2004 TOYOTA SIENNA Structurebody Problems

Passenger right slider Will not open! Only opens About 8 inches. This is a safety hazzard for a passenger back seat r/h! This is well known condition! Could be deadly, in the right Surcomstance

PART # 69300-08011 REAR LEFT DOOR LATCH WITH POWER SLIDING DOOR MALFUNCTION CAUSING A SAFETY PROBLEM DOOR REMAINED OPENING AND CLOSING COULD CAUSE PASSENGER OR ITEMS TRANSPORTING TO FALL OUT OF VEHICLE .IT ALSO CAUSED BATTERY TO DRAIN VEHICLE WOULDN'T START WITHOUT BEING JUMPED EVEN REPLACED BATTERY WITH A NEW BATTERY SAME THING HAPPENED . THIS PART HAS BECOME A PROBLEM IN MANY OF THESE 2004 TOYOTA SIENNA MINI VANS . A SAFETY RECALL NEED TO BE CONCIDERED .

ONE OF THE TWO SUPPORT CYLINDERS FOR THE REAR HATCH ON OUR 2004 TOYOTA SIENNA FAILED IN FALL 2019, SO THE REAR HATCH WOULD NOT STAY UP. THE LIFTGATE SUPPORT CYLINDERS HAD PREVIOUSLY BEEN REPLACED BY TOYOTA UNDER RECALL. WE PURCHASED TWO NEW SUPPORT CYLINDERS, TOYOTA PART #68905-AE022'SUPPORT CYLINDER' FROM CAMELBACK TOYOTA IN PHOENIX, AZ, D/B/A TOYOTA PARTS FACTORY, BY MAIL, SHIPPED 11/19/19. I INSTALLED BOTH OF THE NEW SUPPORT CYLINDERS WITHIN A COUPLE OF WEEKS. NOTE THAT BOTH OF THE OLD SUPPORT CYLINDERS WERE REPLACED WITH NEW TOYOTA PARTS, NOT JUST THE ONE WHICH HAD FAILED. HOWEVER, WITH THE NEW SUPPORT CYLINDERS, WHEN THE WEATHER GETS COOL (BELOW 50 F) AND THE LIFTGATE IS OPENED USING THE ELECTRIC OPENER, THE LIFTGATE GETS PART WAY UP AND REVERSES, COMING DOWN UNEXPECTEDLY. THIS REPRESENTS A SAFETY HAZARD, AS THE DOOR CAN HIT SOMEONE STANDING BELOW IT. THIS IS EXACTLY THE BEHAVIOR...

SLIDING DOORS DON'T PROPERLY LATCHED LIKE THEY ARE SUPPOSE TO WHEN ATTEMPTING TO CLOSE DOOR CAUSING A SAFETY ISSUE FOR PASSENGERS . IT HAPPENS WHEN VEHICLE IS PARKED OR MOTION ON ROAD WAY OR IN PARKING SPACE .

BOTH POWER SLIDING DOORS FREEZE SHUT ANY TIME THERE ARE FREEZING TEMPERATURES AND ANY MOISTURE, AND CANNOT BE OPENED EITHER WITH POWER OR MANUALLY. ATTEMPTING TO OPEN A DOOR WILL ONLY OPEN IT 1/4", SUFFICIENT TO ACTIVATE THE DOME LAMPS, BUT THEN WILL NOT CLOSE. AFTER DRIVING AND WARMING UP, THE DOOR MAY RANDOMLY OPEN AT ANY TIME, PRESENTING A SAFETY HAZARD.

TL* THE CONTACT'S MOTHER OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE OF THE DASHBOARD HAD A DEEP CRACK. THE CONTACT WAS UNAWARE IF A WARNING INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO VICTORY TOYOTA (LOCATED AT 5 HEITZINGER PLAZA, SEASIDE, CA 93955, (831) 393-3020) WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 234,000.

TOOK MY TOYOTA SIENNA 2004 IN FOE EXHAUST WORK AND THE TECHNICIAN ALERTED ME THAT THE CAR HAD EXCESSIVE CORROSION. THE SUSPENSION/ENGINE CRADLE WAS RUSTED OUT AND HAD HOLES. ADVISED THE CAR WAS UNSAFE TO DRIVE. VERY UPSETTING AS EVERYTHING ELSE IS GREAT WITH THE VEHICLE AND PLANNED ON DRIVING IT FOR MANY MORE MILES. THIS IS A VERY DANGEROUS CONDITION WHICH COULD HAVE RESULTED IN INJURY OR EVEN DEATH TO MY FAMILY OR OTHERS. I HAVE BEEN DRIVING AROUND WITH MY FAMILY IN THIS VEHICLE THINKING IT WAS SAFE!

