2000 FORD EXPEDITION Engine And Engine Coolingengine Problems

I OWN A 2000 FORD EXPEDITION WITH A 5.4 LITER TRITON ENGINE WHICH EXPERIENCED A SPARK PLUG BLOW OUT. SO FAR, NHTSA HAS NOT REQUIRED FORD TO ISSUE A RECALL FOR A PROBLEM THAT MANY OTHERS HAVE HAD WITH THE SAME TYPE OF ENGINE. FORD DOES NOT ACCEPT RESPONSIBILITY FOR A DEFECTIVE DESIGN OF THIS ENGINE. I AM NOW FORCED TO PAY $3,000 TO FIX THE PROBLEM BEFORE I CAN EVEN CONSIDER TRADING IT IN OR TRYING TO SELL IT. *TR

2000 FORD EXPEDITION WITH A 4.6L I HAVE HAD 3 FACTORY INSTALL SPARK PLUGS BLOW OUT OF THE CYLINDER HEAD. *TR

WE HAVE A 2000 FORD EXPEDITION THAT BLEW OUT A SPARK PLUG ABOUT 6 MONTHS AGO AND THIS WEEKEND IT BLEW OUT ANOTHER SPARK PLUG. THE FIRST TIME IT HAPPENED I WAS DRIVING TO TOWN AND MY TRUCK STARTED TO RUN ROUGH AND SOUNDED AWFUL. THIS TIME MY SON HAPPENED TO BE DRIVING IT AND IT DID THE SAME THING. WE HAD TO GET IT TOWED BACK HOME PLUS HAVE SOMEONE TO FIX IT. THE GARAGE THAT FIXED IT USED A HELICOIL REPAIR KIT. I GUESS THAT THEY WILL DO THE SAME THING THIS TIME. I SURE AM DISAPPOINTED IN THE FACT THAT IT KEEPS COSTING ME MONEY TO FIX. I THINK THAT FORD NEEDS TO RECALL THE SUV. *TR

2000 FORD EXPEDITION EJECTED SPARK PLUG LEADING TO FAILURE OF VEHICLE TO PROVIDE RELIABLE SAFE TRANSPORTATION IN WINTER DRIVING CONDITIONS, OUT OF CELL PHONE RANGE IN RURAL CENTRAL MOUNTAINS OF COLORADO. SPECIFIC SAFETY FACTOR OF 4WD SUV HAS BEEN REDUCED TO ZERO AND PLACES FAMILY AT ADDITIONAL RISK OF AN ENGINE FIRE. *TR

SPARK PLUG BLOWN OUT ON MY 2000 EXPEDITION. *TR

I HAVE A 2000 4.6 FORD EXPEDITION WITH APPROX 150,000 MILES ON IT. I DROVE IT FROM LOS ANGELES TO SAN FRANCISCO. WHEN I ARRIVED IN SAN FRANCISCO I WAS GREETED BY A LOUD POP AND AN ACCOMPANYING RATTLE AND SPUTTER. THE FRONT DRIVER SIDE SPARK PLUG HAD BLOWN OUT AND BROKE OFF THE IGNITION COIL. THE SPARK PLUG STRIPPED THE THREADING OF THE ALUMINUM HEADS. I TOOK IT TO A FORD DEALERSHIP IN SAN FRANCISCO AND THEY BLAMED FAULTY INSTALLATION OF THE SPARK PLUG. IN RESEARCHING THE PROBLEM I HAVE FOUND THAT MANY OTHERS HAVE HAD THIS SIMILAR PROBLEM NOT SPECIFIC TO CHANGED SPARK PLUGS. I HAVE ALSO LEARNED THAT SOME CLASS ACTIONS SUITS HAVE BEEN FILED AGAINST FORD IN REGARDS TO THIS PROBLEM BUT HAVE NOT BEEN SUCCESSFUL. I AM OUT A COUPLE OF THOUSAND DOLLARS AND AN EXTENDED STAY IN SAN FRANCISCO DUE TO THIS PROBLEM THAT...

