2017 FORD EXPLORER Engine Problems

WHEN GEAR IS ENGAGED IN 'D' WITH ENGINE ON, VEHICLE MOVES WITHOUT FOOT ON THROTTLE. WHEN BRAKE IS APPLIED TO STOP IT, THERE COMES A LOUD VIBRATION FROM THE ENGINE WHICH BECOMES NERVOUS AND TRIES TO DRAG VEHICLE FORWARD UNLESS GEAR IS PUT IN 'N' OR 'P'. IT HAPPENS ANYTIME VEHICLE IS STATIONARY WITH ENGINE RUNNING INCLUDING STOP SIGNS AND TRAFFIC LIGHTS. NO CHECK LIGHT ON DASHBOARD. PHENOMENON OBSERVED IN EARLY FEBRUARY 2019.

2017 FORD EXPLORER SPORT. CONSUMER WRITES IN REGARDS TO CARBON MONOXIDE LEAK ISSUE. *LD *TR

EXHAUST STILL ENTERING CABIN FOLLOWING FORD CORRECTIVE MEASURES. THIS VEHICLE HAS BEEN SERVICED FOR THIS SEEMINGLY ONGOING ISSUE USING THE CORRECTIVE MEASURES SPECIFIED ON THE MOST RECENT TECHNICAL SERVICE BULLETIN (17NO3); HOWEVER, THE CARCINOGENS AND CARBON MONOXIDE PRODUCED BY THE EXHAUST ARE STILL ENTERING THE CABIN FOLLOWING ACCELERATION. AS WITH OTHER SERIOUS COMPLAINTS INVOLVING THIS VEHICLE, THE ODOR IS A DELAYED RESPONSE TO ACCELERATION, BUT VERY EVIDENT. AS NHTSA IS THE CONSUMER'S AVENUE FOR ASSISTANCE IN PROTECTING THEIR HEALTH AND SAFETY, THIS ONGOING OPEN INVESTIGATION SHOULD RESULT IN CREATING PROVISIONS THAT DEMAND THIS COMPANY TAKE ETHICAL MEASURES IN PREVENTING TOXIC SUBSTANCES FROM ENTERING THEIR VEHICLES. THE OPEN NHTSA INVESTIGATION HAS ALREADY CONCLUDED, "FORD HAS ISSUED MULTIPLE TSBS RELATED TO THE EXHAUST ODOR ISSUE, AND IN SOME CASES REVISED THOSE DOCUMENTS MULTIPLE TIMES...". IF THE MANUFACTURER IS CONTINUOUSLY GENERATING NEW TECHNICAL BULLETINS, BUT COMPLAINTS ARE STILL BEING RAISED WITH MODELS AS...

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT AND PASSENGER EXPERIENCED DIZZINESS, HEADACHES, AND FELT AS IF THEY WOULD LOSE CONSCIOUSNESS. MEDICAL ATTENTION WAS NOT RECEIVED. THE VEHICLE WAS TAKEN TO CIOCCA FORD OF QUAKERTOWN (321 S WEST END BLVD, QUAKERTOWN, PA 18951, (215) 536-8600) WHERE IT WAS DIAGNOSED THAT THERE WAS A CARBON MONOXIDE LEAK. THE VENTILATION SYSTEM AND MUFFLER WERE REPLACED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000.

ENGINE OIL LEAKING BETWEEN OIL FILTER AND FILTER ADAPTER ASSY. THE VEHICLE WAS TAKEN TO OC WELCH FORD ON DEC. 28TH 2018 FOR REPAIR FOR FIRST TIME. THE FILTER THEN BEGAN TO SLOW LEAK OIL AND THE VEHICLE AGAIN WAS TAKEN TO OC WELCH FORD ON JAN.18TH 2019. THE PROBLEM APPEARS TO BE THE ADAPTER ASSY HAS EITHER A HAIRLINE CRACK OR WAS MACHINED OUT OF SPECS. OC WELCH FORD ORDERED THE ADAPTER ASSY. CURRENTLY PENDING NOTIFICATION FROM THE DEALER WHEN REPAIR IS COMPLETE.

