2003 FORD EXPLORER Structurebody Problems

There is a crack down the middle section of the liftgate for quite some time. The liftgate has been unlocking and opening automatically by itself. On only rare occasions has the liftgate opened all the way while driving. On the morning of 7/28/2022 while the vehicle was parked in my driveway the liftgate was discovered to have again unlocked by itself and opened slightly and now with one of the two hinges holding the glass sheared leaving the liftgate glass hanging by only one hinge. With the glass now hanging without having both hinge supports functioning and the inability to close and lock the liftgate, 1) the glass could fall out while driving and 2) with the liftgate unable to now close and lock, contents of the back storage area could fall out of the vehicle while driving. On 8/1/2022 the vehicle was inspected by the foreman of the Service...

REAR WINDOW LOWER PANEL PLASTIC CRACKING UP, REPLACED THREE TIMES, STILL CRACKING DUE TO NO SUPPORT AND BENDING TOO MUCH, I CALLED FORD DOES NOT CARE IF CONTINUES CRACKING UP, IT LOOKS UGLY ALSO PANELS CAN CAUSE AN ACCIDENT TO OTHER CARS GETTING INTO THEIR WINDSHIELDS LOOSE PARTS. THEY KNOW ABOUT THE PROBLEM AND NOT FIXING IT.

AWOKE THE MORNING OF MAY 10, 2017 TO FIND THE ENTIRE BACK LIFTGATE AND WINDOW EXPLODED OUTWARDS AND INWARDS OF OUR FORD EXPLORER. THE VEHICLE WAS PARKED IN FRONT OF OUR HOME, WE ARE RURAL, SO NO EVIDENCE OF SOMEONE PURPOSELY BREAKING IT. OUR SHERIFF IN CASCADE COUNTY, MONTANA, STATED IT APPEARS TO BE SOMETHING INTERNAL PROBABLY THE LIFT STRUTS EXPLODING. THIS SEEMS TO BE A PROBLEM AS STATED ON MANY ONLINE SITES, AND MANY FORD EXPLORERS HAVE THIS PROBLEM. THIS PARTICLAR MODEL VIN NUMBER DID NOT SHOW UP AS RECALLED, ALTHOUGH WE SIT HERE LOOKING AT THE DAMAGE CAUSED BY THIS PROBLEM. WE WOULD APPRECIATE SOMEONE LOOKING INTO THIS, AS IT COULD HAPPEN TO ANYONE AND PROVE TO BE VERY DANGEROUS IF THIS VEHICLE WERE BEING DRIVEN WHEN THIS EXPLOSION OCCURED. PLEASE CHECK INTO THIS ASAP.

THE BACK LIFT GATE HAS A CRACK. I HAVE NOTICED THIS ON PRACTICALLY EVERY OTHER EXPLOER OF THIS YEAR. I CONTACTED FORD SEVERAL YEARS AGO AND THEY SAID SINCE IT WAS A DEFECT THAT WAS NOT A DANGER THEY WOULD NOT RECALL OR REPAIR IT.

CHAT CONVERSATION START 5:57PM GREETINGS, I SAW YOU COMMENTARY ABOUT THE FORD EXPLORER EXHAUST FUMES INSIDE THE CABIN, WELL I HAVE A 2004 FORD EXPLORER WITH THE SAME PROBLEM, I AM A MECHANIC I FIGURED MAY BE THE FILTER WAS CLOGGED WELL IT WAS NO FILTER, WHAT I FOUND THE VENT DOOR FELL OFF FROM THE PLACE WHERE IT SUPPOSE TO OPEN AND CLOSE LAYING DOWN ON THE FAN, SO I REINSTALLED BACK AND THE PROBLEM WAS FIXED, IT IS A POOR DESIGN FROM THE FORD COMPANY. I WAS LOOSING HEAT DURING WINTER AND NOT BE COOL AT THE SUMMER LOOSING THE THRU VENT OUT PLACE. FORD NEEDS TO FIX ALL THIS PROBLEMS ALONG WITH SEAT BELTS, REAR WINDOW QUARTER PANEL CRACKED NO ONE IS GETTING FORD TO DO RECALLS ON THIS ITEMS VERY POOR CONSTRUCTION.

