2004 VOLVO XC90 Steering Problems

STEERING-LINKAGES: TIE ROD ASSEMBLY ON CERTAIN PASSENGER VEHICLES, THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT. CONSEQUENCES OF DEFECT: THE DRIVER MAY NOTICE THAT HTE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH. WHEELS: ON CERTAIN SUV'S THE FRONT WHEEL SPEED SENSORS MAY BE DEFECTIVE. CAUSING AN ERRONEOUS WHILL SPEED SIGNAL. CONSEQUENCES OF THE DEFECT: THIS CAN ADVERSELY AFFECT A NUMBER OF VEHICLE FUNCTIONS, INCLUDING BRAKE, ENGINE, TRANSMISSION, AND TORQUE DISTRIBUTION CONTROL WHICH RELY ON THIS SIGNAL FOR PROPER OPERATION. VISIBILTY: WINDSHIELD WIPER/WASHER ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS...

ON CERTAIN PASSENGER VEHICLES, THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF CLAMPING AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FRACTURE OF THE OUTER ROD BALL JOINT. THE DRIVER MAY NOTICE THE VEHICLE IS DIFFCULT TO MANEUVER INCREASING THE RISK OF A CRASH. WHEELS: ON CERTAIN SUV'S, THE FRONT WHEEL SPEED SENSORS MAY BE DEFECTIVE, CAUSING AN ERRONEOUS SPEED SIGNAL THIS CAN ADVERSELY AFFECT A NUMBER OF VEHICLE FUNCTIONS, INCLUDING BRAKE, ENGINE, TRANSMISSION, AND TORQUE DISTRIBUTION CONTROL WHICH RELY ON THIS SIGNAL FOR PROPER OPERATION. SEAT BELTS: REAR ON CERTAIN SUV'S, THE SEAT BELT ATTACHMENT FOR THE SECOND AND THIRD ROW MAY NOT HAVE BEEN FITTED PROPERLY. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY. CORRECTIVE ACTIONS: DEALER WILL INSPECT AND REPAIR FREE OF CHARGE. IN MY CASE,...

I AM CONCERNED THESE 2 ISSUES MAY POSE A SAFETY RISK. I RECENTLY PURCHASED THIS CAR FROM A FRIEND AND HAVE HAD IT ABOUT A MONTH. I NOTICE THE STEERING IS VERY STIFF AND DIFFICULT TO MANEUVER. I WAS TRYING TO FIND OUT IF THERE WERE ANY RECALLS ON THIS BUT HAVING NO LUCK. ALSO, WHEN THE CAR IS IN GEAR "DRIVE", WHEN STOPPED ON AN INCLINE (EVEN THE SLIGHTEST HILL) I NOTICE THAT WHEN I TAKE MY FOOT OFF THE BRAKE PEDAL THE CAR ROLLS BACKWARDS! IT SHOULDN'T DO THAT. THE TRANSMISSION NOTICE ON THE DASH IS SAYING IT NEEDS SERVICE BUT MY FRIEND I BOUGHT IT FROM SAID SHE HAD IT CHECKED TWICE AND WAS TOLD THERE IS NO TRANSMISSION ISSUE. IS THERE A RECALL ON POWER-TRAIN/TRANS PARTS? THE CAR SHOULD NOT ROLL BACKWARDS WHEN IN GEAR "DRIVE", EVEN IF I AM STOPPED ON A HILL. EVEN A...

SRS -AIRBAG SERVICE URGENT OIL LIGHT ON SOMETIMES

THERE HAS BEEN PROBLEMS WITH STEERING THE DRIVER SHAFTS THE FUEL PUMP AIRBAGS AND WHEELS MAKING A CLICKING NOISE WHILE DRIVING ON HIGHWAY. THE GAS SMELL IS ALWAYS INSIDE THE CAR AND MECHANIC HAS SAID IT'S FROM THE FUEL PUMP DEFECT DURING MANUFACTURER. ALONG WITH THE OTHER FORE-MENTION DEFECTS .VOLVO DOES NOT WANT TO ADDRESS ISSUES BECAUSE AGE OF CAR. THERE IS A DEFECTIVE SUNROOF THAT ALLOWS WATER TO LEAK INSIDE THE CAR DURING RAIN FALL . THERE HAS BEEN A TOP CLASS ACTION PLACED AGAINST VOLVO FOR THIS . THEY WANTED TO CHARGE ME $700 TO $800 FOR THIS DEFECT AND $1200 TO $1500 FOR FUEL PUMP .

