2000 FORD EXPEDITION Visibilitywindshield Problems

THERE IS A DEFECT WITH THE INSTALLATION OF THE WINDSHIELD THAT CAUSES WATER IN ENTER THE CAB. UPON ENTRY, THE WATER GOES INTO THE GEM MOD AND FUSE PANEL OF THE SUV. THIS SHORTS THE SYSTEM - AT ONE POINT YOU MAY ENCOUNTER THE HEATER TURNING ON WITHOUT THE KEY IN THE IGNITION. HERE IS A SPECIAL NOTICE SENT BY FORD IN 2002 REGARDING THIS PROBLEM: *FORD SPECIAL MESSAGE #15773 VARIOUSELECTRICALCONDITIONS RESULTING FROM WATER INTRUSION INTO THE GEM/CJB SOME 1997-2002 EXPEDITION AND 1998-2002 NAVIGATOR VEHICLES MAY EXHIBIT VARIOUS UNUSUAL ELECTRICAL CONDITIONS, INCLUDING BUT NOT LIMITED TO: XXXXX XXXXX REAR BLOWER OR EATC STAYING ON WITH KEY OUT OF THE IGNITION, RADIO STAYING ON AFTER DOORS OPENED AND KEY OUT OF IGNITION, WIPER CIRCUIT FAILURE CODES, AND MULTIPLE SYSTEM WARNING LIGHTS WITH 'SHORT TO POWER' OR 'LOW BATTERY VOLTAGE' DTCS. THESE SYMPTOMS MOST OFTEN OCCUR AFTER A RAIN OR SNOW. THIS...

I HAVE A 2000 FORD EXPEDITION THE PAST 3 DAYS WE HAVE HAD HARD RAINS. I WENT OUT TO MY CAR AND FOUND THAT THE FLOOR ON BOTH THE DRIVERS SIDES AND PASSENGER SIDE OF THE SUV WAS FLOODED. MY RADIO WAS ON THE CAR WAS NOT. THE DASH LIGHT WERE GOING CRAZY. I STARTED THE CAR TO MOVE IT SO THAT I COULD GET IT NEAR AN OUTLET TO USE THE WET VAC TO REMOVE THE WATER AND THE WIPERS WOULD NOT WORK. I REMOVED THE WATER FROM THE FLOORS AND WHEN I WENT TO MOVE MY EXPEDITION IT WOULD NOT START IT SEEMS THAT IT IS LEAKING FROM THE WINDSHIELD. I NOTICED THAT THERE ARE ALOT OF COMPLAINTS ON WATER LEAKAGE ON EXPEDITIONS. NOW I AM WORRIED THAT THE WATER MAY HAVE SHORTED OUT THE ELECTRICAL SYSTEM. *KB

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THE WINDSHIELD IS LEAKING, CAUSING WATER TO GET INTO THE ELECTRICAL SYSTEM AND MALFUNCTIONING EVERY ELECTRICAL COMPONENT. THE CONTACT CALLED THE MANUFACTURER REGARDING THE WINDOW WHO THEN CONTACTED THE DEALER, WHO STATED THE WINDOW SEAL AND COMPUTER NEEDS TO BE REPLACED. THE DEALER ALSO INFORMED THE TO CONTACT THEY CAN ONLY REPAIR A COMPONENT AT NO COST UNDER A RECALL. THE CONTACT STATED THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS BECAUSE THIS IS A KNOWN SAFETY ISSUE WITH THIS YEAR MAKE AND MODEL. THE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED WATER WAS LEAKING INTO THE VEHICLE FROM THE FRONT WINDSHIELD, ONTO THE INSTRUMENT PANEL AND INTO THE COMPUTER SYSTEM. THE FAILURE WOULD CAUSE THE COMPUTER CHIPS TO MALFUNCTION AND THE VEHICLE WOULD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER SEVEN TIMES FOR THE FAILURE. THE DEALER REPLACED THE DAMAGED COMPUTER CHIPS NINE TIMES BEFORE DISCOVERING THE FAILURE WAS CAUSED BY THE LEAKING WINDSHIELD. THE WINDSHIELD WAS NOT REPLACED. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 98,000. UPDATED 11/24/10 *CN UPDATED 11/20/10

2000 FORD EXPEDITION EXPERIENCING ELECTRICAL PROBLEMS FROM A LEAK IN THE FRONT WINDSHIELD.*DT THE LEAK WAS INTERNAL CAUSING WATER DAMAGE TO THE FUSE BOX AND CORROSION ON THE GEM MODULE. *JB

