2017 FORD EXPLORER Electrical System Problems

I am filing a safety defect complaint regarding my 2017 ford explorer. The B pillar has broke in half a couple of years ago and nearly struck a vehicle behind me and if the remaining trim piece detaches, it could become a serious risk of collision, injury or property damage. it states NHTSA works to prevent unsafe traveling which is why I'm writing this. I have contacted Ford customer service and dealerships multiple times with no luck of anything. I have had to continuously tape the area to door which is not ordeal nor a forever fix. The b pillar is held on by wires that are slowly breaking. The wires lead to a hole that is inside my door. the opening exposes from the outside, meaning if it rains or snows, it is getting inside the hole, into my car door. If the recall piece ever came in, my...

The windshield wipers activate by themselves, even when it is not raining and there is no water.

In January of 2025 the rear windshield suddenly blew a hole in it after starting the vehicle with the remote start. I was advised that due to the cold temperatures and then the heat from the rear defrost caused this to occur. On Wednesday 12/31/25, the same exact thing happened. My vehicle was parked at my home in the garage when I remote started it. A few minutes later, my daughter and I got in, started it, then proceeded to back up when we heard a loud boom. Same thing happened as the first issue in January of 2025. No reason, no damage and it blows a hole it in near the rear wiper. This is causing glass shards to explode into the interior.

Ya me marco el funcionamiento del motor

Constant fail of O2 sensor and ABS causing check engine and ABS lights to come on. After diagnosis, did research and it is a common problem on Ford Explorers

I recently found out about a Ford recall regarding the backup cameras malfunctioning which did not include my vehicle even though my vehicle is showing the unsafe defect. The backup camera goes fuzzy/glitchy as well as black sometimes while backing up.

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). However, the parts to do the recall repairs were not yet available. The contact stated that while driving at 80 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted. The vehicle was not repaired. Most recently, the keyless entry failed to function as intended. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 85,000.

I’ve been experiencing a buzzing sound whenever I turn the steering wheel, and the more I drive the vehicle, the louder the noise becomes. I took it to a local shop, and they advised me that the power steering rack is going bad — a very common issue in 2017–2019 Ford Explorers, especially around the 100,000-mile mark. They provided a quote of $2,652.86 to have it replaced. I was also warned that if it’s not replaced soon, the steering could lock up while driving, preventing me from turning the wheel, which poses a serious safety risk. No warning lights or dashboard messages have appeared, which makes the issue even more concerning.

intermittened starting problems, vechile wont start, clicks, then starts and power train light comes on. Waiting at a red light, press the gas and the car does not go, also when speeding up transmission slips.

The following is a letter I sent to Ford. I've yet to hear back from them. This is a picture of what happened in my 2017 Explorer on Thursday, June 5, 2025. As I unlocked and got into my car, I realized the seat was moving forward. I tried to get out of the seat, but it was difficult because the space was closing in. I managed to squeeze out of the space before it totally closed me in and pinned me between the seat and steering wheel. As you can see from the picture, the seat is as close to the steering wheel and console as possible. The steering wheel was 7 inches from the seatback and 7 inches from the seat bottom. The seat was 2 inches from the console. This is extremely dangerous. This is not the first time this has happened. This has occurred at least...

The contact owns a 2017 Ford Explorer. The contact stated that while seated in the parked vehicle, the rear passenger’s side head restraint became unhinged. The contact stated that the exterior front driver’s side pin paddle had failed. The vehicle was not taken to a dealer to be diagnosed. The contact stated that the railings on the rear passenger’s side seats were replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 99,208.

There is a constant drain on the battery and overnight the battery can go dead. I replace the battery every 6 months to a year and have been doing that ever since we purchased it. The dealership wants $250 to diagnose it. It's been a problem from day 1. Even when we took it to get serviced and they kept it overnight - the same thing happened at the dealership, but they just ignored it. That was when it was under warranty. I read on the internet that several people have this same problem. I feel this should be a recall. I have a 2017 Ford Platinum

The sunroof gets stuck in the tilted open position and sunshades will not close. This creates an unsafe condition if it starts to rain. Cannot secure the vehicle. This problem is very common and there are many complaints and how to fix videos on the internet. I contacted Ford At first they were cooperative and offered to help with the repair. Then suddenly they refused to help with the repair. This left me with a 1200.00 bill at the dealer. It is a common failure, it was occurring on the previous model year and was not addressed, it requires proprietary tools to fix. There is low incentive to Ford to fix if they can make a profit from the failure. just one online example there are many videos and how to repair post and complaints: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Explorer. The contact stated that while driving 65 MPH, the vehicle made an abnormal beeping sound, the cabin lights illuminated unintendedly, and the message "Tailgate Ajar" was displayed. The contact decelerated and pulled over to the side of the road. The contact resumed driving; however, the failure persisted. The contact then became aware that the front driver's side door exterior keypad trim had detached and had fractured into two pieces, causing damage to the keypad wiring system. The vehicle was taken to the dealer, where it was determined that the keypad needed to be replaced. The contact purchased the part from the manufacturer's website, and the vehicle was taken to the dealer, where the part was installed; however, the failure recurred while driving. The dealer was contacted and provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of...

