2016 FORD FUSION Electrical System Problems

The rear backup camera system on my 2016 Ford Fusion S has failed and no longer displays an image when the vehicle is placed in reverse. The screen remains completely black and does not activate. The backup camera previously worked normally before this failure. The issue appears to be related to the backup camera or associated electrical/display system, and the component should be available for inspection upon request. This malfunction creates a safety risk because the backup camera is necessary to see obstacles, pedestrians, and other vehicles behind the car. Without a functioning backup camera, rear visibility is significantly reduced, increasing the risk of a collision, especially in parking lots and residential areas. The problem occurs every time the vehicle is placed in reverse. The issue has not yet been confirmed by a dealer or independent repair facility. The vehicle has not been inspected by the manufacturer, police, or insurance...

Complete loss of power steering. Service advancetrac light on Hill assist not available 2016 fusion but is not included in the recall. Car was sold to me and is registered in Pennsylvania, the salt belt. Ran scanner got codes U0240 and C102D. Clear codes, immediately get power steering back. Slowly lose power steering again, until complete failure. Super unsafe, first time this happened I was on the turnpike with my son. Speed limit is 70 m.p.h. I had to go 40 with my 4 ways on. Barely had control of my car. Very scary.

- Window motor passanger side not working unable to close window. 2023 - Sync system not working after battery and key changed by dealership. 2021 - Rearview Camera no display found - lighter port in console over heats

The in-dash backup camera stopped functioning about 2 years ago. The errors are random and range from glitching video, delay in activating, not switching off(driving forward with rearview camera activated), and a error code pop-up to contact the dealer. 100 percent of the time, the image is displayed in reverse making backing up impossible.

I have a Coolant intrusion for my car it is supposed to be recalled and serviced under warranty or the Csp

The same issue with the backup camera as the other vehicles in current recall. The 2016 Ford Fusion should be on that list as well.

2016 FORD FUSION TITANIUM BACK UP CAMERA WORKS INTERMITTENTLY. THE VIEWING SCREEN GOES BLANK WHEN IN REVERSE.

2016 FORD FUSION TITANIUM REAR CAMERA WORKS INTERMITTENTLY. SOMETIME WHEN IN REVERSE, THE SCREEN GOES BLANK.

My complaint is, why does my 2016 Ford Fusion 1.5L 4-Cylinder EcoBoost Engine continue to be excluded from these major recalls? It's not fair as I deserve to have my engine, clock spring, & my rear view camera replaced just like the other Ford vehicles! I purchased my 2016 Fusion in 2018 & only a couple of years later I started having problems with the rear view camera but the dealership said that it wasn't covered under the warranty. I have always smelled engine coolant & oil but was always told that there is nothing leaking on the ground so there's nothing to worry about. Also I reached out to you guys in 2024 with the Gmail address of [XXX] ) about my steering wheel clock spring & never heard anything back, so I purchased a new one on [XXX] & replaced it myself when it arrived. Also earlier that...

I was driving on the expressway. My car Went into limp mode it didn’t stall completely out, but I was not able to accelerate any eventually the wheel became tight. every light came on.. I made it safely off the expressway. My car would not start the ODB port is not reading. I’ve taken it to several mechanics all of them say that it’s my PCM. They said my PCM needs to be reprogrammed. There’s currently an active recall from my exact car but when I search my vin It tells me I have no active recalls.

Seemingly randomly all center console functions and door functions shut off (no a/c / heat, can't roll down/up windows, outside ambient temp and can't unlock/lock doors from inside buttons (key still works as well as door handle unlock / speed lock) can be hazardous in even mild temp as interior heats up quickly without air flow. Other non-important functions that stop working include radio/stereo and back-up camera. Research points possibly to bcm apim miscommunication or improper grounding.

rear view camera works ( sometimes ), The rear view camera worked fine for years, but I brought the car in for basic service at the Ford Dealer > oil change, tire rotation, fluids topped off > and after this repair, my rear view camera wasn't working.. I brought it back to the dealer, and they claimed what they did had nothing to do with the rear-view camera.. The service manager said a new camera would cost $ 800, but they would do the repair for $ 500 ( which seemed odd, but that's a story for another day ). Regardless... with all the news I'm reading about Ford recalls, including rear view cameras... I feel this rear view camera issue started years before they think, or will admit to, and should be investigated. I can bring my car into any nearby location for inspection if requested.

engine light turned and, scanned it and code is P0301 Cylinder 1 Misfire detected. Coolant is leaking into the engine. I have looked online and multiple people have had this issue, majority of them taking their vehicles to Ford dealers and being told they need an engine replacement. I have taken my vehicle to a mechanic shop and was told the same thing. my safety was at risk because this issue caused my engine to overheat and the engine would not turn on for a while after. with coolant being mixed in with the oil, it damages the engine and can cause the car to stop being functional while you are still operating it. I am also including a link to a website that has proof that Ford delearships have seen this issue before, are aware of it but do nothing to fix it [XXX] INFORMATION REDACTED PURSUANT TO THE...

