2017 KIA SOUL Engine Problems

Engine threw a rod

My Kias engine had been burning oil i learned at an oil change. I was informed the engine was burning a lot of oil and i had to replace it myself.. i then decided to do an oil consumption and engine test. Kia dealership checked my engine said it looked great but i was burning more than a quart of oil every thousand miles so i had to add it but that it was fine. 1.5 week later while i was driving my car began to violently shake on the highway and my engine light went on. I panicked in morning rush hour traffic and my engine sounded like it exploded. I had to tow it to Kia where they told me the entire engine needed to be replaced and there were multiple holes in the valves. I just bought this car in 2019.. less than 100,000 miles on this...

My vehicle check engine came on and it went into limp mode, and I was unable to accelerate over 60mph on my trip from Greensboro, NC to Wilmington, NC. I drove the entire 200 miles in the right lane with my flashers on. To have it towed would have cost me over $600, so I decided to drive. This was the third time this has happened to this vehicle in the past 12 months and each time Coastal Kia said it was fixed and it wasn't. They told me that the code that kept coming up was a knock sensor, but they told me that whatever was causing the knock sensor code was not covered under warranty. They refused to tell me what was causing the knock sensor code because they said that it would cost me too much money. They told me that the rod bearing test was negative,...

Car burns through oil like no other. I won’t even be half way through my 3000 miles and with no warning the car will be low on oil and stalling in the middle of Turning. Usually when turning left. Mechanic says there isn’t an issue. But no car should be made to burn oil excessively. I can’t even make it the regular 3000 miles. Engine light has come on multiple times. Now replorting catalytic converter issue assuming that’s related to the excessive rate of oil burning.

My daughter's car 2017 Kia Soul (with low milage) suddenly went into limp mode with no previous warning lights. No indication whatsoever of any issues. It just suddenly shut down. This happened on a freeway overpass in Dallas when traffic was moving at 70mph. All of the sudden, my daughter's car began to slow down dramatically and wouldn't speed back up. Freeway overpasses in Dallas are many, many stories above ground level, and traffic backed up behind her. This could have easily caused a catastrophic accident, but thankfully, she was able to limp off of the highway unscathed. Then my [XXX] daughter had to sit in her car on the side of a highway for hours until we could get her help. The problem? Kia's known, but ignored issue of burning oil. Despite her car being within the window of the oil change mileage, her car had burned through the...

The contact owns a 2017 Kia Soul. The contact stated while driving 30 MPH, the vehicle made an abnormal sound, the vehicle lost power and the engine became inoperable. The check engine and oil warning lights were illuminated. The vehicle was towed to the residence. The vehicle was diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty engine. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was 89,200.

The contact owned a 2017 Kia Soul. The contact stated while driving at approximately 70 MPH on the interstate, black smoke emanated from the engine compartment. The vehicle was steered to the side of the road and the flames of the vehicle grew larger. The contact exited the vehicle when suddenly it exploded. The low oil pressure, air bag, and ABS warning lights were illuminated. The fire department extinguished the fire. The police department was on the scene and confirmed that the fire department filed a report. There were no injuries sustained. The vehicle was towed to a tow lot where it was deemed destroyed. The manufacturer was notified of the failure. The failure mileage was 109,000.

The contact owns a 2017 Kia Soul. The contact stated while his wife was driving approximately 65 MPH, the vehicle lost motive power and stalled. The vehicle was towed to the residence and diagnosed by an independent mechanic who determined that the rod bearings had failed and caused damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 68,000.

The contact owns a 2017 Kia Soul. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that smoke entered the cabin of the vehicle. The contact stated she was able to safely drive the vehicle to the shoulder of the roadway. The vehicle was towed to the dealer. The vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 80,806.

The contact owned a 2017 Kia Soul. The contact stated that while driving at 40 MPH, the vehicle started to smoke under the hood. The contact noticed that there was a fire under the hood. The fire was extinguished by the fire department. A police report was filed. No warning light was illuminated. The vehicle was towed to a lot. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 67,000. The VIN was not available.