THE REAR PANEL OF MY 2003 EXPLORER CRACKED TODAY FOR NO REASON. NOT SURE IF THIS IS A SAFETY CONCERN. WHEN I "GOOGLED" THE PROBLEM, IT SEEMS THIS IS A COMMON PROBLEM THAT FORD ONCE ADDRESSED.

THE REAR LIFT-GATE HAS A CRACKED PANEL.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE HINGE FRACTURED WHICH CAUSED THE LIFT GATE TO REMAIN UNLOCKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

I HAVE OWNED THIS 2003 FORD EXPLORER SINCE IT WAS BRAND NEW IN 2003. IT CURRENTLY HAS 70,009 MILES AND HAS BEEN KEPT IN A GARAGE AND NOT DRIVEN OFTEN OVER 13 YEARS. WITHIN TWO YEARS OF PURCHASING THIS VEHICLE I NOTICED A CRACK IN THE MIDDLE OF THE LIFT GATE UNDER THE GLASS. I TALKED TO TWO FORD DEALERSHIPS THAT ADVISED IT WAS NOT A DEFECT BUT MY FAULT FOR GLIDING THE GLASS TO HARSHLY. I HAD NOT USED THE GLASS OFTEN AND HAD NEVER SLAMMED IT.M SINCE THAT TIME I'VE SEEN HUNDREDS OF FORD EXPLORERS FROM THE EARLY TO MID 2000S WITH THE SAME CRACK IN THE SAME LOCATION. TODAY I WAS BEHIND FOUR DIFFERENT EXPLORERS FROM THE SAME TIME PERIOD AND ALL HAD THE SAME CRACK. I CHECKED ONLINE AND REALIZED THERE ARE THOUSANDS OF COMPLAINTS ABOUT THIS DEFECT WITH SOME DRIVERS STATING THE BACK GLASS BURSTS...

1. TRANSMISSION DOES NOT LET YOU ACCELARATE. PRESSURE BUILDS UP WHILE YOU ARE PRESSING ON THE GAS PEDAL AND IT DOESN'T INCREASE YOUR SPEED UNTIL 10 SECONDS OR SO OF PRESSING THE GAS PEDAL, AND THAN IT EXPLODES AND YOU ARE THRUST BACK WITH THE ACCELERATION. VERY DANGEROUS WHEN YOU ARE TRYING TO CHANGE LANES OR ARE ENTERING THE HIGHWAY. LACK OF ACCELERATION HAS ALMOST GOT US INTO A FEW ACCIDENTS. 2. SENSORS ARE NOT FUNCTIONING, CONSTANTLY TELLING ME THAT THE DOORS ARE OPEN. I DON'T KNOW WHEN A DOOR IS ACTUALLY OPEN OR NOT. 3. THE REAR HATCH IS CRACKED AND I'M AFRAID IT DOESN'T PROVIDE ENOUGH STABLE PRORECTECTION FOR THE REAR GLASS TO BE HELD IN PLACE PROPERPLY.

THE BRACKETS CONNECTED TO THE LIFTGATE RELEASED WHILE THE CAR WAS PARKED AND LOCKED AND BLEW THE BACK LIFTGATE PANEL OUT ALONG WITH SHATTERING THE GLASS.

I USED MY KEY REMOTE AND POPPED OPEN THE BACK HATCH AND WHILE THE HATCH WAS UP THE HINGE SNAPPED DROPPING THE HATCH ON MY HEAD NEARLY KNOCKING ME OUT COLD.