PURCHASED TRUCK ON 02/15/2008, AND THE BRAKES WENT ON THE TRUCK ON 02/21/2008, WHICH ALMOST CAUSE ME TO GO HEADON WITH A SEMI-TRUCK. TOLD DEALER ABOUT BRAKES GOING OUT BUT DIDN'T CARE ABOUT IT. TOLD HIM ABOUT ME TAKING THE TRUCK TO THE TRANSMISSION SHOP AND THE INDICATED THAT IT WAS THE MOTOR THAT HAVE THE 5 CYLINDER MISSING IN THE ENGINE AND THE ENGINE HAD A LOT OF DEFECTS WITH THE ENGINE. TOOK THE REPORTS TO THE DEALER AND HE SAID HE WOULD TAKE CARE OF IT BUT HE INDICATED TO ME THAT HE WOULD NOT FIX THE PROBLEM WITH THE TRUCK. HE TOLD ME TO FIX IT MYSELF AND PAY HIM THE CAR NOTE. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. UPON STARTING THE VEHICLE, THE CONTACT HEARD A LOUD POPPING SOUND COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT A SPARK PLUG BLEW OUT. THE DEALER INSTALLED NEW SPARK PLUGS AND A NEW COIL. WHILE DRIVING 25 MPH, THE FAILURE RECURRED AND THE VEHICLE WAS TOWED BACK TO THE DEALER. THE VEHICLE WAS REPAIRED AGAIN. THE FAILURE MILEAGE WAS 170,000 AND CURRENT MILEAGE WAS 171,000. UPDATED 02/19/08 *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT HE HEARD KNOCKING SOUND COMING FROM THE ENGINE AND THE ENGINE SKIPPED. THE DEALER STATED THAT ONE OF THE COIL PACKS CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT. APPROXIMATELY ELEVEN MONTHS LATER THE FAILURE OCCURRED AGAIN. THE DEALER STATED THAT THE NUMBER THREE AND SIX COIL PACKS NEED TO BE REPLACED. IN ADDITION, THEY NOTICED GUNK ON THE SPARK PLUGS. AS OF DECEMBER 27, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 143,000 AND FAILURE MILEAGE WAS 120,000. THE PURCHASE DATE WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT THEN STALLED AGAIN. THERE WAS A LOSS OF STEERING. THE VEHICLE COASTED TO A SERVICE STATION. THE MECHANIC STATED THAT THE SPARK PLUG BLEW OUT OF THE CYLINDER HEAD. NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 101,000. UPDATED 12/12/07

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE CONTACT HEARD A LOUD POPPING SOUND FOLLOWED BY A NOISE COMING FROM UNDER THE HOOD. THE VEHICLE HESITATED AND WOULD NOT ACCELERATE. THE CONTACT HAD TO GLIDE THE VEHICLE DOWNHILL AND INTO HER DRIVEWAY. A MECHANIC DISCOVERED THAT A SPARK PLUG BLEW OUT OF THE HOLE. THE DEALER HAS NOT BEEN NOTIFIED AND THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 140,000.

I TOOK MY 2000 FORD EXPEDITION XLT IN TO HUNTINGTON BEACH FORD TO BE SERVICED DUE TO R.P.M. FLUCTUATION AND A SERVICE ENGINE SOON LIGHT. THEY CONDUCTED A DIAGNOSIS AND STATED I WOULD NEED A I.A.C. PART. THE NEW I.A.C. DID NOT FIX THE PROBLEM SO I TOOK IT BACK TO H.B. FORD AND THEY STATED I WOULD NEED A D.P.F.E. SENSOR. I HAD THEM REPLACE THAT WHICH DID NOT FIX THE PROBLEM BECAUSE THE SERVICE ENGINE LIGHT ILLUMINATED AND THE R.P.M. FLUCTUATION WAS STILL EVIDENT. I WENT BACK TO H.B. FORD AND THEY DIAGNOSED A NEW THROTTLE BODY. I GAVE THEM THE O.K. TO REPLACE THE THROTTLE BODY. THEY CALLED ME A COUPLE DAYS LATER TO INFORM ME THAT THAT DID NOT SOLVE YOUR PROBLEM SO I WILL NEED TO PAY AN EXTRA $400 FOR A DIAGNOSTIC FEE SO THEY CAN CHECK ALL THE WIRING. THE MANAGER HAS STATED...

