2016 FORD FUSION Engine Problems

DRIVING 25 MPH DOWN SIDE STREET, WHEN CAR LOST POWER AND ALMOST STALLED. ENGINE CHECK LIGHT AND WRENCH LIGHT WENT ON, AND ENGINE CUT OUT. RESTARTED CAR AND WAS ABLE TO PULL OFF OF ROAD. WAITED A FEW MINUTES AND CAR RESTARTED, LUCKILY WAS ONLY 1/2 MILE FROM HOME. CAR DIES AGAIN IN DRIVEWAY. CALLED FORD TO HAVE THEM PICK IT UP, WHICH THEY DID. SERVICE THOUGHT IT WAS THROTTLE BODY. PICKED UP CAR NEXT DAY AND IT WAS THROTTLE BODY, WHICH THEY REPLACED. FORD SERVICE KNEW OF PROBLEM, BUT I HAD RECEIVED NO NOTIFICATION OF PROBLEM. THIS IS A MAJOR SAFETY PROBLEM. I AM LUCK I WASN'T GOING 70 ON FREEWAY.

WHILE DRIVING ON I75 IN FLORIDA THE CAR LOST POWER 3 TIMES. JUST MISSED CAUSING BAD ACCIDENTS. DEALER CLAIMS IT WAS ELECTRONIC THROTTLE BLOCK FAILURES. LOOKING ON LINE THOUSANDS OF FUSION OWNERS HAVE HAD THE SAME PROBLEMS SINCE 2006 YET FORD HAS NEVER BEEN FORCED TO HAVE A RECALL.

WHILE DRIVING TODAY, I SUDDENLY LOST THE ABILITY TO ACCELERATE. THE VEHICLE BEGAN TO VIBRATE ABNORMALLY, AND THEN THE POWER WENT OUT. I BEGAN TO SMELL SMOKE, AND I ALMOST HIT THE VEHICLE IN FRONT OF ME BECAUSE I COULDN'T CONTROL MY CAR! ONCE I FINALLY CAME TO A STOP, I WAS ABLE TO RESTART IT AND PULL OVER TO A SAFER AREA-- BUT THE SMOKE REMAINED. I BELIEVE THE THROTTLE BODY IS MALFUNCTIONING, WHICH IS UNACCEPTABLE ON AN ALMOST-NEW CAR.

THE ETB (ELECTRONIC THROTTLE BODY) HAS FAILED TWICE. ONCE CAUSING COMPLETE MECHANICAL FAILURE, THE OTHER CAUSING THE VEHICLE TO GO INTO LIMP HOME MODE. I'VE READ THOUSANDS OF SIMILAR REPORTS ABOUT 2013-2016 FUSIONS DOING THE SAME THING. THIS HASN'T COSTED ME ANY MONEY BUT IT'S EXTREMELY DANGEROUS, FOR THE CAR WONT MOVE OVER 8 MPH SUDDENLY.

MY CAR BARELY PICKS UP SPEEDS I HAVE TO PUT MY FOOT ALL THE WAY DOWN FOR IT TO CATCH SPEED. MY RADIO ONLY WORKS ON ONE STATION OTHER STATION GIVES OUT LOTS OF STACKED

TRAVELING SOUTH BOUND ON FLORIDA RT 54 IN HEAVY TRAFFIC, ENGINE SHUT DOWN,RESTARTED AFTER 15 MIN,TOOK VEHICLE TO PARK FORD IN WESLEY CHAPPLE FL.GOT VEH. BACK 3 DIFFERENT TIMES SAME PROBLEM IN DIFFERENT LOCATIONS T

