2002 FORD EXPLORER Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip Problems

PROBLEMS WITH THIS EXPLORER OVER MY OWNERSHIP INCLUDE: -REAR GLASS REPLACED -FRONT BRAKES REPLACED -REAR WHEEL BEARINGS HAVE REQUIRED REPLACEMENT, -PARKING BRAKE ISSUES, -NEW TIRES, ETC. *TR

WHERE TO START... BROKEN CRUISE CONTROL, HEADLIGHT SWITCH HAS A SHORT, DRIVER SIDE PASSENGER WINDOW DOESN'T ROLL DOWN, TROUBLE GOING INTO GEAR, CAR SUDDENLY DIES AT INTERSTATE SPEEDS, LOUD GRINDING SOUND FROM THE ENGINE BAY (LIKE AN ELECTRIC KNIFE SHARPENER) THAT IS GETTING INCREASINGLY MORE FREQUENT, SERVICE ENGINE SOON LIGHT WILL NOT GO OFF, BRAKES SQUEAL AND DON'T STOP THE VEHICLE PROPERLY, SUPPORT FOR THE HATCH (WHICH IS CRACKED 8 INCHES OR SO IN TWO PLACES) DOESN'T LIFT HATCH COMPLETELY, AND THE FUEL ECONOMY IS DOWN TO 4-6 MPG IN THE CITY. I HATE IT! I DON'T FEEL LIKE MY GIRLFRIEND IS SAFE DRIVING IT, AND I THINK FORD SHOULD BE FORCED TO MAKE THEIR WRONGS INTO RIGHTS! *TR

AFTER NORMAL DRIVING I BEGAN TO HEAR A LOUD GRINDING AND HUMMING NOISE COMING FROM THE REAR DRIVERS SIDE TIRE OF MY 2002 FORD EXPLORER. AFTER GOING TO MY MECHANIC HE HAD SAID MY REAR BEARING AND HUB ARE BAD WHICH ALSO MADE MY REAR TIRE UNSTABLE. HE BEGAN TO TELL ME IT IS A MAJOR PROBLEM WITH THIS VEHICLE AND THE BEARINGS, HUBS, AND BRAKES WERE DEFECTIVE DUE TO THE FACT THAT THEY CANNOT HANDLE THE BRAKING LOAD OF THIS VEHICLE. AFTER RESEARCHING THE PROBLEM ONLINE IT WOULD SEEM HE IS CORRECT. THIS IS A MAJOR SAFETY PROBLEM IN THAT ALL THE BEARINGS AND HUBS EVENTUALLY GO BAD AND CAN FAIL AT ANYTIME MAKING THE TIRES UNSTABLE AND COULD FALL OFF DURING DRIVING. THIS IS OBVIOUSLY A DEFECTIVE DESIGN AND /OR PARTS INSTALLED IN THIS VEHICLE. THERE ARE MANY COMPLAINTS OF THE SAME EVENTS HAPPENING TO OTHER OWNERS. SINCE...

2002 FORD EXPLORER FRONT AND REAR WHEEL BEARING REPLACEMENT. BACK RIGHT WHEEL BEARING FAILED CAUSING DAMAGE TO THE AXLE, BREAKS AND WHEEL DRUM. FRONT LEFT WHEEL BEARING FAILED. IN BOTH OCCASIONS NOISES WERE HEARD. IN REGARDS TO BE BACK WHEEL BEARING THE TIRE ALMOST CAME OFF AND THE WHEEL FROZE. THIS OCCURRED WHILE ON A MAJOR INTERSTATE TRAVELING AT A SPEED OF 65 MILES AN HOUR. BACK WHEEL BEARING, AXLE, DRUM AND BRAKES REPLACED AT A FORD DEALER, COSTING OVER $1700 DOLLARS. FRONT WHEEL BEARING BEGAN MAKING A THUMPING NOISE AND WAS REPLACED AT A LOCAL MECHANIC COSTING $500. IN CONTACTING FORD I WAS TOLD THERE WAS NOTHING THEY COULD DO. *TR

