2004 TOYOTA SIENNA Structure Problems

2004 SIENNA LE PASSENGER SIDE POWER SLIDING DOOR. CABLE WHICH PULLS DOOR OPEN HAS SNAP. DOOR IS NO LONGER OPERABLE. IT CANNOT BE OPENED EITHER ELECTRONICALLY OR MANUALLY. POSES HAZARD AS OCCUPANTS CANNOT EXIT OUT ONTO CURBSIDE. *TR

SPOT WELD ON DRIVERS DOOR IS FAILING. ONCE THIS WELD COMPLETELY FAILS THE DOOR WILL SWING FREELY AND COULD SLAM ON ME OR MY CHILDREN. CONTACTED THE DEALER AND TOYOTA AND THERE IS AN EXTENDED WARRANTY FOR 5 YRS OR 100,000 MILES. MY VAN IS 6 YEARS OLD AND NOT COVERED. THIS PROBLEM STARTED AFTER THE WARRANTY WAS OVER. TOYOTA WILL CHARGE $900 TO CORRECT THIS PROBLEM. THIS SHOULD BE A RECALL THERE ARE HUNDREDS OF THOUSANDS OF SIENNAS WITH THIS ISSUE AND IT IS A KNOWN MANUFACTURERS DEFECT. *TR

ON MY 2004 TOYOTA SIENNA MINIVAN THE REAR HATCHBACK GAS STRUTS HAVE FAILED. THIS IS A DANGEROUS SITUATION THAT COULD EASILY GET A SMALL CHILD KILLED. I ALMOST HAD THIS HAPPEN WHEN MY 5 YEAR OLD WAS HELPING TO GET GROCERIES OUT WHILE I WAS HOLDING THE GATE OPEN IT SLIPPED AND CAME CRASHING DOWN. LUCKILY HE HAD JUST MOVED AND IT MISSED HIM. THESE GAS STRUTS ARE A RECALL ITEM ON THE POWER OPERATED LIFT GATES, WHY AREN'T THEY ON THE MANUAL ONES. AND THE COST OF REPLACEMENTS IS TERRIBLE, $180/EA. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

THE SLIDING DOORS ON OUR TOYOTA SIENNA ARE DEFECTIVE. THEY STICK SHUT FREEZE IF THE TEMPERATURE GETS LOW ENOUGH OR THERE IS ENOUGH MOISTURE. IT'S HARD TO PREDICT THE CIRCUMSTANCE BUT THE FACT IS, OUR KIDS CANNOT GET IN OR OUT OF THE VAN AND WE HAVE HAD TO DRIVE IT ANYWAY, THREE DIFFERENT BEEPERS GOING OFF ALL THE WAY. I HAVE READ THAT THIS IS A COMMON PROBLEM FOR THE SIENNA AND YET TOYOTA CONTINUES TO DO NOTHING ABOUT IT, DENYING IT, IN FACT. IF WE WERE IN AN ACCIDENT, AND HAD TO ESCAPE QUICKLY, ONLY THE DRIVER AND PASSENGER COULD ESCAPE. WHEN SIDE DOORS ARE FROZEN SHUT, KIDS HAVE TO EXIT THROUGH THE BACK DOOR WHICH IS ALSO DANGEROUS. I KNOW MY 2004 IS PAST THE WARRANTY, BUT IF THIS IS A COMMON A PROBLEM AS I HAVE READ, SHOULDN'T THERE BE A RECALL? *TR

2004 TOYOTA SIENNA. THE DRAIN SYSTEM PLUGGED IN MY MOONROOF WITH DEBRIS AFTER A HEAVY RAIN. FLOODED THE HEADLINER AND WENT INTO THE DASH AND SCREWED UP THE ELECTRICAL SYSTEM. WINDOWS STOPPED WORKING, ALARM WAS GOING OFF IN THE MIDDLE OF THE NIGHT. ON THE HIGHWAY, THE DRIVERSIDE SLIDING DOOR STARTED OPENING ON IT'S OWN WHERE MY ONE YEAR OLD CHILD'S SITS AT 65 MPH. IT IS A FLAWED DESIGN WITH NO SCREEN PROTECTION OF ANY KIND TO KEEP DEBRIS OUT. IT PLUGS OFF AND FILLS THE VEHICLE WITH WATER SHORTING OUT THE ELECTRICAL SYSTEM. *TR

THE AUTOMATIC SLIDING DOORS ON OUR 2004 TOYOTA SIENNA WILL NOT OPEN OR CLOSE. THIS LOCKS MY CHILDREN IN THE BACK WITHOUT SAFE ACCESS TO EXIT. *TR

