2004 VOLVO XC90 Power Train Problems

I AM CONCERNED THESE 2 ISSUES MAY POSE A SAFETY RISK. I RECENTLY PURCHASED THIS CAR FROM A FRIEND AND HAVE HAD IT ABOUT A MONTH. I NOTICE THE STEERING IS VERY STIFF AND DIFFICULT TO MANEUVER. I WAS TRYING TO FIND OUT IF THERE WERE ANY RECALLS ON THIS BUT HAVING NO LUCK. ALSO, WHEN THE CAR IS IN GEAR "DRIVE", WHEN STOPPED ON AN INCLINE (EVEN THE SLIGHTEST HILL) I NOTICE THAT WHEN I TAKE MY FOOT OFF THE BRAKE PEDAL THE CAR ROLLS BACKWARDS! IT SHOULDN'T DO THAT. THE TRANSMISSION NOTICE ON THE DASH IS SAYING IT NEEDS SERVICE BUT MY FRIEND I BOUGHT IT FROM SAID SHE HAD IT CHECKED TWICE AND WAS TOLD THERE IS NO TRANSMISSION ISSUE. IS THERE A RECALL ON POWER-TRAIN/TRANS PARTS? THE CAR SHOULD NOT ROLL BACKWARDS WHEN IN GEAR "DRIVE", EVEN IF I AM STOPPED ON A HILL. EVEN A...

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING DRIVEN, THE TRANSMISSION FAILED TO SHIFT OUT OF THIRD GEAR. THE CONTACT WAS ALSO ALERTED TO A MESSAGE DISPLAY WHICH INDICATED A TRANSMISSION FAILURE. ADDITIONALLY, THE VEHICLE WOULD INDEPENDENTLY SHIFT TO NEUTRAL. NIELLO VOLVO CARS SACRAMENTO LOCATED AT 4609 MADISON AVE, SACRAMENTO, CA 95841, (916) 488-2400), WAS CONTACTED BY PHONE. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN NUMBER: 03V434000 (WHEELS). THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS TOWED BACK TO THE RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

WHILE I'M MOTION THE SRS AIRBAG LIGHT CAME ON TRANSMISSION URGENT LIGHT CAME ON AND ABS LIGHT THE BATTERY KEEPS BUBBLING LIKE ITS GONE BLOW UP IN MY TRUNK I HAVE TO JUMP IT OFF EVERY MORNING I PAID ALOT FOR THIS SUV CAN YOU PLEASE HELP ME KEEP MY ONLY CAR IN WORKING ORDER I HAVE HAD ALL MAINTAINS DONE IN PAST NOW THE COOLANT SYSTEM IS LEAKING WHAT IS GOING ON WITH THIS VOLVO XC90 T6 AWD [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

THE VOLVO HAS CONSTANT ISSUES WHEN SHIFTING AND GETTING STUCK IN A SPECIFIC GEAR. ALSO IT WILL DECIDE TO DOWN SHIFT OUT OF KNOW WHERE. I CAN BE DOING 55 ON THE HIGHWAY THEN IT SLAMS INTO 3RD AND I LOSE CONTROL OF THE VEHICLE ALMOST MAKING ME CRASH. MECHANICS DO NOT SEE ANYTHING WEONG WITH THE TRANSMISSION IE ITS GOING BAD BUT SOMETHING IS MAKING THE VEHICLE DO THIS. SOFTWARE POSSIBLY TCM NOT WORKING PROPERLY BUT MY MECHANIC ALSO INSEPECTED THAT. AFTER MUCH RESEARCH IT SEEMS TO BE A VERY WELL KNOWN AND UNSAFE CONDITION.

