NHTSA Complaint #11682234 — 2020 FORD EXPLORER

issued started happening when I tried to get into my car and my keyfob was not working. then notice the number pad was working and was able to get into the vehicle. Once inside, vehicle did not want to start. I turn on and off the headlights and thats when the vehicle started. Once started, vehicle started showing orange warning messages. the following messages were shown: Pre-Collision Assist Not Available Hill Start Assist Not Available 4WD Fault Service Required Service AdvanceTrac See Manual with a wrench on it. There is also a wrench light on with the advance trac light on. This issue was diagnosed by Ford Scarsdale and they charge me $209 just for the diagnostic and stated that I need a new AWD Module plus performing TSB 23-2174. with a list of parts totaling $926.42 plus labor of $1,463. The labor seems a bit over price as I don't believe it will take 7 hours to fix this if we take the labor at $200/Hr. There were no prior messages prior to failure. Issue started happening around August 9th, 2025 where my car would start with no issues and after 10 minutes of driving, all the above messages would start showing. Now, messages show when car starts and dont go away. In addition, I have taken my vehicle to Ford Scarsdale on July 2, 2025 from front/read differential and transfer case fluid change and pinion seal change. In addition, on 03/27/2024, I took my vehicle since there was oil leak in the front axle and was repaired under warranty. Dealership should have suggested to do this TSB 23-2174 knowing this was a common issue and I was still under warranty