2020 FORD ESCAPE Power Train Problems

Turbo failed due to oil lines clogged. Failed again after repair two weeks later on highway almost causing a collision.

I have had 22 recalls to date on this vehicle and received 1 recall notice. Engine light comes on alot, makes noises and then goes away after a couple days. Windshield washer stopped working on front windshield, now back stopped working. Tire pressure monitor & sensor default stays on (previous recall) Window on driver side stopped working, back passenger door on drivers side don't shut correctly like the weld come loose. Back brakes make a crazy noise when backing up. Back up camera warning comes up. I've only had this vehicle since 09-2023 and purchased from Ford as a Ford Blue Certified and have nothing but issues. Most of these recalls risk is a fire. If I'm involved and live through a fire I will make sure FORD is held accountable. The open recall with risk of fire currently has been open since July 2025 and no repair yet. This...

The transmission shifting got increasingly rough over time, and then suddenly refused to shift into gear/reverse. The Ford shop told us it was the reverse solenoid, but it ended up requiring a full transmission rebuild. Safety of the car refusing to shift gears led to loss of power several times, unable to accelerate in traffic, until total failure occurred. Problem was inspected by Ford dealership, then repaired by independent service center due to cost. Not inspected by insurance, as it did not result in a collision. Warning lamps did not turn on until total failure occurred. Then lights on gear shift dial blinked, refused to allow us to put the car in gear. Dash lights also indicated "check engine" at that time, but no earlier.

Summary of Problem: Following the mandatory software update for NHTSA Recall 22V859 (Ford 22S73) on my 2020 Ford Escape 1.5L, the vehicle experienced a catastrophic electrical failure. The vehicle is now subject to the expanded NHTSA Recall 25V467 (Ford 25S76) with a status of 'Remedy Not Available'. Safety Failures: Continuous Overcharging: A multimeter test confirms the alternator is overcharging at 15.5V or higher, posing a severe risk of battery explosion or vehicle fire. Safety System Collapse: The overvoltage has forced multiple safety modules into 'fail-safe' mode, disabling the Anti-Lock Braking System (ABS), Traction Control, and AWD Powertrain. Network Communication Failure: Diagnostic reports confirm a U3000 critical control module fault and 'Lost Communication' with the Battery Energy Control Module, indicating a software-induced network collapse. Undriveable Status: The vehicle has been unusable for over 30 days and cannot pass NY State Inspection due to persistent EVAP and module communication codes triggered by...

Shuddering transmission, vehicle struggles to change gears smoothly resulting in loss of acceleration. Rough gear changes from 1-3 gears Transmission fluid changed. Same issues. Issues go in hand with the current class action lawsuit of Ford Escape and Ford Focus over transmission issues. Failure of transmission and exorbitant repair cost over a safety critical issue should automatically require a NHTSA investigation.

The vehicle is subject to an open federal safety recall involving a fuel injector that may crack and leak fuel onto the top of the engine. According to NHTSA, liquid fuel or fuel vapor may accumulate near hot engine or exhaust components, creating a risk of an under-hood fire and injury. I purchased this vehicle after the recall had already been issued. The recall was not disclosed to me at the time of sale, and the vehicle was presented for service multiple times after purchase without any disclosure of the recall or safety warnings. When I contacted an authorized dealer to ask whether there were any open recalls, I was initially told there were none. After I specifically referenced the recall, I was told that parts were not available and that no repair had been completed. The safety risk is that the vehicle may leak fuel near hot components without...

The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, there was an abnormal cracking sound coming from under the hood, and the vehicle hesitated while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer, where it was diagnosed with transmission failure. However, it was unclear if the failure was recall-related. The parts for the recall repair were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000. The VIN was not available.

