2004 TOYOTA SIENNA Latcheslockslinkages Problems

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 50 MPH, THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED AND A WARNING CHIME SOUNDED. THE VEHICLE LOST STEERING AND BRAKING ABILITY, AND THE STEERING WHEEL STARTED TO JERK FROM LEFT TO RIGHT. THE CONTACT CONTINUED TO DRIVE AND THE FAILURES WENT AWAY AFTER THIRTY SECONDS. THE CONTACT STATED THAT THE FAILURES RANDOMLY STARTED APPROXIMATELY ONE YEAR AGO AND GREW WORSE. THE CONTACT ALSO MENTIONED THAT THE LOCK ON THE SLIDING DOOR SHOWED THAT IT WAS UNLOCKED; HOWEVER, NO ONE COULD EXIT THE VEHICLE WHEN ATTEMPTING TO OPEN THE DOOR FROM THE INSIDE OR THE OUTSIDE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

VEHICLE RANDOMLY SELF-LOCKS WHILE IN PARK WITH CAR TURNED OFF, WITHOUT ANY INDICATION. THIS HAS HAPPENED WITH MY KEYS INSIDE THE VEHICLE ON THE SEAT WHILE PUTTING GROCERIES IN THE BACK AT THE STORE AND AT HOME. IT HAPPENS ALL THE TIME NOW, AND ITS SCARY, BECAUSE I HAVE A YOUNG CHILD WHO I STRAP INTO THE CAR SEAT AND THEN WALK AROUND TO THE DRIVERS SIDE, USUALLY AFTER PUTTING MY PURSE AND KEYS DOWN ON SEAT UP FRONT. IF CAR SELF LOCKS, KIDS COULD BE TRAPPED INSIDE. RESEARCH ON LINE SHOWS THIS IS A PROBLEM WITH OTHER TOYOTAS, POSSIBLY HAVING SOMETHING TO DO WITH A SECURITY SYSTEM HARNESS GLITCH OR DOOR LOCK ACTUATOR? *TR

POWER SLICING DOOR CABLE ASSEMBLIES...... WORK AND THEN NOT WORKING ON AND OFF... DID NOT FILE COMPLAINT BEFORE BECAUSE CHILDREN COMPLAIN NOT WORKING BUT WHEN I TRIED... IT WORKS ABOUT 4 TIMES IN THE PAST. FIRST INSTANCE IN 2008. //// NOW NOT WORKING COMPLETELY/STUCK. THE POWER IS WORKING, BUT LOCK APPEAR STUCK TO WHERE THE LOCK BUTTON WONT UNLOCK SO DOOR CAN NOT BE OPEN BY BUTTON OR MANUALLY. ***** THE WARRANTY IS 120,000 MILE FOR POWER SLICING DOOR CABLE ASSEMBLIES .... MY CAR DOOR IS COMPLETELY STUCK / WONT OPEN NOW AT 142,000. *TR

MANUFACTURER DESIGN FLAW LEADS TO JAMMED SLIDING DOORS, POSSIBLY LOCKING PASSENGERS INSIDE. NUMEROUS COMPLAINTS ONLINE. TOYOTA APPARENTLY ACKNOWLEDGES THE PROBLEM AS IT HAS EXTENDED WARRANTY ON THOSE PARTS TO 9 YRS OR 120K MILES. MAILING LETTERS EARLIER THIS YEAR. I RECEIVED NOTICE FROM THEM WHEN MY CAR HAD 7 YRS / 130K MILES. I THINK THEY ARE NOT BEING PROACTIVE ENOUGH WITH AN ISSUE THAT RENDERED ONE OF MY DOORS INOPERATIONAL. IT IS NOT THAT I CAN'T USE THE ELECTRIC DOOR OPENING MECHANISM, THE DEFECT ALSO IMPEDES THE DOOR FROM OPENING AT ALL. I THINK IT BECOMES A SAFETY HAZARD AND SHOULD BE COVERED NO MATTER WHEN. IT IS NOT MY FAULT IT TOOK THEM SEVERAL YEARS TO ACKNOWLEDGE THE PROBLEM - MY CAR WOULD BE COVERED HAD THEM MAILED THE LETTER ONE YEAR BEFORE. *TR

