2004 CHRYSLER PACIFICA Engine Problems

DRIVING DOWN INTERSTATE WHEN THE CRUISE CUT OUT AND THE ENGINE SKIPPED. PULLED OVER TO CHECK ENGINE FLUIDS AND ALL WERE OK. NO ENGINE WARNING LIGHTS OR ANY OTHER INDICATION OF SOMETHING BEING WRONG. CONTINUED AT APPROX 70 MPH WHEN THERE SEEMED TO BE AN INTERNAL EXPLOSION WITHIN THE ENGINE CAUSING THE ENGINE TO STOP AND ALL FRONT AIRBAGS TO DEPLOY. VEHICLE THEN CAUGHT FIRE AND WAS TOTALLY DESTROYED.

THE UNDER CARRIAGE THAT HOLDS ENGINE IN PLACE IS COMPLETELY RUSTED THROUGH. I BOUGHT BRAND NEW TIRES FROM BELLE TIRE ON SEPTEMBER 9, 2020. BY NOVEMBER 1 2020 I WAS OBSERVING EXTREME WEAR ON THE BRAND NEW TIRES. WENT TO MY MECHANIC AND WAS TOLD THE CAR IS UNSAFE TO DRIVE DUE TO THE CRADLE RUST ROT, AND THE ENGINE IS ABOUT READY TO FALL OUT AND WOULD CAUSE CATASTROPHIC EMERGENCY I AND MY FAMILY COULD DIE. TRYING TO FIND REPLACEMENT AND AM BEING TOLD IT IS SUCH A PROBLEM THAT THERE IS NO PARTS AVAILABLE TO FIX THIS PROBLEM

I WAS DRIVING ON THE HIGHWAY, AND MY LIGHTS ALL LIT UP, CAR STALLED, AND MY DASH BOARD SAID NO BUS

TL* THE CONTACT OWNED A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHEN HE PURCHASED THE VEHICLE THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED, HE HAD TAKEN IT TO CHRYSLER JEEP DODGE RAM BRUNSWICK GEORGIA (5400 ALTAMA AVE, BRUNSWICK, GA 31525) FOR A FULL INSPECTION. A WEEK LATER WHILE AT A STOP SIGN, THE CHECK ENGINE AND AN UNKNOW RED WARNING LIGHTS ILLUMINATED A SECOND TIME. THERE WAS SMOKE AND FIRE COMING FROM UNDERNEATH THE FRONT HOOD AREA. THE CONTACT WAS OCCUPYING THE VEHICLE AS THE DRIVER AND MANAGED TO EXIT THE VEHICLE. THE CONTACT STATED THAT THE FUEL LINE CAUGHT ON FIRE AND BURNED THE VEHICLE CAUSING TO IGNITE INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE AND POLICE REPORT WERE FILED. THE VEHICLE WAS TOWED TO A JUNK YARD WHERE IT WAS BEING INVESTIGATED. THE VEHICLE WAS DEEMED DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE...

ITS THROWING A PCM CODE AN THE CAR IS STALLING SO BAD IN THE MODDLE OF DRIVING I HAVE BEEN STUCK SEVEREAL TIMES AN I THUNK THERE IS A FUEL LEAK I SMEELL GAS SO BED ITS THROING PO300 CODE AN WONT CHANFE EVEN WHEN I GOT ALL THE PARTS I SEE THERE IS A RECALL ON MY YEAR OF CAR CAN SOMWONW HWLP MW I CANT KEEO CUTTING OFF ILL WRECK

