2013 HYUNDAI SONATA Fuelpropulsion System Problems

I started smelling a little gas in the 20th. And on the 21st it got a lot worse so I took it to the dealership. This is the same place that replaced the engine because it failed and it was a recall. I let them know of the recall and they said it is not covered. They told me it was the high-pressure fuel line that connects to the pump. I have provided a picture of what the tech said.

My vehicle had Hyundai Safety Recall 227 (fuel tube replacement) completed on December 7, 2022. After the recall repair, the same fuel-system symptoms returned. A Hyundai dealership diagnosed failure of the high-pressure fuel pump and high-pressure fuel pipe and stated the condition was critical and a safety risk due to fuel system involvement and potential fire hazard. Hyundai Motor America declined assistance, citing vehicle age and mileage, despite this being a recurring fuel-system safety issue following a recall repair. The vehicle continues to present fuel-related safety concerns, and operating the vehicle poses a potential fire risk. In addition, the estimated repair cost exceeds $2,000, which represents a significant financial hardship for a safety-related defect that occurred after a recall repair. I am submitting this complaint due to concern for vehicle safety and the recurrence of a fuel-system defect after a manufacturer safety recall.

Theres a know recall for this issue. Recall 189 AND 227 for hyundai. Fuel leak right by the regulator on the hose. Mine is doing the exact thing. My motor isnt covered for some reason. Same make and model. So id like to make a complaint and make it know the exact same issue is happening STILL, 2013 hyundai sonata and they wont cover it. So if another recall could be opened to help others. I mean its the exact same issue.

We were sitting in our car at a Hardees drive through when we noticed smoke coming out from under the hood. I pulled forward to a parking space and opened the hood. Flames shot up at least 6 feet. I quickly ran a short distance into the fast food place and right near the door was a fire extinguisher, which i grabbed and put the fire out with. The fire burned for about a total of 2-3 minutes, and did not do excessive damage. Coil packs and wiring harness got most of the damage. With the hood closed, you cannot even tell there was a fire. I had the car towed to Grayson Hyundai for the recall part, but then entered a claim to Hyundai. Long story short, they stalled me for over a month and then denied the claim. Citing no damage to the cam. Unlike most of the...

So my car started to stall when I started it an when I started goin down the road like it wanted to die. Then I started to smell gas very strong so had a code tester put to my car an i have 6 permanent codes. An not only that im smelling oil strong an noticing big oil spots under my car. So I look under the hood an behind the turbo I see oil behind an underneath the turbo. I definitely didnt feel safe driving but now its not even drivable. I purchased it couple months ago from an individual an i cant belive the amount of problems this car has. Im a single mom an trying to support my family an its hard to now with a non running car. I've put quite a few parts hoping it would fix some of the problems an nothing has. I...

Unknown, caught fire. 😳

On [XXX], in Washington, D.C., my 2013 Hyundai Sonata experienced sudden engine failure, leaving the vehicle inoperable. My goodwill repair request was denied within 30 minutes, without a proper inspection of the rod bearings (a known failure point covered under the TXXI extended warranty) or the fuel pipe recall—a known issue that could pose a fire hazard. Hyundai cited suspected maintenance neglect, but I have documentation of regular synthetic oil changes. Despite having over 200,000 miles, a Firestone inspection from September 2024 confirmed the vehicle was in good condition prior to the failure. Additionally, Hyundai Theta II engines are widely known to suffer from excessive oil consumption, a defect that can lead to premature engine failure even in well-maintained vehicles. Hyundai has replaced engines in vehicles with similar mileage under the same extended warranty, yet in this case, no proper inspection was conducted before denial. Safety Concerns: The fuel pipe...

The vehicle has begun to vibrate/shake badly but manageable. When a code reader was connected to the vehicle both codes 7E9 and 7E8 showed up. Upon researching, information has been found that these specific vehicles have been known for recalls due to fuel hose issues. If I continue to drive this vehicle without the issues being resolved which is not my fault, I jeopardize my son and I’s lives as well as any potential future passengers.