DOOR STOP ON DRIVER SIDE BROKE AFTER MAKING LOUD POPPING NOISE. TOYOTA DEALER IN MONTCLAIR CA WAS NO HELP. VAN HAS ONLY 64K MILES AND WE ARE THE ONLY OWNERS. I ALWAYS THOUGHT OF TOYOTA AS DEPENDABLE. THIS IS A SAFETY ITEM AND THEY WONT STAND BEHIND IT.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE FAILED AN INSPECTION DUE TO EXTENSIVE RUST, CORROSION, AND HOLES ASSOCIATED WITH THE FRAME (ENGINE CRADLE). AN INDEPENDENT MECHANIC DIAGNOSED THAT THE FRAME, ENGINE CRADLE, AND SUSPENSION ARMS MAY NEED TO BE REPLACED, OTHERWISE THE VEHICLE WAS UNSAFE TO BE DRIVEN AND THE PARTS MAY FRACTURE AT ANY MOMENT. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

MY VAN WAS IN A PARKING LOT. IT WAS A CLEAR HUMID 95 DEGREE DAY. HADN'T RAINED IN DAYS. THE VAN HADN'T BEEN WASHED RECENTLY. I OPENED THE REAR LIFTGATE MANUALLY, GOT IN THE VAN BUT IT WOULDN'T CLOSE WITH THE INTERIOR BUTTON IN SEVERAL ATTEMPTS. IT TOOK 4 ATTEMPTS TO CLOSE IT MANUALLY. THIS IS THE SECOND TIME THIS HAPPENED. I DIDN'T MAKE NOTE OF THE NUMBER OF BEEPS EMITTED. THE FIRST TIME IT HAPPENED, I DIDN'T TAKE NOTE OF THE WEATHER CONDITIONS, BUT THE LIFTGATE WOULD ONLY CLOSE AFTER REPEATED MANUAL ATTEMPTS.

TOYOTA SIENNA FRACTURED DEFECTIVE LEFT FRONT DOOR CHECK POCKET POPPING NOISE. IT'S A BROKEN WELD, THE WHOLE DOOR HAS TO BE REPLACED AT THE COST OF CLOSE TO $2000. OBVIOUSLY IT'S A MANUFACTURING DEFECT.

LLEVE EL TOYOTA POR UN RECALL REPARAR CINTURONES EN 2016 EN ESA MISMA OCACION,REPORTE QUE EL DASHBOARD PRESENTABA GRIETAS PEQUEAS DIJERON TOYOTA NO SE HACA RESPONSABLE POR ESE DAO Y LISTO NO TUVE MS QUE RESIGNARME SABIENDO ERA ERROR DE FABRICA EL CAR CASI NO SE USA EL MES 05/2017 TOC PAGAR LA REGISTRACION Y PIDEN ANOTAR EL MILLAJE TOM UNA FOTO DE NOCHE CON FLASH Y A VER FOTO SE NOT UNAS GIETAS FUE CUANDO PROCED A IR INSPECCIONAR BIEN EL DASHBOARD ME PERCAT SE HABAN FORMADO GRIETAS MS GRANDES Y EN LUGARES MUY DIFCILES DE VER FUI A TOYOTA EN COTTMAN AV PHILADELPHIA.PA Y PED HABLAR CON UN REPRESENTANTE Y EXPLIQU TODO Y QUE HABIA REPORTADO ESTE DAO DESDE 2016 Y ME DENEGARON LA AYUDA ME DIJO NO PODA HACER NADA,PORQUE YA SE HABIA PASADO EL TIEMPO QUE TOYOTA DIO PARA REPARAR DIJE PORQU NUNCA ME AVISARON O...

