2004 VOLVO XC90 Electrical System Problems

Instrument panel shuts down while driving on street. I believe it is the central electronic module that fails. It has happened numerous times and it is unsafe to drive without a speedometer, tachometer, odometer fuel gauge, and temperature gauge. It has now stopped altogether. Gauges just sit there and bounce

Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now when I drive at 60 miles an hour I’ve had it looked at and no one seems to know what that issue is

Unknown..but water accumulated under the passenger seat under the amp and electrical components after a storm or rainy day.and its a lot of water when I brake i can hear a water fall..and water rushing and moving along the bottom. Of the car as I am steering im worried that the wiring and electrical will be damaged by water exposure the battery always dies wires soaked and sitting in water underneath passenger and never can completely get the moisture smell out of front seat area..mildew..why is this water leaking or not draining correctly ??

On May 26, 2022, I was stuck in traffic for four hours, and the car's CEM (central electronic module) overheated causing the dashboard to shut down three times, meaning I lost all instrument readings. After each time the dashboard shut down, I had to pull over and reset fuse #27 to have the dashboard come back online temporarily. Because the CEM was already overheated due to its design flaw with improper ventilation, the dashboard would shut down again and again. A Google search would show this is a very common issue for 2004 Volvo models and before. Driving without any instrument readings is totally unsafe. I strongly urge you to force Volvo to issue a recall for 2004 and before models and fix the CEM overheating problem.

While driving on the highway "SRS urgent" text came on, also hear clicking sounds under dash on driver side, then dashboard indicator lights completely disappear (speed, fuel, temperature, etc) . Extremely hot under driver side dash. Fortunately, still able to steer and brake. This has happened twice now. Mechanic believes most likely CEM failure or DIM failure. My vehicle also has a wet A-pillar fabric (Volvo forums indicate possible cause of failure). I removed drivers A-pillar and found a clogged drain tube from the sunroof. However, did not notice any obvious signs of water inside the vehicle, though it hasnt rained for over a month when this happened.

is been stolen

WHILE I'M MOTION THE SRS AIRBAG LIGHT CAME ON TRANSMISSION URGENT LIGHT CAME ON AND ABS LIGHT THE BATTERY KEEPS BUBBLING LIKE ITS GONE BLOW UP IN MY TRUNK I HAVE TO JUMP IT OFF EVERY MORNING I PAID ALOT FOR THIS SUV CAN YOU PLEASE HELP ME KEEP MY ONLY CAR IN WORKING ORDER I HAVE HAD ALL MAINTAINS DONE IN PAST NOW THE COOLANT SYSTEM IS LEAKING WHAT IS GOING ON WITH THIS VOLVO XC90 T6 AWD [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

SIMILAR TO MANY OTHERS, WHILE DRIVING OUR 2004 VOLVO XC90, WE HEAR A CLICK, THEN THE CLIMATE, RADIO AND WINDSHIELD WIPERS (IF ON) SHUT OFF AND THEIR DISPLAY LIGHTS BLACK OUT, THEN ANOTHER CLICK IN A FRACTION OF A SECOND AND THEY COME BACK ON. THIS WAS HAPPENING RANDOMLY, AND NOTHING ELSE WAS AFFECTED, UNTIL THIS WEEKEND, WHILE ON A TRIP. WE WERE DRIVING ON HIGHWAYS, OUTSIDE TEMP IN THE 80'S, NO RAIN, AVERAGE SPEED ABOUT 70MPH. IT HAPPENED A FEW TIMES OVER ABOUT 45 MINUTES, THEN BEGAN HAPPENING EVERY 5 MILES OR SO. WHEN I TURNED UP THE AC FAN, WITHIN ABOUT A MINUTE IT CLICKED AND WE LOST THE USUAL THINGS, BUT THEY DID NOT COME BACK ON. THEN WE HEARD ANOTHER CLICK AND LOST ALL DASHBOARD LIGHTING AND CONTROLS; WE COULD NOT SEE THE INSTRUMENT PANEL, THE CLIMATE CONTROL WAS BLOWING HOT AIR AND COULD NOT BE...

