2016 FORD FUSION Engine Problems

TSB 19-2346 (https://static.nhtsa.gov/odi/tsbs/2019/MC-10169807-0001.pdf) needs to include 2016 models of the Ford Fusion. My wife was starting our 2016 Ford Fusion 2.0l EcoBoost when it started shaking violently in idle. The check engine light began flashing. We had it towed into Ford where they are now quoting us a $10,000 full engine replacement for “coolant in the cylinders.” This is the exact same problem the 2017-19 fusions are experiencing, so I am not sure why the 2016 isn’t on this list.

Coolant leaking into Engine

The car is missing on cylinder #1 and showing signs of a blown head gasket. Car will stall at random times as well. This is car has a the 1.5 ecoboost with a flway in the block design. Ford told me because of the flaw that I would have to purchase a new engine. There is currently a TSB out for this exact reason, yet ford wants me to pay for their mistake.

I have a 2016 Fusion with a 1.5 L EcoBoost, 54,000 miles on it. I am out of warranty by less than a year. My car told me that the engine was overheating while I was driving down the highway. I pulled off the road, and found there was no coolant in the reservoir. I filled the coolant up and kept an eye on it while scheduling a repair appointment. Every time I would drive the car, it would stutter when accelerating, only when it was cold. Once it warmed up it was not an issue. Every time I would also have to refill the coolant. I took the vehicle in, and found out it was misfiring on cylinder 4, and the coolant was leaking into the engine. Since it is out of warranty, it is $3,000 out of pocket. My car could have started on fire, or started smoking...

In September 2021 my 2016 Ford Fusion that has a 1.5L Eco boost engine had white smoke emitting from the exhaust. A check engine light came on and a test revealed that the #3 spark plug or ignition coil as bad. I had all spark plugs and ignition coils replaced. The light went off and three days later the check engine light came back on. We took it to Bob Tomes Ford 950 S Central Expy, McKinney, TX 75072. A Service inspection revealed that engine coolant was leaking into the cylinders and could potentially cause engine over heating and possibly a fire. This has been a known problem and numerous Service Bulletins (TECHNICAL SERVICE BULLETIN 1.5L EcoBoost - Low Coolant, White Exhaust Smoke And/Or Illuminated MIL - Built On Or Before 06-Apr-2019 19-2139) have been released on this issue, A compete engine replacement is the only repair option due to...

Water seeping into cylinders causing engine warning light, missing, stalling and lost horsepower. Problem was found upon Dealership doing a pressure test and removing spark plugs to see the issue and confirmed. Water loss was being noticed during oil changes couple years before this incident. Last oil change 1200 miles ago noticed a big loss of water in the reservoir. First warning light appear 2 months ago but cleared a couple days later until this last warning light a week ago with noticeable performance issue.

Internal coolant leak inside cylinder causing misfire told engine could catch fire

The engine block failed, cracking, causing coolant to leak into the number 3 cylinder. Causing a misfire code. I could hear what sounded like water flowing behind the dash for awhile. Eventually noticed I was a little low on coolant, then ended up using a whole gallon of coolant in about a week. The dipstick also had coolant on it when I checked the oil level. The car has been at the shop since January 23rd, 2021, they tested the head and it was fine. When I noticed it was a serious issue, coolant was blowing out the tail pipes in white clouds. I have a short video of this happening.

Vehicle is not cooling off

Coolant leaked into engine causing cylinder 2 misfire and is now requiring an 8 thousand dollar repair for the whole engine.

My fusion has had a rough idle when starting for the past year. I took it in to the mechanic and they said the problem was due to a backfire. They replaced the spark plugs and coils for around $500-$600. About 5 months later, I get e check engine light and a warning that the engine is overheating. Take it to the mechanic, where they figured out that this consistent issue is due to a head gasket leak, where coolant is going into the engine. From doing research, I have noticed that Ford Fusions with an eco boost engine have a poor engine manufacture and that this issue is prevalent in most eco boost engines. The new fix seems to be ranging from $1,200, and I have tried to diagnose this issue multiple times. This isn't easily distinguished by the engine warning, and can run the risk of drivers driving...

Vehicle overheats. Filled up coolant reservoir twice in one week. Checked coolant, coolant low, no leaks, no water going into the oil, coolant evaporates and causes car to overheat.