2004 TOYOTA SIENNA POWER SLIDING DOOR CABLE SNAPPED AND RUINED SLIDING DOOR MOTOR. DEALER TO CHARGE $2000 FOR FIX. 1 YEAR EARLIER PASSENGER DOOR CABLE SNAPPED. SAME ISSUES. *TR

PASSENGER SLIDING DOOR CABLE CORRODED AND SNAPPED. *TR

I AM THE ORIGINAL OWNER OF A 2004 TOYOTA SIENNA. THE DASHBOARD IS FULL OF HAIRLINE CRACKS. THEY STARTED ON THE SIDES NEAR THE A/C VENTS, TRAVELING TOWARDS THE CENTER OF THE DASH. FIRST APPEARED IN 2007. NOW THE DASHBOARD IS COVERED WITH CRACKS. TOOK IT TO THE DEALER AND COMPLAINED THAT IT WAS A DEFECT. SERVICE DEPT DIDN'T SEEM TO WANT TO DEAL WITH IT. FINALLY THEY TOOK PICTURES THEN SAID THEY WOULD HAVE TO SEND THE PICTURES OFF AND THEY WOULD GET BACK TO ME, WHICH THEY NEVER DID. CALLED THE SERVICE DEPT AND THEY DISMISSED ME SAYING IT WAS NOT COVERED. I DON'T THINK THEY EVER SENT THE PICTURES IN. THE CRACKS GET WORSE EVERY WEEK - LONGER, AND NEW ONES APPEAR. THIS IS CLEARLY A DEFECT. THERE WERE NO EVENTS THAT TOOK PLACE TO CAUSE THIS, NO CRASH, NO FIRE. THE AUTOMOBILE IS WELL MAINTAINED. THIS...

POWER SLIDING DOOR ON DRIVER'S SIDE IS STUCK OPEN. NO WAY TO CLOSE IT MANUALLY. UNSAFE TO DRIVE. *TR

WE PURCHASED A 2004 TOYOTA SIENNA VAN. THE DRIVER'S DOOR HINGE HAS FAILED CAUSING THE ENTIRE DOOR TO HAVE TO BE REPLACED TO THE TUNE OF ABOUT 3K. IN SEARCHING THE INTERNET, 600,000 VEHICLES HAD THE SAME DEFECT TRACING BACK TO AN INDIANA FACTORY WELDING ISSUE. TOYOTA HAS NOT ISSUED A RECALL AND THE DEALERSHIP IS TELLING US IT IS OUT OF WARRANTY. HTTP://WWW.ALLWORLDAUTO.COM/COMMENTS/2004_TOYOTA_SIENNA_COMMENTS_AND_COMPLAINTS_C202-6966-2004-303-1.HTML THERE ARE ALSO YOUTUBE VIDEOS DEPICTING THE SAME ISSUE. *TR

THE PASSENGER SIDE SLIDING DOOR ON 2004 TOYTA SIENNA IS NOT CLOSING. OUT IN COLD AND RAIN WITH KIDS FOR 45 MINS. *TR

PLASTIC SHEATHING ON PASSENGER POWER DOOR, THE ONLY POWER DOOR, DRIED OUT AND CRACKED CAUSING THE CABLE WIRES TO BE EXPOSED TO THE ELEMENTS. AS A RESULT, THE WIRES OF THE CABLE BEGAN TO RUST AND FRAY AND TANGLED IN THE DOOR SO THAT IT WAS HALF OPENED AND WOULD NEITHER OPEN NOR CLOSE EVEN WITH THE POWER OFF. WE HAD TO CUT THE CABLE OFF TO GET THE TANGLED CABLE FREE OF THE DOOR SO WE COULD CLOSE IT. IT IS POOR QUALITY TO HAVE THE PLASTIC ON THE CABLE DRY OUT AND CRACK OFF SO THAT THE POWER DOOR IS UNABLE TO BE USED AS A POWER DOOR WHICH IS AN OPTION YOU HAVE TO PAY EXTRA FOR. WE ALSO HAD SMALL CHILDREN BUCKLED INTO CARSEATS AT THE TIME AND HAD WE NOT CUT THE CABLE OFF, WE COULD NOT DRIVE IT AS I SAID THE DOOR WAS...

