2003 FORD EXPLORER Structurebodyhatchbackliftgate Problems

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN OPERATING THE VEHICLE, THE REAR HATCH DOOR AND THE REAR HATCH WINDOW BECAME UNSECURED AND OPENED DUE TO A CRACK NEAR THE REAR WINDOW WIPER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE REAR LIFTGATE FIBERGLASS WAS CRACKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR PANEL OF THE LIFTGATE WAS CRACKED. THE FAILURE CAUSED THE CONTACT'S FINGERS TO BECOME PINCHED WHEN ATTEMPTING TO CLOSE THE LIFTGATE. THE CONTACT ALSO STATED THAT THE HINGES FRACTURED ON THE LIFTGATE. THE HINGES WERE REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE), BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

CRACK IN REAR LIFTGATE BODY PANEL. MAY FAIL DURING OPENING/CLOSING AND CAUSE INJURY. THIS IS A KNOWN PROBLEM WITH 2002-2005 EXPLORERS. FORD KNEW ABOUT THE PROBLEM AND COVERED IT UP. THERE IS A CLASS ACTION LAWSUIT IN PROGRESS. *JS

WHEN CLOSING THE GLASS TAILGATE THE RIGHT HINGE THAT ATTACHES THE GLASS TO THE TAILGATE BROKE CAUSING THE GLASS TO DETACH FROM THE CAR AND FALL HITTING ME IN THE LEFT ARM UPDATED 09/16/14*LJ UPDATED 3/18/2015 *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFT GATE WINDOW BECAME DETACHED INTERMITTENTLY. THE LIFTGATE DOOR FAILED TO CLOSE PROPERLY AND IT DEVELOPED A CRACK AT THE BOTTOM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LIFT GATE NEEDED TO BE REPAIRED AND THE WINDOW NEEDED TO BE REPLACED. THE CONTACT WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE). THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED BY AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,002.

ON FEBRUARY 18TH I NOTICED A CRACK IN THE REAR GLASS LIFT GATE MOLDING OTHERWISE KNOWN AS THE REAR APPLIQUE. AFTER A GOOGLE SEARCH I REALIZED THIS IS KNOWN DEFECT THAT FORD MOTOR CO. DOES NOT RECOGNIZE OFFICIALLY. THERE IS A CLASS ACTION LAWSUIT REGARDING THIS DEFECT. ON APRIL 25TH 2014 I OPENED THE REAR GLASS LIFT GATE TO GET SOMETHING OUT OF THE REAR CARGO AREA. UPON CLOSING THE GLASS LIFT GATE THE ENTIRE WINDOW SHATTERED INTO MANY PIECES AND ACTUALLY PUT THREE CUTS ON MY ARM. I HAVE LOOKED INTO THIS ONLINE AND FOUND MANY OWNERS OF THE 2002-2005 FORD EXPLORER'S, MERCURY MOUNTAINEER'S AND LINCOLN AVIATOR'S ALL HAD THIS CRACKING OF THE REAR APPLIQUE. ALSO FOUND OUT WHETHER OR NOT A CRACK WAS VISIBLE MANY PEOPLE HAD THE REAR GLASS SHATTER UPON THEM WHILE CLOSING THE GLASS LIFT GATE. RIGHT NOW I MUST PAY FOR THE ENTIRE REPAIR...

2003 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO HUMMING/WHINING NOISE IN THE REAR END OF VEHICLE AND A FREQUENT LEAK IN THE DIFFERENTIAL. *SMD THE CONSUMER STATED SEVERAL COMPONENTS SUCH AS THE RING AN PINION, BEARINGS, SEALS AND GEAR AND PINION WERE ALL REPLACED. HOWEVER, THE ISSUE REMAINED UNRESOLVED. ALSO, THE REAR HATCH WAS CRACKED. WHEN THE CONSUMER INQUIRED ABOUT A REPLACEMENT AND ITS COST, THE DEALER ADVISED AGAINST THE REPLACEMENT/REPAIR AS THE NEW HATCHES HAD THE SAME PROBLEM. THE VEHICLE OVERHEATED AND HAD TO BE TOWED TO THE DEALER. A DIAGNOSIS REVEALED A DAMAGED THERMOSTAT HOUSING.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE TAILGATE HAD CRACKED UNDERNEATH THE REAR WINDOW. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000 AND CURRENT MILEAGE WAS UNKNOWN. UPDATED 04/18/2013 *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED A CRACK ON THE REAR LIFT GATE PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 91,793.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE PANEL WAS CRACKED DUE TO DEFECTIVE MATERIAL. THE DEALER DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE WARRANTY EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 56,543 AND THE CURRENT MILEAGE WAS 60,000. UPDATED 08/07/12*LJ

