2019 RAM 1500 Suspension Problems

Air suspension keeps failing in cold weather.

I have what seems to a manufacturing issue with my ram 1500. The air suspension will not stay inflated after taking it to the dealership. They cited no issues but the problem continues to take place.

De breakes light its somethimes flashing in the panel and my suspensionsistem i pay tochange because its was damage and the garanted didnt apicate

I purchased a 2019 Ram 1500 in November and have since been unable to pass state inspection due to several issues with the vehicle. I have contacted the dealership three times to request repairs, but they have repeatedly told me there is nothing they can do. I reached out to the Massachusetts Lemon Law, and they advised me to contact a lawyer immediately. The problems preventing my vehicle from passing inspection include excessive play in the bushing of the right front upper control arm, excessive play in the ball joint of the right front lower control arm, issues with both front struts, and excessive wear on the stub shafts of the front differential assembly, necessitating a front axle replacement since a kit is unavailable. Additionally, both front axle shafts need attention, and I require four-wheel spacers to prevent tire rubbing, as well as four fender flares. Within the first 30...

Had my truck in for service and they found a cracked right front CV axle and carrier joint. I was told that this is a safety issue and could lead to uncontrolled steering, but then was told by two different dealers that the part is on national backorder with no time frame for availability. I was also told that this is a common issue and other RAM1500 models have had warranty repair or recalls, but none seems to be available for mine.

Air suspension failure on front drivers side 2019 Ram Rebel. When it was below freezing outside, a warning message flashed across the screen saying service air suspension immediately. Went home and got up later to drive again and the warning message was gone, never to be seen again. Fast forward and it was extremely hot out. Noticed the truck was leaning to one side. Jumped in, started it, and the height recentered. Got out and could hear an active air leak. Drove for a while and would always raise and lower as normal. Issue seemed to go away. Finally, it came back. When trying to change the heights, a message flashed that said “Air suspension system overheating. Ride height safe to maintain.” Sent to dealership. Took 2 days to find issue. Mopar gave oddly specific instructions to determine if that was the issue. Air suspension replacement cost $2500 and not...

My 2019 Ram 1500 is experiencing the exact same issues listed in recall 75B but my VIN number is not part of the recall. The symptoms that it is having are the exact ones listed in your recall from 9/11/24 concerning the ABS and stability control issues. It is very disheartening that there wasn’t a better investigation done on this issue either on your end or on Ram’s end. I’m sure there are plenty more vehicles that are affected that aren’t in this recall. My truck did it as I was going highway speeds (70mph) and the abs and stability control issues also disengaged my speed control as I was on the highway. It was a good thing there wasn’t another car behind me or I would have been struck from behind.

Chime comes on. Then displays parksense temporarily unavailable. Then a few seconds later another chime and a display come on and reads service shifter. And if my cruise control is on the vehicle disengages the cruise control. When this happens occasionally will disengage the transmission and I will have to pull over and shut the vehicle off then start it back off. Then it will let me put it back in gear. When the vehicle will also start up sometimes and the shifter will not let me put it in gear. Then I’ll shut it down. Restart it then it will be ok. The vehicle has been in Ram service department 4 times. Twice in Nevada and twice in California. They haven’t been able to rectify the problem. The first time in the shop was back in May. The last time was in August. And it’s going back in Sept...

The contact owns a 2019 Ram 1500. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart however, the failure recurred. The vehicle was taken to the dealer where the vehicle was diagnosed with alternator, tension belt, torque sensor, and CV axle shaft failure. The contact was informed that the alternator, tension belt, torque sensor, and CV axle shaft needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 82,032.

The steering rack overheated causing the vehicle to lock up while being driven. Looked issue up online and see this has been an issue and recall for other Ram pickups but Dodge Ram says my truck not covered under recall. I do not drive aggressive nor has this vehicle been used to haul anything heavy. It has 81000 miles on it. Dodge dealership says the electric power steering module has a fault and needs to be replaced but says the module can't be replaced without replacing full rack and pinion steering as well as module for $3000.

This truck as well as multiple others I have seen complaints on multiple dodge ram forums where something is causing the battery to die then the stability control light comes on and the the truck will not change gears until the battery is completely disconnected to "reset" the computer and then it's like the battery never died. It works great with no issues for months then out of nowhere the exact same issue happens once again. We have spent thousands of dollars fixing this issue to no avail just keep replacing parts that apparently aren't the fix. So far we have replaced the torque converter, the battery as well as paying for multiple diagnostics to which they keep replacing the battery saying that is the issue but obviously it can't be the battery when it's getting replaced over and over SOMETHING is causing this draw making the battery die. PLEASE...