Coolant leaking into engine, 5 year old car with only 50K miles. Tons of information online about similar issues around the country but Ford has not acknowledged that it’s a design flaw. Local dealer wants 10K dollars to replace engine.

The contact owns a 2016 Ford Fusion. The contact stated while turning on the vehicle, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that there was a misfire detected in cylinder # 1. the check engine warning light was reset. The independent mechanic suggested that the vehicle be driven for a couple of miles to see if the check engine warning light would reappear. During the drive, the contact noticed that there was white smoke coming from the exhaust pipe and an overheat alert message appeared on the display. The contact researched online and saw that there was a technical service bulletin related to the failure and had the vehicle towed back to the same independent mechanic. The vehicle was diagnosed and the contact was informed that the long block was cracked and the engine needed to be replaced. The manufacturer...

I bought my 2016 Fusion two years ago with 75,000 Miles on the odometer. The first day it went into fail safe mode while in the passing lane. I had no engine power and had to pull over in traffic. Code P2111 Throttle body stuck open. I cleaned the throttle body and maf sensor with a $10 two pack of spray cleaner. My car now with 110,000 miles just did the same thing yesterday 5/17/21 while in traffic code P2111. I cleaned the throttle body again even though it didn't look dirty compared to the first time. My car shut down three times today while in traffic. Each time I had to pull over with no power shut off the car and restart the engine. I will replace the throttle body but believe this is very serious defect and should have never happened at 75,000 miles or even at 110,000....

AT APPROXIMATELY 125000 MILES, THE VEHICLE DISPLAYED THE CHECK ENGINE LIGHT AND WAS EXPERIENCING DIFFICULTY RESTARTING AFTER REFUELING. LOCAL AUTO PARTS STORE CODE READER DISPLAYED ETC P1450. ONLINE RESEARCH POINTED TO A FAULTY CANNISTER PURGE VALVE. THIS FAULT AND ACCOMPANYING SYMPTOMS WERE OUTLINED IN RECALL # 18S32. THIS RECALL IS NOT CURRENTLY APPLICABLE TO MY VIN. DIAGNOSIS PERFORMED BY SANDERS FORD IN SWANSBORO, NC CONFIRMED FAULTY PURGE VALVE.

MY 2016 FORD FUSION HAS A COOLANT IS LEAKING IN THE CYLINDER DUE TO HEAD GASKET CAUSING MISS FIRING, OVERHEATING AND SPUTTERING. DRIVING DOWN THE HIGHWAY WHEN THE OVERHEATING LIGHT CAME ON CAUSING ME TO PULL OVER TO LET ENGINE COOL DOWN TO PULL OFF ONTO A EXIT. ONLY HAS 120K MILES.

THE CAR CONTINUOUSLY OVERHEATS NO MATTER WHAT I REPLACE IN THE CAR.

I'VE HAD THE CAR FOR ABOUT 8 MONTHS NOW. FIRST THE SEATS STOPPED MOVING BACK AND FORTH. NO WARRANTY ON THE CAR SO TOOK IT TO MY LOCAL FORD AND THEY SAID IT WAS OFF ITS TRACK. A MONTH LATER THE SAME PROBLEM OCCURRED AND THEY SAID MY SEAT STOPPED SENDING COMMANDS TO THE COMPUTER. NOW THREE MONTHS LATER MY CAR RANDOMLY STARTED MAKING A LOUD RATTLING NOISE. GOT LOUDER EVERY TIME I STARTED THE CAR. SO ONCE AGAIN TOOK IT TO MY NEARBY FORD. THEY CHECKED IT OUT AND SAID MY FLEX PLATE HAS CRACKED ALL AROUND AND THAT IT WOULD BE A $1600 REPAIR. THIS CAR IS STILL FAIRLY NEW. LOOKED INTO IT AND IT SEEMS A LOT OF PEOPLE ARE HAVING THE SAME EXPERIENCE AND FORD IS AWARE OF THE MALFUNCTION AFTER MANY COMPLAINTS BUT STILL HAS NOT MADE IT A RECALL. VERY UPSETTING THAT I WILL...