WINDSHIELD LEAKS ONTO FUSE BOX & GEM MODULE, CAUSING ENGINE TO CUT OFF WHILE MOVING CREATING DANGEROUS SITUATION. *TR

IT STARTED THIS SUMMER IT HAD RAINED PRETTY GOOD WHILE I WAS OUT I CAME HOME A FEW HOURS LATER I GOT INTO THE VEHICLE I HEARD SOMETHING THAT SOUNDED LIKE SOMETHING WAS FRYING DOWN CLOSE TO THE BRAKES BUT I DIDN'T KNOW WHERE ,I COULD HEAR IT AND SMELL IT,I THOUGHT THE TRUCK WAS GOING TO BLOW UP,SO I DIDN'T DRIVE IT FOR A WHILE,(SCARED )ABOUT A WEEK OR SO I DECIDED TO TRY IT AND EVERYTHING WAS FINE,BUT AS SO AS IT RAINED IT STARTED ALL OVER AND I WENT ON WITH IT LIKE THAT UNTIL NOVEMBER WE WERE PLANNING A TRIP FOR THANKSGIVING AND WANTED TO BE SAFE ON THE ROAD ,SO WE PUT IT IN THE SHOP,NOVEMBER 2009 ,THE DISTRIBUTION BOX (PDB),ELECTRONIC MODULE(GEM)/FUSE BOX SHORTAGE,A GOOD WEEK LATER IT RAINED AND THE RADIO WENT OUT ,THEN THE TRUCK WOULDN'T START, I GOT TOAD HOME,CONTACTED THE MECHANIC,TO...

2000 EXPEDITION WINDSHIELD WAS REPLACED IN NOVEMBER LEAK CAUSED VEHICLE TO DO CRAZY THINGS LIKE TRY TO START WHEN I TURNED THE HEADLIGHTS ON WITH KEY OUT OF IGNITION AND HAD A BURNING SMELL. THIS MORNING VEHICLE WOULDN'T START AFTER RAIN. AFTER JUMP STARTING VEHICLE OVERDRIVE LIGHT ON GEARSHIFTER HANDLE WAS BLINKING AND VEHICLE WOULDN'T GO INTO GEAR FEELS LIKE YOU'RE DRIVING WITH BRAKES ON. NO PROBLEMS MOVING IN REVERSE. PROBLEM STARTED OUT OF NOWHERE, ALSO LIGHTS FLICKER WHEN TRIED TO JUMPSTART. CONNECTED CABLES WOULDN'T START LIGHTS WENT DEAD REPOSITIONED CABLES LIGHTS CAME ON AFTER DOING THIS FOR OVER AN HOUR CAR FINALLY STARTED WITH THE ABOVE NOTED PROBLEMS. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING 45 MPH THE DAY AFTER A HEAVY RAINSTORM, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AFTER APPROXIMATELY 100 FEET, THE VEHICLE FINALLY CAME TO A STOP. THE CONTACT PROCEEDED TO HIS DESTINATION AND APPLIED THE BRAKES AGAIN, BUT THE SAME FAILURE RECURRED. WHILE DRIVING ON TWO SEPARATE OCCASIONS ON THE SAME DAY, TWO OTHER VEHICLES PULLED OUT IN FRONT OF HIM, WHICH ALMOST CAUSED A CRASH. THE FOLLOWING DAY, HE CALLED THE DEALER AND INFORMED THEM OF THE FAILURES AND WAS ADVISED TO BRING IN THE VEHICLE FOR REPAIR. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS DUE TO WATER INTRUSION THROUGH THE WINDSHIELD, WHICH VOIDED THE WARRANTY. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST OF THE WINDSHIELD DEFECT. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 96,000.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. AFTER A HEAVY RAINSTORM, WATER SEEPS IN THROUGH THE FRONT WINDSHIELD DOWN INTO THE ELECTRONIC FUSE BOX. THE VEHICLE HAD TO BE TOWED TO A MECHANIC AND THEY REPLACED THE ELECTRONIC FUSE BOX AND WINDSHIELD AT THE COST OF $1,400. AFTER ANOTHER HEAVY RAINSTORM, THE VEHICLE WOULD NOT MOVE FORWARD OR INTO REVERSE. THE VEHICLE WAS TOWED TO THE MECHANIC AGAIN AND THEY STATED THAT THE ENGINE NEEDED TO BE REPLACED. NHTSA CAMPAIGN ID NUMBER 01V258000 (VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR) WAS REFERENCED. THE FAILURE MILEAGE WAS 143,000.

