2003 FORD EXPLORER Structurebodyhatchbackliftgatehinge And Attachments Problems

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN ATTEMPTING TO CLOSE THE REAR WINDOW, THE CONTACT NOTICED THAT THE REAR LIFTGATE WINDOW HINGES WERE CRACKING AND WERE TILTED ON ONE SIDE. THE CONTACT, A CERTIFIED MASTER TECHNICIAN, STATED THAT THE WINDOW NEEDED TO BE REPLACED. THE CONTACT CALLED FORT MILL FORD AT (866) 680-5276 (LOCATED AT 801 GOLD HILL RD, FORT MILL, SC 29708) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE ACCESSING THE POWER LIFTGATE, THE HINGES FRACTURED AND CAUSED THE DOOR TO ABRUPTLY CLOSE. THERE WERE NO INJURIES. THE LIFTGATE WAS COMPLETELY REMOVED AND PLACED IN THE VEHICLE TEMPORARILY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HATCH WAS OPEN AND THE HINGES THAT OPENED THE GLASS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,500.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES WERE FRACTURED AND TILTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS ALSO TAKEN TO THE DEALER WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A LOUD SQUEAKING COMING FROM THE REAR WINDOW. THE CONTACT NOTICED THAT THE DRIVER SIDE OF THE REAR WINDSHIELD HINGE WAS CROOKED AND THE PANEL WAS FRACTURED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THAT THE HINGES NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 118,000 AND THE CURRENT MILEAGE WAS 121,000. UPDATED 6/4/12 *CN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFT GATE:HINGE AND ATTACHMENTS) AND WAS REPAIRED. AFTER THE REPAIR, THE CONTACT NOTICED A FRACTURE IN THE PANEL UNDER THE REAR LIFTGATE WINDOW. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 04/10/12*LJ UPDATD 04/20/12. *JB

I BOUGHT 2003 FORD EXPLORER IN 2008, USED, AND IN 2011 I OPENED MY BACK GLASS AND THE HINGE SNAPPED ON THE LEFT SIDE AND THE GLASS STARTED FALLING, AND THE ONLY THING THAT SAVED THE GLASS FROM BREAKING WAS THE RIGHT SIDE HINGE HELD. I CALLED THE FORD COMPANY AND THEY SAID THAT I COULD TAKE IT TO A DEALER AND HAVE IT INSPECTED, BUT THERE WAS NO SAFTEY RECALL ON MY VEHICLE. I LOOKED ONLINE AND IN 2004 THE 2003 FORD EXPLORER WAS RECALLED FOR THIS VERY PROBLEM. *KB

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE OPENING THE REAR HATCH THE LIFT GATE HINGE FAILED OFF CAUSING THE LIFT GATE TO HANG ON BY ONE HINGE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE HINGE NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE HINGE REPLACED. THE CONTACT STATED THE LIFT GATE COULD HAVE FALLEN OFF WHILE DRIVING. THE FAILURE MILEAGE WAS 123,000.