BOUGHT THE VEHICLE WITH 112,000 MILES ON IT, IT HAS A GAS LEAK TRICKLING DOWN THE SIDE OF THE GAS TANK, PROBABLY A BAD SENDING UNIT, FUMES ARE BAD SOME DAYS BUT WORSE ON WARMER DAYS. THE TRANSMISSION FAILED ONE DAY WITH NO WARNING OR LIGHT, IT JUST LOST MOMENTUM AND FAILED TO ENGAGE IN DRIVE. I THINK THIS IS DUE TO THE POOR ENGINEERING DESIGN VOLVO USED. THIS MODEL IS THE T6 WITH THE GM 4T65E TRANSMISSION WHICH IS WIDELY KNOWN TO FAIL EVEN AT LOW MILES. I THINK A FULL SAFETY RECALL SHOULD E SANCTIONED FOR ALL MODEL YEARS WITH THESE HORRIBLE PROBLEMS

SIMILAR TO MANY OTHERS, WHILE DRIVING OUR 2004 VOLVO XC90, WE HEAR A CLICK, THEN THE CLIMATE, RADIO AND WINDSHIELD WIPERS (IF ON) SHUT OFF AND THEIR DISPLAY LIGHTS BLACK OUT, THEN ANOTHER CLICK IN A FRACTION OF A SECOND AND THEY COME BACK ON. THIS WAS HAPPENING RANDOMLY, AND NOTHING ELSE WAS AFFECTED, UNTIL THIS WEEKEND, WHILE ON A TRIP. WE WERE DRIVING ON HIGHWAYS, OUTSIDE TEMP IN THE 80'S, NO RAIN, AVERAGE SPEED ABOUT 70MPH. IT HAPPENED A FEW TIMES OVER ABOUT 45 MINUTES, THEN BEGAN HAPPENING EVERY 5 MILES OR SO. WHEN I TURNED UP THE AC FAN, WITHIN ABOUT A MINUTE IT CLICKED AND WE LOST THE USUAL THINGS, BUT THEY DID NOT COME BACK ON. THEN WE HEARD ANOTHER CLICK AND LOST ALL DASHBOARD LIGHTING AND CONTROLS; WE COULD NOT SEE THE INSTRUMENT PANEL, THE CLIMATE CONTROL WAS BLOWING HOT AIR AND COULD NOT BE...

TRANSMISSION DOES NOT SHIFT CORRECTLY. NUMEROUS OF PROBLEMS INVOLVING OTHERS. NEEDS TO BE REPLACED. ON HIGHWAY DID NOT WANT TO GO DURING RUSH HOUR TRAFFIC. COULD OF BEEN SERIOUSLY INJURED BY ONCOMING TRAFFIC WHEN THEY OBVIOUSLY KNOW THAT THE TRANSMISSION IS A PROBLEM

WHEN I BROUGHT MY CAR TO RAMSEY VOLVO FOR SERVICE, VOLVO RECOMMENDED THE ANGLE GEAR RESEAL SERVICE BECAUSE THE ANGLE GEAR BOX IS LEAKING AS SHOWN IN THE ATTACHED PICTURE. UPON FURTHER RESEARCH, I FOUND THAT THIS IS A VERY COMMON ISSUE WITH ALL VOLVO XC90S, SO MUCH SO THAT IT CAN BE CLASSIFIED AS A MANUFACTURER DEFECT, AND QUALIFIES AS A RECALL IN MY OPINION. THE ANGLE GEAR BOX IS AN UNDISTURBED PART AND IS SUPPOSED TO BE SEALED FOR THE LIFETIME OF THE CAR. WHEN THE FLUID IN THE ANGLE GEAR BOX IS COMPLETELY LEAKED OUT, WHICH IS SOMETHING WITH NO INDICATION WHATSOEVER, THE CAR WOULD LOSE ALL WHEEL DRIVE ACCORDING TO VOLVO. WHEN THAT HAPPENS IN A SLIPPERY SITUATION WITH ICE OR SNOW, THE CAR IS MOST LIKELY TO LOSE CONTROL AND WOULD LEAD TO A SERIOUS ACCIDENT WITH POTENTIAL LOSS OF LIVES. I WOULD LIKE VOLVO...