2004 TOYOTA SIENNA MINIVAN, SLIDING DOORS FREEZE SHUT ALL WINTER, MY THREE KIDS CANNOT RELY ON WHAT DOOR TO EXIT, ESPECIALLY IN AN EMERGENCY. ONE SLIDING DOOR HAS NOW STOPPED WORKING, CABLE SNAPPED AND BOLTS SHEARED, LIKELY DUE TO THE EXTRA FORCE NEEDED TO WORK THE FREQUENTLY FROZEN DOORS. PERHAPS THESE VANS SHOULD NOT BE ALLOWED IN CLIMATES UNDER 32 DEGREES. I HAVE ALREADY NEEDED TO HAVE FRONT DOORS AND REAR DOOR MECHANISM REPAIRED(RECALLS). THIS SEEMS TO BE A COMMON PROBLEM. *TR

I HAVE 2004 TOYOTA SIENNA. RECENTLY MY SLIDING DOOR CABLE COMPLETELY SNAPPED IN HALF WHEN THE DOOR WAS OPENING. THANKFULLY, I WAS HOME AND WAS ABLE TO GET THE DOOR TO SHUT. *TR

1. TOYOTA SIENNA CE DRIVER'S DOOR WELDED PART (INSIDE DOOR) SNAP OFF CAUSING LOUD THUD SOUND WHEN OPENING & CLOSING THE DOOR. I FOUND OUT IN THE INTERNET THAT BEFORE THERE WAS A LOT OF COMPLAINTS ABOUT IT BUT TOYOTA DID NOT ORDER A RECALL & NOW THEY WANT ME FIX IT IN A SHOP AT MY OWN EXPENSE. 2. SUDDEN ACCELERATION FROM IDLING DURING TRAFFIC CRUISING. *TR

CRACK DEVELOPED ON DASH IN AN AREA BETWEEN INSTRUMENT CLUSTER AND RADIO. THIS IS AN AREA NOT EXPOSED TO ELEMENTS (SUN, HEAT, ETC.). VEHICLE IS GARAGED AND MAINTAINED AND WOULD NOT BE SUSCEPTIBLE TO A CRACK. *TR

THE DRIVER'S SIDE SLIDING DOOR ON MY 2004 TOYOTA SIENNA DOES NOT CLOSE PROPERLY. SOMETIMES ITS OPENS AT THE END OF THE CLOSE CYCLE OR WORSE YET, CLOSES AT THE END OF THE OPEN CYCLE. I EXPERIENCED 3 INCIDENTS WHERE MY CHILDREN'S HANDS WERE ALMOST CRUSHED BY THE DOOR WHICH WAS EXPECTED TO STAY OPEN. TOYOTA HAS ISSUED A TSB (EL004-04), HOWEVER OUR CAR IS NO LONGER IN THE WARRANTY PERIOD. THE OPENING OF THE DOOR AFTER THE CLOSE CYCLE OR CLOSING OF THE DOOR AFTER THE OPEN CYCLE OCCURS INTERMITTENTLY. *CN

THE TRUNK GATE OF MY TOYOTA SIENNA DOES NOT OPEN FULLY AND SOMETIMES GOES DOWN DURING COLD WEATHER. *TR

AUTOMATIC SLIDING PASSENGER DOOR SEIZED ON AUGUST 17, 2009. STUCK IN OPEN POSITION. WENT TO DEALER AND WAS INFORMED IT WAS FOURTH ONE THEY HAD SEEN IN A WEEK. WAS TOLD WARRANTY HAD EXPIRED PRIOR MONTH. WOULD COST OVER $1000.00 TO FIX. *TR

CONTACT OWNS A 2004 TOYOTA SIENNA LE WITH MANUAL LIFTGATE. THE LIFTGATE USED TO WORK PROPERLY - SUDDENLY ON A COLD WINTER DAY IT STOPS WORKING ANYMORE, CONTACT CAN HEAR A HISS AND THE DOOR FALLS DOWN. CONTACT CAN SEE VISIBLE OIL LEAK AROUND THE GAS STRUT. AFTER THAT, IT'S HEAVY TO OPEN THE DOOR. *TR

DRIVER SIDE AUTOMATIC SLIDING DOOR CABLE BROKE. THE DOOR HAS TO BE OPENED AND CLOSED MANUALLY. SIENNA IS NO LONGER UNDER THE SECRET WARRANTY AND TOYOTA WANTS TO CHARGE ME $3000 FOR THE REPAIR. ALSO DOOR WOULD FREEZE EASILY DURING WINTER TIME AND BECOMES VERY HARD TO OPEN. *TR

