2003 FORD EXPLORER Power Trainclutch Assembly Problems
3 NHTSA complaints on file
Power Trainclutch Assembly Issues in the 2003 FORD EXPLORER
3 power trainclutch assembly complaints have been filed with NHTSA for the 2003 FORD EXPLORER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Power Trainclutch Assembly Complaints
TL* - THE CONTACT OWNS A 2003 FORD EXPLORER XLT. THE CONTACT STATED THAT THE VEHICLE WAS MAKING NOISES, WINING, AND GRINDING. THE CONTACT STATED THAT THE DIFFERENTIAL SYSTEM FAILED AND NEEDED TO BE REPLACED. ALSO, THE FOLLOWING COMPONENTS NEEDED TO BE REPLACED: CLUTCHES, RING, PINION, CARRIER BEARING, PINION BEARING, AND PINION SEAL. THE CONTACT HAD TO UPDATE THE AXLE SEALS. AT THE TIME OF THE ORIGINAL FAILURE THE VEHICLE HAD AN ODOMETER READING OF 37,000 MILES AND THE WARRANTY HAD JUST LAPSED. THE CONTACT DID NOT BELIEVE THAT THE WEATHER WAS A FACTOR, AND THE SOUNDS WERE ALWAYS WHEN SHE WAS IN THE PROCESS OF ACCELERATING. THE CONTACT STATED THAT IT STARTED VERY SLOWLY AND BECAME AN EVERY DAY OCCURRENCE. *AK
DEAR NHTSA: IN OCTOBER 2003 I PURCHASED THE NBX - V8 VERSION OF THE FORD EXPLORER WITH AN UPGRADED TOW PACKAGE FOR MY WIFE. SHE NEVER USES THE TOW PACKAGE AND I, VERY OCCASIONALLY PULL A 300LB UTILITY TRAILER. I GET THE OIL CHANGED RELIGIOUSLY AND RECENTLY HAD THE 30,000 MILE 4WD LUBRICATION PACKAGE FROM GOODYEAR FOR APPROX. $500. AT 34,000MI MY WIFE BEGAN TO NOTICE A NON-DESCRIPT NOISE IN THE REAR END, A RUMBLE AT SLOW SPEEDS WHILE TURNING. SHE CARRIES THINGS IN THE BACK AND THOUGHT THEY WERE ROLLING AROUND. I DROVE THE CAR AT 36,600 MI AND ALSO NOTICED THE NOISE BUT WE HAD A LOW REAR TIRE AND I THOUGHT IT WAS THE TIRE PRESSURE. THE TIRE ACTUALLY PICKED UP A NAIL AND WENT FLAT AND I BROUGHT THE TIRE TO GOODYEAR FOR REPAIR. AFTER THE REPAIR THE REAR END NOISE PERSISTED ONLY AT LOW SPEEDS...
I AM THE OWNER OF A 2003 FORD EXPLORER. I HAD PROBLEMS WITH MY TRANSMISSION ENGAGING PROPERLY AND THE TRANSMISSION MAKING A LOUD NOISE WHEN SHIFTING FROM PARK TO REVERSE WHETHER THE VEHICLE WAS HOT OR COLD. THE TRANSMISSION DID THIS INTERMITENTLY FOR A WEEK OR SO UNTIL I TOOK IT INTO A DEALERSHIP FOR REPAIR. THEY SAID NOTHING WAS WRONG. I DROVE IT FOR ANOTHER WEEK WITH THE SAME PROBLEMS. THE VEHICLE WOULD LURCH IN MID-ACCELERATION AT ANY SPEED AND WOULD LUNGE WHEN COMING TO A STOP LEAVING ME NEVER KNOWING WHEN I MIGHT STOP ON THE FREEWAY OR RUN INTO THE BACK OF SOMEBODY. THE NEXT TIME I TOOK IT IN THEY SAID IT WAS THE CLUTCH PACK THAT FAILED AND THE REPAIR COST ME $1,131.00. THE REPAIR CONSISTED OF REMOVING THE TRANSMISSION, OPENING IT UP AND REPLACING THE PARTS AND THEN RE-INSTALLING THE TRANSMISSION. I HAVE READ...
