2002 FORD EXPLORER Power Trainautomatic Transmission Problems

SEALED TRANSMISSION IN 02 FORD EXPLORER. TANNY SHIFTS HARD THEN OVER DRIVE LIGHT FLASHES, STARTS SHIFTING INTO OD HARD THEN NOT AT ALL, THEN HARD THEN BACK AND FORTH ALOT. NO WAY TO CHECK FLUID. ALL FORD OFFERS IS A REBUILT AT 3000.00 DOLLARS. *TR

1. O/D LIGHT STARTED FLASHING, CAR WAS JERKING WHEN SLOWING AND ACCELERATING. 2. ALMOST EVERY TIME STARTING AND STOPPING VEHICLE JERKS. 3. REMOVE AND REBUILD THE TRANSMISSION, FM68 TORQUE CONVERTER, TRANSMISSION OVERHAUL KIT, OVERDRIVE BAND ASSEMBLY, INTER BAND ASSEMBLY, SERVO BUSHING KIT, BUSHING KIT. AS OF APRIL 5TH 2010 O/D LIGHT FLASHING AGAIN AND VEHICLE JERKS WHEN SLOWING AND ACCELERATING. *TR

THE TRANSMISSION ON MY FORD EXPLORER WENT OUT AFTER THE OD LIGHT HAS BEEN BLINKING... FORD THE TO RECALL THE TRANSMISSION ON THIS EXPLORER IT IS REALLY A PROBLEM. *TR

WHILE DRIVING MY VEHICLE WHEN IT SHIFTED GEARS THE CAR SLOWED DOWN AND THE RPMS WENT UP TO 4000 - 5000. AFTER A MINUTE THE CAR SHIFTED INTO THE NEXT GEAR AND IT SEEMED TO DRIVE FINE. THEN THE O/D OFF LIGHT BEGAN TO FLASH ON THE DASH. THIS PROBLEM HAS OCCURRED MULTIPLE TIMES TODAY. I HAVE SEEN MANY INSTANCES OF THE PROBLEM LISTED ON THE INTERNET FOR MY MAKE, MODEL AND YEAR. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 20 MPH THE TRANSMISSION BEGAN TO SLIP. THE CONTACT BELIEVED THE FAILURE TO BE INTERMITTENT; HOWEVER, THE FAILURE BECAME PROGRESSIVELY WORSE AND THE OVERDRIVE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION WAS REPLACED. THE DEALER AND MANUFACTURER WERE CONTACTED BUT WOULD PROVIDE NO ASSISTANCE BECAUSE THE VEHICLE WAS OUTSIDE OF THE FACTORY WARRANTY. THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 150,000. UPDATED 5/24/10 *CN UPDATED 07/07/10.*JB

2002 FORD EXPLORER XLT (4.0L 5R55W) TRANSMISSION SLIPPAGE CAUSING NEAR ACCIDENT AS UNABLE TO PASS THROUGH INTERSECTION IN A TIMELY MANNER. WHEN SHIFTING BETWEEN 1ST AND 2ND GEAR, TRANSMISSION WOULD WIND BEFORE VIOLENTLY ENGAGING. REMEDY WAS TO TAKE FOOT OF ACCELERATOR AND ALLOW RPMS TO DECREASE. INCREASED ACCELERATION TIME IN LOWER GEARS A DANGER WHEN TRYING TO CROSS LANES OF TRAFFIC. *TR

FORD 2002 6 CYLINDER EXPLORER XLT O/D OFF LIGHT FLASHING ON DASHBOARD. TRANSMISSION PROBLEM STARTED WITH 100,800 MILE. HAD REBUILT TRANSMISSION DONE AT 100,800 MILES. NOW VEHICLE HAS 109,900 MILES AND OD/OFF LIGHT FLASHING AGAIN. WAS TOLD THAT TRANSMISSION IS FALLING APART. BACK IN TRANSMISSION SHOP AGAIN. THERE ARE THOUSANDS OF SAME COMPLAINTS FOR THE SAME PROBLEM ON 2002 FORD EXPLORERS. FORD WILL NOT HELP AT ALL! FORD NEEDS TO RECALL TRANSMISSION. *TR