Electric Power Steering Motor Attaching Bolts Corrode (NHTSA 19V-632, OEM 19S26): Corrosion of bolts in the electric power steering system can lead to loss of power steering assist in 2016 Ford Fusion and Lincoln MKZ vehicles in certain states. Dealers will replace bolts and apply a sealant, or install a new steering gear.

Back up camera is saying unavailable or shows a blue screen

When key is in ignition and either In on position with engine off or In accessory state the dash starts to click and the hood then releases and opens Does not happen when key is not in the ignition and driver door is open or when car is running or when car is locked but does happen if key was just removed from ignition and door has not been opened yet There are not service lights on and all trunk buttons still work when pressed

I have had road salt contamination with the electrical wiring to the power steering causing the wires to become brittle and break causing a power steering failure in a right curve which caused the steering wheel to jerk the car to the left nearly causing a collision. The power steering failed again due to high friction inside steering gear and has a broken bolt on the EPAS motor to the steering gear.

Our 1.5 EcoBoost engine overheated on 3/20/25, my daughter was driving and the vehicle started shaking and it slowed way down, for a moment she feared for her life, she said it had a message and the check engine symbol was illuminated and the vehicle would not accelerate, when she got it was leaking coolant and white smoke, I took my OBDII scanner, one code was P1299 Cylinder Over temp Protection Active, it now emits white smoke and overheats and looses fluid. TECHNICAL SERVICE BULLETIN 1.5L EcoBoost - Low Coolant, White Exhaust Smoke And/Or Illuminated MIL - Built On Or Before 10-Jun-2019 20- 2100 01 April 2020 This bulletin supersedes 19-2375. Reason for update: Replace Awareness/Interim Message Model: Ford 2014-2019 Fusion Engine: 1.5L EcoBoost 2017-2019 Escape Engine: 1.5L EcoBoost Summary This article supersedes TSB 19-2375 to update the Service Procedure and Parts List. Issue: Some 2014-2019 Fusion vehicles built on...

The trunk pops open randomly. Noticed that the actuator clicks continuously until I press the door lock button on the fob.

Backup camera hasn't worked for years on 2016 Ford Fusion. Recalls were deployed for other vehicles yet not mine. Obviously Ford has a serious problem with their backup cameras and should be required to fix all make and models.

Sync does not work nor has it ever worked contacted dealer they do not know what’s wrong with it nor have they fixed it or offered to

This is second time my transmission was bad in a ford

The trunk randomly pops open at random times. From the vehicle to being parked or driving down the highway. Multiple mechanics as well as Ford have stated they are unable to locate any problems. Once it is popped it takes 30-45 seconds for the clipping to stop before the trunk will close again. Often it will immediately re open and I have to go through this cycle 3-4 times before it stays closed until the next incident

When audio system is turned on or volume is turned on, loud cracking booming and static noise comes through at random moments. More noise occurs while driving 55+ but still occurs when idiling. The audio occurrence has almost caused several accidents since its loud ear piercing noises that comes from speakers. I have taken it to the ford technician to no avail. Due to other forums this is a issue with most fusions. The noises started occurring after my back up camera was replaced.

On Saturday [XXX] I noticed when I opened my driver side door, the dash light & the light on my touch screen began flickering. I didn't think much about it at the time, but the next day, [XXX] as myself & my wife were traveling on the highway, I tried to turn on my cruise control but it would not come on. I then tried to adjust my stereo volume on the steering wheel & it wasn't working either. Well, the next day I checked the fuses & they were fine, so that's when I went online & found out that the clock spring in the steering wheel could most likely be the problem. Well I decided to dig a little deeper into the matter & I found out that some 2016 Ford trucks had been recalled because of faulty clock springs which also could cause the airbag not to...

The car stalls out and stops moving out of no where while driving and smells like fuel as well

The contact owns a 2016 Ford Fusion. The contact stated that the check engine warning light was illuminated. The contact stated that the battery had failed several times and was replaced approximately 5 times. The contact also stated there was exhaust coming out of the tailpipe during the initial start-up. The vehicle was taken to the dealer and was repaired under NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The dealer diagnosed the vehicle and determined that the alternator was producing 20 volts while accelerating, causing the battery to overheat and burn out. Additionally, cylinder #3 was misfiring due to anti-freeze leaking into the engine. The contact was informed that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and it was confirmed that there were no recalls related to the failure. The contact was referred to the NHTSA Hotline...