Other 2003 FORD EXPLORER Problem Areas
Power Trainautomatic Transmission
141 complaints
Structurebody
135 complaints
Power Train
110 complaints
Structurebodyhatchbackliftgate
90 complaints
Structurebodyhatchbackliftgatehinge And Attachments
55 complaints
Structure
44 complaints
Electrical System
43 complaints
Unknown Or Other
43 complaints
Wheels
42 complaints
Engine And Engine Cooling
33 complaints
Air Bags
28 complaints
Power Traindrivelinedifferential Unit
28 complaints
Vehicle Speed Control
28 complaints
Suspension
27 complaints
Engine And Engine Coolingengine
24 complaints
Power Trainaxle Assembly
24 complaints
Engine
22 complaints
Visibilityglass Siderear
21 complaints
Air Bagsfrontal
20 complaints
Steering
17 complaints
Suspensionrear
17 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
14 complaints
Structurebodytailgate
13 complaints
Wheelslugsnutsboltsstuds
12 complaints
Suspensionfrontwheel Bearing
11 complaints
Visibility
11 complaints
Seat Belts
10 complaints
Service Brakes
10 complaints
Power Trainautomatic Transmissiontorque Converter
9 complaints
Power Traindriveline
9 complaints
Service Brakes Hydraulic
9 complaints
Tires
9 complaints
Latcheslockslinkages
7 complaints
Power Traintransfer Case 4 Wheel Drive
7 complaints
Suspensionfront
7 complaints
Visibilitydefrosterdefoggerhvac System
7 complaints
Visibilitypower Window Devices And Controls
7 complaints
Equipment
6 complaints
Power Trainaxle Assemblyaxle Shaftseal
6 complaints
Structurebodydoor
6 complaints
Structurebodytailgatehinge And Attachments
6 complaints
Vehicle Speed Controlcruise Control
6 complaints
Equipmentapplianceair Conditioner
5 complaints
Latcheslockslinkageshatchbackliftgatelock
5 complaints
Power Traindrivelinedriveshaft
5 complaints
Seats
5 complaints
Structurebodyhood
5 complaints
Visibilitywiper
5 complaints
Engine And Engine Coolingcooling System
4 complaints
Fuel System Gasoline
4 complaints
Latcheslockslinkagestailgatelatch
4 complaints
Parking Brake
4 complaints
Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm
4 complaints
Seat Beltsfrontretractor
4 complaints
Steeringrack And Pinion
4 complaints
Structurebodyhatchbackliftgatesupport Devicestrut
4 complaints
Structureframe And Members
4 complaints
Electrical Systemignition
3 complaints
Electrical Systemwiring
3 complaints
Electronic Stability Control Esc
3 complaints
Fuelpropulsion System
3 complaints
Power Trainautomatic Transmissionlever And Linkagecolumn Shift
3 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light
3 complaints
Service Brakes Hydraulicpedals And Linkages
3 complaints
Steeringcolumn
3 complaints
Suspensionrearspringscoil Springs
3 complaints
Tiressidewall
3 complaints
Tirestreadbelt
3 complaints
Vehicle Speed Controlaccelerator Pedal
3 complaints
Visibilitywindshield
3 complaints
Wheelshub
3 complaints
Engine And Engine Coolingenginegasolinebelts And Associated Pulleys
2 complaints
Engine And Engine Coolingexhaust Systememission Control
2 complaints
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor
2 complaints
Equipmentelectrical
2 complaints
Exterior Lightingbrake Lights
2 complaints
Exterior Lightingbrake Lightsswitch
2 complaints
Fuel System Gasolinedelivery
2 complaints
Power Trainaxle Assemblyaxle Shaft
2 complaints
Power Trainaxle Hubs
2 complaints
Power Trainmanual Transmission
2 complaints
Seat Beltsfront
2 complaints
Seatsfront Assemblypower Adjust
2 complaints
Seatsfront Assemblyseat Heatercooler
2 complaints
Seatsmidrear Assembly
2 complaints
Steering Steering Wheelhandle Bar
2 complaints
Structurebodytrunk Lid
2 complaints
Trailer Hitches
2 complaints
Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Air Bagssidewindow
1 complaint
Child Seatharnessstrapwebbing
1 complaint
Electrical System Instrument Clusterpanel
1 complaint
Electrical Systemalternatorgeneratorregulator
1 complaint
Electrical Systemsoftware
1 complaint
Electrical Systemwiringfuses And Circuit Breakers
1 complaint
Electrical Systemwiringinteriorunder Dash
1 complaint
Engine And Engine Coolingcooling Systemfan
1 complaint
Engine And Engine Coolingenginegasoline
1 complaint
Equipmentelectricalnavigational Systemglobal Positioning System
1 complaint
Exterior Lighting
1 complaint
Exterior Lightingturn Signal
1 complaint
Fuel System Gasolinedeliveryfuel Pump
1 complaint
Fuel System Gasolinefuel Injection System
1 complaint
Fuel System Gasolinestoragetank Assembly
1 complaint
Fuel System Other
1 complaint
Interior Lighting
1 complaint
Latcheslockslinkageshoodlatch
1 complaint
Parking Brakeconventionalmechanicallinkage And Cable
1 complaint
Power Trainautomatic Transmissiongear Position Indication Prndl
1 complaint
Power Trainautomatic Transmissionparkneutral Start Interlock Switch
1 complaint
Seat Beltsintegrated Child Seat
1 complaint
Seatsfront Assemblyrecliner
1 complaint
Service Brakes Airantilockabs Warning Light
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipwheel Speed Sensortone Ring
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscrotor
1 complaint
Steeringhydraulic Power Assisthose Piping And Connections
1 complaint
Steeringlinkagestie Rod Assembly
1 complaint
Structurebodydoorhinge And Attachments
1 complaint
Structureframe And Membersunderbody Shields
1 complaint
Suspensionfrontcontrol Armupper Ball Joint
1 complaint
Suspensionfrontspringscoil Springs
1 complaint
Suspensionrearaxlespindle
1 complaint
Suspensionrearsprings
1 complaint
Tirestemporaryemergency Spare Tire
1 complaint
Traction Control System
1 complaint
Visibilitydefrosterdefoggerhvac Systemfanmotor
1 complaint
Visibilityrear Window Wiperwasher
1 complaint
Visibilityrear Window Wiperwasherlinkages
1 complaint
Visibilityrear Window Wiperwasherswitchwiring
1 complaint
Visibilityrearview Mirrorsdevices
1 complaint
Visibilitywindshield Wiperwasher
1 complaint
Wheelsmulti Piece
1 complaint
Wheelsrim
1 complaint