OIL LEAK AROUND TURBO AT EXHAUST. COULD BE RELATED TO THE NHTSA VEHICLE SAFETY RECALL # 16V925000 AS THE VEHICLE HAS THE SAME 3.5L GTDI ENGINE AND SEEMS TO HAVE BEEN MANUFACTURED DURING THE TIME FRAME OF THE 2017 FORD EXPLORER POLICE INTERCEPTOR VEHICLES EFFECTED.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE THE VEHICLE WAS BEING DRIVEN, THERE WAS AN INTENSE ODOR OF FUMES INSIDE THE VEHICLE. THE CONTACT STATED THAT THE WINDOWS HAD TO BE ROLLED DOWN IN ORDER TO DRIVE THE VEHICLE. THE VEHICLE WAS TAKEN TO PUENTE HILLS FORD (17340 GALES AVENUE, CITY OF INDUSTRY, CA 91748) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

I WAS TRAVELING ON A HIGHWAY IN THE RIGHT LANE AT 55 MPH, WITH TRACTOR TRAILERS TO MY LEFT AND BEHIND ME. I CHANGED THE RADIO STATION AND A WARNING SUDDENLY APPEARED ON THE DASHBOARD STATING "TRANSMISSION NOT IN PARK". I FELT THE CAR BECOMING SLUGGISH AND I LOST POWER STEERING AND POWER BRAKES. I WAS ABLE TO PULL OFF THE ROAD, BUT HAD NO TURN SIGNAL TO WARN THE TRUCK BEHIND ME. HE NARROWLY MISSED ME AS I PULLED OFF. WHEN I CAME TO A STOP I REALIZED THE CAR WAS TURNED OFF, AS IF I HAD HIT THE IGNITION SWITCH. I PUT THE CAR IN PARK AND SWITCHED ON THE IGNITION. I COULD NOT BELIEVE I HAD INADVERTENTLY TURNED THE CAR OFF, BUT ASSUMED I MUST HAVE, WHILE CHANGING THE RADIO. YESTERDAY, JAN 32, 2018, MY VEHICLE LOST A SERPENTINE BELT AND I LOST POWER. THE TOW TRUCK...

EXHAUST FUMES LEAKING IN TO THE CAB OF THE SUV. CAUSES A ROTTEN EGG SMELL, AND HAS LEFT MY SON AND I NAUSEOUS MANY TIMES.

TOOK EXPLORER TO THE DEALERSHIP. FOR THE ROTTEN EGGS SMELL FOR THE SECOND TIME AS WELL AS ANOTHER ISSUE. THEY DID NOT ADDRESS THE EXHAUST SMELL AND WHEN QUESTION A SECOND TIME THEY STATED IT WAS DRIVEN AND THE COULD NOT SMELL IT. I WAS TOLD TO DRIVE THE EXPLORER UNTIL IT GOT WORSE AND THEN BRING IT BACK IN. THIS IS UNACCEPTABLE. FORD IS KNOWINGLY ALLOWING DEALERSHIPS TO PLACE DEFECTIVE EXPLORERS BACK ON THE STREET. PEOPLE ARE GETTING HURT WITH THIS EXHAUST PROBLEM. SOMETHING NEEDS TO BE DONE SINCE I NEED TO DRIVE IT UNTIL IT GETS WORSE, OR PASS-OUT AND WRECK THE EXPLORER

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE THE ENGINE WAS IDLING, THE ODOR OF FUEL WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. LATER, WHILE DRIVING, THE CONTACT BEGAN TO FEEL ILL WITH SYMPTOMS THAT INCLUDED BECOMING DISORIENTED, DROWSINESS, NAUSEA, AND FINGER NUMBNESS. MEDICAL ATTENTION WAS NOT RECEIVED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (PACKYWEBB FORD, 1815 OGDEN AVE, DOWNERS GROVE, IL), BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE CONTACT INDICATED THAT THE VEHICLE WAS SERVICED IN FEBRUARY OF 2018 PER AN UNKNOWN MANUFACTURER SERVICE CAMPAIGN RELATED TO CARBON MONOXIDE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,000.

2017 FORD EXPLORER SPORT AWD HAD THE COURTESY SERVICE FOR THE EXHAUST BULLETIN DONE. I DON'T KNOW WHAT THEY FIXED BECAUSE THE CAR STILL SMELLS OF EXHAUST WHEN I ACCELERATE HARD. TRYING TO MERGE ONTO THE HIGHWAY ON RAMPS COMES TO MIND. OR IF ACCELERATE HARD FROM A STOP LIGHT IN THE CITY. PRETTY MUCH HAVE TO LOWER THE WINDOWS. DEALERS ARE USELESS THEY JUST CLAIM THE VEHICLES ARE SAFE. HAVE HAD THIS ISSUE SINCE PURCHASED NEW.