Passenger seatbelt frayed, inside electrical goes haywire when cold weather, transmission slipping was rebuilt under warranty lasted one week and is slipping again shifting hard, B panels falling off A panel was recalled but panel wasn’t?

Keyless entry panel on driver's side continues to fall off while driving, hanging by wires, which then blow fuses. Lift gate ajar warning comes on and then unable to open/close rear lift gate. Indoor overhead lighting remains on due to "liftgate ajar" even though liftgate is not ajar. This is a Safety hazard, panel could fly off during driving. Took to dealer, misdiagnosed as liftgate latch malfunction. Paid to get latch replaced and one week later, keyless entry panel fell off again and liftgate ajar warning came up and unable to open or close liftgate and interior lighting remains on.

Driving on the highway heard large rattling noise coming from engine loss of power engine light came on battery light came on no acceleration cause to slow down on highway fortunately I was able to get to shoulder had it towed to service shop had p0012 code tensioner may have broken off on timing belt causing low oil pressure and causing engine rattling noise and engine shut down but service garage don’t do that type of work

We notice we were getting a warning about our battery about a year ago, so we took it to Ford and they said they couldn’t find any issues. We found a mechanic in town who looked at it with a volt meter an instantly noticed that the red power cable coming from the battery had burst through the casing that once held it. Now we have an exposed power cable that could potentially catch on fire if fluids from the engine were exposed to it. We first knew something was wrong when the doors would not unlock properly. And while driving we would get a battery warning. Ford told us during our warranty period that they didn’t find anything wrong when this should have been noticed instantly. This is a serious fire hazard. The vehicle was inspected by the manufacturer but a lack of knowledge by their mechanics has led...

The contact owns a 2017 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the front driver’s side door keypad fractured in half leaving the wires exposed. No warning lights were illuminated. The dealer was made aware of the failure but confirmed that the parts to fix the vehicle was not available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 135,000.

The contact owns a 2017 Ford Explorer. The contact stated while her husband was driving at an undisclosed speed, the "Liftgate Ajar" message was displayed. The contact's husband pulled over and inspected the trunk, and the trunk was properly closed. The contact's husband then became aware that while opening the front driver's side door, the keyless entry keypad had detached. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at 80 MPH, the contact heard a loud bang, and the "Door Ajar" message was displayed. The contact pulled over and noticed that the front driver's side keyless entry keypad had detached, exposing the wires from the door. The contact drove to her destination, but the rear liftgate failed to open as needed and the interior lights failed to turn off. The contact purchased and replaced the 10-amp fuse under the steering wheel, which resolved the failure with the rear liftgate and the interior lights; however, the front driver's side keyless entry keypad was not repaired. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately...

The contact owns a 2017 Ford Explorer. The contact stated that the speedometer and RPM gauges were sticking. There was an abnormal ticking sound detected. While in gear, the speedometer and RPM were flashing on and off. The driver was unable to determine the speed of the vehicle while driving. The contact stated that several unknown warning lights were flashing on and off. The contact disconnected the battery. The contact cleaned the cables and terminals and replaced the battery. The vehicle started working as designed, but the failure recurred. The contact called the local dealer, who scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 119,000.

Vehicle’s coolant over temperature warning light comes on only on highway and vehicles slows, which can cause a crash. However, temp gauge fluctuates quickly going back and forth from normal to hot.

My instrument panel completely went blank, flickering and when the car is shut off it continues to click, I'm having to disconnect battery when exiting the vehicle. I have no speedometer, oil gauge, temperature gage. I have no way of knowing my speed when driving. This vehicle has been very well taken care of and maintenance when called for. It believe it causes the battery to corrioid and having to clean battery all the time. This has been continuous since buying the car in Dec 2018.

Like the existing recall for the exterior A pillar , the exterior B Pillar is lifting from the car at the top. This has since caused rain water to leak in from the top and caused a short in the touch entry keypad within the pillar, causing it to flash on and off over and over draining the cars battery until it is dead and won’t start.