After starting, got a warning stating check hybrid braking, do not drive. When going forward, brake pedal went to floor, heard heavy grinding noise and vehicle stopped accelerating. Had to use the emergency brakes to avoid an accident. Hyundai says they can’t find a problem. Now I can’t even drive it back to the dealer! Did an internet search and many other hybrid owners have reported the same issue. I just want to have Hyundai buy the car back at this point. It only has a little over 50,000 miles on it.

2013 Hyundai Sonata engine caught on fire after being replaced TWICE.

My low pressure fuel hose has a leak. The amount of gasoline that is spraying on my spark plugs and engine is concerning. The gas fume smell coming in through the vent was horrible. After finding this leak I came to the conclusion that I am very lucky My car didn’t catch fire while I was driving. For some reason there is already a recall in place that includes my vehicle year but does not include my vehicle Vin. How do I get my vehicle included in this recall so that it can get repaired? The recall in question is NHTSA number 227 or 22V – 314. At this time, the car is sitting in my driveway and I am not inclined to move it until I know it can get repaired. At that time, I will have it towed to the dealership.

While accelerating on the highway, several warning lamps (battery, engine, others that I forget) came on. When I pulled over the hood was smoking, and a fire flared up after I opened the hood. My son and I escaped the car with no injury. Still waiting for report from insurance company.

Car smells like it’s burning, been told it’s oil. Dealership after seeing leakage on the engine replaced the valve gasket. Car still smells like it’s burning and apparently there is no leaking. I went to the same dealership to inform them and they recommended replacing a hose but not a guarantee it will fix the overall problem which is smelling of burning. I’m concerned! I’m 37weeks pregnant and don’t want to inhale burning or any other chemicals pre and post postpartum with a newborn

Wires, reverse osmosis system unauthorized and unknown

While driving the car at freeway speeds it died and quit running, and the engine compartment began smoking, and a fire ensued under the hood. Gasoline could be smelled before it started fire.

The engine went into smoke and caught on fire. Resulting in damage to the vehicle ultimately causing to be totaled.

What component or system failed or malfunctioned, and is it available for inspection upon request? The Car continues to have inconsistent acceleration, hesitation, and sometimes lurches forward. On two occasions, the car felt like it was just going to turn off while driving. I was driving about 75 mph on I295 and driving about 15 mph on a residential road during the second occurrence. How was your safety or the safety of others put at risk? I feel as though I am not in complete control of the acceleration but am mostly concerned with the car stopping on it's own. I am very scared I'm going to be hit by the car(s) behind me. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I have an appointment in October...

My 2013 Hyundai Sonata lost acceleration power while on the road requiring an emergency departure from the road and it fails to acceleration beyond. Placed vehicle in park and attempted to proceed home but was only able to drive 5 to 10 mph max creating a dangerous situation for my fellow commuters and myselt. After about a few block I let the vehicle cool down and attempted to proceed home. The car would only go up to 5 mph requiring me to avoid rear end collisions. Ultimately, requiring a tow vehicle to bring it home. Our neighbor indicated it is the MAP sensor which was changes with no improvement to the car's acceleration issues. Checked all the fluids and assured they were correct. This vehicle has place me and others in a dangerous and potentially fatal situations.

This incident singled happen in a 20 or so miles on my way home commute, no freeway drive. I was driving pulling out of a parking street when I notice the vehicle tendency to pull me forward, even though I was preparing to stop. It continue to have this issue at a stop sign and traffic light. at first it was mild pull as if you are being towed. Sporadic pushing forward, but when I turned to the left I notice that the engine pick up speed on its own and the issue was exacerbated on turns to left and right. The issue continue to the point I stayed at a safety distance from other cars and the pull began to be more aggressive. I was driving slow at that point. With hazards lights on. On arrival to my home driveway and upon putting the car on park the engine...

HE99 P cabin filter DR Break LightV Air Filter Oil Leak Poss Oil Pan. Now having engine problems and my car was taken to Pennsylvania. My car started smoking.