TL-CONTACT OWNS A 2004 VOLVO XC90 ---- CONTACT CALLED VOLVO DEALER IN WHITE PLAINS NY... CONTACT STATED AIRBAG LIGHT CAME ON WHILE DRIVING AND WAS ON FOR A MONTH.... VEHICLE STALLED GOING 50MPH ... POWER STEERING WENT OUT ON MAIN HIGHWAY VEHICLE LOST POWER AND SHUT OFF.... VEHICLE RESTARTS AND THEN SHUTS OFF AGAIN AFTER GOING A COUPLE MILES...SPOKE WITH MECHANIC AT DEALERSHIP WHO STATED THAT AIRBAGS ARE RECALLED....MECHANIC BY THE NAME OF ANTHONY.... TOLD CONTACT THAT AIRBAG LIGHT BEING ON WAS NOT A BIG DEAL....THAT AIRBAG WAS FAULTY SO IT WOULD NOT DEPLOY IN ACCIDENT........ 0 RECALLS ASSOCIATED WITH THIS VIN.. CB

HI, WHEN DRIVING MY CAR UP ANY SLIGHT LITTLE HILL, I HAVE NO POWER AND IT DOESN'T SEEM TO WANT TO DRIVE. IT'S VERY FRUSTRATING!! I HAVE READ THERE ARE RECALLS IN THE FUEL PUMPS AND ALSO OTHER RECALLS WITH THE MODEL VOLVO XC90. I HOPE THEY CAN REPAIR IT AND PAY FOR IT!!

MY VOLVO XC 90 CANNOT SHIFT TO PARK OR REVERSE, IT REMAINED IN DRIVE OR NEUTRAL POSITION. WAS UNABLE TO REMOVE KEYS FROM IGNITION DUE TO PROBLEM. IT IS A SAFETY HAZARD THAT WHEN I SEARCHED U-TUBE FOUND THERE WERE NUMEROUS PEOPLE THAT ENCOUNTERED THE SAME PROBLEM. IT JUST HAD A SERVICE 1 MONTH AGO

WHEN TRAVELING AT HIGH RATES OF SPEED (ON THE HIGHWAY) THE CAR COMPLETELY SHUTS OFF. THE DASHBOARD AND ALL ELECTRICAL SHUTS OFF, THE HAZARDS DO NOT SEEM TO WORK OR THE TURN INDICATORS, ABS DOES NOT WORK SO IT IS A VERY SLOW HEAVY STOP. THIS HAPPENED TO ME IN THIS CAR ONE OTHER TIME IN 2010, AND THERE WAS AN IMMEDIATE COMPUTER MODULE UPGRADE ISSUED.

2004 VOLVO XC90 SUDDEN ENGINE STALL WITH LOSE OF HEADLIGHTS: I WAS TRAVELING ON THE INTERSTATE AT NIGHT WITH THE CRUISE SET AT 75 MPH WHEN SUDDENLY IT WAS LIKE SOMEONE TURNED THE IGNITION KEY TO OFF FOR ABOUT 3 SECONDS, AND THEN TURNED THE KEY BACK ON WITHOUT RESTARTING THE ENGINE. WITH ALL THE WARNING LAMPS ILLUMINATED, AND THE ENGINE AT A STALL I PULLED INTO THE EMERGENCY LANE, AND STOPPED. I THEN SHIFTED TO PARK AND ATTEMPTED TO START THE VEHICLE, WHERE IT TOOK SEVERAL ATTEMPTS TO START. THE HEADLIGHTS DID NOT STOP WORKING WHILE PULLING OVER, AND WHEN I STOPPED I SWITCHED THE LIGHTS OFF BEFORE I RESTARTED THE ENGINE. THE FIRST THING AT MIND WAS A FUEL PUMP THAT WAS STARTING TO ACT UP. AFTER RESTARTING I REVVED THE ENGINE UP A FEW QUICK TIMES (TO CLEAR THE ENGINES THROAT). I THEN GOT BACK ON THE...

THE CAR IS LEAKING A SUBSTANTIAL AMOUNT OF WATER MY DRIVER AND PASSENGER SIDE FLOODS WITH WATER. NOW WHEN I BRAKE I CAN HEAR SO MUCH WATER MOVING BACK AND FORTH. I HAVE WATER DAMAGE ON THE ROOF OF MY CAR FLOOR IS DAMAGED SO BADLY. JUST WAITING ON ELECTRIC PROBLEMS TO ARISE. THIS HAS HAPPENED OVER 5 TIMES... SUNROOF DOES NOT OPEN SO SECURITY ALERT AS WELL. THE CAR HAS BEEN STATIONARY PARKED IN THE PARKING LOT OF OUR TOWNHOUSE 0

AFTER DRIVING FOR AT LEAST AN HOUR THE VEHICLE SUDDENLY SHUTS DOWN FOR A SPLIT SECOND. ALL GAUGES GO OUT, LOSS OF POWER BRIEFLY, WIPERS SOMETIMES KICK ON AND FOG LIGHTS RESET AND SHUT OFF AND THERE IS A THUMP FROM THE TRANSMISSION. THIS HAPPENS MAINLY AT FREEWAY SPEEDS BUT HAS HAPPENED A FEW TIMES AT 30 MPH AND SLOWER. CAN HAPPEN SEVERAL TIMES ON A 2.5 HOUR TRIP. ONCE IT HAPPENS IT CAN HAPPEN ANYTIME. DOESN'T DO IT ON TRIPS AROUND TOWN. CALLED VOLVO OF NORTH AMERICA AND THEY DENIED ANY PROBLEMS WITH THE CEM AND SAID SINCE IT'S AN '04 WITH 85,000 MILES THAT I'M OUT OF WARRANTY AND THEY CAN OFFER NO HELP.

