2003 FORD EXPLORER Power Trainautomatic Transmission Problems

I WENT TO LEAVE FOR WORK ONE MORNING & I NOTICED THE REAR PANEL WAS CRACKED. IT WASN'T LIKE THAT THE NIGHT BEFORE, SO IT LITERALLY HAPPENED OVERNIGHT. MY MECHANIC SAID IT WAS COSMETIC & COMMON PROBLEM WITH THESE TRUCKS. I WAS TOLD THE WINDOW WOULD BE FINE, BUT THERE IS A CHANCE OF THE PANEL PIECE FALLING OFF. I HAVEN'T HAD IT FIXED YET DUE TO THE EXPENSE, BUT I AM AFRAID A PIECE MAY FALL OFF WHILE DRIVING WHICH COULD INJURE SOMEONE. TO ADD INSULT TO INJURY, A WEEK LATER, MY TRANSMISSION STARTED SLIPPING & THE O/D LIGHT WAS FLASHING. I HAD IT TOWED & SURE ENOUGH, IT HAD TO BE REBUILT. IT ALSO NEEDED A NEW HUB BEARING AND BOTH FRONT BALL JOINTS HAD TO BE REPLACED. *KB

TL* THE CONTACT OWNS A 2003 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT WAS DRIVING 30 MPH WHEN THE OVERDRIVE WARNING LIGHT ILLUMINATED AND THE VEHICLE BECAME HARD TO SHIFT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE IT WAS DIAGNOSED THAT THE OVERDRIVE BAND WAS FRACTURED AND POSSIBLY HAD CAUSED DAMAGE TO THE TORQUE CONVERTER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 34,029 AND THE CURRENT MILEAGE WAS 64,846. UPDATED 11/22/11*LJ THE CONSUMER STATED THE SHIFTING WAS ERRATIC AT STEADY SPEEDS, THERE WAS A HARD BANG WHEN SHIFTING. THE PCM WAS REPROGRAMMED. THERE WAS A CLUNK NOISE WHEN COMING TO A STOP. THE DEALER REPLACED THE TRANSMISSION FLUID. THE OVERDRIVE LIGHT ILLUMINATED AND 95% OF THE TIME, THE VEHICLE WOULD NOT SHIFT OUT OF 1ST GEAR. UPDATED 03/12/12

TRANSMISSION FAILURE....O/D LIGHT FLASHES AND SERVICE ENGINE LIGHT STAYS ON. *TR

THE TRANSMISSION ON MY 2003 FORD EXPLORER IS GONE. *KB

O/D LIGHT SPONTANEOUSLY CAME ON. CAN NOT BE TURNED OFF. TRANSMISSION TAKES OFF SLOW. FIRST GEAR SLAMS INTO SECOND, WITH SLOW TAKEOFF CAUSES CARS BEHIND ME TO STOP SHORT BECAUSE MY TAKEOFF IS VERY SLOW. *TR

MY 2003 FORD EXPLORER HAD A "THUNK" NOISE FROM DAY ONE. FORD DEALERSHIP "COULD NOT DUPLICATE" THE COMPLAINT EVEN THOUGH I TOOK IT BACK MULTIPLE TIMES. HAD TO REPLACE THE TORQUE CONVERTER AT 70K MILES AND NOW AT 135K MILES THE WHOLE TRANSMISSION AND ANOTHER TORQUE CONVERTER FOR RATTLING AGAIN. OD/OFF BLINKING LIGHT AND CHECK TRANSMISSION NOTICE CAME ON WITH ERRATIC SHIFTING AND LOSS OF 2ND AND 5TH GEARS. REPLACEMENT OF TRANS ELIMINATED "THUNK" AND MY $4600. SIMILAR COMPLAINTS WITHOUT ANY ACKNOWLEDGEMENT OF FAULTY MATERIALS OR ENGINEERING BY FORD HAS PLAGUED HUNDREDS IF NOT THOUSANDS OF EXPLORER OWNERS. WHERE IS THE EXPECTED INVESTIGATION OF THESE PROBLEMS? WHY DO WE HAVE TO WAIT UNTIL ACCIDENTS OR INJURY TO HAVE FAULTY AUTOS RECALLED? WHY ARE SPARK PLUGS EJECTED MORE OF A SAFETY CONCERN THAN TRANSMISSIONS THAT LEAVE DRIVERS WITHOUT PROPER MOVING CAPABILITY ON THE HIGHWAY? WHERE IS THE RECALL FOR THESE UNITS?...