CARBON MONOXIDE LEAK INTO VEHICLE. CAR HAS FOUL ODOR THAT PERMEATES THROUGH THE CAR WHEN DRIVING. ESPECIALLY WHEN ACCELERATING TO HIGHWAY SPEEDS. SEEMS TO BE ONLY WHEN THE A/C IS IN RECIRCULATION MODE

AS I WAS REVERSING I PLACED THE VEHICLE FROM REVERSE TO DRIVE AND IT BECAME VERY HARD TO TURN THE STEERING WHEEL. ON SEVERAL DIFFERENT OCASSIONS THE EXHAUST HAS BLOWN SMOKE AND THE VEHICLE SMELLS LIKE FUMES AFTER TURNING IT ON.

EXHAUST FUMES IN CABIN WHEN IN MOTION

TAKEN BACK TO DEALER FOR ROTTEN EGG SMELL THIS WILL BE THE SECOND TIME AFTER ALL THEY DID WAS INSPECT PER THE TECH BULLETIN AND REPROGRAMMED AC UNIT,(STILL HAVE SMELL WHILE UNDER MEDIUM ACCELERATION ) ALSO WHISTLING COMING FROM INTAKE SIDE OF MOTOR.

OUR FIRST ROAD TRIP IN THIS VEHICLE WAS NOVEMBER 23, 2017. WE DROVE ABOUT 300 MILES SOUTH TO GALVESTON, TX. ON THE WAY BACK HOME, I WAS DRIVING , WHEN WE GOT TO ABOUT HOUSTON, I TOLD MY HUSBAND I NEEDED TO PULL OVER AND LET HIM DRIVE, AS I DIDN'T FEEL GOOD AND FELT LIKE I WAS GOING TO PASS OUT. HE DROVE THE REST OF THE WAY BACK HOME. I WAS THINKING MAYBE I WAS GETTING SICK OR COMING DOWN WITH SOME KIND OF BUG. I JUST FELT ALWAYS DIZZY AND LIGHT HEADED. I STARTED TO GET A STRANGE FEELING MY HEAD, A STRANGE TIGHTNESS'I THEN GOT CONCERNED. I WENT TO MY DOCTOR ON DECEMBER 27 TO FIND OUT WHAT HE THOUGHT IT MAY BE. I JUST FELT SO WEIRD AND FUNNY. I CONTINUE TO GO THROUGHOUT JANUARY AND MY DOCTOR TELLING ME I NEEDED TO GET A...

VEHICLE STALLS WHEN DRIVING AND IS MORE PRONOUNCED WHEN MAKING TURNS. AFTER STALLING IT STARTS BUCKING AND I HAVE TO PRESS GAS PEDAL TO THE FLOOR TO GET A RESPONSE.

FORD EXPLORER EXHAUST---- WE CONTINUE TO HAVE NAUSEA, DIZZINESS,HEADACHES AND AT TIMES EXTREME SLEEPINESS. A FEW MONTHS AGO FORD SENT US A SAFETY NOTICE, STATING THEY WOULD REPROGRAM THE AIR CONDITIONER. THEY STATED THIS WOULD FIX EXHAUST GASES ENTERING THE VEHICLE. THIS RE-PROGRAMING HAS NOT FIXED THE PROBLEM. WE CONTINUE TO HAVE EXHAUST SMELLS IN THE VEHICLE, ESPECIALLY ON ACCELERATION. WE CONTINUE TO HAVE NAUSEA, DIZZINESS, HEADACHES, SLEEPINESS, AND SOMETIMES PERIODS OF CONFUSION.

FAMILY HAS BEEN HAVING NEUROLOGICAL SYMPTOMS AFTER SMELLING SEVERE EXHAUST IN THE CAB OF OUR VEHICLE.

MY EXPLORER SPORT WITH TURBO HAS A RECURRING OIL LEAK THAT THE DEALERSHIP HAS ATTEMPTED TO REPAIR A FEW TIMES. I CAN SMELL OIL BURNING WITHIN MINUTES OF DRIVING THE VEHICLE AND THERE ARE OIL STAINS ON OUR GARAGE FLOOR. MY CONCERN IS THAT OIL MAY BE LEAKING ONTO HOT ENGINE COMPONENTS CREATING A FIRE HAZARD. THE DEALERSHIP HAS HAD THE VEHICLE FOR OVER 2 WEEKS CUMULATIVELY AND I BELIEVE THIS IS PART OF A BIGGER PROBLEM. THE GM TOLD ME TODAY THAT HE BELIEVES THIS IS A FREAK OCCURRENCE, BUT IN SPEAKING WITH A FRIEND OF MINE WHOSE HUSBAND IS A MECHANIC ON FORDS, HE SAID THE FORD KNOWS THIS IS AN ISSUE, BUT HASN'T ISSUED A RECALL FOR THIS MODEL, YET. I'M NOT SURE WHAT TO DO AT THIS POINT. I JUST KNOW THAT I'M PAYING FOR A VEHICLE THAT I CAN'T DRIVE AND THE DEALERSHIP DOESN'T KNOW...