Date of first incident was Nov 19, 2023. I was driving home from taking my elderly mother to the doctor and my engine just shut off. I had plenty of gas, my oil and transmission had been changed, no warning lights came on my dash prior to the engine stopping. The only message I had on my car said the car is not in park. No one can seem to find out why. It has done this at a moderate rate of speed (45mph). My steering wheel locked and I can't steer the car giving me the option to get to a safe place on the road. I have to hit another vehicle or hit a pole. I have good insurance but I don't want to use it to fix body damage. I can't afford that with a 300 dollar car payment. My break sensor error light will come on...

My trunk pops open by itself, without being activated. So far, if I keep my car locked, it will stay shut, but it has popped open while the vehicle was in motion. This is a safety hazard! It has been happening every day for the last several months.

My driver door lock light will not glow when I lock my vehicle. Transmission is slipping and has a recall on it. Front brakes has a recall.

Rear camera works intermittently. The Ford Dealer service said it failed and it'll be 800.00 to fix... I passed on that... but now that I'm seeing other Fords with camera recalls, I wonder if this problem is related.

This incident has happened to me more than once in the past few months. I am driving along the highway and all of a sudden I lose my power steering. The dashboard reads STEERING ASSIST FAULT. Service required. As well as Service Advance Trac. Safety issue because going at moderate speed to get onto highway and losing all power steering could cause me to go off road if in bad weather like rain or snow. In each situation all it took was me pulling off road and resetting the car by turning engine off and then turning it back on. I have take it to a Ford dealership near me and they ran a full diagnostics but couldnt find anything really wrong with it but it continues to happen at least once a month. Ive read similar incidents with Ford Fusion owners on Google and they werent sure as I...

There is an issue with the (evap) solenoid/associated sensor that causes the vehicle not to restart at unexpectable intervals and the fuel delivery system is also affected during fueling and seemingly during acceleration, at least. The key was recently replaced and association between the problem and the key reading mechanism is unspecified. A power train affect/association is also likely component- that based upon information provided to consumer. I've heard similar problems with other Fords and in other conversations it has not been indicated to me that the models' component's failure is not problematic. It has not been stated how that is contributory to the increased collision risk associated with the brake component that is a current recall. It began prior to the key replacement which is in the dealer repair record and 4 weeks prior to this submission is listed as the incident onset date.

In the last 4 years the battery has had to be replaced 3 times. Each time the car runs great then is shut off and the next day won't start, no lights and can't even get into the car without the key. The vehicle can't be jumped or battery charged, everything is dead. Upon replacing the battery everything works fine for about 2 years.

Rear camera keeps failing. Generic problem for many ford drivers. Bad grounding wire

Vehicle won’t start so I called my roadside/towing assistant number got someone out to do battery jump service because I been through this before twice come to find out that wasn’t the issue might needed more gas still wasn’t the issue so I got the vehicle towed to a shop it came back I needed the dealership to reprogram the vehicle they couldn’t because it wasn’t drivable so I got it towed to another shop just for them to tell me I need a new engine they didn’t know what cause the problem but just off what they seen while doing a diagnostic was low compression on all cylinders oil full and normal color (not brunt) coolant is full and clean warranty doesn’t want to cover parts that’s needed for the vehicle like cylinder head gasket check engine light always came on after repairs was fixed

WHILE DRIVING TRYING TO MAKE A TURN...MY STEERING WHEEL JERKED AND I ALMOST RAN INTO A PARKED CAR BECAUSE MY POWER STEERING JUST ALL OF A SUDDEN FAILED!!! HOW DOES THAT..JUST HAPPEN? SO MY POWER STEERING ASSIST AND MY SERVICE ADVANCED TRAC LIGHT CAME ON.. AFTER THIS HAPPENED..! UNACCEPTABLE..I TAKE GOOD CARE OF MY VEHICLE..SO I SEE THERE WERE A WHOLE LOT OF COMPLAINTS OF THIS HAPPENING...AND WOULD LIKE FORD DEALER TO RECTIFY THIS PROBLEM IMMEDIATLY...THIS IS UNSAFE. IM IN CHICAGO.