OUR 2004 SIENNA'S DRIVER-SIDE MANUAL-SLIDER DOOR DOES NOT LATCH PROPERLY. 2 OF THE 3 BOLTS HAVE BECOME DETACHED. TOYOTA STATES THAT THIS IS NOT COVERED UNDER THE "REAR SLIDING DOOR LATCH ASSEMBLY" WARRANTY ENHANCEMENT NOTICE, ALTHOUGH DETACHED BOLTS AND FAILURE OF THE REAR SLIDING DOOR TO PROPERLY LATCH IS CLEARLY A LATCH ASSEMBLY ISSUE. THIS IS ALSO A SIGNIFICANT SAFETY CONCERN AS MY SON RIDES IN THAT SIDE OF THE CAR AND IF THE DOOR WOULD BECOME UNLATCHED WHILE DRIVING HE COULD BE INJURED NOT TO MENTION CAUSING AN ACCIDENT AS I (THE DRIVER) ATTEMPT TO CONTROL/ASSESS THE PROBLEM AND PROTECT MY SON IN A MOVING VEHICLE. MY "DOOR OPEN" DASH LIGHTS ARE CONSTANTLY ON AND THIS IS A DISTRACTION WHILE DRIVING NOT TO MENTION WHEN I IGNORE THE LIGHTS BECAUSE OF THIS PERSISTENT PROBLEM, I MAY BE MISSING OTHER DOOR-OPEN ISSUES. THERE ARE ONLINE POSTS OF OTHER SIENNA OWNERS...

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN SHE ATTEMPTED TO OPEN THE FRONT DRIVERS SIDE DOOR, BUT THE DOOR WOULD NOT OPEN UNTIL EXCESSIVE FORCE WAS USED. THE CONTACT ALSO STATED THAT THE DRIVER'S SIDE SLIDING DOOR WOULD NOT OPEN WHEN THE BUTTON ON THE KEY FOB WAS ENGAGED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR TO BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 91,000.

TOTAL FAILURE OF REAR LIFTGATE STRUTS (MANUAL LIFTGATE). CANNOT SUPPORT WEIGHT OF LIFTGATE; LIFTGATE DROPS IMMEDIATELY WHEN RELEASED. SIMILAR TO PROBLEM IN RECALL 08V244000 FOR SIENNA POWER REAR LIFTGATE STRUTS. *TR

THE CABLE WHICH DRIVES THE SLIDING DOOR IS COMPLETELY EXPOSED TO ELEMENTS. (YOU'LL FIND IT WITHIN THE GROOVE LOCATED UNDER THE REAR SIDE WINDOWS) THIS CABLE IS MADE OF SOME KIND OF METAL (STEEL? WHO KNOWS.) THEN COATED WITH A BLACK PLASTIC/ACRYLIC/RUBBER CASING (SUCH AS AN ELECTRICAL WIRE). WITH TIME, THE CASING BEGINS TO DRY AND BE BRITTLE, CAUSING IT TO CRACK AND FALL OFF THE WIRE, LEAVING THE WIRES COMPLETELY VULNERABLE TO GETTING WET, RUST, FREEZE, ETC, ALSO RUBBING EXTENSIVELY UNPROTECTED AGAINST THE GEARS. WITHIN A FEW MONTHS OR EVEN WEEKS, THE METAL CABLE WIRES SNAP THUS GETTING CAUGHT IN THE MECHANISM. ONE THING LEADS TO ANOTHER AND THE WHOLE CABLE SNAPS, MAKING THE DOOR JAM ALTOGETHER. *TT

TOYOTA SIENNA AUTOMATIC SLIDING DOOR FAILED. THE DOOR IS UNABLE TO BE OPENED EVEN IN MANUAL MODE. THIS IS A DESIGN FLAW AND A SERIOUS SAFETY ISSUE AS MY CHILDREN NEED TO CLIMB OVER SEATS TO EXIT THROUGH THE ONLY DOOR THAT WORKS. WHEN THAT CABLE MECHANISM BREAKS, THEY WILL HAVE NO WAY TO EXIT THE VEHICLE IN AN EMERGENCY. *TR

MANUAL SLIDING DOOR (DRIVERS SIDE) DOESN'T LATCH COMPLETELY AND COMES OPEN WHEN TURNING RIGHT. *TR

MY COMPLAINT BEGAN AT 110,000 MILES. I BEGAN CALLING TOYOTA IN 2008 WHEN MY PASSENGER SIDE AUTOMATIC DOOR CAUGHT MY DAUGHTERS ARM AND THE SAFETY FEATURE DID NOT REOPEN THE DOOR. ABOUT TWO MONTHS LATER, I DROPPED MY DAUGHTER OFF TO SCHOOL THE PRINCIPAL WAS COMING TOWARD THE DOOR AND THE CABLE SNAPPED! I HAVE CALLED EVERY TOYOTA COMPANY I CAN ONLY TO BE TOLD IT WOULD COST $3,000 AND "ITS NORMAL WEAR AND TEAR" REALLY? THE CABLE WAS RUSTED BECAUSE THE CABLE IS ON THE OUTSIDE OF THE VEHICLE. THE DOOR WOULD NOT SHUT AT ALL, AND COULD NOT BE PUT INTO MANUAL BECAUSE OF THE CABLE. I HAVE TAKEN TO ANOTHERMECHANIC AS TOYOTA HAS NO REGARD FOR HUMAN LIFE, WHEN SOMEONE DIES, THEY WILL FIX IT. I HAVE 6 COMPLAINTS ON FILE AND NOONE WILL HELP ME UNLESS I PAY $3,000 TO FIX A CABLE THAT WAS DEFECTIVE....

