2013 HYUNDAI SONATA Engine Problems

Recall 162 engine died no reason Hyundai refused to replace engine 2nd submission

It is a known issue on several makes and years on Hyundais. excessive oil consumption. burning a quart every 375 miles. at one point we had no oil in the car at all. causing a potential major safety issue lubricating parts of the engine. etc. we have contacted Hyundai several times and brought to Hyundai dealer who has confirmed issue through a test. no warning that oil was low!

My 2013 Hyundai Sonata (VIN: [XXX] , 2.4L Theta II GDI engine) is experiencing symptoms consistent with the known Theta II engine defects covered under prior NHTSA recalls (e.g., 17V-226) and the related class action settlement for connecting rod bearing wear due to manufacturing debris restricting oil flow. The vehicle has begun exhibiting [describe your specific symptoms here, e.g.: "a loud metallic knocking/tapping noise from the engine that increases with RPM, especially during acceleration or at highway speeds; reduced engine power and hesitation; illumination of the check engine light and/or oil pressure warning light; excessive vibration; or sudden loss of power/stalling risk"]. These issues have [escalated/worsened over time or occurred suddenly while driving]. This poses a serious safety hazard because premature bearing wear can lead to complete engine seizure or stall without warning while the vehicle is in motion, potentially at highway speeds, resulting in loss of motive power, inability...

Engine losing power and metal shavings in oil and engining shutting off

While driving, vehicle slowed down abruptly and stopped. It was flashing “vehicle not safe to drive”. This happened before hen I got a new engine 2 years ago. Even with a new engine now it is happening again. I took it to Nissan Moreno Valley and paid $240 for diagnostic only to find out there a software update they had to do with a tablet. No work needed to be one just a software update hooked up to their system. Hyundai cooperate would not assist to over this fee. I like have crashed with this happening. The car just stops with no warning and it’s extremely dangerous how it cuts off while driving. Luckily I was on the streets not freeway.

Engine Seized while driving - took to Hyundai dealership in Newport News VA and was advised it was negligence on our part. car was just inspected 2 months prior with no issues. All repairs were completed 05/23/2023 as required by Hyundai. Car does not start and they refuse to fix it. Car engine was recalled and never replaced. Information states it was but dealership refuses to provide records showing it was replaced since it was not. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2013 Hyundai Sonata qualifies for a Lifetime Warranty engine replacement under the Theta II Class Action Settlement. The dealership is refusing coverage unless I provide maintenance records, even though the settlement prohibits denial based solely on missing records or the presence of sludge. Hyundai must prove neglect caused the failure, which has not been demonstrated. I am requesting review by the Engine Settlement Team and approval of my engine replacement.

New Battery keeps dying, car not starting and when it does start it shuts off when I brake. Oil light on after I already put oil in the car

Vehicle: 2013 Hyundai Sonata VIN: [XXX] Mileage: [163,000] Summary: Theta II 2.4L GDI engine bearing failure (Recall 953 / 20V-393) – severe knocking, risk of sudden engine seizure/fire. Dealer refuses lifetime-warranty repair and forced consumer to pay towing to avoid lien/fees. Description: This vehicle is covered by NHTSA Recall 20V-393 (Campaign 953) and the court-approved Theta II engine class-action settlement providing a lifetime warranty for rod-bearing failure. The engine now has loud knocking from failed rod bearings – the exact defect addressed by the recall and settlement.On 11/28/2025 I dropped the vehicle at Group 1 Hyundai Southwest Houston (10301 Southwest Fwy, Houston, TX 77074) for diagnosis and repair under the lifetime warranty. The dealership confirmed bearing failure but refused to repair, stating the vehicle is “not eligible” because the free Campaign 953 knock-sensor software update was never performed. No owner (current or prior) ever received any recall notice or settlement...

Component/System Failed - Engine – connecting rod bearing wear resulting in complete engine seizure. - Engine is available for inspection upon request. Safety Risk - Engine seizure occurred while my mechanic was driving, causing a complete loss of motive power.Created immediate risk of crash due to inability to accelerate or control vehicle. Hazard to driver, passengers, and others on the road. Reproduction/Confirmation Failure matches known defect described in Recall 17V226000: premature bearing wear leading to engine seizure. Maintenance records confirm proper service; dealership denied repair citing “owner negligence,” which is inconsistent with the recall symptoms. Inspection Engine has not been repaired or replaced by manufacturer. Vehicle was inspected by dealership service tech who determined failure was caused by negligence (text denial received). Spoke with customer service and they confirmed denial. Full maintenance records available for inspection. Hyundai requested service records - we were not able to find all service records,...