DT*: THE CONTACT STATED THAT THERE WAS A PUP-PUP NOISE COMING FROM UNDER THE HOOD AS THE ENGINE WAS STARTED. UPON INSPECTION, THE SOURCE OF THE NOISE CAME FROM THE SPARK PLUG. THE SPARK PLUG SUDDENLY BLEW OUT AND WAS ONLY ATTACHED BY A HANGING WIRE. THE VEHICLE WAS TOWED TO A DEALERSHIP WHO DETERMINED THE ENGINE REPAIR SHOULD BE PERFORMED.

ON 05-04-06, WAS DRIVING 35 MPH DOWN A CITY STREET DURING NORMAL DRIVING CONDITIONS WHEN THERE WAS A LOUD EXPLOSION, THEN MY 2000 EXPEDITION BEGAN TO SOUND AS IF IT WAS SPUTTERING OR MISSING. WIFE SCREAMED, KIDS STARTED CRYING, I SWERVED AS I THOUGHT INITIALLY IT WAS EITHER AN EXPLOSION OR ENGINE BLOWING UP COMING THROUGH THE FLOOR BOARD / FIREWALL. THE EXPEDITION WAS THEN SLOWLY DRIVEN TO THE HOUSE (WAS ONLY A FEW BLOCKS AWAY LUCKILY) AND CALLED A LOCAL MECHANIC TO MAKE AN APPOINTMENT TO BRING IN VEHICLE FOR INSPECTION AND REPAIR. FOUND IT WAS #7 SPARK PLUG BLOWN OUT OF THE HEAD, COIL WAS DAMAGED ETC. THE MECHANIC THEN REPAIRED THE ENGINE FOR ME AND I GOT IT BACK AFTER A WEEK. THE REPAIRS INCLUDED THE TOP HALF OF THE ENGINE BEING DISASSEMBLED, THE HEAD TAKEN TO A MACHINE SHOP AND BEING REPAIRED, THEN THE REMAINDER OF...

I WAS GOING TO THE LAKE WHEN I HEARD A PINGING IN THE ENGINE ON THE DRIVERS SIDE. I STOPPED TO CHECK THE OIL LEVEL. THERE WAS PLENTY OF OIL. I DROVE TO THE LAKE AND HAD A GREAT DAY OF FISHING. ON THE WAY HOME, I HEARD THE PINGING AGAIN BUT THE PINGING WAS NOT THERE ON ACCELERATION. AFTER DRIVING ALMOST TOTAL OF 400 MILES THAT DAY, I STOPPED BY THE GAS STATION TO PUT GAS IN, AFTER PUTTING GAS IN ABOUT 2-3 MILES FROM HOME, THE SPARK PLUG, COIL SHOT OUT OF THE HEAD - WENT HOME TO CHECK - JUST TO MY SHOCK FOUND NO THREADS IN THE HEAD. I ALSO HAD A FRIEND THAT THIS HAPPENED TO SO I WAS THINKING IT WAS JUST A ONE TIME INCIDENT BUT IT ALSO HAPPENED TO ME. I WILL HAVE TO FIND OUT WHAT FORD STATES WHEN I TAKE...

TWO WEEKS AGO I REPLACED THE SPARK PLUGS ON MY 2000 FORD EXPEDITION AND YESTERDAY WHILE DRIVING TO WORK I NOTICED A LOUD CLANKING NOISE. AFTER INVESTIGATING, I FOUND THAT THE #2 SPARK PLUG HAD BEEN BLOWN FROM THE CYLINDER HEAD. THE EXPEDITION HAS 10300 MILES ON IT AND HAS BEEN VERY RELIABLE.*JB