PASSENGER SLIDING DOOR FAILURE. CABLE COMPROMISED DUE TO DESIGN FLAW THAT STRIPPED IT OF ITS INSULATION. DESPITE BEING GARAGED, THIS CAUSED THE CABLE TO FRAY AND THEN RUST, MAKING THE DOOR INOPERABLE. THIS INCLUDES MANUALLY, AS THE CABLE CATCHES ON A ROLLER AT THE DOOR HINGE IN THE SLIDING TRACK. ADDITIONAL FEAR IS THAT CONSEQUENT MOTOR STRAIN MAY CAUSE ADDITIONAL FAILURE/EXPENSE/FIRE. THE CABLE FAILURE CAUSES IT TO BIND ON THE HINGE ROLLER AND PREVENTS THE DOOR FROM BOTH OPENING *AND* CLOSING. IN AN ACCIDENT, YOU WILL NOT BE ABLE TO EXIT THE VEHICLE FROM THAT SIDE IF NECESSARY. DOOR DID OPEN PARTIALLY AND THEN WOULD NOT CLOSE WITHOUT GREAT EXERTION. THANKFULLY, MY WIFE WAS ABLE TO FORCE IT CLOSED BEFORE HAVING TO TAKE THE HIGHWAY WITH OUR CHILDREN INSIDE AND AN OPEN DOOR. ONCE THE PART FAILS, THE DOOR CAN NOT BE MADE OPERABLE WITHOUT MAJOR REPAIR. TOYOTA HAS TSB...

RIGHT POWER SLIDING DOOR IS COMPLETELY INOPERATIVE. UNABLE TO OPEN THE DOOR WITH EITHER THE MANUAL HANDLES (INSIDE OR OUTSIDE) OR THE POWER SWITCH. *TR

2004 TOYOTA SIENNA RIGHT SLIDING DOOR HINGE FAILURE AND DOOR POP OPENED WHILE ON THE FREEWAY. DOOR WILL NOT STAY CLOSE AT ALL. DOOR WILL CLOSE BUT WILL OPEN IMMEDIATELY. DOOR WILL STAY COMPLETELY OPEN AFTER TRYING TO CLOSE MANY TIMES. FINALLY MANUAL DOOR SWITCH HAD TO BE ACTIVATED TO CLOSE DOOR. *TR

THE REAR, AUTOMATIC SLIDING DOOR TO MY 2004 TOYOTA SIENNA IS INOPERABLE. THE CABLE SNAPPED. I'VE READ NUMEROUS REPORTS ON-LINE OF THIS TYPE OF INCIDENT RELATED TO THIS MODEL. THE REPAIR ESTIMATES AVERAGE ABOUT $1500. OBVIOUSLY, THIS IS A CONSUMER ISSUE AS WELL AS A SAFETY ISSUE THAT SHOULD BE ADDRESSED. *TR

THE WIRE APPARATUS THAT FUNCTIONS OUR BOTH OF OUR AUTOMATIC SIDE DOORS ON OUR 2004 TOYOTA SIENNA HAS SNAPPED. BOTH DOORS NOW DO NOT FUNCTION CORRECTLY AND CAUSE THE ONE OF THE DOORS TO REQUIRE A LOT OF FORCE TO SHUT. MY ONLINE RESEARCH HAS ENLIGHTENED ME THAT THIS IS IN PREVALENT ISSUE ON THE 2004 SIENNA MINIVAN. PLEASE HELP! *TR

SLIDING DOORS OPEN WHEN DRIVING. *TR

I HAVE A 2004 TOYOTA SIENNA. BOTH SLIDING DOORS NOW HAVE BROKEN CABLES AND WILL NOT OPEN FROM THE INSIDE. THEY ONLY OPEN WHEN FORCED OPEN FROM THE OUTSIDE. THE REPAIR COST FROM A TOYOTA DEALER IS $1,600.00 PER DOOR. THE PART ITSELF COST $1,100.00 PLUS THE LABOR. THE DOORS NOW ARE A SAFETY ISSUE SINCE MY SON CAN NOT GET OUT OF THE BACK QUICKLY IF NEEDED. THE CABLES RUSTED AND SEVERED WHILE OPENING. THE DOORS DO NOT HAVE A MANUAL OVERRIDE TO ALLOW OPENING PROPERLY ONCE THE ELECTRONIC OPERATION IS COMPROMISED. *TR

