2016 HYUNDAI SONATA Engine Problems

The vehicle consumes oil quickly.

I have 81345 miles on my car and I was driving on a long trip on a turnpike after 3 hours and approximately 150 miles of driving, the blinking check engine light came in my car and the engine lost power, I was unable to go past 50MPH in the posted speed limit of 70MPH. I had other 4 passengers in my car including 2 minors. had to tow it to Stoltz Hyundai of PA and the dealership told me it was low on oil and my car had 2 quarts of oil left which was unbelievable to me because I just had an oil change at 79123 Miles. I also had them replace my spark plugs at 79K miles. I was told by the dealership to perform an oil consumption test at a cost of approx. $400 and I was not covered under any kind of warranty as I...

Car was leaking oil I reported to Hyundai and service repair shop had to take it back 3 times due to them neglecting to listen to me oil got into other parts and I had to get 7 things fix also after having back for 1 day the brakes and electric is not working properly engine also fails to accelerate correctly

The contact owns a 2016 Hyundai Sonata. The contact stated while driving 60 MPH, the vehicle made an abnormal sound. The contact veered to the side of the road before the vehicle ceased. The check engine warning light was illuminated. The contact was able to restart the vehicle and continued driving to his residence at low speed. The vehicle was taken to the local dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 131,000.

The contact owned a 2016 Hyundai Sonata. The contact stated while driving 2 mph, the vehicle seized and multiple warning lights were illuminated. The contact saw fire exiting from under the hood and under the vehicle. The contact was able to exit the vehicle safely before it was engulfed in fire. The fire department extinguished the fire but no fire report was filed. A police report was filed. The contact stated no one was injured nor sought medical attention. The vehicle was not drivable. The police officer deemed the vehicle a total loss. The vehicle was towed to the police department lot. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 100,000.

Purchased car with just under 97000 miles. Was working terrific. Time for the first oil change and 2 miles after the change the car froze and went limp. Traveling 45 miles per hour it recorded a trouble code on my monitoring device. P0605 - ROM error and the car was dead. All lights had lit up on the panel and then it was off. Luckily was able to recover to the side and turn into a parking lot. Oil was low the night before and refiled before oil change. An additional code was recorded on Feb 12 P0128 Coolant Thermostat Malfunction. The selling dealer cleared the code and said the car was fine. I think there may be an additional issue here and why the oil was low.

Oil consumption issue. Car was driving funny and oil light blinked and then stopped. Checked the oil immediately and it was empty. Changed the oil and it was low within less than 100 miles. Could have blown up if I hadn’t noticed the light blink once and car acting funny. No warning and using way too much oil.

Check engine light came on, difficulty accelerating from a dead stop or going up an incline. I had it at to 2 different locations to be placed on a computer, code P0010 for intake (A) camshaft position actuator circuit. I had that replaced only to drive the car for a week and a half for the check engine light to come back on when accelerating up an incline and have the car almost come to a stop. New code, P0302 misfire #2 cylinder. All four spark plugs were replaced, a compression test was performed to confirm low compression on cylinder #2. Car is drivable, however check engine light will continue to come on because of the low compression but was told to baby the car as the engine should probably be replaced sooner than later and I don't have thousands of dollars for this fix. And last be not least,...

I just drove up a small hill and then I had to accelerate to get onto the on-ramp to match the speeds of highway traffic. The engine shut off. no lights from the cluster gauge illuminated. had to really use my leg muscles to step on the brakes really hard to avoid a front collision. had to really use the muscles in my arms and hands to steer the steering wheel hard too. it felt like the loss of brakes and steering capabilities turned off and were really hard to use when the engine turned off for no apparent reason.

engine is running out of oil after driving 200 to 300 miles. Dealer cannt find any oil leakage. I need help with this problem

My 2016 Hyundai Sonata (sport) with the 2.4 GDI theta II seized on me WHILE DRIVING down the interstate on April 14, 2022, no engine light, no warnings, nothing. It was extremely dangerous & also very scary. The car did this at 135,000 miles. I had my Sonata towed to a Hyundai service center after this happened. They did a diagnosis, confirming it needs an engine replacement due to connecting rod bearing failure. They sent in a Prior Approval request to Hyundai and Hyundai DENIED the engine replacement, due to not having Campaign 953 (knock sensor detection software) completed prior to bearing failure. (EVEN WITH having this sensor update done, it would NOT prevent the motor from failing, just tell you when it happened.) That software update wasn't going to save my engine, it was only designed so Hyundai had a LOOPHOLE to deny as many engine replacements as possible...