TL-THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE CLOSING THAT THE LIFTGATE BOTH HINGES FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE BOTH HINGES AND STRUTS WERE REPLACED. IN 2005, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE) HOWEVER,THE REMEDY WAS INSUFFICIENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,000. JS

I NOTICED THAT THE PAINT WAS PEELING OFF IN SEVERAL PLACES ON THE VEHICLE. SIX MONTHS LATER MORE PAINT HAS DISAPPEARED. *TR

NOTICED UPPER PART OF REAR TAILGATE UNDER GLASS NEXT TO FORD EMBLEM IS CRACKED FROM TOP TO BOTTOM. *TR

A RECALL WAS ISSUED FOR 2003 FORD EXPLORERS FOR THE HINGES ON THE BACK WINDOW TAILGATE. THE RIGHT SIDE HINGE ON MY 2003 FORD EXPLORER BROKE, I WAS FORTUNATE TO BE STRONG ENOUGH TO CATCH THE GLASS BEFORE IT SNAPPED THE OTHER HINGE. WHEN I CONTACTED FORD AFTER SEEING THE RECALL NOTICE ONLINE, I WAS TOLD MY FORD WAS NOT PART OF THE RECALL. I HAVE ALSO CHECKED ON THE NHTSA SITE AND IT WAS NOT LISTED THERE EITHER. MY COMPLAINT IS THAT IF EXPLORERS OF THE SAME YEAR ARE RECALLED AND MY HINGE BROKE, I BELIEVE THERE MAY BE AN ISSUE WITH A LARGER RANGE OF EXPLORERS THAN LISTED. *TR

2 COMPLAINTS - BACK REAR HATCH PANEL UNDER REAR WINDOW HAS MULTIPLE CRACKS LIVE IN AUGUSTA GA AND VISIT FLORIDA AND THIS SEEMS TO BE A COMMON PROBLEM EVERY MAKE BODY LIKE MINE HAVE THIS CRACK AND SOME PANEL HAS EVEN FALLEN OFF. THIS HAS TO BE A MANUFACTURING PROBLEM FOR THIS LARGE AMOUNT OF SUV'S TO HAVE THE SAME PROBLEM SEE MORE WITH PROBLEMS THAN WITHOUT. ALSO RECENTLY HAD PROBLEMS WITH WINDOW INTERMITTENTLY NOT GOING DOWN AND BACK UP AFTER ICE STORM IN AUGUSTA THIS YEAR ALL FOUR WINDOWS STOPPED GOING UP AND DOWN. THIS ALSO SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL AND BODY STYLE OF FORD EXPLORERS. OWNED A 1993 FORD EXPLORER EDDIE BAUER HAD APPROX. 300,000 MILES ON IT BEFORE I GOT RID OF IT AND THE MOST HAPPENED TO THIS CAR WAS THE TRANSMISSION AND REAR BRAKE LEAK WHICH WAS THE MOST EXPENSIVE...

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFT GATE WINDOW BECAME DETACHED INTERMITTENTLY. THE LIFTGATE DOOR FAILED TO CLOSE PROPERLY AND IT DEVELOPED A CRACK AT THE BOTTOM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LIFT GATE NEEDED TO BE REPAIRED AND THE WINDOW NEEDED TO BE REPLACED. THE CONTACT WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE). THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED BY AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,002.

PAINT "BUBBLED UP" ON THE FRONT EDGE OF THE HOOD A FEW YEARS AFTER PURCHASE AND HAS CONTINUED TO FLAKE AND PEEL OFF. APPLE VALLEY FORD SERVICE REFUSED TO FIX THE PAINT PROBLEM WHEN REPORTED IN APPROXIMATELY 2006. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE POWER STEERING AND TRANSMISSION LINES FAILED DUE TO CORROSION. THE CONTACT ALSO STATED THAT THE BRAKES LINES, FUEL TANK COVER, DOOR LOCKS AND THE RUNNING BOARDS WERE ALSO CORRODED. THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 157,372. RK

