Vehicle Safety Data

2002 FORD EXPLORER Suspensionrearsprings Problems

15 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Suspensionrearsprings Issues in the 2002 FORD EXPLORER

15 suspensionrearsprings complaints have been filed with NHTSA for the 2002 FORD EXPLORER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

15
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths

All Suspensionrearsprings Complaints

#10256361 |
DURING A SERVICE THE REAR SPRING WAS FOIND TO BE BROKEN IN TWO PLACES. THE FIRST TWO COILS OF THE RIGH REAR COIL SPRING WERE BROKEN. *TR
#10246926 |
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG INDICATOR REMAINED ILLUMINATED. THE DEALER STATED THAT THE SEAT BELT LATCH SYSTEM DOES NOT WORK AND THEY ARE CHARGING HIM TO DIAGNOSE AND REPAIR THE FAILURE. THE CONTACT STATED THAT IT IS A SAFETY HAZARD THAT THE SEAT BELT DOES NOT WORK. THE FAILURE AND CURRENT MILEAGES WERE 47,600. UPDATED 12/10/08 *CN BOTH OF THE REAR SPRINGS BROKE AND THE REAR AXLE BEARING WAS BAD. UPDATED 12/16/08. *JB
#10223204 |
FAILURE OF BOTH REAR SPRINGS ON 2002 FORD EXPLORER. 95,000 MILES, NORMAL DUTY (NEVER OVERLOADED). SPRINGS LITERALLY BREAKING APART STARTING AT TOP. SUSPECT DESIGN OR MATERIAL FLAW. INTERNET SEARCH INDICATES THIS IS NOT ISOLATED INCIDENT. SUSPECT FURTHER SPRING FAILURE COULD LEAD TO LOSS OF CONTROL/ROLL OVER. PLEASE INVESTIGATE -- IN MY OPINION THIS SHOULD BE SERIOUS SAFETY RECALL ITEM. *TR
#10219320 |
I FOUND AN ~3" LONG PIECE OF UNKNOWN STEEL IN MY GARAGE. NOTICED THE RIGHT SIDE OF THE VEHICLE WAS ABOUT 2" LOWER THAN LEFT. THE UNKNOWN STEEL WAS PART OF THE TOP OF THE COIL SPRING. ALSO, THE BOTTOM OF THE SPRING WAS BROKEN AND THE SPRING HAD COME TO REST ON THE LOWER SWING ARM. TOTAL OF 3 BREAKS ON THE RIGHT SIDE SPRING. WHEN THE VEHICLE WAS PLACED ON A LIFT THE RIGHT SIDE WAS FOUND TO HAVE TWO BREAKS, ALSO NEAR THE OPT OF THE SPRING. CALLED LOCAL DEALER AND WAS TOLD THEY HAVE REPAIRED 'A FEW OF THEM'. REPAIR GARAGE COULD NOT OBTAIN AFTERMARKET SPRINGS, THEY WERE TOLD THEY WERE ON NATIONAL BACKORDER. LOCAL DEALER WAS OUT AND RECEIVED 2 TODAY, WHICH WERE INSTALLED. I HAVE PLACED ~95% OF THE ~62,000 MILES AND VEHICLE WAS NOT ABUSED IN ANY FORM. OLD PARTS AND PICTURES ARE...
#10197372 |
BROKEN REAR COIL SPRINGS ON MY 2002 FORD EXPLORER. NOTICED WHEN CHANGING THE BRAKES. *TR
#10195144 |
