2002 FORD EXPLORER Latcheslockslinkagesdoorslatch Problems

12 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Latcheslockslinkagesdoorslatch Issues in the 2002 FORD EXPLORER

12 latcheslockslinkagesdoorslatch complaints have been filed with NHTSA for the 2002 FORD EXPLORER. Of these, 1 involved a crash, 0 involved a fire, and 1 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Latcheslockslinkagesdoorslatch Complaints

#11102649 | June 19, 2018

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE DOOR AJAR AND BRAKE WARNING INDICATORS ILLUMINATED EVEN WHEN THE DOORS WERE CLOSED. THE CONTACT ALSO STATED THAT THE VEHICLE MADE AN ABNORMAL NOISE. AN INDEPENDENT MECHANIC WAS NOTIFIED AND DIAGNOSED THAT THE WHEEL BEARINGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE WHEEL BEARING FAILURE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT NHTSA WAS RESPONSIBLE FOR ALL RECALLS. THE CONTACT WAS TRANSFERRED TO NHTSA. THE FAILURE MILEAGE WAS NOT PROVIDED. *JS

#10220002 | March 4, 2008

REAR PASSENGER SIDE DOOR LOCKS WORK INTERMITTENTLY. DOORS WILL NOT UNLOCK WITH EITHER THE FRONT DOOR LOCK/UNLOCK BUTTONS OR THE WIRELESS KEY. *TR

#10217703 | February 11, 2008

MY FAMILY AND I WENT TO MY FAMILY MEMBERS HOUSE AND AFTER PUTTING THE VEHICLE IN PARK AND UNLOCKING THE DOORS MY DAUGHTER'S DOOR (REAR PASSENGER) WOULD NOT UNLOCK NOR OPEN FOR THE INSIDE OR OUTSIDE, BY SWITCH NOR MANUALLY. FOR MY DAUGHTER TO EXIT THE VEHICLE SHE HAD TO CLIMB IN THE FRONT SEAT TO EXIT THE VEHICLE, WE HAVE A BABY THAT RIDES IN A CAR SEAT SO SHE COULDN'T EXIT ON THE DRIVER PASSENGER SIDE. I'VE DISCOVERED THAT THE ONLY WAY TO FIX THIS IS TAKE THE PANEL OFF AND TAKE THE ONE SCREW OFF THAT HOLDS THE HANDLE MECHANISM AND PULL IT A FEW TIMES TO FINALLY RELEASE THE LATCH. I JUST READ ABOUT A FORD RECALL ON FAULTY LATCHES. THE ONLY DIFFERENCE IN THIS RECALL AND MY LATCH ISSUE IS MY LATCH WILL NOT RETURN TO AN OPEN STATE. I FEEL THAT MY ISSUE IS...

#10186003 | March 23, 2007

I HAVE A 2002 FORD EXPLORER XLS THAT WAS PURCHASED NEW. APPROXIMATELY 1 YEAR AFTER PURCHASE STARTED DEVELOPING A CRACK ON THE PANEL BENEATH THE REAR WINDOW. SINCE THEN, WHEN IT IS HOT, I GET A DOOR OPEN WARNING LIGHT. NO DOOR IS OPENED, BUT THE DOORS REFUSE TO LOCK, AND THE WARNING LIGHT STAYS ON. I BELIEVE WATER ENTERS THE PANEL BENEATH THE WINDOW DUE TO THE CRACK. I HAD IT LOOKED AT BY DEALERS FOR THE WARNING LIGHT-THEY CANNOT FIGURE IT OUT.*AK

#10170694 | October 12, 2006

EACH WINTER SINCE PURCHASING MY 2002 FORD EXPLORER THERE HAVE BEEN DAYS WHEN THE DOOR WOULD NOT LATCH SHUT AND I WAS FORCED TO WAIT FOR THE MECHANISM TO THAW OR USE ONE HAND TO KEEP THE DOOR FROM FLYING OPEN AS I DROVE. AFTER THAWING OUT THE DOOR WOULD LATCH AND I COULD CONTINUE SAFELY. I ALWAYS THOUGHT THAT THIS WAS A PROBLEM ISOLATED TO MY VEHICLE THOUGH AFTER HEARING OF THE RECENT RECALL I AM CERTAIN THIS IS ANOTHER IN A LONG LIST OF DEFECTS I HAVE EXPERIENCED. IN FACT ON JULY 30, 2005 WEST HERR FORD OF HAMBURG, NY HAD TO REPLACE BOTH FRONT DOOR LOCK ACTUATORS BECAUSE THE DRIVERS SIDE DOOR WOULD NOT LOCK AND THE PASSENGER SIDE WOULD NOT OPEN FROM THE OUTSIDE. I NOW WONDER IF THE CONSTANT FREEZE / THAW CYCLE OF THE WATER THAT OBVIOUSLY LEAKS INTO THE DOOR CAUSED THIS DAMAGE....