I HAVE PROBLEMS WITH THE OIL LEAKS. I was told that the oil was leaking from my plug from Precision Tune Auto Care 312 W. Plaza Dr. Mooresville NC. 28117 phone ( 704 )799- 0874. My car had been losing oil and I was told that my plug was losing the oil. I

While driving car began shaking, which lead to a puff of white smoke then blac smoke followed by car locking up in highway. Break petal would not move and when put in neutral power steering was gone every though car was on and everything else besides break worked. Turn on and off and car drive off again with strong shaking. When taken to mechanic I was told a spark plug melted into the engine and the shaking caused one of the ignition coil to become loose and oil to seep in. Now I am being told I need a new engine, all fluids where fine and oil had just been changed Thursday prior to incident, car is unsafe to drive because of random lock ups and extreme shaking

Car has 41,900 miles on it. Engine rod blew through the bottom of the engine without warning 900 miles after last oil change. All maintenance records are with Kia and up to date. Denied a replacement because the car's VIN is not included in the past "Product Improvement Campaign". All symptoms of this engine breaking are in line with the previous years issues. Hoping there is a recall on these later years because there is no help right now.

On 6/30/23 While exiting the highway and waiting at a traffic light he noticed smoke coming from the hood. As he proceeded through the intersection to pull over the dashboard lit up with many lights and then the power went out. He was able to coast to the side of the road. A Police Officer happened to be nearby and called the fire department. When they arrived and opened the hood the engine compartment was in flames. They put the fire out and then the car was towed to a storage yard. A claim was filed with the insurance who then had the car moved to the dealership for repairs. On 7/5/23 Upon arrival, the service advisor proceeded to do their normal intake, put the key in the ignition, and started the car which then burst into flames and became a total loss. The regular driver of the car is...

The contact owns a 2017 Kia Soul. The contact stated while driving 60-65 MPH, the vehicle started pulling to the right. There was no warning light illuminated. The contact stated that she allowed the vehicle to pull to right lane as there was no traffic, and the vehicle struck the guard rail. The vehicle then stopped and made an abnormal banging sound. The vehicle was towed to a local Pep Boys, where it was diagnosed that there was a hole in the engine. The vehicle was then towed to an unknown dealer, where it was determined that the engine needed to be replaced. The dealer informed the contact that the vehicle was out of warranty and would be repaired out-of-pocket. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer was not notified of the failure. The failure mileage was 113,845.

The engine of my vehicle began to make a knocking sound while driving, without a warning. It was diagnosed to be due to a broken rod and excessive cylinder clearance, leading to faulty engine, that needs replacement. Yes, it is available for inspection. Due to being stranded off the freeway for over 4 hours, over 300 miles from home, myself and 1 other person were left stranded overnight without a vehicle. We had to pay for an unplanned hotel room for the night and U-Haul to tow the car back home. We did not drive the car further, because we were worried about the possibility of the car and engine overheating or getting worse. Yes, the issue has been diagnosed by a AAA mechanic and Kia service mechanic, who notified me that this issue is common among many other Kias. The Kia service department notified me that I need the...

The car engine made a clamoring noise and sudden seized up and stopped in the middle of traffic. The hood started smoking and a good Samaritan passed by and alerted me to get out of car. I did and noticed puddle of liquid was in flames and soon the front of the car was also in flames.

The contact owns a 2017 Kia Soul. The contact stated that while driving at various speeds, the vehicle would not properly accelerate. The check engine warning light remain illuminated, and the vehicle stalled. The vehicle was towed to the local dealer to be diagnosed and the contact was informed that the engine failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 183,000.

Engine light flashes every 6 weeks. I have to have my oil checked weekly as it is constantly low despite not apparent leaks.