I HAD THIS PROBLEM A FEW TIMES A YEAR AGO AND NOW IT HAS RETURNED. I WAS DRIVING MY CAR AT NIGHT IN THE RAIN ON A TWO LANE FREEWAY WHEN ALL OF A SUDDEN I LOST THE HEADLIGHTS, DASH LIGHTS, SPEEDOMETER, RADIO, POWER WINDOWS, ELECTRIC TRANSMISSION, AND MUCH MORE FUNCTION OF THE CAR. THE ENGINE IS STILL RUNNING BUT IT SEEMS TO ALMOST RESET OR SOMETHING THEN START SHUTTING STUFF DOWN. I SEE ON YOUR WEBSITE SOMEONE PUT THIS IN AS A COMPLAINT ALSO THIS IS VERY DANGEROUS YOU CANT SEE AT NIGHT THE CAR IS HARD TO DRIVE ITS OBVIOUSLY THIS SAME PROBLEM WITH WATER GETTING INTO THE ECM. I READ THROUGH YOUR INFORMATION AND IT SEEMS LIKE VOLVO KNEW SOMETHING WAS UP WITH ONES PRODUCED BEFORE OR AFTER MARCH. IT SEEMS LIKE THEY HAVE BEEN WELL AWARE OF THE PROBLEM AND STILL WANT TO CHARGE YOU $2000...

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING FAILED AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE CONTACT STATED THAT A NEW ALTERNATOR WAS PLACED IN THE VEHICLE TWO DAYS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

THIS REPORT IS ABOUT A HAZARDOUS SITUATION WITH OUR 2004 XC90. THE ENGINE SHUT DOWN WITHOUT WARNING ON THE I5 FREEWAY! THE CAR SUDDENLY LOST POWER AND WE HAD TO COAST TO THE SIDE IN THE DARK. WE WERE LUCKY TO NOT GET HIT! THE DISPLAY SHOWED THE FOLLOWING ERROR CODE: ECM-981A. WE ARE AWARE OF THE FACT THAT THIS PROBLEM IS NOT NEW TO NHTSA AND THAT YOU HAVE RECEIVED SEVERAL REPORTS ON IT ALREADY. IT APPEARS THAT THE PROBLEM HAS TO DO WITH THE CRUISE CONTROL, AND EVER SINCE THE INCIDENT WE HAVE BEEN DRIVING THE CAR WITHOUT ENGAGING IT WITHOUT ANY PROBLEMS. THE MILEAGE ON THE CAR IS 138,000 MILES. THE PROBLEM OCCURRED WHEN ENGAGING THE CRUISE CONTROL ON AN UPHILL SLOPE. WE SPECULATE THAT IT MIGHT BE CAUSED BY ENGAGING THE CRUISE CONTROL AT THE SAME INSTANT AS THE CAR SHIFTS DOWN AUTOMATICALLY. I TALKED TO...

WHILE DRIVING AT ANY SPEED THE VEHICLES ELECTRICAL SYSTEM COMPLETELY SHUTS DOWN WITH OUT WARNING AS IF THE VEHICLE WAS OFF. THE ENGINE STAYS RUNNING WITH VERY MINIMAL POWER. THIS HAPPENED TO ME AT NIGHT WHILE DRIVING ON THE HIGHWAY, IT WAS RAINING AND ALL THE LIGHTS, WIPERS, EVERY ELECTRICAL PART JUST SHUT OFF, I AM LUCKY I DID NOT CRASH. AFTER RESEARCHING I THAT A LOT OF OWNERS HAVE THE SAME PROBLEMS AND THAT VOLVO IS AWARE OF THE DANGEROUS PROBLEM BUT DOES NOTHING ABOUT IT.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO JERK AND THE INSTRUMENT PANEL FAILED. THE ACCELERATOR PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED FREQUENTLY. THE CONTACT ALSO STATED THAT ON SEVERAL OCCASIONS IT TOOK SEVERAL ATTEMPTS TO START TO VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED AND LOST POWER. THE CONTACT ALSO HEARD WATER RUNNING ON THE RIGHT PASSENGER SIDE DOOR AND UNDERNEATH THE DASHBOARD. THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,00. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. DJR