O/D LIGHT BLINKING AND ENGINE REVVING LIKE THE CAR WAS IN PARK. WILL NOT GO INTO REVERSE. *TR

SHIFTER HANGS-UP WHEN TRYING TO PUT CAR IN PARK. WHEN CAR WAS NEW THE DEALER SAID THEY WOULD HAVE TO PULL THE TRANS. APART TO FIX IT BUT IN A FEW MONTHS THE BURR WOULD WEAR AND IT WOULD WORK FINE.(ANOTHER DEALER LIE). I THINK IT IS GETTING WORSE. THE CAR NOW HAS ONLY 28,000 MILES ON IT. *TR

TRANSMISSION SHIFTS HARD AND THE O/D LIGHT IS STARTING TO BLINK AND BY READING UP ON THIS SEVERAL COMPLAINTS ARE BEING MADE AND FORD SHOULD ADDRESS THIS.

I HAVE A 2002 FORD EXPLORER XLT 4X4 4.0L SOHC. TRANSMISSION BROKEN IN 3RD FEAR. OD LIGHT STARTING FLASHING WITH NO WARNING AND THEN TRANSMISSION BROKE. THE CAR HAS 120,000 MILES ON IT. I HAD A PROBLEM WITH THE TRANSMISSION AT AROUND 75,000 MILES. I TOOK IT TO THE FORD DEALER. IT WAS COVERED UNDER MY EXTENDED WARRANTY. NOW THE TRANSMISSION BROKE AGAIN. 2,400. - 3,000 TO FIX.

2002 FORD EXPLORER. O/D LIGHT FLASHING WITH SERVICE ENGINE SOON FLASHING. CAR JERKING BETWEEN 2ND AND 3RD GEAR. FORD SAYS TO REPLACE TRANSMISSION BUT AFTER READING SO MANY OF THE SAME COMPLAINTS I THOUGHT I SHOULD REPORT THIS INCIDENT.

2002 FORD EXPLORER EDDIE BAUER EDITION. WHILE SHIFTING THE CAR FROM PARK TO REVERSE THE SHIFTING LEVER SIMPLY SNAPPED OFF, LEAVING THE CAR STUCK BETWEEN PARK AND REVERSE. THE PIECE OF ALUMINUM WHERE THIS SHEARING OCCURRED IS UNBELIEVABLY WEAK MATERIAL. I HAVE RESEARCHED ON THE INTERNET AND FOUND HUNDREDS OF PEOPLE WITH THIS EXACT SAME ISSUE FOR THIS EXACT YEAR OF EXPLORER. THE ESTIMATE THAT I RECEIVED FOR REPAIRS EXCEEDED $2,000, AS THEY HAVE TO REPLACE THE ENTIRE STEERING COLUMN TO CORRECT THIS MANUFACTURER DEFECT. THERE HAS BEEN NO RECALL ISSUED FOR THIS, HOWEVER, THE FREQUENCY OF THE PROBLEM, THE RANGE OF MILEAGE THIS CONTINUES TO OCCUR IN (95-106K), AND THE EXTREMELY HIGH COST TO FIX, IN MY OPINION, SHOULD REQUIRE MANUFACTURER ASSISTANCE

I HAVE A 2002 FORD EXPLORER EDDIE BOWER THAT I BOUGHT NEW. I HAVE 88000 MILES ON IT AND ROUGHLY 3WEEKS AGO THE O/D LIGHT STARTED BLINKING AND THE "CHECK TRANSMISSION" WARNING COMES UP. TOOK IT TO THE DEALER AND THEY TOLD ME THAT I NEED A NEW OR REBUILT TRANSMISSION COSTING BETWEEN $2,200-$3,500. THIS SEEMS TO BE A COMMON PROBLEM WITH THE 2002 EXPLORER.

WAS DRIVING ON FLAT ROAD CAR STARTED TO SHIFT FUNNY CAR SLAMS INTO GEAR PROBLEM HAPPENS EVERY TIME THE CAR SHIFTS SECOND GEAR TO THIRD GEAR VEHICLE NEEDS NEW TRANSMISSION

O\D LIGHT BLINKING AFTER ABOUT FIVE (5) MILES. NO ONE CAN SAY WHAT THE PROBLEM IS BUT THE COST TO REPLACE THE TRANSMISSION IS TO MUCH. FORD SHOULD BE ASHAMED.