THE DRIVERS SIDE DOOR CHECK ASSEMBLY HAS BROKE. THE METAL IN THE ARM HAS TORN APART AND THE MOUNT TO THE DOOR HAS TORN OFF THE FRAME OF THE DOOR. AFTER RESEARCHING ON THE INTERNET HOW TO FIX IT I HAVE SEEN MULTIPLE PEOPLE WITH THE SAME ISSUE. IT SEEMS THAT THE MOUNTING TO THE DOOR IS WEAK AND HAS A TENDENCY TO FALL APART AND BREAK. NOT HAVING A DOOR CHECK IS DANGEROUS. THIS IS MY WORK VEHICLE AND HAVING THE DOOR SWING OPEN ALL THE WAY ISN'T GOOD. IT CAN DAMAGES OTHER PEOPLES CARS AND IT HAS ME ALWAYS BEING FEARFUL OF IT SWINGING OPEN ALL THE WAY.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE DASHBOARD STARTED CRACKING IN THE CENTER APPROXIMATELY FIVE YEARS AGO. CURRENTLY, OTHER CRACKS DEVELOPED ALL OVER THE DASHBOARD, INCLUDING THE EDGE OF THE PASSENGER SIDE AIR BAG COMPARTMENT. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT THE EXTENSION OF THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE SLIDING DOORS AND LIFTGATE BECAME INOPERABLE. THE FAILURE OCCURRED RANDOMLY AND THE DOORS LOCKED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO LOCAL DEALER (TOYOTA OF COLCHESTER) WHERE IT WAS DIAGNOSED THAT THE CABLE AND DOOR MOTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE EXCEEDED THE MILEAGE ALLOWED TO REMEDY THE VEHICLE PER AN IN-HOUSE RECALL. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 230,000.

METAL AROUND SCREWS HOLDING DOOR LATCH BROKE MAKING IT IMPOSSIBLE TO CLOSE DOOR.

DOOR HINGES ARE FALLING OFF OF VEHICLE. BOTH MY DRIVER SIDE AND PASSENGER SIDE FRONT DOORS AND NOW MY DRIVERS SIDE SLIDER DOOR HINGES HAVE FALLEN OFF. THE DOOR HINGES ARE LITERALLY FALLEN OFF OF THE VEHICLE! MY LAST VISIT TO DEALER 4/2017 WAS FOR YET ANOTHER SLIDER DOOR MOTOR REPAIR (2X ONE SIDE/ 3X THE OTHER AT $1200 EACH). BUT, THIS TIME WAS DIFFERENT THEY TOLD ME I WAS LUCKY THE SLIDER DOOR DID NOT FALL OFF DRIVING DOWN THE ROAD BECAUSE THE HINGE WAS COMPLETELY BROKEN OFF!! THIS IS NOW THE 3RD BROKEN HINGE ALL ON DIFFERENT DOORS. I CALLED TOYOTA AND THEY SAID THEY HAVE MET THEIR OBLIGATION ON A 14 YEAR OLD VEHICLE. NAME ONE OTHER MAKE/MODEL/YEAR OF ANY MANUFACTURES VEHICLE THAT THE DOOR HINGES FALL OFF. THEY KNOW, AND HAVE KNOWN FOR A LONG TIME, THERE IS A PROBLEM WITH DOOR HINGES ON SIENNA 04-06...

RIGHT SIDE SLIDING DOOR OPERATES SPORADICALLY, NOT OPENING ALL THE WAY TO LOCK IN PLACE.

RIGHT PASSENGER SLIDING DOOR WILL NOT SHUT MECHANISM INSIDE APPEARS TO HAVE BROKEN. OCCURRENCE HAPPENED GETTING OUT OF VEHICLE

IN GROCERY STORE PARKING LOT ,PUT GROCERIES IN DRIVER SIDE BACK POWER SLIDING DOOR . WENT TO SHUT AND DOOR WOULD NOT SHUT ALL THE WAY . IT WAS STUCK .FINELY GOT IT SHUT AFTER ,ABOUT 30 MINUTES .GOT HOME POWER CABLE HAD BROKEN RUSTED AND FRAYED .RECALL WAS FOUND ,BUT TOYOTA WILL NOT FIX !!! THIS HAPPEN 2YRS. AGO 2014 & STILL TRYING TO GET THIS RECALL FIXED ..THEY SAID I HAD TO MANY MILES ON THE VAN ,THAT I GOT IN 2011.. IT HAD 146,892 MILES WHEN THE DOOR CABLE BROKE & WAS INSPECTED . THIS IS VERY DANGEROUS .I WILL NOT LET ANY CHILDREN SIT NEXT TO THAT BROKEN POWERED BACK DRIVER SLIDING DOOR !! THIS SHOULD BE A MANDATORY RECALL !! MILES SHOULD NOT BE A CONCERN ! LIFE OF A PERSON SHOULD BE . I'M STILL FIGHTING TO GET THIS FIXED & IT'S 2016 .....

