2004 FORD EXPLORER Structurebodyhatchbackliftgatehinge And Attachments Problems

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT AFTER OPENING THE REAR GLASS LIFT GATE WINDOW, THE TWO PLASTIC HINGES ATTACHED TO THE WINDOW FRACTURED CAUSING THE WINDOW TO FALL AND SEPARATE FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 141,500.

UPON OPENING THE REAR GLASS HATCH, THE PASSENGER SIDE OF THE HINGE BROKE WHEN FULLY OPEN AND THE WINDOW FELL DOWN, HITTING ME IN THE HEAD. THE PANEL BELOW ON THIS SAME WINDOW TO THE LEFT OF THE FORD LOGO PLATE HAD ALSO CRACKED ABOUT 6 MONTHS AGO. *TR

MY CAR WAS PARKED OUTSIDE OF THE GROCERY STORE. I OPENED THE REAR HATCH TO LOAD MY GROCERIES. AS I REACHED UP TO CLOSE THE HATCH THE RIGHT SIDE OF IT COLLAPSED AND FELL RIGHT ON MY HEAD LEAVING A LARGE LUMP. UPON INVESTIGATION I FOUND THAT THE HINGE ON THE RIGHT SIDE OF THE HATCH HAD SNAPPED AND THE WEIGHT OF THE HATCH HAS TWISTED THE HINGE ON THE LEFT SIDE. LUCKILY, I BROKE THE FALL OF THE HATCH OR THERE WOULD HAVE BEEN SHATTERED GLASS EVERYWHERE. DEFINITELY A SAFETY ISSUE. *TR

REAR LIFT GATE HINGES CRACKING AT PIN CAUSING REAR GATE GLASS TO SHIFT DOWN AND TAILGATE NOT TO LATCH CORRECTLY. *TR

THE RIGHT HINGE ON THE REAR WINDOW LIFT GATE IS CORRODED AND AS A RESULT IS HALF BROKEN OFF. THE WINDOW RATTLES DUE TO IT BEING LOOSE. THE LEFT HINGE IS NOW STARTING TO DO THE EXACT SAME THING. THERE HAVE BEEN TIMES WHEN I TURN THE VEHICLE ON AND THE MESSAGE CENTER WILL INDICATE 'REAR LIFTGATE AJAR' AND IT IS THE WINDOW HATCH THAT IS AJAR. I FEEL THIS ISSUE W/THE HINGE WILL AJAR FROM THE LATCH. I CALLED A LOCAL DEALERSHIP TO SEE IF THIS WAS A RECALL AND HE STATED NOT ON MY SPECIFIC VEHICLE AFTER GIVING HIM MY VIN. I FEEL THIS IS A HUGE SAFETY ISSUE. I REFRAIN USE OF THE WINDOW IN THE FEAR IT WILL FALL ON ME. NOW MY FEAR IS THE WINDOW WILL FALL COMPLETELY OFF WHILE DRIVING.

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFTGATE HATCHBACK HINGE WAS CORRODED AND CRACKED, CAUSING THE GLASS TO SEPARATE FROM THE FRAME. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V442000 (RECASTRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

OUR 2004 FORD EXPLORER - MY SON OPENED THE LIFTGATE AND THE RIGHT HINGE SNAPPED LEAVING THE WINDOW DANGLING IN MY 10 YR OLDS FACE. AFTER MUCH READING ONLINE, WE HAVE DISCOVERED THAT THE REAR WINDOW LIFT GATE GLASS HINGE HAS BEEN A PROBLEM FOR MANY FORD OWNERS. THE RUSTED OUT PLASTIC PIECES ARE SNAPPING OFF AND ALLOWING THE GLASS TO FALL FROM THE HINGE. I WAS ABLE TO RUSH TO THE BACK OF THE CAR TO GRAB THE GLASS BEFORE IT FELL. MY ENTIRE RIGHT SIDE IS SORE FROM TRYING TO HOLD THE GLASS AND TRYING TO SHUT THE WINDOW LIFT GATE SO I COULD GET THE CAR HOME. WITH ONE ADULT AND THREE KIDS, I WAS STUCK TRYING TO FIGURE OUT HOW & WHAT TO DO WITH THIS WINDOW DANGLING. WE ARE SHOCKED THAT FORD HAS YET TO RECALL THE 2004 MODELS BUT HAS RECALLED PREVIOUS YEARS. THIS...