My locks on my doors will not lock with keyfob or when I push my lock button in the car. I am scared that if I can't lock them someone will fall out the car. Someone can steal my car because I cannot lock my doors.

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was running rough and was shuddering while starting and driving. The check engine warning light was illuminated. The contact stated that the failure had been recurring. The vehicle was taken to an independent mechanic twice. The mechanic determined that rodents had damaged the wiring underneath the hood. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the dealer several times, and the same assessment was made. The vehicle was repaired; however, the failure persisted. The dealer determined that the wiring underneath the hood and the wiring in the rear of the vehicle needed to be replaced due to rodent damage. The vehicle was being repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 52,877.

The driver side heated seat does not work at all the passenger side heated seat works just the driver side does not work

Air bag light came on the dash board Headed to dealer to see why Code B141C Cost to repair the problem was very high not covered by warranty The problem seems to me a poor design. Because of this weak design I feel this puts passengers in danger.

Our Explorer, experienced this in June of 2022. My daughter had just graduated college and we were moving some of her stuff back home 350 miles away. The Driver side area where the codes are put into to unlock the door if locked out, fell off and was hanging while we were driving on the freeway. We had to exit the freeway and my husband had to buy duck tape to tape it up. Our hatchback would not work as well as some of the other electrical things. I refused to drive it the rest of the way home, and we switched cars. It did cause electrical to go out throughout the car, intermittently. My husband had to buy the part online and replace it. The passenger side is going to fall off also, I noticed while washing it. So yes we need this done, asap. And we had to...

All plastic parts around all doors and windows have become detached. Windshield wipers do not stay on. All lights and gps go haywire and flash on and off gps system goes off and makes loud buzzing noise

Car dies repeatedly while on the road driving and also while parked. Car has errors on dashboard when attempting to turn on, which I have a video of. First mechanic was able to replicate issue once and got some scan tool codes but he said after that, they all cleared out and he wasn't able to replicate. Car was given back to us, drove to store died and it wouldn't start in parking lot. Mechanic sent tow truck, car started when tow truck arrived. Took car to Ford, tech unable to replicate, car returned to us. Car died once again, which is when I took the error video and took the car back to Ford and showed service rep the video. Ford still unable to figure out the issue. We told Ford to keep the car because it isn't safe to drive until we find and fix the issue. Car...

My two back doors wont lock or unlock. Very frustrating

I had a piece of window trim fly off while I was driving on the highway at 70 mph. When it flew off, it may have hit another car. With the piece gone, I am not unable to open the hatch and the dome lights stays on for a considerable amount of time. There is no way to turn off the dome lights, you have to wait for them to go off, which is sometimes more than 10 minutes. When the piece was replaced, the hatch worked as normal. I had the window trim replaced and the same thing happened. I was traveling down the highway over 70 mph and the piece flew off in heavy traffic. I, again, have not been able to open the hatch nor turn off of the dome lights.

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 10 MPH and making a right turn, the steering wheel did not return to center. The contact stated that the steering wheel failed to respond normally while turning the steering wheel to center. Additionally, the contact stated that the instrument cluster went black, and the vehicle stalled. The contact pulled over safely and restarted the vehicle. The contact stated that the “System Communication Error" message was displayed on the infotainment screen after the restart. The contact later had the vehicle towed to a local dealer, where it was diagnosed and determined that the wiring harness and the GWM harness needed to be replaced. The vehicle had been repaired. The contact stated that after the repair, the battery had started to drain very quickly. The vehicle was towed back to the same dealer but was not diagnosed or...

My door do not lock/unlock automatically. It started with one door. Then that door started working and another door stopped working. Then that started working and a different door stopped working. This cycle kept happening until all doors stopped working. Then they started working again and then stopped working again. On several occasions the locks I couldn't unlock door with the key or open the door from the inside with handle/button or lever. Also tried to lock car manually only for the lever to pop right back up. So my car was left unsecured on many occasions. Door problems Started may of 2022 until recent

The locks on the doors do not all unlock at the same time or lock at the same time. The passenger door has locked and would not unlock. My daughter had to climb through car to get out. If there’s an accident my kids can not safely exit the vehicle due to the locks. You can’t unlock it either from the inside. It randomly will unlock on its own.

The automatic locks on both right passenger sides quit working. It imposes a danger because if you are trying to get out of the vehicle you can’t if it’s locked. If it’s left unlocked then it imposes a danger if someone is trying to get into your vehicle that you don’t want and you can’t lock them out.