MY 2016 FORD FUSION HAS APPROXIMATELY 53,000 MILES ON IT AND THREW THREE CHECK ENGINE LIGHTS IN THE TIME SINCE I PURCHASED IT (WITH ABOUT 18K ON IT). I TOOK IT IN IMMEDIATELY EVERY TIME. ON THE THIRD TIME I WAS TOLD THERE WAS COOLANT LEAKING INTO THE BLOCK AND IT WOULD NEED A NEW ENGINE. IT WAS 2WEEKS PAST WARRANTY. I HAVE RESEARCHED, DESPITE KNOWING NOTHING ABOUT ENGINES, AND FOUND THAT THIS APPEARS TO BE COMMON. FORD REFUSED TO PAY FOR THE WHOLE REPLACEMENT. THEY ARE NOW SAYING MY TURBO CHARGER IS BAD AND I AM OUT FOR 3600?? IT HAS BEEN IN THE SHOP FOR TWO WEEKS... DEALER SHOP AT WHICH I BOUGHT IT AND I AM VERY FRUSTRATED.

CAR BEGAN RUNNING HOT WHILE ON INTERSTATE AND IMMEDIATELY SLOWED TO 40MPH IN 70MPH ZONE. BARELY MADE IT OFF INTERSTATE WITHOUT BEING HIT. AFTER WAITING FOR OVER AN HOUR AND FILLING WITH WATER I WAS ABLE TO MAKE IT HOME BEFORE IT RAN HOT AGAIN. CODES P1299 AND P0303 ARE SHOWING. WHEN I CALLED FORD I WAS TOLD THEY HAVE HAD TO FIX HUNDREDS OF CARS WITH THE SAME PROBLEM WHICH IS INTERNAL COOLANT LOSS, OVERHEATING, AND MISFIRE OF CYLINDER #3. THIS COSTS THOUSANDS OF DOLLARS I WAS TOLD. I JUST FIXED A FAULTY PURGE SOLENOID AND CAN'T AFFORD TO PAY THOUSANDS MORE ON THINGS FORD SHOULD HAVE RECALLED!

TL* THE CONTACT OWNS A 2016 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STARTED OVERHEATING WITH THE HIGH-TEMPERATURE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE FAILURE AND INFORMED THE CONTACT THAT THE CYLINDER HEAD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO A SECOND INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE ENGINE WAS REPLACED AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER REFERRED THE CONTACT TO NHTSA. NO FURTHER ASSISTANCE WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

HACE 2 AOS COMPRE UN FORD FUSIN 2016 CON 34,000 MILLAS DEL DEALER. EL AO PASADO MI FORD FUSIN SE ME APAG CUANDO ESTABA ESPERANDO LA LUZ VERDAD PARA AVANZAR, GRACIAS A DIOS A LOS TRES INTENTOS ARRANCO. DESPUS ESO LO LLEVE A UN MECNICO PERSONAL Y ME DIJO QUE ERAN LOS INYECTORES (267$) TAMBIN EN ESE TIEMPO ARREGLO LAS BUJAS PORQUE ESTABAN DESGASTADAS FUE RARO PORQUE YO APENAS TENA UN AO CON EL CARRO ENTONCES LO ARREGLO Y QUED BIEN. HOY EN DA EL CARRO EMPEZ A HACER LO MISMO DEL AO PASADO PERO AHORA COMO TENA 4 RECALLS PARA ARREGLAR LO LLEVE AL FORD PARA QUE ELLOS COMPUSIERAN LOS RECALLS Y DE PASO CHECARAN QUE ES LO QUE TIENE MI CARRO, EN FIN ME LLAMARON DE FORD PARA DECIRME QUE EL COSTO PARA ARREGLARLO ES DE 9000$ QUE PORQUE OCUPA MOTOR NUEVO Y YO AN ESTOY PAGANDO MI...

RADIATOR FLUID IS LEAKING INTO CYLINDERS. CAR OVERHEATS IF YOU DONT KEEP REFILLING COOLANT.