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING FAILED AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE CONTACT STATED THAT A NEW ALTERNATOR WAS PLACED IN THE VEHICLE TWO DAYS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING OUR VOLVO XC-90, THE ENTIRE ELECTRICAL SYSTEM SHUTS DOWN (DASHBOARD DISPLAY, LIGHTING, AC, POWER WINDOWS, POWER DOOR LOCKS, EVERYTHING ELECTRICAL ETC.). ADDITIONALLY, FOR A SPLIT SECOND THE ENGINE/TRANSMISSION JERKS AND/OR STALLS BEFORE RESUMING. THE FIRST TIME THIS HAPPENED WAS IN 2010 AND NEVER OCCURRED AGAIN FOR SEVERAL YEARS. THEN SUDDENLY ON A RECENT TRIP IN AUGUST 2014 THIS HAPPENED REPEATEDLY AND THE ELECTRICAL SYSTEM NEVER RETURNED TO OPERATION DURING THAT TRIP. IN THAT AUGUST 2014 OCCURRENCE WE WERE TRAVELING DOWN NARROW STATE HIGHWAY 1 IN BIG SUR, CALIFORNIA. HAD WE LOST CONTROL OF THE VEHICLE DURING THE JERKING EPISODES WE COULD HAVE GONE OFF THE NARROW ROAD AND DOWN THE STEEP CLIFF SIDE TO OUR DEATHS. THIS PUT OUR FAMILY IN A VERY PERILOUS SITUATION. ADDITIONALLY, SINCE THE ABOVE INCIDENT IN LATE AUGUST 2014 THE VEHICLE HAS EXPERIENCED NUMEROUS OTHER FLASHES/JERKING INCIDENTS WHILE AT HIGHWAY SPEEDS. THIS OCCURRENCE...

3 HOURS INTO A 3-1/2 HOUR WEEKEND ROAD TRIP THERE WAS A CLUNK IN THE ENGINE COMPARTMENT. THINKING I HIT A POTHOLE, I CONTINUED ON CAUTIOUSLY. WHILE CONTINUING ON THESE UNFAMILIAR 2 LANE WINDY ROADS GOING 43MPH (THE SPEED LIMIT WAS 55) ABOUT 2 MILES FROM WHERE THE CLUNK HAPPENED MY ENTIRE DASH CLUSTER STOPPED WORKING. ALL MY DOME LIGHTS AND LEG LIGHTS CAME ON. THE CAR CLUNKED HARDER THIS TIME. I LOST POWER TO THE ENGINE, STEERING WAS LIKE TRYING TO TURN A TANK, AND THE BRAKES WERE VERY SPONGY. STILL TRAVELING ON WINDY ROADS WITH LARGE SEMI TRUCKS BEHIND ME AND CARS PASSING BY IN THE OPPOSITE LANE I VEERED TO THE RIGHT TO AVOID BEING REAR ENDED BY A SEMI. NOT BEING ABLE TO STEER OR STOP AS EFFICIENTLY AS BEFORE I COASTED INTO A RESIDENTS 2-3 MAN ROCK LANDSCAPE TRAVELING AT ABOUT 5MPH. I DENTED MY...

DRIVING VEHICLE AT 45MPH AND KEY SWITCHED OUT OF THE "RUN" POSITION WHILE BEING DRIVEN. VEHICLE'S ENGINE COMPLETELY SHUT OFF, RENDERING POWER BRAKES, POWER STEERING AND AIRBAGS AS NOT OPERATIONAL. *TR

TL*THE CONTACT OWNS A 2004 VOLVO XC90. WHILE TRAVELING 35-45 MPH THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE TIRE HAD SUDDENLY TURNED OUTWARD RUBBING AGAINST THE WHEEL WHICH CAUSED THE VEHICLE TO COME TO STOP. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 77000.

AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CENTRAL LOCKING SYSTEM STOPPED FUNCTIONING. WE GOT OUT OF TRAFFIC AND INTO THE SHADE. I CHECKED ALL FUSES AND TRIED TO RESTART THE CAR. IT WOULD RESTART, BUT WITHIN SECONDS THERE WERE MULTIPLE "CLICKS" COMING FROM THE AREA NEAR THE FUSE BOX IN THE PASSENGER COMPARTMENT FOLLOWED BY THE ELECTRICAL...