THIS IS NOT A FORMAL COMPLAINT, YET, BUT AN ATTEMPT TO PREVENT FURTHER COMPLAINTS AND BRING TO ATTENTION A DEFECT IN A VEHICLE I OWN IN AN ATTEMPT TO GET HELP TO FIX THIS DEFECT BEFORE IT HAPPENS! PREVENTATIVE MEASURES MUST BE TAKEN! I WAS MADE AWARE OF A BLOG AT HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_SPARK.HTML THAT LIST 67 INDIVIDUAL AND SEPARATE ACCOUNTS OF THE SPARK PLUGS IN FORD EXPEDITIONS THAT ARE BLOWING OUT OF THE HEADS!!!! IT HAS BEEN REPORTED HERE BEFORE AND IT SEEMS THAT THE HEADS ARE NOT EQUIPPED WITH ENOUGH THREADS TO HOLD THE SPARK PLUGS!!!!! IT SEEMS ONLY A MATTER OF TIME BEFORE I WILL GET A PHONE CALL FROM MY WIFE SAYING THAT SHE IS STUCK ON THE HIGHWAY WITH SPARK PLUGS BLOWN OUT. PLEASE INVESTIGATE THIS DEFECT BEFORE SOMEONE GETS HURTS. I HAVE THREE SMALL CHILDREN WHO RIDE IN THIS VEHICLE EVERYDAY! PLEASE HELP BEFORE THEY ARE...

I OWN A 2000 FORD EXPEDITION WITH A 5.4L ENGINE. I HAD HEARD OF THE PROBLEM WITH THESE ENGINES BLOWING SPARK PLUGS OUT OF THE PASSENGER SIDE HEAD. I HAD ALL OF THE SPARK PLUGS REPLACED IN JANUARY 2005 BY A FORD DEALER TO PREVENT A SPARK PLUG FROM INVOLUNTARILY REMOVING ITSELF FROM MY ENGINE. ON JANUARY 4TH, 2006 A SPARK PLUG BLEW OUT OF THE ENGINE'S HEAD ON THE PASSENGER SIDE. MY WIFE WAS TURNING ONTO THE HIGHWAY AT THE TIME. AFTER CONTACTING FORD AND MY FORD DEALER, I REALIZED THAT FORD HAS NOT TAKEN OWNERSHIP OF THIS WELL KNOWN PROBLEM. I HAVE REPLACED MY ENGINE WITH A USED ENGINE THAT HAS LOWER MILES. *NM

ROLLING UP DRIVER WINDOW-CLICKING NOISE/TICKING IN FRONT END DURING SLOW TURNS-SLOWING DOWN/ENGINE VIBRATION AND ROARING ON ACCELERATION/ACCELERATOR STICKING WHILE USING CRUISE CONTROL/ELECTRICAL PROBLEMS(I.E-WINDOWS ROLLING UP AND DOWN W/OUT PROMPTING, DOOR LOCKS INOPERABLE, RUNNING BOARD LIGHTS FLASHING ON AND OFF OR NON-FUNCTIONING, ILLUMINATED TEMP. AND COMPASS FLASHING OR NON-FUNCTIONING, FAN IN A/C RUNNING FOR NO REASON W/VEHICLE OFF AND KEYS OUT OF IGNITION, INDICATOR LIGHTS IN DASH FLASHING ON AND OFF, WIPERS OPERATING W/OUT PROMPTING, REAR WINDOW WIPER NON-FUNCTIONING, STEREO ONLY WORKING IN PARK AND REVERSE OR NOT AT ALL, ELECTRICAL CLICKING NOISE UNDER THE DASH, LEFT BLINKER FASTER THAN THE RIGHT)/BLACK FOAM SUBSTANCE COMING FROM A/C VENTS/THUMPING NOISE RIGHT WIPER WHEN IN USE. THE PROBLEMS HAVE BEEN REPORTED TO FORD DEALER AND THEY STATED IT WAS A BAD GEM MODULE AND TOLD US THAT IT WAS GETTING WET. THEY STATED TO DISCONNECT THE BATTERY WHEN THE VEHICLE IS PARKED. THESE...

BLOWN HEAD GASKET. AFTER PURCHASING THE VEHICLE W/55K, AT 69K THE HEAD GASKET BLEW. FORD REFUSED TO HELP, COST $1800 TO FIX IT. *NM

DT: WHILE DRIVING VEHICLE SUDDENLY HEARD A LOUD POPPING SOUND FOLLOWED BY A STRONG ODOR OF GASOLINE. STOPPED IMMEDIATELY, AND HAD VEHICLE TOWED TO FIRESTONE DEALER ,WHO INFORMED CONSUMER THE SPARK PLUGS BLEW OFF THE CYLINDER. THE THREADING AROUND THE SPARK PLUG WAS TOO THIN, THIS HAD A DEFECT. THEN, HAD TOWED TO FORD DEALER WHERE HAS A PREMIUM WARRANTY, BUT THIS WAS NOT COVERED UNDER WARRANTY. NO REPAIRS AS OF YET, IT IS STILL AT THE DEALER WITH OVER $3,000 WORTH DAMAGE TO THE ENGINE. *AK