#10156925 | May 6, 2006

THE FRONT DRIVER SIDE DOOR WILL NOT LATCH WHEN THE OUTSIDE TEMP IS BELOW FREEZING. I HAD TO WARM THE TRUCK UP FOR 10 MINUTES TO HEAT UP SO THE DOOR WOULD CLOSE CORRECTLY. THIS IS A SAFETY HAZARD AND I THINK THE DOOR LATCH SHOULD BE RECALLED BECAUSE IF THE DOOR DOES NOT LATCH CORRECTLY SOMEONE CAN BE SERIOUSLY INJURED. *NM

#10148759 | January 26, 2006

DT*: THE CONTACT STATED THE AIR BAG LIGHT INTERMITTENTLY ILLUMINATES. THE VEHICLE WAS SEEN BY A DEALER. THE SERVICE DEPARTMENT DETERMINED BOTH FRONT SEAT BELTS NEEDED TO BE REPLACED DUE TO THE INTEGRATED AIR BAG/SEAT BELT SYSTEM. THE ENTIRE FRONT SEAT BELTS WERE REPLACED ACCORDINGLY BUT THE AIR BAG LIGHT LATER ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE SERVICE DEPARTMENT SUGGESTED REPLACING THE SEAT BELTS AGAIN. UPDATED 3/3/2006 - THE CONSUMER HAS ALSO HAD TO REPLACE THE REAR WASHER MOTOR, ODOMETER AND HAS HAD PROBLEMS WITH THE AUTOMATIC DOOR LOCKS. *NM

#10147859 | January 16, 2006

DRIVERS SIDE DOOR WILL NOT LATCH OR LATCHES POORLY DURING COLD WEATHER AFTER OPENED. DOOR HAS SWUNG OPEN WHILE BEING DRIVEN. HAS BEEN TO THE DEALER 4 TIMES WITH NO REMEDY. DEALER HAS "ADJUSTED DOOR AND LUBED LOCK". DEALER OFFERED TO REPLACE LATCH AND CABLE BUT DID NOT THINK THAT WOULD FIX THE PROBLEM. *NM

#10110740 | February 18, 2005

DOOR LOCKS FREEZE AT TEMP. BELOW 30 DEG. F. THIS OCCURS ON BOTH FRONT DOORS. THIS PREVENTS THE LATCH FROM CLOSING COMPLETELY. THE PASSENGER DOOR HAS OPENED WHEN THE TRUCK MADE A RT. HAND TURN. THIS HAS BEEN AN ONGING ISSUE. THE TRUCK WAS TAKEN IN LAST YEAR FOR THIS ISSUE. THE DOOR STRIKER WAS ADJUSETED,. THE DEALER WILL NOT COVER THIS UNDER WARRENTY BECAUSE IT IS NO LONGER COVERED.*AK

#10094343 | September 27, 2004

CONSUMER EXPERIENCED PROBLEMS WITH THE REAR UPPER WINDOW LOCKING AND UNLOCKING FOR NO REASON WHILE DRIVING. CONSUMER HAS FOUR CHILDREN AND WAS SCARE D SOMETHING WILL HAPPEN TO THE CHILDREN. VEHICLE WAS INSPECTED AT TWO DIFFERENT DEALERSHIP 4 TIMES, AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK

#10088660 | August 27, 2004 Crash

OCTOBER 2001, I PURCHASED A NEW 2002 FORD EXPLORER FROM DON REID FORD MAITLAND, FLORIDA. I EXPERIENCED ONE PROBLEM AFTER THE OTHER WITH MY WINDOWS AND DOORS. FIRST, THE BACK HALF DOOR CAME OPEN AND REFUSED TO CLOSE. THE DEALER REPAIRED IT. NEXT, THE REPLACEMENT REFUSED TO WORK; THE DEALER ORDERED THE PART AND REPAIRED IT. NEXT, THE ENTIRE BACK WINDOW, CRASHED TO THE GROUND. I PLACED THE DRAGGING PART IN THE BACK OF MY TRUCK AND STOPPED AT GREENWAY FORD. GREENWAY REFUSED THE REPAIR AND SENT ME WHERE I PURCHASED IT. DON REID KEPT THE TRUCK A FEW DAYS AND REPAIRED IT. NEXT, SCREWS ON THE PASSENGER SIDE DOOR CAME OUT, THAT DOOR WOULDN'T CLOSE. FED UP WITH REPEATED TRIPS TO DON REID I HAD MY HUSBAND FIX IT, THE DOOR CAME LOOSE AGAIN. I'M AT THE LIMIT ON WHAT I'LL ENDURE FROM A VEHICLE I'M PAYING NEARLY $500.00/MO...

#758096 | February 12, 2002

DOOR HANDLES KEEP BRAKING/DRS WILL NOT OPEN/ OWN 2 OF SAME HAVE GONE THROUGH 5 HANDLES ON EACH TRUCK / FORD WAS NO HELP/ IN AN EMERGENCY THE DOORS COULD FAIL TO OPEN/ DEALER SAID THEY'RE STOCKING CASES OF HANDLES TO REPLACE W/SAME DEFECTIVE PARTS/ MY 3 YEAR OLD SON TRIED TO OPEN THE DOOR, AND IT BROKE / HE COULD NOT APPLY MUCH FORCE. *AK

Other 2002 FORD EXPLORER Problem Areas

← Back to 2002 FORD EXPLORER overview