My engine recently seized on my vehicle and Hyundai is refusing to replace my engine. Per their website my vehicles engine has a lifetime warranty. This warranty is eligible for class vehicles who have has to campaign 953 reformed on their vehicles prior to engine failure. This was performed in n my vehicle on April 16, 2019. Per Hyundai’s website. I am being offered a settlement I did not take part in instead of my engine replacement and it should be illegal for them to go against their own word.

Sir this is not first time to make complaint I brought my car to Hyundai company after I got an appointment and they called text emailed me and the know my car information on 10/1/2025 I brought my car but they mentioned wrong VIN NUMBER and after that I came back on 10/8/2025 but when I got there to finish my recall 953 they said your car rebuild title and now my car engine I think out I don’t know but they changed the engine before and i bought the car three months ago and now I can not drive it please help me with that the car just stopped when I was driving and 124369 miles and how the rebuild car not affected by recall

I bought the car on [XXX] used and it’s has 165000 miles drove fine for the 30 miles as I was driving At 65miles car losing power and slightly noise out the engine getting louder as I was to push the gas pedal and the engine light started flashing suddenly car has shut down as I was rolling on the road and I lost the power of breaking luckily I was going uphill on [XXX] and I parked on the side of the road. I call the Hyundai dealership of 3810 W Hillsborough Ave, Tampa, FL 33614 and I explained what happened he asked me have the car lost power I said yes, is the check engine light flashing I said yes. and do I hear knock engine I said yes. The dealership check the vin number and said it’s been warranty And we will inspect if that’s the problem...

The contact owns a 2013 Hyundai Sonata. The contact stated while driving 55 MPH, the vehicle shut off unexpectedly and failed to restart. The engine warning light was illuminated. The vehicle was towed to an independent mechanic who determined that the failure was caused by the starter. The mechanic informed the contact about an engine recall. The vehicle was taken to the local dealer and the contact was informed that the vehicle was working as designed. The starter was replaced. While leaving the dealer lot, the vehicle shut off. The dealer informed the contact that the spark plugs needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, who informed about a monetary compensation, a starter, or a repurchase of the vehicle. The failure mileage was approximately 198,000.

Driving at 70 mph on the highway, the engine seized without warning. The car violently shuddered and rapidly decelerated in the travel lane. A fully-loaded semi-truck was directly behind me and had to swerve violently and brake hard to avoid crushing my vehicle. This created an immediate, life-threatening risk of a catastrophic, high-speed rear-end collision. The failure is with the internal engine assembly (likely connecting rod bearings) and is available for inspection. The dealer confirmed the engine failure but denied the repair. This is a known defect. The "Engine Oil Pressure" warning light flashed and a loud engine knocking began moments before the total power loss. This is a dangerous defect that causes sudden, unpredictable stalling at highway speeds.

I bought this car before less than 3 months when. When I was drive the car on [XXX] the car just stop stopped no power without any warning when the car stop I just came from home. It’s far it’s like the distance between my home and the place the car stop in the highway. It’s like 5 miles. when I park the car to the side road right side road I open the hood. I see some smoke coming from the engine and smell like fire or burn or some plastic fire. I’m a mechanic he said before I bring the mechanic I seen that the screen light it’s like a car with the key in the middle of the car. The picture is the light the car stop starting. I thought I call somebody he told me maybe the car is the program or disconnect. We need to...

I bought the car before less than 3 months the car was good but before 10 days when I was driving it on highway , suddenly the car stopped without any light warnings I was In dangerous situations hard to got the car to right side way exit 19 A express highway when I opened the hood was smoking from engine and smile like plastic fire I brought the mechanic said starter I bought starter I replaced it the same problem they said the key I changed the battery program the key same problem they told me battery I checked the battery 95 % another mechcheck by computer said the engine and he said most of these car has manufacturers problems the engine replaced recall 162 before bought the car what my solutions and I know ther is extended warranty

The contact owns a 2013 Hyundai Sonata. The contact stated that while driving at approximately 75 MPH with three passengers inside the vehicle, the vehicle stalled. There were no warning lights illuminated or messages displayed prior to the failure and the vehicle shutting off. The vehicle could not able to be restarted. The vehicle was coasted off the exit to safety and then towed to the residence. The contact’s neighbor and son inspected the battery but found no fault with the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 135,000.