TRANSMISSION IS DEFECTIVE AND FAILS EVERY 50,000 MILES WITHOUT WARNING WHICH COULD LEAD TO AN ACCIDENT AS VEHICLE BECOMES INOPERABLE (STOPS AND CANNOT BE MOVED) THIS IS THE 3RD TRANSMISSION INSTALLED IN THE VEHICLE BY VOLVO. EACH OF THE TRANSMISSIONS HAVE FAILED AROUND 50,000 MILES WITHOUT WARNING.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT THE ALL WHEEL DRIVE SENSOR MALFUNCTIONED. THE VEHICLE WAS TAKEN TO A MECHANIC, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V434000 (WHEELS). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 172,000.

2004 VOLVO XC90 SUDDEN ENGINE STALL WITH LOSE OF HEADLIGHTS: I WAS TRAVELING ON THE INTERSTATE AT NIGHT WITH THE CRUISE SET AT 75 MPH WHEN SUDDENLY IT WAS LIKE SOMEONE TURNED THE IGNITION KEY TO OFF FOR ABOUT 3 SECONDS, AND THEN TURNED THE KEY BACK ON WITHOUT RESTARTING THE ENGINE. WITH ALL THE WARNING LAMPS ILLUMINATED, AND THE ENGINE AT A STALL I PULLED INTO THE EMERGENCY LANE, AND STOPPED. I THEN SHIFTED TO PARK AND ATTEMPTED TO START THE VEHICLE, WHERE IT TOOK SEVERAL ATTEMPTS TO START. THE HEADLIGHTS DID NOT STOP WORKING WHILE PULLING OVER, AND WHEN I STOPPED I SWITCHED THE LIGHTS OFF BEFORE I RESTARTED THE ENGINE. THE FIRST THING AT MIND WAS A FUEL PUMP THAT WAS STARTING TO ACT UP. AFTER RESTARTING I REVVED THE ENGINE UP A FEW QUICK TIMES (TO CLEAR THE ENGINES THROAT). I THEN GOT BACK ON THE...

CAR MOVED TO RIGHT WHEN APPLYING BRAKES. CAR CLUNKS WHEN MAKING TURNS. CAR VERY NOISY WHEN GOING OVER BUMPS/ POTHOLES.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 65 MPH, THE ENGINE RPMS DECREASED AS IF THE BRAKE PEDAL WERE DEPRESSED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 135,000....UPDATED 01/27/16 *BF *JS

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED AND LOST POWER. THE CONTACT ALSO HEARD WATER RUNNING ON THE RIGHT PASSENGER SIDE DOOR AND UNDERNEATH THE DASHBOARD. THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,00. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STOPPED INDEPENDENTLY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

AS I WAS TAKING MY KIDS HOME THE TRUCK WENT INTO LIMP MODE EVEN THOUGH IT WAS STILL IN DRIVE LEAVING ME AND MY TWO KIDS STRANDED IN THE MIDDLE OF THE HIGHWAY MY DAUGHTER AND I HAD TO ACTUALLY PUSH THE VEHICLE OFF THE ROAD TO SAFETY. NOW I FIND OUT THAT IT NEEDS A NEW TRANSMISSION WHICH WE AREN'T ABLE TO LOCATE. *TR