TRANSMISSION REPLACED JUNE 08 FRONT CONTROL ARMS AND BUSHINGS AND COOLANT RESERVOIR REPLACED SEPT. 08 THERMOSTAT & HOUSING & TEMP SENSOR REPLACED JAN. 08 BRAKE VACUUM PUMP REPLACED FOR 2ND TIME JAN. 08 BRAKE VACUUM PUMP REPLACED SEPT. 07 GASKET, O-RING, HOSE CLAMP RECALL SEPT. 07 POWER STEERING PUMP AND BRAKE VACUUM PUMP INSTALLED JULY 07 STEERING RACK SOLENOID REPLACED JULY 07 - (RECALL MAY 3, 08?) NEW BRIDGESTONE TIRES MAY 07 UPPER ENGINE TORQUES MOUNT REPLACED MARCH 07 RECALL WIPER ARM 156, BALL JOINT 157 OCT. 06 BRAKE PAD & ROTORS REPLACED OCT 06 UPGRADE SOFTWARE A & C JULY 05 ABS BRAKES WARRANTY FIX MAY 06 FRONT PADS & REAR PADS & ROTORS REPLACED DEC. 05 EXHAUST RUBBING ON DRIVELINE, INSTALL KIT TO HOLD EXHAUST OFF DRIVELINE DEC. 05 LEFT REAR WHEEL BEARING & HUB, REAR PADS & ROTORS REPLACED JUNE 05 4 NEW TIRES JUNE 05 TURBO...

WHILE DRIVING MY 2004 VOLVO XC-90 AT NIGHT I EXPERIENCED A MOMENTARY LOSS OF CONTROL, FOLLOWED BY THE HEADLIGHTS PAUSING AND THEN GOING FROM HIGH BEAMS TO LOW. THE INSTRUMENT CLUSTER LOST SOME OF IT'S DISPLAYS AND THE DOOR LOCKS BECAME INOPERATIVE. THE DATA DISPLAY WARNED ME OF AN "URGENT SRS FAILURE". I WAS AT LOW SPEED A BLOCK FROM HOME SO I CREPT HOME AND THE NEXT DAY SENT THE CAR TO TRIAD VOLVO BY ROLL-BACK WRECKER. PROBLEM WAS FAILURE OF CENTRAL ELECTRONIC MODULE. I CALLED VOLVO CORPORATE AND THEY SEEMED DISINTERESTED. *TR

STEERING FEELS SLOPPY AND CAR PULLS TO THE LEFT. DEALER SENT IT FOR ALIGNMENT FOR MORE THAT 10 TIMES. PROBLEM NOT RECTIFIED. DEALER ALSO REPLACED THE FLANGE NUT IN THE STEERING WHEEL BUT FEELS STILL SLOPPY. *TR

ON AUGUST, 26, 2004 THERE WAS A MAJOR MALFUNCTION IN OUR VOLVO XC90 (2004). WHILE DRIVING WITH 2 SMALL CHILDREN IN CAR SEATS AND 2 ADULTS ON A MAJOR HIGHWAY; SUDDENDLY, THERE WAS NO ACCELERATION IN THE GAS PEDAL AND THE STEARING WHEEL DID NOT FUNCTION. WE MANAGED TO SLOWLY MOVE TO THE SIDE OF THE ROAD FROM WHAT MOMENTUM WAS LEFT IN THE CAR, AND AVOID AN ACCIDENT. WE WERE OBVIOUSLY VERY SHAKEN UP, AND FIND THIS CAR COMPLETELY UNSAFE. IT HAS BEEN 3 WEEKS NOW GETTING THE RUN AROUND WITH THE CHERRY HILL, NEW JERSEY VOLVO DEALER. THEY SAID "THERE'S NOTHING WRONG WITH THE CAR". THE CAR IS UNSAFE FOR OUR FAMILY, AND PRESENTS A DANGER FOR OTHERS ON THE ROAD. WE ARE AFRAID IT WILL STOP DEAD AGAIN ON A MAJOR HIGHWAY WITH DEATH OR INJURIES OCCURING TO EITHER OURSELVES OR OTHERS. THE DEALER ASKED US WHAT...