MY REAR HATCH WONT OPEN WITH BUTTON UP FRONT OR REMOTE

I AM ALSO AN UNFORTUNATE OWNER OF A 2004 TOYOTA SIENNA WITH A FAILED FRONT DOOR CHECK. ISN'T AN ORGANIZATION LIKE NHTSA SUPPOSED TO MAKE A MANUFACTURER WITH SUCH AN OBVIOUS, EXTENSIVE AND COMMON ISSUE LIKE THIS PROVIDE A SUITABLE REPAIR?? AN EXTENSION TO THE WARRANTY IS NOT....NOT AN ANSWER. THIS IS JUST A PISS POOR DESIGN AND THE PIECE OF FIRE HOSE I SCREWED TO THE DOOR AND THE BODY IS A BETTER DESIGN THAN THE PIECE OF JUNK THE FACTORY PUT OUT. THIS IS UNBELIEVABLE AND UNACCEPATABLE.

DRIVER DOOR ARM/HINGE HAS PUSHED THROUGH AND TORE THE METAL IN THE DOOR FRAME FROM WHAT APPEARS TO BE A BAD WELD ACCORDING TO ONLINE RESOURCES OF PEOPLE REPORTING SIMILAR PROBLEMS. WE BOUGHT THE VEHICLE USED AND HAD NO INFORMATION THAT MAY HAVE BEEN SENT TO PREVIOUS OWNERS PRIOR TO MARCH 2012. DOOR WAS MAKING A POPPING NOISE WHEN YOU WOULD OPEN OR SHUT IT. ONE DAY I COULDN'T ROLL DOWN MY WINDOW ALL OF THE WAY WHEN THE DOOR WAS CLOSED. WHEN THE DOOR WAS OPEN THE WINDOW WOULD ROLL DOWN NORMALLY. WE LOOKED INSIDE OF THE DOOR TO SEE WHAT WAS CAUSING IT AND NOTICED THE ARM WAS INSIDE OF THE DOOR WITH TORN METAL ATTACHED TO IT. LOOKS LIKE THE ARM WAS DEFECTED AND EVENTUALLY PUSHED THROUGH THE DOOR FRAME RIPPING THE METAL. DATE OF MARCH 2016 IS WHEN THE WINDOW STOPPED ROLLING DOWN ALL OF THE...

PASSENGER DOOR DOES NOT WORK. WE PURCHASED VEHICLE USED AND THEY SAID THEY HAD THE DOOR DISCONNECTED FROM THE ELECTRICAL BUTTONS SO IT IS MANUAL ONLY. I SEE RESOURCES ONLINE THAT SAY THERE IS A CABLE THAT FRAYS MAKING THE DOOR UNABLE TO OPEN OR CLOSE. MARCH 2012 IS WHEN WE PURCHASED VEHICLE FROM PREVIOUS OWNER. DOOR WAS NOT WORKING AT THAT TIME.

PASSENGER SIDE POWER SLIDING DOOR STUCK HALF-WAY DUE TO FRAYED POWER CABLE. DOOR CANNOT FULLY OPEN NOR FULLY CLOSE.

DOOR HAS A BROKEN WELD, THE WHOLE DOOR SWINGS OPEN AS THE WELD IS THE STOPPING DEVICE. THIS IS A MANUFACTURE DEFECT AND I AM NOT ABLE TO GET HELP FROM TOYOTA ON THIS AS IT HAS BEEN BROKE FOR OVER 4 YEARS.

THE DRIVER'S SIDE SLIDING DOOR NO LONGER OPENS/CLOSES WHEN THE BUTTONS ARE PUSHED (FROM THE CEILING IN THE FRONT, FROM A REMOTE KEY, AND FROM THE BUTTON RIGHT NEXT TO THE DOOR.)

THERE IS A POPPING NOISE FROM THE PASSENGER DOOR. APPARENTLY IT WAS A SAME PROBLEM WITH THE DRIVER SIDE DOOR THAT TOYOTA HAD REPAIRED. IT WAS THE WELDING OF THE SUPPORT TO THE DOOR THAT BECOME LOOSE. SIMPLY PUT IT, THEY HAVE PROBLEM WITH THE WELDING OF THE DOORS. THEY HAVE REPAIR ONCE ON THE DRIVER SIDE AND THE PASSENGER SIDE IS HAPPENING AGAIN. I AM AFRAID THE DOOR WILL COME OFF. I HAVE TOLD THEIR SERVICE DEPARTMENT BUT THEY REFUSE TO REPAIR IT.