EXITING DRIVEWAY IN REVERSE, UPON SWITCHING TO DRIVE THE DASHBOARD LIGHTS STARTED FLICKERING AND A JERK WAS FELT IN THE TRANSMISSION. SOON THE DASHBOARD GAUGES AND THE INDICATORS WENT DEAD. SEVERAL ERROR MESSAGES QUICKLY "SCROLLED" (BRAKE FAILURE, AIRBAG FAILURE, ABS FAILURE, ENGINE FAILURE) THEN THE CHECK ENGINE LIGHT CAME ON AND REMAINED ON. NO POWER TO DASHBOARD CONTROLS (GAUGES DEAD, NO LIGHTS/TURN SIGNALS, NO RADIO). FRONT WINDOWS WORK, BUT NOT REAR. VEHICLE DRIVES AS IF IN LOW GEAR. UNSAFE TO DRIVE SO HAD TOWED TO DEALER. THEY ARE RUNNING DIAGNOSTICS SO TBD ON SPECIFIC ISSUE AND COST TO REPAIR. CONCERNED AS NO RECALL AND SITUATION IS SO DANGEROUS (WHAT IF I'D BEEN ON FREEWAY!) VOLVO SHOULD RECALL ALL THE 2004 XC90 AS OTHERS REPORT SAME DEFECT

I WAS HEADING TOWARDS A SUPERMARKET ON A EXPRESSWAY ON A AN AFTERNOON WHERE THERE WAS A CLICKING SOUND NEAR THE DASHBOARD ON DRIVERS SIDE. AND THEN SUDDENLY THE DASHBOARD LIGHTS STARTED FLICKERING AND A JERK WAS FELT IN THE TRANSMISSION. SOON THE DASHBOARD GAUGES AND THE INDICATORS WENT DEAD WHILE DRIVING AND THAT TOO WITHOUT ANY WARNING. THERE WAS SEVERAL ERROR MESSAGES THAT WERE POPPING UP LIKE BRAKE FAILURE, AIRBAG FAILURE, ABS FAILURE, ENGINE FAILURE AND THEN THE CHECK ENGINE LIGHT CAME ON. THE POWER WAS TOTALLY CUT OFF AND THE STEERING WAS VERY HARD. IT APPEARED AS IF THE VEHICLE IS IN A LOW GEAR. IBHAD TO TAKE THE NEXT EXIT TO COME TO A SAFE STOP AS NO INDICATORS WERE WORKING. I TRIED TO TURN OFF THE IGNITION AND THEN TRIED TO RESTART. THE VEHICLE STARTED BUT ALL THE GAUGES ON THE DASH WERE DOWN. HAD TO...

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING APPROXIMATELY 70 MPH, A LOUD ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE VEHICLE LOST ELECTRICAL POWER BRIEFLY. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THERE WAS AN ELECTRICAL MODULE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

I SWITCHED FROM HEADLIGHTS ON TO DAYLIGHT DRIVING LIGHTS ON. I RECEIVED A "BULB FAILURE" FOR THE DAYLIGHT DRIVING LIGHTS. I SWITCHED BACK TO HEADLIGHTS. I RECEIVED A "BULB FAILURE" FOR THE HIDS. I HAVE VERIFIED THAT THE FUSES ARE GOOD, AND THAT THERE ARE NOW NO WORKING HEADLIGHTS ON THE CAR. HAD THIS HAPPENED AT NIGHT IT COULD HAVE BEEN BAD, VERY BAD. THANK GOD IT HAPPENED DURING A SUNNY DAY AND THAT THE TEEN DRIVER WASN'T BEHIND THE WHEEL.