ONE OF THE TWO HINGES THAT SECURE THE REAR LIFTGATE GLASS TO THE VEHICLE RECENTLY BROKE. UNDER THE NHTSA'S GUIDANCE, FORD PREVIOUSLY ISSUED A RECALL DESCRIBING AND ADDRESSING THIS EXACT PROBLEM. HOWEVER, FORD CLAIMS THAT MY TRUCK FALLS OUTSIDE THE BUILD DATES FOR THE AFFECTED VEHICLES. SEVERAL OTHER OWNERS HAVE COMPLAINED OF THIS ISSUE ONLINE, SO IT APPEARS THE RECALL NEEDS TO BE EXPANDED TO THE LATER BUILD DATES. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE ATTEMPTING TO OPEN THE REAR LIFT GATE WINDOW, THE HINGE FOR THE WINDOW BROKE AND THE GLASS BECAME DISENGAGED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS). THE VEHICLE WAS NOT SERVICED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 100,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE REAR LIFT GATE HINGES FRACTURED AND CAUSED THE REAR WINDSHIELD GLASS TO FALL AND SHATTER FROM THE VEHICLE. THE DEALER ADVISED THERE WERE NO RECALLS FOR THE VEHICLE AND ANY REPAIRS WOULD BE AT THE EXPENSE OF THE OWNER. THE VEHICLE WAS REPAIRED ACCORDINGLY. THE FAILURE MILEAGE WAS 110,950 AND THE CURRENT MILEAGE WAS 113,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE CONTACT WAS CLOSING THE REAR LIFT GATE THE HINGE BROKE WITHOUT WARNING. PRIOR TO THE RECENT FAILURE THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE NHTSA CAMPAIGN ID #04V442000 (STRUCTURE: BODY: HATCHBACK/LIFT GATE: HINGE AND ATTACHMENTS) REPAIR WAS PERFORMED ON THE VEHICLE. THE REPAIR WAS INSUFFICIENT AND FAILED TO ADDRESS THE SAFETY DEFECT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION WHERE THE DEALER REFUSED TO REPAIR THE VEHICLE FREE OF CHARGE. THE CURRENT AND FAILURE MILEAGES WERE 70,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE/APPLIQUE SPLIT DOWN THE MIDDLE WHICH CAUSED WATER TO ENTER THE VEHICLE, ALSO KNOWN AS A CRACKING FRACTURE OF THE PANEL. RECALL NUMBER 04V442000, STRUCTURE, BODY, HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS IS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS NOT INCLUDED. THE CONTACT EXPECTS THE MANUFACTURER TO BE RESPONSIBLE FOR THE REPAIRS SINCE THERE IS AN EXISTING RECALL. THE FAILURE MILEAGE WAS 104,000. UPDATED 01/12/10 *BF UPDATED 01/15/10.*JB

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HINGES FOR THE REAR LIFTGATE FRACTURED AND ALMOST CAUSED THE GLASS TO DISENGAGE AND CAUSE INJURY. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS); THEREFORE, THEY WOULD NOT ASSUME ANY RESPONSIBILITY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000.

MY WIFE AND I OWN A 2003 FORD EXPLORER. UNDER NHTSA CAMPAIGN ID NUMBER 04V442000, THE LIFTGATE GLASS STRUTS BRACKETS AND GLASS HINGES WERE ALLEGEDLY REPAIRED. ONE OF THE GLASS HINGES THAT WAS ALLEGEDLY REPLACED HAD FAILED. THE HINGE PIN FOR THIS HINGE HAS BEEN SHEARED OFF IN A SIMILAR MANNER TO THE PROBLEM WITH THE ORIGINAL HINGES COVERED UNDER THE ABOVE REFERENCED RECALL. MY FORD DEALER AND FORD ARE ENTIRELY UNWILLING TO ADDRESS THIS ISSUE UNDER THE ORIGINAL RECALL, STATING THAT THEY HAVE MET THEIR OBLIGATION. SINCE THE 'REPLACEMENT' HINGE HAS FAILED IN THE SAME MANNER AS THE ORIGINAL I AM LEFT WITH ONLY TWO POSSIBLE EXPLANATIONS. THE 'REPLACEMENT' PART IS SIMILARLY FLAWED OR THE PART USED IN THE RECALL WAS NOT THE REPLACEMENT PART. REGARDLESS OF THE EXPLANATION, A SAFETY ISSUE REMAINS WITH THE GLASS LIFTGATE ON MY 2003 FORD EXPLORER AND IT IS MY BELIEF THAT THIS...

WE HAVE OWNED THE SUBJECT 2003 FORD EXPLORER XLT SINCE IT WAS NEW. THE REAR LIFTGATE HINGE HOLDING THE REAR GLASS FAILED. I UNDERSTAND THAT THIS FAILURE IS THE SUBJECT OF NHTSA RECALL #04V442000. FORD INFORMS ME THAT THEY WILL NOT FIX THIS CONTINUING SAFETY DEFECT BECAUSE THEY REPLACED THE HINGE ONCE BEFORE IN 2006. I HAVE NO RECORD OF SUCH A REPAIR, NOT DO I AGREE THAT FORD'S POLICY OF ONLY PERFORMING ONE REPLACEMENT IS VALID. EVEN IF THEY DID REPLACE IT ONCE, THE DESIGN IS CLEARLY DEFECTIVE AND THE SAFETY ISSUE STILL REMAINS. I WOULD EXPECT NHTSA TO DIRECT FORD TO PROPERLY FIX THE PROBLEM, RATHER CAUSE ME TO PAY FORD FOR YET ANOTHER REPLACEMENT FOR THE INEFFECTIVE ONE THEY PREVIOUSLY PERFORMED. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFTGATE HINGE BROKE ON THE RIGHT SIDE AND THE LEFT SIDE OF THE GLASS WAS WEDGED INSIDE THE ROOF. IF THE HATCH HAD NOT BEEN WEDGED, THE GLASS WOULD HAVE SHATTERED ONTO HER FEET OR CAUSED INJURIES. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE FAILURE MILEAGE WAS 74,555 AND CURRENT MILEAGE IS 74,575. 4/01/09 *NJ UPDATED 04/07/09. *JB