When driving my 2016 Ford Fusion, the Transmission Not In Park light comes on without any other warnings. This is unsafe because it stops accelerating. Most times I'm on the freeway. This is a safety issue that has been happening for about 2 years now. The dealerships tell me that they can't fix it because the safety issue does not occur when they have the vehicle and cant read any codes. One Ford dealership sold me a radiator and told me that was the issue. A different Ford dealership told me that it has nothing to do with the radiator. No one seems to be able to repair this safety problem that I am experiencing. Another Ford dealership told me that there is a recall but my VIN Number does not fall in that recall. How can I get my vehicle associated with the recall and have it repaired. I...

Our camera cuts in and out. We took it to Ford initially to run a diagnostic but they killed our battery doing the test and never finished. Now the camera is showing things opposite..our mailbox is on our right backing out but camea shows left. Same when a car pulled to our right but camera showed left and caused us a scare. Completely unreliable. It cuts off/on constantly when using it to back out and sometimes doesn't beep.

The engine coolant leaked into the cylinders as a result the car had rough idles and startups with overheating issues as well we dying on me completely while driving. Confirmation on coolant leak by big o tires, solution is new engine. There was a cylinder 3 misfire code with the check engine light.

When driving vehicle on warm starts, vehicle stalls and engine loses power. Warm start means any time vehicle was driven, turned off, and then restarted after less than 30 minutes of being turned off. For example, when fueling at a gas station, or making a quick errand into a store or fast food restaurant. One once occasion, vehicle also stalled after shifting to drive after an extended period of idling (approx. 20 minutes - was idling hoping to avoid stall when beginning to drive again). In general, vehicle will start (but may need a few tried before turning engine over), and idles at 500 RPM, rather than expected 1000 RPM. On acceleration, when vehicle reaches 2500 RPM or greater, needle drops to 0 and vehicle shuts off while driving. On some occasions, vehicle will also stall/shut off when decelerating as well (particularly in parking lots or instances when one may...

The contact owns a 2016 Ford Fusion. The contact stated that he was unable to unlock the vehicle manually. The dealer was contacted and informed the contact of an alternative way of unlocking the vehicle. The contact stated that after successfully unlocking the vehicle, the vehicle failed to start. The dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

My trunk keeps opening on it's own. With the keys on me, not in my hands. Without the keys on me. While driving, while not driving, just completely at random. My trunk is continuously opening. From my research this seems to be a pretty common thing for this make and model of car, and I think it's time that it be recalled and fixed. It's not safe from a driving standpoint nor a personal safety standpoint.

Electronic systems in my car just slowly stopped working

Temporarily Lost communication with the Climate System. When this error appears on the dash the following doesn’t work: AC and Heat are shut off completely. None of the controls on the bottom half of the center console panel work. This includes the heated seats, radio knobs, or any climate control button, rear defrost doesn’t work. The climate control quadrant, the lower right, on the touch screen doesn’t work. The outside temperature doesn’t work. The control buttons on the door don’t work, can’t adjust mirrors, seat recalls or control the windows. When there is no AC and can’t lower the windows, this is very bad in the summer can cause heat stroke. Bad in the winter can’t keep the windows free of ice. Happens very sporadically, even while driving it turns off. So far, the trouble shooting seems to indicate a wiring harness under the driver seat as the problem. Numerous...

While driving on the road the trunk opens up by itself. The Ford dealership continues to be unable to fix the issue and it has happened several times.

I have a silver 2016 ford fusion the problem is the latching from driver door and rear right side door . I take very good care of my cars for this to happen twice is not my doings but the car. I was off to do some errands I opened my driver side door I got in and closed the door and it shut completely I started to drive off I came to a stop where I was turning right, when I turned right my door opened and I almost crash to a car that was coming straight . I fixed the door latch then a couple weeks later the same thing happens to the rear right side door thankfully there was no car or objects near me i could have crashed into .

The APIM on my 2016 Ford Fusion Energy is, as per the local Ford dealership service department, refusing to take software updates provided by Ford rendering the instrument control cluster inoperative on an intermittent basis. This means that at the least from my personal experience the backup camera (to me, a safety issue), radio (inconvenience), navigation (inconvenience), bluetooth/phone (dialing, hands free - to me, can be a safety issue), and some climate/HVAC functions (inconvenience), do not work. I do not know if the collision avoidance system is also affected. Please see NHTSA Campaign Number: 15V406000 for similar issues for different Ford models. The question here is that Ford is offering a software update for free, but the software as written is not capable of updating the APIM in my car. If Ford agreed to fix an earlier APIM problem with other models with a free software update, and the software...

Over the last few months, the trunk has been opening randomly - this has happened while parked in the driveway, reversing out of the driveway and also while driving. Sometimes when I close the trunk, it stays shut. Other times, it just pops back open and I can hear to mechanism whirring to unlatch.

All the exterior lights went out. None of them will come on.