BOTH REAR COIL SPRINGS BROKEN. VEHICLE DROVE NORMALLY TO DEALER FOR WHEEL BEARING REPLACEMENT. HOWEVER, MECH. FOUND BOTH COIL SPRINGS BROKEN WHILE REPLACING LEFT WHEEL BEARING. *TR
#10185496 |
TL*-THE CONTACT STATED THAT WHILE DRIVING 50 MPH IN THE 2002 FORD EXPLORER HE HEARD A LOUD NOISE COMING FROM THE BACK OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO DEALER FOR A WHEEL BEARING REPAIR WHEN THE ODOMETER REACHED 10,300 MILES, AND WAS INFORMED THAT BOTH THE REAR SPRING AND THE EMERGENCY BRAKE CABLE WERE FRACTURED. THE CONTACT STATED THAT HE TRIED TO GET A RESOLUTION FOR REPAIRS ON THE VEHICLE BECAUSE IT WAS STILL UNDER WARRANTY, BUT THE DEALERSHIP REFUSED TO REPAIR THE VEHICLE UNLESS THE CONTACT PAID FOR THE REPAIRS. THE CONTACT PURCHASED THE VEHICLE FROM WENTWORTH MOTORS , AND THEY TOLD THE CONTACT THAT HE HAD TO TAKE THE VEHICLE TO A FORD DEALERSHIP FOR THE REPAIRS. THE CURRENT MILEAGE WAS 10,600.*AK THE REAR SPRINGS FAILED. UPDATED 04/12/07. *JB
#10176184 |
AFTER NOTICING PROBLEMS WITH THE REAR SUSPENSION, IT WAS DISCOVERED BY MY DEALER THAT BOTH REAR SPRINGS WERE CRACKED, AND ALSO THE SHOCKS WERE FROZEN IN PLACE. I ASKED FOR THE OLD PARTS AND IT IS OBVIOUS FROM SEEING THE SPRINGS THAT THE BREAKAGE RESULTED FROM BAD STEEL. DEALER ADVISED ME IT IS NOT CURRENTLY UNDER RECALL. *NM
#10164814 |
DT*: THE CONTACT STATED WHILE TRAVELING AT VARIOUS SPEEDS, THE VEHICLE SOUNDED AS IF SOMETHING WAS RUBBING AGAINST THE GROUND. THE VEHICLE WAS PULLED OVER AND INSPECTED. THE REAR END WAS OBSERVED TO BE RIDING LOW. AN INDEPENDENT REPAIR SHOP DETERMINED THE REAR SPRINGS WERE FRACTURED AND THEY WERE REPLACED.
#10159448 |
2002 FORD EXPLORER'S REAR SPRINGS CRACKED. *TS *NM
#10154090 |
2002 EXPLORER REAR COIL SPRINGS BROKE AT 76,000 MILES. *TS THE FRONT BRAKE PADS WERE REPLACED. *JB
#10144191 |
2002 FORD EXPLORER BOTH REAR COIL SPRINGS BROKE. *JB
#10143225 |
BOTH REAR COIL SPRINGS BROKE ON BOTH SIDES OF FORD EXPLORER. *TS *JB
#10134440 |
BOTH REAR COIL SPRINGS ARE BROKEN - MILEAGE 50,000. JUST NOTED WHILE DOING UNDERCARRIAGE INSPECTION. *JB
#10117913 |
I TOOK MY 2002 EXPLORER IN FOR RECALL ON REAR DOOR. THEY TOLD ME THAT BOTH REAR SPRINGS BROKE. THIS VEHICLE HAS LESS THAN 44,000 MILES ON IT, AND HAS THE TOW PACKAGE ALTHOUGH NOTHING WAS EVER TOWED. THE SPRINGS THAT BROKE ARE AT THE VERY TOP AND HARD TO FIND. MECHANIC WOULD HAVE HAD TO KNOW TO LOOK THERE TO FIND IT. THIS LED ME TO BELIEVE THAT THERE HAVE BEEN OTHERS WITH THE SAME PROBLEM.*AK