The AWD module failed with less than 60,000 miles on the vehicle. I live in the Northeast and we get some brutal weather, especially snowstorms. I believe this part should be under a broader recall as it was the same grounding issue as reported in the other current recall for a certain production date escape for its awd module this year. I have always owned a four-wheel drive or all-wheel drive vehicle, and we love to take scenic trips especially in winter for something to do. The only inspection of the module was the Tunkhannock ford dealer that replaced it. The system did warn me after filling up with gas that there was an issue. I feel that this could have gone really bad if we had been in lake Seneca, Killington or driving up to Bangor. It is the whole idea of it not working because of a single...

Total failure of transmission. The transmission on this car failed while driving making it unable to move and creating a risk of collision with other vehicles. No warning displayed on dash until after failure. Noticed some minor vibrations when decelerating at speed was at 25mph. Mileage was approx 80,000 miles. Mechanic diagnosed the possible cause as the failure of the transmission fluid pump or failure of "lifetime" transmission fluid. Cost to replace was $9,000

I completed my 70,000 maintenance on my vehicle on Monday. Friday when I got in my car after shopping, the dash light for parking brake kept coming on. When I put it in drive, the engine light, park assist light, collision assist light, and multiple warning lights kept cycling on my car’s screen. I drove back to the dealership and they kept the car from Friday morning until Monday afternoon before a diagnosis was handed to me. The write up states that the vehicle is “is slipping in every gear” due to “internal mechanical failure.” I am at 70,000 miles and I purchased that car on Jan 4, 2021. Therefore I am out of warranty. I have only had the dealer work on my car except for purchasing tires from an outside source. This is a catastrophic failure of a part that should not be failing. The tech is not...

I am smelling gas every time I put gas and it won't start after putting gas there's a strong smell of gas inside my vehicle the recall has not been fixed yet I am a single mother and this is a safety risk issue how do I go forward powertrain is also still coming up I have other things popping up saying recalls were never fixed please help

Since the remedy was completed for the last recall for the fuel injectors cracking my Ford Escape 2020 has had many issues resulting in warning lights on in 5 different modules. My escape will not pass NY state inspection and the dealer wants 600$ just to diagnose these issues. I have a powertrain/AWD fault that results in not AWD and vehicle has no power and does not run smoothly. The RPMs jump constantly between 2 and 3. Others warning lights and errors include traction control, tire pressure sensor failure, ABS, electric park fault, and also issues with the power steering. Got an appraisal down by my dealer and was told the escape is only worth $3,000 now. I owe 16,000.

At about 95,000 miles, I began experiencing transmission issues. On several occasions, the transmission would not go into second gear and left the vehicle unable to move forward unless I let off the accelerator and it shifted back into first gear. At about 96,000 miles, when placing the vehicle into Park, the Park light would flash and a growling/grinding noise is present for about 5-10 seconds. In my experience, the park light flashing is an indication that the vehicle has not shifted into the Park gear yet. On 11/25/2025, my local Ford dealer confirmed these issues, stating the vehicle had “harsh engage, shift flare 1-2 shift”. The fluid sample was dark and contained metal shavings. The Ford dealer has recommended a complete transmission replacement. The dealer stated they have seen numerous Ford Escapes/Broncos/Mavericks with my model years and mileage experience similar failures. Because the transmission lags between 1st and 2nd...

By dong my own research, I found out it was the AWD Module. It's not grounded correctly. There are multiple, long detailed forum posts on this. Here is one: [XXX] I verified my AWD drive module was indeed not getting enough power do to the grounding issue, which sends a cascade of other faults including the anti lock breaks, collision detection, driving modes, cruise control, auto hold, hill park assist. ALL are non-operational. Now my AWD module does not even show up with a OBD scanner. This should be a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

the transmission experienced total failure. Ford repair claimed that the failure was due to the torque converter caused the failure. the car experience issues with not shifting into a higher gear at highway speeds and failure to go into neutral when going from forward to reverse.