THE TRANSMISSION ON OUR 2003 FORD EXPLORER HAD TO BE REPLACED. IT COULD HAVE LEFT US STRANDED ON THE ROAD. FORD KNEW OF THIS PROBLEM WITH THE TRANSMISSIONS ON THE 2003-2004 EXPLORERS. I THINK THEY SHOULD MAKE AN ADJUSTMENT ON THE COST OF THE REPAIRS. TRANSMISSION ARE SUPPOSED TO LAST LONGER THAN 71,000 MILES. WE DID NOT MISTREAT THIS VEHICLE IN ANY WAY. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE OVER DRIVE LIGHT BEGAN ILLUMINATING ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO SHIFT INTO A HIGHER GEAR. THE CONTACT TURNED THE VEHICLE OFF AND UPON RESTARTING IT, THE VEHICLE BEGAN TO FUNCTION NORMALLY. AFTER DRIVING FOR A FEW MILES, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 111,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE DOOR AJAR LIGHT ILLUMINATED FREQUENTLY AND THE DOME LIGHT STAYED ILLUMINATED EVEN WHEN THE DOORS WERE CLOSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A MANUFACTURERS RECALL AND THE DEALER STATED THAT THE REPAIR HAD PREVIOUSLY BEEN PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE HESITATED INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 72,000. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000.

MY 2003 FORD EXPLORER WAS PARKED IN MY DRIVEWAY AND IT SOMEHOW ROLLED DOWN APPROX 150 FEET AND SMASHED INTO A TREE. THERE WAS NO ONE IN THE VEHICLE IT WAS PARKED AND THE KEYS WERE IN THE HOUSE. I IMMEDIATELY CALLED MY INSURANCE (STATE FARM) AND THEY HAD ME CALL A COLLISION GARAGE TO COME OUT AND THEY CAME WITHIN THE HOUR. THEY HAVE STATED THAT THE VEHICLE IS A TOTAL LOSS. THE NEXT MORNING I CALLED FORD AND THEY DISREGARDED ANYTHING I SAID AND SAID MY INSURANCE SHOULD TAKE CARE OF IT. I AM STILL PAYING ON A LOAN FOR THIS CAR AND I DO HAVE FULL COVERAGE BUT I AM NOW WITHOUT A VEHICLE AND I AM SCARED TO THINK OF WHAT MIGHT OF HAPPENED IF MY DAUGHTERS WOULD OF BEEN PLAYING IN THE BACKYARD. *TR

TRANSMISSION PROBLEMS STARTED AROUND 100K MILES; HIGH RPM SHIFTING BETWEEN 1ST AND 2ND GEAR WITH SUBSEQUENT FLASHING O/D LIGHT. MANY TIMES TRANSMISSION WILL "CLUNK" INTO GEAR EITHER FROM GOING INTO REVERSE, STOPPING COMPLETELY, THEN SHIFTING INTO DRIVE AND/OR WHEN PUTTING IN REVERSE OR DRIVE. APPEARS THIS IS A COMMON PROBLEM FOR MY MODEL YEAR EXPLORER (03) AND SAME CODE MANY OTHERS RECEIVE (P0775) WHICH REALLY DOES NOT DESCRIBE THE PROBLEM OR LEAD A NOT SO MECHANICAL INCLINED PERSON TO TRY AND TROUBLESHOOT/BUY PARTS TO FIX. I'M CAREER MILITARY MAN W/FAMILY AND MY TRUCK IS PAID OFF NEXT MONTH--OWNED 5 YEARS AND REALLY SUCKS TO HAVE TO POSSIBLY DUMP $3K INTO A TRUCK THAT FORD HAS KNOWN CONTAINED ISSUES WITH THE 5R55W TRANSMISSION. *TR

VEHICLE TRANSMISSION SLIPS OUT OF GEAR AND SOMETIMES WONT ENGAGE. FREQUENTLY OCCURS AT STOP/START MOVEMENTS. OCURRS IN FORWARD AND REVERSE. "O/D OFF" LIGHT IS FREQUENTLY DISPLAYED. UNSAFE TO DRIVE ANYWHERE!!! *TR

I HAVE A 2003 FORD EXPLORER AND MY O/D LIGHT KEEPS FLASHING I TOOK IT TO THE DEALER TO GET IT CHECKED AND THEY SAID I NEED A NEW TRANSMISSION BECAUSE I HAVE NO 2ND OR 5TH GEAR THEY ALSO SAID THIS IS A COMMON PROBLEM WITH THAT YEAR. THEY SAID THE SHIFT SEALNOID WENT OUT SO NOW I CANT DRIVE MY TRUCK TELL I CAN AFFORD 3400 DOLLARS TO GET IT FIXED SO THAT HAS MADE IT HARDER FOR ME TO GET TO WORK AND TO GET MY FAMILY WHERE THEY NEED TO BE. *TR

TRANSMISSION WENT OUT. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY WITH THE ILLUMINATION OF SEVERAL WARNING LIGHTS. THE FAILURE WOULD RECUR INTERMITTENTLY AND THE EITHER THE VEHICLE WOULD RESTART IMMEDIATELY OR THE VEHICLE WOULD BE TOWED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000. THE VIN WAS UNAVAILABLE.