UPON TAKING A THE VEHICLE TO A MECHANIC, I WAS INFORMED THE SUBFRAME WHICH SUPPORTS THE ENGINE IS RUSTING TO THE POINT IT WILL NOT HOLD THE ENGINE CAUSING CATASTROPHIC FAILURE. I HAVE BECOME AWARE CHRYSLER IS AWARE OF THE FUTURE FAILURE AND WILL NOT FIX IT.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE DRIVING AT UNDISCLOSED SPEEDS, THE VEHICLE DECELERATED INDEPENDENTLY AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON FOUR OCCASIONS HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. ADDITIONALLY, WHILE DRIVING AT 40 MPH, THE VEHICLE DECELERATED WITHOUT WARNING. THE VEHICLE WAS TOWED TO BROOKFIELD CHRYSLER DODGE JEEP RAM (1845 PIPESTONE RD, BENTON HARBOR, MI 49022), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE OXYGEN SENSOR FAILED AND NEEDED TO BE REPLACED. THE OXYGEN SENSOR WAS REPLACED SEVEN TIMES HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

VEHICLE WAS TAKEN TO SERVICE. SHOP WOULD NOT WORK ON VEHICLE STATING THE DETERIORATION OF THE SUBFRAME WAS TO EXTENSIVE AND THEY WOULD NOT WORK ON IT. UPON CLOSER INSPECTION SHOWED THE FRAME IN A GREAT STATE OF DECAY, WITH SOME PLACES ONLY BEING HELD TOGETHER WITH THIN STRIPS OF METAL. THESE VEHICLES WERE RECALLED IN THE PAST FOR DEFECTIVE FRAMES HOWEVER NOT ALL WERE RECALLED AND THIS IS ONE VEHICLE THAT WAS NOT. THE MOTOR IN THESE VEHICLES WILL FALL OUT AND COULD CAUSE AN ACCIDENT WHICH COULD RESULT IN SERIOUS INJURY OR LOSS OF LIFE. THESE FRAMES ARE DEFECTIVE IN WORKMANSHIP FROM THE FACTORY AND SHOULD BE HANDLED BY THE FACTORY ACROSS ALL 2004-2008 CHRYSLER PACIFICA'S AFFECTED BY DEFECTIVE EQUIPMENT KNOWINGLY INSTALLED BY THE FACTORY THAT WILL LEAD TO AN ACCIDENT AND CAUSE SERIOUS INJURY OR DEATH. THOUSANDS OF THESE VEHICLES ARE ON THE ROAD TODAY WITH OCCUPANTS...

ENGINE STALLS FOR NO REASON INDICATED BY ENGINE CODES. VEHICLE WAS COMING TO A STOP. WAS BACKING UP ONCE. JUST IDLING AND STALLED. SOMETIMES WHEN DRIVING IT FEELS AS IF NOTHING IS HAPPENING WHEN I ATTEMPT TO ACCELERATE. HAS DONE THIS BEFORE THE DATE SUBMITTED. DIFFERENT DATES.

VEHICLE.JUST QUIT RUNNING.AND WOULDN'T START.AGAIN. THE VEHICLE WAS IN MOTION

I WAS DRIVING ON A CITY STREET AND I WAS TURNING AT A STOP LIGHT WHEN MY CAR MADE A VERY STRANGE SOUND. I COULD NOT STEER THE CAR SO I PULLED OVER AND UPON LOOKING UNDERNEATH THE VEHICLE AND UNDER THE HOOD THE MOTOR HAD SHIFTED DUE TO A ROTTING CRADLE MOUNT.

K-FRAME IS ROTTED OUT NOT SAFE TO DRIVE ENGINE COULD FALL OUT

HAVE 2004 CHYSLER PACIFICA HAVING ISSUES WITH FUEL SYSTEM TRUCK DRIVES THEN SPUTTER SHUTS OFF TAKE LONG TIME STARTING UP ALSO OVER HEATS NO REASON TRUCKS SHIFTS INTO GEAR 2 BUT DON'T GO SPEED THINK I'M GOING TRANSMISSION SLIPS CAN BE RIDING UP STREET SHUTS OFF ON ME SHIFTS INTO DRIVE WITH RPM SAYING 2

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING APPROXIMATELY 55 MPH IN THE RAIN, THE INSTRUMENT PANEL LIGHTING AND THE ABS INDICATOR BEGAN TO FLASH. IN ADDITION, THE WINDSHIELD WIPERS STOPPED WORKING, THE VEHICLE SUDDENLY JOLTED FORWARD, AND STALLED. THE NEXT DAY, AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,000.