WINDSHIELD LEAKS WATER ON TO GEM MODULE AND FUSE BOX. AFTER RAIN OR SNOW VEHICLE WILL TRY TO START WHILE ALREADY RUNNING WIPERS, RADIO, DOOR LOCKS, POWER WINDOWS, LIGHTS FLASHERS WILL NOT WORK. DUMMY LIGHTS ON DASH WILL COME ON THAT WATER LEVEL LOW, NO OIL PRESSURE AND LOW BATTERY. NOW IT WILL NOT SHIFT OUT OF PARK. FILED A FORMAL COMPLAINT THREE MONTHS AGO WITH FORD MOTOR COMPNY AND THEY HAVE YET TO ACKNOWLEDGE THAT I EVER FILED REPORT. *TR

WE RECENTLY HAD A SPECIALIST INSPECT THE 2000 EDDIE BAUER FORD EXPEDITION BECAUSE OF REPEATED ELECTRICAL PROBLEMS. HE FOUND A TECHNICAL SERVICE BULLETIN FOR FORD ON THE FAILURE OF WINDSHIELD SEALS. HE FURTHER ADVISES THAT THE REPAIRS WILL BE IN EXCESS OF $1000. WE HAVE EXPERIENCED FAILURE OF THE VEHICLES ELECTRIC SYSTEM AS OUTLINED ON AT LEAST 5 SEPARATE OCCASIONS. ALL TIMES WERE PRECEDED BY MOISTURE. THE INTERIOR LIGHTS MALFUNCTIONED, THE WINDSHIELD WIPERS STOPPED, THE BLOWER MOTOR WAS ON HIGH WITH IGNITION OFF, THE RADIO SHUTS OFF, THE INTERIOR DASH LIGHTS REMAINED ON, ETC. I HAVE HAD MY MECHANIC REPLACE SEVERAL ITEMS INCLUDING THE FUSES AND RELAYS FOR THE ELECTRONICS. *TR

I HAVE A 2000 FORD EXPEDITION THAT HAS AN ELECTRICAL PROBLEM. I HAVE RESEARCHED ONLINE AND DISCOVERED MANY OTHERS WITH SIMILAR PROBLEMS. IT IS APPARENTLY DUE TO A WINDSHIELD LEAK THAT CAUSES THE GEM MODULE TO SHORT OUT. THIS FIRST HAPPENED TO ME A MONTH AFTER I PURCHASED THE VEHICLE IN FEBRUARY 2007. THE VEHICLE WOULDN'T START, DASH CLICKING NOISE , LOCKS UNLOCKING AND LOCKING CONTINUOUSLY, LIGHTS ON DASH WOULDN'T GO OUT, AFTER KEY IS REMOVED DASH INFO LIGHTS STILL ON. WHEN VEHICLE DID START RADIO WOULDN'T WORK AND BY THE WAY IT WAS RAINING/ICY. THIS PROBLEM HAS OCCURRED SEVERAL OTHER TIMES. WINDSHIELD WIPERS NOT WORKING PROPERLY, RADIO NOT WORKING ALL PROBLEMS HAPPEN ONLY WHEN IT IS RAINING. I PERSONALLY CANNOT AFFORD THE $1,000. OR SO DOLLARS IT IS APPARENTLY GOING TO COST TO FIX THIS PROBLEM, WHICH IS OBVIOUSLY A FACTORY DEFECT. I HAVE 4 CHILDREN AND HAVE COME...

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE WINDSHIELD LEAKED WHEN IT RAINED AND CAUSED AN ELECTRICAL FAILURE IN THE GEM BOX. THE FAILURE MILEAGE WAS 85,000. THE ENGINE REMAINED ON AFTER THE CONTACT REMOVED THE KEY FROM THE IGNITION. THE DEALER REPLACED THE GEM BOX. HOWEVER, THEY DID NOT RESEAL THE WINDOWS TO PREVENT IT FROM LEAKING. THE CURRENT MILEAGE WAS 97000. *AK