I OWN A 2000 FORD EXPEDITION. I BOUGHT IT IN 2002 FROM MAGARITY FORD. IT HAD 21000 MILES ON THE VEHICLE. I HAVE NOT HAD ANY PROBLEMS WITH THE VEHICLE UNTIL THIS POINT. WAS DRIVING HOME ON 1/6/2004 ON RT 55 IN NEW JERSEY. THE ENGINE LIGHT CAME ON AND I CAME OFF THE HIGHWAY.THE TRUCK WAS SHIMMERING, AND I COULD HEAR A TAPPING NOISE. I STOPPED AT PEPBOYS AND THE MECHANIC WAS NICE ENOUGH TO LOOK AT THE VEHICLE. HOWEVER WHEN I TURNED IT ON IT WOULD NOT START. I HAD IT TOWED TO THER DEALERSHIP WHICH WAS 1/2 MILE AWAY. HOLMAN FORD IN GLASSBORO, NJ. I WAS TOLD THAT THE ENGINE NEEDED TO BE REPLACED. IT WOULD COST $5400 WHICH I DID NOT HAVE. THERE WAS OIL IN THE TRUCK AND I RECENTLY RECIEVED AN OIL CHANGE. I HAD ANOTHER MECHANIC LOOK AT IT AND HE SAID THERE...

MY VEHICLE WENT ON FIRE. I BELIEVE THIS IS A PROBLEM WITH FORD EXPEDITIONS. RECENTLY MY CRUISE CONTROL STARTED ACTING UP. AFTER READING ABOUT AN ONGOING INVESTIGATION ABOUT 200 FORD VEHICLES, I BELIEVE MINE IS THE SAME SITUATION. THE TRUCK WAS ARKED FOR MORE THAN 12 HOURS AND ALL OF A SUDDEN IT WAS ON FIRE. FORD DEFECT!!!!*AK

I DO NOT KNOW IF THIS IS THE PLACE TO VOICE THIS COMPLAINT, BUT SINCE I HAVE TRIED CONTACTING FORD VIA EMAIL WITH NO RESPONSE, I DID NOT KNOW EXACTLY WHERE ELSE TO TURN. WE HAVE A 2000 EXPEDITION. THE TIMING CHAINS WENT OUT AND WE REPLACED THEM. THE VEHICLE WAS DRIVING JUST FINE BEFORE WE REPLACED THEM--JUST NOISY. SO WE HAD THEM REPLACED. WE RECEIVED THE TRUCK BACK ON THE 12TH OF OCTOBER AND DROVE IT APPROXIMATELY 20 MILES (THAT'S BEING GENEROUS). IT WAS RUNNING FINE THEN SOUNDED LIKE YOU HIT A ROCK. THE ENGINE BLEW. LUCKY FOR US THAT IT WAS ON A SIDE ROAD AND NOT ON 465 WHICH WE DRIVE EVERY DAY. CAN YOU IMAGINE WHAT COULD HAVE HAPPENED AT 55+ MILES PER HOUR IN RUSH HOUR TRAFFIC? I BELIEVE THAT THIS IS A DEFECT IN THE ENGINE DESIGN BECAUSE I HAVE SINCE LEARNED THAT IT...

WHILE DRIVING 60 MPH CONSUMER HEARD A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE ENGINE BLEW OUT, AND NEEDED TO BE REPLACED. *AK

SPARK PLUG FAILURE AT 67,000 MILES, WELL BELOW MANUFACTURERS RECOMMENDATION OF 100K MILES. ALSO, SPARK PLUG COIL FAILURE. *AK

SPARK PLUG BLEW OUT WITH NO WARNING, BEFORE RECOMMENDED TIME TO BE REPLACED. THREADS ARE STRIPPED, HEAD ALONG WITH RELATED COMPONENTS NEEDS TO BE REPLACED. SPARKS WERE OBSERVED DIRECTLY AT FUEL INTAKE WHERE FUEL VAPORS WERE AT CONSIDERABLE DANGER OF BEING IGNITED. VEHICLE COULD HAVE EXPLODED WITH AN ENTIRE FAMILY INCLUDING 3 YOUNG CHILDREN RIDING IN VEHICLE AT TIME OF INCIDENT . *LA