2004 CHRYSLER PACIFICA. CONSUMER WRITES IN REGARDS TO SAFETY RECALL THAT WAS NEVER REPAIRED WHICH RESULTED IN VEHICLE FIRE. *LD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *LD *TR *JS *JS THE MANUFACTURER WAS NOTIFIED, BUT HAD NOT OFFERED ANY ASSISTANCE. *JS

WE OWN A 2004 CHRYSLER PACIFICA WITH AROUND 117K MILES ON IT. MY DAUGHTER DRIVES IT. WHILE CHANGING THE ENGINE OIL ON IT LAST WEEKEND, I NOTICED SEVERE CORROSION (PERFORATION ACTUALLY) OF THE VEHICLE ENGINE CRADLE. THE PASSENGER SIDE OF THE CROSS MEMBER IS RUSTED COMPLETELY THROUGH ON THE BOTTOM AND THE DRIVER SIDE IS ABOUT 70% RUSTED THROUGH. AS THIS CROSS MEMBER IS WHAT HOLDS THE ENGINE IN THE VEHICLE AND ACTS AS THE BASE OF THE FRONT SUSPENSION, I DON'T BELIEVE THIS VEHICLE IS SAFE TO DRIVE ANYMORE. SHOULD THIS STRUCTURAL COMPONENT FAIL DURING HIGHWAY DRIVING, I BELIEVE THE VEHICLE WOULD BECOME UNSTABLE AND UNCONTROLLABLE WHICH WOULD BE A HAZARD TO THE DRIVER, PASSENGERS AND OTHER MOTORISTS. YES, WE LIVE IN WISCONSIN (PART OF THE SALT BELT), BUT THIS AMOUNT OF CORROSION ON SUCH A CRUCIAL STRUCTURAL COMPONENT IS CRAZY! THE VEHICLE HAS ONLY BEEN ON THE ROAD...

CHRYSLER DEALERSHIP SERVICED MY CAR WITH A OIL CHANGE. I WAS TOLD MY CAR WAS UNSAFE TO DRIVE DUE TO MOTOR MOUNT RUSTED. I HAD TO SIGN A PAPERS THAT THIS CAR IS UNSAFE TO DRIVE, THEY CAN'T RELEASE THE CAR TO ME. FRAME IS ROTTED AND UNSAFE TO DRIVE. I DIDN'T EXPECT THIS AND WASN'T READY TO BUY ANOTHER CAR. I DON'T KNOW IF THIS PROBLEM WAS A RECALL FOR CHRYSLER PACIFICA. THANKFULLY I WAS TOLD BEFORE SOMETHING HAPPENED.

I HAVE CHRYSLER PACIFICA 2004. HAVE TAKEN GOOD CARE OF VEHICLE, NO ACCIDENTS. VEHICLE BEGAN SHAKING VIOLENTLY WHEN DRIVING DOWN ROAD. I HAVE BRAND NEW TIRES . HAD THEM REBALANCED COUPLE OF TIMES . STILL VIBRATING VIOLENTLY. MY MECHANIC COULD NOT FIND ANY PROBLEMS EXCEPT THAT ENGINE CRADLE FOR ENGINE IS BADLY ROTTED OUT WITH RUST. I LOOKED ON LINE FOR PROBLEM AND SEE THAT CHRYSLER HAD NOT PROPERLY COATED THE ENGINE CRADLE AND HAS LED TO FREQUENT PROBLEMS AND DANGEROUS DRIVING CONDITIONS, DUE THAT THE ENGINE COULD FALL OUT OF VEHICLE. THIS IS OF NO FAULT TO OWNER. I DIDNT FEEL SAFE DRIVING A VEHICLE THAT THE MOTOR COULD FALL OUT OF. THIS IS A SAFETY ISSUE THAT CHRYSLER SHOULD BE RESPONSIBLE FOR. A CONSUMER SHOULD NOT HAVE TO WORRY THAT THERE SEAT BELT OR AIR BAG MIGHT FAIL AND THEY DEFINITELY SHOUDNT HAVE TO WORRY ABOUT THERE ENGINE...

