2020 FORD EXPLORER Power Train Problems

I own a 2020 Ford Explorer with approximately 85,776 miles. The vehicle has experienced two separate loss-of-propulsion events in traffic. On both occasions, the vehicle suddenly lost power while driving and stalled in the middle of a busy intersection. There was no prior warning of imminent engine failure. After stalling, the vehicle would crank but would not restart. The vehicle was disabled in the intersection for approximately 45 minutes to one hour each time. My family was inside the vehicle during these incidents. The vehicle displayed multiple malfunction warnings including “Shift System Fault” and messages indicating the vehicle was not in Park even when the shifter was in the Park position. The dealership, Hansel Ford of Petaluma, verified the concern and referenced Ford Technical Service Bulletin (TSB) 23-2249 related to internal transmission components, including the valve body and park pawl actuator system. The dealership confirmed that when the vehicle is...

The catalytic converters (both) on my 5-year-old Ford Explorer both failed due to cracked welds. This failure appears to be common with the v6 ecoboost engines. It happened sometime before 124000 miles, it was only noticed because my wife and daughters started complaining about headaches and sleepiness when riding in the vehicle. The failure was only noticed when a mechanic evaluated it, the failure was not noticeable otherwise. I believe this is a very dangerous condition, as the fumes were evidently getting into the vehicle somehow and causing symptoms of carbon monoxide poisoning. The estimate to repair both is $5000, but according to the repair shop, there are currently none available. Ford has acknowledged this defect in Customer Satisfaction Program 21B35 and the 2025 service bulletin covering cracked weld failures. At about the same time, the transmission suddenly. The failure is very specific, and is documented in Ford Technical Service...

Driving at speed and starting to slow down the vehicle downshifted hard and afterwards would shift hard on every shift. Vehicle was taken to dealership and was diagnosed with CDF drum failure. Vehicle was under 100k miles and not under warranty.

The contact owns a 2020 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the transmission was shifting roughly while upshifting or downshifting before slamming into gear. Several warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted and worsened. There was transmission fluid odor coming from the vehicle and entering the cabin of the vehicle through the A/C vents. The contact stated that the engine unexpected revved while driving on the freeway. The contact stated that when the transmission slammed into gear, the vehicle felt like the parking brake was activated. The vehicle was taken to another dealer where it was diagnosed with transmission failure. The vehicle was not repaired due to the cost. The contact stated that the repairs were put on hold until the warranty...

Car will be in drive or reverse, start to move with foot on gas then will shift itself into park

The vehicle has experienced repeated automatic transmission malfunctions, including harsh and delayed shifting and hesitation. These issues caused unpredictable acceleration/deceleration and hesitation when starting from a stop or merging, creating a safety risk. The condition has been confirmed by authorized Ford dealers with repairs attempted and service bulletin referenced. The transmission is available for inspection. Symptoms have recurred despite repairs. Warning indicators and abnormal shifting behavior were observed intermittently beginning around 65,000 miles.

I was driving on the highway and I heard a loud bang , with grinding and a jerk i assumed the rear axel or differential something in the rear area along with smoke and I was able to swerve to the side of the highway along the grass and jump out with my kids multiple cars where behind me but I turned on my emergency lights & got out just in time before causing a accident , this is all tied to a recall that’s been fixed twice now here we are a third time and it’s back again at ford dealership

The transmission developed a harsh engagement from part to reverse and a harsh downshift when decelerating. The vehicle would frequently not change gears at highway speeds.Inspection showed that the transmission pan was full but fluid was burnt.

I was driving my vehicle that was just over 5 years old with just over 38,000 miles on the highway out of state for a family wedding with my 3 children and wife. There were no safety lights or indications of any malfunction, but upon acceleration the transmission “was not engaging” and it would not shift up to increase speed. I pulled to the far lane and upon down shifting the vehicle was jerking forward. After getting off the next exit, the vehicle would not engage between gears and speed up. This put my family with 3 kids under 7 at extreme risk and left us stranded out of state with minimal options. The car needed to be towed and arrangements needed to be made for our family and all belongings packed in the car. It was determined that the transmission was in need of full rebuild or replacement and...

Transmission randomly kicks out of gear causing a grinding noise and loss of acceleration. This is the second transmission that has been put in this vehicle due to the same issue. No warning lamps. No codes stored. Each time it has happened has been merging on or off of a highway/interstate causing me to almost be in a rear end collision.