WHILE DRIVING AT APPROXIMATELY 35 MPH, THE TOP PORTION OF THE LIFTGATE ON THE VEHICLE OPENED INDEPENDENTLY AND THEN THE DRIVER SIDE HINGE FRACTURED CAUSING THE LIFTGATE TO FALL AND HANG BY ONLY ONE SIDE. IN ADDITION, THE COMPRESSION ROD WAS BENT WHEN THIS OCCURRED. IN ORDER TO CONTINUE DRIVING THE VEHICLE THE COMPRESSION ROD HAD TO BE REMOVED AND THE LIFTGATE HAD TO BE TEMPORARILY FASTENED WITH HARNESSES. THE VEHICLE WAS THEN TAKEN TO A BODY SHOP TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE MILEAGE WAS 83,000. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT DOOR WAS MISALIGNED AND BECAME CRACKED. THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THE REAR LIFT DOOR HINGE HOWEVER, THE CONTACT STATED THAT THE REPAIR CAUSED THE MISALIGNMENT. THE CONTACT PURCHASED A NEW REAR LIFT DOOR AND THE DOOR WAS REPLACED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 5 AND THE CURRENT MILEAGE WAS 28,273.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE LIFT GATE OPENED INDEPENDENTLY AND CAUSED THE DRIVER'S SIDE HINGE TO BECOME FRACTURED. IN ADDITION, THE COMPRESSION ROD WAS ABNORMALLY BENT. THE CONTACT MADE A TEMPORARY ADJUSTMENT TO THE LIFT GATE IN ORDER TO CONTINUE DRIVING THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

PLASTIC REAR PANEL BELOW THE REAR GATE GLASS CRACKED DIRECTLY BESIDE THE FORD OVAL. THE PANEL IS NOW SPLIT INTO TWO PIECES. CONTACTED FORD DEALER AND FORD CUSTOMER SERVICE (VIA EMAIL) AND FORD WILL NOT STAND BEHIND THE FAILURE OF THIS PANEL. THIS IS A COMMON COMPLAINT WITH EXPLORERS AND FORD HAS NOT EVEN AS MUCH AS TRIED TO HELP THE CUSTOMER WITH REPAIRS. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE BACK PANEL BELOW THE WINDOW BECAME CRACKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR HITCH WAS CRACKED. IN ADDITION, THE DOOR AJAR WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE MECHANIC DID NOT DIAGNOSE OR REPAIRED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 125,000. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE TURNING AT VARIOUS SPEEDS, THE BODY OF THE VEHICLE BEGAN TO BOUNCE ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS STATED THAT THE BODY MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, SHE HEARD A LOUD, ABNORMAL NOISE. AFTER INSPECTING THE VEHICLE, SHE NOTICED THAT THE REAR DOOR HINGE WAS FRACTURED AND CAUSING THE DOOR TO HANG. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 99,600.

TL* THE CONTACT OWNS A 2003 FOR EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE ENGAGED THE LIFTGATE AND THE HINGES FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,000. *UPDATED 09-18-13 *BF UPDATED 09/24/2013 *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE REAR LIFT GATE GLASS HINGE CORRODED AND FRACTURED FROM THE VEHICLE. THE VEHICLE WAS PREVIOUSLY INCLUDED AND REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT BOTH OF THE HINGES WERE CORRODED AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 121,000. *TR

THERE HAS BEEN NO ACCIDENT. UNDER NORMAL WEAR AND TEAR OF CAR WENT TO OPEN HATCHBACK GLASS ONE DAY TO LOAD GROCERIES AND DROPPED LOW ON MY HEAD BECAUSE HINGE HOLDING THE GLASS DOOR CAME LOOSE. HAD TO EASE IT BACK UP IN PLACE , HAVE NOT BEEN ABLE TO OPEN GLASS DOOR SINCE FOR FEAR OF IT FALLING AND BREAKING TO PIECES. THE SECOND COMPLAINT IS THE HATCHBACK DOOR IS CRACKED UNDER THE FORD EMBLEM AND TO THE SIDE . I HAVE SEEN MANY MANY EXPLORERS WITH THIS SAME EXACT CRACK AS MINE. THEY HAVE ALSO COMPLAINED!!!! FORD ONLY RECALLED EXPLORERS UP TO I BELIEVE THAT WERE MADE UP TO FEBRUARY 2003. MY CAR AND OTHERS I HAVE SPOKE WITH THEIR AND MINE WAS MADE IN 8/2003 SO WE WERE NOT COVERED!!! THAT IS BULL!! FORD SHOULD STAND BY THEIR PRODUCTS. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE TAILGATE WAS CRACKED. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THE LIFT GATE WAS NOT UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 110,000. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED A FRACTURE ON THE REAR LIFT GATE PANEL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TR UPDATED 5/24/13 *CN UPDATED 06/12/2013 *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT HE NOTICED THAT THE LIFT GATE WAS FRACTURED NEAR THE MANUFACTURING EMBLEM. THE FAILURE CAUSED THE INTERIOR LIGHTS AND THE ANTI-THEFT ALARM TO ACTIVATE. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE). THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. THE CURRENT MILEAGE WAS APPROXIMATELY 140,000. *TR

