2020 KIA SOUL Engine Problems

My car randomly started stalling and turned off while I was in the middle of a busy intersection with both my children in the car. I had to turn on my hazards and turn off my car and turn it back on and press on the gas pedal. The car did that four times in less than 30 minutes. I am not the original owner of the vehicle, but the previous owner did have the cars camshaft repaired when I took it to the mechanic on 4/21 that was when I found out about the previous owner having the same issue as I am. I called Kia of America regarding the recall on 2020 Kia souls. They ignored my request and told me there was nothing they can do as my warranty was expired. I then proceeded to call carmax where I bought the car and was never informed that...

The contact owns a 2020 Kia Soul. The contact received notification of NHTSA Campaign Number: 21V259000 (Engine); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2020 Kia Soul. The contact stated that the vehicle was consuming a quart of oil every 1,000 miles. The contact stated that there were no visible leaks. While driving at an undisclosed speed, the vehicle stalled. The vehicle failed to accelerate above 2,500 RPM. There was smoke coming from the vehicle. There was an abnormal clunking sound coming from the vehicle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 21V259000 (Engine). The vehicle was taken to the local dealer, where it was diagnosed and determined that a software update was needed. The contact was provided the cost for a diagnostic test. The vehicle was repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 69,000.

2/7/25 went to Dublin CA KIA dealership requested engine diagnostic for engine light and burning oil @76,621 mileage they found code for catalyst efficiency PO42000, upper O2 sensor has failed, verified Cat Comb had no damage and wasn't clogged. inspected cylinder walls and found scoring on cylinder 1due to failed piston, recommended oil combustion test to return in 1000 miles to verify how much oil being burned topped off engine oil. 2/15/25 picked up KIA @76,622 mile drove home @76,637 2/27/25 @77,271 dipstick @ 3 dots -no oil added (634 miles driven) 3/8/25 @77,532 dipstick @ no dots -no oil added( 261 miles driven) drove local 3/10/25 drove to dealership @77,597 I've asked for written estimate ( they say its covered parts/labor free)) to have it writing- they are waiting for parts to replace. I'm a super commuter to San Francisco and will always check my engine oil b/c I...

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. No warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with internal engine failure, and it was determined that the long block, CAT exhaust manifold, intake gasket, exhaust, and oil O-ring needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 90,000.

The contact owns a 2020 Kia Soul. The contact stated while driving at an undisclosed speed, the vehicle stalled. The contact stated that when the vehicle was started, there were several unknown warning lights illuminated. In addition, the contact stated that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was informed that the pistons and the PCV valve needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,000.

Error codes possibly 3 times diagnose. P0017. Crankshaft - camshaft 1 correlation bank b .Could be timing chain being stretched vigorously. Still have excessive oil consumption after getting piston rings replaced.

So my car (despite being regularly maintained) had complete engine failure. At 100,300 miles. I was told the bottom half of the engine had complete shut down due to excessive oil burning. The car would start but then when put in gear would die immediately. When originally noticed the engine would shut down when going from a stopped position into moving, usually through an intersection. Not safe at all.

I have called Kia multiple times about my 2020 Kia soul burning oil. The car is only 5 years old and should not be going through oil like it is. My car takes 5 quarts of oil. I do an oil change every 3,000 miles. When I drain the old oil it’s only at 2 quarts. The car burns 3 quarts of oil every 3,000 miles.

Car started running rough and stalling at stops. Replace crankshaft sensor and vvt solenoids. Found out there was a recall and sent to dealership for recall. They claim that the issue is not related to the recall, that the valves are the issue. But if the piston oil rings aren't working properly that would cause problems with the valves.

The contact owns a 2020 Kia Soul. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that several unknown warning lights were illuminated. The contact heard a loud banging sound coming from the engine compartment. In addition, there was blue smoke entering the cabin of the vehicle with smoke coming from the exhaust pipes. The contact stated that the vehicle lost motive power in the middle of the road. The vehicle was coasted to the shoulder of the roadway. The vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was advised to tow the vehicle to the dealer for assistance. The vehicle was towed to the dealer; however, the cause of...

The contact owns a 2020 Kia Soul. The contact stated that the engine was consuming an excessive amount of engine oil. The contact stated that while at a stop, the vehicle lunged forward and stalled. The vehicle was restarted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who determined that there was an abnormal knocking sound coming from the engine and referred the contact to the local dealer. The vehicle was taken to the local dealer, where it was determined that the failure was due to the timing chain and camshaft, and that the engine had shifted out of position. The dealer informed the contact that the failure was not related to NHTSA Campaign Number: 21V259000 (Engine). The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 88,000.