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT ARRIVED HOME AND WAS NOTIFIED BY AN EYEWITNESS, APPROXIMATELY 15-20 MINUTES LATER, THAT SMOKE WAS COMING FROM THE VEHICLE. THE CONTACT OBSERVED MAJOR SMOKE AND FLAMES UNDERNEATH THE FRONT OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND DETERMINED THAT THE FIRE STARTED FROM THE ENGINE AREA. A FIRE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS STILL PARKED OUTSIDE OF THE OWNER'S HOME. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. IT WAS NOT DETERMINED WHETHER OR NOT THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

ENGINE CRADLE RUSTED OUT TO THE POINT THE ENGINE DROPPED. MY DAUGHTER WAS DRIVING HOME FROM WORK ON I94WEST OUT OF MILWAUKEE WHEN SHE HEARD A CLUNK. SHE WAS ABLE TO DIVE TO OUR RESTAURANT AND PARK. I HAD THE VEHICLE TOWED TO AN AUTO MECHANIC AND THAT IS WHEN HE TOLD ME THAT IT ENGINE CRADLE WAS RUSTED OUT.

ENGINES STALLS INTERMITTENTLY WHILE DRIVING THEN SHUTTERS AND CONTINUES TO RUN. HAPPENS 3 TO 4 TIMES DURING SAY A 25 MILE DRIVE . I FEEL IT IS VERY UNSAFE . ALSO STALLS AT IDLE AT STOP SIGN BUT RESTARTS IMMEDIATELY AND RUNS AS IF NOTHING HAPPENED . I GOT ONLINE TO SEE IF OTHERS HAD SIMILAR PROBLEM AND SEEN OTHER SIMILAR PROBLEMS WHERE THEY SAID IT WAS SOFTWARE RELATED AND HAD TO GO TO DEALERSHIP TO BE REPROGRAMMED.

A POPPING SOUND COMING FROM THE FRONT END WHEN TURNING WHILE MAGEING TURNS. IT IS SO LOUD YOU THINK SOMETHING FELL OFF. THIS HAS BEEN HAPPING FOR AT LEAST 4 YEARS I ALWAYS TAKE IT TO THE SHOP AND THEY SAY THEY CAINT FIND ANYTHING WRONG BUT I KNOW IT IS THE SHOP KEEP COMPUTER RECORDS SO I KNOW THEY WILL HAVE THE TIMES I KEPT RETURING WITH THIS PROBLEM IT NEVER DO IT WHEN I TAKE IT SO THEY SAY THEY CAINT DIGONOSE MY PROBLEM. YOU WILL NEVER KNOW WHEN IT WILL MAKE THAT LOUD POPPING SOUND BUT WHEN IT DOSE IT YOU WILL BE STARTELD YOU BECAUSE YOU THINK YOUR WHEEL IS OFF. IT ALSO WILL NOT START OCCASIONALY YOU NEVER KNOW WHEN THIS WILL HAPPEN I REPLACE MY BATTERY EVERY YEAR BECAUSE IT WILL KILL YOUR BATTERY ALL THE TIME .I HAVE REPLACED MY GAS PUMPS THEY...

I PURCHASED A USED VEHICLE FROM A LOCAL AUTO DEALERSHIP ON JANUARY 30, 2017. AFTER DRIVING THE VEHICLE EVERYDAY FOR ABOUT A WEEK I BEGAN NOTICED THE CAR WOULD SHAKE AND PULL TO THE LEFT EVEN WHILE DRIVING AT VERY SLOW SPEEDS.ON FEBRUARY 23, 2017 I TOOK THE NEWLY PURCHASED CHRYSLER PACIFICA IN FOR AN OIL CHANGE. I RECEIVED A CALL FROM THE MECHANIC ABOUT 15 MINS AFTER I DROPPED THE VEHICLE OFF AND HE INFORMED ME THAT MY FRONT ENGINE CRADLE WAS SEVERELY RUSTED AND IF I CONTINUED TO DRIVE IT THE ENGINE COULD FALL OUT AT ANY MINUTE. I RUSHED BACK TO THE LOCATION THAT MY VEHICLE WAS BEING SERVICED AND I WAS SHOCKED AT HOW BAD THE ENGINE CRADLE ACTUALLY WAS. THERE WAS AT LEAST AN INCH GAP INDICATING IT WAS BEGINNING TO SEPARATE FROM THE BODY OF THE CAR. I TOOK PICTURES OF THE DAMAGE AND...

