2016 KIA OPTIMA Electrical System Problems

Vehicle: 2016 Kia Optima LX Turbo – Approx. 114,155 miles** This complaint concerns ongoing systemic defects affecting the electrical, braking, and engine management systems of the referenced vehicle. Despite multiple documented repair attempts, the failures persist, creating continuous and significant safety hazards. The vehicle has experienced repeated electrical system malfunctions, including multiple battery failures (three replacements within one year), sustained low-voltage conditions, and intermittent lighting loss. Notably, the headlights and exterior lighting have shut off unexpectedly during extended highway operation. The brake control system is also compromised. The electronic emergency brake has engaged spontaneously while the vehicle was in motion, causing abrupt deceleration without driver input. Additionally, the vehicle exhibits continuous fuel vapor and engine performance defects. The purge valve has been replaced four times, yet the failure recurs. The vehicle frequently hesitates upon acceleration, exhibits delayed throttle response, and jerks during takeoff, creating hazardous conditions when merging into traffic...

Window regulator assembly failed twice within 20k miles. Attached is the first repair. Dealership only repaired motor but not full assembly and it failed again.

The headlights and brake lights have been VERY dim for a while. I've had to replace both headlights and brake lights an excessive amount in the last several years. This year alone since December 2024, I've had to replace my headlights 3 separate times. I do not drive more than 10,000 miles per year, or use my vehicle on roads that would lead me to believe the issue is from road conditions.

Complaint Message – 2016 Kia Optima Engine Failure Without Oil Light Warning I am the owner of a 2016 Kia Optima (VIN: [XXX] ). My vehicle suffered complete engine failure due to oil starvation — without any prior oil warning light or indication. The engine died while driving, and it was only afterward that I discovered the engine oil was extremely low. The oil pressure light never illuminated at any point to warn me. I am aware that Kia previously recalled earlier model years (2011–2014) for similar engine issues under Recall SC147 and others, related to the Theta II engine and oil pressure-related failures. Many owners reported the exact same symptom — catastrophic engine failure without oil light warnings — that I am now experiencing in my 2016 Optima. Although my model year is not included in the existing recall, the failure pattern appears identical. I believe this presents a...

1) Rear passenger window failed a couple months ago. I believe it was regulator, not 100% sure. Cost me a couple hundred to fix. Now, few months later, the driver side rear window has failed. I rarely use the windows so I believe the failing parts are Kia known manufacturing defect. The dealer acknowledged that it’s a known problem with the vehicles like mine and even suggested the other one is going to fail soon. Now it has. If the dealership is aware then it’s likely a Kia flaw. If it’s a know manufacturing flaw, shouldn’t Kia should be fixing them instead of making customers spend upwards of $1k+ to fix both windows? 2) cruise control cuts off or doesn’t set and menus won’t go back to speedometer. While trying to set cruise control, it gets into the menu and won’t go back to the speedometer. Sometimes I have to...

Several safety-critical systems failed on this vehicle. The engine (Theta II 2.4L GDI) failed due to rod bearing wear, causing sudden power loss on the highway. The vehicle entered limp mode, once at 50 mph in 2018 and again at 70 mph in 2025, and had to be pulled over quickly to avoid collision. Additional issues: all four windows failed at different times, leaving them stuck open and creating safety risks in weather or emergencies. The trunk latch failed, causing unsecured cargo risk. ABS, TPMS, and traction control warning lights illuminated repeatedly, indicating possible loss of critical safety systems. A loose wiring harness caused the turn signal bulb to burn out repeatedly, reducing visibility and signaling. The dealership performed the KSDS software update after I reported engine trouble but did not resolve the issue. The engine soon failed completely while driving. Other issues, such as the fuse box blowing fuses...

The contact owns a 2016 Kia Optima. The contact stated that while driving in inclement weather on several occasions, all four windows of the vehicle became intermittently inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.

3 of windows do not roll up.

A month in after purchasing the check engine light came on. My car did not want to accelerate, started shaking and having jerking movement while driving on the freeway with my newborn and 3 other children in the car with me. Got stranded 3 hours away from home. Car has been in the shop going on 30 days. Spark plugs changed, coolant thermostat changed and now the engine was reported that it has failed. Still in the shop currently.