MADISON, WI,WEST BELTLINE HWY, HEADED WEST BOUND IN MIDDLE LANE, JAN 21, 2017, 11:00AM: AT 60 MPH ON 6 LANE HWY CAR SUDDENLY SLOWED TO A CRAWL. A WRENCH ICON APPEARED ON THE DRIVER'S DASH PANEL WITH STATEMENT "CHECK OWNER MANUAL". AS CAR SLOWED TO A CRAWL (BUT DID NOT SHUT OFF) WAS ABLE TO MANEUVER IN TRAFFIC SAFELY TO THE BREAKDOWN LANE W/O CONTROL OF CAR OTHER THAN STEERING (AUTO STEERING CONTINUED TO FUNCTION). I PRESSED THE ACCELERATOR BUT NO RESPONSE. THIS WAS REPEAT OF A SIMILAR INCIDENT ON JAN 11. TURN OFF CAR, WAITED 1 MINUTE AND DID A RE-START (MUCH LIKE MY DESK TOP PC. IMMEDIATELY DROVE TO MIDDLETON (WI) FORD DEALER WHO HAD WORKED ON CAR PREVIOUS WEEK (JAN 13-17) FOR SAME FAILURE (A BENT WIRE FOUND). DURING THE JAN 13-17 PERIOD THE DEALER IN A ROAD TEST EXPERIENCED THE SAME FAILURE. LEFT CAR WITH DEALER...

I WAS DRIVING MY 2016 FORD FUSION ON THE HIGHWAY GOING APPROXIMATELY 70-75 MPH. I SUDDENLY LOST ALL POWER AND THE CAR WOULD NOT ACCELERATE. I WAS LUCKILY ABLE TO GET TO THE SHOULDER. THE ORANGE WRENCH LIGHT WAS ON, THE INSTRUMENT PANEL SAID SEE OWNERS MANUAL AND THE CAR WAS SHUDDERING AND SHAKING. IT WAS LATE AT NIGHT IN A VERY REMOTE AREA. I TURNED THE CAR OFF AND WAS ABLE TO RESTART IT AND GET TO MY DESTINATION. THE NEXT DAY THE SAME THING HAPPENED. DRIVING ON VERY REMOTE HIGHWAY GOING APPROX 75 AND CAR LOSES ALL POWER AND DIES. THIS TIME THERE WAS A TRUCK BEHIND ME AND HE HAD TO SWERVE INTO THE ONCOMING LANE TO AVOID REAR ENDING ME. I WAS ABLE TO GET OVER BUT NOT OUT OF MY LANE. CAR WAS SHUDDERING AGAIN, WARNING LIGHTS ON INSTRUMENT PANEL. CAR STARTED AFTER 2 TRIES....

FOR THE SECOND TIME MY FORD FUSION'A ELECTRONIC THROTTLE BODY MALFUNCTIONED WHILE IN TRAFFIC. THE CAR WILL NOT ACCELERATE OR MAINTAIN SPEED. DURING BOTH OCCURRENCES THE SUDDEN LOSS OF ENGINE POWER NEARLY CAUSED ME TO BE STRUCK BY OTHER VEHICLES. THE MOST RECENT OCCURRENCE HAPPENED WHILE IN BUSY INTERSTATE HIGHWAY TRAFFIC. THIS ISSUE IS WELL DOCUMENTED AND WELL KNOWN OF BY FORD AND THE NHTSA. THE FIRST TIME THIS HAPPENED THE DEALER WOULD ONLY REPROGRAM THE ECU DESPITE ME ASKING THEM ABOUT THE ETB. THE CAR IS EXTREMELY UNSAFE TO DRIVE AND SHOULD BE RECALLED IMMEDIATELY. THE NHTSA AND FORD ARE FAILING TO MEET THEIR OBLIGATION TO CONSUMER SAFETY BY PUSHING THIS ISSUE ASIDE.

THE VEHICLE STARTS RUNNING ROUGH, STEERING BECOMES LOOSE, THE WRENCH LIGHT COMES ON WITH THE MESSAGE 'CHECK OWNERS MANUAL', THEN THE ENGINE STALLS. THIS HAPPENS WHEN THE CAR IS IN MOTION. IT HAS HAPPENED TWICE AT LOW SPEED ~35 MPH AND ONCE AT HIGH SPEED ~70 MPH. WE HAVE HAD IT IN THE FORD DEALER TWICE. THE FIRST TIME THEY SAID THERE WAS NO CODE SO THEY COULDN'T DO ANYTHING. THE SECOND TIME THEY SAID THEY REPROGRAMMED THE PCM WITH A RECALL 16B32. I WILL DROP IT OFF THIS MORNING FOR THE 3RD TIME.