WHILE ON THE INTERSTATE AT 60MPH, EXPERIENCED TEMPORARILY LOSS OF POWER, THE IP DISPLAYS AND AN ABNORMAL 'JERKING' IN THE TRANSMISSION/DRIVETRAIN. THE SRS AIRBAG AND BRAKE FAILURE ERROR MESSAGES APPEARED IN THE IP ERROR DISPLAY. THE WIPERS MOMENTARILY CAME ON. LIGHTS DIMMED. POWER FAILURE WAS ONLY FOR A SPLIT-SECOND (AT 60MPH) BEFORE RETURNING TO NORMAL. AFTER NORMAL POWER WAS RESTORED, ERROR MESSAGES CONTINUED TO BE SHOWN IN THE IP ERROR DISPLAY. THE BRAKE FAILURE MESSAGE INSTRUCTED ME TO PULL OVER AND BRING THE VEHICLE TO A SAFE STOP. UPON BRINGING THE VEHICLE TO A SAFE STOP AND TURNING OFF IGNITION, I HEARD EXCESSIVE ELECTRICAL CLICKING UNDER THE DASH (LIKE RELAYS CLICKING). ALL IP DISPLAYS WERE NON-RESPONSIVE (DARK). I LOCKED THE CAR (ALARM ARMED) AND LATER RETURNED WITH A TOW-TRUCK. UPON RETURN TO THE CAR, I WAS UNABLE TO UNLOCK IT OR DISARM THE ALARM. CAR WAS UNRESPONSIVE. ALARM WAS ARMED...

WHILE DRIVING, CAR STOPPED ACCELERATING AND URGENT TRANSMISSION REQUIRED LIGHT CAME ON. TOOK IT TO DEALERSHIP TODAY AND WAS TOLD A NEW TRANSMISSION IS NEEDED; TOTAL COST $6800. I KNOW THIS YEAR AND MODEL VEHICLE HAS HAD SEVERAL ISSUES WITH TRANSMISSION. WHEN I CALLED VOLVO, THEY SAID NOTHING COULD BE DONE. *TR

WHILE DRIVING 70 MPH ON I-5 WE HEARD A LOUD THUMP IN THE ENGINE COMPARTMENT AND WE SUDDENLY WENT TO ABOUT 25 MPH ALL OF OUR ELECTRONIC SYSTEMS SHUT DOWN, THERE WAS AN EXTREMELY LOUD GRINDING SOUND FOR APPROX. 2-3 SECONDS. NOW I THINK MY TRANSMISSION IS DAMAGED AND THE ELECTRONICS SYSTEM SHUTS DOWN PRETTY FREQUENTLY. I AM TOTALLY DISAPPOINTED TO READ THAT THIS HAS HAPPENED TO NUMEROUS OTHER FAMILIES. THANK GOD NO ONE HAS DIED FROM THIS.....THIS IS VERY IRRESPONSIBLE AND NEGLIGENT FROM A REPUTABLE AUTO COMPANY. IS IT GOING TO TAKE SOMEONE OR FAMILY TO GET SERIOUSLY INJURED OR DIE BEFORE THEY ACKNOWLEDGE THIS VERY SERIOUS ISSUE. ITS TIME FOR SOMEONE TO BE ACCOUNTABLE FOR THIS. *JS

AFTER SEVERAL HOURS OF DRIVING IN THE GEORGIA / NORTH CAROLINA MOUNTAINS WITH THE WIFE AND 2 KIDS IN THE BACK, THE AIR-CONDITIONER AND RADIO ON WITH THE 2004 XC90, THE CAR STARTED EXPERIENCING WEIRD BEHAVIOR. SHORTLY AFTER CROSSING THE GEORGIA BORDER INTO THE MOUNTAINS OF NORTH CAROLINA THERE WAS A LOUD NOISE UNDER THE HOOD OF THE CAR AND THE VEHICLE JERKED VIOLENTLY. THE CAR IMMEDIATELY LOST ALL ELECTRICAL POWER (NO DASHBOARD, HAZARD LIGHTS, BLINKERS, WINDOWS AND DOOR LOCKS, SUNROOF, ETC.). THE DRIVE TRAIN ALSO SEEMED STUCK IN A HIGH GEAR AND WOULD NOT DOWNSHIFT WHICH MADE NORMAL DRIVING CLOSE TO IMPOSSIBLE ESPECIALLY ON MOUNTAIN ROADS. ABOUT 15 MINUTES LATER, THE CAR MADE THE VIOLENT NOISE AGAIN UNDER THE HOOD AGAIN AND JERKED VIOLENTLY AGAIN. LUCKILY THERE WAS AN AUTOZONE IMMEDIATELY AFTER THE SECOND INCIDENT AND I HAD THEM READ THE ENGINE CODES WHICH WAS ONLY SHOWING A 'DSTC...