All 4 of the window regulator motors blew in my windows at the same time, only about 9 years into the vehicle's life. The little plastic pulleys that move the cables degrade over time and then ruin the rest of the window motor when they break, and since they decided not to make this an easily repairable part it requires the entire window regulator assembly which is half of the door to be replaced, not just this plastic part. I had to replace all 4 of them out of my own money, KIA REFUSED to replace something that is completely 100% their fault and it cost me over $3,500 to repair all four windows that went out pretty much at the same time. It's insane silly that anyone's windows can just break at anytime and be stuck in the down position. I can't just put up trash bags and then...

Vehicle went into emergency mode while in the highway system completely locked could not drive lost power and was forced to pull over and have vehicle towed, mechanic took a look indicated new alternator was required there for we purchased new alternator and new battery car turned on and same issue happened with in 20 minutes of test driving vehicle, this happened twice and could have cost our life’s! I am extremely disappointed and frustrated I have no means to fix the vehicle we used out saving to finally replace what we though was the issue but I’ve come across many same issues from other parties who experienced the same issue. The vehicle is paid off and we need assistance in fixing this issue it appears the engine or electrical issue at this point but I am scared to get on the road we have tried charging it back on...

The front and rear windows come down unexpectedly. The power controls do not control the windows. This is especially dangerous when younger children are riding in the car and can reach their hands out the windows because the windows just come down. I have to manually lift my windows up

The contact owns a 2016 Kia Optima. The contact stated that the front driver’s and passenger’s side windows and the rear driver’s side and passenger’s side windows were inoperable and would not open or close. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the window regulators for each window had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The contact also stated that the exterior door handles on the front and rear passenger’s side doors had fractured. The cause of the failure was not yet determined. The vehicle was not repaired. The failure mileage was 85,000.

I purchased a 2016 KIA Optima from eCars in Wichita Ks in November of 2022. The car had no major issues until the Optima was stolen this last March. I recovered the car quickly but it was damaged. Had ignition pulled out steering column broken, window broken and lots of cosmetic damage. Was towed twice and in the shop twice. All has been fixed with auto insurance funds. I am part of the KIA theft settlement and waiting for funds to be dispersed. Second part of my issue is that on 07/22/24 the check engine light came on while I was driving to work. It was blinking which indicates a serious engine issue. I turned around and went home and parked it. I started researching KIA engine issues and found that my car is also eligible for the KIA Theta II engine class action settlement but the submission deadline was...

My vehicle has been having engine & electrical issues, I originally took the vehicle to a secondary mechanic after Kia Baltimore stated it would be a couple months before they could diagnose the issue. The secondary mechanic was changed spark plugs, and other fixes but advised the vehicle engine was still shutting down and he believe it was related to the Kia engine recall issues. Thereafter, I had the vehicle towed to Kia Towson on 5/22/23..they have had the vehicle ever since I call daily, leave messages with managers, and essentially pay car insurance and car note, and use ride share services while getting no response about my vehicle. The rental manager at the dealership doesn't return my calls, no one. This is unacceptable.

The contact owns a 2016 Kia Optima. The contact stated that on four occasions while the vehicle was parked and the window switches were depressed on all the windows, the windows failed to roll up or roll down as intended. The vehicle was taken to a dealer where it was diagnosed that the driver's side window regulator had become dismantled, allowing the glass to move up and down. The contact was informed that the window regulator and panel assembly needed to be replaced. The vehicle was repaired each time. The manufacturer was not notified of the failure. The failure mileage was approximately 21,000.

The contact owns a 2016 Kia Optima. The contact stated while starting the vehicle, there was a loud knocking sound coming from the engine, with the check engine, oil, and battery warning lights illuminated. Additionally, the contact noticed that all four windows failed to function properly and failed to roll up. The dealer was contacted; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacture was made aware of the failure. The failure mileage was approximately 124,000.

our ac keeps blowing relays. every month. and they other day we have to force power bank to the blower motor just to get it to work. half the inside and sometimes the even the outside lights works.

