS AND WORN TORQUE CONVERTER. TROUBLE "LOCKING OUT" AFTER REPAIR SO THEY REPLACED THE WARPED VALVE BODY.

I AM THE FLEET MANAGER OF THE BUFFALO GROVE PARK DISTRICT AND WE OWN FOUR FORD EXPLORERS TWO OF THE FOUR A 2002, AND A 2003, EXPLORER 4X4 XLT HAVE HAD NUMEROUS EXPENSIVE PROBLEMS SUCH AS WHEEL BEARING FAILURES THREE FAILURES ON THE 02 EXPLORER AND ONE ON THE 03, REAR STRUT FAILURE,SEALS LEAKING CONVERTER CLUTCH FAILURE,REAR AXLE NOISE GEAR WHINE,CLUTCH PACK NOISE,ALL THESE PROBLEMS ON VEHICLES THAT ARE OUT OF WARRANTY BY MILEAGE BUT ONLY A COUPLE TWO OR THREE YEARS OLD. THIS YEAR JAN 04 TO JAN 05 3,500 IN REPAIRS FOR THESE TWO VEHICLES, NOT INCLUDING THE REAR AXLE PROBLEMS ON THE 03, THIS IS "NOT ACCEPTABLE" P.S. THE MILEAGE 72,000 ON THE 02, AND 51,000 ON THE 03 *JB

MY FORD TRUCK BEGAN MAKING A WHINING NOISE AND DIDN'T SHIFT OUT CORRECTLY. THE FORD TECHNICIAN STATED THAT IT WAS THE TORQUE CONVERTER AND THEY DIDN'T SUGGEST THAT I FIX IT, AND THAT "IT WAS ONLY A GAS SAVER, AND THE TRUCK WOULD BE OKAY WITHOUT IT." AFTER 2 WEEKS THE TRUCK GOT WORST. AFTER RETURNING IT TO THE FORD SERVICE CENTER. I WAS TOLD I NEED A NEW TRANSMISSION. THE TRUCK ONLY HAS 67,000 MILES ON IT. TO REPLACE THE TRANSMISSION COST $2700.00. THE TRUCK IS OFF OF WARRANTY AND FORD WOULD NOT ASSIST WITH ANY TYPE OF HELP DESPITE THE FACT THAT THIS TRUCK SHOULD NOT BE HAVING TRANSMISSION PROBLEMS SO SOON.*AK

FROM PURCHASE THERE WAS A KHKHHHKH NOISE THAT MY BROTHER NOTICED. I TOOK IT BACK TO THE DEALER AND NOTHING WAS FOUND. ON THE 3RD TRIP BACK TO THE DEALER, I WAS TOLD THE TRANSMISSION SHIELD WAS LOOSE SO THEY TIGHTENED IT. THE NOISE CONTINUED SO I HAD MY NEIGHBOR WHO HAS A TRANS SHOP LISTEN AND HE SAID HAVE THEM LOOK AT THE TORQUE CONVERTOR. THE DEALER DID (34,000 MILES), HAD THE CAR FOR 14 DAYS AND FIXED?? IT. ITS BACK IN THE SHOP NOW (16 DAYS) (37,000 MILES) AND 1ST GEAR AND MY FORWARD CLUTCHES ARE BEING REPLACED. DID I GET A LEMON?*AK