2004 VOLVO XC90 Engine And Engine Coolingengine Problems

EARLY CATASTROPHIC ENGINE FAILURE. WE BOUGHT THIS CAR NEW IN 2004. LAST YEAR, AT APPROX 35,000 MILES, WE HAD TO REPLACE THE HEAD GASKET ($5000). TODAY I WAS TOLD BY OUR VOLVO SERVICE CENTER THAT THE ENGINE WAS BLOWN AND WE NEEDED A NEW ONE. ($12,500) THIS CAR HAS ALWAYS BEEN GENTLY DRIVEN, HAS EXTREMELY LOW MILEAGE YET HAS DEMONSTRATED THAT IT'S ENGINE IS A LEMON. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 60 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE BRAKE AND AIR BAG WARNING LIGHTS. THE CONTACT WAS ABLE TO RESTART THE VEHICLE WITHIN FIVE MINUTES AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS AWAITING THE RESULTS OF THE DIAGNOSTIC TEST. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 115,000.

TRANSMISSION FAILURE TWICE AND FUEL PUMP REPLACED AND STILL LEAKING IN OUR VOLVO XC90 2004 T6 TRUCK. VOLVO REPLACED THE TRANSMISSION TWICE, BUT WE STILL HAD REPAIR COSTS BOTH TIMES. FUEL PUMP REPLACED AND STILL LEAKING CAUSING LARGE AMOUNTS OF GAS FUMES IN VEHICLE. TAKING INTO VOLVO TO FIX FUEL PUMP AGAIN TODAY THAT IS COVERED UNDER THE RECALL BUT JUST GOT IT BACK FROM 2ND TRANSMISSION REPAIR WHERE I HAD TO PAY FOR THE INTERNAL ENGINE LEAKS THAT COULD NOT BE DETECTED THAT IN TURN CONTAMINATED THE 2ND TRANSMISSION. I DO NOT BELIEVE I SHOULD HAVE PAID $1600 IN REPAIRS WHEN IT HAS BEEN SERVICED AND CANNOT DETECT THESE INTERNAL OIL LEAKS FROM THE ENGINE. THIS MAKE AND MODEL YEAR HAS BEEN COSTLY AND DANGEROUS. TRUCK HAS STOPPED IN THE MIDDLE OF LEFT TURN, ALMOST RESULTING IN HEAD ON COLLISION. THIS TRUCK SEEMS TO FALL UNDER LEMON LAW. WE...

ENGINE FAILURE. SYMPTOMS STARTED WITH STARTING DIFFICULTY. REPLACEMENT OF RPM AND CAM SENSORS FOLLOWED. SYMPTOMS CONTINUED WITH TROUBLE SHOOTING LEADING TO DISCOVERY OF DAMAGE TO FLYWHEEL AND BELL HOUSING. CRANKSHAFT OUT OF SPEC FOR FRONT TO BACK MOVEMENT. DEALER RECOMMENDATION TO REPLACE ENGINE. DEALER BELIEVES MOST LIKELY CAUSE RELATED TO THRUST BEARING FAILURE. ENGINE AND CAR ALWAYS MAINTAINED TO MANUFACTURER'S RECOMMENDED SCHEDULES. CAR IS OUT OF WARRANTY. ALTHOUGH NO CLAIM OF OWNER FAILURE, VOLVO REFUSES TO STAND BEHIND PRODUCT OR ASSIST IN ANY WAY WITH MAJOR PRODUCT FAILURE. *TR

TRANSMISSION FAILURE ON OUR 2004 VOLVO XC-90 T6 AWD AT APPROXIMATELY 56,000K MILES. FORTUNATELY IT WAS A WARRANTY REPAIR; HOWEVER MY RESEARCH ON AUTOMOTIVE DISCUSSION BOARDS LIKE EDUMDS INDICATES A VERY LARGE PATTERN OF FAILURE OF THE TRANSMISSION ON THIS MODEL. *TR

THANK YOU LETTER REGARDING VOLVO'S RESPONSE TO CONSUMER PROBLEM.***NO ANSWER REQUIRED***. *MR THE VEHICLE'S ENGINE FAILED AT ONLY 10500 MILES DUE TO SLUDGE IN THE ENGINE. THE MANUFACTURER CLAIMED THAT THE VEHICLE WAS IMPROPERLY MAINTAINED ALTHOUGH THE CONSUMER PROVIDED THEM WITH SERVICE RECEIPTS. *NM