I OWN A 2002 FORD EXPLORER XLT, I HAVE HAD PROBLEMS WITH MY ABS LIGHT COMING ON AND MY BRAKES NOT WORKING CORRECTLY, THEY PULSATE AS IF THEY ARE TRYING TO ENGAGE EVEN WHEN IT IS 90 DEGREES OUTSIDE AND COMPLETELY DRY. NOTHING UPSETS ME MORE THAN HAVING TO PUT ON MY BRAKES AND HAVING THE FEELING THEY ARE NOT GOING TO WORK. THIS PUTS ME IN DANGER AS WELL AS THOSE WHO OWN THIS MODEL. I AM SCARED TO DRIVE IT ANYMORE. I AM ASKING FOR HELP HERE BEFORE I KILL MYSELF, MY FAMILY OR SOME RANDOM PERSON BECAUSE OF FAULTY BRAKES. I DON'T THINK I SHOULD HAVE TO PAY OUT OF POCKET FOR FAULTY ABS PROBLEM THAT FORD HAS SCREWED UP ON. BELOW IT ASKS FOR AN INCIDENT DATE, LET ME TELL YOU THERE HAVE BEEN SEVERAL TIMES IN WHICH THEY KICK ON AND IT FEELS LIKE I'M...

TL* THE CONTACT OWNS A 2002 FORD EXPLORER LTD. THE ABS LIGHT CONTINUED TO ILLUMINATE. THE FAILURE MILEAGE WAS 58800. THE DEALER INFORMED THE CONTACT THAT THEY DIDN'T HAVE THE PART TO REPAIR THE VEHICLE. ALSO, THE DEALER STATED THAT THEY WERE UNABLE TO DIAGNOSE WHAT WAS CAUSING THE ABS LIGHT TO STAY ON CONTINUOUSLY. THE DEALER CALLED FORD , AND THEY WERE RESEARCHING THE CAUSE OF THE FAILURE. THE CURRENT MILEAGE WAS 60000. *AK

EXPLORER MAKES WHINING NOISE IN REAR END AT SPEEDS BETWEEN 45 AND 70 MPH. THE ABS LIGHT STAYS LIT CONTINUOUSLY EVEN AFTER HAVING THE BRAKE SYSTEM SERVICES. HAVE ALSO HAD FRONT WHEEL BEARINGS REPLACED ALL THIS SINCE THE VEHICLE REACHED 60,000 MILES IT NOW HAS 86,000 AND MECHANIC SAYS IT NEED A NEW REAR END. *JB

2002 FORD EXPLORER. ABS LIGHT CAME ON INTERMITTENTLY BEGINNING IN 2005 ONLY AFTER EXTENDED TRIPS (ABOUT 60+ MILES), THEN CAME ON AND STAYED ON IN 4-2006. THE ABS SENSOR AND BRAKE SWITCH HAD TO BE REPLACED. MY MECHANIC SAID FORD HAD A RECALL. BUT WHEN I CONTACTED THE DEALER, THEY SAID IT WAS ONLY ON A CERTAIN TRUCK. *JB

ON OR ABOUT NOVEMBER 3, 2005, I PURCHASED A BREAK MODEL USED FORD EXPLORER XLT 2002 FROM NORM REEVES HONDA CAR DEALER IN CERRITOS, CA. THE CAR HAD 78,000 MILES ON IT AT THE TIME OF PURCHASE. I SIGNED THE PAPERS AND TOOK THE POSSESSION OF THE CAR. IT HAS NOT BEEN MORE THAN 2 MONTHS THAT THE CAR STARTED GIVING ME TROUBLE ON THE PICK UP OF THE SPEED, TRANSMISSION, GEAR ADJUSTMENT, OVER USE OF THE GAS, DIFFICULT HIGH ALTITUDE DRIVING EVEN AFTER CHANGE OF GEARS, AIR SUCTION INTO THE ENGINE AND TRANSMISSION, ACCELERATOR AND SIGNS LIKE SERVICE ENGINE SOON ON THE FRONT PANEL, ALTHOUGH I HAVE BEEN GETTING REGULAR LUBE AND TUNE ON THE CAR AFTER EVERY 3000 MILES. WHILE DRIVING THE, OCCASIONALLY, THE CAR GIVES A THUNDERING NOISE ON THE TIRES AS IF IT IS DRAGGING ITSELF AND RUNNING ON THE ROAD. THIS MAKES ME FEAR THAT...