I DROVE TO MY FRIENDS HOUSE, AND 15 MINUTES LATER MY CAR WAS ENGULFED IN FLAMES! THE FIRE CHIEF SAID IT WAS AN ELECTRICAL PROBLEM THAT STARTED THE FIRE. MY CAR WAS NOT RUNNING, AND I WAS NOT IN IT.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING IN REVERSE, A VERY LOUD SCRATCHING NOISE EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE SEPARATED FROM THE CRADLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 216,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE APPROACHING A STOP, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE ERROR CODES AS P401 AND P172. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBERS: 03V471000 (FUEL SYSTEM) AND 04V113000 (POWER TRAIN). THE FAILURE MILEAGE WAS 160,000.

TOOK MY PACIFICA IN TO GET HOSE LOOKED AT AND SOME NEW TIRES. WAS CALLED AND TOLD TO COME GET MY CAR AND PARK IT. WAS TOLD THAT ENGINE CRADLE HAD RUST AND ROT AND THAT IT WAS NOT SAFE TO DRIVE. I'VE HAD THIS CAR FOR ALMOST 10 YEARS AND HAD NEVER HEARD OF THIS. I DRIVE EVERY DAY AND NEED MY CAR.

TAKATA RECALL VEHICLE WILL NOT STAY FIRED UP AS SOON AS SOON AS THROTTLE IS RELASED CAR DIES IMMEDIATELY, SOMETIMES NOT STARTING BACK UP FOR 15-40 MINUTES, REPLACED IDLE AIR CONTROL, REPLACED THROTTLE POSTION SENSOR, REPLACED ALL SPARK PLUGS, RAN A FUEL CLEANER, AND REPLACED ALTERNATOR, CAR STILL WILL NOT STAY TURNED OVER AND STILL WILL NNOT IDLE, IF THROTTLE AND RPM DROP CAR WIL DIE IN TRAFFIC SITTING IN DRIVE WAY HASN'T MATTERD WHERE HAPPENS EVERYWHERE

I WAS DRIVING AND MY CHILDREN SMELLED SMOKE. I PULLED OVER AND OPENED THE HOOD AND SAW A FIRE. A STRANGER STOPPED AND TRIED PUTTING IT OUT WITH A FIRE EXTINGUISHER BUT IT CAUGHT ON SO QUICKLY THAT THERE WAS NO CHANCE. I SUFFERED A COMPLETE LOSS SINCE THE ENTIRE CAR WAS ENGULFED IN FLAMES.

THE COOLING SYSTEM FOR THE CAR DOES NOT WORK CORRECTLY. AFTER A STEADY IDLE OF ABOUT 5 MINUTES, THE CAR WILL BEGIN TO GET HOT AND THE FANS WILL KICK ON. TWO MINUTES LATER IT WILL DO IT AGAIN. THE SYSTEM IT SELF SEEMS OK, BUT THE FAN IS CONSTANTLY ON AND OFF. THE MOTOR GET S SO HOT THAT THE HOOD ON MY CAR IS STARTING TO TURN. NEXT IS THE AIRBAGS. THE AIRBAG LIGHT FOR THE PASSENGER SIDE IS ALWAYS ON INDICATING A FAILURE. THE BAG HAS NEVER BEEN DEPLOYED? NOW THE BIGGEST PROBLEM IS THE TOP END OF THE MOTOR. MY CHECK ENGINE LIGHTS KEEPS COMING ON. KEEPS SAYING MISFIRE ON CYLINDER 4. EVERYTHING HAS BEEN REPLACED AND I STILL GET THIS CODE? MY VEHICLE GETS IT REGULAR MAINTENANCE AND MY MECHANIC SAID MY CAR SHOULD NOT HAVING THESE PROBLEMS.