RECALL ON CARBON MONOXIDE ON 2017 FORD EXPLORER. FORD SERVICE DO NOT TAKE THIS SERIOUSLY WHEN I'M HAVING HEADACHES, DIZZY, VISION BLURRY AND EAR RINGING. WE DID THE CARBON MONOXIDE FORENSICS WITH THE CAR CO DETECTOR AND THE ALARM WENT OFF TRIGGERS WHICH THE NUMBER IS 11!!! WE DID THE VIDEO ON IT AND TRYING TO SHOW PROOF BECAUSE FORD MANAGER AT THE SERVICE DOESN'T BELIEVE ME AT ALL!!! WE TOOK OUR 2017 FORD EXPLORER TO SERVICE 5X THIS MONTH OF JUNE! FORD SERVICES AT JUNE 1ST, JUNE 7TH,JUNE 11TH, JUNE 15TH AND JUNE 16TH AND GOING TO BRING IT BACK AGAIN WITH PROOF OF THE VIDEO THAT OUR SUV DO HAVE CARBON MONOXIDES SMELL! PLEASE HELP AND I CANNOT KEEP DRIVING THIS WITH THE CARBON MONOXIDE SMELL WHICH I AM USING THIS CAR FOR WORK PURPOSE. THE CARBON MONOXIDE SMELL START WHEN I'M OVER 45 MPG ON BUSY MAIN...

I HAVE A 2017 FORD EXPLORER PLATINUM WHICH I PURCHASED BRAND NEW ON NOVEMBER 25, 2016. IT TOOK ME A WHILE TO REALIZE BUT EVERY TIME I WOULD DRIVE THE EXPLORER, MY EYES WOULD GET VERY HEAVY AND I WOULD DEVELOP A HEADACHE. I COMMUTE 42 MILES EACH WAY FOR WORK AND I CANT COUNT HOW MANY TIMES I ALMOST FELL COMPLETELY ASLEEP. AFTER SOME RESEARCH, I FOUND OUT THAT THIS WAS A COMMON PROBLEM TO DUE TO POSSIBLE CARBON MONOXIDE (CO) LEAKS ENTERING THE VEHICLE THROUGH THE VENTILATION SYSTEM. I IMMEDIATELY CONTACTED MY LOCAL FORD DEALERSHIP AND HAD THIS LOOKED AT EARLY THIS YEAR. FORD REPLACED THE EXHAUST MANIFOLD AND I NOTICED A MAJOR DIFFERENCE IN HOW I FELT WHEN DRIVING THE VEHICLE. RECENTLY, IN THE PAST TWO WEEKS I HAVE BEEN EXPERIENCING THE SAME ISSUE AGAIN WITH HEADACHES AND FEELING SLEEPY WHILE DRIVING. I HAVE MADE SEVERAL ATTEMPTS...

I SMELL EXHAUST IN THE CABIN SOMETIMES. I WORK OUT OF MY CAR A FEW HOURS A DAY, LEAVING IT ON AND WITH AIR CONDITIONING ON WHILE I GO DOOR TO DOOR AND GET HEADACHES AND SUPER TIRED WHICH I HAVE NEVER HAD IN MY LIFE. I ALSO GET EXTREMELY SLEEPY AFTER BEING IN THE CAR FOR MORE THAN AN 40 MINUTES AT A TIME. SOMETIMES I TAKE A NAP IN THE CAR WITH THE A/C ON AND ALL 4 WINDOWS CRACKED ABOUT AN INCH EACH. WHEN I WAKE UP I FEEL DIZZY, SICK AND HAVE A HEADACHE AFTER A WHILE.

CARBON MONOXIDE LEAKING THROUGH THE AC VENTS

THE VEHICLE INSIDE CABIN SOMETIMES SMELLS LIKE NATURAL GAS. DRIVER HAS EXPERIENCED HEADACHE AND WEAKNESS AFTER DRIVING LONGER PERIODS OF TIME. WINDOWS HAVE TO BE OPENED TO RID OF THE SMELL.