The Hybrid Battery continues to malfunction and, randomly shuts down at any speed (even after short engine block was "repaired" by Kia Dealership). Also, an odor of burnt oil happens often while driving the car. It is available for inspection, if need be. Safety of all drivers at risk because car shuts down on freeways and highways. It's dangerous where cars driving at speeds of 65 mph are unable to break and avoid collision. Kia calls their RECALLS "CAMPAIGNS". The Kia dealer has acknowledged this problem and has performed maintenance, however the problem still persists. I have the recent receipt of service/ maintenance on my 2016 Kia Optima Hybrid on hand. The first time it happened was on September 25, 2021. There were no warning lights or messages, the car simply shut down and had no power and was not drivable. I took it to a hybrid mechanic who ran...

The engine almost caught on fire. Windows are all down .

Engine failure; oil consumption, misfire, smoking, losing sped, no acceleration. Problem has been diagnosed by 3 mechanics in a mechanic shop. Only warning was the check engine light

Heavy oil consumption , unintended acceleration , car jerks . Back window occasionally won’t roll down .

The high voltage battery and the ability to drive or turn on completely

Since 08/07/21 I’ve been having intermittent issues with my oil light and engine light coming on. I have had all repairs recommended by the Mark KIA Scottsdale, AZ dealership yet my oil consumption has increased significantly and the oil light continues to come on: On 02/14/24 I took my car to a local auto repair shop to get a second opinion due to the oil light coming off and on; they found the engine oil very low and only 1 quart came out when doing the oil change; they also recommended injection induction service which I’ve had done twice previously with the KIA dealership

The contact owns a 2016 Kia Optima. The contact stated that while driving at an undisclosed speed, she became aware that the driver's side window was not functioning. After which, all the windows in the vehicle failed to operate as needed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with all four window regulators. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 70,000.

My Kia Optima randomly stops working while driving. I get a notice that says, "HEV: Check Hybrid System. Stop Vehicle and Turn Off Engine." Also the gas pedal stops working, leaving me to try to coast to safety. The car essentially stops working in the middle of driving, without warning. Once this happened and blew out the spark plug, requiring a new one. Then, a day or two later, the car returns to normal. The Kia dealership could not reproduce the problem, nor could my service center. They say it's fine. I took my car in for previous recalls, and it is currently "up to date." This appears to be the same electrical issue as a recent recall for electrical failure, but the dealership told me the spark plug was fine and that I should change the battery. I did and this still happened. I do not feel safe driving...

We have had two motor replacements in less than 6 months that we have owned this vehicle for the first one started started a knocking noise right after a flashing check engine light both Kia is by us totus will we can't get it in today wouldn't give us a rental and was going to charge us for a diagnostics fee right up front and told us it would still be a few days before they could get it in so we had no choice but to continue driving it not even 2 days later left my fiance on the side of the road wouldn't start wouldn't do nothing engine seized Kia dealer number one put the motor put it back together wrong and then when it seized again in less than 5,000 mi try telling us that they weren't responsible well if we did the engine again give it...

The body shop later informed me that there is a recall for engine fire recently,but my year/make is not listedin the info obtained online. The car started stalling while driving down the off. Smoke started coming through the vents. I pulled over to the side of the highway. A passerby told me that the car was on fire. Called 911. To note I had just picked the car up from Jim marsh Kia for battery replacement and problems with steering after the car was stolen in July. I had no previous issues with my car other than routine maintenance which I have records for.

At 95000 car had problem accelerating and then all of a sudden on the side of the road did that 2 had 2 engine rebuilds done no but the problem is still there and the fuses all look burnt and half my lights don't work.

The engine was has blown twice the first day 95000 miles and again at under 6000 miles. And there is still a bad knock and major vibration and ticking noise coming from the car. We told the car we no longer have faith in this car and didn't want it no more and all he did was see if he could get us another loan to trade it in. We're now scared to really ride in to and can't get no one to help us on this my man is about to lose his job over this car

Every window regulator is broken, 2 of them in the middle of the highway and the other 2 when I parked the car.

My high beams and low beams are starting to shut off randomly. When it happens, my dash shows that i am trying to turn my headlights from auto to another setting, which is not the case. It has happened at night and that poses a danger because i cant see the road and people cant see my car. I have not had it looked at yet. I do see multiple complaints online for multiple different kia models and years. There is no recall and i do not see a TSB.