DURING NORMAL OPERATIONS OF THIS 2004 TOYOTA SIENNA XLE VAN. RIGHT SIDE POWERED DOOR SEIZED. DOOR FAILED TO OPEN COMPLETELY, AND THEN IT WAS DIFFICULT TO SHUT AND LOCK. I TOOK THE SIENNA TO THE LOCAL TOYOTA DEALERSHIP (HEARTLAND TOYOTA, BREMERTON, WASHINGTON) ON 13JAN10, AND THEY DIAGNOSED THE PROBLEM AS A FAILED MOTOR, CONTROL CABLE, AND COMPUTER (ECU). THEY ALSO INFORMED ME IT WOULD COST $3,050 TO REPAIR. I WAS IN SHOCK. I CHECKED ONLINE AND THERE SEEMS TO BE A CHRONIC FAILURE WITH THE 'AUTOMATIC' DOORS OF TOYOTA VANS. TOYOTA CORPORATE INSTRUCTED ME TO WORK WITH THE LOCAL TOYOTA DEALER TO ARBITRATE REPAIRS SINCE THE DOOR IS NOT COVERED UNDER WARRANTY, OR RECALL. I URGE THE NHTSA TO INVESTIGATE THESE DOORS. THEY SHOULD NOT FAIL AND SEIZE AFTER 5 YEARS OF NORMAL WEAR. *TR UPDATED 03/10/10 *BF UPDATED 10/05/10

POWER SLIDING DOORS FAIL TO OPEN, PRIMARILY IN COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ABOUT 10 TIMES. FIST THEY "COULD NOT DUPLICATE THE PROBLEM", THEN WHEN I WAS ABLE TO SHOW IT TO THEM, THEY COULD NOT FIX IT. EVENTUALLY THE MANUFACTURER SENT A FACTORY ENGINEER TO CHECK THE VEHICLE. HE HAD THE DOOR SEAL REPLACED. THAT HELPED FOR A FEW WEEKS, NOW IT'S DOING IT AGAIN. I TOOK IT BACK TODAY THEY SAID THAT THEY DID ALL THAT THEY CAN, ALTHOUGH THERE IS NOTHING MORE THAT THEY CAN DO FOR ME. *TR

MY DOOR HAS THE DOOR CHECK ISSUE TO THE POINT IT WILL NOT HARDLY CLOSE, AND TOYOTA FEELS SINCE IT WAS 5 YEARS , 3 MONTHS FROM DATE OF PURCHASE, THEY ARE NOT RESPONSIBLE FOR IT. I SUSPECT THIS WAS PRESENT AND ALL AFFECTED TOYOTAS SHOULD BE RECALLED TO FIX BOTH THIS DRIVER DOOR, BUT THE PASSENGER DOOR AS WELL. MAKE : TOYOTA MODEL : SIENNA YEAR : 2004 MANUFACTURER : TOYOTA MOTOR CORPORATION SERVICE BULLETIN NUMBER : 07017 DATE OF BULLETIN : OCT 23, 2007 NHTSA ITEM NUMBER : 10023697 COMPONENT : STRUCTURE:BODY:DOOR SUMMARY : CUSTOMER SUPPORT PROGRAM - WARRANTY COVERAGE EXTENSION FOR THE FRONT DOOR CHECK ON CERTAIN 2004-2007 MY SIENNA VEHICLES. *NJ *TR

DRIVER SIDE SLIDING DOOR WILL NOT STAY LOCKED AND LATCHED. THE FASTENERS THAT HOLD THE LOCKING MECHANISM PLACE PULLED THROUGH THE DOOR SHEET METAL. DEALER STATES IT CANNOT BE FIXED AND A NEW DOOR WOULD BE NEEDED AT $3500. DOOR CAN OPEN AT ANY TIME. *TR

2004 TOYOTA SIENNA SLIDING DOORS MALFUNCTIONING. OVER TIME, THE DOORS APPEAR TO WEAR OUT AND WILL NOT OPEN FROM THE INSIDE OR THE OUTSIDE OF THE VEHICLE. THEY CANNOT BE OPENED MANUALLY OR BY USING THE POWER OPERATION FEATURE. THE DEALER WAS ABLE TO OPEN IT AND ADJUST IT BUT TOLD US THAT IT WILL HAPPEN AGAIN UNLESS WE PAID APPROXIMATELY $1200 PER DOOR TO REPLACE THE WORN PARTS. WE ARE CONCERNED ABOUT GETTING TRAPPED IN THE VEHICLE. *TR

THE PASSENGER AND DRIVER SIDE MIDDLE (SLIDING) DOORS OF OUR 2004 TOYOTA SIENNA HAVE FROZEN SHUT EACH WINTER FOR 5 YEARS. AFTER MELTING FREE THE DRIVERS SIDE DOOR CAME SUDDENLY OPEN A FEW TIMES WHILE WE WERE DRIVING DOWN THE ROAD. NOW THE AUTOMATIC OPEN/CLOSE HAS STOPPED WORKING AT ALL. *TR