On December 26, at approximately 7:08 p.m., I was driving on the Belt Parkway during a snowstorm. I was traveling in the middle lane and began to safely change lanes to the right. During the lane change, the vehicle’s four-wheel-drive system suddenly displayed an error and appeared to malfunction. Immediately after this occurred, I lost control of the vehicle. The vehicle veered to the right, struck the median, and flipped over twice before coming to rest on its side. Prior to the system error, I was operating the vehicle normally and driving cautiously given the weather conditions. The loss of control occurred abruptly and without warning.

Vehicle did not want to shift above 35 mph. When letting off gas - harsh downshift (with no break lights) at 25mph. Diagnosed transmission problem - repaired- Ford dealership rebuilt transmission. No warnings or messages prior to failure.

My explorer was very slow/unable to accelerate onto the highway. The next time I started it there was rattling and lots of non engine noises, along with all kinds of warning lights. I took it to the dealership. In his words ‘the turbo grenaded itself into the engine. Quoted me 15k to fix/replace the engine, turbo and half shaft. I still owe 9k on it. Extended warranty that I purchased expired 4,000 miles ago. I have had multiple issues with this vehicle since I purchased it brand new in 2020. I am trading it in tomorrow🙁

The car started hard shifting, bucking like an animal in the middle of driving 70 on the highway, hard to control, hard to stay out of traffic, started to smell like fuel was in the cabin, it took all I had to keep it in my lane and get over to safety without killing myself or someone else, took it to the dealership, they could not look at it for two weeks, took it to a different shop, he found that a wire had been cut and some hoses were zip tied to the frame ( previously only work on this car has been at dealership) he then towed it to the dealership at the two week appointment and they say its burning transmission fluid and hard shifting and needs a new transmission. The warranty expired two days before this occurred so not covered, it is a 2020 , should...

Since I have bought my 2020 Ford Explorer (brand new off the lot) it has had to have the turbo replaced several times now . Currently the turbo is bad again and I’m looking at a $3500 repair for a turbo that was already replaced 2 times since I bought it. I feel there is an issue with this car handling the turbos , I am a single mom of 5 kids and cannot afford to keep replacing turbos every couple years. I now have it sitting in my driveway cause it can’t be driven and still have a $740 momthly payment to pay on it and because I can’t use the car I can’t go to work anymore so I need help with this please

The contact owns a 2020 Ford Explorer. The contact stated that while driving at 50 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning lights were illuminated. The contact stated that the system then resumed normal functionality. The vehicle was taken to the dealer, where it was diagnosed, and determined that an unknown sensor had failed. The vehicle remained at the dealer unrepaired. The contact stated that recently the liftgate failed to function as intended. The contact used the key fob to open the liftgate, and the liftgate failed to function as intended. The contact turned off the vehicle and waited to restart the vehicle; however, the failure persisted. The contact was able to open the liftgate after fifteen minutes. The vehicle was not taken to the dealer or an independent mechanic. The contact stated that one year ago, there was an abnormal sound...

Car was bought from Healy Ford in Goshen Ny in January 2023. Car drove fine for the first 6 months. Out of no where all the lights on the dash came on. Hill assist 4wheel drive fault power train malfunction. Collision assist I mean everything. Took it it Rea Ford they looked at it and charged me for a system update. Was good for about 8 months still had a problem when in reverse splitting out of gear then would slam back in to gear. Then the power train malfunction comes on every time I drive it, Took it back to dealership he updated the software I was told it was a bulletin not a recall and it is going to cost me over 2000.00 to fix since the update didn’t fix the problem. I am truly disappointed but stuck with ford at the moment. How can this not be...

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed, the accelerator was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact stated that the transmission was shifting roughly while upshifting or downshifting. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure. The contact was informed about a TSB with a similar failure, and the contact was informed that there were no recalls on the VIN related to the transmission. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Subject: Formal Complaint – 2020 Ford Explorer Transmission Failures and Unfair Coverage Practices Dear Ford Customer Service, I am writing to formally express my concern and disappointment regarding repeated transmission failures in my 2020 Ford Explorer. The vehicle required its first transmission replacement at just 4,000 miles, and again recently at approximately 100,000 miles. It has come to my attention that Ford issued a recall for transmission issues affecting a large number of 2020 Ford Explorers manufactured at the Chicago Assembly Plant during the COVID production period. My vehicle, however, narrowly falls one month outside of the official recall range. Despite this, the symptoms and failures my vehicle experienced are identical to those described in the recall and in numerous owner complaints online. I find it deeply concerning and unjust that Ford refuses to extend coverage to vehicles like mine that clearly suffer from the same manufacturing defects. It is...