While driving car engine compartment caught on fire. Unknown to me two passing motorist alerted me I pulled over at that time engine was on fire. Fire extuginsh using extuginsher. Car towed to major hyundai of Stroudsburg 1534 north main Stroudsburg PA.

Fuel line is leaking as with the recall, but my car shows that it is not part of the recall 189...fuel tube. Problem is the same as the recall campaign 189

Was losing power while driving, oil consumption issues (had to add oil every 1000 miles). Engine started knocking and went into limp mode, had it towed to dealership where they said they fixed it ($1100). Less then a week later while driving on the highway lost lower, went into limp mode (89 mph to 15 mph in seconds) and was almost hit by a semi truck. Car has been sitting at the dealership since May 2022, they said I need a new engine but Hyundai declined.

I have owned my car about a year. There were no problems from the beginning but just a few days ago I was waiting in my car and turned the heater on. The strong smell of fuel came through the vents I immediately shut off the vents and took the car home and did not drive it for a few days. After a inspection from myself to see if I could find the issue nothing was found and so I took the car into a shop to have them inspect it. They quickly found that the metal high pressure fuel line was leaking at the connection to the fuel pump. They said I was lucky that the car had not caught on fire during the drive to the shop as the leak was right near the spark plugs and the fuel vapors were very strong. They tried to reestablish the...

2013 sonata. Constant oil consumption. Had replaced the oil pan and piston, oil caps, pvc valve. Car stalled twice and kept getting check engine lights popping up. Turns out the engine is defective and needs to be replaced. The car is starting at my mechanic right now and trying to figure out how to get it to Hyundai dealer so the engine can be replaced. the car is unsafe to drive right now. my son has the car.

My 2013 Hyundai sonata caught fire yesterday after the car stalled at a red light - car is totalled - i am just hearing about this now that numerous car like mine have gone up in flames. I am devastated

Everytime I put fuel in my car I get a strong gas smell outside and inside my car. I’ve looked to see if there is a leak and do not see anything. Looked to see if there are recalls and shows there are 8 but when I put vin in. There is no recalls. Don’t know if the have been taken care of alright or I never had them on my car.

The low pressure side fuel line on the vehicle has cracked and has a hole in it. Just above the back of the engine. Hyundai has issue a recall on this EXACT problem mid last year. However they say there is no open recall for my vehicle. This tells me Hyundai is NOT being honest about the amount of vehicles this has affected. When trying to reach Hyundai about this issue I simply get told there is not a recall for my specific vehicle. Vehicle stalls while driving and is very hard to start up after fueling. This is an extremely unsafe vehicle do to the strong possibility of fuel leaking on to the engine or exhaust while running. I find it completely irresponsible of Hyundai to potentially put someone’s life at risk by not including ALL vehicles of the model any year in their recall related to this problem....

I had my car recall fixed on 12/10/2022 at the Burns Hyundai in Marlton NJ. It seems to have failed when I parked my car it smelled like gas and I got out and see gas all over the ground. They were supposed to fix 2 recalls on my vehicle. My gas was empty after I had just filled it. My car would not start. It cranked but didn’t start. There were no warning signs.

The car caught on fire while my family was driving it. Nearly killing them in the fire. Witnesses say the fire started underneath the car then went to the engine. There is a TSB recall 227 on those types of cars indicating the fuel tube needed replacement. This car was serviced last in September with an engine replacement at Hyundai dealership. That day the check engine light came on. Police was called, insurance is investigating. Have not contacted manufacturer.

Received recall NHTSA Recall Number:22V-312, Fuel Hose Replacement. Contacted Hyundai of Bowie , Service 301-850.-6802. The scheduler explained that the company does not have a plan to correct the problem. The problem has not been confirmed by a dealer or independent service center. I received several recall notices and the response never changes "No remedy available.