I OWN A 2000 FORD EXPEDITION. WITHIN THE LAST MONTH, I WOULD TURN THE KEY TO CRANK MY TRUCK AND NO SOUND. NOTHING WOULD TURN ON. THE ELECTRICAL, TOTALLY DEAD. I WOULD JUMP IT OFF AND IT RAN FINE FOR 2 DAYS AND THEN THE SAME WOULD HAPPEN AGAIN. I HAVE RESEARCHED THIS PROBLEM AND HAVE FOUND THAT A LEAKING WINDSHIELD IS THE PROBLEM. IT IS LEAKING AND CAUSING MY GEM MODULE AND FUSE BOX TO GET WET. THIS CAN CAUSE A FIRE AS EVERYONE KNOWS AS WELL AS UNWANTED ELECTRICAL ACTIVITY WHEN THE TRUCK IS UNATTENDED. IT IS ALSO AFFECTING MY RADIO WHICH WILL NOT TURN ON THEN TURN ON BY ITSELF. THIS IS A MANUFACTURING DEFECT AND I HAVE READ WHERE MANY EXPEDITION OWNERS ARE HAVING THE SAME PROBLEM WITH WINDSHIELD LEAKAGE CAUSING NO STARTS AND ELECTRICAL PROBLEMS. THIS SHOULD BE FIXED AT FORDS EXPENSE CONSIDERING IT WAS...

MY 2000 FORD EXPEDITION HAS CAUSED US NUMEROUS HEADACHES AND NEAR ACCIDENTS AS A RESULT OF RAIN ENTERING THE VEHICLE DUE TO A DEFECTIVE WINDSHIELD INSTALLATION. ONCE THE RAIN WATER ENTERS THE DRIVER SIDE DASH PANEL ( UNDERSIDE ) AND COMES IN CONTACT WITH ELECTRICAL COMPONENTS MOUNTED THERE, NUMEROUS FAILURES OCCUR, SUCH AS : WINDSHIELD WIPERS QUIT WORKING, INTERIOR AND DASH PANEL LIGHTS FLASH ON AND OFF, AND EVENTUALLY QUIT WORKING. THE SAFETY SWITCH WHICH ALLOWS THE VEHICLE TO BE PLACED IN DRIVE WHILE DEPRESSING THE BRAKE ALSO FAILS ONCE THE VEHICLE IS TURNED OFF. THESE PROBLEMS ARE NOT JUST A NUISANCE, BUT A SAFETY HAZARD, AND AFTER SPEAKING TO OTHER EXPEDITION OWNERS AND READING NUMEROUS COMMON STORIES OF THE SAME PROBLEM, I FEEL THAT THIS IS A MANUFACTURER'S DEFECT AND SHOULD BE RECALLED AND REPAIRED ACCORDINGLY. IN CLOSING I WOULD LIKE TO STATE THAT MY WIFE WAS DRIVING ON...

ON JANUARY 16, 2007 MY WIFE DROVE OUR 2000 EDDIE BAUER EXPEDITION TO WORK AS USUAL PARKED N A COVERED PARKING GARAGE AND WENT TO WORK. AT THE END OF THE DAY SHE ATTEMPTED TO START HER CAR AND IT WAS TOTALLY DEAD AND WOULD NOT START. SHE THEREFORE HAD TO GET JUMP STARTED IN ORDER TO GET HOME. ON 1-17-07 I TOOK THE VEHICLE TO A CERTIFIED FORD SERVICE DEPARTMENT AND HAD THEM EVALUATE AND DIAGNOSE THE PROBLEM. SEEMS THAT THE GEM AND CJB WERE WATER DAMAGED AND CREATING SIGNIFICANT ELECTRICAL SHORTS THROUGHOUT THE VEHICLES OPERATING SYSTEM. WHEN THE CAR WAS TURNED OFF THE FAN MOTOR WOULD ACTUALLY CONTINUE TO BLOW EVEN WITH THE KEYS OUT OF THE IGNITION. ALSO THE CAR AT TIMES WOULD NOT TURN OFF WITH THE KEY. YOU CAN TAKE THE KEY OUT OF THE IGNITION AND THE CAR WOULD STILL RUN. ANYWAY, THE DEALER...

WATER IS LEAKING IN FROM THE WINDSHIELD ACCORDING TO THE DEALERSHIP. THE WATER IS THEN ENTERING THE VEHICLE AND AFFECTING THE FUSE BOX AND THE GEM MODULE. IT DOES VERY WEIRD THINGS TO THE ELECTRICAL COMPONENTS OF THE VEHICLE, WINDSHIELD WIPERS QUIT WORKING WHILE DRIVING DOWN THE ROAD, RADIO TURNS OFF ONCE VEHICLE IS PUT IN DRIVE, RUNNING LIGHTS DO NOT WORK, BATTERY DIES, JUST TO NAME A FEW THE LIST GOES ON AND THE CONSEQUENCES ARE VERY DANGEROUS IN SOME CASES. HAVE YOU EVER BEEN DRIVING DOWN INTERSTATE IN THE RAIN AND THEN ALL OF A SUDDEN HAVE NO WIPERS. LET ME TELL YOU NOT GOOD. THE DEALER WANTS AN ARM AND A LEG TO FIX IT, MONEY I DO NOT HAVE AFTER SPENDING 15K ON A VEHICLE. SO HELP ME ANYTHING HAPPENS AS A RESULT OF THE FAILURE AND THERE WILL BE A LAWSUIT. TAKE A LOOK AROUND...