The 4wd has never worked in my 2019 Ram 1500. I bought the truck in November of the same year, I tried to engage the 4wd with the snow that year and it would not engage. Notification showed service 4wd, I took it to a ram dealer in South Carolina where I worked out of town they had it for two days and they informed me they didn't know what was wrong with it. I then took it to the dealer at home they kept it overnight and installed a new actuator. It engaged the first time and then back to service 4wd. This time was different it stayed in neutral, I turned the emergency brake on and turned the truck off. The dial tried to return to park but couldn't so with the truck off and Ebrake applied I had to have a tow service pick it up and...

The contact owns a 2019 Ram 1500. The contact stated that while driving at an undisclosed speed, the rear differential axle seized. The contact stated that the vehicle had seized in the middle of the road. The contact was able to safely get the vehicle to the shoulder of the road. The vehicle was towed to the dealer where it was diagnosed with a failed rear suspension and a failed rear differential axle and that the rear suspension and rear differential axle needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving at an undisclosed speed, the rear suspension axle seized again. The contact was able to move the vehicle to the shoulder of the road. The vehicle was towed to the dealer. The vehicle was diagnosed with a failed rear differential axle and failed rear suspension, and it was determined that...

I am not sure if this issue is electrical or suspension or even computer related. My car battery was dead after just driving it a few hours ago. I came out and heard a noise coming from the truck that sounded strange coming from under the hood, like something was trying to start or like a long delayed switching sound or airpump (I'm not sure). When starting the vehicle it only clicked and the battery showed low, the air suspension, airbags, safety systems and a lot more all lit up on my dashboard. I do have a video but on my cell phone not the computer from which I am writing this and it is too large of a file size for here. I placed the batter on a charger and it took a very long time to get enough of a charge but still wouldn't start. I had to...

Left rear shock absorber reservoir broke and fell from the vehicle. It appears the weldment is defective. Had this happened while traveling at highspeed the reservoir tank could have caused serious damage, injury or death. The uploaded picture shows the left shock above with the missing reservoir tank. The right shock has the mfg information.

2019 ram 1500 bighorn 5.7 slowed down truck started shaking really bad , throttle actuator mass airflow, stability control come on. Tried to start it quit and tried again engine started to turn over and stopped no lights nothing local shop said cylinder #8 gone engine locked needs engine 76,844 miles not under warranty had 2 other rams up to almost 150k no problems

The sway bar bushings failed under 36000 miles. I had been hearing a clunk since 25000k, and it was only diagnosed at 35000 miles. The issue started in Feb 2022, fixed in July 2022 under warranty. Initially looked at by Lindsay CDJR in Manassas VA. Second look by Farrish CDJR in Fairfax. June 2022. Repaired by Lindsay CDJR in Manassas VA.

On October 27, 2021 I was pulling into a parking lot at extremely low speed and upon turning heard a pop noise and felt a minimal jolt in the steering wheel. Letter in the day as I was leaving I turned right to come home and had the same experience. The next morning same thing at slow speed turning either left or right. Made appointment at dealer for first available date which was November 1, 2021. I received this from the dealer service team: Concern Critical Customer States There’S A Popping In The Front End Wall Turning Issue TEST DRIVE AND INSPECT FRONT SUSPENSION - PASSENGER FRONT SWAY BAR LINK WORN/SEPARATED DRIVER SIDE ALSO SHOWING SIGNS OF FAILING NEEDS BOTH REPLACED AND ALIGHNMENT Recommendation REPLACE SWAY BAR LINKS AND ALIGNMENT with an almost $1,300.00 repair bill. I was told this was not covered by my 5 year 60,000 mile warranty...

[XXX] *TR

1ST PROBLEM....STEERING COLUMN RATTLES LOUDLY IN-BETWEEN 45 AND 60 MPH AND AT SPEEDS BELOW 10MPH. TRUCKS FRONT END GRINDS WHEN MAKING SLOW SPEED RIGHT HAND TURNS. ALSO TRUCK LURCHES, GRINDS AND RATTLES THE ENTIRE FRONT END SLOWING DOWN OR BACKING UP AT SLOW SPEEDS....THIS HAPPENS WHEN BRAKES ARE NOT BEING APPLIED. SOMETIMES WHEN I DRIVE THE TRUCK THE STEERING WHEEL STAYS OFF CENTER TO THE RIGHT AND PULLS VERY HARD TO THE RIGHT. CHRYSLER SAYS IT POSSIBLE THE ELECTRONIC POWER STEERING RACK BUT THEY DONT HAVE A FIX. GETS WORSE ALMOST EVERY DAY. 2ND PROBLEM....I HAVE NOTICED THE TRUCK HAS MARKS WHERE THE KNUCKLE AND THE LOWER CONTROL ARM ARE HITTING EACH OTHER. I UNDERSTAND THE NEED FOR STEERING STOPS BUT THESE ARE NOT STEERING STOP HITS. THESE PARTS ARE STRUCTURAL PARTS OF THE TRUCK THAT ARE NOT SUPPOSED TO HIT. BOTH SIDES ARE DOING THIS AND I DO NOT...