UPON OPENING THE REAR LIFT GATE, THE HINGES COMPLETELY GAVE OUT AND THE LIFT GATE FELL AWAY FROM THE TRUCK. I WAS FORTUNATE IN THAT I WAS ABLE TO CATCH AND HOLD IT, AS MY 5 YEAR OLD SON WAS STANDING BENEATH IN ORDER TO HAND ME HIS BEACH TOYS, AT THE TIME OF THE INCIDENT. I HAD TO HOLD THE (VERY HEAVY) LIFT GATE UNTIL A MECHANIC ARRIVED TO DETACH ELECTRICAL COMPONENTS AND PLACED THE LIFT GATE INSIDE THE 2004 FORD EXPLORER. I THEN HAD TO DRIVE HOME WITH NO LIFT GATE WHILE EXHAUST FUMES FILLED THE TRUCK. IT SHOULD BE NOTED THAT PRIOR TO THIS INCIDENT, THE TAILGATE CRACKED, WHICH I SEE IS A COMMON ISSUE WITH THIS PARTICULAR VEHICLE AND THE SUBJECT OF A CLASS ACTION LAWSUIT. *TR

THE LEFT (DRIVER SIDE) REAR LIFT GATE HINGE BROKE MAKING THE REAR LIFT GATE AND WINDOW UNUSABLE. THIS OCCURRED WHEN I WAS GOING TO CLOSE THE DOOR, THANKFULLY IT WAS ONLY THE WINDOW SECTION THAT WAS BEING CLOSED AS I'M SURE THE DOOR ITSELF IS PRETTY HEAVY. *TR

I WAS DRIVING DOWN THE STREET AND HEARD A NOISE. WE TURNED AROUND AND THE LIFTGATE HAD FALLEN OFF ITS ON HINGES AND WAS HANGING LOOSE ON BOTH SIDES. WE HAD TO HOLD IT ON AND DRIVE THE CAR BACK HOME. THE CAR HAS NOT BEEN DRIVEN SINCE THAT DATE IN 2010. FORD NEEDS TO BE RESPONSIBLE FOR THE 2004 MODEL AND ALL OF ITS DEFECTIVE PRODUCTS. THIS IS THE SECOND COMPLAINT THAT I HAVE FILED AGAINST FORD CONCERNING THIS CAR. THE FIRST WAS A #2 VALVE FALLING IN THE ENGINE AND CAUSING THE ENGINE TO BLOW UP. NHTSA PLEASE DO SOMETHING ABOUT FORD. SOMEONE HAS TO MAKE CAR MANUFACTURERS RESPONSIBLE TO THE CONSUMER. EVERY TIME THAT NHTSA IS CONTACTED NOTHING IS DONE UNTIL MILLIONS ARE NEGATIVELY AFFECTED. *TR

THE REAR LIFT GLASS HINGES ON MY 2004 FORD EXPLORER BROKE DURING USE OF THE LIFT GLASS. THE PIN BROKE RIGHT THROUGH THE HINGE ON BOTH SIDES. THIS HAPPENED WHILE CAR WAS PARKED AND LIFT GATE WINDOW WAS OPEN. LEFT SIDE JUST FELL, AND THEN RIGHT ABOUT 1 MINUTE LATER, I JUST HAPPENED TO HAVE SOME 2X4'S IN THE BACK WHICH PREVENTED THE WINDOW FROM FALLING TO THE GROUND. THIS SEEMS LIKE A PRETTY DANGEROUS DEFECT. INTERNET RESEARCH HAS REVEALED THIS ISSUE WAS CAUSE FOR A RECALL ON THE '02 & '03 EXPLORER AND SEEMS TO BE WIDE SPREAD ON THE '04, YET NO RECALL FOR THE '04. *KB

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE HINGE ON THE REAR LIFT GATE WINDOW SEPARATED FROM THE VEHICLE AND THE GLASS SHATTERED ON THE GROUND. ONE PERSON WAS INJURED AS A RESULT. AN AUTHORIZED DEALER WAS NOTIFIED, BUT DID NOT OFFER ANY ASSISTANCE. THE MANUFACTRER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 129,990 AND THE CURRENT MILEAGE WAS 130,000.