I OWN A 2004 TOYOTA SIENNA WITH POWER SLIDING DOORS. THE CABLE ON MY DRIVER'S SIDE DOOR SNAPPED, CAUSING THE DOOR TO NOT BE ABLE TO CLOSE. MY HUSBAND SAT IN THE BACK SEAT AND HELD THE DOOR SHUT WHILE WE DROVE IT TO THE SERVICE CENTER. THE REPAIR WAS ESTIMATED TO BE AROUND $1500, SO WE HAD THEM DISABLE THE POWER FEATURE AND WE NOW USE THE DOOR MANUALLY. THIS CABLE SNAPPING ON 2004 SIENNA VEHICLES IS A KNOWN PROBLEM WHICH THEY REFUSE TO ISSUE A RECALL FOR. THE SLIDING DOORS ARE POORLY DESIGNED AND DANGEROUS. I CURRENTLY DRIVE A NEWBORN AND A TODDLER AROUND IN MY SIENNA AND I DON'T TRUST THE DOORS THAT ARE SUPPOSED TO PROTECT THEM. PLEASE ENCOURAGE TOYOTA TO ISSUE A RECALL AND FIX THESE BROKEN SLIDING DOORS! *TR

A FEW MONTHS AGO A CABLE SNAPPED ON THE PASSENGER SIDE SLIDING SIDE DOORS. WITHOUT THE CABLE THE DOOR WILL NOT OPEN PROPERLY. RECENTLY, THE SAME CABLE SNAPPED ON THE DRIVER'S SIDE SLIDING SIDE DOOR. NOW THAT DOOR WILL NOT OPEN. I HAVE BEEN TOLD THAT AN ENTIRE NEW CABLE ASSEMBLY MUST BE PLACED IN EACH DOOR. WITHOUT THE SLIDING SIDE DOORS OPENING THE ONLY MEANS OF INGRESS AND EGRESS FROM THE VEHICLE IS THROUGH EITHER THE REAR HATCH OR THE FRONT DOORS. IT IS BOTH A SAFETY CONCERN AS WELL AS VERY INCONVENIENT TO NOT BE ABLE TO USE THOSE DOORS. THE SIDE SLIDING DOORS, BACK WHEN THEY STILL WORKED, WERE ALSO PRONE TO FREEZING SHUT WHENEVER IT GOT COLD OUTSIDE AND THE DOORS WOULD NOT OPEN UNLESS THEY THAWED. AGAIN, THIS MADE THE PASSENGER COMPARTMENT DIFFICULT TO ACCESS AND DANGEROUS IN CASE OF AN EMERGENCY. *TR

2004 TOYOTA SIENNA XLE DRIVER'S SIDE POWER DOOR CABLE (PART OF THE MOTOR AND CLUTCH ASSEMBLY) FRAYED AND SNAPPED. TOYOTA RECOMMENDS FULL REPLACEMENT OF MOTOR AND ASSEMBLY PART AT $1200 PLUS LABOR $660. (WIRE MATERIAL COST ESTIMATED AT $20 OR LESS.) ISSUE: DESIGN DEFECT LEADING TO MATERIAL STRESS/BREAKAGE. *TR

2004 TOYOTA SIENNA DRIVER DOOR PROBLEM. DOOR MAKES CRACKING AND POPPING WHEN BEING OPENED HAVE BEEN TOLD THAT IT IS A BROKEN WELD BUT THE DOOR HAS NEVER BEEN PUSHED TO FAR OR COMPROMISED IN ANY WAY THAT WOULD HAVE BROKEN WELD. TOYOTA BASICALLY WASHED THEIR HANDS OF ANY RESPONSIBILITY THOUGH FROM READING POSTS ON THIS SITE AND OTHERS IT IS A COMMON PROBLEM. *TR

MY 2004 TOYOTA SIENNA MINI VAN POWER SLIDING DOOR MADE A HORRIFIC 'SNAPPING' SOUND WHEN THE CABLE THAT ACTIVATES THE DOOR SNAPPED. THE SNAPPING CABLE DID NOT HURT ANYONE, BUT COULD HAVE IF SOMEONE WAS STANDING BEHIND THE DOOR NEAR THE REAR QUARTER PANEL WINDOW. THE DOOR IS NO LONGER FUNCTIONAL AND WILL COST $1500-$3000 TO REPAIR. *TR