STRONG BURNING SMELL INSIDE OF VEHICLE WHEN ACCELERATING. THE SMELL IS SO STRONG IT WILL MAKE YOU NAUSEOUS, REQUIRING ME TO PULL OVER AND EXIT THE VEHICLE. I REPORTED THE PROBLEM TO THE DEALERSHIP AND WAS ADVISED IT WAS THE UNDERCARRIAGE COATING BURNING OFF. I AM NOW AT 5500 MILES ON MY VEHICLE AND THE SMELL CONTINUES TO PERSIST. THE DEALERSHIP AND FORD MOTOR HAVE NOT BEEN HELPFUL IN RECTIFYING THIS PROBLEM OR FINDING THE CAUSE OF THE SMELL. THE PROBLEM OCCURS EVERY TIME I HAVE TO ACCELERATE, ON A DAILY BASIS.

VEHICLE SURGE ON FIRST ACCELERATION AFTER STARTING THE ENGINE. SURGE - THE VEHICLE EXPERIENCES AN ACCELERATING LUNGE FORWARD AND THEN STOPS FOR ABOUT TWO OR THREE CYCLES (STOP/START, STOP/START ETC.) IT IS UNEXPECTED AND UNCONTROLLABLE UNTIL IT SUBSIDES WITHIN 20 TO 30 FEET. THE DEGREE OF THE UNEXPECTED ACCELERATION IS EXCESSIVE WHEN COMPARED TO THE SLIGHT APPLICATION OF THE GAS PEDAL CONDITIONS - HAPPENS ONLY AFTER THE FIRST STARTUP OF THE ENGINE, IN WARMER WEATHER WHEN THE "CHOKE" IS NOT REQUIRED. EXAMPLE: START ENGINE, BACK OUT OF GARAGE, PLACE IN FIRST GEAR, ACCELERATE SLOWLY FOR THE FIRST TIME. THIS IS WHEN THE SURGE IS EXPERIENCE. IT DOES NOT HAPPEN WITH EVERY STOP/START CYCLE DURING NORMAL DRIVING, LIKE STOPPING AT A TRAFFIC LIGHT. IT HAPPENS ONLY AFTER STARTING THE ENGINE, AND GOING FORWARD FOR THE FIRST TIME. THE PRIMARY PROBLEM IS THE DEGREE OF THE UNCONTROLLED, OSCILLATING ACCELERATION RELATIVE TO THE...

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, EXHAUST FUMES EMITTED INTO THE CABIN OF THE VEHICLE. THE FUMES CAUSED THE CONTACT'S CHILDREN TO BECOME NAUSEOUS AND VOMIT. THE CONTACT WAS CONCERNED FOR THE SAFETY OF HIS CHILDREN. THE CONTACT CALLED ROD BAKER FORD AT (877) 222-7336 (LOCATED AT 16101 S LINCOLN HWY, PLAINFIELD, IL 60586) WHERE AN APPOINTMENT WAS SCHEDULED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 6,310.

I AM AN ATTORNEY FILING THIS REPORT ON BEHALF OF AND AT THE REQUEST OF MY CLIENT, THE VEHICLE'S OWNER. THE COMPLAINT IS A NOXIOUS ODOR WHICH FILLS THE VEHICLE DURING ITS OPERATION; AFTER NUMEROUS REPAIR ATTEMPTS BY FORD, THIS CONCERN HAS NOT BEEN CORRECTED. WHEN DRIVING THE VEHICLE, THE DRIVER HAS OBSERVED THE INTERIOR HAS BECOME INUNDATED WITH A NOXIOUS, OVERWHELMING, AND POTENTIALLY DANGEROUS ODOR OF GASOLINE, EXHAUST AND/OR FUMES. THE DRIVER HAS FELT ILL EFFECTS AFTER THIS OCCURRENCE AND IS CONCERNED ABOUT CARBON MONOXIDE POISONING OR OTHER HEALTH PROBLEMS AS A RESULT. THIS ISSUE IS VERY CONCERNING BECAUSE OF THE POTENTIAL HEALTH EFFECTS AND BECAUSE VEHICLE CANNOT BE DRIVEN FOR ANY SUBSTANTIAL PERIOD OF TIME WITHOUT FILLING WITH THIS ODOR. THE ISSUE HAS MOST OFTEN BEEN OBSERVED WITH HIGHWAY DRIVING WHEN THE ENGINE IS UNDER LOAD, I.E. ACCELERATING. THE PROBLEM HAS BEEN ONGOING SINCE SHORTLY AFTER THE TIME...