The contact owns a 2013 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle, which grew louder. The dealer was made aware of the failure; however, the contact was informed that the vehicle had a Branded Title. The contact was informed that the title was Branded because the previous owner had not provided the requested maintenance documents. The vehicle was taken to an independent mechanic, where it was diagnosed with failure of the rod bearings. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the title was Branded in the Manufacturer’s database. The failure mileage was approximately 125,000.

The car was being driven from Virginia to Austin, Texas. In Tennessee within 10 miles of Jackson, TN, on [XXX] the car suddenly lost power and the engine light started flashing and could not be driven above 60 MPH (the speed limit there was 75 and the car was being driven at the speed limit until this occurred). Even though the car lost power, the temperature remained steady and was driven to a car repair place and the next day it was towed to a nearby Hyundai dealership in Jackson, TN where they declared the engine needed to be replaced. This was also confirmed by our insurance company, Progressive. Ran the VIN and the car is an affected vehicle under Service Campaign 953 and engine should qualify for lifetime warranty but Hyundai is trying to deny the claim due to bogus claim of "Exceptional Maintenance Neglect" which is not even...

Excessive oil usage

I am filing a complaint regarding my 2013 Hyundai Sonata in connection with a known recall related to connecting rod bearing wear (I believe this is Recall 198). My vehicle is experiencing issues consistent with this defect, but Hyundai has denied my warranty/recall claim. Hyundai’s denial was based on an allegation of “engine neglect,” which is not accurate. I have maintained my vehicle with regular oil changes since purchase, and I have records to support this. I work from home and therefore do not drive as frequently as the average commuter, but I have always performed at least the standard minimum maintenance required. The car has never shown signs of engine neglect or had prior engine issues until now. The failure occurred while I was driving on the highway, when the engine suddenly stopped running. This placed me in a very dangerous situation, as the car stalled in active traffic...

I have tried to have my Sonata 2013 gone over gor the previous ownership never gave me any RO in this bias was stared. This previous wherebpurchased and worked , was not on The the up and up. vwhere ,Steele hyundaibwhen owned know keating group purchased. I'm asking ngo iver the safety i the setvice ussues t hat hyundai is awarevand have all thr campsign numbers looked up I do not believe since ive oened the car ,sonata anythingbwas donen,agein nothing evervstated and knly oil changes done without any given paper wirk given on recalls except oil changes. ssues and . So wanting, asking that no chargeb,go iver make sure for the situation posted and Hyundai posts in 6bareas yes , go over for the brake system is causing the hybird tobshit down and the car with squiggly line know comes on Fuses and the the brake power booster sensor...

This has been going on nothing resolved and no cooperation. Im going yo locate an Attorney that really don't want to. Requesting this be ,the situation be loojedvatb,at no chargevand replace whatbwasvsuppisedly replaced by Steele South Loop Hyundai ,Houston Texas ,sold to Keating groupbbased out if Texas. What I'm asking isn't make sure itvwas done ,and whatever replaced ,inexpensive to do to.repkace the parts , And computerbprograned to make current no chsrgebto ne for hyundaibsta t es in line and would not be getting emails from NHtsa as i do . Hope finally 24 hours resolve, cooperation and done finally.

The contact owns a 2013 Hyundai Sonata. The contact stated that while her sister was driving at various speeds, there was an abnormal, fuel odor coming from the vehicle. Despite the odor, the contact's sister resumed normal driving operation and later refueled the vehicle. After fueling the vehicle, the fuel odor was stronger, and the tire pressure warning light was illuminated. The contact's sister pulled over to inspect the vehicle, but found no failure. The next day, upon starting the vehicle, there was smoke coming from under the hood of the vehicle. The vehicle was taken to an independent mechanic, where the mechanic immediately smelled a fuel odor and later discovered a fuel leak while inspecting the vehicle. The mechanic showed the contact the fuel leak and diagnosed the vehicle with a defective fuel system. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 18V934000 (Engine, Fuel System,...

Losing oil somewhere in the engine and the oil smells like fuel.

With no warning light indication the Sonata lost all power on I-75 South near Dayton Ohio. After tow & vehicle I inspiration the engine was said to be dead. There is a recall for the 2015 for the SAME issue.