Powertrain malfunction/ Reduced power Bill start assist warning Pre-collision assist not available

Hard shifting in lower gears when transmission warms up, hard downshifting to lower gears as well. This is extremely harmful if the shifting jerks hard, causing whiplash or can cause a wreck.

The component that failed was the CDF Clutch Hub. Very hard shifting when accelerating from a stop and when going up hill. The problem has been confirmed by the Ford dealership. I had no warning prior to this happening. Safety concerns in that I could not accelerate quickly to avoid impending traffic.

Ford ST 2020 just 37000 miles, the window from driver side can’t complete close when you try to roll up. When it all most close- it will automatically roll down. TPMS fails cause 4WD fault, ABS turn off and a lot of warning symbol turn on like pre-collision…etc. Dealer can’t fix and claim for client need to paid for 4WD program.

On my way to visit my cousin down south my vehicle wouldnt go in park. A warning came across stating that it was a shift system fault. I went to the Ford dealership in North Carolina. They werent helpful. I went to a nearby auto repair shop alerted me that it was an issue with tge powertrain that Ford covered in vehicles same as my yr make and model. Ford refused to honor it due to the fact that it doesnt fit my vin number even though it is the very same issue presented in the other vehicle with the similar yr make and model. It is unsafe. I have a family. I would not move

The contact owns a 2020 Ford Explorer. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted from 3rd to 2nd gear as indicated on the console shift indicator. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. After investigating the failure, the contact related the failure to Technical Service Bulletin: 22-2428. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 83,000.

On [XXX]., in heavy rush‑hour traffic on [XXX] , my vehicle (~75,417 mi) suddenly lost motive power w/o warning at ~55 mph. It became immobile in a live lane, creating a roadblock and rear‑end crash risk. Drivers swerved/honked. Accelerator had no effect; limited/no power‑steering assist; I coasted to an in‑lane stop (no safe shoulder) and activated hazards. Cluster displayed “SHIFT SYS FAULT—Service Required” and wrench icon. Attempts to restart failed; the vehicle remained disabled ~30min until a tow arrived; police responded. After tow, on a slight incline, the vehicle rolled backward when started and the parking brake was released, though the cluster showed Park—clear rollaway concern. Recovery/diagnosis: Towed first to AutoTech Clinic (advised replacement trans). Then to Bill Brown Ford (Livonia, MI): fractured planetary gear and broken park pawl; recommended full transmission replacement (~$8,500). Repair history (pre‑purchase): I’ve owned the car <6 mos (now ~75k). A Ford dealer later informed...

Ford has released a technical service bulletin for this issue , however they are not being held accountable for the issue at hand that I believe poses a safety issue while driving and could cause other drivers to run into the back of your car. The TSB was posted for a part inside the transmission which is a snap ring that comes dislodged from its groove and causes harsh down shifts between gears. This has happened to thousands of owners of these vehicles with a simple internet search. To say a harsh downshift is the issue is putting it mildly. When you are decelerating and the transmission downshifts as it does, It feels as if you slammed on your brakes, however the cars behind you see no brake lights light up to tell them you just slowed down considerably which could cause a pile up accident, especially in rush hour...

Car vibrate and jerk when switching gears randomly. Also the control panel has went out twice. I read everywhere these vehicles have issues with transmission problems on all the 2020 and there is no recall this is. Ridiculous.

For new model year 20 20, and 2021 Ford developed an all-wheel-drive vehicle. This is not a four-wheel-drive vehicle. It is an all-wheel-drive vehicle that you can select manually into four-wheel-drive, but it has an automatic system that engages and disengages the front drive axle through a comp component called an FADA. Front axle disconnect actuator. Ford has problems with that actuator going bad to the point that they put out a technical service bulletin to fix this unsafe design TSB 23-2174 dated 24 July 2023. They replace the drive axle and this component and make the car full time all wheel drive. The reason was because the actuator would fail and it would damage the front differential when it locked up on the highway. My car is in Service right now getting it replaced over $3000 and it just clicked past the drivetrain warranty. Now, unfortunately, the car is...