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD AN EXPLOSION COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE THEN STALLED WITHOUT WARNING. IN ADDITION, THE FRONT PASSENGER SIDE CONTROL ARM DETACHED, WHICH CAUSED THE PASSENGER TIRE TO EXPLODE. THE VEHICLE WAS TOWED TO A TOWING LOT. THE VEHICLE WAS LATER TAKEN TO PENSKE FORD COLLISION CENTER (8970 LA MESA BLVD, LA MESA, CA 91942, (619) 464-7777) WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE AND ADVISED THE CONTACT TO "WORK IT OUT THE BEST HE COULD". NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE CONTACT FELT NAUSEATED, ESPECIALLY WHEN THE HEATER WAS ACTIVATED. THE CONTACT DID NOT PERCEIVE AN ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO MATTHEW'S FORD NEWARK (500 HEBRON RD, NEWARK, OH 43056) AND THE HEATER SOFTWARE WAS REPROGRAMMED. THE FAILURE RECURRED AND WAS NOT REMEDIED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 250.

THERE'S EXHAUST FUME IN THE CABIN MY WIFE HAS SUFFERED SEVERE HEADACHE AFTER 60 MINS OF DRIVING INCLUDED MY 20MONTHS OLD BABY. MY CAR HAS ALREADY BEEN REPAIRED ONCE AND IS IN THE SHOP AGAIN BECAUSE I LEFT A CO2 SENORS IN BACK SEAT AND HAS GONE OFF MULTIPLE TIMES. FORD IS NOT BEING VERY HELPFUL BECAUSE I DON'T WANT THE CAR ANYMORE. IT IS A HUGE SAFETY CONCERN AND I DON'T WANT MY WIFE AND TODDLER IN THE VEHICLE AT ALL.

FAILED TO ACCELERATE FROM STOP.

MY WIFE WAS INVOLVED IN AN ACCIDENT ON ICY ROADS ON DECEMBER 5. SHE WAS DRIVING OUR 2017 FORD EXPLORER WHICH WE HAD PURCHASED ON MAY 31, 2017. SHE WAS STOPPED AT A RED LIGHT ON A COUNTRY HIGHWAY AND HEADED NORTH. THE LIGHT TURNED GREEN AND SHE HAD JUST GOTTEN THROUGH THE INTERSECTION WHEN A VEHICLE THAT WAS HEADING SOUTH, LOST CONTROL AND HIT HER HEAD-ON. THE ATTACHED PICTURE SHOWS THE AMOUNT OF DAMAGE SUSTAINED ON THE FRONT END OF THE VEHICLE. BEYOND THIS DAMAGE, THE IMPACT WAS STRONG ENOUGH THAT A MOTOR MOUNT MOUNTING PIN WAS SHEARED CLEAN OFF THE MOTOR AS WAS THE COVER ON THE TIMING BELT. THE REBAR IN FRONT OF THE RADIATOR WAS SNAPPED COMPLETELY IN HALF. ALL THIS DAMAGE...AND THE AND AIRBAGS DID NOT DEPLOY. THERE WAS SUFFICIENT DAMAGE THAT THIS $50,000+ VEHICLE WAS CONSIDERED A TOTAL LOSS. I'VE CONTACTED THE FORD DEALERSHIP...

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A STRONG ODOR COMING FROM INSIDE THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE CAUSED THE CONTACT TO SUSTAIN A HEADACHE, DIZZINESS, EYES WATERED, LIPS DRIED AND HAD CHEST PAIN THAT REQUIRED NO MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO THE LASCO FORD DEALER LOCATED AT 2525 OWEN RD, FENTON, MI 48430 WHERE IT WAS DIAGNOSED THAT THE INSULATE 05 AND THE VALVE A009 NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.

THERE'S EXHAUST FUME IN THE CABIN AFTER HARD ACCELERATION(RPM WAS AROUND 5000). AND MY FAMILY SUFFERED A SEVERE HEADACHE AFTER 90 MINUTES DRIVING INCLUDED MY 12 MONTHS OLD BABY. MY CAR HAS ALREADY BEEN REPAIRED TWICE IN FORD, BUT IT HAS NOT BEEN RESOLVED.

I BOUGHT A 2017 FORD EXPLORER FOR MY DAUGHTER TO DRIVE BACK AND FORTH TO COLLEGE. SHE HAS BEEN EXPERIENCING DIZZINESS, HEADACHES AND NEARLY PASSED OUT AFTER DRIVING THE VEHICLE. WHEN I GET IN THE VEHICLE AND START IT UP, IT SMELLS LIKE EXHAUST INSIDE THE VEHICLE. THERE IS OBVIOUSLY A PROBLEM.