AUTOMATIC PASSENGER SLIDING DOOR NOT WORKING. THE CABLE BECAME FRAIL AND IT IS NOT OPENING AND I HAVE TO CUT THE CABLE OFF TO OPEN THE DOOR.

THE RIGHT PASSENGER SLIDING DOOR CABLE HAS FRAYED TO THE POINT THAT THE DOOR WILL NOT OPEN OR CLOSE.

TAKATA RECALL I HAVE A TOYOTA SIENNA 2004. LAST YEAR, THE SLIDING DOOR CABLE WAS BROKEN AND IT WAS JUST PAST THE WARRANTY. I HAD TO PAY $1,200 TO HAVE IT FIXED AS THE DOOR COULD BE OPEN. AND THEN AFTER A FEW MONTH, THE DOOR CAN'T OPEN AUTOMATICALLY AND THE DEALER SAID A MOTOR FAILURE WHICH WOULD COST ANOTHER $1,000. I HEARD A LOT OF COMPLAINTS ABOUT TOYOTA SIENNA SLIDING DOOR AND UNFORTUNATE I AM ONE OF THE VICTIMS. I URGE TOYOTA TO TAKE THE RESPONSIBILITY AND PAY CUSTOMERS BACK.

PASSENGER POWER SLIDING DOOR WON'T OPEN OR CLOSE. DOOR ACTUATOR NOT WORKING

SLIDING DOORS TYPICALLY FREEZE SHUT IN WINTER, EVEN WHEN WATER IS NOT PRESENT (I.E. GARAGED). RENDERS INGRESS AND EGRESS IMPOSSIBLY THROUGH THESE DOORS. ALSO, MOTORS AND DOOR BEARINGS WEAR TO THE POINT OF POWER DOORS BECOMING INOPERABLE OR PLACE THEM IN CONTACT WITH THE BODY OF HE VEHICLE. MULTIPLE OWNERS REPORT THESE AND RELATED/SIMILAR ISSUES.

FRONT DRIVER SIDE DOOR STARTED MAKING POPPING NOISE WHEN OPENING AND CLOSING. THE CAR HAS ONLY 105,000 MILES AT TIME OF START OF PROBLEM.I HAVE READ THAT THERE ARE NUMEROUS SIENNA OWNERS OF VARYING MODEL YEARS WHO HAVE THE SAME PROBLEM. CAUSED BY A FAILING DOOR CHECK. IT IS AN ANNOYINGLY LOUD SOUND AND AS THE VEHICLE OWNER I AM CONCERNED ABOUT THE INHERENT DANGERS FROM FURTHER DETERIORATION. WHAT IF I AM UNABLE TO OPEN THE DOOR IN AN EMERGENCY? CAN THE DOOR FALL OFF? WHAT ABOUT POTENTIAL INJURY TO BYSTANDERS? WHAT WILL IT TAKE FOR TOYOTA TO DO A FULL RECALL? INJURIES, DEATHS AND LAWSUITS? THIS PROBLEM IS NOT DUE TO CARELESS USE OF THE VEHICLE. THIS IS DUE TO SHODDY WORKMANSHIP BY THE MANUFACTURER - TOYOTA. THEIR ABILITY TO MANUFACTURE RELIABLE PRODUCTS IS BECOMING INCREASINGLY SUSPECT. THEY DON'T SEEM TO BE WILLING TO TAKE FULL RESPONSIBILITY FOR THIS...

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER SIDE SLIDING DOOR CABLE FRACTURED AND CAUSED THE DOOR NOT TO OPEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CABLE CONNECTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE 162,000.