DURING THE NORMAL OPERATION OF THE DRIVER'S SIDE AUTOMATIC SLIDING DOOR, THE CABLE SNAPPED AND GOT CAUGHT SO THAT THE DOOR COULD NOT FULLY OPEN OR FULLY CLOSE. IT WAS NECESSARY TO CUT THE CABLE OUT AND OPERATE THE DOOR MANUALLY TO GET THE DOOR TO SHUT AT ALL. THE QUOTE TO REPAIR THE PROBLEM WAS $1232.12. *TR

MY 2004 TOYOTA SIENNA AUTOMATIC SLIDING DOOR MECHANISM STOPPED WORKING AND WE WERE UNABLE TO OPEN THE DOOR ON THE PASSENGER SIDE. IT IS CLEAR FROM FORUMS ON THE INTERNET THAT THIS IS A WIDESPREAD PROBLEM. *TR

TOYOTA SIENNA 2004 SLIDING DOOR MOTOR CABLE WAS TOTALLY RUSTED AND SNAPPED. SLIDING DOOR IS NOT OPERABLE. SLIDING DOOR WIRE IS TOTALLY RUSTED DURING NORMAL USE. AS S RESULT, DOOR WAS JAMMED AND NEITHER CAN BE CLOSED NOR OPENED. TOYOTA DOES NOT SELL CABLE SEPARATELY, SHOULD PURCHASE WHOLE MOTOR ASSEMBLY INSTEAD. SIMILAR CABLE COST IS AROUND 10 DOLLAR (FROM HARDWARE STORE) BUT MOTOR ASSEMBLY IS AROUND 1500 DOLLAR. *TR

WE HAVE A 2004 TOYOTA SIENNA XLE THAT HAS JUST SUFFERED A FAILURE OF THE POWER SLIDING DOOR, CAUSING IT TO BECOME STUCK IN THE OPEN POSITION. MY WIFE WAS FORCED TO DRIVE WITH TWO YOUNG CHILDREN IN THE BACK SEAT AND THE SIDE DOOR WIDE OPEN. THIS IS EXTREMELY UNSAFE AND DEMANDS A RECALL. APPARENTLY THE CABLE WAS FRAYED BY A FAILED HINGE, AND I HAVE READ MANY COMPLAINTS ABOUT THIS PROBLEM. THIS IS A 5-YEAR-OLD MINIVAN WITH 84,000 MILES. HOW IS TOYOTA ALLOWED TO IGNORE SUCH A BLATANT SAFETY DEFECT TO THEIR CARS THAT OCCURS WITHIN THE FIRST 3 TO 5 YEARS? IT IS OUT OF WARRANTY AND THEY WILL PROVIDE NO MEASURES FOR REPAIR, BUT NO REASONABLE PERSON WOULD EVER EXPECT THE DOORS OF A CAR TO BE THE FIRST THING TO STOP WORKING, AND IN THAT SHORT A PERIOD OF TIME. THIS IS UNACCEPTABLE AND DANGEROUS...

WE HAVE A 2004 SIENNA WITH AUTO-SLIDING DOOR FOR PASSENGER SIDE. THE VAN HAS AROUND 57000 MILES. IT IS RAINING/SNOWING TODAY AND THE PASSENGER DOOR COULDN'T BE CLOSED. MY WIFE AND MY KID IS STUCK IN NEWTOW, 30 MIN AWAY FROM HOME. THE PASSENGER SIDE DOOR CAN'T BE CLOSED MANUALLY. THE OUTSIDE TEMP IS AROUND 35 DEGREE. BY READING THE INTERNET, IT LOOKS LIKE MANY 2004 SIENNA OWNER HAVE THE SAME ISSUE. I CONSIDER IT AS A SAFETY ISSUE SINCE MOST VAN OWNERS HAVE YOUNG KIDS IN THE VAN. IF THE DOOR IS STUCK IN THE WINTER TIME, IT IS A BIG PROBLEM. *TR

I OWN A 2004 TOYOTA SIENNA XLE MODEL. THE SLIDING DOOR CABLES PLASTIC/RUBBER SHIELD BEGAN TO PEEL OFF AND NOW THE DOOR WON'T CLOSE IN AUTOMATIC MODE BECAUSE IT ALWAYS SENSE RESISTANCE. I TRIED TO DISABLE THE AUTOMATIC MODE AND PUT THE DOORS ON MANUAL MODE, BUT IT'S NEARLY IMPOSSIBLE TO MOVE THIS DOOR AS SOMETHING SEEMS TO BE STUCK. DID A SEARCH ON THE WEB AND IT SEEMS LIKE ALMOST EVERYONE IS HAVING THIS PROBLEM NOW THAT THIS MODEL IS GETTING TO BE 4-5 YEARS OLD. SOME SAYS TO CUT THE CABLE IN ORDER TO GET THE DOOR TO OPERATE SMOOTHLY IN MANUAL MODE. BUT I DON'T WANT TO TAKE THE CHANCE. TOYOTA REALLY SHOULD HAVE A RECALL ON THIS MAJOR DESIGN FLAW AND SAFETY HAZARD. THANK YOU. *TR