The contact owns a 2017 Kia Soul. The contact stated that there was a continual clicking sound coming from the front of the vehicle while making a left or right turn. Additionally, while the brake pedal was depressed, there was a clicking sound coming from the engine compartment. Additionally, when the brake pedal was depressed, the oil light illuminated. The contact stated that after the brake pedal was released, the warning light disappeared. The contact stated that on another occasion, while driving approximately 5 MPH, the vehicle lunged forward and stalled. The vehicle failed to restart. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 74,000.

The contact owns a 2017 Kia Soul. The contact stated that while her friend was driving at an undisclosed speed, he heard an abnormal sound inside the vehicle then the vehicle started to decelerate without warning. The contact then stated that other drivers on the road alerted the contact’s friend that a fire had ignited underneath the vehicle. No warning lights were illuminated. The contact’s friend was able to pull the vehicle off the road and exit the vehicle. The local authorities were notified and extinguished the fire. No injuries were sustained. No medical attention was required. A police report was filed. The vehicle was towed to a collision lot where the technician diagnosed the vehicle that the engine failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and the contact was informed of the NHTSA Campaign Number: 22V031000 (Air Bags)....

First, on January 13, 2023, my 2017 Kia Soul leaked all but 1/4qt. oil while parked in a lot for about 30 minutes. There was no indication of an issue prior to the event. I just happened to see the puddle while walking to my car. On this date I had 64,100miles on the car. I was stranded in a parking lot 3 hours from home for over 9 hours. Mobile mechanic stated it looked like a loose oil filter and did a complete oil change (to include the filter). He said had I tried to drive my car, I would have blown my engine within a few miles. He also stated that the oil pressure sensor was not in good shape and needed replaced as soon as I could do so; within a week,the sensor was replaced. No items available for I inspection but mechanic bills available. Aside from...

I am writing this letter to inform you of what I feel is an unacceptable situation. On November 17, 2022, my friend and I were heading to a veterinary specialist about 3 hours from where we live. On the way there the engine in her 2017 KIA Soul with about 85,000 miles on it started knocking. I said this isn’t right, so we called for a tow. We had it towed back to our local mechanic, and they said it was a low-end engine knock. The mechanic called the local KIA dealership’s service department to see if it was covered by the warranty. The KIA rep asked for the VIN after which they informed the mechanic since Julie did not respond to a letter (not a recall) sent out about a software upgrade that needed to be done to detect the problem early, it was not covered. She never saw...

The contact owns a 2017 Kia Soul. The contact stated her daughter parked the vehicle however, the vehicle failed to restart. The contact stated unknown warning lights were illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer the next day, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was 84,435.

The contact owns a 2017 Kia Soul. The contact stated while driving at an undisclosed speed, the oil warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the oil filter needed to be replaced. The vehicle was repaired, and an oil change service was performed; however, the failure persisted. The contact stated that the oil warning light was intermittently illuminated. The vehicle was then taken to two independent mechanics, who diagnosed that the engine needed to be replaced; however, the contact was advised to take the vehicle to a local dealer for further diagnostic test and repair. The contact made various local dealers aware of the failure; however, the vehicle had not yet been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 72,859.

The car has been back for two for oil consumptions test at 1000 miles and is burning about 5 quarts every thousand miles.

My kia has been having a issue with the check engine light on blinking after driving it over 30 miles... The car then slows down to 2rpm and I'm really concerned about this after 2other people I know are having that same problem.

On January 16, 2023, my engine suddenly died while driving in moderate traffic, with a loud banging noise. I could have been in a serious accident, or killed, due to manufacturer and dealer negligence. When I was able to restart the car, it knocked terribly, but I was (barely) able to get it the short distance back to my home, where I discovered that there was very little oil in the car, though I have it changed more frequently than recommended and check it, as well. NO WARNING LIGHT came on. On January 17, I called a local dealer, who informed me of a recall that addressed that issue, though I NEVER received a recall notice. The dealer where I bought the car confirmed that this was a safety recall issue, and therefore, since I hadn't done the recall, because I was not notified, my unsafe, barely drivable car would...