DT*: THE CONTACT STATED THE AIR CONDITIONER BLOWER DID NOT DEACTIVATE, WHILE THE VEHICLE WAS ON OR OFF. THE DEALERSHIP DETERMINED THE WINDSHIELD HAD A LEAK, CAUSING WATER TO GET INTO THE GEM MODULE. THE WINDSHIELD AND GEM MODULE NEEDED TO BE REPLACED.

DT*: THE CONTACT STATED THE WINDSHIELD LEAKS WHEN IT RAINS AND WATER GETS INTO THE FUSE BOX CAUSING THE DASH LIGHTS TO ILLUMINATE. ALSO, THE FUSE BOX IS CORRODED AND RUSTING. THE DEALER DETERMINED THERE IS NO RECALL FOR THIS PROBLEM.

2000 EXPEDITION HEATER BLOWER HAD TO BE MANUALLY TURNED OFF AFTER KEYS WERE REMOVED FROM IGNITION. WHEN ATTEMPTED TO START VEHICLE IT WOULD NOT START. *TS THE FUSE BOX WAS RUSTED, CORRODED AND FULL OF WATER. THIS WAS THE RESULT OF THE WINDSHIELD NOT BEING SEALED PROPERLY. *NM

DT*: THE CONTACT STATED IN WET CONDITIONS THE VEHICLE SURGES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP NUMEROUS TIMES FOR INSPECTION. THE DEALERSHIP DETERMINED THE WINDSHIELD WAS NOT THE CORRECT SIZE FOR THE VEHICLE WHEN MANUFACTURED. THE MANUFACTURER WAS ALERTED.

DT: CONTACT STATED WHENEVER IT RAINED 2000, FORD, EXPEDITION LEAKED RAIN WATER. THE RAIN LEAKED IN ON RIGHT SIDE OF THE VEHICLE AROUND THE BOTTOM OF THE WINDSHIELD ABOVE THE DRIVER'S DASHBOARD. THE LEAK SHUT OFF THE ELECTRICAL SYSTEM. THIS WAS OBSERVED ON JANUARY 2, 2006. THE VEHICLE HAS BEEN TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE CONTACT WAS TOLD BY THE MECHANIC THAT THIS WAS A MANUFACTURING DEFECT.*AK

ON SEVERAL OCCASIONS MY LIGHTS AND/OR RADIO AND OR WIPERS WOULD GIVE OUT DURING A RAIN STORM. ON THE LAST OCCASION MY CAR'S ELECTRICAL SYSTEM FAILED AND MY CAR TURNED OFF. I COULD NOT RE-START UNTIL NEXT DAY. I TOOK IT TO THE DEALER AND THEY TOLD ME THAT WATER HAD SEEPED IN BETWEEN THE WINDSHIELD AND INTO THE ELECTRICAL CONTROL BOX. THEY WOULD HAVE TO REMOVE THE WINDSHIELD, RE-CAULK IT, REPLACE THE GEM AND FUSE BOXES AND THAT WOULD TAKE CARE OF THE PROBLEM. THIS WAS NOT UNDER WARRANTY BECAUSE THE CAULKING HAD DETERIORATED WITH TIME AS IT NORMALLY WOULD. I'VE HAD CARS FOR 10 TO 15 YEARS AND THE CAULKING ON THE WINDSHIELD HAS NEVER DETERIORATED LIKE THIS. THE SUV IS ONLY 4 YRS OLD ANYWAY. MY PROBLEM WAS COMPOUNDED BY THE FACT THAT THEY BROKE THE WINDSHIELD DURING THIS PROCESS AND I WAS STUCK FOR THAT COST...