WE HAVE A 2004 TOYOTA SIENNA. WE HAVE DISCOVERED THAT THE CABLE ON DRIVER SIDE OF THE SLIDING DOOR HAS RUSTED/ROTTED AND SNAPPED OFF. WE HAVE CALLED TOYOTA ABOUT THIS ISSUE AND THEY INFORMED US THAT THE DOORS ARE NOT COVERED. WE FEEL THAT THIS IS A SAFETY ISSUE AS THE DOORS ONLY OPEN PART WAY. WE HAVE FOUND THAT THERE WAS NO RECALL ON THIS ISSUE. PLEASE LOOK INTO THIS ASAP. JUST PICTURE YOUR CHILDREN TRAPPED IN THE VAN DURING AN ACCIDENT- THESE DOORS ARE TOO HEAVY FOR THEM IN MANUAL MODE. THIS IS HAPPENING TO MANY TOYOTA VEHICLES, TO THE POINT WHERE THIS NEEDS TO BE AIRED ON NATIONAL TELEVISION FOR TOYOTA TO STEP UP AND STAND BEHIND THEIR VEHICLES. THIS IS ABOUT SAFETY AND OUR CHILDREN - NOT JUST A BONUS FEATURE. HELP US TO KEEP OUR CHILDREN SAFE IN THESE FAMILY BUILT VEHICLES! PLEASE!!! *TR

THE DOORS ON MY 2004 TOYOTA MINIVAN HAVE BEEN FREEZING EVERY WINTER SEASON SINCE 2006. CANADA TOYOTA HAS MADE THIS A RECALL ITEM, BUT THE UNITED STATES WILL NOT? I FIND THIS TO BE ABSURD - ESPECIALLY WHEN CHILDREN HAVE TO CLIMB UP THROUGH THE FRONT SEATS TO GET OUT OF VEHICLES. THIS COULD BE FATAL IN AN ACCIDENT IF THE DOORS CAN NOT BE OPENED. I HAVE CONTACTED TOYOTA DEALER AND THEY CLAIM TO USE WRENCH GREASE TO LUBE THE DOORS TO HELP AND PREVENT FROM STICKING. I LIVE IN NEW ENGLAND AND THE DOORS HAVE ALREADY STARTING FREEZING SHUT THIS YEAR (OCT 2009). THIS IS EXTREMELY FRUSTRATING, THIS ISN'T A CHEAP VEHICLE AND IT WAS PURCHASED FOR FAMILY USE. TOYOTA HAS REALLY FAILED THE AMERICAN PUBLIC WITH THEIR MINIVANS. I WOULD HAVE USED THIS AVENUE TO COMPLAIN YEARS AGO - I HAVE BEEN WASTING MY TIME TRYING TO...

I HAVE A TOYOTA SIENNA 2004 LE 8 PASSENGERS. MY COMPLAINT IS THAT THE DASH OF THE SIENNA IS CRACKING LIKE SOMEONE HAS SLICED IT WITH A BLADE. PLEASE INVESTIGATE THIS DEFECT. I KNOW THAT I`M NOT ALONE WITH THIS COMPLAINT. THANK YOU, JESUS *TR

THE POWER DOORS OF OUR 2004 SIENNA FROZE EACH WINTER SINCE PURCHASE AND WOULD NOT OPERATE UNTIL VEHICLE WARMED - 2 CHILDREN HAD TO CLIMB IN AND OUT THROUGH FRONT DOORS. THIS WINTER, PROBABLY FEBRUARY ONE CABLE SNAPPED ON PASSENGER SIDE, OTHER CABLE FRAYED AND REFUSED TO OPERATE - DEALER ESTIMATED APPROXIMATELY $600 PER DOOR FOR REPAIRS. MY HUSBAND TOLD HIM WE WOULD WAIT UNTIL THE RECALL WAS ISSUED AS THIS WAS A SAFETY CONCERN. MY HUSBAND DISCONNECTED THE DOORS SO THEY WOULD OPERATE MANUALLY - WHICH IN NOT SOMETHING THE TOYOTA DESIGN ALLOWED FOR. SINCE MY HUSBAND DISCONNECTED THE DOOR, WE HAVE EXPERIENCED SOME OTHER ELECTRICAL PROBLEMS, NOT CERTAIN IF THEY ARE RELATED. ALSO HAVE HAD PROBLEMS MAINTAIN AIR PRESSURE IN TIRES ALTHOUGH NOT ALL WHEEL DRIVE MODEL. DEALER WAS SUPPOSED TO CONTACT US TO SCHEDULE ADDITIONAL RECALL WORK ON THE VEHICLE, BUT HAS NOT DONE SO, I BELIEVE...