Transmission starting to fail at around 91,000 miles. Diagnosed at dealership. Just out of warranty. Other repair shops say this is a common issue. This should be a recall matter.

Transmission shifts hard from first to second gear upon acceleration, then shifts hard down at approximately 25-30mph. Dealership is aware. Has been happening since I got vehicle, but no fix has been available.

i have been seeing complainants about the 2020 ford explorer transmission, I just want to say that I also had transmission issues with my 2020 ford explorer, I had Vehicle down shift issues at or around 50,000 miles, i took it back to the dealer because it was still under the 60K miles power train warr. The dealer had my explorer for about a week to do repairs, I do remember them saying there was a technical bulletin about this problem. I still have transmission jerking issues when i am driving slowly and have to let's say step on the gas to accelerate. I am at 67,000 miles now and worried is this thing going to make it to 100K.

Dear NHTSA, I am writing to formally report a critical safety issue involving our 2020 Ford Explorer that I believe demands immediate investigation and consideration for a recall. While my wife was driving the vehicle on the freeway with our two young children, the transmission began shifting erratically and aggressively at various speeds. The vehicle experienced sudden power loss, delayed gear engagement, and violent jerking motions that nearly resulted in a rear-end collision due to the abrupt deceleration. This malfunction placed my family and others on the road in immediate danger. This is not an isolated incident. I am aware that there is already a Technical Service Bulletin (TSB) issued for this transmission issue, as well as an active class action lawsuit related to the same defect. These facts indicate that Ford is aware of the problem, yet the risk to consumers remains unaddressed through a formal recall. This is...

On highway was accelerating to pass another vehicle the transition froze , engine revved with no acceleration ( transmission skipped) this has happened several times over the 5 years. The lasted event we documented the date and mileage it happened date 7/13/25 mileage is 34990. These skips have put us in extremely dangerous situations. Transmission has been making growling noise now under normal driving.

Th car goes into gear but does not go anywhere.

The transmission shifted into neutral at a stop sign and a see dealer warning light came on. Turned the vehicle off and restarted it and it was able to resume drive. It happened twice more at a speed of 70mph. Ford has had the vehicle all but 3 weeks since 5/12 to repair it. Replaced the trans and harness.

Bought my car 2020 and every year I have been on and off the shop to fix it. Last year I just paid them to fox my transmission gearing, clutch and axle. The other dY I have them service it again due to power train malfunction. And sent me an invoice of $1700 not including the $195 to diagnostic test for my car.

Vehicle down shifts hard from 7th to 6th gear tested in manual mode but was originally feeling it while driving automatic when slowing down between 25 - 35 mph then I found a tsb that suggested trying it in manual in those gears and it happens every time

The 2020 Ford Explorer was repaired due to a recall on the rear differential bolt. The bolt that was replaced fell out and had to go back in for service. The dealer said Ford refused to pay the full cost and it was split between Ford and the owner. We had to pay $2085.97 for the repair of a recalled item.

The transmission has failed due to a snap ring being dislodged. This caused substantial damage requiring complete transmission rebuild. The vehicle is currently at a ford dealership where they have identified the issue. The serviceman stated that the snap ring failure is due to manufactures defect and that it is a well known and common failure. Ford has a service bulletin describing this issue. Failure to repair this in a timely manner will cause catastrophic failure that could lead to loss of control of the vehicle. There were no warning lights for this issue. The first symptom was harsh shifting. The vehicle was taken to the dealership the day following the first symptom but the damage had been done.

I recently had my vehicle serviced for reprogramming of the AWD control module after it failed. When the dealer returned the vehicle, I expected the issue to be resolved. Instead, I immediately noticed a new check engine light with code C00A6, related to the front axle disconnect. This was concerning because the dealer had assured me there were no active codes after programming the new module. After driving with the new fault, it became clear the vehicle was operating only in rear-wheel drive. I contacted Ford and was quoted $4,030 for repairs to the front axle disconnect. Given the cost, I researched whether this issue had a recall but found none, despite widespread reports from other owners experiencing the same failure. My main frustration is that this problem stems from Ford’s design of the intermittent AWD system, which engages the front wheels only when needed to improve fuel economy. The...