The APIM module failed in our 2017 Ford Explorer. The module failed so the windshield wipers do not work, the turn signals do not work, the heater does not work, the speedometer does not work, the tachometer does not work, the temperature gauge does not work, the fuel gauge does not work, the center display does not work, the reverse camera does not work and the radio will not turn off and the center display lights will not turn off.

We had an issue with Fuse 34, it popped and sent warning lights to the dash regarding safety systems and sensors, as well as the cameras in front and back stopped working. We replaced the fuse and it held for a while, but then popped again. I noticed a lamp flickering one day on the front of the vehicle, and upon further inspection saw that the front camera and wiring harness had started on fire. The wiring harness is fully melted and there are signs of smoke and fire damage on the front of the car. I took the vehicle to a Ford dealer who confirmed their wiring harness had failed, but will not take responsibility for the issue. The care only has about 45k miles on it. I called to their corporate office who also rejected any liability. Obviously this is more than just the money for repairs, but...

Bad APIM, available for inspection. Diagnosed by Ford dealer when I took it in for Sync screen going black, navigation fault, steering wheel Sync controls not working. Backup camera does not work periodically - which is my prime safety concern. It is also distracting when the navigation and sync screen go black while driving. Ford seems to know the problem, and from other on-line posts, this is a popularly recurring malfunction.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and attempting to make a left turn, the steering wheel failed to respond. The contact shifted to park(P) and then shifted back into drive(D). The vehicle then regained steering functionality. The contact was able to continue driving however, the failure recurred on several occasions. The vehicle was taken to the local dealer on three occasions; however, the dealer was unable to duplicate the failure and the failure persisted. The manufacturer was notified of the failure and referred the contact to NHTSA Hotline for assistance. The failure mileage was approximately 30,676.

I took my Vehicle in because the AC stop blowing cold air, and the overheating lights kept coming on. After waiting for a week, I was told it was a water pump but that did not fixed the AC being at all, couple days later I got a call from the dealership (GRAPEVINE FORD) that the compressor went out. After 3 weeks of waiting, I end up paying out of pocket what is supposed to be covered based of this letter I received from FORD. I feel like I should not have to pay for something that FORD should have covered. Letter below explained the very issues I had with the vehicle, including OVERHEATING and damages like bad cooling relay would cause.

Our model is a platinum explorer with the panoramic sunroof. Apparently there is a sunroof leak which due to the way the headliner is made , fills the headliner (holds like a bowl) then either spills out at the front of the vehicle or rear depending on going forward , reverse, accelerating, braking, uphill, or downhill etc. The front is worse because of the electrical in the overhead lights, sunroof motors, and lane departure at the rear view mirror. Also everything electronic below on the dashboard and center console. There are high expenses related to replacing these electronics due to water damage in addition to the driver being suddenly started by a wave of water crashing down on them while accelerating or braking.

I backed into a parking spot, put the car in park and turned the vehicle off. As I was getting ready to get out of the car, it rolled backwards into another car parked to my passenger side rear. My vehicle did not give any warning, no sensor alert, or anything!

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 55 MPH, the front driver’s side the keypad on the door detached from the vehicle and was hanging on by a wire. The contact stated that the liftgate ajar warning light was illuminated however, she was unable to open the liftgate. The contact took the vehicle to the local dealer and the dealer was made aware of the failure. The contact also requested that the vehicle be serviced and the recalls associated with the VIN be repaired. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 112,000.

The APIM is malfunction in my 2017 explorer. Accessories stay on after vehicle turned off, killed battery, vehicle collision sensors and camera intermediate malfunction. Cruise control intermittent function, GPS and screen options /operations inoperable

The GPS, radio, backup camera, front facing camera and other items controlled by the APIM have been malfunctioning in the vehicle. The GPS will freeze, phones will not answer properly, the cameras will not engage often and the cruise control will occasionally malfunction. The only remedy is to replace the APIM. The vehicle is out of warranty on mileage so I am on my own to pay for the repair of the one item that controls almost all of the vehicle accessories, including heat/defrost, some lighting, etc.

Started car back up after driving noticed mirrors on both doors didnt extend out. and both front door windows wouldn't work the the defroster was on and I had climate set for ac then the tire pressure monitoring fault came on Sync touch screen would not do anything , the radio was working But nothing else , rear windows worked and sunroof as well. I drove it home the defroster was on and would not go off I parked vehicle let it set for several hours and it is still doing the same thing I plan on taking it to dealership for inspection on monday Aug 30 2021 I'll call first thing in the morning

My car keeps saying charging system service now but I’ve checked my alternator and my battery and they are both good. And I’m not the only Ford that has this problem as well. Multiple people who have had Ford have this problem. It should be a recall at this point.