2004 VOLVO XC90 Engine And Engine Cooling Problems

WHILE DRIVING ON THE HIGHWAY WITH MY TWO SMALL CHILDREN, THE CAR MADE A KNOCKING NOISE AND DRIVER CONSOLE/DASH STOPPED WORKING. THE LIGHTS WENT OUT, AND ALL GAUGES WENT TO "ZERO." I NO LONGER HAD TURN SIGNALS EITHER. I FEARED FOR OUR LIVES. I HAVE DONE RESEARCH, AND HAVE FOUND THAT OTHERS HAVE THIS SAME ISSUE WITH 2004 XC90S. *TR

2004 VOLVO XC-90. CONSUMER STATES PROBLEM WITH CRANKCASE VENT *TGW THE CONSUMER RECEIVED A SECOND A OPINION AND WAS INFORMED THE THROTTLE BODY NEEDED TO BE CLEANED.

THERE APPEARS TO BE A PROBLEM WITH THE XC90 VOLVO TRANSMISSION IN ALL YEARS. THE MESSAGE ERROR CODE GIVEN IS "TRANSMISSION SERVICE REQUIRED". THE DEALERS CLAIMS IT JUST HAS TO UPDATE THE CAR SOFTWARE TO CORRECT THE PROBLEM. HOWEVER, IF YOU CHECK THE INTERNET FOR PROBLEMS REPORTED ON THIS SAME ISSUE, YOU WILL FIND IT IS NOT JUST AN ISOLATED PROBLEM WHICH NEED TO BE INVESTIGATED. *TR

WHILE DRIVING ON THE HIGHWAY AT NIGHT, ALL ELECTRICAL INDICATORS ON DASHBOARD INCLUDING THE TURN SIGNALS STOP WORKING THEN THE VEHICLE STARTED SLOWING DOWN. AFTER STOPPING I WAS UNABLE TO OPEN GAS TANK AND TAILGATE WHERE THE BATTERY IS LOCATED. I TOOK THE VEHICLE TO THE VOLVO DEALER AND THEY WERE UNABLE TO DUPLICATE THE INCIDENT. NOW THIS HAS HAPPEN 7 MORE TIMES. I AM A SINGLE PARENT WITH MINOR CHILDREN IN MY VEHICLE. PLEASE ASSIST. SOMEONE INFORM ME THE PROBLEM MIGHT BE WITH THE CENTRAL ELECTRICAL MODULE. I PURCHASE THIS VEHICLE USED AND IT IS OUT OF WARRANTY. I HAVE SEEN LOTS OF COMPLAINTS ABOUT THIS VEHICLE WHY IS THERE NOT A RECALL ON THE CENTRAL ELECTRICAL MODULE? PLEASE DO SOMETHING BEFORE THERE ARE FATALITIES. *TR

SIX OCCURRENCES STARTING WHEN VEHICLE (PURCHASED NEW) WAS APPROX "7 YEARS OLD AT MILEAGE 70K": WHILE DRIVING, ENGINE DIES WITHOUT WARNING. HAS BEEN CHECKED BY DEALER 3 TIMES, HAD IGNITION ASSEMBLY AND COLUMN REPLACED AFTER 2ND OR 3RD EPISODE AND PROBLEM STILL OCCURS. DEALER STATES COMPUTER CHECK DID NOT REVEAL ANY CODE TO DIAGNOSE THE PROBLEM. WHEN THE ENGINE DIES, LOSE POWER STEERING AND BRAKES, HAVE TO GLIDE TO EDGE OF STREET, PUT HAZARD BLINKERS ON, ONCE HAD TO JOLT THE CAR INTO PARK TO STOP IT. CAR RESTARTS VERY SHORTLY AFTER POWER WAS LOST. SO FAR HAPPENS AT "NEIGHBORHOOD" SPEEDS <=35 MPH. *TR

WHILE DRIVING THE ELECTRONICS SHUT OFF AND THE ENGINE DIES AS IF ITS IN NEUTRAL. TOOK TO VOLVO SERVICE AND THEY SAID A CAN SOFTWARE UPGRADE WOULD SOLVE IT, THIS DID NOT SOLVE IT, IMMEDIATELY AFTER WE LEFT THE SAME THING HAPPENED WITHIN A FEW MILES, ENGINE SHUT DOWN, POWER WENT OUT, WHEN RESTARTED THE SRS AIRBAG ERROR CODE CAME ON AS WELL AS THE ABS BREAK FAILURE MESSAGE. I SEE YOU GUYS HAVE COMPLETED AN INVESTIGATION (PE10025) ON THIS BUT WHAT THE HECK IS BEING DONE ABOUT IT. THIS CAR IS VERY DANGEROUS TO MY WIFE AND NEWBORN!!!! THE CAR GOES FROM 70 TO 10MPH ON THE FREEWAY, HOW IS THIS NOT AS IMPORTANT AS THE ISSUE WITH TOYOTAS EXCESSIVE ACCELERATION PROBLEM, DOES SOMEONE NEED TO DIE BEFORE YOU GUYS TAKE THIS SERIOUS! *TR