AT 65 MPH WIPERS WENT ON BY THEMSELVES THEN FOLLOWED BY SPLIT SECOND POWER FAILURE,MEANING DASHBOARD LIGHT OUT,HAZARD LIGHTS COULD NOT BE TURNED ON,WINDOWS WOULD NOT OPEN,A/C OUT,IN THE MESSAGE SCREEN AT THAT MOMENT ANTILOCK BRAKE FAILURE WAS DISPLAYED BEFORE EVERYTHING WENT OUT,DRIVING ANOTHER 20 MILES TILL NEXT EXIT AT THE DUSK,AFTER PULLING OVER AND RESTART ( TO RESET) SRS FAILURE IN THE MESSAGE SCREEN. CAR CHECKED BY VOLVO DEALER AND STATEMENT FROM THEM:FAULT IN CEM IS SHUTTING DOWN NETWORK AND CAUSING DIM TO BLACK OUT. REPLACEMENT WILL RUN ABOUT $1500,THIS CAR HAD AUTOMATIC TRANSMISSION FAILURE AT 91822 MILES AND IGNITION FAILURE RECENTLY,AND MANY MANY OTHER COSTLY PROBLEMS. *TR

THE TRANSMISSION IS SLIPPING. ENGINE REVS AND THE TRANSMISSION WON'T UPSHIFT...EVENTUAL GEAR CHANGE CAUSE THE VEHICLE TO LURCH FORWARD A BIT, WITH A LOUD THUD HEARD. THE VEHICLE ALSO FAILS TO MOVE OFF FROM A STOP ON OCCASION...WITH THE ENGINE REVVING FOR A WHILE BEFORE MOVING FORWARD. DISPLAY MESSAGE IN THE CLUSTER: "TRANSMISSION SERVICE URGENT"...GOES OFF AND ON FOR DAYS AT A TIME. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE TRANSMISSION FAILED. THE VEHICLE STOPPED ACCELERATING AND THE SPEED DROPPED TO ZERO. THE CONTACT PULLED TO THE SIDE OF THE ROAD TO RESTART THE VEHICLE AND THE VEHICLE ACCELERATED BUT WOULD NOT EXCEED BEYOND SECOND GEAR. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS WHERE THEY INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 130,000.

ADD TO THE VERY LONG LIST ONE MORE XC90 T6 OWNER WITH AN AUTOMATIC TRANSMISSION FAILURE. TRANSMISSION BEGAN SLIPPING WHILE DRIVING. REPAIR ESTIMATE WAS $5800. THIS IS THE GM-SOURCED TRANSMISSION ISSUE THAT VOLVO APPEARS TO BE IGNORING. REST ASSURED I WILL BE PARTICIPATING IN ANY CLASS ACTION SUITS THAT I CAN FIND UNTIL VOLVO ISSUES A RECALL OR MONETARY COMPENSATION. *TR

WE ARE OWNERS OF A 2004 VOLVO XC90 T6 AWD AND HAVE EXPERIENCED A TRANSMISSION FAILURE THAT WILL COST $6500 TO REPLACE. UPON FURTHER INVESTIGATION, WE HAVE FOUND THAT THERE ARE LITERALLY THOUSANDS OF COMPLAINTS REGARDING THESE TRANSMISSIONS FAILING YET VOLVO HAS FAILED TO STEP UP AND ADDRESS THE PROBLEM. IN OUR CASE, MY WIFE WAS DRIVING THE CAR, IN TRAFFIC, WHEN THE CAR SLIPPED OUT OF GEAR AND STARTED SLOWING DOWN! LUCKILY SHE WAS ABLE TO GET OFF ON THE SHOULDER BEFORE TRAILING TRAFFIC CAUGHT UP TO HER, BUT IMAGINE WHAT MAY HAVE HAPPENED IF SHE WASN'T ABLE TO GET OUT OF THE WAY! VOLVO KNOWS THIS IS A PROBLEM AND SHOULD DO SOMETHING SO THAT 1) NO SERIOUS INJURIES COME FROM THIS FAILURE, AND 2) TO COMPENSATE THE VOLVO OWNERS OUT THERE THAT HAVE HAD TO SHELL OUT THOUSANDS OF DOLLARS IN REPAIR COSTS FOR THIS PROBLEM. PLEASE...

