Vehicle Safety Data

2002 FORD EXPLORER Fuel System Other Problems

5 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Fuel System Other Issues in the 2002 FORD EXPLORER

5 fuel system other complaints have been filed with NHTSA for the 2002 FORD EXPLORER. Of these, 0 involved a crash, 1 involved a fire, and 0 resulted in injury.

5
Complaints
0
Crashes
1
Fires
0
Injuries
0
Deaths

All Fuel System Other Complaints

#10293139 |
ACCELERATOR PEDAL STICKS WHEN WIDE OPEN THROTTLE SCENARIO PRESENTS ITSELF IN REAL WORLD APPLICATION ! 2002 FORD EXPLORER AUTOMATIC,TRANNY, FOUR WHEEL DRIVE. *TR
#10273684 |
WHEN I TRIED TO REMOVE MY KEY FROM THE IGNITION, THE ENTIRE IGNITION CYLINDER CAME OUT!! MY CAR HAD TO BE TOWED AND HAVE A NEW CYLINDER INSTALLED! A YEAR LATER, IT HAPPENED AGAIN!!! SO I HAVE HAD TO REPLACE MY FORD IGNITION CYLINDER TWICE AND MY CAR ONLY HAS 60,000 MILES ON IT NOW---SO PROBABLY HAD ONLY ABOUT 40,000 MILES THE FIRST TIME IT HAPPENED AND 50,000 THE SECOND TIME. ALSO-- NOW MY FUEL GAUGE SAYS EMPTY ALL THE TIME, EVEN AFTER I JUST FILLED IT WITH GAS! AND IT'S TOO EXPENSIVE TO FIX! I DID GET THE DRIVER SEATBELT FIXED, BECAUSE IT DIDN'T TIGHTEN, BUT NOW IT'S TOO HARD TO PULL OUT AND USE! LASTLY, BOTH INSIDE MIRROR COVERS HAVE JUST CRACKED OFF WHEN LIFTING OPEN, AND I CAN'T AFFORD TO REPLACE BOTH OF THE ENTIRE VISORS! WE HAVE 3 FORDS AND THIS IS THE ONLY ONE THAT'S...
#10246051 |
THROTTLE STUCK AND CAR WOULD NOT SLOW DOWN, ALMOST CAUSED AN ACCIDENT, PUT CAR IN NEUTRAL BUT ENGINE KEPT ON RACING, SEARCHED INTERNET ON FOUND THAT THE THROTTLE CABLE IS DEFECTIVE, FORD CHANGED DESIGN FROM 12 TO 9 WIRE DESIGN, SAW ALOT OF POSTS ON INTERNET WITH SIMILAR EXPERIENCES, CAN'T BELIEVE NO RECALL. CAR ACCELERATED ON ITS OWN. *TR
#10102256 | Fire
1. DRIVING APPROXIMATELY 30 MINUTES ON THE EVENING (7:30 PM) OF 12-4-04 TO A HOLIDAY PARTY WITH JUST MYSELF AND MY WIFE. UPON ARRIVING WITHIN SECONDS OF THE LOCATION AN ANONOYMOUS DIRVER STOPPED OUR VEHICLE AND MADE US AWARE THAT THERE WAS A FIRE COMING FROM UNDER OUR VEHICLE, A 2002 FORD EXPLORER XLT. AS WE JUMPED OUT OF THE VEHICLE AND SAW THE FIRE A NEIGHBOR WATCHING CALLED THE LOCAL FIRE DEPARTMENT. WITHIN MINUTES THE FIRE DEPARTMENT ARRIVED AND TRIED TO EXTINGUISH THE FIRE. BEING UNSUCCESFUL IT TOOK THE FIRE DEPARTMENT APPROXIMATELY AN HOUR TO STOP THE FIRE AT WHICH TIME THE VEHICLE WAS DESTROYED. THERE WAS NOTHING TO BE REPAIRED AS THE VEHICLE WAS DESTROYED. AND THERE HAD BEEN NO INDICATION THAT THERE WAS ANYTHING WRONG WITH THE VEHICLE PRIOR TO THIS INCIDENT.*AK
#10074832 |
I OWN A 2002 FORD EXPLORER 4 DOOR. THE REAR LEFT WINDOW WAS FAILING TO GO DOWN, AND WHEN IT DID IT WOULD TAKE TIME FOR IT TO GO BACK UP AGAIN. MY MOTHER PURCHASED A 2003 FORD EXPLORER AS WELL AND MY NIECE AND THEY TOO EXPERIENCED THE SAME PROBLEM. I ALSO HAD PROBLEMS WITH MY AIR LEAKING AND WAS INFORMED THAT SOME FORM OF AN INVISIBLE GAS WAS LEAKING INTO MY VEHICLE. I HAVE AN INFANT DAUGHTER AND WAS CONCERNED THAT SHE WAS BREATHING THIS.*AK