2002 FORD EXPLORER O/D LIGHT FLASHES, THE GEAR SLIPS AND TRUCK LUNGES HARD FORWARD. THIS OCCURS EVERYTIME YOU ACCELERATE INTO 1ST TWO GEARS. DID A SEARCH AND LEARNED IT IS COMMON TRANSMISSION PROBLEM FOR THESE VEHICLES, FORD IS AWARE AND DOES NOTHING TO CORRECT THE ISSUE. *TR

MARCH 17TH, 2010: WIFE CALLS ME AT WORK AND SAYS SHE WAS BRINGING MY DAUGHTER HOME FROM SCHOOL AND THE EXPLORER 2002 TRANSMISSION STARTED SLIPPING AND THE CHECK ENGINE LIGHT CAME ON AND THE O/D LIGHT WAS FLASHING. SHE WAS ABLE TO DRIVE IT HOME UNTIL I COULD LOOK AT IT. I DROVE IT LATER THAT EVENING AND DETERMINED THAT IT WAS SLIPPING BETWEEN 2ND AND 3RD HEAR AND THE CHECK ENGINE LIGHT IS ON. ON MARCH 19TH...I DROVE TO AUTOPARTS STORE AND HAD THEM READ CODE FROM COMPUTER: P0745. I DID ALOT OF RESEARCH AND IT APPEARS THAT THE INTERMEDIATE BAND MAY HAVE BROKEN AND TRANSMISSION NEEDS REPAIRED/REPLACED ($1500-$3000???) I WILL BE CONTACTING FORD ON MONDAY MARCH 22ND, 2010 TO TAKE IT INTO SHOP AND HAVE THEM DETERMINE WHAT THEY THINK IS WRONG. SEEMS TO BE A VERY COMMON ISSUE... IT IS A SAFETY ISSUE DUE TO THE FACT...

2002 FORD EXPLORER BAD TRANSMISSION. THE CAR HAS 65,000 MILES ON IT. *TR

I WAS DRIVING HOME FROM WORK YESTERDAY AFTERNOON, AND MY O/D OFF LIGHT BEGAN FLASHING. I PRESSED THE O/D OFF BUTTON TO SEE IF THAT WAS THE PROBLEM, AND IT DID NOT DO ANYTHING. I NOTICED THAT THE CAR BEGAN HAVING TROUBLE WHEN TRYING TO SHIFT GEARS WHILE ACCELERATING. ONCE THE CAR DOES SHIFT INTO THE CORRECT GEAR THERE IS A STRONG JERK. ONCE I GOT HOME, I TURNED THE CAR OFF AND BACK ON TO SEE IF THE LIGHT WAS STILL FLASHING. IT WAS NOT AT FIRST, BUT AFTER DRIVING A MILE OR SO, IT BEGINS FLASHING AGAIN. I TOOK IT BACK TO THE DEALERSHIP SINCE I PURCHASED THIS CAR LESS THAN A MONTH AGO. THEY STATED THAT THE SOLENOID TRANSMISSION PACK NEEDS TO BE REPLACED, AND THAT THE PART ALONE WILL COST $860. MY FAMILY IS LIVING ON ONE INCOME RIGHT NOW, SO WE DO NOT HAVE THE...

WHEN I WAS IN THE HIGHWAY THE TRANSMISSION IN THE FORD EXPLORER 2002 BEGIN TO SLIPPED IN THE MIDDLE OF THE HIGHWAY, WAS A DANGER SITUATION BUT WHEN I PUT MANUALLY THE CHANGE TO THE 3RD GEAR , START TO RUN AGAIN AND SPEED UP. THEN THE O/D LIGHT BEGIN BLINKING, AND THE TRANSMISSION CONTINUE WITH CONSTANT SLIP ALL THE WAY. THE TRANSMISSION IS BROKEN AND I NEED A REPLACEMENT. WHEN I LOOK UP IN THE INTERNET FOR THIS PARTICULAR SITUATION FIND A LOT OF NARRATIVE WITH THE SAME ISSUE. THE FORD EXPLORER 2002 ONLY HAVE 92,000 MILES. *TR