THE LIFTGATE GLASS HINGE ON MY 2004 FORD EXPLORER (MODEL EXXLTSPNBX) BROKE WHILE CLOSING. THERE IS ONLY ONE BOLT HOLDING EACH OF THE TWO HINGES ONTO THE GLASS AND THE BOLT BROKE ON ONE OF THE HINGES. FORTUNATELY, I HELD THE GLASS AS TO NOT SLIP DOWN AND PULL THE OTHER HINGE CAUSING IT TO BREAK. THE WINDOW LIFT DID HOLD IT BUT WOULD NOT SLIDE BACK UP. THE LIFT HAD TO BE REMOVED IN ORDER TO SHUT AND LATCH THE WINDOW DOOR. THE BACK PANEL BELOW THE WINDOW WAS CRACKED WHEN I BOUGHT THE CAR AND THIS MAY HAVE LEAD TO SHIFTING IN THE WINDOW AND ADDITIONAL STRESS ADDED TO THE BOLT IN THE HINGE. THIS IS THE SAME PROBLEM THAT OCCURRED IN THE 2002 AND 2003 HATCH WINDOW HINGES. THERE ARE MANY EXAMPLES ONLINE OF THE BOLT BREAKING IN THE 2004 MODELS BUT A RECALL HAS NOT BEEN...

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HINGE LIFTGATE WAS FRACTURED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V44200(STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS)BUT THE DEALER INFORMED THE CONTACT THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE YET THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 76,000 AND THE FAILURE MILEAGE WAS 76,000.MANUFACTURED NEAR THE CUTOFF DATE OF MENTIONED CAMPAIGN. SAME EXACT PROBLEM. PAID FOR REPLACEMENT HINGES. REPLACED MYSELF. UPDATED 09/14/2011 *LN UPDATED 12/13/11

I HAVE HAD MY 2004 FORD EXPLORER FOR 3 YEARS NOW. TODAY I WENT TO OPEN MY REAR HATCH AND THE WINDOW HINGES JUST BROKE. NOW MY WINDOW IS HANGING THEREAND I DON'T KNOW HOW I AM GOING TO GET THEM FIXED SINCE I DON'T HAVE ANY EXTRA MONEY. I THINK THIS SHOULD BE A RECALL SINCE THERE HAS BEEN A LOT OF COMPLAINTS ABOUT THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFTGATE GLASS HINGE WAS FRACTURING FROM THE VEHICLE. THE DEALER INFORMED THE CONTACT THAT THE HINGE WOULD NEED REPLACING AND THERE WERE NO RECALLS FOR THE VEHICLE. ANY REPAIR TO THE VEHICLE WOULD BE AT THE CONTACTS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 150,100.

2004 EXPLORER WITH 110K MILES - DEVELOPED CRACK IN LIFTGATE PANEL APP DEC 2008. FORD COVERED 80% OF REPAIR COST OF $750 SINCE VEHICLE WAS UNDER 75K MILES, EVEN THOUGH AN OBVIOUS DESIGN FLAW. SEPT 29, 2010 REAR HATCH WINDOW HINGE BREAKS CAUSING DOOR TO FALL ONTO MY HANDS AND LEGS...SORE BUT NOT PERMANENT. TWO CO-WORKERS HAD TO HELP ME RAISE IT UP ENOUGH TO LOCK IT IN PLACE. DEALER REPAIRED FOR $65 PARTS IN $170 LABOR. DANGEROUS AND UNSAFE. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT ATTEMPTED TO CLOSE THE REAR LIFT GATE WINDOW AND THE HINGES FRACTURED CAUSING THE GLASS TO FALL AND SHATTER OVER HER HEAD. SHE SUFFERED MINOR INJURIES AS A RESULT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS AWAITING A DIAGNOSIS OF THE FAILURE AND REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED, SHE OPENED THE REAR GLASS WINDOW LOCATED ON THE LIFT GATE. THE WINDOW WAS OPEN FOR A FEW MOMENTS UNTIL ONE OF THE TWO HINGES BROKE RESULTING IN THE WINDOW HANGING BY ONE HINGE. UPON EXAMINING THE BROKEN HINGE SHE NOTICED THAT THE SCREW HOLDING THE HINGE IN PLACE ALSO BROKE IN HALF. THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. SHE ALSO STATED THAT THE VEHICLE HESITATED TO SHIFT INTO REVERSE AND WOULD LUNGE FORWARD BEFORE MOVING IN REVERSE. WHEN SHIFTING FROM REVERSE TO DRIVE, THE FAILURE RECURRED AND SHE HEARD A POPPING NOISE WHEN THE VEHICLE FINALLY SHIFTS INTO GEAR. THE FAILURES HAVE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE FAILURE...