THERE APPEARS TO BE A PROBLEM WITH THE XC90 VOLVO TRANSMISSION IN ALL YEARS. THE MESSAGE ERROR CODE GIVEN IS "TRANSMISSION SERVICE REQUIRED". THE DEALERS CLAIMS IT JUST HAS TO UPDATE THE CAR SOFTWARE TO CORRECT THE PROBLEM. HOWEVER, IF YOU CHECK THE INTERNET FOR PROBLEMS REPORTED ON THIS SAME ISSUE, YOU WILL FIND IT IS NOT JUST AN ISOLATED PROBLEM WHICH NEED TO BE INVESTIGATED. *TR

TRANSMISSION FAILED WITH NO WARNING. FLUID IS IN GREAT SHAPE, BAD TRANSMISSION. *TR

IN THE WINTER OF 2011 WHILE DRIVING MY CAR IN HEAVY RUSH HOUR TRAFFIC IN THE CHICAGO AREA THE TRANSMISSION FAILED SUDDENLY AND LOST ALL POWER WHICH WAS VERY DANGEROUS AND CONCERNING. I WAS BARLEY ABLE TO GET TO THE SIDE OF THE ROAD WITHOUT POWER AND WITHOUT ENDANGERING THE OTHER VEHICLES AROUND ME. THE REPAIRS REQUIRED THAT MY TRANSMISSION BE REBUILT, DRIVE TRAIN GEARS REPLACED, AND MY RADIATOR REPLACED WHICH TOOK FOUR WEEKS AND COST $7,000. THE TRANSMISSION FAILED BECAUSE COOLANT FROM THE RADIATOR LEAKED INTO THE TRANSMISSION FLUID. MY VEHICLE WAS MAINTAINED PER THE MANUFACTURES REQUIREMENT INCLUDING A TRANSMISSION FLUID CHANGE LESS THAN A YEAR EARLIER. IT IS OBVIOUS FROM A SIMPLE GOOGLE SEARCH THAT THIS IS A COMMON PROBLEM DUE TO DEFECTIVE PARTS AND MANUFACTURING. EVEN MORE OBVIOUS BECAUSE VOLVO WILL ONLY WARRANTY A REPLACEMENT TRANSMISSION IF THE RADIATOR AND OTHER TRANSMISSION PARTS ARE REPLACED. I ALSO...

I PURCHASED THIS VEHICLE THINKING IT WOULD BE A LIFE LONG VEHICLE CONSIDERING I HAD ALREADY PURCHASED A RELIABLE VOLVO CAR IN THE PAST, THE URGENT SERVICE TRANSMISSION APPEARED AND I TOOK IT TO A LOCAL TRANSMISSION SHOP (BEING THAT THERE IS NO LOCAL DEALERSHIP) AS SOON AS THE MESSAGE APPEARED THE TRANSMISSION STARTED TO SKIP CONSTANTLY CAUSING A HAZARD, AND THEN CONFIRMED THAT THE TRANSMISSION NEEDS TO BE REPLACED. I HAVE DONE EXTENSIVE RESEARCH ON THE INTERNET AND I CAME TO FIND THAT MANY OF YOUR XC90 TRANSMISSIONS FAIL AND I WOULD LIKE TO KNOW HOW VOLVO NORTH AMERICA STANDS BEHIND THEIR VEHICLES IN THESE SITUATIONS. I WOULD LIKE TO CONTINUE BEING A VOLVO OWNER BUT BEING THAT I WILL BE FORCED TO SPEND THOUSANDS ON A DEFECT FROM VOLVO IT WILL MAKE ME THINK TWICE. I HOPE SOMEBODY CAN HELP ME WITH THIS. *TR