UnknownOn my dash my AWD fault warning has showed up followed by hill assist not available and traction control not available. I have looked for in formation online about it and it seems that it’s a recurring issue with 2020 Ford Escape and many others. I’ve seen that there was a customer satisfaction effective on April 9,2021 through April 30, 2022 but I have just gotten this car last year and dealer states that I am responsible for fixing a manufacturing issue. I’m not sure where my car was manufactured but my car is affected. I have about 83,600 miles and don’t seem to understand why I have to pay since in the customer satisfaction program it states that the module needs to be replaced before sale and customers that have already purchased the vehicle should have it replaced no charge to them. I’ve only just gotten this car last...

Upon starting our vehicle, we received several warning lights relating to collision control and that the AWD system had failed. This happened on a Saturday so we had to wait until Monday to bring the car in to the dealer for service. The service department told us that the diagnostic testing indicated that the AWD module and the PTU actuator motor needed to be replaced. Our vehicle is under six years and under 29,000 miles, along with being garage kept and having regular maintenance.

When the interior of the car gets hot, the gear select dial will not rotate out of park. This has occurred on 5 separate occasions. Eventually the interior of the car cools down enough to shift, but that can take anywhere from minutes to hours, leaving the vehicle and its passengers stranded until the selector shifts. This same problem has been reported by several others on the Ford Escape forum.

The contact owns a 2020 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact stated that after refueling, the vehicle hesitated while attempting to start, with the power train warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 18,474.

On my dash my AWD fault warning has showed up followed by hill assist not available and traction control not available. I have looked for in formation online about it and it seems that it’s a recurring issue with 2020 Ford Escape and many others. I’ve seen that there was a customer satisfaction effective on April 9,2021 through April 30, 2022 but I have just gotten this car last year and dealer states that I am responsible for fixing a manufacturing issue. I’m not sure where my car was manufactured but my car is affected. I have about 83,600 miles and don’t seem to understand why I have to pay since in the customer satisfaction program it states that the module needs to be replaced before sale and customers that have already purchased the vehicle should have it replaced no charge to them. I’ve only just gotten this car last...

It appears that either the rear differential is locked up, or the traction control system has decided to lock all tires for the same rotation. When making any turns at slow speed, the tires grind and pop on the road. If turning in grass it will rip up the grass where the turn was made. In addition, the RPMs and vehicle lurch at normal cruising speed and when accelerating. I understand this as an issue with the torque converter. When the tires locked up, it put excessive force e on this component. It was stated in a similar TSB with the exact issue. There was a lack of fluid in the rear differential when it left the factory. Determination on repair was based on an inspection of the differential fluid and its levels. The cascade of failures happened after a road trip from FL to NY, I believe the miles...

The gear shift module for my 2020 Ford Escape is detaching and sinking below where it is attached in the car. The gear shift isn't working correctly and sometimes operates as if it is in a different gear than what I shift the circular knob to be in gear for... P N R D (park, neutral, reverse, drive). Sometimes I put it into reverse but the car acts like it is in drive. This has cause some very dangerous near accidents with myself and my children in the car. The 2020 Ford Escape has been the worst car I have ever owned and is constantly falling apart. It has had over 10+ recalls since I purchased my car. I hope they will get this problem recalled before I am injured in a serious accident. I have attached pictures to show what it SHOULD look like if attached properly and what...

The contact owns a 2020 Ford Escape. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. An independent mechanic was contacted regarding the failure and the mechanic acknowledged that several other similar vehicles had experienced the same failure with the transmission. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.

On 9/15/2025, my 2020 Ford Escape SE began experiencing serious electrical and shift system issues: hard downshifting, “Shift System Fault” warning, inability to go into park, and failure to shut off without disconnecting the battery. I confirmed a related PCM recall was active and had the vehicle towed to Art Hill Ford for diagnostic and recall service. The dealership refused to perform the PCM recall, claiming my issue “didn’t match” the symptoms — despite clear electrical failure. Instead, they diagnosed a park pawl solenoid issue without scanning or physically inspecting the vehicle. I was told the issue was resolved, paid ~$1,400, and picked up the vehicle. Within 24 hours, new and dangerous transmission issues arose: harsh downshifting, loss of power, sudden high RPMs, and dashboard warnings. I became stranded in the middle of the road and had to have the car towed again. After this second visit, the dealer claimed...