LOOSE REAR SUSPENSION. CREATES A WOBBLE THAT INCREASES WITH SPEED. VEHICLE SEEMS UNSTABLE. BEEN TO MULTIPLE DEALERS AND THEY SAY TIRES ARE OUT OF LINE. I HAVE PAID FOR EIGHT WHEEL ALIGNMENTS AND THE PROBLEM HAS BEEN CONSTANT SINCE I PURCHASED THE VEHICLE. *TR

MILD TO EXTREME VIBRATION FROM REAR OF THE VEHICLE BUT NOT LIMITED TO THE STEERING WHEEL SEATS AND GAS PEDAL AT ANY SPEED BUT WORSENS AS SPEED INCREASES. WAS TOLD AFTER MULTIPLE VISITS TO DEALER THAT EVERYTHING IS WITHIN SPEC. AND THEY WILL NO LONGER PURSUE THE ISSUE FURTHER. FILED LEMON LAW CLAIM AND WAS AWARDED COMPENSATION AND WAS ALLOWED TO KEEP THE VEHICLE. IN MY OPINION THE VEHICLE IS PROGRESSIVELY UNSAFE TO DRIVE AND THERE ARE HUNDREDS OF COMPLAINTS ON THE SAME SUBJECT THROUGHOUT MULTIPLE FORUMS (OVER 932 PAGES ON THE ONE I AM A MEMBER OF ALONE) AND WE ARE ALL BEING TOLD THE SAME LINE..FLAT SPOTS ON THE TIRES..WE DON'T WARRANTY TIRES. *TR

MY VEHICLE HAS BEEN IN SERVICE FOR OVER 6 MONTHS. THEY ARE UNABLE TO FIGURE OUT WHAT IS WRONG. MY RAM CONSTANLY MAKES A BANGING NOISE WHILE DRIVING. THEY CHANGED THE ENTIRE FRONT END AND THE NOISE CONTINUES. ALSO HAVE A MILDUE SMELL AND PICTURES OF WATER LEAKING DOWN THE INSIDE OF THE WINDSHIELD. OPENED A CASE WITH FCA THEY REFUSE TO BUY THE TRUCK BACK

DRIVING DOWN HIGHWAY WHEN BALL JOINT FELL OUT CAUSING TO SKID DOWN HIGHWAY, TOOK TO DEALERSHIP IN THEY SAID WAS A DEFECT.

TL* THE CONTACT OWNS A 2019 RAM 1500. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS AND MAKING LEFT TURNS, THE STEERING WHEEL MOMENTARILY SEIZED BEFORE RETURNING TO THE CENTER POSITION. THE CONTACT STATED THAT THE FAILURE WAS NOT PRESENT WHEN MAKING RIGHT TURNS. THE VEHICLE WAS TAKEN TO MCCLURG CHRYSLER DODGE JEEP (LOCATED AT 125 N CENTER ST, PERRY, NY 14530, (585) 969-3496) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE. THE MECHANIC WAS ABLE TO DUPLICATE THE FAILURE. THE CONTACT STATED THAT THE MECHANIC PERFORMED MINOR ADJUSTMENTS ON THE FRONT SUSPENSION AND STEERING; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 3,200. *BF*JB

I LET MY SON OFF AT TSC DOOR, TURNED TO PARK, AND BAM!!, LOUD NOISE AS IF I HIT CONCRETE. I PROCEEDED TO MOVE FORWARD, TO ONLY HAVE MY TRUCK VEER TO THE LEFT, BUMPING UP NEXT TO POLE. I REVERSED SLIGHTLY AND MY LEFT FRONT SIDE WENT DOWN. I STOPPED. GOT OUT AND SEEN MY FRONT LEFT TIRE DOWN INWARD, FOUND A BROKEN PIECE UNDER THE FRONT OF THE TRUCK. CALLED MY INSURANCE SF, WAS TOLD TO CALL CHRYSLER BECAUSE MY VEHICLE IS UNDER WARRANTY. CHRYSLER CONTACTED. TRUCK WAS TOWED TO NEAREST CHRYSLER DEALERSHIP. THIS OCCURED APRIL 9TH, 2019. I JUST BOUGHT THE TRUCK JAN. 4TH, 2019. THE BROKEN PIECE IS THE KNUCKLE TO THE SPINDLE, MY STEERING WAS GONE. IT SAT AT THE DEALERSHIP UNTIL APRIL 26TH, 2019. HAVING BEEN SEEN BY 3 CHRYSLER REPRESENTATIVES, 2 OF WHICH DEEMED THE PART DEFECTIVE, THE 3RD DEEMED IT MY FAULT...