I OWN A 2003 FORD EXPLORER, I HAVE OWNED IT FOR ALMOST 5 YEARS AND TOOK CARE OF IT. I ALSO PAID ALOT OF MONEY FOR IT AND AFTER ABOUT THREE YEARS OUT OF NOWHERE MY O/D LIGHT STARTED BLINKING AND MY CAR STARTED SHIFTING WRONG. I HAD THE SOLENOID ON TRANNY REPLACED SOON AS I PUT IT IN 4WHEEL DRIVE MY O/D LIGHT STARTED BLINKING AGAIN AND SHIFTING WRONG. THIS IS MAKING THE CAR ACCELERATE TO MUCH AT TIMES AND ALMOST NOT WANTING TO SHIFT OTHERS.SO WHILE WAITING THINKING I NEED A NEW TRANSMISSION MY ENGINE LIGHT COMES ON FOLLOWED BY A LIGHT TICKING NOISE, THAT GOT LOUDER AND LOUDER OVER ABOUT A MONTH.SO THE CAR WAS TAKEN TO THE DEALERSHIP AN PUT ON A COMPUTER THEY SAID I SHOULD JUNK IT, YES ITS 5 YEARS OLD BUT I BOUGHT MY CAR FROM THEIR AND I PAID ALOT FOR...

WELL THIS WILL BE THE 2ND TRANSMISSION FOR MY 2003 FORD EXPLORER, THE FIRST WAS AT 88700 MILES ABOUT 4 YEARS AGO. IT TOOK THE DEALERSHIP ALMOST 2 WEEKS TO FIGURE OUT WHAT WAS WRONG. THEN 2 WEEKS AFTER THAT HEARD A LOUD PING WHILE DRIVING HOME, AT 9:00 AT NIGHT, TOOK IN TO DEALER AND THE DRIVE SHAFT HAD WATER IN IT. NOW I AM THE ORIGINAL OWNER, TRUCK HAS NEVER BEEN OFF ROAD, NEVER TOWED ANYTHING, HIGHWAY MILES. SO, I FIX ALL THAT( ABOUT $3,000.00 IN ONE MONTH) NOW THIS PAST WEEKEND COMING HOME ON THE INTERSTATE TRUCK GIVES A LARGE SHUDDER 3 TIMES, I ALMOST GET RUN OVER BY A TOUR BUS BECAUSE TRUCK IS GETTING READY TO DIE. LIMP HOME CAN'T DRIVE OVER 60 MILES AN HOUR, WENT BACK ROADS HOME, DID NOT LIKE GOING UP SMALL HILLS. WHEN 1 MILE FROM HOME O/D OFF LIGHT...

I RECENTLY ENCOUNTERED PROBLEMS WITH MY VEHICLE'S ACCELERATION. THE VEHICLE THEN BEGAN TO BUCK, MAKE LOUD NOISES, THE CHECK ENGINE LIGHT CAME ON AND THEN THE O/D LIGHT BEGAN TO FLASH. I TOOK MY VEHICLE TO THE DEALER TO HAVE A DIAGNOSTICS TEST PERFORMED WHICH DETERMINED THAT MY TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE THAT I AM REFERENCING IS A 2003 FORD EXPLORER WITH 73,859 MILES (AT THE TIME OF THE DIAGNOSIS). I DID RESEARCH WHICH REVEALED THAT THIS HAS BEEN A COMMON ISSUE WITH 2003 FORD EXPLORERS WITH APPROXIMATELY THE SAME NUMBER OF MILES. I DID GET THE TRANSMISSION REPLACED IN MY VEHICLE, HOWEVER THE COMPLAINT IS THAT THESE VEHICLES ARE REQUIRING TRANSMISSION REPLACEMENTS AT SUCH LOW MILES. WITH ALL OF THE COMPLAINTS INVOLVING THIS ISSUE, IT SEEMS TO WARRANT AN INVESTIGATION INTO THE MATTER........PLEASE INVESTIGATE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT WAS TRAVELING 45 MPH WHEN THE OVER DRIVE WARNING LIGHT ILLUMINATED AND THE TRANSMISSION FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TORQUE CONVERTER, SERVO PACK AND CLUTCH WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE OVER-DRIVE AND ENGINE SERVICE WARNING INDICATORS ILLUMINATED. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED WHICH DETECTED THAT THE GEAR RATIO AND PRESSURE CONTROL SOLENOID WERE DEFECTIVE WITHIN THE TRANSMISSION. THE CONTACT WAS AWAITING THE PARTS FOR THE VEHICLE TO BE REPAIRED. THE FAILURE MILEAGE WAS 94,583. UPDATED 03/31/11*LJ UPDATED 04/05/11