The primary component that failed is the turbocharger system, which has malfunctioned five times since October 2024. Additional failures include the catalytic converter, and there is now suspected motor damage. These components are currently in possession of the dealership and are available for inspection upon request. The safety of myself and my children was repeatedly put at risk. The first turbocharger failure left us stranded in early morning traffic, with no engine power and limited ability to exit the roadway safely. Subsequent failures occurred within 24 hours of service completion. These breakdowns created dangerous roadside conditions, especially during high-traffic hours and in areas without safe pull-off zones. The problem has been reproduced and confirmed multiple times by the dealership’s service department. Each turbocharger replacement has failed within days, and the vehicle is currently awaiting its fifth turbocharger in two months. The dealership has also confirmed damage to the catalytic converter...

Purchased certified vehicle from Wray Ford on 2/23/24. Car was previously leased by FMCC and still listed as a Ford Fleet Vehicle in Michigan as of 9/12/25. VIN confirms it falls under Ford safety recall 24S79, which was never performed. Vehicle experienced unintended acceleration and non-responsive braking, behaving autonomously. FordPass Connect, FMCC, and Wray Ford all confirmed it was unsafe to drive based on 38 diagnostic codes from July/August 2025. June 2025 data and other dates were blacked out. No warning lights or alerts appeared in the FordPass app prior to the crash on 8/25/25.Allstate Insurance removed the vehicle from Wray Ford without authorization, falsely claimed a $10,000 salvage offer, and altered the accident date in the online portal. Damage estimates were manipulated: initial $4,500 based on five photos, later inflated to $13,195 using the same photos. Shreve Collision’s manager confirmed no estimate was performed, contradicting Allstate’s claims. Allstate appears...

Powertrain control module failure causing vehicle to lose power and engine to run at 5 to 6 RPMs. and transmission not shifting properly. Vehicle is going into limp mode and will also shut down while driving but the engine stays running and the cruise does not shut off. There is not remedy for the recall that I believe is causing these issues. This has been going on for 6 month. This vehicle has been nothing but a problem.

My car togs a lot. My tire sensors keep going out. I've smelt gas before while driving. It's very slow going up hill. I hear grinding sounds intermittently

Summary: Failure of AWD/transfer case control module causing loss of multiple safety and driveline functions. Vehicle is currently being repaired at Ford dealership so will have already been corrected. While driving, multiple dash warnings appeared: “Service AdvanceTrac,” “AWD Not Available,” “Hill Start Assist Not Available,” and “Drive Mode Not Available.” The vehicle lost all all-wheel-drive functionality as well as traction/stability features. Dealer diagnosed an internal failure of the AWD/transfer case control module. Safety Impact: This failure disables critical safety systems (AdvanceTrac stability control, Hill Start Assist, AWD traction). In poor weather or emergency maneuvers, loss of these systems could increase the risk of crash. Repair Estimate: Dealer quoted ~$1,070 for replacement of AWD control module (parts, labor, and programming). Concern: This is a major driveline and safety system failure at only 40,000 miles. Ford previously acknowledged AWD module defects in 2020 Escapes under Customer Satisfaction Program 21B19, which suggests this...

There are many thousands of Ford Escape owners with this same issue. The shifter knob will not shift out of park in hot weather, sometimes taking 20 to 30 minutes for the vehicle's interior to cool sufficiently to shift into drive. Ford is ignoring this problem. I don't understand why they are looking the other way and not fixing this well-known issue.