2004 FORD EXPLORER LIFT GATE GLASS FELL OFF AFTER UPPER LEFT HAND HINGE SNAPPED. SECONDARY FAILURE OF LEFT HAND GAS SHOCK SHEARING NEAR MOUNTING BOSS ON GATE. *TR 1) THE GLASS LIFT GATE WAS GETTING HARDER TO CLOSE. I BELIEVE CORROSION LOOSENED THE HINGE JOINT TO THE GLASS. 2) THE FAILURE WAS IMMEDIATE AND WITHOUT WARNING. THE BACK GATE CAME CRASHING DOWN AND THE RIGHT HAND SIDE CAME FLYING UP. 3) SHORT TERM FIX - VISQUEEN AND DUCT TAPE. LONG TERM FIX - WILL BE TO DISASSEMBLE AND REPLACE THE HINGE/SHOCK ASSEMBLY.

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE SITTING IDLE, THE CONTACT PRESSED THE PASSENGER REAR WINDOW RELEASE BUTTON AND THE HINGE FRACTURED FROM THE VEHICLE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE HAD NOT YET BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 74,800. UPDATED 06/03/10*BF UPDATED 06/07/10.*JB

2004 FORD EXPLORER RIGHT REAR LIFTGATE HINGE PIN HAS CORROSION CAUSING THE HINGE TO BREAK LOOSE FROM THE GLASS. WHEN OPENING THE WINDOW IT BROKE AND FELL ON MY HUSBAND WHILE LOADING CARGO. THE RIGHT SIDE SHOCK (STRUT) HAS SEEMED TO GET STUCK AT TIMES MAKING IT HARD TO CLOSE THE HATCH. *TR

I HAVE A 2004 FORD EXPLORER XLT AND I WAS CLOSING THE REAR HATCH WHEN THE HINGE PINS SNAPPED AND LUCKILY I WAS HOLDING IT WHEN IT BROKE. IF THERE WAS A PROBLEM WITH OTHER VEHICLES THEN I THINK THERE SHOULD BE A RECALL ON ALL 2004S. *TR

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE MANUALLY OPENING THE REAR LIFT-GATE, IT SPONTANEOUSLY CLOSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION, AND THE LIFT-GATE HINGE KIT WAS ORDERED FOR THE REPAIR, BECAUSE THE LIFT-GATE HINGE HAD FRACTURED. THE FAILURE MILEAGE WAS 69,400. THE CURRENT MILEAGE WAS 69,450.

1. THE EVENTS LEADING TO THE FAILURE WERE NORMAL USE OF THE VEHICLE. 2. REAR LIFT-GATE HINGES ON 2004 FORD EXPLORER XLT BEGAN FAILING WITH A LOUD BANG FROM THE REAR OF THE VEHICLE. THE REAR WINDOW BEGAN TO SAG AND OVER THE COURSE OF SEVERAL MONTHS CRACKS APPEARED IN THE HINGE STRUCTURE. I HAVE PURCHASED NEW HINGES, BUT AT THIS TIME I STILL NEED TO INSTALL THEM. *TR

THE REAR LIFT GLASS HINGES ON OUR 2004 FORD EXPLORER BROKE DURING USE OF THE LIFT GLASS. THE PIN BROKE RIGHT THROUGH THE HINGE. THIS IS A VEHICLE THAT HAS BEEN PARKED IN A GARAGE WITH ONLY MINIMAL USE OF THE ACTUAL LIFT GLASS. WE ARE NOW SEARCHING JUNK YARDS FOR REPLACEMENT HINGES BUT ASSUME THESE WILL ALSO BE BAD. *TR

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE LIFTGATE GLASS STRUT BECAME DISENGAGED FROM THE HINGE, WHICH ALLOWED THE GLASS TO LOOSEN. THE GLASS APPEARS THAT IT COULD FALL OUT AT ANY MOMENT WHILE DRIVING VARIOUS SPEEDS. THE CONTACT FOUND RECALLS ON THE 2002 AND 2003 EXPLORERS, BUT NOT FOR 2004. THE DEALER STATED THAT THERE WERE NO RECALLS FOR HER VEHICLE AND IT COULD NOT BE REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS). THE FAILURE MILEAGE WAS 90,000.

