2016 KIA OPTIMA Engine Problems

I was told that my engine had a recall on it so I had an upcoming appointment with Kia in like 2 weeks for them to check my engine but the car didn’t make it. I was driving my car on interstate 20 my car had began to have a bad chemical smell and started smoking so I pulled over on the interstate and my car was in flames. Me and my daughter was in the car we could have lost our lives thank God we were able to make it out just in time. The fire department came and made a report on the incident. It wasn’t any engine light on at the time. I have contacted Kia about the tragedy that has happened but nothing has been resolved yet.

The contact owns a 2016 Kia Optima. The contact stated while driving at undisclosed speeds, the vehicle was jerking abnormally. The vehicle was restarted several times; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed with oil leaking into the spark plugs causing an engine misfire. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the dealer to be diagnosed. The vehicle was diagnosed with engine failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,000.

Was on highway, engine seized, flashing engine light and knlocking noise, car went into limp mode, took to dealership code p1326 was thrown which is engine failure, I have had the knock sensor installed thru kia prior which put me in lifetime warranty for the engine, kia dealership did a diagnostic BCT, which is a 4 to 5 hour job at the most, kia called me in less than 2 hours and told me is passed the BCT ! there is no way they did the testing in less than 2 hours, and no way it passed with engine light blinking and knocking, that's what the sensor detects is engine failure, they are refusing to honor my warranty for the new engine , picked up my car from. Dealership, soon as I hit the end of the parking lot engine seized and loud knocking noise, was barely drivable but yet...

UNKNOWN

Vehicle first went into “limp mode” and dealer said high voltage recall needed to be done. Worked ok for a while then again “limp mode” dealer said knock sensor recall was happening and knock sensor was replaced. Few weeks ago limp mode again, all during car was moving in traffic. Car currently sitting at a Kia dealer, knock sensor again, haven’t heard from Kia regarding engine replacement

The Hybrid Battery continues to malfunction and, randomly shuts down at any speed (even after short engine block was "repaired" by Kia Dealership). Also, an odor of burnt oil happens often while driving the car. It is available for inspection, if need be. Safety of all drivers at risk because car shuts down on freeways and highways. It's dangerous where cars driving at speeds of 65 mph are unable to break and avoid collision. Kia calls their RECALLS "CAMPAIGNS". The Kia dealer has acknowledged this problem and has performed maintenance, however the problem still persists. I have the recent receipt of service/ maintenance on my 2016 Kia Optima Hybrid on hand. The first time it happened was on September 25, 2021. There were no warning lights or messages, the car simply shut down and had no power and was not drivable. I took it to a hybrid mechanic who ran...

Lost power while driving. Likely seized engine.

While driving home on the interstate the vehicle had a sudden loss of power. No warning lights or check engine lights were on prior to this incident. The vehicle would not start and I had it towed to a dealership who told me that the engine was low on oil and that KIA would not be covering the engine replacement. I provided the dealership/KIA with all of my service records showing that I had performed all maintenance to my vehicle at KIA dealerships and that I had never skipped any recommended repairs. I also pointed out that there was never any notes made that I should be monitoring for excessive engine oil consumption or that I had a leak anywhere to be found. Despite having all of my records in order, all of my services performed at a KIA dealership and in a timely manner, no low oil lights that...

The engine almost caught on fire. Windows are all down .

Engine failure; oil consumption, misfire, smoking, losing sped, no acceleration. Problem has been diagnosed by 3 mechanics in a mechanic shop. Only warning was the check engine light

My engine has been consuming oil since 30,000 miles. It consumes in excess of 1 qt per 500 miles. There's zero dripping oil from under my car, it's all being consumed. I've lost power and gone into limp mode because it's consumed too much oil and ran dry in between regular oil changes. Kia has not helped me. I've done more than 5 consumption tests with a Kia dealer. And now Kia says that it's a warranty event. However they will not accept my warranty event without evidence of every self oil change such as receipts for oil filters or oil. I don't have all of these records so Kia refuses to repair my vehicle.

Heavy oil consumption , unintended acceleration , car jerks . Back window occasionally won’t roll down .