Other 2002 FORD EXPLORER Problem Areas

Power Trainautomatic Transmission 887 complaints Power Train 286 complaints Suspensionrear 192 complaints Structurebodyhatchbackliftgatehinge And Attachments 166 complaints Power Traindrivelinedifferential Unit 160 complaints Electrical System 115 complaints Suspension 115 complaints Structurebodyhatchbackliftgate 112 complaints Steering 110 complaints Structurebody 110 complaints Vehicle Speed Control 103 complaints Air Bags 96 complaints Wheels 58 complaints Engine And Engine Cooling 56 complaints Suspensionfrontwheel Bearing 56 complaints Engine And Engine Coolingengine 50 complaints Engine 49 complaints Power Trainautomatic Transmissionlever And Linkagecolumn Shift 44 complaints Unknown Or Other 42 complaints Equipment 39 complaints Power Trainaxle Assembly 38 complaints Structure 38 complaints Suspensionrearspringscoil Springs 38 complaints Visibilityglass Siderear 38 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip 37 complaints Air Bagsfrontal 34 complaints Power Traindriveline 31 complaints Visibilitypower Window Devices And Controls 31 complaints Tires 29 complaints Power Traintransfer Case 4 Wheel Drive 28 complaints Fuel System Gasoline 27 complaints Steeringcolumn 25 complaints Vehicle Speed Controlaccelerator Pedal 25 complaints Engine And Engine Coolingenginegasoline 24 complaints Visibility 23 complaints Power Trainaxle Assemblyaxle Shaftseal 22 complaints Structurebodytailgate 22 complaints Seat Belts 21 complaints Latcheslockslinkages 19 complaints Air Bagsfrontalsensorcontrol Module 18 complaints Fuelpropulsion System 18 complaints Seats 18 complaints Vehicle Speed Controlcruise Control 17 complaints Parking Brake 16 complaints Power Trainaxle Hubs 15 complaints Service Brakes 15 complaints Service Brakes Hydraulic 15 complaints Suspensionrearsprings 15 complaints Power Trainautomatic Transmissiontorque Converter 14 complaints Structurebodydoor 14 complaints Suspensionfront 14 complaints Air Bagssidewindow 13 complaints Power Trainautomatic Transmissiongear Position Indication Prndl 13 complaints Power Trainmanual Transmission 13 complaints Equipmentapplianceair Conditioner 12 complaints Latcheslockslinkagesdoorslatch 12 complaints Latcheslockslinkageshatchbackliftgatelock 12 complaints Structurebodyhatchbackliftgatesupport Devicestrut 12 complaints Service Brakes Hydraulicfoundation Componentsdiscrotor 11 complaints Engine And Engine Coolingexhaust System 10 complaints Suspensionfronthub 10 complaints Visibilityrear Window Wiperwasher 10 complaints Wheelslugsnutsboltsstuds 10 complaints Exterior Lighting 9 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light 9 complaints Visibilitywiper 9 complaints Power Traindrivelinedriveshaft 8 complaints Vehicle Speed Controlcables 8 complaints Electrical Systemwiringinteriorunder Dash 7 complaints Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor 7 complaints Fuel System Otherstoragefuel Gauge System 7 complaints Interior Lighting 7 complaints Steeringrack And Pinion 7 complaints Suspensionrearaxlespindle 7 complaints Engine And Engine Coolingcooling System 6 complaints Latcheslockslinkagestailgatelatch 6 complaints Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm 6 complaints Structurebodytailgatehinge And Attachments 6 complaints Wheelshub 6 complaints Electrical Systemignitionswitch 5 complaints Electrical Systemwiring 5 complaints Exterior Lightingbrake Lightsswitch 5 complaints Fuel System Gasolinedeliveryfuel Pump 5 complaints Power Trainaxle Assemblyaxle Shaft 5 complaints Seat Beltsfront 5 complaints Seatsfront Assemblyrecliner 5 complaints Service Brakes Hydraulicfoundation Components 5 complaints Structureframe And Members 5 complaints Visibilitydefrosterdefoggerhvac System 5 complaints Visibilitysunmoon Roof Assembly 5 complaints Electrical Systemwiringfuses And Circuit Breakers 4 complaints Fuel System Gasolinedeliveryhoses Linespiping And Fittings 4 complaints Power Trainclutch Assembly 4 complaints Seat Beltsfrontretractor 4 complaints Service Brakes Airantilockabs Warning Light 4 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule 4 complaints Service Brakes Hydraulicfoundation Componentsdiscpads 4 complaints Steeringhydraulic Power Assist System 4 complaints Suspensionrearaxlenon Powered Axle Assembly 4 complaints Tiressidewall 4 complaints Visibilitywindshield 4 complaints Electronic Stability Control Esc 3 complaints Engine And Engine Coolingexhaust Systememission Control 3 complaints Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe 3 complaints Equipment Adaptivemobility 