I HAVE A 2016 FORD FUSION THAT I PURCHASED IN FEBRUARY OF THIS YEAR. IT HAS LOST POWER FOUR TIMES IN THE LAST THREE DAYS THAT I HAVE DRIVEN IT, TWICE IN RUSH HOUR TRAFFIC HEADING TO AND FROM DALLAS FOR WORK. A WRENCH WILL SHOW UP ON THE DASHBOARD, A MESSAGE SAYING "SEE MANUAL" WILL POP UP, AND THE VEHICLE FAILS TO ACCELERATE. I CANNOT PULL THE VEHICLE OVER OUT OF THE WAY OF ONCOMING TRAFFIC BECAUSE IT WILL NOT ACCELERATE AT ALL. I'VE TAKEN THE CAR INTO THE DEALERSHIP TWICE. THE FIRST TIME WAS THIS PAST MONDAY. I WAS TOLD THAT THE VEHICLE NEEDED A SOFTWARE UPDATE AND A NEW THROTTLE BODY AND THAT THE CAR WOULD BE FINE AFTERWARDS. ON MY WAY HOME YESTERDAY, DURING RUSH HOUR TRAFFIC ON A BUSY FOUR LANE HIGHWAY WORK NO SHOULDER TO PULL OFF ON BECAUSE OF CONSTRICTION, MY VEHICLE LOST...

WHILE DRIVING DOWN THE HIGHWAY IN CONGESTED TRAFFIC THE VEHICLE SUDDENLY LOST ALL ENGINE POWER. THE ENGINE AND CAR STARTED SHAKING AND THE ENGINE IDLED BACK AND FORTH BETWEEN 1000 AND 2500 RPM'S. A MESSAGE APPEARED ON THE INFORMATION SCREEN "SEE MANUAL". THE CAR HAD NO ACCELERATION AT ALL AND I HAD TO COAST THROUGH SEVERAL LANES OF TRAFFIC TO THE SHOULDER. ALL ELECTRICAL REMAINED WORKING. JUST NO ENGINE POWER AT ALL. I SHUT THE VEHICLE OFF AND STARTED IT BACK UP, IT STRUGGLED TO START AT FIRST. WHILE DRIVING TO THE FORD DEALERSHIP FOR REPAIRS THE SAME PROBLEM OCCURRED TWICE MORE. DURING NORMAL DRIVING. NO INTENSE ACCELERATION. CRUISING TRAFFIC AT AROUND 65 MPH. IT WAS A VERY DANGEROUS SITUATION TO LOOSE ALL ACCELERATOR POWER IN THE MIDDLE OFT OF A 5 LANE HIGHWAY. I HAD SEVERAL CLOSE CALLS TRYING TO DRIFT ACROSS LANES OF TRAFFIC AS I DID NOT...

THIS IS AN ISSUE THAT HAS GROWN. I HAVE DOCUMENTED PROOF THAT DATES BACK TO MARCH 2016. THIS ISSUE IS AN ESCALATION OF OLD PROBLEM THAT FORD REFUSES TO ACKNOWLEDGE IS AN ISSUE. I SAY THIS BECAUSE THERE IS NO CURRENT RECALL ON THIS ISSUE. ON 9/03/2016, I WAS DRIVING ON WEST GEORGIA RD IN SIMPONVILLE SC WHEN ALL IF A SUDDEN THE CAR JERKED. THEN A WRENCH AND CHECK ENGINE LIGHT CAME ON. I CAR STARTED TO LOSE POWER. LUCKILY, NO CAR WAS TRAILING BEHIND US OR I'M SURE IT WOULD HAVE RAN INTO THE BACK OF US. I SAY THIS BECAUSE MY FOOT WAS ON THE GAS PEDAL SO A CAR BEHIND ME WOULD NOT HAVE KNOWN TO SLOW DOWN TIL TOO LATE. I HAD JUST TAKEN MY CAR TO THE DEALERSHIP THE WEEK BEFOR FOR A SECOND TIME DUE TO CAR STALLING RIGHT AFTER A TAKE OFF...