AT 18:00 MILES STARTED DEVELOPING A SHIMMY HAD TIRES ROTATED READ BALANCED HAS NOT CREATED THE PROBLEM

ON THREE (3) DIFFERENT OCCASIONS BETWEEN FEBRUARY 25 AND APRIL 29, 2019 WHILE DRIVING THE VEHICLE ON AN OPEN HIGHWAY, TWICE ON THE INTERSTATE AND ONCE IN THE CITY, THE VEHICLE STARTED TO BOUNCE OUT OF CONTROL AND SHORTLY AFTERWARDS THE ALERT MESSAGE CAME ON THE SCREEN INDICATING THAT I SHOULD "SERVICE THE SUSPENSION SYSTEM IMMEDIATELY". THREE DIFFERENT TIMES I HAVE HAD TO RETURN THE VEHICLE TO THE DEALERSHIP DUE TO SUSPENSION PROBLEMS. EACH TIME THE VEHICLE JUST STARTED BOUNCING OUT OF CONTROL WHILE DRIVING AND SHORTLY AFTERWARDS THE ALERT WARNING MESSAGE CAME ON THE SCREEN INDICATING THAT I SHOULD "SERVICE THE SUSPENSION SYSTEM IMMEDIATELY". THE FIRST TIME IT HAPPENED THE SERVICE DEPARTMENT STAFF INDICATED "INSPECTED UNDER CARRIAGE AND FOUND A RUPTURED AIRBAG ON RIGHT REAR, NO PHYSICAL DAMAGE REPLACED RIGHT REAR AIRBAG ON SUSPENSION AND FILLED WITH NITROGEN. TEST DROVE TO VERIFY REPAIR". THE SECOND TIME THE SERVICE DEPARTMENT...

WHILE DRIVING, POWER STEERING UNAVAILABLE CAUTION FOLLOWED BY SERVICE SUSPENSION IMMEDIATELY. POWER STEERING IS LOST WHILE DRIVING AND INTERMITTENTLY COMES BACK OR IS LOST. I HAVE TAKEN TO THE DEALERSHIP TWICE AND THEY 'CAN'T FIND ANYTHING WRONG'. THIS IS EXTREMELY DANGEROUS WHILE DRIVING AT 50-70 MPH ON THE HIGHWAYS AND INTERSTATE.

THE VEHICLE INITIALLY HAD A REPORTED STEERING FAILURE TWICE ON DECEMBER 19TH. THIS WAS REPORTED TO NHTSA UNDER FILE 1162423. THE VEHICLE WAS TAKEN TO THE DEALER THE SAME DAY. THE DEALER WAS UNABLE TO DETERMINE WHY THIS OCCURRED. THEN, AGAIN ON DECEMBER 30TH THIS OCCURRED AGAIN AT HIGHWAY SPEED, ALMOST CAUSING A COLLISION. IMMEDIATELY CONTACTED THE DEALER AGAIN AND THE DEALER WAS CONCERNED OVER SAFETY ISSUE AND OFFERED A RENTAL VEHICLE WHILE INSPECTING THE VEHICLE. ON THE WAY TO THE DEALER THIS MORNING, THE POWER STEERING TURN OFF AND AGAIN THE MESSAGE CENTER DISPLAYED IN RED " POWER STEERING UNAVAILABLE SERVICE REQUIRED".. THIS WAS DISPLAYED ON THE PRIOR OCCASIONS.... WHILE DRIVING SLOWLY TO THE DEALER THIS LOSS OF STEERING OCCURRED ANOTHER 3 TIMES INTERMITTENTLY WITH ANOTHER WARNING "SERVICE AIR SUSPENSION IMMEDITALEY".... KEEP IN MIND THAT WHEN THE POWER STEERING LEAVES WITH ELECTRONIC STEERING VERY LITTLE CONTROL REMAINS. SINCE THIS...

WHILE DRIVING SOMETIMES THERE IS A NOISE UNDERNEATH BY THE STEERING SUSPENSION AREA. FEELING LIKE IF SOMETHING LOOSE. MOST NOTABLE WHEN HITTING A HOLE, DITCH OR UNEVEN ROAD AS WHEEL TURNS. TOOK VEHICLE TO DEALER EVEN THOUGH THEY HEAR IT ALSO, ALL VEHICLES MAKE THE SAME NOISE.