3 complaints Equipmentmechanicalcarrierrack 3 complaints Fuel System Gasolinestorage 3 complaints Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap 3 complaints Seatsfront Assemblyhead Restraint 3 complaints Service Brakes Electric 3 complaints Steering Steering Wheelhandle Bar 3 complaints Steeringgear Box Other Than Rack And Pinion 3 complaints Structurebodydoorhinge And Attachments 3 complaints Tirestemporaryemergency Spare Tire 3 complaints Vehicle Speed Controllinkages 3 complaints Visibilityrearview Mirrorsdevicesexterior 3 complaints Electrical System Instrument Clusterpanel 2 complaints Electrical System12v24v48v Battery 2 complaints Electrical Systemignition 2 complaints Electrical Systemignitionanti Theftcontrol Module 2 complaints Electrical Systemignitionmodule 2 complaints Engine And Engine Coolingenginegasolinebelts And Associated Pulleys 2 complaints Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve 2 complaints Equipmentelectricalradiotape Deckcd Etc 2 complaints Equipmentrecreational Vehicletrailer 2 complaints Exterior Lightingheadlights 2 complaints Power Trainautomatic Transmissionparkneutral Start Interlock Switch 2 complaints Power Traindrivelinecenter Support Bearing 2 complaints Power Traindrivelineconstant Velocity Joint 2 complaints Power Trainmanual Transmissionfloor Shift Assembly 2 complaints Seat Beltsfrontbuckle Assembly 2 complaints Seatsmidrear Assembly 2 complaints Service Brakes Airantilock 2 complaints Service Brakes Hydraulicfoundation Componentsdisccaliper 2 complaints Service Brakes Hydraulicfoundation Componentsmaster Cylinder 2 complaints Service Brakes Hydraulicpedals And Linkages 2 complaints Steeringgear Boxshaft Sector 2 complaints Steeringlinkagestie Rod Assembly 2 complaints Suspensionfrontcontrol Armupper Ball Joint 2 complaints Suspensionfrontstabilizer Bar 2 complaints Suspensionrearshock Absorber 2 complaints Tirestreadbelt 2 complaints Visibilityrear Window Wiperwashermotor 2 complaints Visibilitywindshield Wiperwasher 2 complaints Visibilitywindshield Wiperwashermotor 2 complaints Wheelsmulti Piece 2 complaints Air Bagsfrontaldriver Sideinflator Module 1 complaint Air Bagson Off Switch Assembly 1 complaint Back Over Preventionwarningsexternalpedestrian Alert 1 complaint Electrical Systemalternatorgeneratorregulator 1 complaint Electrical Systemhorn 1 complaint Electrical Systemstarter Assemblysolenoid 1 complaint Electrical Systemwiring Rear Compartmenttrunk 1 complaint Electrical Systemwiringfront Underhood 1 complaint Engine And Engine Coolingcooling Systemfan 1 complaint Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv 1 complaint Equipmentelectricalnavigational Systemglobal Positioning System 1 complaint Exterior Lightingbrake Lights 1 complaint Exterior Lightingheadlightsswitch 1 complaint Exterior Lightingtail Lights 1 complaint Fuel System Gasolinedelivery 1 complaint Fuel System Gasolinestoragetank Assembly 1 complaint Latcheslockslinkageshoodlatch 1 complaint Parking Brakeconventionalmechanicallinkage And Cable 1 complaint Power Trainautomatic Transmissioncooling Unit And Lines 1 complaint Power Trainaxle Assemblybanjo Housing 1 complaint Seat Belts Rearotherbuckle Assembly 1 complaint Seat Beltsfrontanchorage 1 complaint Seat Beltsrearother 1 complaint Seatsfront Assemblypower Adjust 1 complaint Seatsfront Assemblyseat Heatercooler 1 complaint Service Brakes Airantilockcontrol Unitmodule 1 complaint Service Brakes Airdiscpads 1 complaint Service Brakes Hydraulicfoundation Componentsdifferential Proportional Valve 1 complaint Service Brakes Hydraulicfoundation Componentsdrum 1 complaint Steeringcolumn Lockinganti Theft Device 1 complaint Steeringrack And Pinionpinion Shaft 1 complaint Structurebodytrunk Lid 1 complaint Structureframe And Membersunderbody Shields 1 complaint Suspensionfrontcontrol Armlower Arm 1 complaint Suspensionfrontcontrol Armlower Ball Joint 1 complaint Suspensionfrontspringscoil Springs 1 complaint Tiresvalve 1 complaint Vehicle Speed Controlsprings 1 complaint Visibilitydefrosterdefoggerhvac Systemfanmotor 1 complaint Visibilitydefrosterdefoggerhvac Systemrear Window 1 complaint Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element 1 complaint Visibilityrear Window Wiperwasherlinkages 1 complaint Visibilityrearview Mirrorsdevices 1 complaint Visibilityrearview Mirrorsdevicesinterior 1 complaint Visibilitywindshield Wiperwasherswitchwiring 1 complaint Wheelshubcapcover 1 complaint Wheelsrim 1 complaint
← Back to 2002 FORD EXPLORER overview
Check any vehicle history by VIN - Free vehicle history report