Vehicle Safety Data

2002 FORD EXPLORER Engine And Engine Cooling Problems

56 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

All Engine And Engine Cooling Complaints — Page 2

#10128127 |
DRIVING AND HEARD ENGINE NOISE ENGINE STALLED WOULDN'T START IN THE MIDDLE OF RUSH HOUR TRAFFIC...I WAS GOING DOWNHILL AND ABLE TO ROLL TO THE SIDE OUT OF TRAFFIC AND TO SAFETY. ENGINE FROZE WHILE DRIVING WITH NO WARNING, NO SIGNS...IN THE MIDDLE OF TRAFFIC ENDANGERING MYSELF AND MY DAUGHTER. MY CAR SAT 2 WEEKS AT THE FORD DEALER AS THEY RECEIVED 5 CARS WITH ENGINES FROZEN AND COULDN'T GET TO MY CAR UNTIL 7/8/05 CAUSE THEY HAD TO REPLACE ENGINES. WHEN ENGINE WAS TORN DOWN I WAS ADVISED A VALVE SPRING BROKE AND DROPPED INTO THE CYLINDER TEARING UP THE ENGINE AND NOW I NEED A NEW ENGINE. FORD MOTOR WILL NOT BACK UP THEIR PRODUCT.
#10122656 |
2002 FORD EXPLORER EXPERIENCING PROBLEMS WITH THE 4WD, THE OVER DRIVE LIGHT ILLUMINATES ON THE DASHBOARD AND THE VEHICLE IS GIVING OFF A ROTTEN EGG SMELL. *MR THERE WERE FRONT END PROBLEMS. THE 4WD MODULE WASN'T WORKING. THE DRIVESHAFT AND BOTH FRONT WHEEL BEARINGS WERE REPLACED. THE ROTORS WERE OUT OF ROUND. THE SERVICE ENGINE LIGHT ILLUMINATED ALONG WITH THE OVER DRIVE LIGHT. THE TRANSMISSION EXPERIENCED THE SAME PROBLEM ON TWO OCCASIONS AND POSSIBLY A THIRD TIME. A LARGE PUDDLE OF TRANSMISSION WAS FOUND UNDER THE VEHICLE. THE TORQUE CONVERTER WAS NOISY. THE ACCELERATION PEDAL WOULD PULL BACK. WHEN THE VEHICLE WAS ACCELERATED, IT WOULD WHINE. THE LEFT REAR WHEEL BEARING WAS GONE AND CAUSED DAMAGE TO THE AXLE, BRAKES AND THE TIRE WAS BARELY HOLDING ON. THE ERROR CODE FOR THE SERVICE ENGINE SOON LIGHT WAS DUE TO THE SOLENOID WHICH HAD BEEN CHANGED BEFORE. THE A/C WAS INOPERATIVE....
#10112988 | Fire
VEHICLE WAS PARKED IN THE GARAGE WHEN IT CAUGHT ON FIRE UNEXPECTEDLY. THE SOUNDS OF FIRE TRUCKS AT ABOUT 3:15 AM BEFORE CONSUMER KNEW THEIR GARAGE WAS THE ONE ON FIRE. THE FORD EXPLORER WAS COMPLETELY DESTROYED AS WELL AS THE OTHER 1992 GMC. THE FIRE CAME FROM UNDER THE HOOD OF THE FORD EXPLORER. *BF
#10098276 |
TRUCK WELL MAINTAINED AT 59,000 MILES TRUCK BROKE AN ENGINE ROD NEED NEW ENGINE, COST $4800.00, REPLACING ENGINE. I THINK FORD SHOULD PAY FOR THIS.*AK
#10097245 |
WHILE DRIVING 65 MPH THE VEHICLE COMPLETELY LOST POWER WITHOUT WARNING. AS A RESULT THE VEHICLE FAILED TO ACCELERATE. THE DEALER STATED THEY WERE UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB THIS HAS ACCURED 5 TIMES. FORD CAN NOT FIND THE PROBLEM. *EH
#10002730 |
I HAVE A 2002 FORD EXPLORER AND HAVE HAD NUMEROUS PROBLEMS THAT THE DEALER HAS NOT BEEN ABLE TO FIX. AT ANY SPEED THE ENGINE IS CONSTANTLY MAKING A TICKING NOISE. SOMETIMES WHEN MAKING A COMPLETE STOP THE TRUCK WILL STALL AND THEN JERK FORWARD WHEN I AM TRYING TO PUSH ON THE GAS TO GO. THIS HAPPENS SO MUCH AND I HAVE SENT IT IN NUMEROUS TIMES FOR THIS AND NO SOLUTION. THIS ALSO HAPPENED TWICE ON THE FREEWAY WHEN I HAD TO PRESS ON THE BRAKES TO STOP QUICKLY THE TRUCK LOCKED UP FOR ABOUT 5-10 SECONDS AND THEN JERKED FORWARD. I STILL HAVE TO DEAL WITH THIS SITUATION SINCE I AM IN A LEASE AND THE DEALERSHIP SAYS THEY CAN'T FIND ANYTHING WRONG. I TELL THEM IT IS DANGEROUS FOR ME TO BE DRIVING THIS VEHICLE. TWICE AT A STOP SIGN I TOOK MY FOOT OFF THE...