THE POWER STRUTS ON THE REAR HATCH OF MY SIENNA WERE RECALLED AND REPLACED BECAUSE THEY WERE NOT HOLDING, AND WERE FALLING DOWN ON PEOPLE. MY HATCH RECENTLY FELL ON ME, EVEN WITH THE NEW PART. AT THE TIME OF THE INCIDENT, I WAS PUTTING THINGS IN MY TRUNK. THE HATCH SLAMMED DOWN, HITTING ME ON MY HEAD. THIS HAS CAUSED HEAD, NECK AND BACK INJURIES. I AM NOW IN MONTH 2 OF PHYSICAL THERAPY AND REHABILITATION. THE NEW STRUTS ARE NOT THAT OLD AND WILL HAVE TO BE REPLACED, AS THIS CONTINUES TO HAPPEN, ESPECIALLY WHEN IT IS COLD. A REPLACEMENT PART FOR A RECALL SHOULD FIX THE PROBLEM, NOT CONTINUE IT. *TR

WE HAVE A 2004 TOYOTA SIENNA CE. SINCE PURCHASING THIS VEHICLE, ANY TIME THE TEMPERATURE IS 32 DEGREES OR LOWER, THE SLIDING DOORS DO NOT OPEN. THIS IS A DANGEROUS SITUATION. I HAVE TO GET MY KIDS IN AND OUT OF THE CAR VIA THE BACK TAILGATE. IF THERE WERE AN EMERGENCY AND WE NEEDED TO EXTRICATE OUR CHILDREN OR PASSENGERS QUICKLY, WE WOULD NOT BE ABLE TO DO SO. *LN

POWER SLIDING DOOR FAILURE 2004 SIENNA THE POWER SLIDING DOOR ON MY 2004 SIENNA HAS FAILED 3 TIMES. THE FIRST 2 WERE COVERED UNDER WARRANTY, BUT THE 3RD TIME IS NOT. THIS IS A VERY COSTLY REPAIR AS THE WHOLE DOOR NEEDS TO BE TAKEN APART AND IS ESTIMATED @ $1,400. IT IS ALSO A SAFETY ISSUE AS CHILDREN CANNOT GET OUT BY THEMSELVES IF THEY NEED TO IN A CRASH. I HAVE CONTACTED TOYOTA CORPORATE TO NO AVAIL. MY CASE # [XXX]. NOTHING IN A VEHICLE SHOULD NEED TO BE REPAIRED THREE TIMES!! THERE ARE 1000S OF COMPLAINTS AND ONCE AGAIN TOYOTA WILL NOT DO SOMETHING UNTIL SOMEONE DIES IN A CRASH AS A RESULT OF THIS! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

THE DRIVER DOOR MAKES A LOAD CLICKING NOISE WHEN YOU OPEN OR CLOSE THE DOOR. THE DOOR DOES NOT OPEN OR CLOSE PROPERLY. I HAVE NOT REPAIRED IT YET BUT HAVE BEEN TOLD IT IS A SPOT WELD THAT HAS FAILED. I ALSO READ ONLINE THAT THIS IS A VERY COMMON PROBLEM ON THE 2004 SIENNA. *TR

2004 TOYOTA SIENNA VAN DRIVERS SIDE SLIDING DOOR REAR LATCH HAS BECOME DETATCHED AND THE DOOR WON'T CLOSE. NOT ONLY IS THIS A SAFETY HAZARD WHILE DRIVING BUT THE LOCKS WILL NOT ENGAGE WITH AN OPEN DOOR. *TR

POWER DOOR CABLE SNAPPED DURING OPERATION. *TR

TOYOTA SIENNA XLT 2004 POWER DOOR CABLE SNAPS DUE TO EXPOSURE TO WEATHER. CABLE THEN JAMS IN DOOR, CAUSING DOOR TO MALFUNCTION AS DAUGHTER WAS EXITING THE VAN. *TR

THE DRIVER DOOR MAKES A LOAD CLICKING NOISE WHEN YOU OPEN OR CLOSE THE DOOR. THE DOOR DOES NOT OPEN OR CLOSE PROPERLY. I HAVE NOT REPAIRED IT YET BUT HAVE BEEN TOLD IT IS A SPOT WELD THAT HAS FAILED. I ALSO READ ONLINE THAT THIS IS A VERY COMMON PROBLEM ON THE 2004 TOYOTA SIENNA. *TR