I WAS DRIVING ON THE FREEWAY AND THERE WAS A SLIGHT THUMPING NOISE AND THE ELECTRICAL SYSTEMS FAILED AND SHUTDOWN IN A SECOND. THE POWER WAS LOST AND THE VEHICLE CAME TO A SUDDEN HALT. LUCKILY I WAS ON THE RIGHT SIDE OF THE ROAD AND I HAD PULLED OVER TO THE SIDE OF THE ROAD. IT WAS VERY SCARY, AS I WAS ON THE FREEWAY IN THE NIGHT AND I COULD HAVE VERY WELL BEEN IN AN ACCIDENT CAUSING DAMAGE TO MY LIFE AND OTHERS. THE ELECTRICAL FAILURE CAUSED THE CAR TO LOOSE COMPLETE CONTROL OF THE SPEED AND THE CAR CAME TO AN IMMEDIATE HALT. THERE WAS A MESSAGE OF BREAK FAILURE FOR A SECOND BEFORE THE CAR SHUT DOWN COMPLETELY. REQUEST YOU TO PLEASE LOOK INTO THIS CONCERN AS IT IS A POTENTIAL SAFETY HAZARD. I HAVE RESEARCHED OVER THE INTERNET AND I READ THAT MOST OF...

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING APPROXIMATELY 50 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD, THE VEHICLE WAS TURNED OFF. UPON RESTARTING THE VEHICLE, THE CONTACT RESUMED OPERATION CAUTIOUSLY. THE VEHICLE WAS TAKEN AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE DEALER REGARDING THE CAUSE OF THE FAILURE. THE MALFUNCTION OCCURRED AFTER DRIVING FOR AT LEAST ONE HOUR AT HIGHWAY SPEEDS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT AND A COMPLAINT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNAVAILABLE.

A RUBBING NOISE BEGAN IN LATE SEPTEMBER. I HAD AN INSPECTION AND DIAGNOSTIC AT THE DEALERSHIP ON SEPTEMBER 23RD. THEY TOLD ME THE FRONT BEARINGS AND THE LOWER ENGINE MOUNT PAD SHOULD BE REPLACED. THE NEXT DAY, WHILE I WAS DRIVING, THE TRANSMISSION SEIZED. THE CAR WAS TOWED AND THE DEALERSHIP SAID THEY HAD TO REPLACE THE TRANSMISSION AND ENTIRE COOLANT SYSTEM. THEIR DIAGNOSTIC SPECIALIST WAS UNABLE TO DETECT SUCH A CATASTROPHIC FAILURE THE DAY BEFORE IT HAPPENED. WHO KNOWS WHAT WOULD HAVE HAPPENED IF I WAS ON THE HIGHWAY. VOLVO ACKNOWLEDGED THE PROBLEM BUT ONLY PAID FOR HALF OF THE PARTS AND LABOR. I STILL HAD TO COME OUT OF POCKET $3000+.

AT 65MPH ON A HIGHWAY, THE VEHICLE REGISTERED A "ANTI-SKID SERVICE REQUIRED" FAULT MESSAGE, THEN AN "ELECTRICAL SERVICE REQUIRED" MESSAGE. THE ENGINE THEN QUIT RUNNING, THE STEERING BECAME UNRESPONSIVE AND THE VEHICLE IMMEDIATELY STARTED DECELERATING. THE BRAKING WAS VERY MUSHY AND THE CAR WAS DIFFICULT TO PULL OVER AND STOP. THE CAR WOULD NOT START. ALL THE LIGHTS AND THE BATTERY SEEM TO BE WORKING FINE. THE DEALERSHIP DETERMINED THE CEM (ENGINE CONTROL MODULE) WAS DEFECTIVE AND NEEDS REPLACEMENT.

WE JUST PURCHASED A 2004 VOLVO XC90 T6 ON JUNE 2, 2010 FROM A PRIVATE SELLER WHO ORIGINALLY PURCHASED THE VEHICLE AND HAVE IT MAINTAINED FULLY AT RICKENBAUGH VOLVO IN DENVER. WE ARE FIRST TIME OWNERS OF A VOLVO VEHICLE. THE CAR CURRENTLY HAS 76,783 MILES ON IT. AFTER JUST OWNING THE VEHICLE FOR 4 WEEKS AND ADDING JUST 400 MILES ON THE VEHICLE, THE CHECK ENGINE LIGHT WENT ON AND WHILE DRIVING TO THE RICKENBAUGH VOLVO SERVICE STATION, A MESSAGE CAME UP WITH 'URGENT TRANSMISSION SERVICE REQUIRED'. WE WERE TOLD BY THE SERVICE MANAGER THAT THE CAR NEEDS NEW TRANSMISSION WITH RADIATOR, OIL COOLER AND OIL COOLER LINES IN THE AMOUNT OF $7,800.00. MY WIFE AND I WERE SHOCKED AND DECIDED TO TAKE THE VEHICLE HOME BECAUSE WE CANNOT AFFORD THIS EXPENSE AFTER JUST SAVING MONEY FOR A YEAR TO PURCHASE THE VEHICLE 4 WEEKS AGO. THE VEHICLE WAS...

TRANSMISSION REPLACEMENT ON 2004 VOLVO XC90 WITH 41,000 MILES. *TR