FAMILY LOADED IN VAN TO LEAVE, PUSHED BUTTON ON REAR PASSENGER AUTOMATIC DOOR TO CLOSE IT AND MADE A WEIRD NOISE THEN FAILED TO CLOSE. SOME HOW THE AUTOMATIC DOOR CABLE CAUGHT IN TRACK OF SLIDING DOOR PREVENTING DOOR CLOSURE PAST HALF WAY. ALL EFFORTS TO CLOSE DOOR FAILED. LUCKILY WE WERE LEAVING HOME NOT RETURNING HOME. VAN HAD TO BE DRIVEN TO SHOP WITH DOOR WIDE OPEN! TOYOTA DEALER CHARGED $450 TO CUT CABLE OFF AND FREE DOOR TO CLOSE MANUALLY, OR OVER $1600 TO REPLACE CABLE AND MOTOR THAT ARE APPARENTLY ALL ONE PIECE. THERE WAS ABSOLUTELY NO WARNING TO THIS FAILURE. IT SEEMS THAT IF AN AUTOMATIC DOOR PART IS GOING TO FAIL, IT SHOULD BE DESIGNED TO AT LEAST FUNCTION IN A MANUAL STATE. CHILDREN CANNOT BE DRIVEN AROUND IN A MINIVAN WITH THE DOOR WIDE OPEN. TOYOTA REFUSED TO ACKNOWLEDGE THAT THIS COULD BE A...

CABLE SNAPPED ON REAR POWER SLIDING DOORS. IT APPEARS THAT THE OUTER PLASTIC COATING DRIED AND BROKE OFF OF THE CABLE. CABLE IS HANGING OUTSIDE OF THE CAR AS I DRIVE DOWN THE ROAD. THE DOOR IS VERY HEAVY AND MY CHILDREN ARE UNABLE TO OPEN THE DOOR THEMSELVES. *TR

I HAVE 2004 TOYOTA SIENNA WITH 1 POWERDOOR. THE MOTOR AND CABLE ASSEMBLY IS NOW BROKEN, AND TOYOTA WILL NOT MAKE IT MANUAL. I NOW HAVE TO PAY $1,600.00 FOR A NEW ASSEMBLY. *TR

BOTH LEFT AND RIGHT SLIDING DOOR CABLES BROKE ON VAN. RIGHT DOOR WILL NOT OPEN AT ALL TWO MONTHS LATER LEFT BROKE AND OPENS ABOUT 12IN.THAT FOUR KIDS HAVE TO GET IN AND OUT. WILL COST$1500 EACH TO FIX. *TR

TOYOTA SIENNA ELECTRIC SLIDING DOOR DOES NOT OPEN WITH BUTTON. CAN ONLY BE OPENED BY PULLING HARD ON OUTSIDE HANDLE. DEALER SUGGESTED REPLACING DOOR MOTOR. *TR

INITIAL NOTE: THIS IS A DANGEROUS DEFECT. TOYOTA SHOULD BE ORDERED TO RECALL THIS VEHICLE TO FIX THIS PROBLEM. WE HAVE A 2004 SIENNA LE, WITH ABOUT 70,000 MILES ON IT. A FEW WEEKS AGO, WE NOTICED SOME DIFFICULTY WITH THE PASSENGER SIDE POWER DOOR. THE PROBLEMS BEGAN WITH THE DOOR NOT OPENING WHEN WE USED THE REMOTE CONTROL OR THE BUTTON IN THE FRONT OF THE CAR. THE DOOR SEEMED TO FUNCTION NORMALLY WHEN PULLING THE HANDLE, SO WE THOUGHT THE PROBLEM WAS LIMITED TO THE REMOTE CONTROLS. WHEN WE WERE AWAY AT A CAMPING TRIP FROM JULY 24 - 26, I NOTICED THE PROBLEM HAD STARTED TO AFFECT THE HANDLE AS WELL. THE DOOR WOULD HESITATE, BUT WOULD OPEN NORMALLY IF I PULLED IT A SECOND TIME. WHEN WE RETURNED HOME, AFTER MY FAMILY EXITED THE VEHICLE, I TRIED TO OPEN THE DOOR TO UNLOAD THE CAR. IT...