On 11/07/22 my car started to sputter & lose power while going up a hill, the incident only lasted a few seconds with no warning lights. Later that same day my car wouldn't start and when it finally did start it started sputtering, had no power with no warning lights, plus there was a strong smell of gas from inside the car. I had the car towed to a local shop. The shop cleaned the injectors, put a fuel treatment in the tank and replaced a bad O2 censor. 8 Days later on another hill it happened again. A hard sputtering followed by loss of power, still no warning lights but also no smell of gas. I drove it back to the same shop and after just one day the shop could not get my car to reproduce the same incident but was having difficulty starting it so they installed...

We had a computer flash done and it has not ran right since. Engine started knocking and almost caused and accident engine felt like it was locking up causing the car to lose control

The car died, found out it was the engine. We didn’t own the car for the 2019 recall and was never told. We owed 7,000 on a dead car.

On the day after Thanksgiving 11/26/22, I was driving this vehicle home via the interstate when it began to decelerate without any warning. I pressed to accelerator and the car began moving slower and slower. I pulled off at the nearest exit and as I was exiting the interstate, the car almost completely stalled on me, idling very rough at the red light. While waiting for the light to turn, the engine light illuminated and began flashing. I live a mile from the interstate but I was able to make it home. I was very nervous because the car jerked and shuddered like it was about to die on me in the middle of the road. The next morning, I took the car next door to my residence and has some diagnostics ran on it. I was told that the car needed new spark plugs and coils. After paying for...

The contact owns a 2017 Kia Soul. The contact stated while driving 55 MPH, the vehicle started to hesitate then stalled. The contact stated there was no warning light illuminated. The contact restarted the vehicle but was only able to pull to the side of the road. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the engine needed to be replaced. The vehicle was not repaired. The contact towed the vehicle to her residence and then towed the vehicle to the local dealer. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 83,000.

The contact owns a 2017 Kia Soul. The contact stated while driving 45 MPH, the vehicle started jerking abnormally. There was no warning light illuminated. The contact pulled over to the side of the road and had the vehicle towed to the residence. The vehicle was then taken to the dealer to be diagnosed. The contact was informed that the engine needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was contacted but offered no additional assistance. The failure mileage was 120,000.

The oil light flickers at idle.... weak oil pressure. Blowby issues. Oil consumption an usage excessive...only has 130.000 miles. taken consistent care of it on oil changes. Motor louder than normal. Ticking sounds an loud tacking. I think the engine going south. The date shows it to be 12/16 model.but the serial numbers show it to be 17/17 what's up with that.... I believe the engine was left over 16 year. The one with problems. I need this thing fixed, it's my daughter's work car!!! She's been having to drive my truck to get to work....

NO CODES KICKED BUT WHEN I SWERVED TO MISS SOMETHING IN ROAD OIL LIGHT CAME ON AND WENT RIGHT BACK OFF GOT HOME CHECKED OIL IT WAS 2 QT L0W I HAD JUST HAD THE OIL CHANGED I ADDED OIL AND SAME THING HAPPENED AGAIN SHORTLY AFTER THE NEXT OIL CHANGE. THEN ON IMY WAY HOME ONE NIGHT THE ENGINE BLEW!!! ALL THIS STARTED AT BETWEEN 60 AND 70 THOUSAND MILES ENGINE BLOWN AT 112,000 MILES. I HAD THE ENGINE REPLACED AND HAD TO GET A NEW CATALITIC CONVERTER. WHEN THIS ENGINE REACH 70,OOO MILES IT STARTED HAPPENING AGAIN I HAVE HAD TO ADD 2 QTS OF OIL OFTEN TO KEEP IT GOING. AFTER CHECKING THIS SAME ENGINE IN THE 2011-2016 WAS RECALLED. KIA WAS ALLOWED TO KEEP PUTTING SAME DEFECTIVE ENGINE IN THE 2017 AND UP CARS WITHOUT FIXING THE PROBLEM. WHY IS THE 2017 ENGINE NOT RECALLED? 2nd...