2016 FORD FUSION, 2.5L ENGINE, 10,500 MILES. WHILE DRIVING STRAIGHT ON A TWO LANE ROAD, CONSTANT SPEED, 55MPH, I EXPERIENCED A SUDDEN LOSS OF POWER FOLLOWED BY THE ENGINE STALLING. ALTHOUGH THERE WERE CARS BEHIND ME I WAS ABLE TO PULL OVER TO THE SHOULDER. THE 'CHECK ENGINE' LIGHT TURNED ON, I CYCLED THE IGNITION AND WAS ABLE TO DRIVE THE VEHICLE ONCE AGAIN, ALTHOUGH THE CHECK ENGINE LIGHT WAS STILL ON. AFTER STOPPING FOR A BRIEF PERIOD, I CONTINUED ON MY JOURNEY HOME ENGINE LIGHT STILL ON. WHEN ACCELERATING ONTO THE EXPRESSWAY INTO RUSH HOUR TRAFFIC, I ONCE AGAIN EXPERIENCED A SUDDEN LOSS OF POWER FOLLOWED BY STALLING OF THE ENGINE. FORTUNATELY I WAS ABLE TO GET THE CAR TO THE RIGHT SHOULDER. I RECYCLED THE IGNITION AGAIN AND IT OCCURRED TO ME THAT I COULD DRIVE THE CAR WITHOUT STALLING ONLY BY PUSHING THE THROTTLE VERY LIGHTLY. I...

MY 18 YEAR OLD DAUGHTER WAS DRIVING THE FUSION ATTEMPTING TO ENTER A HIGHWAY RAMP (ROUTE 22 IN SPRINGFIELD NJ) TO GO DORM SHOPPING FOR SCHOOL. UPON ENTERING THE HIGHWAY AND ACCELERATING ON THE RAMP THE VEHICLE STALLED AND BECAME UNRESPONSIVE TO ACCELERATION WHILE PRESSING DOWN IN THE PEDAL. THE VEHICLE BEHIND HER BEGAN TO ACCELERATE; THE FUSION THEN LOST ALL POWER, THE VEHICLE STUCK HER IN THE REAR AND PUSHED MY DAUGHTERS FUSION INTO AN ACTIVE LANE WITH TRAFFIC TRAVELING AT 55 MPH AND UP. THERE WAS MINOR AESTHETIC DAMAGE TO THE FUSION. BUT THAT IS NOT MY CONCERN IN THE LEAST! THE FUSION WAS STUCK ON AN ACTIVE HIGH SPEED HIGHWAY, MY DAUGHTER COULD OR SHOULD HAVE EASILY BEEN SERIOUSLY INJURED OR KILLED! THIS IS THE DEMARCATION OF A NEAR MISS! THE CHECK ENGINE LIGHT CAME ON WITH THE 'WRENCH ICON' THE VEHICLE HAD TO BE TOWED TO...

TL* THE CONTACT OWNS A 2016 FORD FUSION. WHILE DRIVING APPROXIMATELY 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE FAILED TO ACCELERATE. THE CHECK ENGINE AND AIR BAG WARNING INDICATORS ILLUMINATED CONTINUOUSLY. THE VEHICLE CAME TO A COMPLETE STOP, SHOOK, AND STALLED. THE VEHICLE WAS ABLE TO RESTART. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 9,700.

LOST ALL POWER TO THE VEHICLE WHILE GOING 45 TO 50 MPH. TERRIBLE SITUATION TO BE IN AND WOULD NOT WANT THIS TO HAPPEN TO OTHERS. FORD KNOWS THIS IS AN ISSUE AND NEEDS TO DEAL WITH IT BETTER

TL* THE CONTACT OWNS A 2016 FORD FUSION. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE DECELERATED AND STALLED. THE WRENCH WARNING INDICATOR ILLUMINATED AND THE VEHICLE SHOOK VIOLENTLY. THE CONTACT HAD TO COAST THE VEHICLE TO THE SHOULDER. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY ASSEMBLY FAILED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10,900.