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN THE CONTACT OPENED THE LIFTGATE, THE RIGHT HINGE SWUNG OUT AND BECAME DETACHED. THE HINGE NEARLY STRUCK HIS CHILD. HE CALLED THE DEALER AND WAS NOTIFIED OF A RECALL ON HIS YEAR, MAKE, AND MODEL VEHICLE FOR THIS IDENTICAL FAILURE. HE CALLED THE MANUFACTURER AND WAS INFORMED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT BELIEVES THAT IF THE FAILURES ARE THE SAME, HIS VIN SHOULD BE INCLUDED. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 70,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 55 MPH WITH THE CRUISE CONTROL ACTIVATED, THE CRUISE CONTROL FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THE CRUISE CONTROL WIRING FAILED. THERE IS A RECALL FOR THE VEHICLE SPEED CONTROL, BUT HIS VIN WAS NOT INCLUDED. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 11,550 AND FAILURE MILEAGE WAS 11,330. UPDATED 06/25/08. *LJ THE CONSUMER STATED AFTER THE DEALER FIXED THE RECALLED REAR HATCH PROBELM, THE CARGO HATCH FLEW OPEN WHILE DRIVING DOWN THE HIGHWAY. A

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR WINDOW HATCH HAS A PIECE OF PLASTIC UNDER THE GLASS, WHICH HOLDS THE WINDOW IN PLACE. THE PLASTIC HAS CRACKED ALL THE WAY THROUGH THE WINDOW. THE CURRENT MILEAGE WAS 75,000 AND FAILURE MILEAGE WAS 8,000. UPDATED 04/02/08. *LJ

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE REAR LIFTGATE WINDOW SUDDENLY BLEW OUT WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WAS A COMMON FAILURE, BUT THEY COULD NOT EXPLAIN THE CAUSE. THE VEHICLE IS CURRENTLY AT THE SHOP BEING REPAIRED. THE CONTACT HAS PICTURES OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 72,000. UPDATED 03-31-08 *BF AFTER DOING SOME RESEARCH, THE CONSUMER DISCOVERED THE GAS IN THE STRUTS THAT HOLD THE TOP PORTION OF THE REAR HATCH CAN EXPLODE WHEN COLD WEATHER IS A FACTOR. UPDATED

2003 FORD EXPLORER WITH BAD RECALL REPAIR WORK. CONSUMER STATED THAT THE DEALER REPAIRED THE VEHICLE WRONG. HE STATES THAT THE HINGES WERE SUPPOSED TO BE REPLACED. DEALER REPLACED THE STRUTS AND HINGES. *KB WHEN THE CONSUMER TRIED TO GET THE PROBLEM FIXED THE FIRST TIME HE WAS TOLD THE STRUTS LOOKED FINE. HOWEVER, THE DRIVER'S SIDE HINGE BEGAN TO SEPARATE AND THE WHOLE LIFTGATE SUBSEQUENTLY SHIFTED; THE GAP BETWEEN THE LIFTGATE AND THE BODY WAS NO LONGER SYMMETRICAL BUT WAS SIGNIFICANTLY INCREASED ON THE DRIVER'S SIDE WHILE DECREASED ON THE PASSENGER SIDE. AS A RESULT, THE LIFTGATE NO LONGER LATCHED OR WOULD ONLY LATCH WITH A GREAT DEAL OF PRESSURE APPLIED WHEN CLOSING IT. THE CONSUMER STATED IT WAS THE TWO HINGES AT THE TOP OF THE REAL HATCH GLASS SECTION THAT ATTACHED TO THE ROOF OR BODY OF THE VEHICLE THAT WERE BROKEN. THE CONSUMER STATED THE LIFTGATE...