On freeway accelerated and it stalled the attempted to push button start all dash light were on and then it completely started smoking and that was from the starter getting to hot and died and nothing engine won't turn over so vehicle has no to started since

The contact owned a 2013 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the contact smelled fuel and noticed smoke coming from the engine compartment with no warning lights illuminated. The contact stated that the engine had caught on fire. The contact stopped the vehicle, and the contact and the two passengers quickly jumped out of the vehicle. The contact stated one of the passengers sustained a minor leg injury, and medical attention was provided. The fire was extinguished by the Fire Department. A fire report was filed, and a fire report number was not provided. The origin of the fire was not yet determined. A Police report was filed. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,000.

My Hyundai vehicle experienced a sudden engine failure due to a known defect in Hyundai’s Gasoline Direct Injection (GDI) engine. This engine issue is part of a widely documented safety concern that causes rod bearing wear, leading to stalling or catastrophic failure while driving. Despite the dealership confirming it’s consistent with the known defect, Hyundai denied assistance solely because my title is branded, even though the engine failure is unrelated to any crash or damage. Hyundai has replaced engines for others with branded titles, proving the inconsistency in their handling of a serious safety problem. This defect poses a risk of stalling in traffic, engine fires, and potential accidents. The vehicle shut down completely, and I believe this violates federal safety standards.

while driving on the highway the engine caught fire.

I purchased a 2013 Hyundai Sonata in 2022. I never had any problems or warning signs of vehicle until late Feb 2025. The engine begin to making a knocking sound and stalling almost causing my son to have an accident. After researching the issue I found that there had been a law suit filed against this company for the engines in those vehicles and that they had placed a limited lifetime warranty on the engine in my vehicle. I reached out to Hyundai and they assured me that my vehicle was covered under the TXXI warranty due to the class action suit filed against them. Next they set up an appointment for me to take the vehicle to the local Hyundai dealership which was Bentley Hyundai in Huntsville, Alabama. I had the vehicle towed there in March 2025 and was immediately met with unprofessional dialogue on my arrival. I explained...

So my car started to stall when I started it an when I started goin down the road like it wanted to die. Then I started to smell gas very strong so had a code tester put to my car an i have 6 permanent codes. An not only that im smelling oil strong an noticing big oil spots under my car. So I look under the hood an behind the turbo I see oil behind an underneath the turbo. I definitely didnt feel safe driving but now its not even drivable. I purchased it couple months ago from an individual an i cant belive the amount of problems this car has. Im a single mom an trying to support my family an its hard to now with a non running car. I've put quite a few parts hoping it would fix some of the problems an nothing has. I...

My car starts making noise then i pull over. my car completely shuts off and i tried to restart it, didn’t start. My engine i think is ruined

The contact owns a 2013 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle with engine failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V934000 (Engine, Fuel System, Gasoline); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was unknown.

Unknown, caught fire. 😳

The car engine was sputtering and the check engine light came on. I was notified by a repair shop that the problem may relate to an engine recall. I called Hyundai about the recall and they advised me to take the vehicle to Cardinale Hyundai in Corona. I did take it there. Testing showed that the issue was, in fact, the same issue that was part of the recall (I believe it is called the internal engine bearing failure). HOWEVER, the Hyundai dealer then advised that, due to owner neglect, the problem will not be fixed by Hyundai. I firmly dispute Hyundai's contention!

The contact owns a 2013 Hyundai Sonata. The contact had received an undisclosed NHTSA recall campaign, and the vehicle was repaired under the recall. The contact stated that the check engine warning light had been illuminated since the vehicle was picked up from the dealer after the recall repair. The contact stated that on a separate occasion, the vehicle failed to start. The vehicle was towed to an independent mechanic where the vehicle was diagnosed and determined that the engine had seized. The vehicle was not repaired. The contact then towed the vehicle to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The vehicle remained at the dealer and had not been driven since. The approximate failure mileage was 150,000.