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE GLASS ON THE HINGE OF THE REAR WINDSHIELD WOULD GLIDE UP AND DOWN, AS IF IT WERE NOT SECURED OR MOLDED PROPERLY. THE MANUFACTURER STATED THAT THE ENTIRE HATCH NEEDED TO BE REPLACED IN ORDER TO CORRECT THE FAILURE AT AN ESTIMATED COST OF $1,200. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 40,000. UPDATED 12/30/08 *CN UPDATED 12/30/08. *JB

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE ATTEMPTING TO SHUT THE REAR GLASS ON THE LIFTGATE, THE HINGES FAILED AND PREVENTED THE GLASS FROM CLOSING. THE HINGES WERE BENT BACK INTO PLACE IN ORDER FOR THE LIFTGATE GLASS TO CLOSE, BUT CURRENTLY IT CANNOT BE USED AT ALL. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER FOR REPAIR. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 91,000.

THE REAR HINGES ON MY 2004 FORD EXPLORER ARE FAULTY, THEY CRACKED AND ARE BARELY HOLDING MY GLASS WINDOW UP. FOR FORD, THIS IS NOT A NEW ISSUE; THE 2003, 2002, AND 2007 MODELS HAVE A RECALL ON THIS ISSUE. FORD WILL NOT RECALL THE 2004 MODELS THAT HAVE THE SAME ISSUE. THIS IS COSTLY AND IS DANGEROUS. WHILE DRIVING, THE HATCH COULD POSSIBLY CAUSING THE GLASS TO BREAK. *TR

I HAVE 2 ISSUES THAT I WOULD LIKE ADDRESSED. 1. I BELIEVE THAT I HAVE AN ELECTRICAL SHORT OR SOMETHING BECAUSE MY RADIO KEEPS GOING OUT ON THE DRIVERS SIDE. THIS HAS BEEN HAPPENING FOR ABOUT A YEAR OR SO NOW. NOT SURE HOW TO GO ABOUT CORRECTING THE ISSUE BECAUSE I DON'T KNOW IF IT IS COVERED UNDER WARRANTY OR NOT. 2. MY HATCHBACK HAS A CRACK IN IT AND I AM WONDERING IF IT IS ON RECALL TO BE REPLACED SINCE I SEE ALOT OF THE SAME CRACK ON OTHER EXPLORERS. *TR

THE BACK GLASS HINGES ON 2004 EXPLORER BROKE CAUSING THE GLASS TO COME OFF MY VEHICLE. LUCKILY I CAUGHT IT AND HAD MY HUSBAND COME UNDO ALL THE PIECES SO NOTHING ELSE WAS BROKEN. *TR

2004 FORD EXPLORER WAS PARKED IN MY DRIVEWAY AND, AFTER OPENING THE LIFTGATE AND ATTEMPTING TO CLOSE IT, THE RIGHT HAND HINGE FRACTURED AND LANDED ON MY HAND. LUCKILY MY HUSBAND WAS RIGHT BESIDE ME AND HE WAS ABLE TO LIFT IT AND THERE WAS NO INJURY TO MY HAND. THE LEFT HAND HINGE WAS FRACTURED ON ONE SIDE AND WE HAD TO REMOVE THE HYDRAULIC ARMS TO CLOSE THE LIFTGATE AND DUCT TAPE IT CLOSED. AFTER READING ONLINE THAT THE 2002/2003 EXPLORERS HAD BEEN RECALLED I HOPED THEY WOULD ALSO INCLUDE THE 2004 MODELS. I CHECKED WITH THE DEALERSHIP AND IT WAS NOT COVERED. MY TRUCK WAS MANUFACTURED IN MARCH 2004 AND THERE IS A GOOD CHANCE THAT 2003 PARTS WERE USED SO FORD SHOULD STAND BY THEIR PRODUCT AND HONOR THE RECALL FOR THE 2004 MODELS. THIS IS A MAJOR SAFETY ISSUE AND I WAS LUCKY THAT THIS...

THE REAR HINGES ON MY 2004 FORD EXPLORER FELL APART AND THE WINDOW FELL OFF. THIS SAME ISSUE WAS RECALLED FOR 2002 AND 2003 FORD EXPLORERS BUT FORD WOULD NOT HONOR THE RECALL FOR MY 2004 VEHICLE USING THE SAME DEFECTIVE HINGES. *TR