Other 2002 FORD EXPLORER Problem Areas

Power Trainautomatic Transmission 887 complaints Power Train 286 complaints Suspensionrear 192 complaints Structurebodyhatchbackliftgatehinge And Attachments 166 complaints Power Traindrivelinedifferential Unit 160 complaints Electrical System 115 complaints Suspension 115 complaints Structurebodyhatchbackliftgate 112 complaints Steering 110 complaints Structurebody 110 complaints Vehicle Speed Control 103 complaints Air Bags 96 complaints Wheels 58 complaints Engine And Engine Cooling 56 complaints Suspensionfrontwheel Bearing 56 complaints Engine And Engine Coolingengine 50 complaints Engine 49 complaints Power Trainautomatic Transmissionlever And Linkagecolumn Shift 44 complaints Unknown Or Other 42 complaints Equipment 39 complaints Power Trainaxle Assembly 38 complaints Structure 38 complaints Suspensionrearspringscoil Springs 38 complaints Visibilityglass Siderear 38 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip 37 complaints Air Bagsfrontal 34 complaints Power Traindriveline 31 complaints Visibilitypower Window Devices And Controls 31 complaints Tires 29 complaints Power Traintransfer Case 4 Wheel Drive 28 complaints Fuel System Gasoline 27 complaints Steeringcolumn 25 complaints Vehicle Speed Controlaccelerator Pedal 25 complaints Engine And Engine Coolingenginegasoline 24 complaints Visibility 23 complaints Power Trainaxle Assemblyaxle Shaftseal 22 complaints Structurebodytailgate 22 complaints Seat Belts 21 complaints Latcheslockslinkages 19 complaints Air Bagsfrontalsensorcontrol Module 18 complaints Fuelpropulsion System 18 complaints Seats 18 complaints Vehicle Speed Controlcruise Control 17 complaints Parking Brake 16 complaints Power Trainaxle Hubs 15 complaints Service Brakes 15 complaints Service Brakes Hydraulic 15 complaints Power Trainautomatic Transmissiontorque Converter 14 complaints Structurebodydoor 14 complaints Suspensionfront 14 complaints Air Bagssidewindow 13 complaints Power Trainautomatic Transmissiongear Position Indication Prndl 13 complaints Power Trainmanual Transmission 13 complaints Equipmentapplianceair Conditioner 12 complaints Latcheslockslinkagesdoorslatch 12 complaints Latcheslockslinkageshatchbackliftgatelock 12 complaints Structurebodyhatchbackliftgatesupport Devicestrut 12 complaints Service Brakes Hydraulicfoundation Componentsdiscrotor 11 complaints Engine And Engine Coolingexhaust System 10 complaints Suspensionfronthub 10 complaints Visibilityrear Window Wiperwasher 10 complaints Wheelslugsnutsboltsstuds 10 complaints Exterior Lighting 9 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light 9 complaints Visibilitywiper 9 complaints Power Traindrivelinedriveshaft 8 complaints Vehicle Speed Controlcables 8 complaints Electrical Systemwiringinteriorunder Dash 7 complaints Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor 7 complaints Fuel System Otherstoragefuel Gauge System 7 complaints Interior Lighting 7 complaints Steeringrack And Pinion 7 complaints Suspensionrearaxlespindle 7 complaints Engine And Engine Coolingcooling System 6 complaints Latcheslockslinkagestailgatelatch 6 complaints Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm 6 complaints Structurebodytailgatehinge And Attachments 6 complaints Wheelshub 6 complaints Electrical Systemignitionswitch 5 complaints Electrical Systemwiring 5 complaints Exterior Lightingbrake Lightsswitch 5 complaints Fuel System Gasolinedeliveryfuel Pump 5 complaints Fuel System Other 5 complaints Power Trainaxle Assemblyaxle Shaft 5 complaints Seat Beltsfront 5 complaints Seatsfront Assemblyrecliner 5 complaints Service Brakes Hydraulicfoundation Components 5 complaints Structureframe And Members 5 complaints Visibilitydefrosterdefoggerhvac System 5 complaints Visibilitysunmoon Roof Assembly 5 complaints Electrical Systemwiringfuses And Circuit Breakers 4 complaints Fuel System Gasolinedeliveryhoses Linespiping And Fittings 4 complaints Power Trainclutch Assembly 4 complaints Seat Beltsfrontretractor 4 complaints Service Brakes Airantilockabs Warning Light 4 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule 4 complaints Service Brakes Hydraulicfoundation Componentsdiscpads 4 complaints Steeringhydraulic Power Assist System 4 complaints Suspensionrearaxlenon Powered Axle Assembly 4 complaints Tiressidewall 4 complaints Visibilitywindshield 4 complaints Electronic Stability Control Esc 3 complaints Engine And Engine Coolingexhaust Systememission Control 3 complaints Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe 3 complaints Equipment Adaptivemobility 