FORD EXPLORER 2002 2 WHEEL DRIVE WAS DRIVING AT 65 MPH ON FREEWAY. A CAR CUT OFF THE FORD AND ANTI LOCK BRAKES WERE APPLIED. BRAKES LOCKED AND DRIVER LOST CONTROL OF SUV. SUV ROLLED OVER AND OFF THE FREEWAY. SIDE AIR BAGS AND FRONT AIR BAGS DID NOT DEPLOY. *JB

WHEN WE FIRST BOUGHT OUR 2002 EXPLORER XLT FROM FINKS USED CAR LOT IN ZANESVILLE OHIO IT HAD ABOUT 22 OR SO THOUSAND MILES ON IT AND WE REQUESTED A CHECK UP ON THE VEHICLE. THE BACK HATCH BRACKETS WAS REPLACED, AND THE BACK WHEEL BRAKES WERE STICKING AND BURNING, LOCKING UP. THAT PROBLEM SEEMED TO BE FIXED. THEN THE ANTILOCK BRAKE SYSTEM LIGHT STARTED COMING ON AND THE FRONT BRAKES SEEMED TO BE GRABBING....JUST LAST MONTH. I HAD THE CRUISE CONTROL SET ON THE VEHICLE ONCE AND IT SMELLED LIKE SOMETHING SMOLDERING SO I SHUT IT OFF AND IT HASN'T BEEN ON SINCE. I CALLED THE FORD GARAGE TO ASK IF MY CRUISE CONTROL WAS ON THE FIRE HAZARD LIST BECAUSE THE VEHICLE WAS BUILT IN 2001. I WAS TOLD IF I DID NOT RECEIVE A LETTER IN THE MAIL IT WOULDN'T BE REPLACED. THIS VEHICLE WAS STILL UNDER...

STEERING COLUMN BROKE WHILE DRIVING. CONSUMER APPLIED THE BRAKES, AND THE PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND IT CRASHED INTO A GUARD RAIL. UPON IMPACT, BOTH AIR BAGS FAILED TO DEPLOY. DRIVER SUSTAINED MINOR INJURIES, AND WENT TO THE DOCTOR ON HER OWN. VEHICLE WAS TOWED, AND TOTALED OUT BY THE INSURANCE COMPANY.*AK

THIS VEHICLE EXPERIENCED MULTIPLE PROBLEMS, AND THE DEALER WAS AWARE OF THE PROBLEMS. CONSUMER APPLIED THE BRAKES, AND THE PEDAL WENT TO THE FLOOR. VEHICLE SWAYED FROM LEFT TO RIGHT ON ITS OWN. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. ALSO, DOOR RUBBER PANEL FAILED TO STAY ATTACHED TO THE DOOR. MECHANIC DETERMINED THAT THE BRAKE PROBLEM COULD NOT BE DUPLICATED,AND VEHICLE WAS OPERATING AS DESIGNED. HOWEVER, THE RUBBER PANEL WAS ADJUSTED PROPERLY BY THE MECHANIC. CONSUMER INFORMED THE MECHANIC THIS PROBLEM STILL OCCURRED. *AK

THERE WOULD BE A THUMPING NOISE COMING FROM THE ABS WHEN IN USE. PLEASE PROVIDE MORE INFORMATION. *JB

ABS LIGHT WAS ON. ALSO, BACK AXLE WAS REPLACED. CURRENTLY, THE ABS LIGHT WAS ON AGAIN. *AK THE ABS LIGHT WAS ON A TOTAL OF 3 TIMES. *TC