WE PURCHASED A CERTIFIED USED 2003 FORD EXPLORER EDDIE BAUER 4X4 IN JUNE 2006. ONE MORNING IN MID-FEB 2007, WE DISCOVERED A CRACK IN THE LIFEGATE GLASS APPLIQUE THAT STARTED FROM THE TOP DOWN, APPROXIMATELY 8" LEFT FROM THE CENTER OF THE GATE. THERE WAS NO EVIDENCE OF IMPACT TO THE PLASTIC, BUT RATHER A STRESS CRACK. SINCE THAT TIME, THE CRACK HAS GROWN WIDER AND ALL THE WAY THROUGH THE PLASTIC APPLIQUE. NOW, ANOTHER CRACK HAS STARTED ON THE RIGHT HAND SIDE APPROXIMATE 6" FROM THE CENTER OF THE LIFTGATE. WE CONTACTED THE LOCAL DEALERSHIP IN MID-FEB 2007 AND THEY STATED WE WOULD HAVE TO PAY FOR THE CRACKED LIFTGATE AND IT WOULD COST APPROXIMATELY $800. WE CONTINUE TO OBSERVE OTHER FORD EXPLORER'S IN THE LOCAL AREA WITH SIMILAR CRACKS IN THEIR LIFTGATE PLASTIC APPLIQUE. *JB

2003 FORD EXPLORER. CONSUMER STATES THAT THE VEHICLE BOTTOM REAR LIFTGATE IS CRACKED. CONSUMER BELIEVES CONCERN IS RELATED TO RECALL ON THE HINGES FOR THE LIFTGATE. THE CONSUMER BELIEVED THE CRACKS ON THE LIFTGATE WERE DUE TO WEAKNESS. UPDATED 07/08/07. *JB

2003 FORD EXPLORER HAS STRUCTURE: BODY: HATCHBACK 6" VERTICAL CRACK IN PLASTIC BELOW HATCHBACK WINDOW. RECALL 04V442000 DOES NOT APPLY TO MY VIN NUMBER HOWEVER IS SAME PROBLEM. SPENT 40 MINUTES ON PHONE WITH FORD AND THEY STATED THAT I MUST COMPLETE A COMPLAINT FORM. *TR

REAR HATCHBACK WAS TAKEN TO FORD FOR A RECALL REGARDING THE HATCHBACK HINGES. THE STRESS OF THE FAILED HINGES HAS CAUSED CRACKS TO DEVELOP BELOW THE REAR WINDOW IN THE FACIA, IT IS CRACKING. *JB

THE LIFT GATE TRIM PIECE NEEDS TO BE REPAIRED FOR THE 4TH TIME NOT INCLUDING LIFT GATE RECALL WHICH WOULD BE THE 5TH REPAIR. I HAVE BEEN INFORMED BY LOCAL DEALER THAT THIS IS "DESIGN FLAW" AND FORD HAS YET INFORMED THEM HOW TO CORRECTLY REPAIR THE PROBLEM. *JB

AFTER OPENING THE HATCHBACK TO PUT GROCERIES INSIDE, THE WINDOW FELL. AFTER INSPECTING IT, IT TURNS OUT THE HINGE ON HATCHBACK BROKE CAUSING THE WINDOW TO FALL. IT HIT MY LEFT ARM AND FOREARM CAUSING SEVERE BRUISING, OTHER THAN THAT NOBODY ELSE WAS HURT AND THE WINDOW DID NOT FALL OFF COMPLETELY. I CALLED THE DEALER AND WAS ASKED TO DROP IT OFF FOR INSPECTION. WAS EVENTUALLY FIXED. BUT I CAN'T HELP TO WONDER IF IT WILL HAPPENED AGAIN AND IF THE CONSEQUENCES WILL BE WORSE. *JB