I was driving down the interstate and my car made a loud noise, so I pulled over. Smoke started pouring out then it was immediately in flames. No prior issues. No injuries as I was able to get out. If fire recalls were till 2015, clearly my vehicle had issues too. What do I do?

The car will burn through almost a full 4 quarts of oil within 1000 miles. From reading online oil consumption issues are a common problem for 2014 through 2017 Kia Souls, but even some later models are having similar issues. Beyond the issue of the car burning that much oil that quick, the check oil light does not fully turn on even when the car was as the dealership put it, "Bone Dry" meaning that I as the driver had no idea that my engine could have seized up or stalled out at any moment. Also due to the fact that Kia Souls have an oil pressure driven timing chain the low oil issue extends down another level making engine stalling that much more likely. Though the most recent incendent occurred at around 94000 miles ot has been an ongoing problem for around 20000 miles.

The contact owns a 2017 Kia Soul. The contact stated that while operating the vehicle, the "low oil level" message displayed even though the engine oil had recently been changed. The vehicle was taken to the local dealer who serviced the engine for an oil consumption test. No additional information was available. The vehicle was retrieved but the failure persisted. The vehicle was taken back to the dealer who had replaced the engine. On another occasion while driving at an undisclosed speed, the vehicle started to shake and vibrate with the check engine warning light illuminated. The vehicle was towed back to the dealer who diagnosed that the catalytic converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 80,000.

May 2021 catalytic converter failed on vehicle. It was on back order and could not be replaced until July 2021 at 106,612 miles. At that time, I had dealership and national check for any recalls or recommended repairs. There were none. November 18, 2021, while siting at a stop light, engine suddenly began to knock loudly, I pulled over immediately and had it towed to dealership, at 118,729. Engine failure due to rod bearing failure. Engine had to be replaced. National claims there was a recall repair that was not performed before November 2021. As of oil change in October 2021, there was none. Recall repair was issued first week of November 2021. I received the mailed flyer after November 21, 2021.

Bought 2017 Kia Soul from Carmax Jan 2021 w/MaxCare extended warranty. All maintenance had been done as scheduled and no problems no warning lights. At approx 79K miles, on 9-14-22 , noticed a slight knocking sound. had already sched an oil change so i asked them to check out the knocking. Tech said there was metal in my oil but it was not a big deal, just get the oil changed more often. 9-15 picked it up, the knocking seemed to go away a little drove approx 10 miles home. 9-16, started it up and the knocking and rattling were terrible engine light came on and car died. luckily i was in my driveway and not on the highway or driving in traffic, i count myself lucky that my car did not catch on fire like many others. 9-19 paid to tow to a repair shop on my warranty plan,...

The contact owns a 2017 Kia Soul. The contact stated while driving approximately 50-60 MPH, the vehicle emitted an abnormal sound and stalled. There was no warning light illuminated. The contact was able to veer to the side of the roadway. The vehicle failed to restart after several attempts. The vehicle was towed to an independent mechanic and the contact was informed that the engine needed to be replaced. The vehicle was then towed to the residence. The local dealer and an unknown dealer were notified of the failure but had not called the contact back. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. There was no additional assistance provided. The failure mileage was approximately 120,000.

On or about June 20, 2022, I began an approximate 700 mile roundtrip from my home to the Oregon Sunstone Mines in SE Oregon. Approximately half way into the trip (and in the mountainous area where cell service is spotty at best and non-existant at most) my KIA Soul lost all propulsion beyond a top speed of 30MPH. With highway traffic, which consisted mostly of semi trucks and campers, trying to pass me on this two lane highway I was forced to impede the flow of traffic until I could find a place to pull to the side of the road. Once I pulled over I called my dealership to explain the problem. When I returned home I took the vehicle in to the dealership immediately. The problem was diagnosed as the Turbo which apparently got so hot it welded itself to the manifold. Since the vehicle was still under...