Vehicle has active alerts for powertrain control module, and low boost pressure with the turbocharge along with emissions codes P0299, P0496 and P0456. The vehicle is constantly going into deep sleep mode. While driving the vehicle started to enter safe mode. And displayed an alert that said please turn ignition on. The dash and screen went black like vehicle was off but it was still running. This happened multiple times. My vehicle also will not start after pumping gas so I have to leave vehicle running every time I pump gas. My vehicle will not pass NY state inspection because of the recalls.

2020 ford escape titanium with 28111 miles on it throwing A VERY COMMOM error “AWD fault” the amount of these at this point should be recalled.

The contact owns a 2020 Ford Explorer. The contact stated that while driving 15 MPH, the vehicle experienced a complete loss of automotive power with the “Service Vehicle Soon” light illuminated. The vehicle came to a complete stop in the middle of the roadway. The vehicle was towed to a local dealer, where it was diagnosed, and the contact was informed that the powertrain was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 62,000.

Around the 38,000 mile mark on our 2020 Ford Escape we received many different errors (AWD Fault, ABS, AdvanceTrac Service, Hill assist, etc). I found out via NHTSA and other forums that this is a common issue in the vehicle from the AWD module, and although it is AWD related, it is not eligible for the Powertrain warranty per Ford because it is an electrical component. I declined the $1200 repair at the dealership so I could first call Ford Customer Service, at the recommendation of the dealership, though the Service Tech did mention it is a safety concern because the ABS is apparently also controlled by the AWD. After a couple different calls to Ford, they have refused to acknowledge that it is a manufacturer defect, or pay for the repair. With no help from Ford, I have no other option than to file a complaint here. Based on...

2020 Ford Escape SEL was taken into Ford Service Center for oil change and to address acceleration issue that started two days prior, (check engine light had come on the day before drop off). One week after dropping my vehicle off to be assessed, I was told I needed a small part and it would be complete in 3 days. Another week went by, so I reached out and was told that I need a new engine because of a known Ford issue. Unknown to me, coolant was leaking into the engine and destroyed it. I was assured by the Ford technician that this was a known issue and the problem did not arise from something I did/did not do. I was quoted over $9k and weeks worth of work. I easily drove the vehicle to the Service Center, but was told it is now no longer drivable. I drive...

The contact called on behalf of the owner of a 2020 Ford Escape. The contact stated that while her daughter was driving at various speeds, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and multiple warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle and found metal shavings inside the transmission, with a burn odor coming from the transmission. The contact's daughter was informed that the transmission needed to be replaced. The vehicle was not repaired. The failure persisted, and the vehicle remained at the residence unrepaired. The manufacturer was notified of the failure and referred contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.

AWD FAULT, PRE-COLLISION ASSIST AND HILL START ASSIST WARNINGS DISPLAYING IN CLUSTER.

Car was jerking during acceleration. RPM needle was bouncing while accelerating. It felt like there was a loss of power. Brought it to a Ford Dealership and they were unable to find a problem directly related to this issue. They took care of other problems such as the fuel sensor. Brought it to a transmission specialist and they said the torque converter was bad and need to be replaced. Car has 89k miles on it.

Shortly after having new tires installed at the dealership the following warnings displayed: AWD Fault Service Required, Hill Start Assist, Pre-Collision and Traccontrol. Mileage was around 10,700, June 2025. Dealer unable to look at until July 2025. Advised that the RDU motor needed replacement. Replacement was completed 7/23/25. The vehicle was 5 months past the Powertrain warranty. So out of pocket was over $1,900. Given the low mileage on the vehicle it seems that this should not have happened. Research here and other websites indicate this is a known issue. The dealer indicated the same.

Power Train Fault Indicator came on indicating that the Turbo Charger was in an underboost condition. This caused the vehicle to lose power on the highway which could have placed my family in a unsafe condition.