I WAS DRIVING MY 2003 FORD EXPLORER XLT V6 4.0L ON I40W, WHEN ALL OF A SUDDEN THE VEHICLE BEGAN TO DECELERATE WHILE THE RPMS WERE CONSTANTLY GOING UP. THIS PUT ME IN THE INTERSTATE WITH NO POWER AS THE GEARS WEREN'T SHIFTING. I TOOK IT TO MY LOCAL FORD DEALERSHIP AND THEY PUT IT ON THE DIAGNOSTIC MACHINE AND TOLD ME THEY REALLY DIDN'T KNOW WHAT WAS WRONG WITH IT AND THAT THEY WOULD HAVE TO BREAK THE TRANSMISSION DOWN IN ORDER TO KNOW FOR SURE. I SEARCHED ONLINE FOR ANY COMMON TRANSMISSION PROBLEMS AND CAME ACROSS A SITE WHERE PEOPLE WITH VEHICLES JUST LIKE MINE HAVING THE SAME EXACT PROBLEM. AS OF NOW I'M STILL WAITING ON FORD TO LET ME KNOW WHAT'S GOING ON WITH MY TRUCK, BUT WITH HUNDREDS OF OTHER PEOPLE HAVING THE SAME PROBLEM I SEE NO REASON FOR THEM NOT KNOW WHAT THE...

THE TRANSMISSION WENT OUT SEVERAL MONTHS AFTER THE WARRANTY EXPIRED AND THE COMPANY DID NOTHING TO ADDRESS THIS...THE CAR WAS ONLY 5 YEARS OLD WHEN THIS HAPPENED AND WE HAD TO GET A NEW TRANSMISSION. *TR

NO SECOND GEAR. *TR

LIKE EVERY OTHER DAY, I STARTED THE SUV A FEW MINUTES BEFORE I HAD TO LEAVE TO LET IT WARM UP BECAUSE NY IS COLD, AND THEN LEFT TO RUN SOME ERRANDS. I REALIZED RIGHT AWAY THAT THE TRUCK SOUNDED A LITTLE FUNNY WHEN ACCELERATING, SO THE RADIO WENT OFF SO I COULD LISTEN. I FOUND THAT WHEN SHIFTING FROM FIRST TO SECOND, IN THIS AUTOMATIC VEHICLE, THE OVERDRIVE WAS KICKING ON PREMATURELY. THEN THE O/D LIGHT STARTED FLASHING. I CAME HOME AND STARTED RESEARCHING IT AND FOUND HUNDREDS OF COMPLAINTS, SO HERE I AM, IN THE SAME BOAT AS EVERYONE ELSE, ABOUT TO LOOK UP NUMBERS TO TRANSMISSION SPECIALISTS BECAUSE THE DEALER IS DEFINITELY NOT GOING TO MAKE ANY MONEY OFF OF MY WITH THIS ONE. *TR

I OWN A 2003 FORD EXPLORER AND HAVE NEVER HAD ANY PROBLEM WITH MY VEHICLE. I DO NOT DRIVE IT HARD AND MAKE SURE THAT IT GETS THE PROPER UPKEEP. AS I WAS DRIVING DOWN THE ROAD ONE DAY MY CHECK ENGINE LIGHT CAME ON. THE NEXT DAY ON MY WAY TO WORK I NOTICED THAT THE TRANSMISSION WAS HAVING TROUBLE SHIFTING AND THE TIME I GOT HOME THAT EVENING THE TRANSMISSION WAS SHIFTING VERY HARD IF IT WOULD EVEN SHIFT AT ALL. MY O/D OFF LIGHT ALSO STARTED FLASHING. I THOUGHT THAT IT WAS JUST A FLUKE WITH MY TRANSMISSION UNTIL I CHECKED ONLINE TO FIND THAT THERE IS ALOT OF OTHER PEOPLE HAVING THE SAME PROBLEM AND THAT FORD IS DOING NOTHING TO FIX THE PROBLEM. MY CAR IS CURRENTLY IN THE SHOP AND THEY HAVE SAID THAT IT WILL COST ATLEAST 3200 OR MORE TO FIX THE...