ENGINE OIL LEAK. REPAIRED TWICE UNDER WARRANTY, THIRD TIME THEY COULDN'T FIND THE SAME LEAK. *LA

I BOUGHT A 2000 FORD EXPEDITION ,THE CAR IS LESS THAN THREE YEARS OLD AND THE ENGINE "SEIZED". MY VEHICLE IS OVER 36000 MILES SO IS NO LONGER COVERED BY WARRANTY, HOWEVER, THE CAR WAS REGULARLY MAINTAINED AND THE ENGINE ALWAYS HAD OIL. THE ENGINE SHUT OFF IN THE MIDDLE OF THE HIGHWAY WITH NO WARNING. I BELIEVE THIS VEHICLE IS DEFECTIVE AND DANGEROUS. I CONTACTED FORD AND THEY WERE UNWILLING TO HELP. I AM STUCK WITH A $6000 BILL TO REPLACE THE ENGINE.*JB

WHILE DRIVING ON HIGHWAY AT APPROXIMATELY 70 MPH THE VEHICLE'S GAUGES BEGAN FLASHING ERRATICALLY AND THE ENGINE STALLED IMMEDIATELY. DEALER DIAGNOSED THAT ENGINE HAD FAILED AND CONSUMER HAD TO REPLACE.

WHILE DRIVING, THE ENGINE STALLED WHICH CAUSED THE VEHICLE TO LOSE BRAKE POWER AND, POWER STEERING. A LOUD NOISE CAME FROM THE ENGINE. THE DEALER HAD BEEN NOTIFIED, HOWEVER THEY WERE UNABLE TO DUPLICATE THE PROBLEM MR *CB *JB

MOTOR MOUNT BOLT HAD BROKEN FROM VEHICLE, CAUSING ENGINE TO SHUTTER AND LOSE POWER. PLEASE PROVIDE FURTHER INFORMATION.*AK

I PURCHASED MY NEW EXPEDITION IN OCTOBER OF 2000. ON 5/16/02 I TOOK IT IN FOR MY SECOND ANNUAL INSPECTION (44,000 MILES). I HAD ALSO ASKED THEM TO LOOK INTO A SMALL OIL LEAK ON MY VEHICLE. I THOUGHT THAT PERHAPS THE PLUG WASNT FULLY TIGHTENED AT MY LAST OIL CHANGE. NEEDLESS TO SAY I WAS SHOCKED WHEN I WAS INFORMED THAT I HAVE A DEFECTIVE HEAD GASKET. I WAS EVEN MORE SHOCKED WHEN I WAS INFORMED THAT THE REPAIR ESTIMATE FOR THE HEAD GASKET WAS $2100! I WAS INFORMED THAT BECAUSE MY CAR WAS OUT OF WARRANTY THERE IS NOTHING THEY COULD DO. I ASKED THEM TO HOLD OFF ON THAT REPAIR UNTIL I COULD DO SOME RESEARCH REGARDING THIS ISSUE. I DID SOME RESEARCH AND FOUND THAT THERE HAVE BEEN 3 SERVICE BULLETINS ISSUED FOR THIS SPECIFIC PROBLEM. NUMEROUS COMPLAINTS REGARDING THIS ISSUE HAVE ALSO BEEN LOGGED ON...

ENGINE CAM BEARING ARE WORN. DEALER NOTIFIED, AND INFORMED CONSUMER THAT ENGINE NEEDED TO BE REPLACED. VEHICLE AT DEALER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

WHEN TRAVELING ON THE HIGHWAY, VEHICLE CUTS OFF WITHOUT PRIOR WARNING, ALSO LIGHTS ON DASHBOARD FLASHED ON AND OFF, DEALERSHIP WAS AWARE OF PROBLEM. *AK THE VEHICLE CUTS OFF WHILE DRIVING DUE TO CRANK SENSOR FAILURE. WHILE DRIVING RIGHT REAR WHEEL JINGLES. VEHICLE CUTS OFF WHILE ACCELERATING, AFTER STOPPING THE VEHICLE RESTART AND IDLES UP TO 1100 RPM AT TIMES. CONSUMER STATES TRANSMISSION SLIPS, THE DASH WAS RATTLING AND THE PEDAL BUTTON ON THE LEFT STEERING WHEEL WAS INSTALLED BACKWARDS. *YH