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A LOUD SQUEAKING COMING FROM THE REAR WINDOW. THE CONTACT NOTICED THAT THE DRIVER SIDE OF THE REAR WINDSHIELD HINGE WAS CROOKED AND THE PANEL WAS FRACTURED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THAT THE HINGES NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 118,000 AND THE CURRENT MILEAGE WAS 121,000. UPDATED 6/4/12 *CN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE PARKED, THE CONTACT NOTICED THAT THE PANEL BELOW THE REAR WINDOW HATCH WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE REAR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,000. UPDATED 03/21/12*BF THE CONSUMER STATED THE REAR PANEL CONNECTED TO THE BACK REAR WINDOW CRACKED UNDERNEATH THE REAR WINDOW AND HAS WEAKENED THE REAR VIEW WINDOW. THE SEAL HAS ROTTED OUT DUE TO WATER SEEPING INTO THE DEFECTIVE CRACKED PANEL. UPDATED 04/09/12 WATER SEEPED INTO THE CRACKED PANEL AND CAUSED CORROSION AND ELECTRICAL PROBLEMS. UPDATED 05/07/12

I HAVE A 2003 FORD EXPLORER, RAN TO THE STORE LAST NIGHT TO BUY GROCERIES. LOADED THINGS INTO MY TRUCK, CLOSED THE DOOR AND THINGS WERE FINE. ARRIVED HOME TO REMOVE THE GROCERIES AND THERE WAS A 6 INCH LONG CRACK ON THE REAR HATCH OF MY TRUCK RIGHT BESIDE THE FORD LOGO AND REAR WINDSHIELD WIPER. I TAKE PRIDE IN MY VEHICLE AND KEEP IT CLEAN AND THE OUTSIDE BODY IS PERFECT; UNTIL THIS HAPPENED. I AM DISAPPOINTED THAT I CALLED FORD AND THERE IS NO RECALL IN REGARDS TO THIS, BUT THERE ARE HUNDREDS OF COMPLAINTS ONLINE ABOUT THE EXACT SAME ISSUE. I WANT FORD TO PAY FOR THE REPAIR OF THIS. I HAVE BEEN A LOYAL FORD CUSTOMER AND SO HAS BY FAMILY SINCE THE EARLY 1980S. I WILL PROBABLY NEVER PURCHASE ANOTHER FORD AS THIS IS JUST ANOTHER ISSUE THAT FORD WON'T ACKNOWLEDGE. *KB

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REAR LIFTGATE, EXTENDING UP TO THE WINDOW. THE CONTACT EXPRESSED CONCERN OVER THE POSSIBILITY OF THE WINDOW SEPARATING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS COSMETIC AND THEY WOULD BE UNABLE TO ASSIST WITH REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 77,130.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HATCH BACK HAD A CRACK FROM THE END OF IT TO THE WINDOW. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HER THAT IT WAS CAUSED BY STRESS FROM OPENING AND CLOSING OF THE DOOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE FRACTURED DIRECTLY UNDERNEATH THE WINDOW SEAL. SHE NOTICED WHEN THE DOOR WAS AJAR THE WARNING LIGHT WOULD ILLUMINATE AS IF SHE HAD OPENED THE DOORS. THE DEALER ADVISED HER THAT THEY WERE AWARE OF THE FAILURE, BUT THERE WAS NO RECALL. THE VEHICLE WAS NOT INSPECTED NOR WAS IT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REAR LIFTGATE FROM THE TOP OF THE MANUFACTURERS EMBLEM UP TO THE WINDOW. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FRO THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 130,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE REAR LIFT GATE THAT EXTENDED ACROSS. THERE WERE ALSO THREE OTHER SMALLER CRACKS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT STATED THAT THE REAR WINDOW LOOKED AS IF IT WOULD EXPLODE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 83,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A CRACK IN THE PANEL ATTACHED TO THE GLASS OF THE REAR LIFTGAGE. THE CRACK WAS SMALL AT FIRST BUT BECAME LARGER OVER TIME. THE VEHICLE HAD NOT BEEN TAKEN TO BE INSPECTED FOR THE PROBLEM. ALSO, THE HEATED STOPPED BLOWING HEAT AND WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BLEND DOOR ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. SHE NOTICED THAT THERE WERE CRACKS ON THE REAR LIFT GATE UNDERNEATH THE REAR WINDOW. AN AUTHORIZED DEALER WAS NOTIFIED AND INFORMED HER THAT THIS WAS A KNOWN FAILURE BUT SHE WOULD HAVE TO PAY TO HAVE IT REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 115,000.