I WAS DRIVING MY 2003 FORD EXPLORER, AND ALL OF A SUDDEN WHEN MERGING ONTO THE HIGHWAY, MY OVERDRIVE LIGHT STARTED FLASHING, AND THE TRANSMISSION WON'T SHIFT OUT OF 1ST GEAR. ABSOLUTELY UNACCEPTABLE! AN 03?! PLEASE! *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE EXPERIENCED DIFFICULTY CHANGING GEARS WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE TRANSMISSION WAS REBUILT. APPROXIMATELY 3 YEARS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE TRANSMISSION WAS REBUILT. THE FAILURE MILEAGE WAS 54,655 AND THE CURRENT MILEAGE WAS 111,260.

SOME SORT OF TRANSMISSION FAILURE DEALING WITH THE SHIFTING SOLENOID. THIS LEADS TO SPORADIC SHIFTING BETWEEN THE LOWER GEARS. THIS LEAD TO VERY HARD DRIVING IN SLOW AND ICY CONDITIONS. THE CAR WOULD BE AT SUCH HIGH RPMS AT SLOW SPEEDS SUCH AS 20-30 MPH THAT THE CAR WOULD LOOSE TRACTION, SO FAR I HAVE HAD NO ACCIDENTS WITH THIS PROBLEM BUT THE POTENTIAL IS VERY APPARENT. *TR

SERVICE ENGINE LIGHT APPEARED, THEN THE OD (OVERDRIVE) LIGHT BEGAN FLASHING. THEN THE EXPLORER HAD DIFFICULTY ACCELERATING. THE ENGINE WAS RUNNING HIGHER RPMS THAN USUAL, ESPECIALLY WHEN ACCELERATING FROM 0 TO 30MPH. I TOOK THE EXPLORER TO THE FORD DEALER WHERE THE EXPLORER WAS PURCHASED AND EXCLUSIVELY SERVICED SINCE WHEN I BOUGHT IT NEW IN JULY 2003. THEY WOULD NOT ACKNOWLEDGE THAT THIS IS A PERSISTENT PROBLEM WITH 2003 EXPLORERS. THEY TOLD ME THAT I HAVE NO 2ND OR 5TH GEARS, INT. SERVO FAILED AND CASE BORE DAMAGED. THEY WANT OVER $3,600 TO REPAIR (AND THAT, THEY SAY IS A DISCOUNT!). I THEN TOOK IT TO A TRANSMISSION SHOP, WHO WAS WELL AWARE OF THIS PROBLEM AND THERE WERE 2 OTHER EXPLORERS CURRENTLY THERE BEING REPAIRED FOR THE SAME THING. AN INVESTIGATION NEEDS TO BE DONE FOR A RECALL. THIS IS A SAFETY ISSUE AND A CONSUMER RIP-OFF! *TR

MY 2003 FORD EXPLORER XLT ONLY HAS 70000K AND THE TRANSMISSION IS COMPLETELY IN NEED OF REBUILD. IT DOESN'T DRIVE IN REVERSE AND DOESN'T GO FASTER THAN 25MPH WITHOUT SOUNDING AS IF THE ENGINE IS GOING TO FALL OFF. IT KICKS BACK WHILE ATTEMPTING TO CHANGE GEARS AND THE RPM IS WORKING HARD WITH THE TRUCK GOING NOWHERE FAST. I CANT AFFORD TO REPAIR THE PROBLEM AS IM STILL MAKING MONTHLY PAYMENTS ON IT. THIS SHOULD NOT BE HAPPENING WITH AN EIGHT YEAR OLD VEHICLE. THIS LITTLE BIT OF INFORMATION ON HOW THERE IS NO DIPSTICK TO CHECK THE TRANSMISSION FLUID SHOULD HAVE BEEN REVEALED AT TIME OF PURCHASE I THINK. *TR

"OD (OVERDRIVE)" LIGHT BLINKING IN DASH. THEN "SERVICE ENGINE SOON" LIGHT ON 12-31-10. HIGHER RPM'S IN ENGINE THEN USUAL, TO SHIFT GEARS IN AUTOMATIC TRANSMISSION. TRANS HAVING THUMPING SOUNDING WHEN PLACED INTO PARK, DRIVE OR REVERSE. BROKEN SERVO SIDEARM INSIDE TRANSMISSION.. VEHICLE ONLY HAS 62,000 MILES ON IT. TAKEN TO LOCAL TRANSMISSION SHOP. ESTIMATE OF $1,475 TO FIX. *TR