HELLO VOLVO, FOR THE RECORD, WE LOVE OUR VOLVO SUV (2004, XC90). OVER THE YEARS THE SERVICE FROM MICHELLE BALSIDE AT VOLVO ON PLAINFIELD ROAD IN CINCINNATI HAS BEEN TRULY EXCELLENT, HER CONTACT INFORMATION IS ATTACHED. HOWEVER, WE HAVE HAS AN ISSUE SINCE 2011 THAT HAS NOT BEEN RESOLVED, WHICH IS SO UNCHARACTERISTIC OF VOLVO. I AM HOPING YOU CAN HELP ME CHANGE THE OUTCOME. FOR YEARS MY HUSBANDS RIGHT HEADLIGHT HAS BEEN TURNING ON AND OFF INTERMITTENTLY. THIS IS VERY DANGEROUS WHEN HE DRIVES TO AND FROM WORK AT NIGHT ON AN OLD 4 LANE HIGHWAY (COLUMBIA PARKWAY) THAT HAS NO SEPARATION BETWEEN EAST AND WEST BOUND LANES, WHICH MEANS CARS TRAVEL HEAD-ON AT 70 MILES AN HOUR. OUR DEALER LOOKED AT THE ISSUE SEVERAL TIMES AND SAID THEY COULD NOT FIX IT; SO WE LIVED WITH THE DANGEROUS ISSUE BECAUSE WE THOUGHT THE PROBLEM WAS UNIQUE TO US....

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE IN PARK, THE CONTACT HEARD A NOISE. ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE AND THE VEHICLE STALLED. IN ADDITION, THE CONTACT STATED THAT THE ODOMETER DISPLAYED AN INCORRECT READING AND THERE WAS A FUEL ODOR IN THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED BACK TO THE INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CENTRAL ELECTRONIC MODULE AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES OF DRIVING THE SAME STALLING AND ELECTRICAL ISSUES HAPPEN AGAIN. THIS IS SERIOUS BECAUSE YOU ARE ON FREEWAY AND YOU LOOSE BRAKES AND ENGINE CONTROL, NO INFORMATION IN INSTRUMENT PANEL, ETC. I FOUND THAT THE RELAYS IN THE CEM (CONTROL ELECTRONICS MODULE) ARE SUPER HOT POSSIBLY DUE TO LOOSE CONNECTIONS, IN THE VIDEO BELOW YOU WILL SEE...

CAR LOST ALL POWER AND MESSAGE WINDOW READ "REDUCED ENGINE PERFORMANCE". WE WERE TRAVELING IN THE LEFT LANE AND HAD TO COAST THROUGH TRAFFIC TO THE SHOULDER. THERE WAS ABSOLUTELY NO THROTTLE RESPONSE, SO WE SHUT THE CAR OFF. UPON RESTARTING IT, THE MESSAGE DISAPPEARED AND WE WERE ABLE TO CONTINUE OUR TRIP. IT HAPPENED AGAIN, AND WE RESET IT ONCE AGAIN. WE STOPPED AT THE FIRST VOLVO REPAIR FACILITY WE FOUND AND HAD THEM SCAN ALL THE COMPUTERS USING THE VOLVO DIAGNOSTIC EQUIPMENT. THE CODE THEY RETRIEVED WAS ECM-981A. THEY CLEARED OUR COMPUTER USING THE VOLVO COMPUTER, BUT THE PROBLEM RETURNED ON OUR RETURN HOME. WE WERE BARELY ABLE TO GET OUT OF THE WAY OF A SEMI BARRELING UPON US! THE PROBLEM STILL PERSISTS, AND I FINALLY WENT TO MY COMPUTER TO FIND SOME INFORMATION ON MY OWN. APPARENTLY, THIS IS NOT SO UNCOMMON A PROBLEM WITH THESE...

IN OCTOBER 2014 MYSELF MY BOYFRIEND AND MY 7 YEAR OLD WE'RE DRIVING HOME WHEN ALL OF A SUDDEN THE CAR WOULD NOT ACCELERATE WHEN I TRIED TO PUSH THROUGH THE TRAFFIC LIGHT THE VEHICLE THEN SLOWED DOWN IN THE MIDDLE OF THE ROAD THEIR WAS NO WAY OF ME TRYING TO PULL OVER BC THE CAR COMPLETELY STOPPED I THEN PROCEEDED TO GET MY 7 YEAR OLD OUT THE TRUCK AND HER SPELT BELT IN THE BACK WAS STUCK AND WOULD NOT COME OUT WE WERE ALMOST HIT FROM THE BACK DUE TO THE VEHICLE STALLING IN THE MIDDLE OF THE ROAD IN A CURVE WE WERE STRANDED FOR ABOUT THREE HOURS IN THE DARK WHEN WE WERE FINALLY TOWED HOME I WAS TOLD THAT THE TRANSMISSION WAS NO GOOD AND THIS IS THE REASON OUR VEHICLE STALLED AND WAS DISABLED. *TR