I NOTICED WHEN EVER I DROVE MY CAR IN THE RAIN WATER WOULD LEAK ON MY RIGHT LEG AND FOOT, MY WIPERS, RADIO AND CLOCK WOULD STOP WORKING AND I HEARD A SIZZLING NOISE IN THE LEFT DASH AREA. I ALSO WAS UNABLE TO USE MY KEYLESS REMOTE, THE ALARM WOULD GO OFF EVERY TIME. I BROUGHT MY 2000 EXPEDITION TO HAYWARD FORD TO HAVE THEM CHECK AND REPAIR THE PROBLEM IN MARCH OF THIS YEAR. THEY COULD NOT FIND ANYTHING LEAKING, OR THE SIZZLING NOISE I HEARD IN THE DASH, HOWEVER THEY DID TELL ME THERE WAS A DAMAGED JUNCTION BOX AND KEPT MY CAR FOR 5 DAYS (THEY WERE WAITING FOR THE PARTS TO COME), WELL AFTER 5 DAYS OF HAVING A RENTAL THAT ALSO COST ME MONEY, I WENT AND PICKED UP MY EXPEDITION. IT MADE NO SENSE TO ME TO HAVE THE JUNCTION BOX REPLACED SINCE...

DT: CONTACT STATES WHENEVER IT WAS RAINING THE WINDSHIELD WIPERS WOULD NOT WORK, ONLY AFTER THE VEHICLE WAS STOPPED. ALSO, THERE WERE ELECTRICAL ISSUES; THE DOORS WOULD UNLOCK WHILE DRIVING, AND RADIO WENT ON AND OFF. WHILE DRIVING THE CONTACT NOTICED WHILE IT WAS RAINING THE WINDSHIELD WOULD LEAK. THE WINDSHIELD AND PART OF THE ELECTRICAL SYSTEM WERE REPLACED.*AK

I OWN 2000 FORD EXPEDITION. JUST FOUND OUT THE WINDSHIELD IS LEAKING, CAUSING WATER TO GET INTO FUSE BOX AND GEM MODULE UNDER DASH CAUSING MAJOR ELECTRICAL PROBLEMS. THE 4-WAY FLASHERS CAME ON WHILE DRIVING; THE BLOWER STAYED ON EVEN AFTER REMOVING THE KEY FROM THE IGNITION, ETC. HAD WINDSHIELD REPLACED TODAY AND IT ONLY TOOK 1 MINUTE TO BREAK THE SEAL. THE REPAIR GUY SAID IT SHOULD TAKE AT LEAST 20 MINUTES AND THAT IF WE WOULD HAVE HAD A WRECK THE WINDSHIELD WOULD HAVE FALLEN OUT. I'VE DONE EXTENSIVE RESEARCH ON INTERNET AND FOUND THIS IS A VERY COMMON PROBLEM IN 1997-2001 F150'S, EXPEDITIONS AND NAVIGATORS, BUT ESPECIALLY THE 2000 EXPEDITION. THE SEAL USED BY FORD AROUND THE WINDSHIELD DRY ROTS CAUSING THE LEAK. SERVICE MAN AT FORD ACKNOWLEDGED THE PROBLEM BUT SAYS NO RECALL HAS BEEN ISSUED. *AK

WATER LEAKED INTO THE VEHICLE THROUGH THE WINDSHIELD SEAM, AND SHORTED OUT THE ELECTRICAL SYSTEM. WIPERS WERE INOPERATIVE. THE VEHICLE WOULD NOT START. THE FUSE BOX AND THE WINDSHIELD HAD TO BE REPLACED.

CONSUMER STATES THAT WHILE DRIVING AND NO WARNING THERE IS WATER LEAKING FROM THE WINDSHIELD INTO THE INSTRUMENT PANEL CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED TS

WHILE DRIVING SUN ROOF SHATTERED. ALSO, ON ANOTHER OCCASION SIDE WINDOW SHATTERED. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

CONSUMER STATES THAT WHEN STARTING UP THE VEHICLE THE VEHICLE TENDS TO JUMP FORWARD AND/OR JUMP INTO NEUTRAL WHEN COMPING TO A STOP. ON SEPERATE OCCASIONS THE VEHICLE HAS HIT OTHER VEHICLES AND ALSO HAS HIT PEOPLE WALKING IN FRONT OF THE VEHICLE. NLM DEALER REPLACED TRANSMISSION BUT PROBLEM STILL EXISTS. ON A SEPARATE OCCASION, THE VEHICLE WAS INVOLVED IN AN ACCIDENT, CAUSING THE AIR BAG LIGHT TO COME ON. CONSUMER STATES THERE IS A BAD ODOR COMING FROM THE A/C UNIT. DEALER DRAINED A/C UNIT, BUT PROBLEM STILL EXIST. CONSUMER STATES THAT REAR WINDOW IS LEAKING. *TT