PROBLEMS WITH THE REAR PANEL CRACKING UP, BEING REPLACED TWICE, STILL CRACKED AGAIN, ALSO THE TRANSMISSION NOT ABLE TO CHECK IT DURING A TRIP UNLESS YOU GO UNDER THE TRUCK, LAST THING THE BRAKE LIGHT SWITCH STICKING CAUSING TO DRAIN BATTERY AND NOT ABLE TO ORDER PART BECAUSE THE MANUAL ARE WRONG. *TR

O/D OFF LIGHT BLINKS ON DASHBOARD AND VEHICLE SHIFTS HARD. WAS ADVISED THAT TRANSMISSION REBUILD WAS NECESSARY. *TR

2003 FORD EXPLORER 5R55-W TRANSMISSION FAILURE WHEREIN THE INTERNAL LINKAGES, SERVO VALVE AND BEARINGS FAILED AT STARTUP, RENDERING THE VEHICLE UNMOVABLE UNDER IT'S OWN POWER AND STRANDING THE DRIVER. *TR

I SENT A LETTER OF COMPLAINT TO FORD REGARDING MY SITUATION WITH MY TRANSMISSION FAILING ON ME AND THE LOCAL FORD DEALER CHARGING ME $4,300 SINCE MY CAR IS NO LONGER UNDER WARRANTY. I TRULY HOPE THAT FORD GETS THEIR ACT TOGETHER AND ADDRESSES THIS ISSUES AS I'M SEEING MORE AND MORE COMPLAINTS POP-UP EVERYWHERE REGARDING THIS. POOR EXCUSE!!! DEAR VALUED CUSTOMER, THANK YOU FOR CONTACTING THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER INQUIRING FOR ANY RECALLS ON YOUR 2003 FORD EXPLORER. I SINCERELY UNDERSTAND THE FRUSTRATION THAT THIS TRANSMISSION CONCERN ON YOUR VEHICLE HAS BROUGHT YOU. PLEASE BE INFORMED THAT FORD MOTOR COMPANY IS WORKING WITH THE NATIONAL HIGHWAY TRAFFIC AND SAFETY ADMINISTRATION (NHTSA) TO PROACTIVELY IDENTIFY AREAS OF CONCERN THROUGH INVESTIGATION OF CONSUMER AND DEALERSHIP FEEDBACK. IF A CONCERN IS NOTED, A RECALL IS CONDUCTED TO REMEDY A SAFETY OR EMISSIONS CONCERN IN THE INTEREST OF CUSTOMER SATISFACTION...

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH WHEN THE RPMS INCREASED UP TO 405 AND THE OVER DRIVE LIGHT ILLUMINATED AS WELL. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND WAS ABLE TO RESTART THE VEHICLE IT RECURRED. THE DEALER WAS INFORMED ABOUT THE FAILURE AND THEY STATED THAT THE BANDS IN THE TRANSMISSION ARE SHOT AND WILL HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 62000 AND THE CURRENT MILEAGE WAS 62010.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER XLT (N/A). WHILE DRIVING THE OVER DRIVE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE MECHANIC LOCATED THE FAILURE AT THE TRANSMISSION SOLENOID. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THERE WERE NO RELATED RECALLS. THE CONTACT PLANNED TO HAVE THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000 THE CURRENT MILEAGE WAS APPROXIMATELY 153,300.

THERE HAVE BEEN MULTIPLE PROBLEMS WITH MY 2003 FORD EXPLORER SINCE I BOUGHT IT BRAND NEW IN AUGUST OF 2003. BUT IRONICALLY THEY HAVE ALL APPEARED AFTER THE WARRANTY HAD EXPIRED. IN SEPTEMBER 2007 THE AIR CONDITIONING UNIT NO LONGER WORKED. IT COST ME $2000 AND A WEEK WITHOUT A CAR, TO GET IT FIXED. IN AUGUST 2009 THE PASSENGER DOOR WINDOW WOULD NO LONGER WORK. IN SEPTEMBER 2009 MY SUV STARTED MAKING A CLICKING SOUND WHEN TURNING ON THE HEATER. SINCE WE LIVED IN A WARM CLIMATE THIS DID NOT CONCERN US MUCH, AS THE HEAT HAD WORKED EVEN WITH THE CLICKING SOUND. BUT WE MOVED TO A COLDER CLIMATE AND THE HEATER WENT OUT IN MARCH 2010. IN APRIL 2010 THE SERVICE ENGINE LIGHT CAME ON. AFTER SPEAKING WITH THE MECHANIC, HE SAID IT WAS A TRANSMISSION PROBLEM THAT OCCURRED WHEN THE CAR SHIFTED FROM 1ST TO 2ND...