THE FRONT DOOR CHECK HAS COME LOOSE AND "POPS" WHEN OPENING/CLOSING. THIS RESULTS IN THE DOOR SWINGING SHUT WITHOUT WARNING AND COULD EASILY CAUSE PHYSICAL HARM TO AN ADULT AND SEVERE HARM TO A SMALLER CHILD. TOYOTA ISSUED A SEVERELY LIMITED "TECHNICAL SERVICE BULLETIN" THAT ONLY EXTENDED COVERAGE FOR THIS DEFECT TO 5 YEARS/100,000 (WHICHEVER CAME FIRST). HOWEVER, THE AVERAGE PERSON DOES NOT DRIVE 20,000 MILES PER YEAR SO THE PROBLEM IS NOW SHOWING UP EN MASSE AND TOYOTA IS REFUSING TO FIX THE KNOWN ISSUE. MY 2004 SIENNA STARTED SHOWING SIGNS OF THIS DEFECT BEFORE IT REACHED 100,000 MILES RECENTLY BUT BECAUSE IT WAS BEYOND 5 YEARS THEY HAVE REFUSED TO ADDRESS THIS SAFETY/PERFORMANCE ISSUE THAT HAS BEEN PREVIOUSLY ACKNOWLEDGED BY TOYOTA TO AFFECT AS MANY AS 600,000 VEHICLES. UNLIKE NUMEROUS OTHER TECHNICAL AND SAFETY ISSUES TOYOTA HAS RECALLED ON THIS SAME RANGE OF SIENNAS THIS DEFECT WAS PURPOSEFULLY...

THERE WAS A RECALL ON THE BACK HATCH DOOR. I REPORTED TO THE DEALERSHIP OF PURCHASE AND COMPLAINED THAT THE BACK DOOR HATCH SOMETIMES DID NOT CLOSE PROPERLY AND IN THE MIDST OR OPENING WHETHER ELECTRONICALLY OR MANUALLY WOULD COME DOWN AGAIN WHILE PUTTING GROCERIES ETC IN THE BACK AND SEVERAL TIMES WAS HIT ON THE HEAD OR BACK AND ALSO MY GRANDSON. VEHICLE WAS PARKED IN A PARKING LOT AND/OR AT MY HOUSE. IT HAPPENS 1 OUT OF 10-20 TIMES OPENING BACK HATCH.

BOTH PASSENGERS DOOR QUIT SHUTTING OR OPENING FROM INSIDE OR OUTSIDE. SINCE THEY ARE ELECTRONICALLY OPENED AND CLOSED THEY WOULD NOT OPEN MANUALLY. ONE DOOR OPENS JUST ABOUT 5 INCHES AND AUTOMATICALLY SHUTS AGAIN. THIS DOOR HAS NOT OPENED IN ABOUT 6 MONTHS. THIS IS THE DOOR ON DRIVERS SIDE BUT SECOND SEATS WITH SLIDING DOOR. PASSENGER SIDE DOOR SECOND SEAT OPENS AND CLOSES INTERMITTENTLY, SOMETIMES IT OPENS SOMETIMES NOT. IT HAS ALMOST SHUT MY PETS TRYING TO GO OUT THE DOOR AND AUTOMATICALLY WILL SHUT BACK. IT STARTED DOING THIS AROUND THE SAME TIME THE OTHER DOOR STOPPED OPENING AND SHUTTING. I MENTIONED THIS TO THE DEALERSHIP BUT THEY BRUSHED ME OFF. THE FRONT DRIVERS DOOR STARTED MAKING A NOISE WHEN OPENING AND WOULD CLOSE BY ITSELF WHEN JUST PARKED AND MADE A POPPING NOISE WHEN OPENED. ALSO TOLD THIS TO DEALERSHIP WITH SAME RESULTS. VEHICLE PARKED WHEN ALL...

REAR BACK DOOR FLEW OPEN AND UNABLE TO LATCH WHILE DRIVING ON PARKWAY.

I WAS DRIVING FROM A MAJOR CITY HIGHWAY ONTO A FREEWAY. I WAS GOING 50MPH AND ACCELERATING TO THE APPROPRIATE FREEWAY SPEED OF 60MPH. AT THAT TIME, I REALIZED MY REAR WING WINDOWS WERE OPEN (IT OPENS AT THE REAR OF THE CAR AT AN ANGLE OF ABOUT 1 INCH) AND I PRESSED THE AUTOMATIC CLOSURE BUTTON. I HEARD A LOUD 'POP' ON THE PASSENGER SIDE. I LOOKED BACK AND THE WINDOW WAS GONE. I PULLED OVER TO THE SIDE OF THE HIGHWAY IMMEDIATELY. A CAR/JEEP WITH A FAMILY IN IT PULLED UP BEHIND ME. THEY WERE HIT BY THE WINDOW COMING OFF OF MY VEHICLE. THANK GOD NO ONE WAS HURT, BUT IT DID CAUSE DAMAGE TO THEIR VEHICLE. IT SHOOK BOTH THEM AND MYSELF UP. A WINDOW FLYING FROM A CAR ON A HIGHWAY COULD HAVE SERIOUSLY CAUSED DAMAGE AND INJURIES. WE WERE VERY LUCKY. I CALLED 911...