I WAS GETTING READY TO LEAVE TO WORK MY CAR HAS BEEN PARKED OUTSIDE MY HOUSE I GOT IN TRIED STARTING IT AND DONT WANT TO TURN ON I TOOK IT TO AUTOZONE TO HAVE BATTERY CHECKED AND BATTERY IS GOOD IT WILL START IF I GET A JUMP I CALLED MY MECHANIC AND HE SAYS IT COULD BE MY ALTERNATOR I DONT SEE HOW I BARLEY GOT THE CAR I SEEN THAT THERE WAS SOME ISSUES WITH THE ALTERNATOR ON MY CAR

I PURCHASED THIS IN GOOD CONDITION FROM INDEPENDENT DEALER. LESS THAN A YEAR LATER, ENGINE LIGHT CAME ON AND IT WAS ATTRIBUTED TO EVAP CANISTER. GOT THAT REPLACED, ENGINE LIGHT STAYED OFF FOR 4 MONTHS. LIGHT RETURNED AND MECHANIC ASSESSED FLUID LEAK INTO CYLINDERS 2 AND 3, REPLACED SPARK PLUGS. LIGHT WAS OFF FOR A DAY, RETURNED WHILE DRIVING AND NOW WE ARE FACED WITH REPLACING THE ENGINE. LESS THAN 100K ON THE ENGINE, THIS IS THEFT.

GETTING A CHECK ENGINE LIGHT - THE READING IS MISFIRE ON CYLINDER 1. AFTER OUR MECHANIC HAS TRIED OVER AND OVER TO FIND WHERE THE LEAK IS COMING FROM. HE SPOKE TO A MECHANIC THAT WORKS FOR FORD. HE WAS TOLD THAT IT IS A KNOWN FAULT IN THAT ENGINE THAT THE COOLANT LEAKS INTO THE ENGINE AND WILL EVENTUALLY CAUSE THE ENGINE TO LOCK UP - CRACK THE BLOCK. FORD HAS NOT DONE A RECALL FOR THIS ITEM EVEN THOUGH I AM ABLE TO FIND NUMERORUS COMPLAINTS OF THE SAME PROBLEM. MY CAR IS NOT UNDER WARRANTY AND I OWE TOO MUCH TO JUST TRADE THE CAR IN TO BECOME SOMEONE ELSE'S PROBLEM. SO KNOW I HAVE OUR MECHANIC LOOKING FOR AN ENGINE AND HAVE TO JUST HOPE AND PRAY THAT THIS ENGINE THAT WE FIND DOESN'T HAVE THE SAME ISSUE. WISH I COULD UNDERSTAND WHY THERE HAS NOT...

LOOSING COOLANT, THICK WHITE SMOKE AT STARTUP AFTER THE CAR SITS FOR A WHILE.

CAR IS LOSING COOLANT. I SEE THERE HAVE BEEN OTHER FORDS HAVE BEEN RECALLED FOR A COOLANT LEAK / POOR CIRCULATION BUT MY CAR IS NOT ON THAT LIST. WE CAN'T FIGURE OUT WHERE IT IS LOSING COOLANT OR WHY IT KEEPS SHOWING IT IS OVERHEATING. IN IDLE IS SHOWS IT IS OVERHEATING WHEN YOU ARE START MOVING THE TEMP GOES DOWN. CHECKED COOLANT AND IT WAS LOW. ADDED COOLANT THEN THERE WAS WHITE SMOKE COMING FROM THE ENGINE. SMOKE STOPPED BUT THE NEXT DAY IT SHOWED IT WAS OVERHEATING AGAIN WHEN IN IDLE STATE. TOOK BACK TO THE MECHANIC. THEY CAN'T FIND WHERE IT IS LOSING COOLANT BUT SHOWS IT IS LOSING COOLANT. I SEE THERE HAVE BEEN OTHER RECALLS FOR THIS ON THE SAME MODEL AS MINE AND OTHER FORD MODELS AS WELL. MY VIN DOESN'T SHOW IT IS RECALLED FOR THIS ITEM. WANT TO GET FIXED BEFORE...