I RECENTLY PURCHASED A USED 2004 PACIFICA. WHILE GETTING THE OIL CHANGED FOR THE FIRST TIME I WAS INFORMED BY THE TECHNICIAN THAT THE ENGINE CRADLE / SUB-FRAME WAS SHOWING SEVERE CORROSION. I SPOKE TO CHRYSLER THE NEXT DAY AND WAS INFORMED THAT EVEN THOUGH THIS IS A KNOWN ISSUE, AND CHRYSLER DID ISSUE A CONSUMER SATISFACTION BULLETIN AND EXTEND THE WARRANTY UP TO 150000 MILES ON THIS ITEM THAT MY VEHICLE WAS OUTSIDE THAT AND THEY WOULD NOT HONOR THE WARRANTY REPAIR. EVEN THOUGH THE PREVIOUS OWNER DID NOT HAVE THE WORK COMPLETED UNDER THE WARRANTY EXTENSION.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFIC. THE CONTACT STATED THAT WHILE REPLACING TIRES ON THE VEHICLE BY A SERVICE STATION, IT WAS INFORMED THAT THE ENGINE CRADLE OF THE VEHICLE HAD CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

MY PACIFICA HAS AN EXHAUST PROBLEM I HEAR AN EXHAUST NOISE AND SMELL FUMES INSIDE OF VEHICLE.

CHRYSLER DID NOT PROPERLY COAT THE ENGINE CRADLES WHICH ALLOWED RUST TO DAMAGE THE CRADLES AND CREATE A SERIOUS SAFETY DEFECT. DURING A ROUTINE INSPECTION, MY MECHANIC DISCOVERED THE ENGINE CRADLES WERE RUSTING OUT. THE ENGINE CRADLES WERE REPLACED BEFORE THE ENGINE FELL THROUGH.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE MAINTENANCE AND IT WAS DISCOVERED THAT THE ENGINE CRADLE HAD EXCESSIVE RUST AND FRACTURES AND NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,300.

THE FRONT SUBFRAME KNOWN AS THE "ENGINE CRADLE" IS SEVERELY RUSTING OUT. THIS IS A KNOWN ISSUE BY CHRYSLER ON 2004-2005 PACIFICAS. THERE WAS AN INADEQUATE COATING OF THE METAL WHICH LEADS TO PREMATURE RUSTING. IN 2010 CHRYSLER ISSUED AN EXTENDED WARRANTY FOR THIS, BUT ONLY FOR CARS BUILT IN A SIX WEEK PERIOD IN 2004. THIS ONLY COVERED A SMALL FRACTION ON THE CARS AFFECTED. CHRYSLER NEVER SENT INFORMATION TO OWNERS WARNING OF THIS OR OFFERING SUGGESTIONS ON MAINTENANCE OF THIS ISSUE. AS A RESULT, THOUSANDS OF PACIFICA OWNERS LIKE MYSELF ARE LEFT WITH CARS UNSAFE TO DRIVE AND UNABLE TO SELL BECAUSE OF THE SEVERITY OF THE ISSUE. THE RESPONSE FROM CHRYSLER (FAC) WHEN YOU CONTACT THEM IS "SORRY, IT IS NOT UNDER WARRANTY".

I OWN A 2004 CRYSLER PASIFICA THAT I PURCHASED NEW THAT HAS SEVERE RUST OF THE ENGINE CRADLE AKA SUBFRAME WHICH MAKES IT IMPOSSIBLE TO DRIVE THE CAR SAFELY OR SELL THE CAR AS WELL. THIS RUST SEEMS ABNORMAL FOR A CAR THAT IS 10 YEARS OLD. DOING RESEARCH ONLINE, WE HAVE NOTICED THAT CHRYSLER ADMITTED TO THE PROBLEM AND HAS FIXED CERTAIN CARS WITHIN SOME LIMITED PRODUCTION RUN SOLD IN CERTAIN STATES. OUR PROBLEM DOES NOT SHOW UP ON ANY RECALL LIST AND WE DON'T HAVE A RECORD OF CHRYSLER CONTACTING US ALTHOUGH THEY SHOULD HAVE. WHAT CAN I DO ABOUT THIS PROBLEM?