ABS WARNING LIGHT HAD BEEN COMING ON PERIODICALLY, THUS LOSING ABS. AFTER A FEW WEEKS, THE LIGHT WAS OFF, BUT MY ABS KICKED IN ON DRY PAVEMENT, MAKING IT DIFFICULT TO STOP. THIS HAPPENED A COUPLE OF TIMES. CAR ONLY HAD 38,000 MILES. BROUGHT IT TO DEALER. THEY DIAGNOSED IT AS A FAULTY SENSOR ON ONE OF THE TIRES...SINCE I WAS OUT OF WARRANTY AND THIS WAS AN ITEM WHICH TAKES "WEAR AND TEAR" , FORD WOULD NOT ASSIST IN THE PAYMENT AT ALL. DEALER ALSO STATED THAT IT WAS NOT A SAFETY ISSUE, HOWEVER, IF IT WAS AN EMERGENCY BRAKING SITUATION I DO NOT FEEL THAT I COULD HAVE STOPPED IN TIME. *JB

MY ABS LIGHT CAME ON. WHEN SERVICED, THEY SAID A SPEED SENSOR NEEDED TO BE REPLACED. OF COURSE THIS OCCURERED ONE WEEK FOLLOWING THE EXPIRATION OF THE WARRANTY. TALKING WITH OTHERS, THIS SEEMS TO BE AN OFTEN OCCURANCE, AND SEEMS TO BE A DEFECT. SOME POEPLE HAVE HAD THEIR'S REPLACED SEVERAL TIMES WITHIN A YEAR.*AK

ABS LIGHT ILLUMINATED. SPEED SENSOR FOUND DEFECTIVE. THIS OCCURRED TWICE, FIRST ON 9OCT03 @ 29607 MILES, SECOND ON 3AUG04@44202 MILES.*AK

ABS LIGHT COMES ON INTERMITTENTLY, THE BRAKES SEEM TO STICK AND SMELL LIKE THEY ARE BURNING. I HAVE HAD THE VEHICLE IN FOR SERVICE 3 TIMES FOR THE SAME PROBLEM BUT THE PROBLEM HAPPENS INTERMITTENTLY, SO 2 OF THE 3 DEALERSHIPS SAID THAT THERE WAS NO PROBLEM. MY BRAKE PADS ARE NOW PRE-MATURELY WORN AND THE LATEST DEALERSHIP HAS CLAIMED TO HAVE REPLACED A SENSOR ON THE DIFFERENTIAL THAT WILL "FIX" THE PROBLEM. AFTER BEING TOLD THAT THERE WASN'T A PROBLEM, NEXT THAT THE REAR BRAKES WERE WORN OUT, AND THEN THAT THE SENSOR WAS BAD. MY VEHICLE HAS 25,000 MILES ON IT AND ABOUT 30% LEFT ON THE REAR BRAKES AND 40% ON THE FRONT BRAKE PADS. I HAVE MADE 4 ROUND TRIPS FROM CHICAGO TO NEW ORLEANS, AND 1 ROUND TRIP FROM CHICAGO TO LAS ANGELES TOTALING ABOUT 13,000 OF THE 25,000 MILES ON THE VEHICLE. I HAVE...

NAR 06/19/2003. *MR THERE IS A RECCURRING PROBLEM WITH THE BRAKES ON THE CONSUMERS 2002 FORD EXPLORER. THE SERIES OF INCIDENTS OCCURRED NOV 2, 2002, FEB, 2003, MAY 5, 2003, AND THE LAST TIME WAS MAY 17, 2003 TO DATE. IT IS EVIDENT TO THE CONSUMER THAT THERE IS AN CONSISTENT PROBLEM AND NEEDS TO BE FIXED. THE DEALERSHIP CAN'T SEEM TO FIND THE SOURCE OF THE PROBLEM. PLEASE DO FURTHER INVESTIGATIONS. *CB THE CONSUMER STATED WHEN HE APPLIED THE BRAKES T HE VEHICLE ACCELERATED AND CONTINUED TO MOVE FORWARD *JB