WHILE DRIVING OUR VOLVO XC-90, THE ENTIRE ELECTRICAL SYSTEM SHUTS DOWN (DASHBOARD DISPLAY, LIGHTING, AC, POWER WINDOWS, POWER DOOR LOCKS, EVERYTHING ELECTRICAL ETC.). ADDITIONALLY, FOR A SPLIT SECOND THE ENGINE/TRANSMISSION JERKS AND/OR STALLS BEFORE RESUMING. THE FIRST TIME THIS HAPPENED WAS IN 2010 AND NEVER OCCURRED AGAIN FOR SEVERAL YEARS. THEN SUDDENLY ON A RECENT TRIP IN AUGUST 2014 THIS HAPPENED REPEATEDLY AND THE ELECTRICAL SYSTEM NEVER RETURNED TO OPERATION DURING THAT TRIP. IN THAT AUGUST 2014 OCCURRENCE WE WERE TRAVELING DOWN NARROW STATE HIGHWAY 1 IN BIG SUR, CALIFORNIA. HAD WE LOST CONTROL OF THE VEHICLE DURING THE JERKING EPISODES WE COULD HAVE GONE OFF THE NARROW ROAD AND DOWN THE STEEP CLIFF SIDE TO OUR DEATHS. THIS PUT OUR FAMILY IN A VERY PERILOUS SITUATION. ADDITIONALLY, SINCE THE ABOVE INCIDENT IN LATE AUGUST 2014 THE VEHICLE HAS EXPERIENCED NUMEROUS OTHER FLASHES/JERKING INCIDENTS WHILE AT HIGHWAY SPEEDS. THIS OCCURRENCE...

I HAVE EXPERIENCED THE KNOWN ISSUE WITH THE CENTRAL ELECTRONIC MODULE MANY TIMES NOW. I HAVE BEEN DRIVING AT HIGHWAY SPEEDS AND THEN EXPERIENCE THE MOMENTARY JERKING, LOSS OF POWER, LOSS OF INSTRUMENT PANEL, AND MORE. SOMETIMES I START MY VEHICLE AND IT STARTS IN LIMP HOME MODE. VERY FRUSTRATING AND DANGEROUS. THIS SHOULD BE RECALLED AND REPAIRED BY VOLVO. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHENEVER THE VEHICLE WAS DRIVEN OVER A BUMP IN THE ROAD OR IF THE CONTACT INADVERTENTLY HIT THE KEY, THE VEHICLE WOULD STALL. THE LATEST FAILURE OCCURRED WHILE DRIVING 70 MPH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. UPDATED 10/30/14*LJ UPDATED 04/27/2015 *JS

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 55 MPH, THE VEHICLE STALLED INTERMITTENTLY. THE CONTACT STATED THAT THE INSTRUMENT PANEL AND RADIO WOULD SHUT OFF AND THE WINDSHIELD WIPERS ACTIVATED. ALSO, THE ABS AND ANTI SKID TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 104,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLES AGE. UPDATED 3/23/15 *JS

2004 VOLVO XC90 2.5T ...DRIVING AT ABOUT 65 MPH WITH NO WARNING ALOUD THUMP NOISE, WINDSHIELD WIPER COMES ON RADIO GOES OFF DASH LIGHTS GO OFF, LAST FOR A SEC. THEN RESUMES TO NORMAL . THIS HAS HAPPENED SEVERAL TIMES NOW, WHILE I HAVE ONLY OWNED THIS VEHICLE FOR A MONTH. TODAY IT HAPPENS AGAIN ONLY WORSE ..AFTER THE INITIAL THUMP AND JERK IT HAPPENS THREE MORE WITHIN 5 MILES THE LAST TIME I WAS GOING ABOUT 35 MPH, BIG THUMP AND JERK, WIPERS COMES ON , RADIO GOES OFF , ALL DASH LIGHTS OFF ..NO HAZARDS AVAILABLE AND I GET SEVERAL WARNINGS ON DASH BRAKE FAILURE , SRS FAILURE AND ANTI SKID FAILURE. .I TURN CAR OFF THEN BACK ON AND CONTINUE HOME...IT HAPPENS AGAIN 5 MINUTES LATER AT 15 MPH....I AM READING MANY, MANY COMPLAINTS LIKE MINE. THIS ISSUE NEEDS TO BE ADDRESSED ASAP. .I ALMOST WAS REAR...