AUTOMATIC DOOR STOPPED WORKING. *TR

2004 TOYOTA SIENNA PASSENGER SIDE (POWER) DOOR REFUSES TO CLOSE; BROKEN DOOR CABLE. ALSO, THE DRIVER'S SIDE DOOR (MANUAL) HAS BEEN BROKEN FOR OVER 3 YRS; TOYOTA FIXED THIS 3 TIMES WHILE STILL UNDER WARRANTY BUT REFUSES TO FIX IT AGAIN DESPITE THE FACT THAT IT IS A DESIGN DEFECT SINCE IT KEEPS HAPPENING. *TR

2004 TOYOTA SIENNA XLE VAN DOOR CABLE/MOTOR BROKE. DOOR STUCK OPEN AND WERE NOT ABLE TO CLOSE MANUALLY. CAN'T DRIVE BECAUSE DOOR IS STUCK OPEN. ONLY WAY TO FIX IS CUT CABLE OR PAY $2000 TO TOYOTA TO FIX THE DOOR MOTOR. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT PASSENGER DOOR WOULD NOT OPEN FROM THE INSIDE OR OUTSIDE. THE AUTOMATIC DOOR LOCKS FAILED FIRST AND THE DOOR STOPPED WORKING ALTOGETHER. THE SLIDING DOOR ON THE PASSENGER SIDE ALSO WAS NON-FUNCTIONED.; IT WOULD OPEN MANUALLY ONLY FROM THE INSIDE. THE VEHICLE HAD NOT BEEN INSPECTED OR EPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 71,000.

CABLES ON BOTH REAR POWER SLIDING DOORS HAVE FRAYED AND SNAPPED. REPLACEMENT COST OF CABLE IS EXCESSIVE AT $2200 PER DOOR. *TR

DRIVER SIDE SLIDING DOOR CABLE FRAYED AND SNAPPED. *TR

SIENNA 2004 XLE POWER DOOR CABLE SNAPPED AND SLIDING DOOR WONT WORK. THOUGH CAR HAD BEEN SERVICED BY TOYOTA DEALER ALL THE TIME. *TR

2004 TOYOTA SIENNA'S AUTOMATIC SLIDING DOOR MECHANISM JAMMED PREVENTING DOOR CLOSURE. THE DOOR COULD NOT BE CLOSED AUTOMATICALLY OR MANUALLY. CIRCUMSTANCES FORCED PASSENGERS, INCLUDING 4 SMALL CHILDREN, TO TRAVEL SEVERAL HIGHWAY MILES WITH THAT DOOR OPEN. IN APRIL 2004 TOYOTA MODIFIED THAT DOOR MECHANISM FOR NEW PRODUCT AND ISSUED TECHNICAL SERVICE BULLETIN EL004-04 "POWER SLIDING DOOR INOPERATIVE" TO CORRECT EXISTING PRODUCT. SIENNA'S EARLY 2004 SLIDING DOOR IS A DEFECTIVE PRODUCT. THE SIENNA PRODUCT IS A MINIVAN MARKETED TO FAMILIES AND CHILDREN. AS SUCH IT IS DESIGNED TO BE A CLOSED VEHICLE. THE DEFECTIVE DOOR SHOULD BE CONSIDERED A CHILD RESTRAINT FAILURE BECAUSE CLOSED DOORS ARE, IN FACT, THE PRIMARY PROTECTIVE RESTRAINT IN A FAMILY VEHICLE. CORRECTIVE ACTION WE ELECTED IS TO CUT THE AUTOMATIC DOOR'S TRACTOR CABLE. THAT FREES THE DOOR TO CLOSE AND PERMANENTLY DISENGAGES THE DEFECTIVE DOOR MECHANISM. *TR

2004 TOYOTA SIENNA. POWER SLIDING DOOR CABLE SNAPS. LEAVING DOOR UNABLE TO OPEN FULLY. TOYOTA DEALER SAYS PART IS $1200 DOLLARS AND 4.3 HOURS LABOR TO INSTALL. $1800 TO FIX. *TR

2004 TOYOTA SIENNA MINIVAN. TOYOTA HAS RECOGNIZED THAT THERE WAS A SAFETY ISSUE WITH THE DRIVER'S DOOR MECHANISM IN 2007 AND AN EXTENDED WARRANTY WAS ISSUED TO REPAIR THE PROBLEM AND IT INCLUDED MY VEHICLE MODEL SPECIFICALLY. I HOWEVER, DID NOT GET ANY MAIL REGARDING THE ISSUE. THE ONLY TIME I WAS MADE AWARE OF IT IS WHEN I MENTIONED IT TO MY PERSONAL MECHANIC AND HE IS THE ONE THAT PRINTED THE LETTER FOR ME ON MAY 07, 2010 FROM AN INTERNET SITE. I TOOK MY CAR IN FOR REPAIR OF THE PROBLEM TODAY ON AUGUST 25, 2010 AND THE TOYOTA DEALERSHIP CHARLES MAUND TOYOTA IN AUSTIN TEXAS FAILED TO HONOR AND REPAIR THE PROBLEM ON TODAY'S DATE STATING BECAUSE OF SOME TECHNICALITY THEY WILL NOT HONOR THE REPAIR IT AT NO COST TO ME ANYMORE, AND DO NOT CONSIDER IT A SAFETY ISSUE ANYMORE. THE DOOR STILL HAS...