O/D LIGHT BEGAN FLASHING AND TRANSMISSION STARTED TO SLIP FROM 2ND T 3RD GEAR. HAD THE TRANS SOLENOID PACK REPLACED WHICH HELPED FOR AWHILE BUT PROBLEM CAME BACK AFTER A MONTH OR SO. TOOK IT TO REPAIR SHOP AGAIN AND THIS TIME THEY SAID IT'S THE 4TH AND 5TH GEAR SERVOS. *TR

2003 FORD EXPLORER WITH 74,000 MILES ON IT - O/D LIGHT BEGAN FLASHING. AROUND THE SAME TIME I NOTICED THAT WHEN GOING FROM A STOP TO A START IT WOULD TAKE A LONG TIME TO SHIFT INTO GEAR. TOOK IT INTO THE MECHANIC - SUGGESTED A NEW TRANSMISSION FOR $4100!!! FOR A CAR THAT HAS LESS THAN 100,000 MILES THIS IS RIDICULOUS. *TR

THE TRANSMISSIONS IS FAILING IN 2ND AND 5TH GEAR. IT OCCURS EVERYDAY AND YOU CAN NOT ACCELERATE WITHOUT IT STICKING IN A HIGHER GEAR, MAKING IT DIFFICULT TO STOP SAFELY. *TR

WITH NO WARNING, WHILE DRIVING MY 2003 EXPLORER YESTERDAY, THE O/D OFF LIGHT COMES ON THEN THE CHECK TRANSMISSION LIGHT ALSO COMES ON. AFTER THAT I NOTICE THE SHIFTING OF GEARS FEELS REALLY WEIRD. IT SHIFTS SLOWER AND HARDER WHEN IT SHIFTS. I CANNOT DRIVE THE CAR BECAUSE IT IS UNSAFE FOR ME AND MY 2 YOUNG CHILDREN. THE REPAIR SHOP SAYS I NEED A NEW TRANSMISSION WHICH WILL COST ME $2000 THAT I DON'T HAVE, TO PUT INTO A VEHICLE I AM STILL PAYING ON. IF I CONTINUE TO DRIVE IT WITH THE TRANSMISSION THE WAY IT IS NOW, IT COULD LOCK UP AND MAKE ME STOP IN THE MIDDLE OF THE ROAD, AND POSSIBLE GET MYSELF AND OTHERS SERIOUSLY INJURED OR KILLED. THIS SEEMS TO BE A PROBLEM WITH THIS MAKE, MODEL AND YEAR VEHICLE THAT I HAVE, BUT I DIDN'T NOT KNOW THAT UNTIL I BEGAN DOING...

I OWN A 2003 FORD EXPLORER-4.6 LITER V8 4 WHEEL DRIVE, THE VEHICLE HAS 158,000 MILES AND HAVE EXPERIENCED THE SPARKPLUG BLOWOUT WHILE DRIVING HOME FROM WORK. I WAS TRAVELING ON A BUSY STATE ROAD WHEN THE ENGINE MISS FIRED AND THEN HEARD A LOUD POP AND THE ENGINE WENT TO MISSING BAD. I IMMEDIATELY PULLED TO THE SIDE AND CHECKED TO SEE WHAT WAS HAPPENING. I LIMPED THE VEHICLE INTO A PARKING LOT AND PROCEEDED TO REINSTALL THE PLUG AND COIL PACK. THE FORCING PUSH OF THE PLUG BROKE THE COIL PACK AND TORE THE PLUG BOOT. I JUST REPLACED THE COIL PACK AND PLUG BOOT ASSEMBLY AND REINSTALLED THE PLUG BCK IN. I FEEL THAT THIS ISSUE IS COMMON ON THE 4.6 LITERS, A FRIEND AND SHADETREE MECHANIC DID A MOTOR SWAP IN AN EXPEDITION WITH THIS SAME MOTOR FOR THE SAME REASON CAUSE THE PLUG IN CYLINDER...

OVERDRIVE LIGHT IS BLINKING AND TRANSMISSION IS SHIFTING HARD AND SOMETIMES NOT AT ALL. THE CAR HAS 90,000 MILES ON IT. NOTHING HAS EVER BEEN TOED. IT IS A DAILY COMMUTE CAR I HAVE OWNED SINCE BRAND NEW. THERE IS NO WAY I SHOULD ALREADY NEED A NEW TRANSMISSION. ALSO THE WHEEL BEARINGS HAVE GONE ON BOTH SIDES OF THE FRONT OF MY CAR. THIS HAS HAPPENED TO COUNTLESS OTHER PEOPLE WITH THIS YEAR (2003) EXPLORER. I HAVE RESEARCHED BOTH AND THIS IS A COMMON OCCURRENCE WITH THIS CAR. AND BOTH ARE EXTREMELY HAZARDOUS FOR SAFETY REASONS. I BELIEVE THIS IS A HUGE DEFECT FROM FORD AND NEEDS TO BE INVESTIGATED. *TR