I WAS DRIVING AND JUST ENTERED THE EXPRESSWAY WHEN I GOT TO THE BOTTOM OF THE RAMP MY BACK WINDOW ON MY TRUNK RAISED UP AND HALFWAY FELL OFF AND WHEN I GOT OUT TO LOOK AT THE DAMAGE. THE PASSENGER SIDE HINGE IS VERY LOOSE AND THE DRIVER SIDE HINGE COMPLETELY BROKE OFF AND THE SUSPENSION SHOCK THAT OPENS AND CLOSES THAT WINDOW. I WAS TERRIFIED WHEN THIS HAPPENED AND I PANICKED AND LUCKILY I WAS ALREADY SO CLOSE TO THE EXIT RAMP. I CALLED FORD AND WAS TOLD HOW MUCH THE PARTS WERE AND HOW MUCH LABOR IS BUT THE SERVICE PERSON MENTIONED THAT HE HAS HAD ALOT OF PEOPLE COMPLAIN ABOUT THAT SHOCK THAT OPENS AND CLOSES THE WINDOW. I AM WAITING FOR MY PARTS TO COME IN NOW. *TR

1. OPENED REAR HATCH GLASS ON 2004 FORD EXPLORER. 2. HINGES FAILED ON GLASS HATCH DISCONNECTED FROM BODY. 3. THIS JUST HAPPENED. HAVE TO BUY REPLACEMENT HINGES. *TR

THE REAR WINDOW LIFTGATE HINGES ON MY 2004 FORD EXPLORER FAILED. HINGE PINS ARE CORRODED AND JUST SHEARED RIGHT OFF. LOOKS LIKE THE HINGES BECOME LOOSE AND GO SLIGHTLY OUT OF ALIGNMENT AND WHEN HATCH IS OPENED THE PINS BREAK. APPEARS THERE WAS A RECALL FOR THIS SAME PROBLEM FOR THE YEARS PRIOR TO MY MODEL YEAR. FROM THE REVIEW OF THIS WEBSITE DOES NOT LOOK LIKE FORD HAS SOLVED THE HINGE PROBLEMS. THE EARLIER RECALL WAS # 04V442000. CAN THE RECALL BE EXTENDED TO COVER THE 2004 (AND MAYBE LATER YEARS)? *TR

MY FORD EXPLORER HAS A TWO PART REAR LIFT GATE. THE MAIN LIFTGATE WORKS FINE, HOWEVER, THE SMALLER GLASS LIFT GATE "COLLAPSED" WHEN I WAS OPENING IT. IT IS A HINGED LIFT GATE WITH HINGES THAT ATTACH TO THE GLASS. ONE OF THE HINGES FAILED AND THE GLASS DOOR COLLAPSED (HITTING ME ON THE HEAD AND CUTTING MY HAND). THE HINGE THAT BROKE LOOKS AS IF IT MAY HAVE CRACKED RIGHT WHERE THE RETAINING PIN IS LOCATED SECURING THE GLASS DOOR TO THE HINGE ATTACHED TO THE BODY. THE HINGE APPEARS TO BE MADE OF A CAST IRON OR "POT METAL", WHICH COULD BE SUBJECT TO BREAKING OR CRACKING. WHEN IT BROKE IT ALSO CAUSED THE OTHER HINGE TO COME DISCONNECTED. THE DOOR IS JUST "HANGING" BY THE DOOR SHOCKS. THE AUTO IS A 2004 FORD EXPLORER. I AM TAKING IT IN TO HAVE IT REPAIRED, BUT WANTED TO FILE...

MY WIFE AND I NOTICED A CRACK UNDER THE REAR WINDOW, (1/8 BY 6") TO THE LEFT OF THE FORD EMBLEM IN THE CENTER OF THE REAR HATCH.. THERE WAS NO IMPACT INVOLVED, IT JUST APPEARED OVERNIGHT. LATER THE REAR WINDOW WAS RAISED AND THE HINGE ON THE LEFT SIDE IS LOOSE, AND CANNOT BE TIGHTENED. NOW WE CAN'T CLOSE THE THE REAR WINDOW ALL THE WAY. WHEN IS SOMETHING GOING TO BE DONE ABOUT THIS ONGOING PROBLEM WITH THE 2004 EXPLORERS? FORD IS VERY AWARE OF THIS PROBLEM AND AND THEY COULD CARE LESS. I COULD HAVE TAKEN OUR EXPLORER TO A KIA DEALER INSTEAD OF A FORD DEALER AND RECEIVED THE SAME TYPE OF SERVICE..NO HELP AT ALL. IT SEEMS THAT FORD DOESN'T CARE ABOUT QUALITY ANYMORE AND ONLY ABOUT THE MIGHTY DOLLAR, NO MATTER HOW THEY GET IT! *TR

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. THE GLASS ON THE REAR HATCH DOOR HAS CRACKED AND THE CONTACT FEELS THAT IT MAY SHATTER AT ANY MOMENT WHILE DRIVING. THE DEALER STATED THAT IT IS NOT A DEFECT AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 49,000.