REAR PASSENGER ELECTRIC SLIDING DOOR DOES NOT OPEN OR CLOSE AND FAILED ONE DAY. THE DOOR LATCH ASSEMBLY IS ELECTRICALLY OPERATED AND THERE IS NO MANUAL OVERRIDE. THE DOOR CAN ONLY BE OPERATED ELECTRICALLY AND CANNOT BE OPENED MANUALLY AT ALL WITH OUT MAKING A $1500 - $3500 REPAIR TO REPLACE THE FAULTY ELECTRICAL SYSTEM (DOOR LATCH ASSEMBLY AND DOOR MOTOR) OF THE VEHICLE. THIS IS A POTENTIALLY LIFE THREATENING SITUATION FOR SMALL CHILDREN SINCE IF THERE IS AN ACCIDENT HOW ARE YOU GOING TO GET THE CHILDREN OUT OF THE VEHICLE SINCE THE DOOR CANNOT BE OPERATED MANUALLY? THIS ISSUE NEEDS TO BE INVESTIGATED AND A TOTAL RECALL OF ALL ELECTRICAL DOOR ASSEMBLIES NEED TO BE MADE FOR ALL YEARS AFFECTED AND A MANUAL OVERRIDE NEEDS TO BE ENGINEERED SUCH THAT CHILDREN'S LIVES ARE NOT AT RISK DUE TO FAULTY ENGINEERING.

BOTH SLIDING DOORS BROKE WITHIN 6 MONTHS OF ONE ANOTHER; ONE STILL OPERATES MANUALLY, THE OTHER CANNOT BE OPENED AT ALL. TOYOTA STATES THE $3000 REPAIR WILL NOT BE CONVERTED UNDER WARRANTY THOUGH THIS APPEARS TO A VERY FREQUENT PROBLEM DISCUSSED ON ONLINE CHATROOMS.

THE DRIVER'S SIDE DOOR HINGE IS BROKEN AND MAKES OPENING AND CLOSING OF THE DOOR DIFFICULT AND SEEMS UNSAFE. WE TOOK IT TOO THE DEALER AND THEY TOLD US IT'S NOT COVERED AND WILL COST TOO MUCH MONEY FOR US TO REPAIR.

DUE TO WHAT I HAVE LEARNED IS AMONG NEARLY ALL 2004 TOYOTA SIENNA OWNERS, THE SLIDING CAN DOORS FREEZE SHUT AND CAN'T BE OPENED. ON CHRISTMAS DAY 2012, MY VAN WAS PARKED ON THE STREET, AND AT ABOUT 1AM I WENT OUT TO START THE VAN AND WARM IT UP FOR MY FAMILY, ABOUT 15 MINUTE LATER I CAME OUT WITH THE KIDS TO LEAVE. I THEN DISCOVERED THAT THE DOORS WERE FROZEN SHUT. I TRIED PULLING MANY TIMES AND THEN TRIED HAVING SOMEONE GO INSIDE THE VAN AND PUSH WHILE I PULLED, IT DIDN'T WORK. THEN I HAD MY WIFE TAKE THE KIDS BACK IN THE HOUSE WHILE I WORKED ON IT, I GOT THE DOOR TO OPEN ABOUT AN INCH AND I STUCK MY FINGERS IN AND GRIPPED THE EDGE OF THE DOOR FOR BETTER LEVERAGE AND TO AVOID DAMAGING THE HANDLE. I THEN PULLED REALLY HARD AND...

THE DRIVER DOOR WELDS HAVE BROKEN, WHICH CAUSES THE DOOR TO BE DIFFICULT TO OPEN AND CLOSE. RESEARCH ON THE MATTER REVEALED EVENTUALLY THE ENTIRE DOOR CHECK MOUNTING PANEL CAN FAIL, CAUSING THE DOOR TO CLOSE UNEXPECTEDLY AND BECOME A SAFETY ISSUE. I CALLED TOYOTA'S CONSUMER AFFAIRS DEPARTMENT, AND THEY REFUSED TO TAKE ANY CORRECTIVE ACTION. TOYOTA WAS AWARE OF THIS PROBLEM YEARS AGO, WHICH WAS DOCUMENTED IN THEIR OWN TSB #NV003-07. AS A SENIOR CITIZEN, I AM AFRAID I WILL BE INJURED BY THIS DEFECT, WHICH IS BECOMING WORSE AS TIME PROGRESSES.