A LITTLE OVER A YEAR AGO I AND A FRIEND CAME OUT OF A GROCERY STORE TO DISCOVER THERE WAS A HAIRLINE CRACK IN THE REAR PANEL OF MY 2003 FORD EXPLORER. I DROVE RIGHT OVER TO A FORD DEALERSHIP TO REPORT THE INCIDENT. I DO HAVE AN EXTENDED WARRANTY FOR 100,000 MILES. IT WAS REPORTED TO THE WARRANTY COMPANY AND I WAS DENIED REPAIR. I WAS TOLD I COULD PAY $1,000.00 TO HAVE IT REPAIRED OR PUT CAULKING ON IT TO HELP TO SEAL THE CRACK. I PUT THE CAULKING ON IT AS I DID NOT HAVE THE MONEY TO PAY TO HAVE IT FIXED. I AM RETIRED AND ON A FIXED INCOME. OVER THE COURSE OF TIME THE CRACK WIDENED CAUSING THE PANEL AND WINDOW TO SHIFT TO THE LEFT. ON MONDAY 4/12/10 I OPENED THE HATCHBACK WINDOW TO PLACE A FEW ITEMS INSIDE AND THE WINDOW CAME...

I OWN A 2003 FORD EXPLORER AND WAS CLOSING THE WINDOW OF THE BACK HATCH WHEN THE REAR LIFT GATE HINGE FAILED AND BROKE AND THE WINDOW BECAME DISLODGED AND HIT ME IN THE HEAD. MY SON WAS STANDING NEXT TO ME AND THANKFULLY THE WINDOW DIDN'T FALL OUT COMPLETELY AND LAND ON HIM! I HAVE CONTACTED FORD AND THEY SAID THAT ALTHOUGH THERE WAS A RECALL FOR THIS VERY SAME PROBLEM, YOUR AGENCY DID NOT IDENTIFY MY VEHICLE AS BEING AFFECTED AND THEY WILL NOT REPAIR IT AT THEIR COST. AGAIN, THEY SAID IT WAS BECAUSE YOUR AGENCY DID NOT IDENTIFY MY VEHICLE AS BEING AFFECTED BY THIS DEFECT. AT THE PRESENT TIME, THE WINDOW IS HANGING BY THE STRUTS AND THE LEFT HINGE. FURTHER, I HAVE GONE ONLINE AND SEEN THAT MANY OTHER PEOPLE HAVE HAD THIS VERY SAME PROBLEM AND IT WAS NOT COVERED BY FORD'S RECALL....

TL-*THE 2003 FORD EXPLORER. THE CONTACT STATED THAT THE PAINT PORTION ON THE LIFTGATE HAS CRACKED IN SEVERAL PLACES JUST UNDER THE GLASS. THE CONTACT FEELS THIS CAN BE A POTENTIAL SAFETY HAZARD BECAUSE THERE HAVE BEEN OTHER VEHICLES WHOSE REAR GLASS HAS BROKEN. THE FAILURE MILEAGE WAS 75000 AND THE CURRENT MILEAGE WAS 80000.

2003 FORD EXPLORER XLT - OVERDRIVE LIGHT STARTING FLASHING AND NOW THE TRANSMISSION SLIPS WHEN SHIFTING FROM 1ST TO SECOND GEAR. ENGINE REVS TO 3200 RPMS AND MAKES A LOUD NOISE BEFORE FEATHERING THE GAS TO GET THE TRANSMISSION TO SHIFT INTO 2ND GEAR. VERTICAL CRACK IN FIBERGLASS TAILGATE PANEL JUST BELOW REAR WINDOW GLASS. NO IMPACT TO TAILGATE OCCURRED-CRACK JUST APPEARED. *TR