THE ABS ENGAGED WHICH CAUSED THE VEHICLE TO JERK, AS A RESULT, THE VEHICLE WAS REAR ENDED. NO INJURIES REPORTED. *AK THIS WOULD OCCUR EVEN THOUGH THE BRAKES WERE NOT TOUCHED. *SC *JB

THE ROOF RACK (WHICH WAS FACTORY EQUIPMENT) SEPARATED FROM THE ROOF OF THE VEHICLE. THE CONSUMER FELT THAT THE RACK WAS LIABLE TO COME OFF AND CAUSE DAMAGE TO MOTORIST DRIVING BEHIND HIS VEHICLE. ALSO THE ABS LIGHT ILLUMINATED ON INTERMITTENTLY AND STAYED ON. THE CONSUMER HAD THE ABS PROBLEM REPAIRED SEVERAL TIMES ALREADY. THE MANUFACTURERS WAS AWARE OF THE PROBLEM. *JB

THE ROOF RACK (WHICH WAS FACTORY EQUIPMENT) SEPARATED FROM THE ROOF OF THE VEHICLE. THE CONSUMER FELT THAT THE RACK WAS LIABLE TO COME OFF AND CAUSE DAMAGE TO MOTORIST DRIVING BEHIND HIS VEHICLE. ALSO THE ABS LIGHT ILLUMINATED INTERMITTENTLY AND STAYED ON. THE CONSUMER HAD THE ABS PROBLEM REPAIRED SEVERAL TIMES ALREADY. THE MANUFACTURERS WAS AWARE OF THE PROBLEM. *JB

ABS WARNING LIGHT CAME ON/OFF, AND THE ABS BRAKES ENGAGED PREMATURELY. ALSO, THERE WAS VIBRATION IN THE FRONT END WHEN BRAKING. VEHICLE HAD BEEN SERVICED 3 TIMES. DEALER REPLACED THE ROTORS ONCE, AND ABS REAR SENSOR TWICE. THE ABS WARNING LIGHT CAME ON AGAIN. *AK

THE ANTI LOCK BRAKES MALFUNCTIONED. AS A RESULT THE ABS SENSOR LIGHT CONTINUED TO STAY ON. *AK

CONSUMER STATED WHEN DEPRESSING THE BRAKES BRAKE PEDAL TRAVELED TO THE FLOORBOARD, CAUSING VEHICLE TO VIBRATE. *AK

WHILE DRIVING, THE VEHICLE'S ABS LIGHT WOULD COME ON INTERMITTENTLY. THE CONSUMER HAD COME IN CONTACT WITH THE DEALERSHIP. *AK THE FIRST TIME THE ABS LIGHT HAD COME THERE WAS NO UNUSUAL EFFECT. THE SECOND TIME THE ABS LIGHT HAD COME, THERE WAS A DIFFERENCE IN BEING ABLE TO BRAKE SMOOTHLY. THE THIRD OCCASION OCCURRED AT THE LIGHT WHEN THERE WERE NO OTHER VEHICLES. THE VEHICLE FINALLY STOPPED AND THE CONSUMER WAS ABLE TO DRIVE HOME. *SCC *JB

REPEATED FAILURE OF ABS SYSTEM ON 2002 FORD EXPLORER. ABS HAS BEEN REPAIRED 5 TIMES SINCE JANUARY 2002. LATEST FAILURE INCLUDED WATER IN REAR DIFFERENTIAL WITH NO KNOW REASON. FAILURE OF ABS HAS BEEN REAR SENSOR CABLE AND ONCE A COMPUTER MODULE. LATEST DATE SHOWN. *NLM