*****2004 SIENNA POWER SLIDING DOOR FELL OFF********I PURCHASED A 2004 TOYOTA SIENNA MINIVAN BRAND NEW IN MARCH 2003. I LOVED THE VAN UNTIL THE SUMMER OF 2007. WE HAD THE OPTIONAL POWER REAR PASSENGER SLIDING DOOR. AT THE BEGINNING OF SUMMER, THE POWER CABLE SNAPPED SO WE CHANGED THE DOOR SETTING TO MANUAL UNTIL WE COULD HAVE IT REPAIRED. THIS MANUAL SETTING WAS WORKING FINE AND WE TOOK A 2 HOUR ROAD TRIP TO ATTEND A LACROSSE TOURNAMENT FOR OUR SON ABOUT A WEEK LATER.***** OUR DAUGHTER WHO WAS 4 AT THE TIME ALWAYS SAT IN THE PASSENGER SEAT FURTHEST TO THE BACK. AFTER WE ARRIVED AT THE TOURNAMENT, MY HUSBAND WENT BACK TO THE VAN TO RETRIEVE A CHAIR. HE UNLOCKED THE VAN, OPENED THE SIDE, REAR PASSENGER DOOR AND THE DOOR WENT ROLLING DOWN THE TRACK, DISENGAGED, SLID OFF THE TRACK, ALL THE WAY BACK AND SMASHED IN...

2004 TOYOTA SIENNA LE POWER DOOR CABLE FAILED AND THUS DOOR CAN NOT BE CLOSED. THE COATING OVER THE CABLE WORE OUT AND ULTIMATELY WIRE FAILED. *TR

DEFECT WITH TOYOTA SIENNA POWER DOOR. THE DOOR MOTOR / TRAIN MECHANISM IS PRONE TO BREAKING LEAVING THE DOOR STUCK IN AN OPEN POSITION. THITS MAKES THE CAR UNUSABLE AND/OR VERY UNSAFE. CLEARLY A MINIVAN IS MEANT TO TRANSPORT CHILDREN. THIS HAS HAPPENED TO MY 2004 SIENNA TWICE IN THE LAST 12 MONTHS. THIS CLAIM IS FOR THE MOST RECENT INCIDENT. *TR

2004 TOYOTA SIENNA'S DRIVER SIDE AUTOMATIC SLIDING DOOR FELL OFF OF THE VEHICLE AS THE CABLE CAME OFF OF ITS TRACK AND WOUND TIGHTLY AROUND THE MOTOR [LOCATED INSIDE THE DOOR]. THE VERY TIGHTLY WOUND CABLE AROUND THE MOTOR PULLED THE DOOR OFF THE TRACK CAUSING A QUOTED $1,800 IN REPAIRS. *TR

I OWN A 2004 TOYOTA SIENNA AND MY SLIDING MOTOR HAS GIVEN OUT AND I SEE THIS PROBLEM IS JUST NOT HAPPENING TO A FEW VEHICLES AND FROM WHAT I UNDERSTAND IT ALSO COULD POSSIBLY LEAD TO A SAFETY ISSUE. I OFFICIALLY WOULD LIKE TO SEE THIS PROBLEM RESOLVED BEFORE IT IS TOO LATE. *TR

THE PASSENGER SIDE POWER SLIDING DOOR ON MY 2004 TOYOTA SIENNA HAS FAILED -- WE HAVE JUST UNDER 45K MILES ON THE VEHICLE. WE PRESSED THE BUTTON TO CLOSE THE DOOR AND, AS IT WAS CLOSING, HEARD A GRINDING NOISE. UPON FURTHER INSPECTION, THE CABLE WAS BROKEN. FORTUNATELY WE WERE ABLE TO GET THE DOOR CLOSED, BUT NOW THE DOOR IS UNABLE TO OPEN MORE THAN 12 INCHES OR SO. I TOOK THE VEHICLE IN FOR SERVICE AND FOUND THAT PARTS/LABOR IS $1800+. SOME QUICK RESEARCH ON THE WEB POINTS TO THIS BEING A FAIRLY COMMON PROBLEM WITH THE VEHICLE. THIS IS CLEARLY A MANUFACTURING DEFECT AS THE CABLE SIMPLY FRAYS AND FAILS OVER TIME. FOR SOMEONE WITH A NEWBORN AND TWO OTHER CHILDREN, LOSS OF ACCESS TO THIS DOOR IS A PROBLEM. *TR