3 complaints Equipmentmechanicalcarrierrack 3 complaints Fuel System Gasolinestorage 3 complaints Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap 3 complaints Seatsfront Assemblyhead Restraint 3 complaints Service Brakes Electric 3 complaints Steering Steering Wheelhandle Bar 3 complaints Steeringgear Box Other Than Rack And Pinion 3 complaints Structurebodydoorhinge And Attachments 3 complaints Tirestemporaryemergency Spare Tire 3 complaints Vehicle Speed Controllinkages 3 complaints Visibilityrearview Mirrorsdevicesexterior 3 complaints Electrical System Instrument Clusterpanel 2 complaints Electrical System12v24v48v Battery 2 complaints Electrical Systemignition 2 complaints Electrical Systemignitionanti Theftcontrol Module 2 complaints Electrical Systemignitionmodule 2 complaints Engine And Engine Coolingenginegasolinebelts And Associated Pulleys 2 complaints Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve 2 complaints Equipmentelectricalradiotape Deckcd Etc 2 complaints Equipmentrecreational Vehicletrailer 2 complaints Exterior Lightingheadlights 2 complaints Power Trainautomatic Transmissionparkneutral Start Interlock Switch 2 complaints Power Traindrivelinecenter Support Bearing 2 complaints Power Traindrivelineconstant Velocity Joint 2 complaints Power Trainmanual Transmissionfloor Shift Assembly 2 complaints Seat Beltsfrontbuckle Assembly 2 complaints Seatsmidrear Assembly 2 complaints Service Brakes Airantilock 2 complaints Service Brakes Hydraulicfoundation Componentsdisccaliper 2 complaints Service Brakes Hydraulicfoundation Componentsmaster Cylinder 2 complaints Service Brakes Hydraulicpedals And Linkages 2 complaints Steeringgear Boxshaft Sector 2 complaints Steeringlinkagestie Rod Assembly 2 complaints Suspensionfrontcontrol Armupper Ball Joint 2 complaints Suspensionfrontstabilizer Bar 2 complaints Suspensionrearshock Absorber 2 complaints Tirestreadbelt 2 complaints Visibilityrear Window Wiperwashermotor 2 complaints Visibilitywindshield Wiperwasher 2 complaints Visibilitywindshield Wiperwashermotor 2 complaints Wheelsmulti Piece 2 complaints Air Bagsfrontaldriver Sideinflator Module 1 complaint Air Bagson Off Switch Assembly 1 complaint Back Over Preventionwarningsexternalpedestrian Alert 1 complaint Electrical Systemalternatorgeneratorregulator 1 complaint Electrical Systemhorn 1 complaint Electrical Systemstarter Assemblysolenoid 1 complaint Electrical Systemwiring Rear Compartmenttrunk 1 complaint Electrical Systemwiringfront Underhood 1 complaint Engine And Engine Coolingcooling Systemfan 1 complaint Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv 1 complaint Equipmentelectricalnavigational Systemglobal Positioning System 1 complaint Exterior Lightingbrake Lights 1 complaint Exterior Lightingheadlightsswitch 1 complaint Exterior Lightingtail Lights 1 complaint Fuel System Gasolinedelivery 1 complaint Fuel System Gasolinestoragetank Assembly 1 complaint Latcheslockslinkageshoodlatch 1 complaint Parking Brakeconventionalmechanicallinkage And Cable 1 complaint Power Trainautomatic Transmissioncooling Unit And Lines 1 complaint Power Trainaxle Assemblybanjo Housing 1 complaint Seat Belts Rearotherbuckle Assembly 1 complaint Seat Beltsfrontanchorage 1 complaint Seat Beltsrearother 1 complaint Seatsfront Assemblypower Adjust 1 complaint Seatsfront Assemblyseat Heatercooler 1 complaint Service Brakes Airantilockcontrol Unitmodule 1 complaint Service Brakes Airdiscpads 1 complaint Service Brakes Hydraulicfoundation Componentsdifferential Proportional Valve 1 complaint Service Brakes Hydraulicfoundation Componentsdrum 1 complaint Steeringcolumn Lockinganti Theft Device 1 complaint Steeringrack And Pinionpinion Shaft 1 complaint Structurebodytrunk Lid 1 complaint Structureframe And Membersunderbody Shields 1 complaint Suspensionfrontcontrol Armlower Arm 1 complaint Suspensionfrontcontrol Armlower Ball Joint 1 complaint Suspensionfrontspringscoil Springs 1 complaint Tiresvalve 1 complaint Vehicle Speed Controlsprings 1 complaint Visibilitydefrosterdefoggerhvac Systemfanmotor 1 complaint Visibilitydefrosterdefoggerhvac Systemrear Window 1 complaint Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element 1 complaint Visibilityrear Window Wiperwasherlinkages 1 complaint Visibilityrearview Mirrorsdevices 1 complaint Visibilityrearview Mirrorsdevicesinterior 1 complaint Visibilitywindshield Wiperwasherswitchwiring 1 complaint Wheelshubcapcover 1 complaint Wheelsrim 1 complaint
← Back to 2002 FORD EXPLORER overview
Check any vehicle history by VIN - Free vehicle history report