I WAS DRIVING AND HAVE YET TO HEAR BACK FROM SOMEONE. IT IS VERY DANGEROUS TO DRIVE MY VEHICLE. AFTER READING OTHERS CONCERNS THIS HAPPENS TO FUSIONS A LOT MORE THAN USUAL. I WAS DRIVING AND SOMETIMES WOULD SMOKE WHILE JOLTING FORWARD. THIS IS VERY CONCERNING BECAUSE I DRIVE WITH KIDS IN THE CAR AND THIS IS UNACCEPTABLE THAT THIS KEEPS REOCCURRING. IT READS A MISFIRE BUT I HAVE REPLACED THE COIL TWICE AND THE SPARK PLUGS TWICE. THAT IS NOT THE CASE THE COOLANT GOES INTO THE ENGINE CAUSING THE PROBLEMS AND IS VERY DANGEROUS FOR THE KIDS AND MYSELF.

MY ENGINE IS MISFIRING ON THE SECOND CYLINDER DUE TO A CRACK IN THE ENGINE THAT'S CAUSING COOLANT TO LEAK INTO THE CYLINDER BECAUSE OF THE MATERIAL THAT THE ENGINE BLOCK WAS MADE.

HAD TO HAVE THE ENGINE REPLACED FOR 2500$. ENGINE STARTED LEAKING COOLANT LAST YEAR. TRIED TO SEAL WITH HEAD GASKET LEAK FIX. AFTER OVER HEATING SEVERAL TIMES THROUGHOUT THE YEAR, ENGINE FAILED. THIS SHOULD BE A RECALL.

COOLANT IS ENTERING CYLINDERS - KNOWN ISSUE IN THE 1.5 ECOBOOST MOTORS AS THERE ARE RECALLS IN THE 2017 AND 2018 VEHICLES. FORD WILL NOT REBUILD MOTOR MUST BE REPLACED AT A COST OF $5K. VEHICLE IS 4 YEARS OLD AND JUST VER 100K MILES. NO EXCUSE FOR NEEDING A MOTOR AND ALSO FORD IS DOING NOTHING TO HELP THE CUSTOMER. SAFETY ISSUE IS MINE LOST POWER GOING UP A HILL AND STOPPED ME IN THE MIDDLE OF THE ROAD, THEN APPEARED FINE ONCE RESTARTED. NOW MISSES AND DOES NOT RUN HARDLY AT ALL.

THE CAR READS AS A 4TH CYLINDER MISFIRE BUT IT'S NOT. THE COIL HAS BEEN REPLACED TWICE AND THE SPARK PLUGS HAVE BEEN REPLACED TWICE ALSO. WENT BACK TO FORD AFTER SPENDING ALL THIS MONEY TO TELL ME THERE IS A LEAK GOING INTO MY ENGINE FORM MY COOLANT. NOW I HAVE TO GET A NEW WHOLE ENGINE AND I ONLY HAVE THE CAR FOR ABOUT 3-4 YEARS. THIS IS ABOUT A $5,000-$6,000 FIX. AFTER RESEARCHING, THIS SHOULD BE A RECALL DUE TO THE AMOUNT OF SIMILAR CASES THERE HAS BEEN. WHEN DRIVING, THE LIGHT WOULD COME ON AND OFF WHEN IT WANTS AND IT SOMETIMES WOULD BOLT FORWARD THIS IS DUE TO THE LEAK TO THE ENGINE. I'VE HAD TO HAD IT TOWED ONCE BECAUSE IT WAS STARTING TO GIVE UP. THIS IS WHEN I TOOK IT TO FORD TO MISDIAGNOSE ME THAT IT WAS THE SPARK PLUGS WHEN...

CAR HAS 60K MILES. LOSING COOLANT NO LEAK. DIDN'T START ONE DAY. FIRESTONE COULDN'T FIND THE PROBLEM. HAD MY CAR TOWED TO BAYTOWN FORD. AFTER A WEEK AND A $800 AUTHORIZATION TO OPEN THE ENGINE ONLY. NEXT DAY I WAS TOLD I NEED A NEW ENGINE. $6K. MY QUESTION WAS WHAT CAUSED THE ENGINE FAILURE, AND HOW CAN I BE SURE THE NEW ENGINE WONT HAVE THE SAME PROBLEM. MY OIL CHANGES ARE REGULAR. MOBIL 1 OIL AND FILTER. I WAS TOLD THE SLUDGE IN MY ENGINE WAS BECAUSE I HAD A AFTERMARKET OIL FILTER NOT A MOTORCRAFT FILTER. NOT IN WRITING. I KNEW BETTER AND AFTER SOME RESEARCH I FOUND A PLETHORA IF OTHER OWNERS HAS HAD THE EXACT SAME PROBLEM. MY CAR IS MY KEY TO PROVIDING FOR MY FAMILY AND I DONT HAVE $6K FOR A MANUFACTURER DEFECT. CAR HAS ALSO CUT OFF WHILE MY WIFE WAS...