NEW VEHICLE SUBMITTED TO DEALER FOR ENGINE OIL LEAK WARRANTY SERVICE AT ODOMETER 3973, 9402, 9565, AND 11,864. ALL MAJOR GASKETS REPLACED IN COURSE OF WARRANTY SERVICE. ON FOURTH WARRANTY SERVICE VISIT, PROBLEM WAS DIAGNOSED AS WARPED BLOCK. REMANUFACTURED ENGINE INSTALLED. REQUESTING DISPUTE SETTLEMENT BOARD HEARING FOR RELIEF IN THE FORM OF FULL REFUND BASED ON BREACH OF PURCHASE CONTRACT FOR NEW VEHICLE AND SUBSTANTIAL IMPAIRMENT OF MARKET VALUE RESULTING FROM INSTALLATION OF REMANUFACTURED ENGINE. SUBMITTED AS REPLACEMENT FOR ODI ID: 753031 FOR BETTER CLARITY OF PROBLEM.*AK

GASKET FAILED CAUSING OIL TO LEAK FROM THE VEHICLE. NLM

INJECTOR IN CYLINDER #5 WAS HELD WIDE OPEN WHICH ALLOWED RAW FUEL TO SATURATE CATALYTIC CONVERTER, WHICH ENDED UP RUNNING OUT OF EXHAUST. DEALERSHIP HAS EXAMINED VEHICLE, AND WAS GOING TO REPLACE ENGINE BLOCK WITHOUT RENEWING ANY WARRANTY ON VEHICLE. *AK CONSUMER IS REQUESTING THAT FORD BUY BACK THE VEHICLE, CONSUMER STATED THAT WHILE DRIVING, THE STEERING WHEEL BEGAN TO SHIMMY AND THE CHECK ENGINE LIGHT ILLUMINATED ON AND OFF SEVERAL TIMES, MECHANIC INFORMED CONSUMER THAT VEHICLE COULD HAVE BLOWN UP DUE TO THE BENT PISTON ROD AND STATED THAT ONCE THE INJECTOR STICKS OPEN, THE ENGINE COMPUTER DOES NOT SHUT THE ENGINE DOWN BUT LEANS TO OTHER CYLINDERS OUT AND KEEPS POURING THE FUEL TO THE STUCK INJECTOR STRAIGHT IN THE CATALYTIC CONVERTER, CONSUMER IS ALSO ANGRY BECAUSE A REBUILT ENGINE IS BEING PUT IN THE VEHICLE INSTEAD OF A NEW ENGINE. *SLC

ON ENGINE START, AT 1,935 MILES THE OIL PRESSURE GAUGE DROP TO ZERO AND THE "ENGINE OIL" LIGHT ILLUMINATED. I TURNED THE ENGINE OFF TO CHECK THE OIL LEVEL ON THE DIP STICK. THE DIP STICK INDICATED BELOW "MIN". I POURED 3 QTS. OF OIL IN THE ENGINE AND DROVE TO THE NEAREST DEALER TO HAVE SERVICE. THE DEALER WAS NOT FULLY STAFFED SINCE IT WAS A SATURDAY. I ADDED 2 MORE QTS. OF OIL AND DROVE HOME. I RETURNED TO THE DEALER ON MONDAY FOR A LEAK CHECK. THE SERVICE TECHNICIANS FOUND NO LEAKS BUT ADDED ANOTHER 3 QTS. OF OIL. I WAS TOLD TO WATCH THE OIL LEVEL AND THAT FORD COULD DO NOTHING UNTIL THE ENGINE IS "BROKEN IN" WHICH IS AT 7,500 MILES. 1 DAY LATER I RETURNED TO THE DEALERSHIP WITH A "BLUISH/GRAY" SMOKE COMING FROM THE TAILPIPE. THE ASST. SERVICE MANAGER SAID THAT WAS...