I was driving and the car’s electrical completely cut out and locked my steering wheel up and ran us off the road and we hit a big rock on the driver side and then the power kicked back on and the steering yanked super hard to the right about 4 times and caught a fallen tree on the right side then completely died with me and my young kids . Took it to Kia to be serviced and got it back and it started to do it again

On July 4th, my vehicle lost engine power and flashed a quick prompt of "engine warning" before turning off completely, smoke from under the hood which resulted in a fire. I was able to extinguish it fortunately. I have since discovered there are three open recalls, which I received no notification about. I frequently check for recalls and all sites say there are none.

This will be the second time this has happened to my vehicle my vehicle just randomly stopped while driving and will not start back up. It keeps showing on the dashboard “check hybrid system stop car and turn off engine” this happen 4 years ago and then a safety recall came out for it to get fixed this should have been fixed from the safety recall and never happened again unfortunately it happened again. The dealership is booked with appointments so my car will not get fixed for about a month or two. It is very dangerous for the car to just caught off in the middle of the road.

My steering wheel locked while I was on my way to work early Monday, March 28,2022. I was driving down county road Park Avenue around 30MPH and suddenly, I was unable to move the steering at all. Luckily, I was already in the right lane =; however, it was very challenging to steer to get off the road. I called the local dealership and they suggested I bring the car in for inspection to determine what the cause is. I took the car to the dealership and I was informed the vehicle was not drivable because the Steering Wheel Column Assembly and ECU needs repair. They also informed there was no recall on the vehicle. The mileage at the time was 67,400 miles which was very surprising. I received a letter from Kia Motors in February 2022 (6 years after the car was manufactured about the recall however, most cars...

2016 Kia Optima was towed to Kia Dealer after it became inoperable; on 10/22/22 diagnostic done and found engine failure. Kia Motors denied claim for repair/replacement. Not sure why not covered under class action settlement, and/or extended warranty, or subsequent technical bulletins regarding Kia's defective engines.

Soonroof/Moonroof closed rattle noise. When the Soonroff/Moonroof is closed at highway speeds or windy weather it make a rattle noise to inside of the car, i try to do their reset method and nothing worked, i being looking in kia forums and most of the people had complained about this issue, and that kia doesnt wants to fix. I will like an investigation of this issue and if you can start a repair campaign recall due this soonroof parts are really pricey. And i think is a manufacturer problem.

Three power window regulators have failed over the course of a year. Without warning the window suddenly drops down and cannot be let up. On each occasion, the regulator gears appear to have just desecrated. The car windows are rarely let down. The passenger side rear was the first to fail. The driver's side rear failed 4 months later. The passenger side front was the third to fail 3 months later. It seems like this is a very common problem, but Kia has not set up a recall. Instead, they are raising the price of the window regulators. Interestingly enough, the new regulators have a blue gear instead of a white gear.

While driving down major highway the engine failed and the electrical system started blinking and I lost all power. No warning, dashboard just lit all up and engine seized up.

*The vehicle is burning oil at a very speedy rate....much quicker than normal. Perhaps more than a quart per 1000 miles. The car is available for inspection. *Today was the second time that I was surprised to find that there was not enough oil to even register on the dip stick. I don't yet know if there was any permanent damage to the engine. My experience seems to be very similar to many other people who have posted online....a possible flicker of the oil light before finding out about the oil deficiency. It concerns me that others said that this led to their car faltering and/or freezing up while driving. That is certainly a safety risk for the drivers/passengers and other motorists. Some people indicated that their engine was ruined and needed to be replaced. *It was the Valvoline mechanic that told me today that there was an issue with...

On Sept. 21, 2021, my Kia Optima Hybrid ex shut down and would not start. I took it to King of Hybrid EV Auto Repair where they ran a diagnostic test and found that there was an issue with the Hybrid System affecting the transmission and the High-voltage system. I paid $3,000.00 out-of-pocket. On October 26, 2022, while driving 75mph on Hwy 15 to Las Vegas, my car randomly shut down. The dash warning lights read "STOP VEHICLE TO CHARGE BATTERY". I was in an unsafe position with cars speeding past me. I was afraid that I would be rear-ended by another car. I had to have my car towed. I believe that these cars have issues with faulty high voltage systems and transmissions. Please investigate. Thank you.