SEVERAL WEEKS AGO I WAS DRIVING MY CAR AND I NOTICED I DIDNT HAVE ANY HEAT AND MY COOLANT TEMP HIGH LIGHT CAME ON. SO WHEN I CHECKED THE COOLANT I DIDNT HAVE ANY AT ALL. NONE OF MY HOSES WERE LEAKING FROM ANYWHERE. I ADDED COOLANT TO IT AND DIDNT THINK NOTHING OF IT. TODAY ON MY WAY TO WORK THE SAME THING HAPPENED. MY COOLANT TEMP HIGH LIGHT CAME ON AND WHEN I PULLED OVER I DIDNT HAVE ANY COOLANT WHATSOEVER. THE COOLANT HAS GOT TO BE GOING SOMEWHERE IN THE ENGINE BECAUSE THERE IS NO SIGNS OF IT LEAKING FROM THE RADIATOR OR ANY OF ITS HOSES.

BLOWN ENGINE DUE TO BLOWN HEAD GASKET AT 83,000 MILES

A SITUATION THAT I ENCOUNTERED WITH MY 2016 FUSION WHEN IT HAD 55K MILES ON IT WAS THAT THE VEHICLE WOULD HAVE A ROUGH IDLE ON STARTUPS AND WOULD HAVE A ROUGH IDLE WHEN IT WAS STOPPED (EX. ON A STOP SIGN, RED LIGHT, PARKED, ETC.). IT DID HAVE A CHECK ENGINE LIGHT ON WHEN THESE ISSUES OCCURRED AND SO I TOOK IT TO A SHOP TO GET THE CODES CHECKED OUT AND IT DESCRIBED HAVING A MISFIRE ON CYLINDER TWO. THE SHOP RECOMMENDED ME TO TAKE IT TO THE FORD DEALER FOR A MORE THOROUGH INSPECTION. I MADE AN APPOINTMENT TO VISIT THE SHOP A COUPLE OF DAYS AFTER BUT IN BETWEEN THOSE DAYS I NOTICED THICK WHITE SMOKE COMING FROM THE EXHAUST. THE ROUGH IDLING STILL PERSISTED AND I TOOK IT IMMEDIATELY TO THE FORD DEALER. AFTER TALKING WITH THE STAFF ABOUT MY ISSUE, THEY RAN A DIAGNOSTICS...

STARTED TO LOSE COOLANT, COULDNT SEE ANYWHERE THAT IT WAS LEAKING, OR ANY SIGNS OF LEAKING. REFILLED THE COOLANT RESVOIR. DROVE TO WORK THE NEXT DAY, AND WHEN I GOT OFF OF WORK I TRIED TO START THE CAR AND IT WOULDNT FIRE. ONCE IT WAS MOVED ALL OF THE OIL HAD BEEN LAYING ON THE GROUND WHERE THE CAR WAS PARKED. DONE ALOT OF RESEARCH AND FOUND OUT THAT THE CYLINDER HEADS ARE JUNK AND WAS LOOSING COOLANT IN TO THE CYLINDER. SO NOW IM STUCK WITH A $200 A MONTH PAYMENT FOR SOMETHING THAT HAPPENED THAT HAS HAPPENING TO THOUSANDS OF CARE WITH THE 1.5L ECO BOOST TURBO... AND THERE STILL IS RECALL??? THE CAR DOESN'T HAVE 130,000 MILES YET.

PURGE FUEL VALVE. CAR IS STALLING AT TIMES. OTHER TIMES IT WON'T START. THIS HAS BEEN A RECALL IN THE PAST BUT NOT SHOWING ON MY VIN. SOMETIMES IT IS MAKING A NOISE.