Other 2002 FORD EXPLORER Problem Areas

Power Trainautomatic Transmission 887 complaints Power Train 286 complaints Suspensionrear 192 complaints Structurebodyhatchbackliftgatehinge And Attachments 166 complaints Power Traindrivelinedifferential Unit 160 complaints Electrical System 115 complaints Suspension 115 complaints Structurebodyhatchbackliftgate 112 complaints Steering 110 complaints Structurebody 110 complaints Vehicle Speed Control 103 complaints Air Bags 96 complaints Wheels 58 complaints Suspensionfrontwheel Bearing 56 complaints Engine And Engine Coolingengine 50 complaints Engine 49 complaints Power Trainautomatic Transmissionlever And Linkagecolumn Shift 44 complaints Unknown Or Other 42 complaints Equipment 39 complaints Power Trainaxle Assembly 38 complaints Structure 38 complaints Suspensionrearspringscoil Springs 38 complaints Visibilityglass Siderear 38 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip 37 complaints Air Bagsfrontal 34 complaints Power Traindriveline 31 complaints Visibilitypower Window Devices And Controls 31 complaints Tires 29 complaints Power Traintransfer Case 4 Wheel Drive 28 complaints Fuel System Gasoline 27 complaints Steeringcolumn 25 complaints Vehicle Speed Controlaccelerator Pedal 25 complaints Engine And Engine Coolingenginegasoline 24 complaints Visibility 23 complaints Power Trainaxle Assemblyaxle Shaftseal 22 complaints Structurebodytailgate 22 complaints Seat Belts 21 complaints Latcheslockslinkages 19 complaints Air Bagsfrontalsensorcontrol Module 18 complaints Fuelpropulsion System 18 complaints Seats 18 complaints Vehicle Speed Controlcruise Control 17 complaints Parking Brake 16 complaints Power Trainaxle Hubs 15 complaints Service Brakes 15 complaints Service Brakes Hydraulic 15 complaints Suspensionrearsprings 15 complaints Power Trainautomatic Transmissiontorque Converter 14 complaints Structurebodydoor 14 complaints Suspensionfront 14 complaints Air Bagssidewindow 13 complaints Power Trainautomatic Transmissiongear Position Indication Prndl 13 complaints Power Trainmanual Transmission 13 complaints Equipmentapplianceair Conditioner 12 complaints Latcheslockslinkagesdoorslatch 12 complaints Latcheslockslinkageshatchbackliftgatelock 12 complaints Structurebodyhatchbackliftgatesupport Devicestrut 12 complaints Service Brakes Hydraulicfoundation Componentsdiscrotor 11 complaints Engine And Engine Coolingexhaust System 10 complaints Suspensionfronthub 10 complaints Visibilityrear Window Wiperwasher 10 complaints Wheelslugsnutsboltsstuds 10 complaints Exterior Lighting 9 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light 9 complaints Visibilitywiper 9 complaints Power Traindrivelinedriveshaft 8 complaints Vehicle Speed Controlcables 8 complaints Electrical Systemwiringinteriorunder Dash 7 complaints Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor 7 complaints Fuel System Otherstoragefuel Gauge System 7 complaints Interior Lighting 7 complaints Steeringrack And Pinion 7 complaints Suspensionrearaxlespindle 7 complaints Engine And Engine Coolingcooling System 6 complaints Latcheslockslinkagestailgatelatch 6 complaints Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm 6 complaints Structurebodytailgatehinge And Attachments 6 complaints Wheelshub 6 complaints Electrical Systemignitionswitch 5 complaints Electrical Systemwiring 5 complaints Exterior Lightingbrake Lightsswitch 5 complaints Fuel System Gasolinedeliveryfuel Pump 5 complaints Fuel System Other 5 complaints Power Trainaxle Assemblyaxle Shaft 5 complaints Seat Beltsfront 5 complaints Seatsfront Assemblyrecliner 5 complaints Service Brakes Hydraulicfoundation Components 5 complaints Structureframe And Members 5 complaints Visibilitydefrosterdefoggerhvac System 5 complaints Visibilitysunmoon Roof Assembly 5 complaints Electrical Systemwiringfuses And Circuit Breakers 4 complaints Fuel System Gasolinedeliveryhoses Linespiping And Fittings 4 complaints Power Trainclutch Assembly 4 complaints Seat Beltsfrontretractor 4 complaints Service Brakes Airantilockabs Warning Light 4 complaints Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule 4 complaints Service Brakes Hydraulicfoundation Componentsdiscpads 4 complaints Steeringhydraulic Power Assist System 4 complaints Suspensionrearaxlenon Powered Axle Assembly 4 complaints Tiressidewall 4 complaints Visibilitywindshield 4 complaints Electronic Stability Control Esc 3 complaints Engine And Engine Coolingexhaust Systememission Control 3 complaints Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe 3 complaints Equipment Adaptivemobility 