MY RECENTLY BOUGHT 2004 VOLVO XC90 T6 TRANSMISSION FAILED WHILE I WAS DRIVING ON A MAJOR HIGHWAY DURING RUSH HOUR. IT TOOK THE ENTIRE LENGTH OF THE LIGHT TO CROSS THE INTERSECTION AND SEVERAL NEAR-MISSES BY OTHER CARS. VOLVO REFUSES ANY RESPONSIBILITY FOR THE FAULTY TRANSMISSION AND AFTER FURTHER RESEARCH, I FOUND THAT THE TRANSMISSION WAS REPLACED AT 50,093 MILES IN 2008 WHILE UNDER WARRANTY BY A PREVIOUS OWNER. *TR

TRANSMISSION FAILURE, LOSS OF POWER AND POWER STEERING. UPDATED 07/28/11*BF

MOVING ABOUT 70MPH IN CRUISE WE FELT A SEVERE JERK FOLLOWED BY NEAR INSTANTANEOUS HARD ACCELERATION. THE JERK/THUD ACTION SO EXTREME IT WAS ALMOST LIKE THE VOLVO TRIED TO REVERSE GEAR BY ITSELF. IT'S STRANGE HOW AN 'EVENT' CAN CONJURE UP COMMON THOUGHTS. AFTER THE UNCONTROLLED HARD ACCELERATION, I HAD THOUGHTS OF THAT STATE PATROL OFFICER DRIVING THE LEXUS IN CALIFORNIA WHO WAS KILLED ALONG WITH HIS FAMILY WHEN HE COULDN'T CONTROL THE BIZARRE BEHAVIOR OF THE CAR. TURNS OUT IT WAS THE SAME THOUGHTS MY BROTHER HAD. 'AS WE PULLED OVER AND CALL FOR HELP OUR VOLVO DID SOMETHING BIZARRE AGAIN. WE THOUGHT THE REAR WHEEL GOING BACKWARD AT THIS TIME, ALMOST AT THE SAME TIME MOST ALL THE POWER IN THE VOLVO WENT DEAD. O GAUGES INCL. SPEEDOMETER, THE TACK, THE GAS, THE BATTERY, ALL OUT. OTHE WINDOWS STUCK IN THE UP POSITION. ONO TAILLIGHTS, NO BRAKE LIGHTS,...

2004 VOLVO XC 90 T6 TRANSMISSION. PURCHASED THIS VEHICLE NEW FROM DEALER. @ 35,000 THE TRANSMISSION FAILED. PRIOR TO THE FAILURE TRANSMISSION BEGAN TO SLIP AND THE VEHICLE WAS NON RESPONSIVE. DUE TO THE DELAY OF THE TRANSMISSION CATCHING AND PROPELLING THE VEHICLE FORWARD WE WERE IN A NEAR COLLISION WITH ANOTHER VEHICLE. UNIT WAS REPLACED WITH A REFURBISHED ONE FROM THE DEALER. @ 85,000 THE VEHICLE BEGAN TO SHOW SYMPTOMS OF TRANSMISSION FAILURE AGAIN. THIS TIME IT WAS CORRECTED WITH A SOFTWARE UPDATE. NOW VEHICLE HAS 125,000 MILES AND TRANSMISSION FAILURE AGAIN. VEHICLE SHOWED NO SIGNS OF TRANSMISSION WEAR AND TEAR. JUST ALL OF THE SUDDEN VEHICLE CAME NON RESPONSIVE TO DRIVERS GAS INPUTS. THIS COULD BE A HUGE HAZARD IN HIGH TRAFFIC CONDITIONS AND POTENTIALLY RESULTING IN SERIOUS INJURIES AND EVEN DEATH. VOLVO REFUSES TO RECALL THIS UNITS. THEY ONLY OFFERED TO COVER 50% OF THE COST TO...