DRIVING DOWN A DIRT TRAIL FROM A MOUNTAIN OUTLOOK THE CARS ELECTRICAL SHUT OFF. WE HAD NO CONTROL OF BRAKES, OR ANYTHING BUT STEARING. NOT TO MENTION WE WERE PICKING UP MAJOR SPEED DOWN A MOUNTAIN, AND BOUNCING EVERYWHERE. WE HAD TO SWERVE BACK AND FORTH, HITTING BUSHES AND SEMI DRIVING UP THE SIDE OF THE MOUNTAIN TO TRY AND SLOW DOWN. OUR WHOLE FAMILY WAS IN THE CAR, INCLUDING A TWO MONTH OLD AND A THREE YEAR OLD. THE ONLY WAY WE GOT IT TO WORK AGAIN WAS SLAMMING THE SHIFTER INTO NEUTRAL AND THEN PUSHING THE RESTART BUTTON, BUT IT WAS PROBABLY JUST OUR PRAYERS THAT GOT THE CAR TO TURN BACK ON AND GIVE US BRAKE CONTROL AGAIN. I'M AFRAID TO DRIVE MY CAR IN FEAR OF IT HAPPENING AGAIN.

MY 2017 FORD EXPLORER XLT WITH BASE 3.5 V6 HAS BEEN HARD TO START FROM THE FIRST WEEK OF OWNERSHIP. IT HAS LESS THAN 5000 MILES ON IT NOW AND ISN'T FIXED. FORD DEALERSHIP STATED IT WOULD HAVE TO GET WORSE BEFORE THEY COULD FIX IT. VEHICLE SHOWS NO DTC'S OR ANY HISTORY! MY WIFE HAS REFUSED TO DRIVE IT OUT OF TOWN DUE TO THE FEAR OF IT NOT STARTING AT ALL. WE HAVE RECORDED OVER 30 VIDEOS OF IT NOT STARTING AND HAVE SENT VIDEOS TO FORD MOTOR CO. WITH THE SAME RESPONSE, CANT FIX IT IF IT ISN'T BROKE. APPARENTLY IT WILL HAVE TO EITHER BREAK SOMETHING INTERNALLY AND LEAVE MY WIFE AND CHILD STRANDED, BEFORE IT WILL BE DIAGNOSED. IT IS A $40000 LEMON THAT TAKES 3-4 TIMES ATTEMPTING TO START BEFORE THE ENGINE WILL RUN. THIS WEEKEND IT TOOK AT LEAST 30-40 SECONDS BEFORE VEHICLE...

SMELL OF EGG/SULFUR IN THE CABIN OF THE CAR AFTER RAPID ACCELERATION. I HAD NOTIFIED THE DEALERSHIP AT MY LAST OIL CHANGE. THEY DIDN'T SEEM CONCERNED ABOUT IT. THE SMELLS HAS CONTINUED. DEALERSHIP IS NOW TELLING ME TO WAIT TILL NOV 1ST. THIS HAS BEEN HAPPENING SINCE I BOUGHT THE CAR IN DEC 2016 AND HAS STEADILY GOTTEN WORSE. I DIDN'T THINK IT WAS A BIG DEAL SINCE THE DEALERSHIP DIDN'T SEEM CONCERNED.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, CARBON MONOXIDE EMITTED THROUGH THE VENTS IN THE VEHICLE. THE DRIVER BECAME DROWSY WHILE DRIVING. THE CARBON MONOXIDE REMAINED IN THE VEHICLE UNTIL THE WINDOWS WERE ROLLED DOWN. THE CARBON MONOXIDE DETECTOR DETECTED 13 PPM TO 16 INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO LAKE ELSINORE FORD (31500 AUTO CENTER DR, LAKE ELSINORE, CA 92530, PHONE NUMBER: (951) 471-4100), BUT THEY COULD NOT DETECT THE CARBON MONOXIDE DUE TO NOT HAVING A CARBON MONOXIDE DETECTOR. THE MANUFACTURER INFORMED THE CONTACT THAT IT WAS NOT AN ISSUE AND SOMEONE WOULD CALL BACK. THE APPROXIMATE FAILURE MILEAGE WAS 20,350.