I brought the vehicle in for the open recall, which clearly states that the dealership would conduct a thorough inspection of the engine. Not only did they inspect the engine as required by the recall, but they refused to complete the recall altogether and told me that I needed to purchase a new engine. The recall language clearly indicates that a new engine may be needed, at Kia's expense, if there are issues noted in the inspection. Can a dealership really deny completing an open recall? Now I have a vehicle that is dangerous to drive with no way to get it repaired. The dealership was Jones Kia (2001 Belair Rd, Fallston, MD 21047).

The contact owns a 2020 Kia Soul. The contact stated while driving at an undisclosed speed, the vehicle stalled, and the check engine warning light illuminated. The vehicle was later towed to an independent mechanic, who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure. The contact stated that the vehicle was previously serviced under NHTSA Campaign Number: 21V259000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 140,000.

While driving the vehicle on the highway I lost speed slowly..pull over an car made a rattling noise an stop running..Took to dealer.they have had my car going on three months..last I talk with them I had to agree with the next step which could cost me.to take apart.to see if I kept up with my oil changes...no offer of a rental car...I have almost lost my job twice..an I been there fifteen years..

I brought my vehicle in for the open recall as my engine seized: Manufacturer Safety Recall issued NHTSA: #21V259 Recall: #SC209A SC209A ECM UPDATE (PISTON-RING NOISE) Kia is refusing the repairs and has not completed the recall, which includes the following remedy: KIA WILL INSPECT AND IF NECESSARY REPLACE THE ENGINE AT NO COST TO YOU. IF IT HAS NOT BEEN DONE ALREADY, KIA WILL INSPECT AND, IF NECESSARY REPLACE THE ENGINE THE ESTIMATED TIME REQUIRED TO PERFORM THE INSPECTION IS APPROXIMATELY 1-2 HOURS. IF ENGINE REPLACEMENT IS NECESSARY, THE ESTIMATED TIME REQUIRED IS 8 HOURS OR MORE. IN ADDITION, KIA WILL INSTALL THE PISTON-RING NOISE SENSING SYSTEM SOFTWARE FOR THE ENGINE CONTROL UNIT IN THE VEHICLE THAT WILL ALERT THE DRIVER OF POTENTIAL DAMAGE TO THE PISTON OIL RINGS. THE ESTIMATED TIME TO INSTALL THE SOFTWARE WILL BE APPROXIMATELY 1 HOUR. THE SOFTWARE SHOULD BE INSTALLED WIETHER OR NOT...

Engine failure while driving, only 51,000 miles on the vehicle. I was driving on the interstate and fortunately was in the right lane so I could pull over immediately and it did not cause an accident. I was driving approximately 45 miles per hour to pull onto the interstate when a loud noise and engine failure occurred.The engine light and oil light came on when I heard the engine stalling. My car was taken to the dealership where they stated the engine needs to be replaced for $8200 and it’s beyond warranty. According to their recall test, it passed the recall. I’m assuming that’s for the piston oil recall, but they have been unable to provide proof or details on how it passed. I have had regular maintenance on my car and should not require a new engine at this point. Please advise.

When I would come to a complete stop at a stop sign it would stall battery light and oil light would come on. I would need to put it in park then turn it off and turn it back on. It also would suck up oil like crazy I would need to replace the oil every few days otherwise it wouldn't start. I took it to the shop and 2 of the 4 pistons blew and all the timing stuff stopped working.

The contact owns a 2020 Kia Soul. The contact stated while driving at various speeds, the check engine warning light illuminated. The vehicle was taken to the dealer where it was discovered that the engine was consuming an excessive amount of oil. The contact was provided an estimate for a diagnostic test to determine the cause of the oil consumption. The manufacturer was notified of the failure, and the contact was provided a case number. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 76,000.

I had software installed for piston rings. Got car back with check engine light on. Brought it back and was told I need a new engine which I need to pay for. Car was bought brand new gave receipt for oil changes.

Our vehicle experienced every dash light on the board coming on intermittently. At time, we could not use the remote control and had to open the door and crank the car manually. Windshield Wipers and headlamps did not work, nor did any of the safety features on the car or indicator lights. When all illuminated, we took the vehicle to local Kia dealership and eventually they replaced the electrical panel. The side and rear collision indicators never worked again even after repairs were done. The car continued to display every light on the dash after the electrical panel was replaced and local dealership could not fix it. None of the indicator lights showed problems with the engine and regular maintenance to the vehicle was maintained on schedule. Four years into the life of the vehicle, the car started burning all the oil in the engine and oil indicator light did...

When taken for oil changes, no oil is left on stick and motor will lock and cut off. I have to restart the car to get it to turn on.

While driving vehicle; stalling, sputtering, failure to shift gears, engine knocking/shaking car. Altinator was replaced and stopped sputtering. Following day I was going 55 mph and car completely stalled out on a busy road and almost got rear ended and car lost power car was towed to Kia Dealership for further diagnostics test. Failures of systems have been on going but always started back up after leaving dealership where purchased. After altinator was replaced batter light and oil light came on dash along with check engine light stalled for about a minute I turned car off and back on and it was able to drive off lot. Place of purchase would do a temporary fair and also changed transmission fluid. One hour later was when vehicle stalled out and lost power.