ON A CITY STREET, MY VEHICLE SUDDENLY LOST POWER--ACCELERATOR WOULD NOT WORK. CAR WAS SHUDDERING. WARNING LIGHT SHOWING A WRENCH CAME ON. ANOTHER WARNING LIGHT SHOWING AN ENGINE ALSO CAME. ON. TURNED ENGINE OFF. DROVE A SHORT DISTANCE, THEN THE SAME THING HAPPENED AGAIN. HAD VEHICLE TOWED TO THE FORD DEALER. FORD REPLACED THE THROTTLE BODY & MOTOR ASSEMBLY UNDER WARRANTY.

ON (3) SEPARATE OCCASIONS NOW MY CAR HAS STALLED OUT WHILE DRIVING ON A STREET AND GIVEN ME THE "WRENCH" CHECK OWNERS MANUAL ALERT ON THE DISPLAY. AS I DO ALL I CAN TO GET OUT OF THE LINE OF TRAFFIC AND OFF THE THE SIDE OF THE ROAD, THE CAR SPUTTERS, SHAKES AND STALLS OUT. TURN OFF THE KEY, WAIT A FEW SECONDS, OPEN AND CLOSE THE DOOR (SO ALL ELECTRONICS ARE OFF) AND SOMETIMES THE CHECK ENGINE LIGHT COMES ON WHEN IT STARTS AND IT RUNS FINE. SOME TIMES, IT STARTS AND SHAKES AND SPUTTERS AND STALLS. ON ALL OCCASIONS, I HAVE EVENTUALLY BEEN ABLE TO GET IT TO "LIMP" HOME. THE LAST TIME (3RD TIME) I CALLED FORD ROADSIDE ASSISTANCE AND HAD IT TOWED TO THE DEALER. THE SHOP TOLD ME THIS IS THE 5TH OR 6TH 2016 FORD CAR (FUSION, FIESTA OR FOCUS) THIS MONTH WITH...

MY BRAND NEW FORD FUSION SHUT DOWN ON ME IN THE MIDDLE OF A BUSY HIGHWAY IN ATLANTA! I WAS DRIVING AND ALL OF A SUDDEN IT SLOWED DOWN AND WOULDN'T ALLOW ME TO PRESS THE GAS. THE VEHICLE STARTED SHAKING VERY BADLY AND I HAD TO FIND A WAY TO STEER THE CAR ALL THE WAY OVER TO THE SIDE OF THE HIGHWAY. THIS WAS THE WORSE AND MOST FRIGHTENING EXPERIENCE THAT I HAVE EVER HAD IN MY LIFE! I WAS TOLD THAT THIS PROBLEM WAS DUE TO A THROTTLE BODY ISSUE. I AM VERY DISAPPOINTED WITH FORD.

I WAS ON THE INTERSTATE. ALL OF A SUDDEN A WRENCH AND THE WORDS SEE MANUAL APPEARED. THE CAR WOULD NOT GIVE GAS (SLOWLY CUT OFF), AND CAR STARTED SHAKING. WAITED ABOUT 6 MINUTES AND GOT BACK ON THE ROAD ONLY FOR IT TO CONTINUE TO HAPPEN EVERY FEW MILES. I GOT A DIAGNOSTIC CHECK DONE AND MECHANIC TOLD ME THE CODE SAID IT WAS THE THROTTLE BODY. THE CAR IS FAIRLY NEW WITH A LITTLE OVER 10,000 MILES.