I'm noticing that I'm burning oil frequently. I started to notice this becoming an issue summer of 2023. Once when I get an oil change about 3-4 Weeks later my oil light comes on. Then I would have to put oil and my car. The dealership always ask me if I'm sure that I want an oil change because I haven't hit my time for an oil change. 26th Feb 2024 I spoke with Kia Customer Care and they stated that this is not an issue and that oil consumption is not under warranty. I stated that I didn't inquire about the oil consumption. I repeated my question asking if it's a known issue that the Kia optimas burn oil. Angel the customer care representative stated that it isnt. However, I started how is when I took my car to numerous dealerships and mechanics that they all said the same...

Engine is burning 2qts of oil every 500-900 miles. Risk of engine seizing during drive.

Oil light continues to come on only after 1 month of a 5 quart oil change. Only driving about 300 miles a month. Have taken it to a kia dealership where they said there was no oil leak. Took it to a private mechanic for a second opinion where I monitored my miles after an oil change and they found that it is an engine problem and the engine is burning my oil. This has been happening for the past 6 months. I did not have the mechanic fix the issue as it should be covered through the manufacturers warranty.

When I was coming home from work my car lost power and didn’t accelerate anymore when I was on the freeway. I almost didn’t make it to the shoulder when trying to pull over. Every single light I could imagine came on when I was trying to pull over, It said check hybrid system, BSP system failed, etc. All the lights came on at once. My car didn’t start, so I had to wait on the side of the freeway at 4am for a ride and a tow. Kia told me that I need service records to prove that I was up on my maintenance and that the reason my engine failed was at no fault of my own, But I am up on maintenance. That same dealership had my car in February 2023 and said my car was in perfect condition and up on maintenance, I just needed a...

The contact owns a 2016 Kia Optima. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the turbo booster sensor and turbo charger. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 114,000.

Since 08/07/21 I’ve been having intermittent issues with my oil light and engine light coming on. I have had all repairs recommended by the Mark KIA Scottsdale, AZ dealership yet my oil consumption has increased significantly and the oil light continues to come on: On 02/14/24 I took my car to a local auto repair shop to get a second opinion due to the oil light coming off and on; they found the engine oil very low and only 1 quart came out when doing the oil change; they also recommended injection induction service which I’ve had done twice previously with the KIA dealership

Engine is burning 2qts of oil every 500-900 miles. Risk of engine seizing during drive or engine compartment fire…both very dangerous for occupants of vehicle. Case opened with Kia…no response back.

Constantly burning oil every 500 - 1,000 miles. There is a huge issue with these engines there needs to be a recall to replace or fix these engines.

The contact owns a 2016 Kia Optima. The contact stated while driving 80 MPH, the vehicle began sputtering. The check engine warning light was flashing. The contact stated that several unknown warning lights were illuminated. The contact pulled over and heard an abnormal knocking sound coming from the engine. The vehicle was taken to an independent mechanic, who informed her that the code P1326 (Knock Sensor Failure) was retrieved. The mechanic informed the contact that an engine replacement was needed. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 150,000.

I see there is recall on some Kia Optima with the oil being loss and knocking of the engine. I keep up the maintenance on my car and this particular issue is happening with my car. Why is there only some optimas recall for this issue.

The contact owns a 2016 Kia Optima. The contact stated that while her husband was driving at an undisclosed speed, the low oil pressure warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the oil pressure switch. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin Number: 237. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 45,000.

Starting to burn oil started it at 40,000 miles it burns 3 quarts in less than a 1,000 miles worrying that it might be one of this that catch on fire

2.4 motor burns excessive amount of oil, has a serious loss of power. The dealer informed me the only way to get a new motor or get it fixed is for motor to blow. The dealer informed me that this is a common problem with 2016 kia 2.4 motors. Currently burning 5 qts of oil every 2-3 weeks. Fouling spark plugs every 4-6 months. Car hesitate to take off even with accelerator to floor

Engine failure . Engine failed on highway car wouldn’t go past 15 MPH. Then suddenly accelerated

My 2016 kia optima shut off on me and would not start on December 20th 2023. I had the vehicle towed to bergeys kia and they looked at the vehicle and said that it was the engine and it would cost between $6,000-10,000 to replace the engine. The vehicle has never had any problems. I do not bring my car to kia for oil changes because it is really expensive so we do that at home and kia is telling me they can’t fix my engine because I do not have a receipt of the maintenance. The engine has a recall and I was never notified about it. My vehicle was in their shop on September 6th 2023 and I was not notified then either. I am a single mother and I currently do not have a vehicle to take my son to and from school or to get to...

My car burns lots of oil also hear motor knocking with oil in it.