THE CAR SHUTS OFF WHILE DRIVING UNDER THE SPEED OF 20 MPH. IT HAS HAPPENED 6 TIMES IN THE LAST 2 MONTHS. THE WORSE PART WAS IT HAPPENED ON THE INTERSTATE IN THE RAIN AND I HAD TO PULL OVER QUICKLY ON TO THE RAMP WHILE AN 18 WHEELER WAS COMING MY WAY.

THE ENGINE IS MISFIRING, SAID 'ENGINE 2 CYLINDER MISFIRING' PROBABLY COOLANT LEAK. AND I CANT AFFORD TO PAY 5000 FOR A NEW MOTOR.

THE ENGINE HAS CRACKED AFTER NOT EVEN 100,000 MILES. NOW I HAVE TO REPLACE IT FOR 8000. RIDICULOUS AND DANGER WITH THE FUMES THAT FORM FROM LEAKING THROUGHOUT THE ENGINE. ALL I DID WAS DRIVE IT TO WORK !!! FORD KNOWS IT AN ISSUE TOO!! DO THEY THINK WE DON'T DESERVE OUR MONIES WORTH OR TO BE SAFE!

MY VEHICLES CHECK ENGINE LIGHT CAME ON AND IMMEDIATELY AFTER THE LIGHT APPEARED THE CAR BEGAN TO LOSE POWER, BECOME SLUGGISH AND SLOW TO ACCELERATE. THE VEHICLE HAD TO BE STOPPED ON THE EXPRESSWAY AND TOWED TO A REPAIR SHOP (DELKERS AUTOMOTIVE 12198 LEWIS AVE, TEMPERANCE, MI 48182) WHO LOOKED AT THE VEHICLE AND EXPLAINED TO ME THAT THERE WAS LEAKING ENGINE COOLANT INTO THE CYLINDER THAT CAUSED THE ENGINE TO OVERHEAT AND CRACK. THERE WAS COMPLETE ENGINE FAILURE AND I WOULD NEED A NEW ENGINE AT 73,000 MILES. I HAD THE VEHICLE TOWED TO BRONDES FORD AT 5545 SECOR ROAD TOLEDO, OH ON AUGUST 28TH. BRONDES FORD VERIFIED WHAT DELKER'S AUTOMOTIVE HAD FOUND, THE COOLENT LEAK INTO THE CYLINDER THAT CAUSED THE ENGINE TO CRACK. BRONDES FORD TOLD ME THAT THIS IS A KNOWN ISSUE AND THAT I SHOULD TRY TO FILE A CLAIM WITH FORD TO RECOUP SOME...

IN JUNE OF 2020 A CHECK ENGINE LIGHT POPPED UP ON MY DASHBOARD; THEREFORE, I TOOK MY CAR INTO THE DEALERSHIP TO BE DIAGNOSED. THEY ULTIMATELY UNCOVERED THAT THERE WAS A KNOWN ENGINE DEFECT WITH MY 2.0 L 4 CYLINDER ENGINE DUE TO A COOLANT LEAK. UNFORTUNATELY, MY VEHICLE IS WITHIN 2 MONTHS OUTSIDE OF THE CURRENT SAFETY RECALL. THERE IS AN ACTIVE RECALL ON ALL OF THE 1.5 L THAT COVERS 2014 THROUGH 2019; HOWEVER, THE RANGE ON MY 2016 2.0 L FUSION BEGINS IN 2017. I REACHED OUT TO FORD AND THEY INDICATED THAT EVEN THOUGH I AM WITHIN 1.5-2 MONTHS OUTSIDE OF THE RECALL THEY CANNOT ASSIST ME WITH FINANCING MY OVER $7,000 REQUIRED ENGINE REPLACEMENT AND I AM QUITE DISAPPOINTED THAT THE RECALL HAS NOT BEEN EXTENDED YET. FURTHER, I AM WRITING THIS AS OF 11/1 AND IT HAS BEEN NEARLY 5 MONTHS SINCE I DROPPED...