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD STALL AND UNKNOWN WARNING INDICATORS WOULD ILLUMINATE. IT TOOK THE CONTACT NUMEROUS ATTEMPTS TO RESTART THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

3 HOURS INTO A 3-1/2 HOUR WEEKEND ROAD TRIP THERE WAS A CLUNK IN THE ENGINE COMPARTMENT. THINKING I HIT A POTHOLE, I CONTINUED ON CAUTIOUSLY. WHILE CONTINUING ON THESE UNFAMILIAR 2 LANE WINDY ROADS GOING 43MPH (THE SPEED LIMIT WAS 55) ABOUT 2 MILES FROM WHERE THE CLUNK HAPPENED MY ENTIRE DASH CLUSTER STOPPED WORKING. ALL MY DOME LIGHTS AND LEG LIGHTS CAME ON. THE CAR CLUNKED HARDER THIS TIME. I LOST POWER TO THE ENGINE, STEERING WAS LIKE TRYING TO TURN A TANK, AND THE BRAKES WERE VERY SPONGY. STILL TRAVELING ON WINDY ROADS WITH LARGE SEMI TRUCKS BEHIND ME AND CARS PASSING BY IN THE OPPOSITE LANE I VEERED TO THE RIGHT TO AVOID BEING REAR ENDED BY A SEMI. NOT BEING ABLE TO STEER OR STOP AS EFFICIENTLY AS BEFORE I COASTED INTO A RESIDENTS 2-3 MAN ROCK LANDSCAPE TRAVELING AT ABOUT 5MPH. I DENTED MY...

WHILE GOING UP A HILL ABOUT 45 MILE PER HOUR THE LIGHTS ON MY DASH AS WELL AS THE RADIO TURNED OFF. I PULLED OVER TURNED THE CAR OFF AND BACK ON ALL THE LIGHTS RETURNED HOWEVER MY GAS GAUGE NO LONGER WORKS AS WELL AS UNLOCKING BACK DOORS AND DOOR TO GAS TANK. THERE ARE MANY COMPLAINTS ABOUT THIS PART I DON'T SEE WHY THERE ARE NO RECALLS THIS IS VERY UNSAFE I COULD'VE EASILY CRASHED DUE TO LOSS OF POWER BREAKS AND THE CAR NOT MAKING IT UP THE HILL. *TR

DRIVING VEHICLE AT 45MPH AND KEY SWITCHED OUT OF THE "RUN" POSITION WHILE BEING DRIVEN. VEHICLE'S ENGINE COMPLETELY SHUT OFF, RENDERING POWER BRAKES, POWER STEERING AND AIRBAGS AS NOT OPERATIONAL. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC 90. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY AND THE INSTRUMENT PANEL WENT COMPLETELY DARK. THE VEHICLE STARTED MAKING A CLICKING NOISE AND STALLED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND THE BATTERY WAS DISCONNECTED. THE VEHICLE WAS RESTARTED AND RESUMED ITS NORMAL OPERATIONS. THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 86,000 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 10/1/14*CN

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS THE VEHICLE FAILED TO START. THE CONTACT MENTIONED THAT FOR A MOMENT THE ENTIRE INSTRUMENT PANEL ILLUMINATED, BUT THEN THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE CE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 18,000.

WHILE ON THE INTERSTATE AT 60MPH, EXPERIENCED TEMPORARILY LOSS OF POWER, THE IP DISPLAYS AND AN ABNORMAL 'JERKING' IN THE TRANSMISSION/DRIVETRAIN. THE SRS AIRBAG AND BRAKE FAILURE ERROR MESSAGES APPEARED IN THE IP ERROR DISPLAY. THE WIPERS MOMENTARILY CAME ON. LIGHTS DIMMED. POWER FAILURE WAS ONLY FOR A SPLIT-SECOND (AT 60MPH) BEFORE RETURNING TO NORMAL. AFTER NORMAL POWER WAS RESTORED, ERROR MESSAGES CONTINUED TO BE SHOWN IN THE IP ERROR DISPLAY. THE BRAKE FAILURE MESSAGE INSTRUCTED ME TO PULL OVER AND BRING THE VEHICLE TO A SAFE STOP. UPON BRINGING THE VEHICLE TO A SAFE STOP AND TURNING OFF IGNITION, I HEARD EXCESSIVE ELECTRICAL CLICKING UNDER THE DASH (LIKE RELAYS CLICKING). ALL IP DISPLAYS WERE NON-RESPONSIVE (DARK). I LOCKED THE CAR (ALARM ARMED) AND LATER RETURNED WITH A TOW-TRUCK. UPON RETURN TO THE CAR, I WAS UNABLE TO UNLOCK IT OR DISARM THE ALARM. CAR WAS UNRESPONSIVE. ALARM WAS ARMED...