THE 2002 FORD EXPLORER TRANSMISSION HAS WELL DOCUMENTED ISSUES. THESE COMPLAINTS ARE ALL OVER THE INTERNET. THE TRANSMISSION FAILS IN AS LITTLE AS 23,000 MILES AND NEEDS A COMPLETE RE-BUILD. I HAVE SPENT OVER $5000.00 IN REPAIRS AND EXTENDED WARRANTY SERVICE ON THIS TRANSMISSION ALONE. FORD WON'T DO ANYTHING TO HELP THE CONSUMER. WHAT CAN THIS AGENCY DO TO HELP? *TR

MY SON OWNS A 2002 FORD EXPLORER. LAST YEAR HIS TRANSMISSION BEGAN EXPERIENCING PROBLEMS WHERE THE OVERDRIVE LIGHT STARTED BLINKING, IT WAS SHIFTING VERY HARD AND SOMETIMES IT WOULD EVEN JUST GO INTO NEUTRAL OUT OF THE BLUE. I TOOK IT TO THE LOCAL FORD DEALERSHIP WHERE THEIR TRANSMISSION TECHNICIAN TOLD ME IT WAS EASY TO DIAGNOSE BECAUSE IT WAS A VERY COMMON PROBLEM, SO I WAS FORCED TO REPLACE THE TRANSMISSION IN THE FALL OF 2009 WITH A USED ONE THAT I FOUND AT A RECYCLING CENTER. LAST MONTH MY SON WAS LEAVING THE DRIVEWAY OF A FRIENDS HOUSE AND THE REPLACEMENT TRANSMISSION BEGIN DOING THE SAME THING AS THE FIRST ONE BUT ONLY THIS TIME IT MADE A LOUD BANG AND STOPPED MOVING. MY SON GOT OUT OF THE TRUCK TO FIND THAT THE TRANSMISSION EXPLODED AND ALL THE FLUID LEAKED ONTO HIS FRIENDS DRIVEWAY. I HAVE FOUND...

AFTER DRIVING OFF THE LOT WITH MY CAR THE O/D LIGHTS START BLINKING AND CHECK TRANSMISSION LIGHT COME ON SO I TURN AROUND AND GO BACK TO THE DEALERSHIP THEY CHECK AND SAY OH ITS PROBABLY JUST THE TRANS FLUID NEEDS REFILLED...SO THIS WAS ONE MARCH SECOND HERE IT IS MARCH 13TH AND I'M WITHOUT A CAR BECAUSE ON THE FIFTH THE CAR WOULD DRIVE SO WEIRD NOW GUESS WHAT LIKE ALL FORD OWNERS OF THIS YR ITS TRANSMISSION IS GONE. *TR

- FORD TSB # 06-4-4 (BINDING DURING TURNING); SOLUTION IS LIMITED SLIP CLUTCH PACK REPLACEMENT - FORD TSB # 05-23-3 (REAR DIFF. HUM); SOLUTION IS AXLE REPAIR KIT - FORD TSB # 4-24-17 (5R55W TRANSMISSION - NO 3RD GEAR OR SLIPPING 2-3 SHIFT); SOLUTION IS REPLACEMENT OF INTERMEDIATE CLUTCH BANDS - CHRONIC O/D LIGHT BLINKING WITH DTC P0755 (PRESSURE CONTROL SOLENOID B CIRCUIT MALFUNCTION) THIS IS JUST THE LIST OF ISSUES I DON'T HAVE THE CAPABILITY TO PROPERLY TROUBLESHOOT. I HAVE DONE A LOT OF OTHER WORK ALREADY MYSELF WHICH I WON'T MENTION. FORD IS AWARE OF THESE PROBLEMS WITH MANY 02' EXPLORER'S AS I HAVE READ. IN MY OPINION, THESE PROBLEMS SHOULD BE CORRECTED AT NO CHARGE TO THE OWNER AS THESE PROBLEMS ARE NOT ISOLATED CASES. *TR