BRAKE PEDAL FADES AND GOES CLEAR DOWN TO FLOORBOARD WHILE STOPPED AT A STOP LIGHT OR STOP SIGN. PROBLEM IS GETTING WORSE. I HAVE TAKEN TO DEALER 5 TIMES AND LAST TIME THE SERVICE MANAGER TOLD ME THIS IS NORMAL. HE SAID THAT SOME OTHERS (NOT ALL)DO THE SAME THING. MINE STARTED THIS AT ABOUT 28,000 MILES. I CURRENTLY HAVE 35400 MILES ON VEHICLE. TS

CAR WAS ON A FAMILY TRIP WHEN ABS LIGHT CAME ON FOR NO REASON. DEALERSHIP CAN NOT GET THE LIGHT BACK ON. CAR WAS STARTED IN THE MORNING AND AIR BAG LIGHT FLASHED AND THEN STAYED ON AND THE DEALERSHIP SAID IT WAS DUE TO A SHORT. DAY AFTER IT WAS IN THE SHOP FOR THE AIR BAG LIGHT THE CAR WOULD NOT START. WOULD NOT TURN OVER. IT WILL BE IN THE SHOP AGAIN. FOR THE THIRD TIME IN 6 MONTHS.*AK

VEHICLE WOULD INTERMITTENTLY HAVE EXTENDED STOPPING DISTANCE. BRAKE WOULD SQUEAL ,AND PEDAL WOULD BE SOFT WHEN APPLIED. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

WHILE APPROACHING AN INTERSECTION APPLIED BRAKES AND PEDAL WENT ALL THE WAY TO THE FLOOR. VEHICLE RAN ON A CURB AND HIT A FIRE HYDRANT. DEALERSHIP WAS AWARE OF PROBLEM.*AK

VEHICLE EXPERIENCES PERIODS OF STALLING AT LOW SPEEDS. APPLYING BRAKES THERE IS A LOSS OF BRAKES AND STEERING. NO PRIOR WARNING BEFORE STALLING. EXISTING PROBLEM 5 TIMES, TAKEN INTO THE DELAER. *AK DEALER REPLACED FUEL PUMP, MAIN CONTROL VALVE BODY, TRANSMISSION OIL PAN, IDLE AIR CONTROL VALVE AND PROGRAMMED PCM. VIBRATION LIKE ANTI-LOCK BRAKE SYSTEM IS KICKING IN. DEALER COULD NOT DUPLICATE. OVERDRIVE COMES IN AND OUT AT ODD SPEEDS. NO PROBLEM FOUND.

CONSUMER REARENDED ANOTHER VEHICLE DUE TO BRAKE FAILURE AT 20 MPH. UPON IMPACT, NEITHER AIRBAG DEPLOYED. NO INJURIES. VEHICLE AT DEALERSHIP AT THIS TIME.*AK

CONSUMER APPLIED BRAKES AT 20 MPH AND PEDAL WENT TO THE FLOOR. THERE WAS NO BRAKING ACTION, AND HE REARENDED ANOTHER VEHICLE. NO INJURIES. VEHICLE AT DEALERSHIP AT THIS TIME. *AK

WHEN APPLYING ABS BRAKES PEDAL GOES TO FLOOR CAUSING EXTENDED STOPPING DISTANCE. PROBLEM BECOMES MORE PRONOUNCED WHEN VEHICLE IS DRIVEN ON WET PAVEMENT. PLEASER GIVE ANY FURTHER DETAILS.*AK

WHILE TRAVELING AT APPROXIMATELY 30 MPH ON WET PAVEMENT HAD TO APPLY BRAKES HARD TO BRING VEHICLE TO A STOP. THIS HARD BRAKING ENGAGED ANTI-LOCK SYSTEM AND BROUGHT VEHICLE TO A COMPLETE STOP. HOWEVER, WHEN CONSUMER ATTEMPTED TO ACCELERATE, BRAKES WOULD NOT RELEASE, AND BRAKES WERE GRABBING. CONSUMER HAD TO RELEASE BRAKES BY PULLING BRAKE PEDAL UP WITH HIS FOOT. DEALERSHIP COULD NOT REPRODUCE THIS PROBLEM. *AK *JB