WHILE DRIVING DOWN THE ROAD AROUND 50 MPH THE XC90 SKIPPED AND TEMPORARILY TURNED OFF ALL ELECTIONS. THOUGHT IT WAS A GLITCH SO CONTINUED DOWN THE ROAD MORE CAREFULLY. THEN IT HAPPENED AGAIN AND THE ELECTRONICS NEVER CAME BACK ON. I COULDN'T MAKE IT UP A SMALL HILL ON THE ROAD TO GET SAFELY HOME. MY TRANSMISSION WOULDN'T PULL. THE SPEED GAUGE AND RPMS WERE COMPLETELY UNWORKING. WINDOWS WOULD NOT ROLL DOWN AIR HAD WENT OUT. POWER STEERING TEMPORARILY WENT OUT. MADE IT HOME FINALLY AND NOTHING SEEMS WRONG NOW BUT THERE IS OBVIOUSLY A PROBLEM THAT NEEDS TO BE FIXED. I COULD HAVE EASILY BEEN IN A WREAK OR STRANDED ON THE SIDE OF THE ROAD WITH MY BABIES. VOLVO NEEDS TO TAKE RESPONSIBILITY. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE MOMENTARILY LOST POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN COULD NOT DIAGNOSE A FAILURE HOWEVER, THE BATTERY WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 109,000.

ON TWO SEPARATE OCCASIONS, OUR VEHICLE WOULD NOT RESTART AFTER STOPPING FOR GAS. THIS OCCURRED AFTER IT WAS SERVICED AND BATTERY REPLACED A WEEK PRIOR. AAA WAS UNABLE TO JUMP START IT AS WELL, AND VEHICLE HAD TO BE TOWED BACK TO DEALERSHIP FOR REPAIRS. ACCORDING TO THE TWO SEPARATE DEALERSHIPS, THE CENTRAL ELECTRONICS MODULE IS THE CULPRIT, AND NEEDED REPLACING. ACROSS MULTIPLE ONLINE FORUMS, VOLVO OWNERS HAVE COMPLAINED ABOUT SIMILAR PROBLEMS WITH THE CEM, OFTEN PLACING DRIVERS AND OCCUPANTS IN DANGER AS THEY EXPERIENCED COMPLETE ELECTRICAL OUTAGE AT HIGHWAY SPEEDS. WE WERE FORTUNATELY THAT OUR VEHICLE JUST DID NOT RESTART, INSTEAD OF SHUTTING DOWN IN TRAFFIC AT 65 MPH. THIS IS A SIGNIFICANT SAFETY ISSUE, AND VOLVO SHOULD BE RESPONSIBLE FOR REPLACING THE FAULTY UNITS. *TR

THE IGNITION TURNS TO THE ACCESSORY POSITION IF THE KEY IS BUMPED, WHILE THE VEHICLE IS IN GEAR. THE VEHICLE LOSES POWER STEERING AND POWER BRAKES. THIS HAS HAPPENED TWICE IN THE LAST YEAR. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM FAILED AND THE INSTRUMENTAL PANEL BECAME DARK AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED. THE TECHNICIAN ADVISED THAT THE ELECTRONIC CONTROL MODULE FAILED DUE TO WATER INTRUSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 115,000.

WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE EXPERIENCED A COMPLETE SYSTEMS FAILURE OF ENGINE, LIGHTING, WIPERS, INTERIOR LIGHTING (DASH), BRAKE FAILURE MESSAGE AND SRS AIRBAG SERVICE WARNINGS. THIS HAS BEGUN TO HAPPEN REPEATEDLY. THIS PROBLEM APPEARS TO BE THE SAME THAT MANY OTHER XC90 OWNERS HAVE BEEN EXPERIENCING. *JB

WHILE DRIVING 70 MPH ON I-5 WE HEARD A LOUD THUMP IN THE ENGINE COMPARTMENT AND WE SUDDENLY WENT TO ABOUT 25 MPH ALL OF OUR ELECTRONIC SYSTEMS SHUT DOWN, THERE WAS AN EXTREMELY LOUD GRINDING SOUND FOR APPROX. 2-3 SECONDS. NOW I THINK MY TRANSMISSION IS DAMAGED AND THE ELECTRONICS SYSTEM SHUTS DOWN PRETTY FREQUENTLY. I AM TOTALLY DISAPPOINTED TO READ THAT THIS HAS HAPPENED TO NUMEROUS OTHER FAMILIES. THANK GOD NO ONE HAS DIED FROM THIS.....THIS IS VERY IRRESPONSIBLE AND NEGLIGENT FROM A REPUTABLE AUTO COMPANY. IS IT GOING TO TAKE SOMEONE OR FAMILY TO GET SERIOUSLY INJURED OR DIE BEFORE THEY ACKNOWLEDGE THIS VERY SERIOUS ISSUE. ITS TIME FOR SOMEONE TO BE ACCOUNTABLE FOR THIS. *JS