TRANSMISSIONS OF THE 2002 FORD EXPLORER SEEMS TO HAVE NUMEROUS ISSUES. I HAVE HAD MY TRANSMISSION FIXED TWICE, BUT THERE ARE NUMEROUS REPORTS ON-LINE WITH THE SAME ISSUES. I HAVE ADDRESSED WITH FORD, BUT THEY DO NOT SEE IT AS A SAFETY ISSUE. WHEN A VEHICLE DOES NOT SHIFT INTO GEAR AS YOU PULL INTO A ROADWAY, IT IS VERY MUCH A SAFETY ISSUE. I WOULD JUST LIKE YOUR OFFICE TO REVIEW THESE ISSUES AS A SAFETY CONCERN. PLEASE READ THE ON-LINE POSTINGS OF PEOPLE THAT OWN THESE VEHICLES. THANK YOU FOR YOUR CONSIDERATION IN THIS MATTER. *TR

TRANS STARTED SLIPPING,OD LIGHT STARTED BLINKING, CHECK ENGINE LIGHT ON,WENT TO DEALER STATED THAT NEED NEW TRANS. *TR

2002 FORD EXPLORER. TRANSMISSION OD LIGHT FLICKERING, WILL NOT SHIFT. HAD BEEN REBUILT ONCE AND HAD NOT HAD IT 3 MONTH AND DOING IT AGAIN. WILL NOT PURCHASE ANOTHER FORD VEHICLE AGAIN. *TR

LIKE MANY OTHERS BEFORE ME THE O/D OFF LIGHT STARTED BLINKING, I ALSO CHECKED THE MANUAL WHAT DO MY EYES SEE BLINKING O/D TAKE IN FOR SERVICE==YEA GUESS WHAT? NEEDS A NEW TRANSMISSION. I STILL OWE $7900 ON THIS VEHICLE. COST OF JASPER TRANSMISSION $3550. DON'T KNOW BOUT REBUILD VS REBUILT BUT HAVE TO GO WITH BEST WARRANTY SINCE NOW I WILL HAVE SO MUCH INVESTED IN THIS THAT I WILL HAVE TO DRIVE IT UNTIL THE WHEELS FALL OFF AS WILL NOT BE ABLE TO AFFORD TO GET RID OF THE PIECE OF TRASH VEHICLE IT HAS TURNED OUT TO BE. *TR

OVERDRIVE LIGHT TURNED ON AND NOW TROUBLE SHIFTING FROM 1ST TO 2ND GEAR. CAR DID THIS 25,000 MILES AGO BUT ADJUSTED ITSELF. *TR

NO EVENT LED TO THE FAILURE THE COLUMN MOUNTED SHIFT LEVER BROKE OFF WHEN SHIFTING INTO REVERSE FROM PARK, OCCURRED ONCE CAR CANNOT BE OPERATED WITHOUT SHIFT LEVER. NO REPLACEMENT PART AVAILABLE WITHOUT REPLACING THE ENTIRE STEERING COLUMN ASSEMBLY. THE PART THAT BROKE IS EASILY SERVICEABLE AND COULD BE REPLACE IF SOLD SEPARATELY FROM THE COLUMN ASSEMBLY COLUMN ASSEMBLY IS $1400 FOR PART ONLY. *TR

AUTOMATIC TRANSMISSION HARD SHUDDERING BETWEEN 50-70 MPH WITH O/D OFF LIGHT BLINKING. EXACTLY THE SAME AS THE MORE THAN 2000 OTHER COMPLAINTS ON THIS SAME VEHICLE. TOOK IT TO FORD DEALER WHO CHARGED ME $250 TO TELL ME THAT THEY COULD ONLY REPRODUCE THE PROBLEM ONCE, BUT WHEN IT HAPPENED IT WAS HEAVY. DESPITE THAT THEY SAID NOTHING WAS WRONG BECAUSE THEY COULD NOT REPRODUCE THE PROBLEM AGAIN. I DROVE IT 2 MORE MONTHS UNTIL THE SHUTTERING WAS VERY BAD AND ALSO GOT THE CHECK ENGINE LIGHT WITH CODES P0775 AND P0735. NOW THEY WANT TO REPLACE MY TRANSMISSION FOR $4100. THIS DEFECT LEADS TO A VERY DANGEROUS SITUATION AS IT HAPPENS AT HIGH SPEEDS AND CAUSES THE DRIVER TO BELIEVE THEY MAY HAVE HIT SOMETHING AND POSSIBLY SWERVE OFF THE ROAD. *TR