THE REAR WINDOW LIFTGATE HINGE ON MY 2004 FORD EXPLORER FRACTURED. THIS WAS OBVIOUSLY A DEFECTIVE HINGE IN THAT IT SHOULDN'T HAVE WORN OUT LIKE IT DID. I HAD TO BRING IT TO THE DEALER WHO REPLACED BOTH HINGES FOR APPROX $165. THEY TOLD ME THERE WAS A RECALL FOR THIS SAME PROBLEM FOR THE YEARS PRIOR TO MY MODEL YEAR. THEY ALSO SAID THAT THE HINGE WAS THE SAME TYPE THAT WAS FAILING IN THE PRIOR MODEL YEARS. I AM FILING THIS COMPLAINT IN ORDER TO HAVE ANY OF THIS TYPE OF HINGE THAT WAS USED TO BE INCLUDED IN THE RECALL. THE RECALL WAS # 04V442000. *TR

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE USING THE REMOTE TO OPEN THE REAR WINDOW, THE GLASS HINGE FAILED AND CAUSED THE WINDOW TO FALL FROM THE WINDOW FRAME. THE CONTACT NOTIFIED THE DEALER AND MANUFACTURER AND THEY STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01I010000 (VISIBILITY:GLASS, SIDE/REAR). THE WINDOW HAS YET TO BE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 33,500 UPDATED 01/02/08. UPDATED 01/02/08.*LJ

FORD EXPLORER 2004, BACK TAILGATE WINDOW FELL OFF VEHICLE. THERE WAS A RECALL FOR THE 2003, FORD REFUSES TO PAY FOR REPAIR, CLAIMING THAT THEY HAVEN'T HAD ENOUGH COMPLAINTS TO WARRANT AN ADDITIONAL RECALL. THIS BACK WINDSHIELD FELL OFF THE VEHICLE INTO MY HUSBANDS HANDS. THANK GOD MY CHILDREN WEREN'T THE IN THE WAY OR INJURED. THIS RECALL OF THE 2003, TO PLACE ON SEPTEMBER 13,2004, WELL AFTER MY VEHICLE WAS MADE AND PURCHASED. I FEAR FOR THE OWNERS OF THIS $35,000.00 VEHICLE, AND WHAT MAY HAPPEN WHILE FORD DRAGS THEIR FEET WITH THIS RECALL. I IS SOMEWHAT APPARENT THAT THE SAME HINGES WERE USED ON THIS VEHICLE AS THE 2003. PLEASE LET THE PUBLIC KNOW. THANKS. *JB

THE HINGES ON THE LIFT GATE WINDOW ON MY 2004 FORD EXPLORER BROKE CAUSING THE REAR WINDOW TO FALL OUT OF THE WINDOW FRAME. FORD MOTOR COMPANY TOLD ME THAT THERE IS A RECALL FOR THE PROBLEM ON THE 2002 AND 2003 MODELS BUT WERE NOT "AWARE" OF ANY SIMILAR PROBLEMS WITH THE 2004 MODEL. *TR

I OWN A 2004 FORD EXPLORER 4 DOOR. ON JULY 5, 2007 WHILE CLOSING THE WINDOW PORTION OF THE BACK HATCH THE GLASS CAME LOOSE FROM THE HINGES. I TOOK THE VEHICLE TO GULLO-HASS FORD IN CONROE TEXAS TO HAVE THEM REPAIR IT, AND I WAS TOLD THAT THE HINGES AND BACK WINDOW SECTION WERE THE SUBJECT OF A TECHNICAL SERVICE BULLETIN. IT WAS APPARENT THAT FORD WAS AWARE OF A POTENTIAL PROBLEM WITH THE BACK HATCH WINDOW AND THE HINGES, SINCE ,IT SENT OUT A TSB ADVISING ITS SERVICE PERSONNEL ON THE BEST WAY TO FIX THE PROBLEM. *AK RESEARCH SHOWED THAT THE TSB WAS ISSUED ON 1/1/05. FORD WAS AWARE OF THIS PROBLEM AND THE QUICKEST WAY TO FIX IT WHILE MY VEHICLE WAS STILL UNDER WARRANTY. FORD FAILED TO ADVISE ME AS AN OWNER THAT THERE WAS A POTENTIAL PROBLEM WITH THE REAR WINDOW HATCH AREA. THIS...