We were travelling from Minnesota to Arkansas to see our family for thanks giving on 11/24/2022. Car engine starts blinking and engine started to make rattling noise. Took exit and pull over our car in one of the gas station. It was closed, this was our first road trip and first time in Iowa. Called insurance and towed our car to O'reaily auto part. They found out the error code p1326 which is related to engine issue. Looked for nearby Hyundai dealership and booked hotel near them. We went to Hyundai dealer at 7:00am on Friday 11/25/2022. We told them what happened. They told us they will check in our car. We waited from 7am to 1:30pm our car was still outside. At 2pm service manager came and said they cant check our car. We booked rental car ourselves and decided to come back home. We forgot our apartment key...

I CALLED CIRCLE HYUNDAI OVER A MONTH AGO TO SCHEDULE AN APPOINTMENT FOR RECALL #22V-312 AND WAS TOLD I'D BE CALLED WHEN THE PART ARRIVED. I CALLED BACK 2 WEEKS AGO AND WAS TOLD IT WASN'T IN YET. I CALLED TODAY, 11/18/22 AND WAS TOLD THE WAREHOUSE WASN'T RELEASING PARTS FOR THIS RECALL. MY NOTICE STATES TO CALL FOR AN APPOINTMENT FOR THIS TO BE CHANGED OUT. AS A SAFETY MANAGER MYSELF I'M NOW BEING PUT IN HARMS WAY IF THIS PART FAILS AND CATCHES ON FIRE. NOT A HAPPY HYUNDAI CUSTOMER!

I was driving my daughter’s 2013 Hyundai Sonata Hybrid to the gym early one Sunday morning. I pulled into the parking lot to park the car. When I stopped to put the car in park the car suddenly accelerated and I drove through the glass wall of the gym. The car accelerated through the gym, hit a metal pole , and crashed into a wall on the far side of the gym. The front end of the driver’s side corner was smashed in and my airbags did not go off.

Was driving down the highway doing about 70 miles per hour engine just flats out stalls on me. Was trying to merge over to get out traffic had no power and almost got hit by semi.Wait 5 minutes and restart car. Car started Making clicking noise and gave it gas went a little bit and stalled out and would not restart. Contact a manufacturer said there is an issue With the engines but does not know if it qualifies for their extend warranty.

While driving my 2013 Hyundai Sonata, I smelled fuel fumes coming through my a/c vents for several minutes. I shut the a/c off and rolled the windows down. White smoke began billowing out of my exhaust tail pipe then from under the hood. Being in the far left lane of a five lane freeway, other motorists and I were placed in danger as I had to travel across all lanes of traffic as my vehicle billowed thick white smoke into the air limiting the clear view of other motorists and increasing the chance of causing collisions. I pulled over to the shoulder of the freeway and then lost all power steering and brakes on my vehicle. I applied the emergency brake and brought my vehicle to a stop then turned it off. I looked at the temperature gauge and it read normal range but the check engine light came on...

The engine is burning oil again this is the second engine my car was part of the first recall after noticing how low n black my oil was I noticed it also smells like gasoline. Now I tried to get it in for the recall 227 part of recall 189, it hesitates to start will just stahl whenever n wherever it feels necessary I contacted Hyundai they said drop it off at dealership until it is repaired if no loaner was available then I would have to rent a car now that’s not even feasible considering I might not even get it back rent a car indefinitely that’s ridiculous and expensive. So it’s burning oil again, stahling out, has no power sometimes when u hit gas, oil smells of gas as well as my dipstick smells of gas as well.

While driving car started beeping and making noises - check engine light, brake light, lcd displayed brake warning and flashed "hybrid system warning! safely stop and do not drive". Brake pedal then went to floor, and engine power reduced. Re-starting the car only cleared the problem for a minute before the warning message re-occurs. Others have encountered this issue resulting in crashes. https://www.carproblemzoo.com/hyundai/sonata/2013/service-brakes-problems.php also reported here: https://www.carcomplaints.com/Hyundai/Sonata/2013/brakes/service_brakes.shtml

My fuel line is actively leaking. The dealerships told me that the car is under recall but there is no remedy at this time. At this point, I was told I am unable to drive my car and I just have to wait.