Engine light is blinking

While we were driving home (3 people in my car), with no notice, my car lost complete acceleration and broke down while we were on the highway. We hardly had notice to understand what was happening, let alone the other cars/people behind us on the highway where we almost got hit before being able to pull over to the side of the highway. We then had to wait for a tow-truck, again, on the shoulder of a very busy highway. Later, I came to find out that this was "sudden and unexpected engine failure" that occurs in multiple models of Kia and Hyundai that was included in the Hyundai and Kia Engine Litigation, Case No. 8:17-cv-00838, and Hyundai and Kia Engine Litigation II, No. 8:18-cv-02223-JLS-JDE, New Theta II Class Action Lawsuit. Unfortunately, this was the first time I had heard of this, as I'd never received any recalls or notices...

My Kia Optima randomly stops working while driving. I get a notice that says, "HEV: Check Hybrid System. Stop Vehicle and Turn Off Engine." Also the gas pedal stops working, leaving me to try to coast to safety. The car essentially stops working in the middle of driving, without warning. Once this happened and blew out the spark plug, requiring a new one. Then, a day or two later, the car returns to normal. The Kia dealership could not reproduce the problem, nor could my service center. They say it's fine. I took my car in for previous recalls, and it is currently "up to date." This appears to be the same electrical issue as a recent recall for electrical failure, but the dealership told me the spark plug was fine and that I should change the battery. I did and this still happened. I do not feel safe driving...

The contact owns a 2016 Kia Optima. The contact stated that while driving at approximately 70 MPH, the vehicle decelerated and went into LIMP Mode. The vehicle failed to go over 2,000 RPM. The vehicle was shaking and shuddering violently. There was a loud knocking sound detected at 1,500 RPM. There was an abnormal odor detected from the exhaust pipe. The check engine warning light was illuminated and flashing. The vehicle was taken to the local dealer, where it was diagnosed that the engine needed to be replaced. The engine was replaced on three occasions. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the same dealer, who replaced the engine and catalytic converter. The vehicle was taken to another local dealer, Kia Coughlin of Lancaster (784 N Columbus St., Lancaster, OH 43130), where it was diagnosed and determined that an engine replacement was needed....

Loss of power. Was driving across a 4 lane intersection and the vehicle lost power. The engine light came on. I stopped and check the oil and it was 2 quarts low. We had just changed oil less than 2,000 mikes ago. I tool the car to parts store and they said it was a p0309 code. That #4 cylinder misfire. It was either coil or spark plug. I replaced both coil and spark plugs 15,000 miles ago. The plug was covered in oil had black oiley substance covered on the spark area. I had similar loss of power due to oil burning 15,000 miles ago. The car has 97,720. This is an ongoing safety issue.

Purchased this car in July of this year. I checked all fluids prior to purchase and after driving it for 30 days the oil light flicked then went off. I decided to check the oil and it was 2 quarts low. I immediately called my extended warranty and they said to take it to the shop. After it being there for 3 months they said it was the rings in the piston and it needed a new motor. They referred to it as excessive oil consumption. Of course the warranty company Old Republic refused to cover it because it’s a on going issue with this model car.

Car is leaking oil. It is not only visible but I can smell it as well. Visibly it looks like its leaking onto the heat shield. This is very dangerous as heat shield gets extremely hot since it is over the exhaust. Also visible are the stains on my driveway. Additionally, I have been measuring oil levels and it is dropping slowly.

Engine cuts out while driving. Engine light comes on. Unavailable to turn on hazard blinkers. Can restart engine after a few minutes . Also gas mileage has gone down.

When accelerating the car will randomly loose all power from the engine. The electrical systems will stay on but the car RPMs will drop to zero. The accelerator will not provide acceleration when being pressed. The car has to be turned off and then turned back on for power to be restored. The check engine light, the oil light and another warning light will come on.

We have had two motor replacements in less than 6 months that we have owned this vehicle for the first one started started a knocking noise right after a flashing check engine light both Kia is by us totus will we can't get it in today wouldn't give us a rental and was going to charge us for a diagnostics fee right up front and told us it would still be a few days before they could get it in so we had no choice but to continue driving it not even 2 days later left my fiance on the side of the road wouldn't start wouldn't do nothing engine seized Kia dealer number one put the motor put it back together wrong and then when it seized again in less than 5,000 mi try telling us that they weren't responsible well if we did the engine again give it...