A RUBBING NOISE BEGAN IN LATE SEPTEMBER. I HAD AN INSPECTION AND DIAGNOSTIC AT THE DEALERSHIP ON SEPTEMBER 23RD. THEY TOLD ME THE FRONT BEARINGS AND THE LOWER ENGINE MOUNT PAD SHOULD BE REPLACED. THE NEXT DAY, WHILE I WAS DRIVING, THE TRANSMISSION SEIZED. THE CAR WAS TOWED AND THE DEALERSHIP SAID THEY HAD TO REPLACE THE TRANSMISSION AND ENTIRE COOLANT SYSTEM. THEIR DIAGNOSTIC SPECIALIST WAS UNABLE TO DETECT SUCH A CATASTROPHIC FAILURE THE DAY BEFORE IT HAPPENED. WHO KNOWS WHAT WOULD HAVE HAPPENED IF I WAS ON THE HIGHWAY. VOLVO ACKNOWLEDGED THE PROBLEM BUT ONLY PAID FOR HALF OF THE PARTS AND LABOR. I STILL HAD TO COME OUT OF POCKET $3000+.

WE JUST PURCHASED A 2004 VOLVO XC90 T6 ON JUNE 2, 2010 FROM A PRIVATE SELLER WHO ORIGINALLY PURCHASED THE VEHICLE AND HAVE IT MAINTAINED FULLY AT RICKENBAUGH VOLVO IN DENVER. WE ARE FIRST TIME OWNERS OF A VOLVO VEHICLE. THE CAR CURRENTLY HAS 76,783 MILES ON IT. AFTER JUST OWNING THE VEHICLE FOR 4 WEEKS AND ADDING JUST 400 MILES ON THE VEHICLE, THE CHECK ENGINE LIGHT WENT ON AND WHILE DRIVING TO THE RICKENBAUGH VOLVO SERVICE STATION, A MESSAGE CAME UP WITH 'URGENT TRANSMISSION SERVICE REQUIRED'. WE WERE TOLD BY THE SERVICE MANAGER THAT THE CAR NEEDS NEW TRANSMISSION WITH RADIATOR, OIL COOLER AND OIL COOLER LINES IN THE AMOUNT OF $7,800.00. MY WIFE AND I WERE SHOCKED AND DECIDED TO TAKE THE VEHICLE HOME BECAUSE WE CANNOT AFFORD THIS EXPENSE AFTER JUST SAVING MONEY FOR A YEAR TO PURCHASE THE VEHICLE 4 WEEKS AGO. THE VEHICLE WAS...

TL*THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT HE EXPERIENCED TONS OF FAILURES WITH THE VEHICLE. THE RACK AND PINION WAS REPLACED AT 52,000 MILES. THE STRUTS FAILED ON THE REAR OF THE VEHICLE AND THE DEALER HAD TO REPAIR THE U JOINT. WHILE DRIVING 60 MPH, THE VEHICLE WOULD NOT SHIFT GEARS AND THE DEALER STATED THAT A NEW TRANSMISSION WAS NEEDED. LATER, THE CONTACT DISCOVERED HUNDREDS OF COMPLAINTS IN REGARDS TO THE SAME YEAR, MAKE, AND MODEL VEHICLE. THE SEALS FOR THE POWER TRANSFER UNIT FAILED. RECENTLY, THE ENTIRE THERMOSTAT UNIT HAD TO BE REPLACED AND THE TRANSMISSION FAILED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 76,500.

GRINDING NOISE IN DRIVE TRAIN RF WHEEL BEARING SEIZED , REPLACED FOR 257.50 LABOR CHARGE. VEHICLE IS MAKING NOISE AGAIN NOW. *TR