While driving home on my way from work, the car started to stall on the highway and slow down. A knocking sound began to come from under the hood and would speed up when I stepped on the gas. From the sound of it, it seemed like the engine was malfunctioning and yes it is available for inspection. My safety was put at risk because if the car was to stop in the middle of the highway, not only am I at risk of being in an accident but other people as well as we are all driving at high speeds. This problem has not yet been confirmed by a dealer but when I took it to a mechanic, I was told that it was a rod that's what's causing this, and though there are no recalls on this specific model (2016 Sonata Limited) there are other recalls on the...

Burning oil at an alarming rate. No oil leaks. Had oil changed and 3 weeks later checked and it had about 2 quarts in it.

Pulled in driveway and putted out and wouldn't start. It is an internal engine issue. Possibly a rod issue

The contact owns a 2016 Hyundai Sonata. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact was constantly topping off the engine oil. The vehicle was taken to the dealer, where an oil consumption test was performed, and the dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,156. The VIN was unavailable.

The contact owns a 2016 Hyundai Sonata. The contact stated four days after purchasing the vehicle, he needed to add oil to the engine. The contact stated that the low oil pressure warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing an oil consumption test performed. The contact stated after 1,000 miles the vehicle was taken back to the dealer and the contact was informed that oil needed to be added to the engine. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was 67,156.

My car idles very rough at times, and sometimes when idling, it dies out. At times it is difficult to even start as if it's not getting the electrical signal to the engine. Hyundai replaced the fuel pump, but that did not fix the problem, but cost $1,200. No warning messages. Two other automotive companies also did a diagnostic tests, but couldn't find the problem as it seems it has to be tested WHEN IT IS ACTING UP. It died on me far from home a week ago, but eventually restarted. I'm afraid to drive it especially at night as it died when idling at a light and almost didn't restart.

While driving the vehicle within the city the engine turned off in the middle of the intersection causing near miss in the middle of the intersection as other vehicle were trying to pass me because my vehicle stalled. After having to towed the vehicle it was found that the engine has seized which is why the vehicle stopped.

While driving on the highway my vehicle started making a very loud ticking noise and all of a suddenly my car stopped working. Due to being on the highway everybody was going high speeds which almost caused a serious accident. There were cars swerving everywhere. I truly thought I was going to be involved in a high-speed accident which would most likely cost me my life. The check engine light came on and smoke was coming out and the dash started throwing errors. One of the drivers came to my car and started yelling to get out because these cars have been catching on fire. I had to call a tow truck to tow my car over an hour back home which cost me quite a bit of money. After I got home I researched my vehicle and placed to VIN to find out there were 3 safety recalls, one...

The contact owns a 2016 Hyundai Sonata. The contact stated that while driving approximately 25 MPH downhill, the vehicle stalled. No warning light was illuminated. The contact was able to coast to the side of the road and had the vehicle towed by AAA. The dealer diagnosed that the engine had failed and needed to be replaced. The vehicle was repaired with a rebuilt engine. The manufacturer was made aware of the failure. The approximate failure mileage was 65,000.

Burns oil at an extraordinary rate. Takes about 1-2 quarts every week. No leaks, I’m unsure what the cause is for the oil burning so fast but it’s not leaking because I’ve gotten it checked for leaks and there is not oil stains or puddles when the vehicle is parked.

Engine burns off oil at an excessive rate. I was told there is a recall on the engine for my vehicle. Also, the transmission is acting up. I have a white pearl sonata and the paint has peeled off the roof and part of the hood. There is a recall on that as well, as I was told.

On April 12, 2022. I was driving with my grandson. I heard some loud engine noise in which I thought was coming from an old red truck next to me. I continued driving and continued to hear the noise after I was away from the truck. I realized the noise was coming from my vehicle (2016 Hyundai Sonata). The interior lights started flashing ( oil light, engine and battery lights) and the car started losing power. I was able to pull over to the right lane by the curb. The engine shutdown and wouldn't start back up. The car was towed to Jeff Wyler Superior Hyundai, 238 W. Mitchell Ave., Cincinnati, Ohio 45232. My vehicle is still there. In January of 2022 I had my car at the dealership for losing power. They repaired it, saying it was the cylinders and then in April 2022 the whole engine shuts completely...

I have a 2016 Sonata with 81,000 miles, I was driving the car when I started hearing knocking noise under the hood and Suddenly the car cut off and wouldn’t start. No dash board lights came on. Prior to car shutdown. My safety was put at risk because the car cut off near the highway and I had to push the car to a safe location. The dealer confirmed that the engine needed to be replaced at $8,500.

I was driving the vehicle, it started making a weird noise, the console lights started flashing and then the engine shutdown and wouldn't start back up.

Purchased a 2016 Hyundai Sonata on 7/2/22. At the time, it had approximately 119,000 miles on it. About a month later, the car overheated. Thankfully, husband is a mechanic. Since the initial overheating, we had been diligently adding coolant every few days. However, as of last month, the overheating had gotten so bad, we took it to an independent mechanic who quoted us about $8,500.00 for repairs, including installing a new engine.