Lurches at highway speeds and nearly stalled.

it appears the engine is burning oil or leaking. I have been needing to fill up with oil every 1,000 miles. There is a very faint smell of burning every now and then. I was told by Kia that the oil pump needed to be replaced along side with the oil pan, i had that replaced at in independent shop however it still seems to be having the same issue. No risk to me while driving

I found my car on a list of recalls. The recall is NHTSA ID: 23V-652000. Why was I not notified of this recall. This is a serious recall that Kia has no fix for. I can't believe that Kia is putting people and families at risk. This plan that Kia has is ridiculous and unprofessional. You want people to park cars outside of there garages. That does not work. Kia needs a better plan and thats to come up with a fix and NOW!

The contact owns a 2016 Kia Optima. The contact stated while driving approximately 40 MPH, the vehicle was shaking and making an abnormal knocking sound. The contact was able to pull over and had the vehicle towed to the residence. There were no warning lights illuminated. The vehicle was trailered to the local dealer, where it was diagnosed that the engine was blown and needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 107,000.

my 2016 kia optima start at 60000 miles was using about a qt.ever 800-1000 miles under the 10yr. 100000 warranty they replaced the motor with about 80000 miles on it now with new motor now with about 80000 miles on 2nd.motor it doing the something they did all text now at 1000 miles I'm using about 3qt. after all the tests they say nothing they can do.was told after test was done if all checked out nothing they could do it did not pass they would replace motor when test started i was using 2-qt. every 1000 miles after they did there combustion cleaning i felled test and now use 3-qt. every 1000 mile now back 2 sq. 1 nothing they can do. ANY HELP WITH THIS MATTER WOULD BE GREAT!

Driving 80 miles an hour several hours from home on a major interstate and my car shut off. Pulled over on side of interstate and check engine light came on and car won’t accelerate and is making a knocking noise

The motor is knock and no acceleration . Burning oil to much. Get oil change but adding oil everyday.

The contact owns a 2016 Kia Optima. The contact stated while driving at an undisclosed speed, the vehicle started shaking violently. The contact pulled into a parking area where the vehicle stalled and failed to restart. The contact also stated that the low-oil warning light was illuminated intermittently. The contact stated that frequent oil top off was needed. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic but was not yet diagnosed. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was 80,000.

It started shaking really bad out of no where , then wasn’t going faster than 80 then down to 65 but wouldn’t go more than 80 with my foot all the way on the gas. As soon as I made it to work tonight the car cut off. I got a jump the car was still shaking & wouldn’t stay on if I let my foot off of the gas. I started it again without the cables but it cut right back off. I saw on cars.com it’s a recall for the similar thing, number Sc172. I have been having fuel leaks for a while and had my knock sensor replaced from a previous recall. Now I have no way home.

Vehicle Dash Check Engine Light came on 08/31/2023 Code P200A was found. Several weeks went by and vehicle started to hesitate pretty bad Vehicle was towed to Kia dealership on 10/04/2023 : Was told engine failure which needed replacement along with intake and several other required parts. Covered under Powertrain Warranty, vehicle was completed and ready for pick up on 10/17/2023 On 10/24/2023, on my way home from work, Dash Warning "Engine has overheated" has came on. Vehicle was towed back to original dealership. Kia reportedly found "air pocket" in cooling system. Vehicle was ready for pickup same day. On 10/30/2023, on my way to work, Dash Warning "Engine has overheated" has once again came on. Luckily I was able to get off the interstate and happened to be by a Kia dealership in the area. At this time, info is pending.

The car fails to respond to throttle. It does it randomly every one in a while. It's very dangerous. There are no check engine lights or anything. The car can run for weeks beautiful and all of a sudden you hit the gas and the car doesn't move. It can take 3-4 seconds before it responds.

Car purchased in 11/2022 with roughly 60,000 miles. I have owned the car for about 11 months. When we took the car for its first oil change there was no oil registering on the dipstick. The engine began knocking before the second oil change was due and after checking the oil I needed to aff 4.5 quarts of oil. I took the car to my mechanic was informed that there was no oil leak and that KIA engines were known for oil consumption and engine failure. He recommended I take the car to a dealership. I spoke with KIA corporate at this point and they said the car needed an oil consumption test before they would possibly help me. I scheduled an appointment at a Kia dealer for the test and when I took the car on 10/26/2023. They started it and refused to do the oil consumption test stating...