Transmission gears were not running properly. On a Saturday evening the car was sleeping when slowing down and the following morning it completely died. Ford is reporting to me that I need a new transmission and I am only 1K miles over the warranty. i have read on line from several others with the 2020 explorer having this issue or the tranny dieing within 10-20K miles after warranty.

At this time, I am unsure if there is some kind of recall, but my alarm is going off alerting me that the lift gate opened but that isn't true once my vehicle is locked. Also, the headlights turn on by themselves as if i have pressed on the keyfob. I then get an alert stating that the remote features disabled to preserve battery. These are just a few of the issues that i am having with this vehicle at this moment. I am a mother to 3 kids and i need to have a reliable vehicle and I don't have time to stress about not locking my vehicle at night jus to avoid my alarm going off. This is insane.

On [XXX], after starting my vehicle, I received multiple safety warnings, prompting the check engine light and a wrench icon on the dashboard. The alerts included issues with the anti-collision system, hill assist, traction control, lane departure, and adaptive cruise control, as well as my drive modes which were also unavailable. I contacted Raceway Ford in Riverside, CA, and dropped off the vehicle that day, reporting the errors. The dealership informed me the next day that the Half Shaft Speed Sensor had failed and would cost $870.52 to replace. Since the warranty had expired a month earlier on [XXX], this was no longer covered under the drivetrain warranty. I agreed to the repairs. After installing the new sensor, and conducting a test drive, additional errors appeared. After two weeks in the shop and multiple follow-ups, the dealership concluded that the AWD/FWD sensor had also failed and replaced both sensors. The...

My got multiple warning messages while driving my 2020 Ford Explorer. My local repair shop ran test and determined it needs a new front axle disconnect actuator/shaft - TECHNICAL SERVICE BULLETIN 23-2174. Without this repair, several sensors are deactivated: 4WD, Hill Start Assist, Forward Collision Warning, Blind Spot system, pre-collision Assist and Service AdvanceTrac. With those functions disabled, it puts the driver/passengers at higher risk of collision - especially in the winter months. This repair is costing me over $2000. A vehicle with less than 70000 miles should not be having an issue like this, and Ford is award of the problem, yet have not issued a warranty extension or recall.

While braking vehicle downshifted harshly with a noticeable slam into gear. While under acceleration, vehicle rpms raised sharply as transmission slipped and would not engage and accelerate. Potential risk to injury as vehicle transmission failed on interstate with loss of acceleration. Towed vehicle to Ford dealership. Ford dealership inspected to the conclusion of "Fluid full/extremely burnt. Possible A clutch failure due to faulty front support". Ford dealer recommended to remove and replace transmission. - Transmission failure, not available for inspection. - Safety risk due to transmission failure at interstate speeds with loss of acceleration. - Problem reproduced by Ford dealership - Transmission inspected by Ford dealership - Wrench light illuminated shortly after initial harsh downshift and acceleration with transmission slip.

I have a 2020 ford explorer with the 3.3 motor. It was making an odd ticking noise, and I took it into the dealership, here the waterpump is bad. I have looked online and there are plenty of people complaining about pre mature waterpump failure. I called ford consumer affairs and warranty dept as my vehicle is not far out of warranty and they refuse to cover the repair.

issued started happening when I tried to get into my car and my keyfob was not working. then notice the number pad was working and was able to get into the vehicle. Once inside, vehicle did not want to start. I turn on and off the headlights and thats when the vehicle started. Once started, vehicle started showing orange warning messages. the following messages were shown: Pre-Collision Assist Not Available Hill Start Assist Not Available 4WD Fault Service Required Service AdvanceTrac See Manual with a wrench on it. There is also a wrench light on with the advance trac light on. This issue was diagnosed by Ford Scarsdale and they charge me $209 just for the diagnostic and stated that I need a new AWD Module plus performing TSB 23-2174. with a list of parts totaling $926.42 plus labor of $1,463. The labor seems a bit over price as I...

What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission failed at approximately 80,000 miles. It requires a complete rebuild/replacement. The failed transmission is available for inspection upon request. It is currently at the transmission shop. How was your safety or the safety of others put at risk? Although the vehicle was technically still drivable, it did not feel safe. The transmission slipped and struggled to shift, and the vehicle felt like it could break down or cause a wreck at any point. The sudden and unpredictable loss of proper control put me and other drivers at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. An independent transmission repair service confirmed the failure and determined that the transmission required a full rebuild/replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives...

Transmission slipping at 32m/h when downshifting