My 2013 hyundai sonata was apart of the original fuel leak recall about a year ago. I went to my local hyundai dealership and to my knowledge they "fixed" the issue. Now there is another recall with "no remedy" as of yet. My car definitely has a leak as my entire cabin smells of gas, really bad to the point of headaches and getting nauseous. If you're sitting next to my vehicle you can also smell the gas leaking. This is so dangerous for my child & I and everyone my car is near as this could catch on fire! I took my vehicle to a local repair place to fix the issue and inspect my car and thats when I was made aware that this is infact a leaking hose & is apart of the new recall. The repair place would not fix it and told me to take...

The fuel line is leaking fuel. I was put at risk because it can cause an engine fire while driving.

While driving the car flashed "Hybrid System Warning! Safely stop and do not drive" and immediately shut off propulsion. I was able to coast just enough to get off to the side of the road. Now the warning comes up as soon as the engine kicks on to charge the hybrid system and the car will not move. If I wasn't in the right hand lane on the highway this could've caused an accident. This happened once in December 2021 with about 86000 miles and went away after letting the car sit for about 30 minutes. It happened again today July 21, 2022 and left me stranded. The car is unusable as of now.

I smelled gasoline in my car every time the car was idle and when I turned on the AC. I googled everything I could but could not figure out the problem. I had to drive the car from Miami to Orlando while this issue was going on (due to me attending school in Miami and living in Orlando). I dropped it to Tire Plus the same day I arrived in ORL & they called me on Sunday morning, stating that I should not be driving the car, it is a hazard because of the issue they identified. Shortly after (about 10 min after that phone call from Tire Plus) I found out that there has been a recall for this same issue tire Plus identified. I called tire plus and told them it is a recall and they said I must get the car to Hyundai to be fixed since...

The car start over but was unable to keep power upon hitting gas pedal. The seatbelt would unlatch. The back break lights wouldn’t shut off after turning off engine causing the car battery to lose power.

On May 7th 2022 my 2013 Hyundai Sonata engine caught fire just driving down the road. I had only bought it 2 months prior. Smoke started coming pouring out of the vents and I had to pull over and have the fire department put it out. Hyundai has looked at it and offered to pay off my loan but I gave $4000.00 cash down and now that is lost. They won't cover that. Will there be another class action lawsuit ?

I was notified of two recalls on my vehicle. I am the second owner of the vehicle but need to know if I am able to get these recalls fixed without paying out of pocket.

I was driving on the way home doing 55 mph with my kids and the car started to slow down and light began to pop up on the dashboard. The car shut off. I tried to restart it it wouldn’t restart. I called a tow truck as I was waiting in 100 degree weather with two kids someone tried to give me a jumpstart how ever when they tried to jump start it we noticed smoke coming from the hood. I went to a part store and brought another battery. Thinking it’s the battery I put the new battery in. Car still would not start. And smoke arised again as I’m Still waiting for tow truck for 7 hours @10pm tow truck finally comes. Tow truck takes car to my residence. The next day I call Carvana and silverrock they tow the car to a dealer then call me and...

The car cut off while I was driving. Had it towed to a repair shop, and they said the engine had seized up. Found out that the vehicle was affected by a recall involving the engine having debris left inside at the factory which causes restricted oil flow. I had the car towed to the dealer, and they claimed the engine failed due to "neglect." They didn't inspect for any recalls, and I was charged.

FUEL IN ENGINE. ENGINE FAILURE. had car towed to hyundai of louisvile dealership due to recall on may 20,2022.as of today the dealer has not even began to do anything toward my car. i was told it may take up to 8 weeks before they could even look at my car. I was given a clain number from hyundai #19842116 and a case worker who has not helped at all. I was also denied a loaner from the dearlership

For about a month, while driving lights go off during the night, MOST recently the lights and car shut off DURING the ride home!! No flashers working! When we attempted to move the steering wheel locked and would not go into drive! Feels like something was stuck, further inspection NOTHING WAS STUCK! when I fuel up the car seizes in the middle of my drives!