2003 FORD EXPLORER Structurebodytailgate Problems

THE TAILGATE CRACKS DOWN THE CENTER. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED THAT THERE WAS A LARGE CRACK IN THE REAR LIFT GATE PANEL. THE CRACK WAS LOCATED UNDER THE TAIL GATE WINDOW. THE FAILURE WAS DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED THAT THE REAR TAILGATE WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE CONTACT WOULD HAVE TO PAY TO HAVE THE TAILGATE REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD PAY FOR R HALF OF THE REPAIR COST. THE CONTACT STATED THAT HE SHOULD NOT HAVE TO PAY ANY PORTION OF THE REPAIR COST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 2/23/11 *CN UPDATED 04/25/11

I KEEP READING ABOUT 2 COMPLAINTS THAT PEOPLE NEED TO KNOW ABOUT AND FORD SHOULD TAKE ACTION ON; THE FIRST BEING THE BACK TAIL GATE... FORD DO THE RIGHT THING. THE SECOND HAS TO DO WITH THE TRANSMISSION, OVERDRIVE LIGHT, THE PARKING BRAKE AND THE CRUISE CONTROL. I USE THE CRUISE CONTROL WHEN DRIVING LONG DISTANCES AND WHILE ON A FEW TRIPS THE OVERDRIVE LIGHT WOULD COME ON FOR NO REASON, AT LEAST I THOUGHT, I THEN FOUND OUT THAT I HAD AN ABS PROBLEM AND WHEEL BEARINGS PROBLEMS. ALL HAPPENING AT THE SAME TIME? AS IF THAT WASN'T ENOUGH MY TRANSMISSION WAS DRIPPING FLUID ON MY NEW DRIVEWAY! THIS WAS WHILE I ONLY HAD ONLY 70,000 MILES, IT WASN'T RIGHT, I CHECKED OUT THE BRAKES, THEY HAD BEEN REPLACED BEFORE HOWEVER WHEN I PULL OFF THE REAR DRUM / DISK TO CHECK THE PARKING BRAKE THAT'S WHEN I FOUND...

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. IN AN ATTEMPT TO DRIVE THE VEHICLE, THE CONTACT NOTICED A CRACK IN THE TAILGATE BELOW THE REAR WINDOW. THE DEALER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS. THE CURRENT MILEAGE WAS 80,000 AND FAILURE MILEAGE WAS 60,000.

2003 FORD EXPLORER, AFTER HAVING SERVICE COMPLETED , JAN '07 NOTICED AFTER SEVERAL WEEKS VERTICAL CRACK ON REAR HATCH PANEL RIGHT OF FORD EMBLEM. DIDN'T THINK MUCH OF IT BECAUSE THERE WAS ROAD SALT COVING THE BACK HATCH AND I COULDN'T CONFIRM WHAT HAD HAPPENED.HOWEVER THERE WAS NO IMPACT MARKS. I HAVE NOTICED A NUMBER OF OTHER SAME YEAR EXPLORERS WITH THE SAME VERTICAL CRACK. IWILL TRY TO PURSUE WITH FORD. *CN

2003 FORD EXPLORER XLT VERTICAL CRACK IN FIBERGLASS TAILGATE PANEL JUST BELOW REAR WINDOW GLASS (NO IMPACT TO TAILGATE OCCURRED - CALLED DEALERSHIP AND THEY NOTED THIS IS A COMMON PROBLEM). *TR

THE REAR TAILGATE ON MY FORD EXPLORER HAS A VERTICAL CRACK THAT RUNS THROUGH THE FORD MEDALLION ON THE BACK. MY NEIGHBOR HAD THE SAME PROBLEM WITH HIS EXPLORER AND REPLACED IT. WHEN I LOOKED ON A GOOGLE SEARCH, I FIND THIS IS A COMMON PROBLEM WITH EXPLORERS. NOT REPLACED, THE PIECE WILL FALL OFF AND POSSIBLY CREATE A ROAD HAZARD. *TR

FOLLOWING THE ACTIONS TAKEN BY THE FORD DEALERSHIP TO CORRECT THE FAULT WITH THE REAR DOOR/LIFTGATE RECALL, A LARGE CRACK DEVELOPED ON THE LIFTGATE FROM THE BOTTOM OF THE GLASS TO THE BOTTOM OF THE LIFTGATE. I HAVE NOTICED THIS SAME CRACK ON SEVERAL OTHER EXPLORERS. I HAVE BEEN TOLD THAT THIS IS NOT SOMETHING THAT FORD RECOGNIZES AS AN ITEM FOR "RECALL." I AM UNSURE OF THE INTEGRITY OF THE STRUCTURE OF THE REAR DOOR/LIFTGATE. *JB

CRACK IN BODY OF TAILGATE WITH NO CAUSE; CRACK STARTED AT THE BOTTOM OF THE BACK WINDOW AND RAN TO THE BOTTOM OF THE PANEL. *JB

FORD EXPLORER 2003. TAILGATE CRACKED IN HALF BELOW WINDOW. NO PRECIPITATING CAUSE. CAR UNDER WARRANTY, DEALER STATED THIS WAS MANUFACTURING DEFECT. REPLACED AT NO CHARGE, APPARENTLY WITH ANOTHER DEFECTIVE TAILGATE. TAILGATE CRACKED AGAIN 9 MOS. LATER. DEALERSHIP REQUIRED PAYMENT OF 20% FROM OWNER SINCE VEHICLE OUT OF WARRANTY (38K MILES) EVEN THOUGH IT WAS ADMITTEDLY FORD'S MANUFACTURING DEFECT. FORD REPLACED THE TAILGATE WITH A THIRD DEFECTIVE TAILGATE THAT WILL UNDOUBTEDLY CRACK AGAIN. BOTH FORD FACILITIES STATED THAT THEY'D WISH THAT FORD WOULD DO A RECALL AND "ACCEPT RESPONSIBILITY FOR THE DEFECT". THEY'D REPLACED ONE A MONTH AT THE SMALL DEALERSHIP AND "MANY" AT THE LARGER DEALERSHIP. PICTURES AVAILABLE PER E-MAIL IF DESIRED. *NM

THE PANEL BELOW THE REAR WINDOW OF MY 2003 EXPLORER HAS CRACKED/BROKEN INTO PIECES. THE 6-8 INCH BREAK RUNS TO THE RIGHT OF THE FORD EMBLEM. APPARENTLY THIS IS A VERY COMMON DEFECT IN 2002-2003 EXPLORERS WHICH FORD REFUSES TO ACKNOWLEDGE. *JB

CONSUMER RECEIVED MANUFACTURER'S RECALL 04007, NHTSA RECALL 04V129000 CONCERNING TAILGATE CABLES. NO PARTS WERE AVAILABLE.*AK