On Sept. 21, 2021, my Kia Optima Hybrid ex shut down and would not start. I took it to King of Hybrid EV Auto Repair where they ran a diagnostic test and found that there was an issue with the Hybrid System affecting the transmission and the High-voltage system. I paid $3,000.00 out-of-pocket. On October 26, 2022, while driving 75mph on Hwy 15 to Las Vegas, my car randomly shut down. The dash warning lights read "STOP VEHICLE TO CHARGE BATTERY". I was in an unsafe position with cars speeding past me. I was afraid that I would be rear-ended by another car. I had to have my car towed. I believe that these cars have issues with faulty high voltage systems and transmissions. Please investigate. Thank you.

Complete power window failure (driver and 2 rear windows). Estimated repair cost is $2,084.90. This model has a history of power window defects that Kia Motors is well aware of. Over time, this defect becomes increasingly severe until you have a complete without warning failure like in my case. Kia Motors refuses to acknowledge problems and stated there is no recall by NHTSA. I want a full reimbursement for my out of pocket payment for untimely repair cost.

Was driving my car and it just lost all power and cut off. It will not start now. It only has 1 click. The car has used a lot of oil since I've owed it. I do regular oil change and the oil lights still go off and on. I researched why it had power failure and replaced the starter but that didn't work. I started looking into the engines for 2016 kias n found out some have a recall. I hope my car falls in that recall bc I need it fixed . my car gave no warning signs that anything was wrong . just cut off all of the sudden and will not start . had to have it towed to my home

I have a 2016 Kia Optima within the 2nd year all my window motors fail within a 6 month timeframe. My car in the 4th year started to burn oil quickly the oil light would not appear until I begin to hear a knocking sound. Also, in the 4th year of having my car there has been cracking in my passenger side (I think it is where the airbag is located). All of the areas could put my life in some type of danger or a family member if KIA doesn't see fit to remedy these areas. In 2018, my warranty was out and I didn't know until I received my bill the service person didn't advise me of this issue. So, I ended up paying $700 for a battery installment when I advised him that it was the issue, he insisted I get a diagnosis done.

Every window in my car has come off track within a 3months time period . The motor steady runs in the door and the window will not move up or down.

My name is E........ M........ and I'm writing this email/complaint in hopes it can be resolved or you can pass this email along to the appropriate person or persons to have this matter looked into. We purchased a used 2016 Kia Optima a few years back and have had nothing but trouble, from electrical issues, recalls, transmission issues, oil consumption, and smoke coming through the air vents!!!! and there's more, the last time we had an issue and took it to a dealer for problems shifting, hard shifts, loss of power, and smoking, we were told the dealer could not duplicate the problems while driving it and that was that, not a damn thing fixed because apparently everyone is stupid or blind and I was more than pissed. On 7/13/22 the car has been at the dealer again (for almost two weeks now, but they were so busy they just...

Car was stolen off of the street. No alarm went off, keys were with my person. Back window was busted on the ground and all that was left. From video evidence, we can see that all it takes to steal a Kia is a screwdriver and a usb cord. Kia’s stolen are driven recklessly and harmfully to pedestrians (see #kiaboyz on tik tok or instagram). Problem has NOT been acknowledged by Kia or Hyundai. Insurance providers are aware of the situation.

#1Headlights & break lights going out often. Bulbs can’t be replaced anymore due to wiring burnt ( 1 headlight ) Took it in and they didn’t even look at it. Have do Documents to back that up #2 Engine light coming on, diagnostic testing indicated spark plugs need to be replaced . Had to do this two times with oil on plugs Took it in and they NEVER look at the spark plugs #3 car burning excessive amount of oil anywhere from 1 quart a week to 3 1/2 quarts after driving 600 miles. Took it into the shop for oil consumption testing only to be told that their warranty would not cover it and it needs a new engine. I have a 10 year or 100,000 mile warranty on my car! and at the present time I only have 88496 miles on my car I have documentation to back...