WE OWN A 2004 TOYOTA SIENNA XLE AND HAVE OWNED IT FOR 5 YEARS. LAST YEAR, OUR AUTOMATIC SLIDING DOOR (PASSENGER SIDE) CABLE SNAPPED, MAKING THE DOOR UNABLE TO OPEN AUTOMATICALLY. WE HAD BEEN USING IT JUST AS A MANUAL DOOR, AND HAVE RECENTLY BEEN HAVING PROBLEMS WITH BOTH SLIDING DOORS UNABLE TO OPEN AT ALL, EVEN MANUALLY. IT SEEMS TO HAVE SOMETHING TO DO WITH THE LOCKING MECHANISM. IT IS AS IF THE DOORS ARE STILL LOCKED EVEN THOUGH THEY ARE NOT. THIS IS A DANGEROUS PROBLEM, AND AFTER SOME RESEARCH I HAVE FOUND THAT THIS IS NOT AN ISOLATED INCIDENT, BUT RATHER THAT THIS IS AN INHERENT PROBLEM WITH THIS PARTICULAR VEHICLE. WITH SO MANY OWNERS HAVING THESE SAME PROBLEMS, I THINK TOYOTA SHOULD ISSUE A RECALL INSTEAD OF MAKING MONEY ON HAVING THEM HAVE TO FIX IT THEMSELVES. THEY ARE VERY COSTLY REPAIRS. *TR

THE DRIVER'S SIDE SLIDING DOOR ON MY 2004 TOYOTA SIENNA BEGAN TO GET STUCK WHEN IN THE AUTOMATIC POSITION OVER A TWO MONTH PERIOD. THEN WE HAD AN INCIDENT WHERE THE DOOR WOULD NOT CLOSE. WE HAVE TAKEN THE MINIVAN TO A TOYOTA DEALER AND THEY HAVE SAID THE WHOLE MOTOR HAS TO BE REPLACED, WHICH IS $1700 INCLUDING LABOR. I AM NOW AWARE THAT THIS IS A COMMON PROBLEM FOR THAT YEAR'S MODEL, WHICH WOULD IMPLY THAT IT IS NOT JUST NORMAL WEAR AND TEAR, BUT A DEFECTIVE PART OR A DEFECTIVE DESIGN. GIVEN THE COST OF THE REPAIR WE HAVE DECIDED NOT TO HAVE THE PROBLEM FIXED, BUT WILL RATHER USE THE MINIVAN WITH ONLY ONE OPERATIONAL DOOR. *TR

2004 SIENNA, THE RIGHT SIDE SLIDING DOOR CABLE COATING IS BRAKING DOWN. THE DOOR IS NOT CLOSING PROPERLY AND IS HARD TO MOVE IN EITHER DIRECTION MANUALLY. STILL INVESTIGATING ISSUE TO SEE IF REPAIRS ARE POSSIBLE OR IF NEW ASSEMBLY WILL BE REQUIRED. CONCERNED ABOUT SAFETY OF DOOR OPERATION AS MANY OTHERS. WE HAVE STOPPED USING THAT DOOR AT THIS TIME. *TR

PURCHASED TOYOTA SIENNA LE 2004 (NEW) IN MAY 2004. ALSO PURCHASED THE EXTENDED WARRANTY "BUMPER TO BUMPER" 60 MONTHS/100,000 MILES COVERAGE PLAN - HIGHLY RECOMMENDED BY THE DEALERSHIP. JAN.2008 (APPROX.82,000 MILES) THE LEFT, MANUAL PASSENGER DOOR WOULD NOT OPEN. DEALERSHIP GAVE REPAIR ESTIMATE $1231 FOR NEW LATCHES, ETC. TOLD "NOT COVERED UNDER WARRANTY." DEALERSHIP WOULD NOT REPAIR DUE TO "EXCESSIVE MILEAGE." NOW, THE RIGHT PASSENGER DOOR WILL NOT OPEN. WE HAVE TO ENTER/EXIT OUT OF BACK HATCH OR THROUGH FRONT DOORS. THIS DEFECT IS COMPLAINED ABOUT ALL OVER THE INTERNET. TOYOTA MUST DO SOMETHING!!! THESE ARE NOT ISOLATED INCIDENTS!! THERE IS A CONTINUING PATTERN OF THOUSANDS OF SIENNA OWNERS WITH THE SAME DEFECTS. TOYOTA MUST BE MADE TO COMPENSATE/REPAIR THESE DEFECTS!! THEY ARE SHOWING BILLIONS IN QUARTERLY PROFITS...THEN LET THEM FIX THIS! WHAT IF THERE IS AN ACCIDENT OR FIRE, ETC. AND THIS DEFECT PREVENTS A SAFE EVACUATION FROM THESE...