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED AT HOME THE REAR LIFT GATE WINDOW EXPLODED. DURING THE INCIDENT THE TEMPERATURE OUT DOORS WAS ABOUT 70F. LAST YEAR, THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO REPLACED THE GATES DEFECTIVE HINGES, ACCORDING TO RECALL # 04V442000 INSTRUCTIONS. THE CONTACT EXPRESSED CONCERN ABOUT THE INCIDENT BECAUSE IT COULD HAVE CAUSED A SERIOUS ACCIDENT. *AK THE CONSUMER WAS TOLD POOR QUALITY GLASS MAY HAVE USED TO PERFORM THE RECALL WORK. THE CONSUMER HAD THE WINDOW REPAIRED AT HIS EXPENSE, HOWEVER DAYS LATER HE HEARD A NOISE AND UPON INSPECTION, THE CONSUMER DISCOVERED THE INSIDE PANEL OF THE LIFTGATE WAS VERY LOOSE AND IT LOOKED AS THOUGH IT WAS ABOUT TO FALL OFF. UPDATED 08/02/06. *JB

PANEL UNDER TAILGATE WINDOW CRACKED AND SPLIT WHILE VEHICLE PARKED IN DRIVEWAY ON COLD DAY. VEHICLE HAD PREVIOUSLY HAD TAILGATE HINGES REPLACED UNDER RECALL. DEALERSHIP ADVISES THAT MANUFACTURER DENIES ANY RESPONSIBILITY TO REPAIR/REPLACE. DEALER ESTIMATE OF $401 TO REPAIR. *JB

DT: THE CONTACT STATES WHILE THE VEHICLE WAS PARKED SHE HEARD THE LIFTGATE GLASS EXPLODE. NOTHING HIT THE GLASS AND THE HYDRAULIC SHAFT RELEASED. THE VEHICLE IS CURRENTLY AT A LOCAL MECHANIC, BUT THEY HAVE NOT DIAGNOSED WHAT HAPPENED. THE DEALERSHIP AND MANUFACTURER WERE NOT WILLING TO ASSIST WITH REPAIRS, THEREFORE, THE INSURANCE COMPANY WAS REPAIRING THE VEHICLE. *AK

COMPLAINT REGARDING RECALL 04S20 RELATING TO THE REAR LIFT GATE.*** NO ANSWER REQUIRED***. *MR THE CONSUMER STILL HAD NOT RECEIVED A CALL OR LETTER AS TO WHEN TO TAKE THE VEHICLE IN TO HAVE THE RECALL WORK PERFORMED. *JB

THE PLASTIC MOLDING AROUND THE REAR GLASS ON THE LIFTGATE CRACKED. CONSUMER WAS CONCERNED THAT THE GLASS MAY FALL OUT WHILE OPENING THE LIFTGATE OR WHILE DRIVING. THE DEALER WAS NOTIFIED.*AK.....THE CONSUMER WAS ADVISED BY DEALERSHIP THAT THIS HAPPENED TO A LOT OF PEOPLE. IF NOT UNDER WARRANTY THE CONSUMER MUST PAY. THE CONSUMER'S GAS GAUGE FAILED WITH ONLY 2500 MILLES OVER WARRANTY. *AK

NHTSA RECALL CAMPAIGN 04V442000, CONSUMER RECEIVED A RECALL FOR THE HINGES ON THE LIFTGATE. CONSUMER HAS BEEN UNABLE TO HAVE THE VEHICLE REPAIRED SINCE THE DEALER HAS MADE NOT CONTACT WITH HER FOR THE SERVICE DATE. *AK *TC

RECEIVED RECALL NOTICE FOR HINGES ON REAR WINDOW OF HATCH AND WAS ADVISED NOT TO OPEN UNTIL HINGES WERE REPLACED, WHICH I DID NOT. NOTICED THE FIBERGLASS UNDER THE WINDOW CRACKED APPROXIMATELY 4 INCHES TO THE LEFT OF THE LATCH. TOOK THE VEHICLE TO FORD DEALER AND THE WARRANTY ADMINISTRATOR SAID THE FIBERGLASS WAS NOT COVERED UNDER RECALL. THE WARRANTY ADMINISTRATOR SAID HE WOULD SEND A REQUEST FOR FORD TO REPAIR THE FIBERGLASS UNDER THE GLASS BUT DOESN'T KNOW IF THEY WILL SINCE THEY HAVE DENIED PAYING FOR A FEW OF THESE THAT HE HAS ALREADY SUBMITTED. I AM CONVINCED THIS DAMAGE IS A DIRECT RESULT OF THE DEFECTIVE HINGE AND FEEL THAT FORD SHOULD REPAIR MY VEHICLE. *JB