UPON TAKING MY VEHICLE TO BE SERVICED AFTER PURCHASE 1 DAY AGO, THE MECHANIC DISCOVERED THAT THE ENGINE CRADLE WAS RUSTED OUT ON THE RIGHT SIDE. THIS IS THE ONLY RUST ON THE UNDERSIDE OF THE VEHICLE. I AM CURRENTLY IN DISCUSSIONS WITH THE DEALER TO REMEDY THIS ISSUE, BUT HAVE DISCOVERED THAT THIS IS A FREQUENT PROBLEM.

I PUT MY 2004 CHRYSLER PACIFICA IN THE SHOP ON 8/24/2015 FOR AN OIL CHANGE AND INSPECTION AND TO MY SURPRISE WAS TOLD THE "SUBFRAME IS ROTTING OUT". MY MECHANIC STATED THIS IS A COMMON PROBLEM FOR THE PACIFICA. I DID SOME RESEARCH AND FOUND A CONSIDERABLE AMOUNT OF COMPLAINTS FOR THE SAME EXACT ISSUE. APPARENTLY, CHRYSLER PROVIDED AN EXTENDED WARRANTY FOR A VERY SMALL NUMBER OF CARS EFFECTED BY THIS SAFETY HAZARD. CHRYSLER IS NOT TAKING THIS DEFECT SERIOUSLY; SHOULD PROVIDE CORRECTIVE ACTION BEFORE FATALITIES OCCUR.

TOOK 2004 PACIFICA IN FOR ROUTINE OIL CHANGE AND FOUND OUT CRADLE IS RUSTING OUT. TO REPLACE THE CRADLE WILL COST OVER $3000. TO NOT FIX IT MEANS THE CAR WILL BE UNSAFE TO DRIVE.

I HAVE AN 04 CHRYSLER PACIFICA WITH A SEVERELY RUSTED ENGINE CRADLE. I WAS TOLD BY A MECHANIC AT GOODYEAR WHILE TRYING TO GET AN ALIGNMENT THAT MY CRADLE WAS TOO RUSTED TO DO THE ALIGNMENT. HE THEN SAID THIS IS A KNOWN ISSUE WITH CHRYSLER PACIFICAS. I DID SOME RESEARCH AND FOUND A LETTER THAT WAS ISSUED TO OWNERS OF PACIFICAS REGARDING THIS PROBLEM. HOWEVER, I DID NOT RECEIVE THE LETTER. SO I CALLED THE CHRYSLER COMPLAINT LINE AND SPOKE WITH SOMEONE WHO GAVE ME A CASE # AND TOLD ME I WOULD NEED TO HAVE THE ISSUE VERIFIED BY A CHRYSLER DEALER AND THEN THEY WOULD LOOK INTO PAYING FOR THE REPAIR. I TOOK IT TO MY DEALER WHO VERIFIED THE REPAIR AND TOOK SEVERAL PICTURES. I HAD NOT HEARD ANY THING BACK SO I CALLED BACK TO THE COMPLAINT LINE ABOUT MY CASE#. AT THAT TIME I...

THE MOTOR MOUNTS ON THIS VEHICLE HAVE BEEN REPLACED MULTIPLE TIMES. 3 AT A TIME. THERE ARE ONLY 4 OF THEM. I WAS NOT AWARE THAT IT WAS A COMMON ISSUE ON THESE CARS SUBSEQUENT RESEARCH HAS SHOWN THAT IT IS VERY COMMON. IT DOES PRESENT A SAFETY RISK.