The contact owned a 2017 Kia Soul. The contact stated that while driving at highway speeds, a cloud of black-colored smoke began to emit from the vehicle without warning. The contact attempted to stop the vehicle by depressing the brake pedal; however, the brakes failed to operate as needed. The contact used his emergency brake to stop and immediately exited the vehicle. Upon exiting the vehicle, the vehicle quickly caught fire; by the time the fire department arrived, the vehicle was incinerated. A fire report and police report were both filed, and no injuries were reported. The vehicle's remains were towed to an independent tow yard. The contact went to the unknown dealer where he was informed that there were no recalls on the vehicle. The manufacturer had yet to be notified of the failure. The vehicle was destroyed. The failure mileage was approximately 61,000.

The contact owns a 2017 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to a tow yard where an independent mechanic diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 113,000.

Purchased used Kia Soul 2017 and extended warranty in October 2020, in Niles, Michigan. Engine failed at 44,000 miles (approx. May 2022) in San Diego, CA. Towed to Kia Dealer, El Cajon, CA. Waited four weeks for new engine to be installed (Purchase of extended warranty covered cost of replaced engine). Drove vehicle for one week and then total engine failure on second engine. Towed to Kia, El Cajon, CA. Dealer provided no explanation other than "engines come wrapped to us, and we don't know if it is good or bad before we put it in the car." Totally unacceptable. Luckily, engine failure happened as it was exiting the freeway (San Diego) and was able to safely get to the curb on both occasions. Because vehicle was needed to drive from San Diego to Michigan (moving), and Dealer has had vehicle since second engine failure, Dealer agreed to buy vehicle,...

On the freeway the engine began knocking and died very shortly afterwards. Vehicle had been well maintained and there were no warning lights.

Kia was supposed to send me recall notifications. However I am the second owner of the car and kia told me on the phone that they sent my recall notifications to the original owner. I currently have unprepared recalls on my car. I made an appointment with a dealership and they had a 2 month waiting list to get my car serviced. While waiting for that 2 months to go by, while driving on the highway at 65 mph, my engine seized due to one of their recalls. I almost crashed because of that. Now I'm trying to get my engine repaired due to a manufacturers defect and kia is refusing to fix it. I have exhausted all other options and don't know what to do. But this is definitely a safety issue.

The contact owned a 2017 Kia Soul. The contact stated that while driving at various speeds, an abnormal, knocking noise would emit from the engine without warning. The contact notified the dealer and they informed him that the knocking noise was normal vehicle operation. The contact then stated that while driving at 60 MPH as the knocking noise persisted, the noise grew increasing louder without warning. The contact looked out of his rearview mirror and saw a cloud of white smoke coming from underneath the vehicle. As he pulled over, he inspected the hood and saw flames encroaching towards the front driver's seat. The contact instructed his girlfriend to exit the vehicle, as he went back to retrieve a cell phone, he burned the hairs off both arms, and his right leg, as well as some hair on his head and face. The contact called the authorities while the vehicle...

My cars check engine light has come on at 87,659 miles with a p0420 code. My dealer has determined that this is a defective catalytic converter and because of the mileage it is not warrantied. In doing research the 2012-2016 Kia Soul with the 1.6 gdi engine. My car is a 2017 experiencing the same symptoms as the cars a year older. The recall campaign is 19v120000 with the NHTSA and SC 176 with KIA dating back to 04/17/2019. My cars model year being a 2017 had not been determined at that time to be effected as the mileage had not yet accumulated to the mileage of the previous years. Now that my 2017 car had reached the mileage in which previous cars where effected , it too is experiencing this defect. The safety issue lies in that when the car is driven it could overheat without any warning lights...