AT 66,000 MILES, MY 2004 TOYOTA SIENNA DRIVER SIDE FRONT DOOR BEGAN MAKING A POPPING SOUND. IT IS BROADLY KNOWN BY TOYOTA THAT THIS IS A DEFECT IN CONSTRUCTION AND WHILE THERE IS NOT A RECALL, THEY HAVE EXTENDED THE WARRANTY FOR THIS PROBLEM TO 6 YEARS OR 1000,000 MILES. THIS PROBLEM MANIFESTED ITSELF ONE WEEK AFTER THE CAR'S 6 YEAR PURCHASE DATE. TOYOTA CORPORATION REFUSED TO REPLACE THE DOOR. I WENT TO SEVERAL DEALERSHIPS AND FOUND ONE THAT SAID THAT TOYOTA AGREED THAT THE DOOR WOULD BE REPLACED ( WITH A NEWLY DESIGNED DOOR ) AND I WOULD HAVE TO PAY HALF OF THE PRICE: $1,700.00 . ISUBSEQUENTLY CANVASSED BODY SHOPS AND MECHANICS IN THE LOCATION OF THE DEALER IN QUESTION AND FOUND OUT THAT THEY KNEW OF MANY VEHICLES WITH THE SAME PROBLEM AND THAT THEY KNEW THAT DEALERSHIPS IN THE AREA WERE FIXING THE PROBLEM WITHOUT CHARGE...

REGARDING A 2004 TOYOTA SIENNA XLE. SLIDING DOOR ON DRIVER SIDE DOOR WILL NOT OPEN PROPERLY. SLIDING DOOR CABLE SNAPPED UNDER NORMAL USAGE -- OPENED THE DOOR UP THIS MORNING AND IT SNAPPED. TOYOTA HAS TSB EL004-004 FOR THE ISSUE, BUT NO RECALL. THE TSB IS VALID FOR 3 YRS/36K MILES. MY VEHICLE HAS OVER 100K MILES. CALLED TOYOTA CUSTOMER SUPPORT AND RECORDED A COMPLAINT. TOYOTA WILL NOT OFFER AN FINANCIAL ASSISTANCE FOR THIS REPAIR WHICH WILL COST $1500-2000. *TR

I HAVE A 2004 TOYOTA SIENNA (LE), BOTH MY SLIDING DOORS WILL NOT OPEN FROM INSIDE OR OUTSIDE, I CONTACTED THE DEALER AND THEY SAID THEY COULD FIX THE PROBLEM FOR APPROXIMATELY $2200. THIS IS A SERIOUS SAFETY CONCERN OF MINE AND I NEED TO KNOW IF THEIR IS ANY TYPE OF RECALL ON THE ON THE SLIDING DOORS, OR WHAT COURSE OF ACTION CAN I TAKE BESIDES PAYING THE DEALER $2200 TO CORRECT THIS PROBLEM. I'VE READ ONLINE NUMEROUS COMPLAINTS ON THIS SIMILAR SITUATION WITH THESE SLIDING DOORS, AND THE DEALERS ARE TELLING ITS CUSTOMERS THE SAME THING AS THEY TOLD ME. AGAIN, I PERSONALLY FEEL THIS IS A SERIOUS SAFETY CONCERN FOR A LIFE WHEN YOU CANNOT OPEN THESE DOORS TO SAFETY. *TR

2004 SIENNA LE PASSENGER SIDE POWER SLIDING DOOR. CABLE WHICH PULLS DOOR OPEN HAS SNAP. DOOR IS NO LONGER OPERABLE. IT CANNOT BE OPENED EITHER ELECTRONICALLY OR MANUALLY. POSES HAZARD AS OCCUPANTS CANNOT EXIT OUT ONTO CURBSIDE. *TR

2004 TOYOTA SIENNA AUTOMATIC SLIDING DOOR CABLE BROKE AND DOOR CAN NOT OPEN ANYMORE. *TR