The contact owns a 2016 Hyundai Sonata. The contact stated the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to a dealer, and it was confirmed that no cause for the failure was found. The contact then took the vehicle to an independent mechanic where it was diagnosed as engine wear, due to a lack of proper lubrication The vehicle was not repaired. The contact then took the vehicle to another dealer, North Freeway Hyundai (20440 Interstate 45 N, Spring, TX 77373) where it was diagnosed as needing the engine to be flushed. The vehicle was not repaired. The manufacturer was made aware of the failure but stated that the vehicle was out of warranty. The failure mileage was approximately 59,013.

Upon buying the vehicle the engine started to burn excessive amounts of oil.

My 2016 Hyundai Sonata is sitting at the Red Hoagland dealership in Winter Haven, FL after the engine started knocking. Rather than continue driving it and risk an accident with our 19-yr old child driving it, or risk worse damage to the engine, I had it towed to Red Hoagland service department. This occurred less than a week after we had it at the dealership for the third and final oil consumption test. These tests were being conducted as part of Hyundai’s process to identify the known engine issue with this model. Each 1,000 mile test revealed that the engine was consuming approximately 3.5 quarts of oil per 1,000 miles (approximately 1 month timeframe). Despite the results of the tests and now the engine failure, Hyundai has denied the claim on the lifetime warranty of the engine. Their stated reason is “out of warranty caused by time in service and...

Huge amounts of oil consumption, have to refill all oil every 20-30 days. Car shut down on highway and went into limp mode, had to impede traffic to attempt to pull over safely. Potential known issue with Theta II engine, but dealership is declining a fix.

*On 10/9/22 I was traveling approximately 60 miles an hour on Hwy 25 in Hollister when I experienced Engine Failure in my 2016 Hyundai Sonata Sport 2.4 liter. Engine available for inspection. *This was the 2nd time the engine light has turned on and resulted in vehicle stalling while driving on the highway. Fortunately, there was no accident. *Hyundai Dealer, Hyundai Corporate, or independent service center have not reproduced or confirmed the problem. There is an extended warranty covering the rod bearing and associated parts, that was neither inspected nor granted by Hyundai. I also reported excessive oil consumption to Hyundai and was put through an "Oil Consumption test" at 120677 miles and was denied repair/replacement, even though the engine was burning more than a quart every 1000miles. This increased to me adding a quart every 500 miles and eventually the engine failed at 161147 miles. The vehicle is an...

The vehicle has had mechanical problems since I purchased it. I have submitted a complaint with the dealership who sold it to me and at their recommendation I am moving it up the ladder. The engine had the knock sensor go bad and also failed the bearing test. As I was driving the check engine light, oil light, and battery light came on and the vehicle lost all power. I was going 60 miles an hour and was barely able to safely get it on the side of the road. It had to be towed to the dealership I bought it from, who determined it had no oil in the reservoir and had burned through it in less than 2000 miles. There was no warning lights. I have had mechanical issues since purchasing the vehicle and they failed to correctly diagnose it. It had an oil consumption test that it...

The engine light has come on and I have done extensive repairs on my vehicle since January 2022. No warning signs showed prior as I have kept up with maintenance on the car since the 60,000 mile marker. The valve gasket cover was replaced as the engine was smoking due to an oil leak. A pipe was repaired due to the leak. The engine camshaft position sensor was replaced. There is still issues with the engine after replacing the CVVT cover and plugs. The spark plugs have been replaced. If my car stalls or blows on the highway, this can cause a major accident putting myself and others at risk. I have done multiple tests with Hyundai dealerships and Firestone and AutoZone and no one can tell me what the ultimate issue is with the Sonata.

While driving at about 45MPH, the car lost and acceleration was limited as the car wouldn’t work properly. Engine make a ticking sound when trying to accelerate. At the time of lost power the check engine(flashing), abs and traction control all came on. It almost caused me to get into an accident. The car also indicated to shut off vehicle. The vehicle code read P1326, called dealer and they stated multiple vehicles has been having the same issues and that they are full with no openings. So I’m in the process of getting it to a dealer who has an opening for a better diagnostic. Dealer says it may be rod bearings.

2016 Hyundai Sonata (not part of any recall) driven short distance on expressway had "check engine light" come on. Pulled off of expressway and checked under hood...No visible issues. Chose to return home via side streets as car was riding rough and having problems with acceleration at that point. Short while later, heard loud noise and saw smoke coming from under hood. Pulled to the side of the road and exited car. Was told by bystander that car was on fire. Called Fire Dept, by the time of their arrival, entire front end ablaze, tires and body melted. Thankfully, fire extinguished before any explosion or damage to neighbor's property occurred. Vehicle was a total loss.