I HAVE A 2003 FORD EXPLORER WITH APPROX. 70,000 MILES ON IT. ON JULY 15, 2010, I NOTICED THAT THE OVERDRIVE LIGHT WAS FLASHING ON AND OFF AND THEN THE CHECK ENGINE LIGHT TURNED ON. THIS PROBLEM HAPPENED ON AND OFF FOR ABOUT A WEEK. ON JULY 26, 2010, I TOOK THE VEHICLE IN FOR REPAIR AND WAS TOLD THAT I NEEDED A NEW TRANSMISSION AND A NEW SOLENOID PACK. THE COST OF THESE ITEMS WAS $2,500! I PROCEEDED TO DO SOME INTERNET RESEARCH AND FOUND THAT THIS SEEMS TO BE A COMMON PROBLEM WITH THE 2002 AND 2003 FORD EXPLORERS. THE TRANSMISSIONS OF THESE VEHICLES HAVE MAJOR PROBLEMS AS NO ONE SHOULD HAVE TO REPLACE A TRANSMISSION WITH ONLY 70,000 MILES ON IT. I FEEL FORD NEEDS TO ISSUE A RECALL OF THIS ITEM AS IT HAS CAUSED MANY PEOPLE A LOT OF MONEY TO REPAIR. *TR

WHILE I AM DRIVING THE TRUCK SLOWS DOWN THEN SPEEDS BACK UP. VEHICLE IS ONLY 7 YEARS OLD AND HAS 71,000 MILES, A FEW DAYS AGO THE O/D LIGHT STARTED FLASHING AND THEN A DAY LATER THE CHECK ENGINE SOON LIGHT CAME ON AS WELL. I TOOK THE TRUCK TO A TRANSMISSION SHOP THEY HOOKED THE TRUCK UP TO THE MACHINE AND 5 MALFUNCTIONS CAME UP IN THE TRANSMISSION HE SAID THAT THE 1ST AND 5TH GEAR IS SLIPPING. HE WOULD HAVE TO REBUILT THE TRANSMISSION, WHICH WOULD COST AT LEAST $2000. HE ALSO STATED THAT MY TRUCK WAS TOO YOUNG AND DIDN'T HAVE ENOUGH MILES IN IT TO ALREADY HAVE TRANSMISSION PROBLEMS. I SEE BY THE OTHER COMPLAINTS ON CARCOMPLAINT.COM THAT I AM NOT THE ONLY ONE HAVE THIS PROBLEM. WHO DO WE HAVE TO CONTACT IN ORDER TO HAVE FORD NOTICE THAT THEY TRUCK SHOULD GET RECALLED B/C...

OVERDRIVE LIGHT FLASHES ON MY 2003 FORD EXPLORER. *TR

I HAVE A 2003 FORD EXPLORER THAT I BOUGHT BRAND NEW, IT NOW HAS 135,553 MILES ON IT. HAVE NEVER HAD PROBLEMS AND IT ACTUALLY DRIVES VERY WELL, BUT THE O/D OFF LIGHT STARTED FLASHING. TOOK IT TO THE FORD DEALER 3 DAYS LATER, WAS TOLD THE TORQUE CONVERTER NEEDED TO BE REPLACED AT A COST OF $1,225.00. THE DEALER HAS TOLD ME THAT THE TORQUE CONVERTER HAS BEEN REPLACED TWICE, THE O/D OFF LIGHT STILL FLASHING AND AFTER FURTHER DIAGNOSTICS THEY HAVE NOW DETERMINED THE COMPUTER NEEDS TO BE REPLACED AT A COST OF AN ADDITIONAL $1,325.00. ACCORDING TO THE INTERNET THIS IS A PERSISTENT PROBLEM THAT FORD HAS YET TO DO ANYTHING ABOUT. IT SHOULD BE A RECALL ISSUE. *TR

STEERING COLUMN.. HARD TO SHIFT INTO PARK. *TR

TRANSMISSION STARTED SLIPPING AND TAKING A LONG TIME GOING INTO GEAR AND JERKING INTO GEAR SINCE AROUND 67000 MILES. IT NOW HAS OVER 91000 MILES AND KEEPS GETTING WORSE. THE TRANSMISSION SHOP TOLD ME THAT THIS IS COMMON WITH THIS MODEL EXPLORER. *TR