JUST BROUGHT OUR CAR TO THE SHOP FOR AN OIL CHANGE AND THEY INFORMED US THAT OUR ENGINE CRADDLE IS SO BADLY ROOTING THAT WE HAVE TO SPEND $2300 TO REPAIR. I HAVE HEARD CHRYSLER NEW ABOUT THIS AND IS DOING NOTHING ABOUT IT BECAUSE OUR CAR WAS BUILT IN AUG OF 2004. THAT IS HORRIBLE !!!!!

MY CAR HAS BEGUN TO SHAKE. I JUST GOT BACK FROM THE MECHANIC, WHO EXPLAINED THAT THE ENGINE CRADLE IS SEVERELY CORRODED AND RUSTED WITH SEVERAL HOLES IN IT. HE PRINTED UP THE RECALL INFORMATION CONCERNING THIS, WHICH I NEVER RECEIVED OR KNEW ABOUT ... AND WHICH DOESN'T COVER MY CAR. I HAVE $2,000 WORTH OF WORK NEEDED TO MAKE MY CAR SAFE THAT CHRYSLER SHOULD BE PAYING FOR. I AM COMPLETELY SICK OF PAYING OUT OF POCKET TO FIX THINGS ON MY CAR THAT HAVE BEEN RECALLED, BUT MY CAR ISN'T COVERED UNDER. I AM ABSOLUTELY LIVID AT THIS POINT!!!

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO REPLACE THE STARTER. THE CONTACT WAS INFORMED THAT THE MOTOR CRADLE WAS CORRODED AND THE STARTER WAS UNABLE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 8/19/15*CN

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING AT 30 MPH, THE VEHICLE JERKED AND THE CONTACT HEARD A NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE CRADLE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

WHILE IN FOR AN OIL CHANGE I WAS INFORMED THAT THE ENGINE CRADLE HAS RUSTED THROUGH. I WAS TOLD THE SAME THING LAST YEAR ALSO. I WAS INFORMED THAT NOW IT HAS RUSTED THROUGH TO WHERE IT MAY NOT BE SAFE TO DRIVE SINCE THE ENGINE COULD SHIFT ON THE RUSTED ENGINE CRADLE AND CAUSE AN ACCIDENT. LOOKING ONLINE I SEE THAT MANY 2004, 2005 PACIFICAS HAVE THIS PROBLEM AND MANY HAVE BEEN TOLD BY CHRYSLER CORP., AS I WAS LAST YEAR, THAT MY VEHICLE WAS NOT MANUFACTURED WITHIN THE 2 MONTHS WHERE THEY SAY THEY HAD MANUFACTURING PROBLEMS AND HAD FIXED THOSE THAT THEY SAY WERE DEFECTIVE. CHRYSLER HAS REPAIRED MANY PACIFICA ENGINE CRADLES, ACCORDING TO INFORMATION ONLINE, BUT ONLY AFTER HAVING AN OUTSIDE INVESTIGATING AGENCY LIKE A TV STATION OR OTHER ENTITY GETTING INVOLVED. THIS APPARENTLY IS A DANGEROUS SITUATION THAT CHRYSLER DOES NOT WANT TO ADDRESS WITH...

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING AT 40 MPH, THE TIRES SQUEALED AND THE VEHICLE VEERED TO THE RIGHT. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE WHEEL LEANED INWARDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ENGINE CRADLE WAS CORRODED AND FRACTURED. THE TECHNICIAN DIAGNOSED THAT THE STRUT, STRUT MOUNT, TIE ROD, AND ENGINE CRADLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

TECHNICIAN FOUND PERFORATION ON THE FRONT SUBFRAME/CRADLE AREA ESTIMATED COST TO REPLACE $ 2,566.62.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE THE VEHICLE WAS BEING INSPECTED, THE INDEPENDENT MECHANIC DIAGNOSED THAT THE PASSENGER SIDE OF THE ENGINE CRADLE HAD A HOLE THAT RUSTED THROUGH. AS A RESULT, THE ENGINE CRADLE NEEDED TO BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,000.