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. EVER SINCE THE CONTACT PURCHASED THE VEHICLE AND BEGAN DRIVING IT, SHE EXPERIENCED NAUSEA, VOMITING, DIZZINESS, BLURRED VISION, AND HEADACHES INTERMITTENTLY. THE CONTACT REQUIRED HOSPITALIZATION FOR THE SYMPTOMS, BUT RECEIVED NO DIAGNOSIS. THE CONTACT STATED THAT THE SYMPTOMS OCCURRED WHEN SHE WAS IN THE VEHICLE FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. A DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 300.

EXHAUST CAN BE EASILY SMELLED WHEN ACCELERATING, POSSIBLY INDICATING A LEAK OF CARBON MONOXIDE INTO THE CABIN.

WE PURCHASED THIS VEHICLE BRAND NEW ON 8/11/2017 (19 MILES)AND WE STARTED NOTICING A SMELL OF EXHAUST WHEN WE ACCELERATED AND WHEN WE HAD THE REAR A/C ON COMING IN THE CABIN. WE HAD IT AT THE DEALERSHIP FROM SEPT 25, 2017 TO OCT 6,2017 (1496 MILES). THE PROBLEM STILL EXISTS WHEN WE PICKED IT UP FROM THE DEALERSHIP ON OCT 6, 2017. WE BELIEVE THIS IS A SERIOUS HEALTH CONCERN AS WE HAVE BEEN EXPERIENCING HEADACHES, ESPECIALLY MY WIFE, WHO IS THE PRIMARY DRIVER. WE WILL NOT LET OUR GRANDCHILDREN RIDE IN THIS VEHICLE WITH THE EXHAUST FUMES PRESENT. WE ARE AWARE THAT FORD IS AWARE OF THIS PROBLEM SINCE 2012. AS THIS IS A BRAND NEW VEHICLE,WITH 1496 MILES, WE FEEL THAT THIS PROBLEM IS NOT GOING TO GO AWAY ANYTIME SOON. WE DO NOT WANT HAVE TO KEEP TAKING THIS TO THE DEALERSHIP FOR TEMPORARY FIXES (TSB)....

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL TO INCREASE THE RPMS TO APPROXIMATELY 25-30 MPH, THE VEHICLE EMITTED A STRONG, FOUL ODOR SIMILAR TO ROTTEN EGGS. THE CONTACT TOOK THE VEHICLE TO SANDERS FORD (1135 LEJUNE BLVD, JACKSONVILLE, NC 28540; 1-888-897-8527) WHO DIAGNOSED THE VEHICLE AND COMPLETED THE DIRECTIONS ON A SPECIFIC SERVICE BULLETIN. THE CONTACT STATED THAT THE DEALER REPLACED THE VENTS UNDERNEATH THE BUMPER. THE SERVICE BULLETIN NUMBER WAS UNKNOWN. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.

FUMES ENTER CAR WILE DRIVING!

2017 FORD EXPLORER SPORT. 3.5 ECOBOOST. WHEN ACCELERATING 3/4 OR MORE ON THE PEDAL. DOES NOT SMELL SO MUCH AS EXHAUST AS IT DOES SULFUR AND BAD EGG SMELL. ONLY WAY TO GET THE SMELL OUT OF VEHICLE IS TO TURN AIR OFF AND ROLL WINDOWS DOWN. SEEMS WORSE WHEN AIR CONDITIONING IS ON THAN THE HEAT. PASSENGERS USUALLY GET IT WORSE THAN DRIVER.. AT LEAST THAT'S MY EXPERIENCE, OR THAT IS THE SIDE WITH THE PROBLEM. I WAS READING ON WEBSITES BEFORE ALL THESE CLAIMS WERE BROUGHT UP AND I KEPT COMING TO THE CONCLUSION FROM READING UP WHAT COMPLAINTS I FOUND, IT WAS THAT THE TWIN TURBOS HAD A LOT OF BLOW BACK AND IT WAS ONLY THE ECOBOOST MOTORS. NOW I NOW DIFFER AND THERE IS A CURIOUS PROBLEM AND I OWE A SMALL FORTUNE ON A VEHICLE THAT'S NOT SAFE TO DRIVE AND ALSO WITH A...

EXHAUST FUMES ENTERING VEHICLE WHEN STATIONARY AND IN MOTION.

EXHAUST FUMES FILL THE CABIN OF VEHICLE DURING HEAVY ACCELERATION. USUALLY CAUSES HEADACHE. DEALER CONFIRMED ISSUE. DEALER ADVISES FORD HAS ISSUED A TSB BUT THE PARTS HAVE BEEN RECALLED FOR MONTHS SO NO REPAIR IS ABLE TO BE COMPLETED AT THIS TIME.