2003 FORD EXPLORER , 70,000 MILES REAR LIFT GATE CRACKED IN MIDDLE SPLITTING OFF IN "Y" SHAPE THERE WAS NO IMPACT DONE TO MAKE THIS HAPPEN. HEARD LOUD POP TOLD THAT FORD WILL NOT DO ANYTHING & I WILL HAVE TO PAY OUT OF POCKET.*TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE CONTACT WAS EXAMINING THE VEHICLE SHE NOTICED THAT THERE WAS A LARGE CRACK ON THE PANEL UNDER THE REAR WINDOW. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 115,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK IN THE LIFT GATE WHICH INCLUDES A PLASTIC PART JUST BELOW THE WINDOW. THE FORD MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND HE SHOULD CALL NHTSA. THE FAILURE MILEAGE WAS 116,000. UPDATED 2/26/10 *CN UPDATED 07/09/10.*JB

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE REAR WINDOW PANEL HAS FRACTURED. THE DEALER WAS CONTACTED, AND HE WAS ADVISED THAT THE FORD MANUFACTURER DID NOT RECOGNIZE THIS FAILURE AS A DEFECT. NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 28,700.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED THAT THE REAR LIFTGATE WAS CRACKED ON HER VEHICLE. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT IT WAS NOT DEFECTIVE; THEREFORE, SHE WOULD HAVE TO PAY FOR THE REPAIR. THE CONTACT DISAGREES AND BELIEVES THE MANUFACTURER SHOULD PAY FOR THE REPAIR. THE MANUFACTURER STATED THAT THERE WAS NO DEFECT AND WILL NOT ASSIST WITH THE REPAIR. THE FAILURE MILEAGE WAS 39,000 AND CURRENT MILEAGE WAS 54,300. UPDATED 03-04-09 *BF THE BACK OF THE LIFTGATE PANEL BELOW THE WINDOW CRACKED. UPDATED 03/04/09. *JB

I HAVE A 2003 EDDIE BAUER FORD EXPLORER. LAST NIGHT, WHEN MY SON WAS ATTEMPTING TO CLOSE THE REAR LIFT GATE GLASS DOOR, THE HINGE ON THE PASSENGER SIDE BROKE OFF. THE GLASS LIFTGATE IS PRESENTLY BEING HELD UP BY THE OTHER HINGE AND IT WON'T BE LONG BEFORE THAT ONE BREAKS ALSO. I SPOKE WITH AN ANDREA AT FORD 1-800-392-3673 AND SHE BASICALLY TOLD ME THAT I WAS OUT OF LUCK, THAT I WOULD HAVE TO PAY FOR THE REPAIRS BECAUSE MY VEHICLE WAS NOT INCLUDED IN THE RECALL. I DON'T UNDERSTAND WHY, I TOLD HER THE DESCRIPTION OF MY VEHICLE. I HAVE A FRIEND WHO OWNS A FORD EXPLORER AND HE HAD THE SAME PROBLEM, AND SINCE HIS WAS INCLUDED IN THE RECALL, HE DIDN'T ENCOUNTER ANY PROBLEMS IN HAVING IT REPAIRED. YOU WONDER WHY SO MANY PEOPLE BUY JAPANESE CARS AND TRUCKS. HERE IS ONE OF MANY...

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED THAT THE LIFTGATE GLASS APPLIQUE WAS DAMAGED AND CRACKED. THE DEALER STATED THAT BECAUSE THERE WAS NO RECALL FOR THE FAILED COMPONENT, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000. UPDATED 10/16/08. *LJ UPDATED 10/17/08. *JB

THERE IS A VERTICAL CRACK THAT JUST APPEARED IN THE REAR HATCH OF MY 2003 FORD EXPLORER. WE TAKE VERY GOOD CARE OF OUR VEHICLES AND THIS TRUCK IS RARELY DRIVEN. IT IS ALSO PARKED IN OUR GARAGE EXCEPT WHEN BEING DRIVEN. I HAVE READ THAT THIS PROBLEM IS VERY COMMON IN THIS TRUCK. OUR "DOOR AJAR" LIGHT AND WARNING REGULARLY INDICATES THAT THE DOOR IS NOT CLOSED PROPERLY. IT HAS EVEN FLUNG OPEN WHILE WE ARE DRIVING. WE HAVE THE THIRD ROW SEAT IN THIS MODEL AND KEEP MY TWO 5 YEAR-OLDS IN THAT SEAT. IT WAS VERY FRIGHTENING WHEN THIS HAPPENED AND WE HAD TO PULL OVER SUDDENLY TO REMEDY THE PROBLEM. THERE IS A SERIOUS DEFECT IN THIS DESIGN WHICH CAN CAUSE INJURY TO THOSE IN THE VEHICLE OR AROUND YOU SINCE THE HATCH OPENING OUT OF NO WHERE IS STARTLING. *TR