O/D LIGHT BLINKS ALL THE TIME. TRANSMISSION SLIPS AND CLANKS. *TR

I HAVE A 2002 FORD EXPLORER WHILE I WAS COMING HOME THE OD LIGHT CAME ON AND THE CHECK TRANS. CAME ON. THERE WAS NO PROBLEM LEADING UP TO THIS IT JUST HAPPENED. SO TAKE IT TO THE FORD PLACE AND THEY SAY NEEDS NEW TRANSMISSION. I STILL OWE 3,000 ON IT THAT IS ALSO THE PRICE OF THE NEW TRANS. THE TRANS. HAS NEVER USED ANY FLUID . I NEED HELP! *TR

THE O/D LIGHT ON MY DASH OF MY 02 EXPLORER STARTED BLINKING . IT TAKES A WHILE AND STRUGGLES TO GET TO 30MPH, WHEN IT FINALLY REACHES 30 IT SLAMS INTO GEAR AND ACTS FAIRLY NORMAL. THE NEXT DAY, IT WOULDN'T GET ABOVE 20MPH. WE PAID FOR A NEW TRANNY ($1732) AND PAID A CERTIFIED MECHANIC TO PUT IT IN ($225, WHICH DOES NOT INCLUDE THE COST OF THE FLUID). THE PROBLEM WAS NOT FIXED. WE THEN BOUGHT A $75 ELECTRONIC RANGE SENSOR, MECHANIC PUT IT ON, AND STILL THE SAME PROBLEMS. IT IS NOW STILL IN THE SHOP (3 WEEKS, NOW) AND WE HAVE SPENT ABOUT $2100 AND MY CAR IS STILL NOT FIXED! WE ARE A ONE INCOME FAMILY AND CANNOT AFFORD THE CONTINUED NEGLIGENCE OF FORD. *TR

I WAS DRIVING UNDER NORMAL CONDITIONS WHEN MY 2002 FORD EXPLORERS TRANSMISSION BEGAN TO BANG AND CLUNK INTO GEAR...APPARENTLY THIS IS A POPULAR PROBLEM AMONG THE EXPLORERS AND REALLY SHOULD BE RECALLED. A NEW TRANSMISSION AND $3,000 LATER.... *TR

2002 FORD EXPLORER TRANSMISSION PROBLEMS. WE BOUGHT THIS TRUCK IN JAN OF O4 WITH 40,000 MILES ON IT. AROUND 50,000 IT STARTED SHIFTING FUNNY, LIKE MISSING A SHIFT AND BANGING INTO GEAR. WENT TO DEALER AND HAD SYSTEM FLUSHED. HAD COMPUTER REFLASHED AROUND 80,000 MILES AND REVERSE SOLENOID REPLACED ALONG WITH FLUSHING AGAIN, WOW WHAT A SHOCK ON THE RACKS WAS 2 OTHER EXPLORER GETTING NEW TRANSMISSIONS. SHORTLY AFTER THE O/D LIGHT STARTED FLASHING THEN WENT OUT. NOW IT CAME ON AGAIN. WENT TO DEALER THEY SAID WITHOUT THE LIGHT ON THEY COULDN'T SAY WHAT IS WRONG FOR SURE. MIGHT BE A ACCUMULATOR OR BAND. SUGGESTED IT WOULD BE BETTER TO GET A FORD REMANUFACTURED TRANS THAT HAS ALL THE PROBLEMS CORRECTED. THIS WOULD COST OVER 3,000. HE TOLD BE TO KEEP DRIVING IT TILL THE LIGHT STARTS COMING ON REGULARY THEN COME IN. IF MY TRANS IS SEALED FROM...