The entire car is infested with Mold due to a prior evaporator leak that was improperly installed prior to my purchase of the vehicle. The dealership Lighthouse Point Kia in Pompano, Florida, refusing to fix the car issues.

The contact owns 2020 Kia Soul. The contact stated while driving 60-65 MPH, the vehicle stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The contact was able to restart the vehicle; however, the check engine warning light was illuminated. The vehicle failed to restart and was towed to the dealer, where the camshaft accessory exhaust, the CVT exhaust, the timing belt tensioner, and the three bond were replaced. Additionally, an oil change was performed; however, the failure recurred while driving. The vehicle was towed to the dealer, where the catalytic converter, the crankshaft sensor, the spark plugs, and the ignition coils were replaced; however, the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V259000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case...

In the timeframe of 1 oil change had to add 3-4 qts of oil to my car and still have 1000 miles left before i have to have an oil change. It is a 2020 2L kia soul. The car has no leaks and has been properly maintained. I have taken it to a shop that told me that it is probably going to blow a motor in the next few thousand miles. The car only has 78,414 miles on it. They explained that if it blows to get ready to hopefully not crash as the power steering will go away.

Car is making a knocking sound

I was driving to work. 12 miles my oil leaked. A state trooper turned around when seeing flames and called the fire department and tow truck. I lost control of the car, nothing was working. I was only ever given one recall notice which I fixed 2 months after buying the car. The car also has issues with security. Only certain insurance companies will cover the car and their prices are higher. We took car to dealership . three months later I contact attorney general. The GM this started attacking us, denying anything happened etc. He should be fired for how he treats people. Reviews of their business show others have had issues. Kia corporate has always told us they r waiting on images yet this GM contacted them, told us to leave, and screamed he would charge us for every day it was on lot. So we had it...

Engine using oil at only 45,000 miles. It's been less than 500 miles since last oil change and today had to put 1/2 quart of oil. Had all recalls done. Told the dealership it was using oil, they said it was a faulty gasket and oil drain plug was lose. Changed everything including oil,gasket and tightened the oil drain plug. But today less than 500 miles later had to add half quart of oil. I am the original owner and I know Kia says a quart per 1000 miles is acceptable. I have owned older cars with over 100,000 miles never used oil in between changes, I have owned new cars never had to top off between oil changes. I am afraid my engine should be recalled now, I don't trust my soul anymore. There's absolutely no reason for this car with 50,000 miles should be using oil. If it...

Unknown. Consuming oil at a high rate. Car also randomly loses acceleration power acting as if it’s in neutral.

The contact owns a 2020 Kia Soul. The contact stated while driving 80 MPH and attempting to pass another vehicle, the accelerator pedal was depressed, but the vehicle failed to accelerate while the RPMs were significantly high. The contact stated that she intendedly decelerated to 60 MPH; however, the failure recurred while depressing the accelerator pedal. The contact pulled to the side of the road and parked the vehicle for 15 minutes. The contact resumed driving; however, the vehicle failed to exceed 30 MPH. The contact pulled to the side of the road and parked the vehicle for 20 minutes; however, the failure persisted. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was...

The car had transmission failure at 44000 miles.

The contact owns a 2020 Kia Soul. The contact stated that while driving at 30 MPH, the vehicle inadvertently lost motive power. The contact was unable to pull to the shoulder of the roadway but was able to restart the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The dealer initiated a 1,000-mile oil consumption test. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V259000 (Engine) but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.

Appropriately April 2024, The engine service light came on at about 115,000 miles, followed by the 2020 Kia Soul X-line engine stopped running. I tried turning off the key and attempting to restart the car however it would start but for only a few seconds. After 5 or 6 tries to restart the car, I finally turned off the car, waited about 3 minutes and then restarted the car in as it continued to run. The check engine light remained on but I noticed that there was a drop in power when I tried to accelerate. Since then I have notice the engine check light go on and off several times. I recently brought my car in to have an oil change only to find out that there was no oil on the dipstick. I signed a form stating this and got the oil change completed. I have had the...

The contact owns a 2020 Kia Soul. The contact stated that while driving at various speeds, the vehicle was shaking, vibrating and a loss of motive power. The vehicle was towed to the dealer who diagnosed that the engine was faulty and needed to be replaced. The engine was replaced but the failure persisted. The contact stated that later while driving at an undisclosed speed, the check engine warning light remained illuminated. The vehicle was taken to the local dealer and serviced under NHTSA Campaign Number: 21V259000 (Engine) however, the failure reoccurred, and the vehicle would not properly accelerate. The vehicle was taken back to the dealer who informed the contact that the DC-to-DC converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 26,000.