On [XXX], in Washington, D.C., my 2013 Hyundai Sonata experienced sudden engine failure, leaving the vehicle inoperable. My goodwill repair request was denied within 30 minutes, without a proper inspection of the rod bearings (a known failure point covered under the TXXI extended warranty) or the fuel pipe recall—a known issue that could pose a fire hazard. Hyundai cited suspected maintenance neglect, but I have documentation of regular synthetic oil changes. Despite having over 200,000 miles, a Firestone inspection from September 2024 confirmed the vehicle was in good condition prior to the failure. Additionally, Hyundai Theta II engines are widely known to suffer from excessive oil consumption, a defect that can lead to premature engine failure even in well-maintained vehicles. Hyundai has replaced engines in vehicles with similar mileage under the same extended warranty, yet in this case, no proper inspection was conducted before denial. Safety Concerns: The fuel pipe...

I had an issue on my car where engine oil level is getting low day by day, then I have visited service center to solve they have said to change spark plug, pcv value and also done fuel induction service , said me to come after 1000 miles then after I had a another problem where my car RPM is increasing and speed is getting low. I have visited the service center again saying catalytic converter issue and asked me to pay 3000$ to do repair before that I have paid 700$ but mentioning you one thing till now I have spend 2000$ for the same issue what was happen. Today as now my car is issue to move in toll road it is very hard to move. And also Hyundai is denying my request and saying me I am out of warranty. My car has 94000 miles as for...

submitting a formal complaint to NHTSA regarding unresolved safety defects in my 2013 Hyundai Sonata Hybrid. Despite Safety Recall 251 issued in December 2023 for an ABS fire hazard, my vehicle continues to experience sudden loss of acceleration, engine shutdowns, and persistent dashboard warnings. Failed Recall Repairs & Lack of Transparency Since receiving the recall notice, my vehicle has been serviced multiple times at Thompson Hyundai in Dundalk, MD, yet the defects persist. When I requested service records to verify recall repairs, I was told that Thompson Hyundai’s acquisition by Heritage prevents them from providing full documentation—only three edited records missing key details. This raises concerns about: 1.Whether recall repairs are actually resolving safety defects. 2.Hyundai’s failure to maintain proper repair documentation. 3.The risk that other Hyundai vehicles remain unsafe due to incomplete recall fixes. Life-Threatening Breakdowns & Financial Hardship Since Hyundai’s supposed “fix,” my vehicle has broken down at...

While driving the vehicle under normal conditions, the vehicle lost power. Eps, and oil lights came on engine completely shut off. I changed belt, alternator and starter. It rolled over 3 times and seized. There doesnt appear to be a rod slung, or cracks in the block, but ive spent almost 2000 dollars trying to get it running and have another 1300 in parts waiting to rebuild the motor.I know there is a recall on the motors, but never received mail or any attempt at engine replacement.

Burns excessive oil/excessive oil consumption

I have a recall for the rod bearing , I drop off my car at AutoNation Hyundai North Richland Hills . Before 3 days to replace the engine because last time I changed the oil on Firestone the technician show me a metal on the oil and that coming from the rod bearing wear also when I cold start the vehicle I listen a rod bearing noise coming from the engine for a while , AutoNation Hyundai North Richland Hills called me today and say that the engine pass the rod bearing test and that is not right maybe it’s now but will not last like that , also i don’t want to drive the vehicle with this safety recall and get crashed when the bearing fail . I just need a help to replace this engine due to this recall I didn’t pickup the vehicle from the dealer location...

The contact owns a 2013 Hyundai Sonata. The contact stated that over time the vehicle became slow to start and that the engine was rattling and shaking abnormally at start-up. The contact stated while driving at undisclosed speeds, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed and the contact was informed that there was oil inside cylinder #1, causing a loss of compression. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V226000 (ENGINE AND ENGINE COOLING); however, the VIN was not included. The manufacturer was not notified of the failure. The approximate failure mileage was 125,000.

Fuel pump failed on long distance travel. Never been notified of issue. Fuel failed to inject itself as vehicle loss power. Along with engine.

my car broke down and now the car does not pick up speed and rattles when i press the gas pedal.

Having to add 1-2 quarts of oil per month and engine knock noise has started and been louder when oil is low.

The contact owns a 2013 Hyundai Sonata. The contact stated while driving at approximately 40 MPH, there was an abnormal sound coming from the engine. The contact stated that the failure occurred increasingly while driving at higher speeds on the freeway. The contact could not confirm whether there was any warning lights illuminated. The vehicle was taken to an independent mechanic, where it was determined that the abnormal sound was coming from the engine base. The mechanic informed the contact that they could not repair the vehicle. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

Hybrid system issue. Do not drive, stop safely.