3 complaints Equipmentmechanicalcarrierrack 3 complaints Fuel System Gasolinestorage 3 complaints Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap 3 complaints Seatsfront Assemblyhead Restraint 3 complaints Service Brakes Electric 3 complaints Steering Steering Wheelhandle Bar 3 complaints Steeringgear Box Other Than Rack And Pinion 3 complaints Structurebodydoorhinge And Attachments 3 complaints Tirestemporaryemergency Spare Tire 3 complaints Vehicle Speed Controllinkages 3 complaints Visibilityrearview Mirrorsdevicesexterior 3 complaints Electrical System Instrument Clusterpanel 2 complaints Electrical System12v24v48v Battery 2 complaints Electrical Systemignition 2 complaints Electrical Systemignitionanti Theftcontrol Module 2 complaints Electrical Systemignitionmodule 2 complaints Engine And Engine Coolingenginegasolinebelts And Associated Pulleys 2 complaints Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve 2 complaints Equipmentelectricalradiotape Deckcd Etc 2 complaints Equipmentrecreational Vehicletrailer 2 complaints Exterior Lightingheadlights 2 complaints Power Trainautomatic Transmissionparkneutral Start Interlock Switch 2 complaints Power Traindrivelinecenter Support Bearing 2 complaints Power Traindrivelineconstant Velocity Joint 2 complaints Power Trainmanual Transmissionfloor Shift Assembly 2 complaints Seat Beltsfrontbuckle Assembly 2 complaints Seatsmidrear Assembly 2 complaints Service Brakes Airantilock 2 complaints Service Brakes Hydraulicfoundation Componentsdisccaliper 2 complaints Service Brakes Hydraulicfoundation Componentsmaster Cylinder 2 complaints Service Brakes Hydraulicpedals And Linkages 2 complaints Steeringgear Boxshaft Sector 2 complaints Steeringlinkagestie Rod Assembly 2 complaints Suspensionfrontcontrol Armupper Ball Joint 2 complaints Suspensionfrontstabilizer Bar 2 complaints Suspensionrearshock Absorber 2 complaints Tirestreadbelt 2 complaints Visibilityrear Window Wiperwashermotor 2 complaints Visibilitywindshield Wiperwasher 2 complaints Visibilitywindshield Wiperwashermotor 2 complaints Wheelsmulti Piece 2 complaints Air Bagsfrontaldriver Sideinflator Module 1 complaint Air Bagson Off Switch Assembly 1 complaint Back Over Preventionwarningsexternalpedestrian Alert 1 complaint Electrical Systemalternatorgeneratorregulator 1 complaint Electrical Systemhorn 1 complaint Electrical Systemstarter Assemblysolenoid 1 complaint Electrical Systemwiring Rear Compartmenttrunk 1 complaint Electrical Systemwiringfront Underhood 1 complaint Engine And Engine Coolingcooling Systemfan 1 complaint Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv 1 complaint Equipmentelectricalnavigational Systemglobal Positioning System 1 complaint Exterior Lightingbrake Lights 1 complaint Exterior Lightingheadlightsswitch 1 complaint Exterior Lightingtail Lights 1 complaint Fuel System Gasolinedelivery 1 complaint Fuel System Gasolinestoragetank Assembly 1 complaint Latcheslockslinkageshoodlatch 1 complaint Parking Brakeconventionalmechanicallinkage And Cable 1 complaint Power Trainautomatic Transmissioncooling Unit And Lines 1 complaint Power Trainaxle Assemblybanjo Housing 1 complaint Seat Belts Rearotherbuckle Assembly 1 complaint Seat Beltsfrontanchorage 1 complaint Seat Beltsrearother 1 complaint Seatsfront Assemblypower Adjust 1 complaint Seatsfront Assemblyseat Heatercooler 1 complaint Service Brakes Airantilockcontrol Unitmodule 1 complaint Service Brakes Airdiscpads 1 complaint Service Brakes Hydraulicfoundation Componentsdifferential Proportional Valve 1 complaint Service Brakes Hydraulicfoundation Componentsdrum 1 complaint Steeringcolumn Lockinganti Theft Device 1 complaint Steeringrack And Pinionpinion Shaft 1 complaint Structurebodytrunk Lid 1 complaint Structureframe And Membersunderbody Shields 1 complaint Suspensionfrontcontrol Armlower Arm 1 complaint Suspensionfrontcontrol Armlower Ball Joint 1 complaint Suspensionfrontspringscoil Springs 1 complaint Tiresvalve 1 complaint Vehicle Speed Controlsprings 1 complaint Visibilitydefrosterdefoggerhvac Systemfanmotor 1 complaint Visibilitydefrosterdefoggerhvac Systemrear Window 1 complaint Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element 1 complaint Visibilityrear Window Wiperwasherlinkages 1 complaint Visibilityrearview Mirrorsdevices 1 complaint Visibilityrearview Mirrorsdevicesinterior 1 complaint Visibilitywindshield Wiperwasherswitchwiring 1 complaint Wheelshubcapcover 1 complaint Wheelsrim 1 complaint
← Back to 2002 FORD EXPLORER overview
Check any vehicle history by VIN - Free vehicle history report