THE BACK LIFT GATE PANEL IS CRACKED ON MY 2003 EXPLORER. I HAVE HAD THE CRACK FOR APPROX. 2 YEARS. THE CRACK HAS PROGRESSIVELY WORSENED. I TOOK IT TO THE DEALER AND THEY SAID " THERE HAS BEEN SEVERAL CASES SUCH AS THIS, BUT FORD HAS NOT ISSUED A RECALL" I HAVE SEEN SEVERAL EXPLORERS WITH THIS PROBLEM. I DO NOT THINK IT SHOULD BE MY RESPONSIBILITY TO COVER THIS WHEN IT IS OBVIOUSLY A FORD DEFECT. *TR

THE REAR HATCH HAS DEVELOPED A CRACK THROUGH THE MIDDLE OF THE PANEL JUST BELOW THE VISIBLE GLASS OF THE HATCH. THIS CRACK ENCOMPASSES THE REAR FORD LOGO. THIS CRACK OCCURRED WITHOUT ANY DAMAGE TO THE VEHICLE. *TR

REAR DOOR HATCH HAS CRACKED FROM THE BOTTOM OF THE WINDOW TO THE BOTTOM OF THE HATCH. *TR

I HAVE A 03 EXPLORER. AND MY HATCH CRACKED IN 07. WHEN I TOOK IT TO THE DEALERSHIP AFTER SEEING OTHER MODELS WITH THE SAME PROBLEM. I WAS INFORMED THERE WAS NO RECALL ON THE PART AND IT COST ME ROUGHLY $800.00 TO FIX. I FEEL AS THOUGH FORD SHOULD RECALL THE PART AND REFUND ALL THE CUSTOMERS WHO HAS HAD THE SAME PROBLEM, AND HAD TO SPEND $$ TO GET IT FIXED. *TR

THE REAR HATCH ON MY 2003 FORD EXPLORE XLT CRACKED IN 3 SEPARATE PLACES. THE VEHICLE IS PRIMARILY HOUSED IN A GARAGE. I CALLED FORD TO REPORT THE PROBLEM. THEY TOLD ME THEY WOULD NOT FULLY COVER THE DEFECT. THEY WOULD "HELP" SINCE IT WAS OUT OF WARRANTY. I FEEL THE CRACKS ARE A FLAW IN MANUFACTURING OR PRODUCT DESIGN. THEY SHOULD BE COVERED ENTIRELY BY THE MANUFACTURER. *TR

CRACK IN BODY OF TAILGATE WITH NO CAUSE; CRACK STARTS AT THE BOTTOM OF THE BACK WINDOW AND RUNS TO THE BOTTOM OF THE PLASTIC PANEL. I TOOK IT TO THE DEALERSHIP AND THEY SAID IT IS A KNOW DEFECT, BUT WILL NOT FIX IT. IN MY NEIGHBORHOOD ALONE, THERE ARE AT LEAST 4 OTHER EXPLORERS WITH THE SAME ISSUE. FORD NEEDS TO FIX THIS ! IT TAKES AWAY FROM THE TRADE-IN VALUE OF MY CAR. *TR

BODY PANEL BELOW REAR GLASS ON LIFT GATE IS CRACKED FROM TOP TO BOTTOM. I NOTICED THIS ON MANY EXPLORERS OF THE SAME APPROX. AGE WHILE SHOPPING FOR THIS VEHICLE. *TR

REAR TAILGATE MOLDING BELOW WINDOW CRACKED. APPEARS TO BE A PREVALENT FLAW BASED ON INTERNET RESEARCH. CALLED FORD AND THEY ADVISED IT WAS A KNOWN PROBLEM HOWEVER WERE NOT PLANNING TO RECALL. I BELIEVE THIS IS RELATED TO THE PRIOR RECALL OF REAR LIFTGATE GLASS AS THIS PART WAS NEW POST RECALL. *TR