A CRACK ON THE REAR HATCH NEXT TO FORD EMBLEM. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT NOTICED A LARGE FRACTURE UNDER THE REAR LIFTGATE GLASS NEAR THE MANUFACTURING EMBLEM. THE FRACTURE WAS APPROXIMATELY SIX INCHES LONG. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE WAS FRACTURED NEAR THE WINDOW. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THEY WOULD LOOK FURTHER INTO THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A FRACTURE IN THE TRIM THAT HELD THE REAR WINDOW IN PLACE. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE PART WAS DEFECTIVE AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 20,000. ...UPDATED 12/17/12 *BF

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFT GATE WINDOW DETACHED FROM THE HINGES AND CRACK THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE HINGES NEEDED TO BE REPLACED. THE DEALER ALSO STATED THAT THE VEHICLE WAS UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS). THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED AND THE DOOR WAS STILL CRACKED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO KEEP THE RECEIPTS IN CASE OF ANOTHER RECALL. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE HAD DEVELOPED A CRACK ON THE TAILGATE OF THE VEHICLE UNDER THE REAR WINDOW. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO STATED THERE HAD NOT BEEN ENOUGH COMPLAINTS TO ISSUE A RECALL AND REFERRED HER TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFT GATE WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE IT WAS FOUND THAT THE HINGE FOR THE LIFTGATE WAS BROKEN. THE VEHICLE WAS NOT TAKEN TO A MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED WHO INFORMED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS). THE FAILURE AND CURRENT MILEAGE WAS 110,308.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HINGES ON THE BACK LIFT GATE FRACTURED AND ALLOWED THE GLASS TO BECOME DISENGAGED. THE VEHICLE COULD NOT BE DRIVEN. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO STATED THAT THE VEHICLE HAD BEEN REPAIRED UNDER THE RECALL NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS) 8 YEARS PRIOR AND PROVIDED NO OTHER ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE LIFT GATE HINGES WERE FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 82,000.....UPDATED 10/11/12 *BF UPDATED 10/16/2012 *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE HINGES FOR THE REAR LIFT GATE FRACTURED. THE CONTACT MENTIONED THAT THE GLASS FELL DOWN INTO THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER AND HAD THE HINGES WERE REPLACED. THE MANUFACTURER WAS CONTACTED WHO STATED THAT THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS) BUT THE VEHICLE WAS NOT INCLUDED SINCE THE RECALL WAS ONLY ISSUED FOR THE 2002 MODEL YEAR EXPLORER. THE FAILURE AND CURRENT MILEAGE WAS 115,000.

REAR WINDOW HINGES BROKE FOR THE SECOND TIME. THEY WERE FIXED ONCE WITH RECALL AND ARE NOW BROKE AGAIN. ALSO THE BACK LIFT GATE PANEL HAS CRACKED. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THERE WERE TWO LARGE CRACKS BELOW THE REAR LIFTGATE, LOCATED NEAR THE MANUFACTURER'S EMBLEM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY WERE UNABLE TO PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER XLT. THE CONTACT STATED THAT A CRACK WAS FOUND IN THE REAR DOOR PANEL. THE CRACK WAS NOTICED WHILE THE VEHICLE WAS PARKED IN THE CONTACT'S GARAGE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 125,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE REAR LIFT GATE DETACHED FROM THE HINGES OF THE VEHICLE. THE DEALER WAS NOTIFIED AND STATED THERE WAS A RECALL BUT THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS). THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE WINDOW ON THE REAR HATCH DEVELOPED A CRACK AND THE HINGE WAS BENT DUE TO DEFECTIVE MATERIAL. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE REPAIRS ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS) WERE PREVIOUSLY PERFORMED. THE MANUFACTURER WOULD NOT PROVIDE FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,000 AND THE CURRENT MILEAGE WAS 64,000.