Engine burning oil..started knocking

Pistion Rings

The contact owns a 2020 Kia Soul. The contact was driving at approximately 35 MPH when the check engine warning illuminated. The contact stated that the vehicle stalled and she was able to pull over and restart the vehicle. The check engine warning light would turn off and on. The vehicle was taken to an independent mechanic who advised a new engine was needed. The contact checked online and discovered that the VIN was associated with NHTSA Campaign Number: 21V259000 (Engine). The contact drove her vehicle to a local dealer who ran a test on the engine and advised the contact that to determine that the engine needed to be replaced she would need to pay a diagnostic fee. The vehicle was not repaired. The contact then drove her vehicle to another dealer who advised that she would need to pay a diagnostic fee to determine if the piston oil...

The contact owns a 2020 Kia Soul. The contact stated that while his daughter was driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle stalled. The following day, while the contact was driving, and in route to take the vehicle to the dealer, the check engine warning light illuminated, and the vehicle stalled. The contact had received notification of NHTSA Campaign Number: 21V2590000 (Engine) however, the only part of the recall completed was the noise sensing software. The failure occurred the day after the recall repair was completed. The vehicle was taken back to the dealer however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.

The engine burns all oil out within 1000 miles of driving. No leaks, but oil disappers.

The oil plug

The contact owns a 2020 Kia Soul. The contact stated while driving 65 MPH, the vehicle hesitated upon depression of the accelerator pedal, with the check engine warning light illuminated on the instrument panel. Despite the failure, the contact was able to coast the vehicle back to the residence. The contact called several dealers and independent mechanics who were unable to service the vehicle or provided a high estimate for the repair. The manufacturer was also notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 98,000.

My check engine light is on. I took to mechanic and the diagnostic code that came up as p1327:00. Piston Ring Noise Sensing System". And KIA issued a service bulletin [XXX] (Rev 1, [XXX]). I called the dealership Premier KIA in Kenner, LA. They refuse to even acknowledge or respond to have it checked out. I emailed owner and service manager and explained issue and informed them of everything and added that I did indeed have the software update done when the initial recall came out. Today February the car stalled on me as I was pulling out onto [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had transmission changed out in May of 23 and then in November the check engine lights starts blinking and now I need a new engine, prior to needing a new engine the car would cut off it was loud and it wasn’t taking off like it should.

The contact owns a 2020 Kia Soul. The contact received notification of NHTSA Campaign Number: 21V259000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 35 MPH, the vehicle lost motive power. The contact depressed the accelerator pedal, and the vehicle failed to respond. The contact stated that the vehicle stalled and coasted to a stop. The contact stated no warning light was illuminated. The contact had the vehicle towed to the residence and then towed to a dealer. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The contact was informed by the dealer that the vehicle failed to qualify for the recall. The vehicle was not repaired. The manufacturer...

The engine when it heats up drives so rough. Then the car completely shuts off. This creates such a dangerous situation when on the freeway. The motor needs to be replaced. I bought car from a used dealership and have only had 2 months and the motor is gone. Recall on certain motors is garbage because this motor is suffering from the same problem as the GDIs. I have an MDI. $15,000 down the drain. Thanks

Unresolved Recall. The vehicle was under recall in 2019 and should not have been sold by JTs Kia in Columbia, SC. The piston oil rings were affected in the 2019 recall and also caused an issue for the 2020 Kia Souls. The car was sold under recall. Once the revised recall came out in 2021 JTs Kia did not properly resolved the issue and later the car engine overheated and caught fire. JTs Kia Never took responsibility and told the South Carolina Department of Consumer Affairs that the Kia Corporation will not honor any repairs. The car was no longer able to turn on and JTs KIA is still selling these dangerous cars that has had piston oil ring issues since 2010

I bought my car brand new off the lot 0 miles on it. Recieved a letter in mail Dec. 7th 2021 bout the pistons not being treated properly. And the software being available. I've been putting anywhere from 1 quart to 1.5 quart of oil in weekly. There's no leaks no smoke not sure where oil is going. It stalls when stopped or idling. When in park will stall. After I get gas it won't start I have to put gas pedal all the way to floor and hope it's turns over and when it finally does I have to keep it idle over 2rpms or it sputters til it stalls. I feel these are continued safety issues. Besides my oil issue gas mileage is awful.

The engine was damage and the Kia Wesley chapel. Does not want to respond and is within the warranty and has less than 100,000 miles . The car broke do2n on the express and it turned off .

Apparently the engine according to the dealership. The engine has been stalling a slow speeds usually in stop and go traffic. No because they told me they will only drive it about a half a mile and not in the same conditions as I explained. I am being told the dealership has inspected this. Absolutely nothing appeared as a warning.