2004 TOYOTA SIENNA XLE LIMITED: THE REAR DOOR/HATCH CLOSES RANDOMLY AFTER OPENING. THE METHOD OF OPENING DOES NOT SEEM TO MAKE A DIFFERENCE WHETHER BY REMOTE OR INTERIOR DOOR CONTROLS. THREE TIMES NOW I WAS NEARLY CRUSHED IN THE DOOR, BARELY ESCAPING IN TIME. IT IS BEYOND REASON WHY THIS HAS NOT BEEN ADDRESSED ALREADY AS IT IS CLEARLY AN ISSUE THAT HAS OR WILL CAUSE BODILY HARM AND NOT A NEW ISSUE. A WELL DOCUMENTED DEFECT THAT IS NOT ADDRESSED...WOW. THE VEHICLE WAS PARKED WHEN THE INCIDENCE(S) OCCURRED. WHOEVER HAS THE AUTHORITY PLEASE PUT THIS ITEM ON RECALL BEFORE SOMEONE IS SERIOUSLY INJURED OR WORSE! THANK YOU. *TR

THE VEHICLE WAS PARKED IN A SHOPPING CENTER PARKING LOT. I HAD LIFTED THE TALIGATE WITH THE POWER LIFTER. AS MY WIFE WAS BENDING INTO THE CARGO AREA TO GET TOTE BAGS, THE DOOR CAME DOWN ON HER. SHE JUMPED ASIDE. THE DOOR CONTINUED TO COME DOWN. THIS HAPPENED AGAIN IN THE MANUAL MODE. WE TOOK THE VAN TO THE DEALER. THEY "VERIFIED CUSTOMER'S CONCERN." BECAUSE THESE STRUTS HAVE BEEN THE SUBJECT OF A RECALL OR EXTENDED WARRANTY AND BECAUSE THIS IS A SAFETY ISSUE, I CONTENDED THAT TOYOTA SHOULD PAY FOR THE REPAIR/REPLACEMENT, ALTHOUGH THE WARRANTY HAD EXPIRED. WE DID NOT GO FORWARD WITH THE WORK. THE DEALER REFERRED ME TO CORPORATE, WHERE I HAD ALREADY ESTABLISHED A CASE. I HAVE TALKED AGAIN WITH CORPORATE. THE CASE IS UNDER REVIEW.

THERE IS AN ISSUE WITH THE DOOR CHECK MOUNTING PANEL ON BOTH OF THE MINIVAN'S FRONT DOORS. THE DOOR CHECK MOUNTING PANEL IS THE PIECE THAT KEEPS THE DOOR OPEN, AND IF THE PART FAILS THE DOOR CAN SWING FREELY AND UNEXPECTEDLY SHUT ' OBVIOUSLY A CONCERN FOR PARENTS WITH KIDS. TOYOTA HAS TRACED THE PROBLEM BACK TO BAD SPOT WELDS PERFORMED AT THE AUTOMAKER'S PRINCETON, INDIANA FACTORY.

DRIVER SIDE SECOND ROW PASSENGER POWER SLIDING DOOR SUDDENLY STOPPED WORKING. ONLY SLIGHTLY BUDGES MANUALLY AND ELECTRICALLY THEN HAS TO BE FORCED CLOSED. MECHANIC SUSPECTS BROKEN CABLE AND QUOTED ME $1,500 - $2,000 TO REPAIR. REALLY? AND IF THE OTHER DOOR STOPS WORKING LIKE THE HUNDREDS OF COMPLAINTS I AM READING ON JUST ONE BLOG (REPAIRPAL)? I LOVE THIS VAN AND HAVE BABIED IT WITH ON-TIME MAINTENANCE AND REPAIRS BUT THIS IS TOO MUCH! I CAN'T AFFORD THIS BUT SAFETY IS A MAJOR CONCERN TO ME AS THIS EXIT NO LONGER EXISTS.

WHEN OPENING THE POWER/SLIDING DOOR, PASSENGER SIDE, A WIRE SNAPPED AND THE DOOR GOT STUCK IN AN ALMOST CLOSED POSITION AND WOULD NOT BUDGE. I AM TOLD THIS IS A KNOWN PROBLEM AT TOYOTA. THE CABLE USED IS VERY THIN FOR THE LOAD IT BEARS. POOR DESIGN, WHICH APPARENTLY THEY HAVE FIXED IN LATER MODELS.