CONSUMER RECEIVED RECALL CAMPAIGN 04V442000 CONCERNING REAR LIFTGATE GLASS. HOWEVER, CONSUMER WAS WAITING SINCE OCTOBER 2004 FOR REPAIRS. FORD CONTINUOUSLY TOLD HER THAT THE PARTS WERE NOT IN. *AK

THE CONSUMER RECEIVED A RECALL LETTER FOR THE LIFTGATE, AND NO PARTS WERE AVAILABLE TO MAKE THE REPAIR. NHTSA LIFTGATE RECALL 04V442000 *JB *SC

THE CONSUMER WAS EXPERIENCING PROBLEMS WITH THE LIFTGATE LATCH. SHE THEN TOOK VEHICLE TO GET SERVICED. RECENTLY WHILE SHE WAS DRIVING, THE BACK WINDOW LITERALLY CAME OFF. SHE WAS AWARE OF A RECALL FOR THIS VEHICLE. NHTSA'S RECALL #04V442000. WHEN THE CONSUMER CONTACTED THE MANUFACTURER, THEY DENIED THAT THERE WAS SUCH A RECALL. *JB

COMPLAINT RECEIVED VIA E-MAIL."I HAVE A 2003 FORD EXPLORER AND THE REAR GLASS HATCH HAS A RECALL. RECALL # 04S20 WE FIRST BROUGHT THE PROBLEM TO HAWKINSON FORD'S ATTENTION SEPT 2004. IN OCT 2004 WE RECEIVED A NOTICE AND WERE TOLD THE HINGE HAD TO BE REDESIGNED AND WOULD TAKE SEVERAL MONTHS. JAN 11, 2005 WE HAD THE REPAIRS DONE TO THE HINGES. THE NEXT DAY THE VERY FIRST TIME THE HATCH WAS OPENED BOTH HINGES MOVED I DROVE RIGHT BACK TO THE DEALERSHIP. I SPOKE TO PAUL'S THE ASSISTANT MANAGER AND SHOWED HIM THIS PROBLEM, HE WAS AMAZED. WE SET UP ANOTHER APPOINTMENT TO HAVE IT CHECKED AND REPAIRED. MY CONCERN IF THIS IS THEIR NEW DESIGN, WOW IT LASTED 1 OPENING AND NOW I HAVE MOISTURE IN MY EXPLORER BECAUSE THE WINDOW DOESN'T CLOSE PROPERLY. I CAN ONLY USED THE LIFT GATE AND HAVE TO WORRY IF I...

CONSUMER WAS UNABLE TO HAVE THE LIFTGATE BRACKET REPAIRED SINCE NO PARTS WERE DELIVERED TO THE DEALER SINCE RECEIPT OF NHTSA RECALL 04V442000. *AK....CONSUMER WAS ADVISED NOT TO USE TAILGATE WINDOW. HOWEVER THE REMOTE OPERATED WINDOW WAS ONE OF THE REASONS FOR PURCHASING THE FORD EXPLORER. CONSUMER COMPLAINED THAT TO WAIT FOUR MONTHS FOR REPAIRS WAS RADICULOUS. *AK

THE RIGHT HINGES ATTACHED TO THE VEHICLE BODY AND THE LIFTGATE BROKE. DEALER WAS NOTIFIED. CONSUMER WAS WAITING FOR THE PART SINCE SEPTEMBER, AND NO PART WAS AVAILABLE. CONSUMER WAS CONCERNED THAT THE LIFTGATE MAY FALL UNEXPECTEDLY AND CAUSE SEVERE INJURIES TO SOMEONE WHEN OPENED.*AK