Component: Powertrain / Transmission Vehicle: 2020 Ford Escape Mileage at failure: 53,500 Transmission began violently jerking, hesitating, and mis-shifting around 53,000 miles. Brought to Ford of Sunnyvale on May 2, 2025 where the dealership diagnosed complete transmission failure. Instead of replacing, they installed a software update that masked the problem for a few weeks before it returned worse. Vehicle is now unsafe to drive — surging, delayed shifting, unpredictable acceleration — especially dangerous for highway merging or family use. This is a known issue with Ford’s 8F35 transmission. Ford TSB 22-2281 documents widespread failures and need for planetary gear replacement. What’s more concerning is that this failure occurred within what should have been the 5-year/60k powertrain warranty. Ford denied full coverage based on a hidden warranty start date from demo use. I was never informed at lease that the warranty had started 6 months earlier. My wife drives our two...

I started experiencing transmission issues with my vehicle around 80,000 miles. When I initially brought it to a Ford dealership for inspection, I was told there was nothing wrong—despite also reporting other concerns with the vehicle. The jerking and shifting issues continued over the following months and became more frequent. Once the vehicle reached just over 100,000 miles, I returned to the dealership and was then informed that the transmission had failed. This was frustrating, as I had been reporting symptoms for a long time with no resolution. To this day, no warning lights or dashboard messages have appeared to indicate any transmission issues.No warning lights, messages, or diagnostic codes appeared before or during the progression of this issue. The only symptom has been the physical jerking and irregular shifting, which first appeared around 80,000 miles. I have a case number with Ford.

When it's hot outside, the car will not shift out of park.

Transmission shredded internally after piston blew.

The contact owns a 2020 Ford Escape. The contact stated that when the vehicle was started, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the DPFE sensor needed to be replaced. The vehicle was then taken to an independent mechanic to be repaired. The vehicle was repaired but the failure reoccurred approximately five months later when the check engine warning light illuminated. Additionally, the contact stated that when the vehicle was started, the check engine warning light illuminated, and several minutes later, the power train warning light illuminated and a message to "Refer to the Owner’s Manual” was displayed and the vehicle failed to accelerate above 40 MPH. The contact stated that the vehicle went into "LIMP Mode". The vehicle was pulled over to the side of the road and turned off. The vehicle was then towed to an independent...

turn on vehicle dashboard lights up where my AWD not working, my collision assist not working, Trac not working, drive mode not working. This started about a week ago from end of June. I did find a recall for 2020 Escape EcoBoost but my vin is not on there. I cannot access my drive mode my collision light does not work and I am driving in front wheel.

For 6 months, after a routine visit and safety recall preformed by ford, I have had an issue with the park brake engaging on its own. When pressing the button to disengage it, the car would not disengage and would remain locked. The only way to disengage it would be to throw the car into reverse, press the button to disengage the park brake and step on the gas pedal as fast as you could. After 6 months of trying to diagnose the issue, ford pittsville came up inconclusive, replacing multiple parts of the e-brake such as the buttons themselves, the wires connecting the brakes, and checking over the brakes. The issue itself was unrecreatable but the only common denominator was remote starting the car via the app. The most recent investigation this past month conducted by ford revealed that the pin for my brake and e brake was loose...

The contact owns a 2020 Ford Escape. The contact stated while driving approximately 35 MPH, the power train warning light illuminated, and the "AWD Fault" message was displayed. The vehicle taken to the dealer where it was diagnosed and determined that an unknown module needed to be replaced. The vehicle was repaired but the failure reoccurred approximately a year later. The manufacturer was notified of the failure. The failure mileage was 21,804.

AWD Fault

The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed on two occasions, the powertrain warning light illuminated, and the vehicle lost motive power. The contact stated that upon starting the vehicle on one of the occasions, the message "No Hill Assist" and another unknown message were displayed. The vehicle was taken to a dealer, where it was diagnosed that an active shutter switch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of failure. The failure mileage was approximately 47,000.