TRANSMISSION FAILURE ON MY 2002 FORD EXPLORER. TRANSMISSION HAS ALWAYS HAD "SO-SO" PERFORMANCE. HARD SHIFTING INTO GEARS. NOW IS GOING TO COST ME $3500 TO REPAIR. *TR

O/D LIGHT CONTINUOUSLY BLINKING, TRANSMISSION SLIPPING AND ENGINE REVVING UP CAUSING LOTS OF JERKING EVERYTIME I DRIVE MY 2002 EXPLORER. IN ORDER FOR ME TO DRIVE MY SUV I HAVE TO TURN THE O/D OFF...AND SOMETIMES THE ENGINE WILL CONTINUOUSLY REV UP EVEN WHEN THE O/D IS MANUALLY TURNED OFF. THERE ARE TOO MANY PEOPLE WITH THIS PROBLEM FOR IT TO CONTINUE TO BE IGNORED. PLEASE HELP US CONSUMERS.*TR

2002 FORD EXPLORER EDDIE BAUER HAS HAD THE OD LIGHT COME ON DRIVING DOWN THE ROAD. THE RPM'S INCREASE AND SHIFTS FROM GEAR TO GEAR HARD. PULLED OVER TO FIGURE OUT WHAT IS WRONG AND PROBLEM WENT AWAY. LIGHT HAS CONTINUED TO COME ON AND OFF AT RANDOM TIMES AND NOISE CONTINUES AS THE LIGHT IS ON. THE PROBLEM OCCURS OF AND ON. PROBLEM FIRST BEGAN IN AUG 2009. HAVE HAD THIS PROBLEM OCCUR THIS PAST WEEK. HAVE BEEN TOLD THAT WE NEED TO HAVE A OVER HAUL OF THE TRANSMISSION TO FIX CURRENT PROBLEM. *TR

TRANSMISSION FAILURE OD BLINKING REPAIR NEW TRANS BUT STILL HAS THE SAME PROBLEM 42 K MILES FORD EXPLORER. *TR

THE O/D OFF LIGHT STARTED TO BLINK AND WHEN I PRESSED ON THE GAS PEDAL THE RPM'S WENT UP LIKE CRAZY THE CAR WAS HARD TO SHIFT. *TR

O/D LIGHT FLASHING AND THEN TRANSMISSION WARNING CAME ON IN 2002 EDDIE BAUER EXPLORER. FORD DEALER QUOTED $4500 TO REBUILD TRANSMISSION. *TR

MY 2002 FORD EXPLORER HAS A TRANSMISSION FAILURE. THE OD LIGHT IS BLINKING. AND IT SHIFTS HARD WITH GEARS. ALSO MAKES A KNOCKING NOISE WHEN TRYING TO SHIFT. WHEN I TRY TO GO, THE RPM JUST RUNS HIGH AND THE TRUCK DOES NOT MOVE. WHEN IM DRIVING AND IT NEEDS TO SHIFT TO ANOTHER GEAR, IT JUST REMS AND DOESN'T SHIFT. *TR

I HAVE A 2002 FORD EXPLORER. I BOUGHT TI USED WITH 64,000 MILES ON IT. REPLACED BOTH REAR WHEEL BEARINGS. I HAVE ALSO REPLACED ALL STRUTS AND COILS SPRINGS. I HAVE AN ENGINE LIGHT ON FOR A INTAKE GASKET PROBLEM. THEN ON MY WAY HOME FROM WORK TODAY MY O/D LIGHT CAME ON. MY TRUCK HAS 130,000 MILES ON IT. BEFORE I PURCHASED EXPLORER I FOUND OUT IT WAS IN A REAR END ACCIDENT. *TR

O/D LIGHT FLICKERING AND TRANSMISSION IS SLIPPING. WILL NOT GO INTO GEAR WITHOUT A VIOLENT JERK AND SOMETIMES WONT GO INTO GEAR AT ALL. CAR HAS TO COMPLETELY IDLE BEFORE YOU CAN PRESS THE GAS WHICH IS VERY DANGEROUS BECAUSE I WILL SOMETIMES BE IN THE MIDDLE OF THE ROADWAY OR DRIVING DOWN THE ROAD OR CROSSING OVER TRAFFIC TO THE LEFT AFTER A STOP AT A LIGHT. *TR