RECEIVED RECALL NOTICE FOR HINGES ON REAR WINDOW OF HATCH AND WAS ADVISED NOT TO OPEN UNTIL HINGES WERE REPLACED, WHICH WE DID NOT. NOTICED THE FIBER GLASS UNDER THE WINDOW CRACKED FROM THE WINDOW TO BOTTOM OF WHERE WINDOW LIFTS. TOOK TO FORD DEALER AND SERVICE WRITER SAID THE FIBER GLASS WAS NOT COVERED UNDER RECALL BUT HE FELT THE CRACK WAS A RESULT OF HINGE FAILURE. HE OPENED THE REAR WINDOW ON THE HATCH AND WAS UNABLE TO CLOSE IT. THE DEALER HAD TO REPLACE THE HINGES BEFORE WE COULD DRIVE THE VEHICLE. THE SERVICE WRITER HAS SENT A REQUEST FOR FORD TO REPAIR THE FIBER GLASS UNDER THE GLASS BUT DON'T KNOW IF THEY WILL. I AM CONVINCED THIS DAMAGE IS A DIRECT RESULT OF THE DEFECTIVE HINGE AND FEEL THAT FORD SHOULD REPAIR MY VEHICLE. *JB

CONSUMER HAS BEEN WAITING FOR RECALL 04V442000 CONCERNING REAR LIFTGATE GLASS REPAIR SINCE OCTOBER. CONSUMER CONTACTED FORD SEVERAL TIMES, AND WAS TOLD THE PARTS HAVE NOT COME IN. ALSO, WHILE DRIVING AND UPON DEPRESSING THE ACCELERATOR PEDAL AND RELEASING FOOT OFF IT VEHICLE SURGED FORWARD. *AK RECALL CAMPAIGN *TC

RCALL 04V442000 CONCERNING REAR LIFTGATE GLASS: CONSUMER WAS UNABLE TO GET THIS RECALL HONORED BY THE DEALER BECAUSE NO PARTS WERE AVAILABLE.*AK

CONSUMER WAS WAITING THREE MONTHS FOR RECALL 04V442000 CONCERNING LIFTGATE PARTS TO COME IN. HE CONTACTED FORD MANUFACTURER, AND WAS TOLD THEY DO NOT KNOW WHEN THE PARTS WILL BE AVAILABLE. CONSUMER WAS VERY CONCERNED. *AK

CONSUMER HAS BEEN WAITING FOR THE REPAIR PARTS TO COME IN FOR RECALL 04V442000 CONCERNING REAR LIFTGATE GLASS FOR FOUR MONTHS. WAS TOLD THE PARTS SHOULD HAVE BEEN HERE LATE NOVEMBER. HOWEVER, THE PARTS WERE NOT HERE, AND THE PROBLEM RECURRED. *AK

THE LIFTGATE WINDOW WOULD OPEN WHEN NO ONE WAS NEAR IT AND ON SEVERAL OCCASIONS THE VEHICLE WAS IN MOTION. BF THE CONSUMER RECEIVED THE LIFTGATE RECALL AND HOPES THAT THE REPAIR WILL ALSO REPAIR THE WINDOW. *NM CAMPAIGN ID NUMBER : 04V442000 *TC

THE GLASS BLEW OUT OF THE BACK REAR TRUNK WINDOW. AFTER GOING TO THE DEALER FOR REPAIR, THE MANUFACTURE STATED THERE WAS A RECALL, HOWEVER, THE CONSUMER WAS NEVER NOTIFIED. PLEASE PROVIDE INFORMATION. *JB

THE LIFT GATE SHEARED OFF THE HINGES WHILE PRESSING THE REMOTE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER. THE MECHANIC INFORMED THE CONSUMER THE PARTS WERE NOT AVAILABLE AT THIS TIME. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

2003 FORD EXPLORER...WHEN OPENING GLASS PORTION OF HATCHBACK, THE RIGHT HINGE FAILED, CAUSING THE WINDOW TO FALL ON MY WIFE'S HEAD, GIVING HER A CONCUSSION. AR HAS 38000 MILES AND HAS NOT BEEN IN AN ACCIDENT. HINGE FAILURE DUE TO BOLT SHEARING OFF AT WINDOW. GOING TO GET IT LOOKED AT TOMORROW. *AK PE04045.PCO