PANEL BELOW GLASS ON LIFT GATE DEVELOP A CRACK. *TR

I OWN A 2003 FORD EXPLORER XLT 4WD. APPROXIMATELY 12 MONTHS AGO, THE REAR TRIM PANEL BENEATH THE REAR WINDOW CRACK DOWN THE MIDDLE. I CONTACTED MY NEAREST DEALER WHO INFORMED ME THAT WHILE FORD HAD RECOGNIZED THAT IT WAS A PROBLEM, THEY DID NOT PLAN TO ISSUE A TECHNICAL SERVICE BULLETIN OR RECALL. THE DEALER SERVICE REPS EVEN AGREED THAT THERE IS A SIGNIFICANT PROBLEM WITH EXPLORERS AND MOUNTAINEERS. I HAVE SEEN MANY OTHER EXPLORERS AND MOUNTAINEERS WITH THE SAME PROBLEM AS WELL AS MANY COMPLAINTS ON-LINE. TODAY THE REAR HATCH LEFT LATCH BROKE OFF CAUSING THE ENTIRE REAR LIFT GATE WINDOW TO NEARLY FALL OFF. THE PROBLEM COULD POSSIBLY BE RELATED DUE TO THE EARLIER CRACK CAUSING THE WEIGHT OF THE REAR GLASS TO SHIFT, PLACE TOO MUCH STRAIN ON THE LEFT LATCH. THE DEALER IS REPAIRING THE BROKEN LATCH, WINDOW MOLDING AND REAR HATCH STRUTS, UNDER AN...

2003 FORD EXPLORER CRACKED REAR HATCH WITHOUT IMPACT. WEATHER CONDITIONS WERE COLDER THAN NORMAL. THERE ARE TWO VERTICAL 1/4" CRACKS THAT APPEARED SUDDENLY BELOW THE REAR HATCH LIFT GATE WINDOW. WE HAD NOT USED THE BACK LIFT DOOR OR THE LIFT GATE WINDOW IN SEVERAL DAYS. *TR

CRACKED HATCH ON 2003 FORD EXPLORER. WORRIED THAT PANEL WILL FALL OFF. FORD DOES NOT WANT TO TAKE CARE OF THIS PROBLEM THAT IS OBVIOUSLY A DEFECT. HAVE READ THAT MANY OTHER PEOPLE AROUND COUNTRY HAVE SAME PROBLEM NO MATTER WHAT CLIMATE IS. FEEL THAT IT IS A SAFETY HAZARD WITH THE POSSIBILITY OF PANEL FALLING OFF WHILE DRIVING AND CREATING AN ADVERSE INCIDENT WHICH COULD CAUSE INJURY. *TR

REAR GLASS APPLIQUE UNDER REAR HATCH HAS CRACKED TWICE, FIRST TIME UNDER WARRANTY, SECOND TIME IT IS NOT COVERED. *TR

CRACK IN LIFTGATE OF 2003 FORD EXPLORER; NOTE: 2ND TIME IT HAS CRACKED, AFTER REPLACEMENT ONCE...NOW ABOUT 25,000 MILES LATER, SAME PROBLEM WITH NEW LIFTGATE. CRACK JUST "APPEARS". *TR

WHEN I GOT TO MY CAR THIS MORNING, THE MIDDLE OF THE BACK REAR PANEL OF MY '03 FORD EXPLORER EDDIE BAUER SERIES HAD CRACKED FROM BETWEEN THE WINDOW TO THE LATCH - RIGHT UNDER THE FORD EMBLEM. THERE WAS NO ACCIDENT - NOTHING THAT COULD HAVE CAUSED THIS DAMAGE. LUCKILY THERE ARE ONLY 51K MILES ON THE TRUCK, AND THE DEALER IS WILLING TO FIX WITH A $75 DEDUCTIBLE. *TR

HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2003/BODY_PAINT/CRACKED_PANEL_BELOW_THE_REAR_WINDOW.SHTML THE LINK ABOVE IS BASICALLY WHAT I EXPERIENCE - A CRACK IN MY BACK BODY PANEL - NO WRECK - NOTHING TO CAUSE IT - JUST SITTING THERE! FORD WILL NOT REPLACE - THEY CLAIM IT IS OUT OF WARRANTY - AS IF A BODY PANEL SHOULD CRACK BY ITSELF! *TR

BACK HATCH SPLIT ON 2003 FORD EXPLORER. *TR