I PULLED UP TO THE GAS PUMP AND PUT THE EXPLORER INTO PARK. AS I GOT OUT, IT STARTED ROLLING BACKWARDS..AS IT ROLLED BACKWARDS APPROXIMATELY 10 FEET, I HUNG ON TO THE DOOR AND WAS ABLE TO GET BACK IN AND BRING IT TO A STOP. I SAT THERE IN SHOCK FOR A MINUTE AS SEVERAL PEOPLE WHO WITNESSED THIS WERE IN HORROR..I PUT IT BACK INTO PARK.I WAS LUCKY THE EXPLORER DID NOT HIT ANOTHER CAR,ANY PEOPLE OR RUN ME OVER!! SINCE THAT TIME,ABOUT 2 YEARS AGO,I HAVE A HARD TIME WITH PUTTING THE CAR IN PARK AT TIMES..IT SEEMS TO GET STUCK AROUND REVERSE..SO, I AM VERY CAREFUL TO MAKE SURE WHEN I PUT IT IN PARK,IT IS IN FACT,IN PARK! *TR

OWNED 2002 EXPLORER SINCE OCT 2004- WITHIN 10 MONTHS OF OWNING CAR I HAD TO HAVE THE TRANSMISSION REPLACED. I HAD PURCHASED THE EXTENDED WARRANTY, OTHER THAN DEDUCTIBLE, THE REPLACEMENT WAS COVERED, MINUS THE FEES FOR RENTAL CAR FOR 3 DAYS. NOW, FEB 19, 2010, MY O/D LIGHT STARTED FLASHING AND TRANSMISSION IS OUT AGAIN; HIS TIME THE FULL EXPENSE PLUS RENTAL CAR WILL BE OUT OF MY POCKET AND COST WILL BE BETWEEN $1800-$2800 DEPENDING WHAT ALL NEEDS TO BE FIXED AND REPLACED ONCE IT IS OPENED UP IN REPAIR SHOP. *TR

SHORTLY AFTER PURCHASING OUR 2002 FORD EXPLORER XLS, WE BEGAN EXPERIENCING DELAYED SHIFTING ON OCCASION. THE PROBLEM CONTINUED TO GET WORSE UNTIL OCCASIONALLY, AFTER MAKING A TURN, IT WOULD SLIP OUT OF GEAR IMPEDING ACCELERATION IN TRAFFIC SITUATIONS. IT ALSO HESITATES GOING INTO GEAR AFTER BACKING UP OUT OF PARKING SPACES. THIS ALMOST CAUSED US TO BE HIT FROM BEHIND ONE DAY WHEN ANOTHER DRIVER BACKED OUT OF A PARKING SPOT BEHIND US WITHOUT LOOKING. LUCKILY IT WENT INTO GEAR JUST IN TIME SO THAT I COULD MOVE THE VEHICLE BACK INTO THE PARKING SPACE AND OUT OF THE WAY. EVENTUALLY THE O/D LIGHT BEGAN TO FLASH AND NOW THE TRANSMISSION SLAMS INTO HIGH GEAR AND DOWNSHIFTS HARD WHEN COMING TO A STOP. MY CONCERN IS THAT THIS IN NOT AN ISOLATED PROBLEM WITH JUST OUR EXPLORER AS I HAVE READ NUMEROUS REPORTS OF THE EXACT PROBLEMS. NOT BEING ABLE...

FORD EXPLORE 2002 4.0L V6 SUDDEN AND TOTAL FAILURE OF THE AUTOMATIC TRANSMISSION AT 122,000 MILES. OD LIGHT FLASHES AND TRANSMISSION INSPECTION BY MECHANIC REVEALS IT IS JUNK. DESPITE CAREFUL MAINTENANCE THIS SUV IS THE WORST VEHICLE I HAVE EVER OWNED THE LIST OF PROBLEM ON THIS VEHICLE HAVE NOTHING TO DO WITH THE OPERATION OR MAINTENANCE OF THIS VEHICLE. IT IS POSSIBLY THE MOST POORLY ENGINEERED VEHICLE SINCE THE VEGA! *TR