2020 FORD EXPLORER Visibilitysunmoon Roof Assembly Problems

The contact owns a 2020 Ford Explorer. The contact stated that while driving 70 MPH, the contact depressed the button to open the moonroof, and the cloth material covering the moonroof detached. The contact's daughter was sitting in the second row in the middle seat and alerted the contact to the failure. No warning lights were illuminated. The contact stated that hanging cloth covers over the rear-view mirror was obstructing his view. The vehicle was not taken to a dealer. There was no cause for the failure found. The vehicle was not repaired due to the cost. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2020 Ford Explorer. The contact stated while driving 75 MPH, the sunroof fractured without impact. Additionally, the fractured glass fell onto the contact and all over the interior of the vehicle. The contact sustained cuts from the fractured glass. The contact had not received medical treatment. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

The front panel of my 2020 Ford Explorer ST panoramic sunroof exploded on May 6, 2022. Fortunately, I had closed the sun shade two days prior while on vacation in Florida. It was not due to being hit by debris as traffic was light and no trucks nearby. I was driving westbound on I-4 between Orlando and Tampa when a sudden "BOOM" occurred. I looked around as to what happened as their was no vibration or shuttering in the steering. I then heard glass shattering. When I could safely pull to the side of the road to inspect, the entire front panel of the sunroof was gone except around the perimeter. If I had not previously closed the sun shade, the tempered glass would have been in my eyes and any passengers in the front or rear seats. The local Ford dealership initially stated that the sunroof would be covered...

The vehicle has been in the Ford Dealer 3-times to replace the sunroof/moonroof wind deflector. It has fallen off while driving two times interfering with traffic and one time it detached on one side only. Fortunately, no one was injured or any damage done other than the deflector was damaged by traffic after it detached. It was replaced just a few weeks ago for the second time and it just detached and fell off again while driving yesterday. I notified Ford Quality and Customer Concerns of the situation but no reply, apparently Ford, nor the dealer appear to care. However, besides the cost someone is going to get hurt. The first time the wind deflector came off was in April 21 and the second time October 22, the third time was yesterday, 01-14-22.