THERE IS A COOLANT LEAK IN CYLINDER 2. OF MY 2L ECOBOOST REQUIRING A COMPLETE LONG BLOCK REPLACEMENT. THIS CAN CAUSE THE CAR TO OVERHEAT AND/OR RUN UNRELIABLY. I HAVE HAD TO PULL OVER ON THE SIDE OF A BUSY HIGHWAY TO ADD COOLANT. THIS WILL NO DOUBT LEAVE ME STRANDED ONE DAY SOON, AS THIS IS A KNOWN PROBLEM FOR MANY OF FORD'S ECOBOOST ENGINES YET THEY HAVE NOT RECALLED THESE FAULTY ENGINES. AND I CAN NOT AFFORD AN $8,000 REPAIR THERE IS A FORD TECHNICAL SERVICE BULLETIN 19-2346 DATE OF ISSUE DECEMBER19 2019

THE VEHICLE WAS STATIONARY IN MY GARAGE. I WAS ATTEMPTING TO LEAVE FOR WORK AND THE VEHICLE WOULDN'T START. I CHECKED THE FLUIDS AND CHECKED BATTERY CABLE AND FINALLY THE VEHICLE STARTED WITH HESITATION. WARNING LIGHTS 'STERRING ASIST FAULT' 'LOW BATTERY FEATURE' AN 'SERVICE ADVANCE TRAC' APPEARED. COULD NOT TURNED THE STERRING WHEEL AT ALL TO BACK OUT OF GARAGE. BATTERY IS 1YEAR OLD SHOULD NOT BE LOW.

ENGINE TEMP NEARS RED BUT DOESN'T OVERHEAT. SOME WHITE SMOKE COLD STARTING. I TOLD DEALER ABOUT THIS BUT SINCE IT ONLY WAS DURING COLD START IT WOULDN'T REPLICATE. WARRANTY LAPSED. OVERHEATING MORE OFTEN SO I TOOK IT TO DEALER. DECLINED DUE EXPIRATION OF WARRANTEE. RECENTLY ENGINE OVERHEATED AND STARTED TO SHUT DOWN ON A FREEWAY IN TRAFFIC. SLOWING VEHICLES IN TRAFFIC ARE DANGEROUS. ENGINE LIGHT CODES READ MISFIRE CYLINDER 2. THE CAR IS FAMILY'S ONLY SOURCE OF TRANSPORTATION. WE CANT AFFORD TO PURCHASE A NEW ENGINE FROM FORD AND FORD CANT GUARANTEE A NEW MOTOR WONT REPEAT THESE ISSUES. OUR LOCAL DEALER DUPED US BY NOT ACKNOWLEDGING THAT MANY OTHER OWNERS HAVE HAD SIMILAR PROBLEMS. WORRIED THAT THIS CAR WILL LEAVE ME STRANDED IN THE HEAT, BANKRUPT US, OR BE THE CAUSE OF AN ACCIDENT.

MY 2016 FORD FUSION 1.5L ECO BOOST ENGINE WITH 62,000 MILES IS CURRENTLY IN THE SHOP NEEDING A NEW ENGINE. ONE DAY I WAS DRIVING ON THE HIGHWAY AND ALL OF A SUDDEN MY CAR STARTS SHAKING WHEN ACCELERATING AND LOSS OF POWER TO THE WHEELS. SINCE I WAS ON A HIGHWAY I TRIED TO GET TO THE NEAREST REPAIR FACILITY, BUT AFTER 3 MILES MY CAR WAS NOT DRIVABLE AS THE CHECK ENGINE LIGHT STARTED FLASHING AND MY CAR HAD NO POWER FROM THE ENGINE. THE REPAIR FACILITY ADVISED I HAVE COOLANT IN MY CYLINDERS DUE TO DESIGNED FLAW FROM FORD, FORD'S FACTORY BULLETIN 19-2139 DATED NOV 21, 2019 ADVISES TO REPLACE ENGINE. SPOKE WITH FORD CUSTOMER RELATIONS REPRESENTATIVE AND SUPERVISOR AND THEY WILL NOT HELP SINCE THE POWER TRAIN WARRANTY IS 2,000 MILES OVER. MY EXTENDED WARRANTY WILL NOT COVER COST OF REPAIR DUE TO FORDS FACTORY BULLETIN...

TL* THE CONTACT OWNS A 2016 FORD FUSION. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE MESSAGE ENGINE MALFUNCTION DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER ROY O'BREAN FORD LOCATED AT 22201 EAST NINE MILE RD, ST. CLAIR SHORES, MI 48080 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000. THE VIN WAS AVAILABLE.