ON JUNE 21, 2007 I USED THE KEYLESS ENTRY REMOTE TO OPEN THE REAR WINDOW OF THE 2004 FORD EXPLORER FOR MY 11 OLD DAUGHTER TO PUT MY SON'S BABY BAG IN THE BACK. WHEN THE GLASS OPENED THE DRIVER'S SIDE HINGE FATIGUED AND BROKE, TWISTING THE GLASS HARD ENOUGH TO CAUSE A DENT IN THE WINDOW RECESS AND FALLING ON MY DAUGHTER'S HEAD, BENDING BOTH STRUTS. AFTER INVESTIGATING OTHER MODELS I DISCOVERED THAT MODEL YEARS UP TO 2003 WERE COVERED UNDER A RECALL ,BUT THE 2004 WAS NOT. I CONTACTED FORD MOTOR COMPANY AND EXPLAINED THE SITUATION ,AND THEY WERE ABSOLUTELY NO HELP, TELLING ME THAT THE VEHICLE WAS NOT COVERED UNDER ANY WARRANTY AT THE TIME. THE VEHICLE HAS 72,000 MILES ON IT. THE LOCAL DEALERSHIP WAS NOT MUCH MORE HELP, REPLACING MY HINGES WITH THE 2003 RECALL PACKAGE AND INFORMING ME THAT 33% OF THE TIME WHEN...

ON JUNE 4 2007, I OPENED THE HATCH ON MY 2004 FORD EXPLORER XLT. WHEN I SHUT THE HATCH, THE WHOLE ASSEMBLY FELL AND THE GLASS HATCH SHATTERED SHOWERING ME AND THE EXPLORER AND THE GARAGE WITH THOUSANDS OF SHARDS. I SUSTAINED SOME SMALL CUTS ON MY FACE. I WAS LUCKY THAT MY SON WAS ALREADY IN THE CARSEAT AND NOT OUTSIDE BY THE SUVLIKE HE USUALLY DOES. OTHERWISE HE WOULD HAVE BEEN HURT BY THE THOUSANDS OF GLASS SHARDS. LATER, I NOTED THAT THE HINGE ON WHICH THE HATCH WAS SUSPENDED, THE ONE SIDE BROKE OFF CAUSING THE WHOLE HATCH ASSEMBLY TO FALL AND THE GLASS TO SHATTER.I WAS ALSO LUCKY I WAS WEARING MY SUNGLASSES(WHICH BROKE). I NOTICED THAT THE METAL PART ON WHICH THE HATCH WAS HUNG WAS PUT ON COCKEYED WHICH PROBABLY CAUSED THE PROBLEM. HATCHES ARE MEANT TO BE OPENED AND CLOSED AND THE WHOLE...

TL*- THE CONTACT STATED THAT THE BACK OF THE HATCH OF THE 2004 FORD EXPLORER WITH 74050 FAILURE MILEAGE WAS CRACKED. THE CONTACT WAS CONCERNED THAT THE HATCHBACK GLASS COULD FALL OUT AND INJURE HER CHILDREN. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER, BUT THEY HAVE BEEN CONTACTED AND WERE AWARE OF THE PROBLEM. THE CURRENT MILEAGE WAS 75,000.*AK

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE OPENING THE REAR GLASS HATCH THE CONTACT HEARD THE GLASS CRACK ,AND NOTICED THAT THE HINGE CAME LOOSE ON THE RIGHT HAND SIDE OF THE HATCH. THE CONTACT CAN PROVIDE PICTURES. THE CURRENT AND FAILURE MILEAGE WAS 51,283. *AK

WE HAVE EXPERIENCED MULTIPLE PROBLEMS WITH THE ELECTRICAL SYSTEMS OF OUR 2004 FORD EXPLORER ALONG WITH OTHER MISCELLANEOUS PROBLEMS. THE ELECTRICAL PROBLEMS HAVE NOT BEEN CORRECTED TO DATE. IN NOVEMBER 2006, THE REAR WINDOW OF THE LIFTGATE BROKE OFF THE HINGE. WE WERE TOLD THERE WERE NO RECALLS FOR THIS PROBLEM AND HAD TO PAY FOR THIS REPAIR OUT OF OUR POCKET. TODAY, JANUARY 16, 2007 THE FRAME OF THE REAR LIFTGATE CRACKED IN THE MIDDLE. *NNM