TRAVELING ON INTERSTATE 66 VEHICLE CHECK ENGINE LIGHT CAME ONE AND MESSAGE SAID SEE SERVICE MANUAL. LOST OF SPEED, NO ACCELERATION, AND STALLED OUT. MOVED OVER ON SHOULDER OF INTERSTATE DURING RUSH HOUR. TOWED TO DEALERSHIP. THROTTLE BODY HAD TO BE REPLACED. CAR IS JUST 6 MONTHS OLD BOUGHT IT BRAND NEW. 10,000 MILES ON THE CAR AND THIS PIECE OF EQUIPMENT ALREADY GOES OUT. SEE THIS HAS BEEN AN ISSUE IN THE PAST. NEED TO REOPEN THE INVESTIGATION ON GETTING RID OF THE ELECTRONIC THROTTLE BODY.

THIS CAR HAD APPROX 2400 AT THE TIME OF INCIDENT. MY WIFE AND I WERE DRIVING THE CAR DOWN A STEEP GRADE ON 4/23/16 THE CAR CHIMED 4 0R 5 TIMES . I ASKED MY WIFE IF SHE KNEW WHAT THE SOUND WAS AND SHE SAID NO. ABOUT 5 TO 10 SECONDS LATER I TOLD MY WIFE THAT THE CAR WAS NOT RUNNING. AND I LOOKED AT THE DASH AND IT WAS BLANK. I QUICKLY PUT THE CAR IN NEUTRAL AND STARTED THE CAR. IT TURNED ON. I CONTINUED DRIVING ABOUT 300 MILES AFTER THIS INCIDENT. I BROUGHT THE CAR TO MADISON FORD IN OHIO TO BE LOOKED AT. THEY COULDNT FIND ANY CODES. THEY SENT ME HOME WITH THE CAR. THEY CALLED ME BACK ON TUES AND SAID BRING THE CAR BACK . THIS TIME THEY FOUND 6 CODES. BUT TO MY KNOWLEDGE NOTHING STATING THE PROBLEM. THEY DROVE...

LAST WEEK MY CAR ENGINE WOULD SHUT OFF WITHOUT WARNING WHEN I WAS AT A STOP LIGHT AND IDLE ABOUT TO TURN ONTO ROAD. THIS HAPPENED TWICE SO I TOOK MY CAR WHERE I PURCHASED AT RYAN FORD SEALY AND THEY HAD IT 4/6-12/2016. THEY COULDN'T FIND ANYTHING BECAUSE NO CODES OR LIGHT CAME UP. RAN VEHICLE HEALTH CHECK AND NOTHING. ACTED FINE YESTERDAY. TODAY GOING RIGHT UNDER 30 MPG AND AT THE STOP SIGN IT SHOOK BAD AND LIGHTS CAME ON. ENGINE STAYED ON BUT COULD NOT MOVE. WAITED 15 MINUTES AND LIMPED TO MY HOUSE AND HAD TOW TRUCK TAKE IT BACK TO RYAN FORD. DETERMINED AND REPLACED THROTTLE BODY.

2016 FORD FUSION RECEIVED FROM DEALER ON DEC 2015. AT 39 MILES ON THE ODOMETER, FUSION WOULD NOT START, AND ALL ALARMS CAME ON (LOW TIRE PRESSURE, ENGINE OVERHEAT, PARKING BRAKE, PARKING SENSORS, ETC). CAR STARTED AFTER HITTING OK AND SEVERAL MORE CRANKS. FEB 2015 - AT ABOUT 2500 MILES, THE CAR WOULD NOT START FOR THE SECOND TIME, AND THE THIRD TIME WAS AT 3000 MILES, ALL WITH THE SAME EXACT ALARM BEHAVIOR. THE FOURTH TIME OCCURRED ON MARCH 7, 2016 WITH 3200 MILES ON ODOMETER; THE CAR DIED IN THE MIDDLE OF THE HIGHWAY AND WHILE GOING 45MPH IN RUSH HOUR TRAFFIC. THERE WAS NO ENGINE POWER, NO STEERING POWER, NO POWER BRAKES, NOTHING BUT ALARMS. I WAS FORTUNATE TO NOT BE IN AN ACCIDENT. THE FORD DEALERSHIP HAS TAKEN THE CAR IN TWICE WITH ABSOLUTELY NO REPAIRS AND NO REPORTED DIAGNOSTIC CODES. FORD HAS EXPERIENCED THE SAME...