My vehicle lost power exiting the freeway. I went from 70 miles an hour to 10 miles per hour in a matter of seconds. The Check Hybrid system, Turn off engine HEV ! triangle showed up on the dash, then the car slowed to a halt. I had to get my vehicle towed home, then towed to the dealer the next day. The problem with this is, for the past year, the Check Hybrid System HEV light would come on. I took it to the World Car Hyundai North dealership in Live Oak, Texas and a few months later, it's doing the same thing. My vehicle was in the shop at World Car Hyundai from March 24, 2022 until 9/9/2022. I drove my vehicle one week, went out of the country for 2 weeks and upon return, coming from the airport almost home, the car does the same thing. You...

For the past several months I have been experiencing extreme oil consumption. I drive my Hyundai Sonata 2016 an average of 120 miles per week and I am required to put in at least one quart of oil each week. This is not normal and there is a serious internal problem with my engine. I am not leaking any oil whatsoever, therefore, the engine is burning oil . The Planet Hyundai dealership in Golden, CO has told me that they have many cars with the same problem waiting to get their engines replaced under warranty. Planet Hyundai has told me there is nothing more to be done and I need a new engine and to contact Hyundai Headquarters, which I have. I have an extended warranty I purchased when I bought the car and it goes for $100,000 miles or July 2, 2023. My extended warranty has referred me to...

Vehicle has excessive oil consumption. Has been an issue for some time now. Same engine is under recall for the rods/valves malfunction. vehicle has had regular maintenance done. there is no aftermarket work done to the engine. Vehicle has been to the dealer for this issue 3 separate times now and the issue is progressively getting worse.

The engine failed. PIAZZA HYUNDAI in West Chester,Pa confirmed that the engine bearing in my THETA 2 ENGINE failed however HYUNDAI refused to honor their Expressed warranty of 10 year 100,000 mile. This engine is part f the Whistleblower's case which was reported to NHTSA however HYUNDAI refused to replace the engine even though they know they have a major problem with the design and manufacturing of their engine. We have been without our car since March of 2022. We want HYUNDAI to honor their warranty and compensate use for our loss of use of our vehicle during the last 6 months. HYUNDAI knew and knows they have a problem however they have failed to live up to their responsibility. Please contact me as soon as possible via phone and in writing. My cell # is [XXX]. My home # is [XXX]. My mailing address is [XXX]. I have additional...

Had previous issue with HEV warning light and took to dealer. But While driving down the road last night, the HEV light on the dash comes on and beeps, the car sputters then the brakes slam on and the car immediately shut off in the travel lane. Turn car back on put into drive and same thing happens. Vehicle was towed to Dealer.

The contact owns a 2016 Hyundai Sonata. The contact stated that the vehicle was taken to the dealer for routine maintenance and the contact was informed that there was a leak in the scored piston cylinder walls and that the part needed to be replaced. No warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was no longer under warranty. The failure mileage was approximately 140,000.

The contact owns a 2016 Hyundai Sonata. The contact stated that on multiple occasions while driving at undisclosed speeds, the vehicle stalled without warning. Additionally, the contact stated that he noticed white smoke coming from the exhaust. The contact stated that the vehicle was taken to the dealer where it was diagnosed that the engine needed to be replaced. The mechanic stated that the vehicle experienced excessive oil consumption. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the failure was due to the lack of proper maintenance. The failure mileage was approximately 147,000.

Driving down the road so if a sudden it felt like something fell out from under the car and it sputtered a bit then lost all . When I tried to start it a few minutes late all comes on except engine

I was driving and then my car jerk every time I tried to go pass 20mph so I took it to the auto zone to get it checked and they hooked a machine that read code p1326 so I took it in to get checked and the mechanic replaced a knock sensor spark plugs and coil pack and for some reason the vehicle still is misfiring on spark plug number 3 it’s getting no fire I’ve bought a new fuel injector that’s still new in the box but now the vehicle is reading code p0193 which is the fuel rail pressure sensor and was told it could possibly be the engine and I’ve been online and see there has been a lot of problems with Hyundai and knock sensors

The contact's daughter owns a 2016 Hyundai Sonata. The contact stated while her daughter was driving at an undisclosed speed, the check engine warning light illuminated and the engine misfired. The vehicle was taken to an independent mechanic that was unable to diagnose the vehicle. The vehicle was taken to another independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was then taken to the dealer where it was also diagnosed that the engine needed to be replaced and the contact was provided a rental vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was under warranty. The failure mileage was approximately 100,000.

Oil Consumption Test Failed, I was originally told if I could prove it was burning oil and not leaking then I would receive a new engine. New engine rejected saying Hyundai no longer warranty engines for that reason. Was told that when motor seized to have it reevaluated for bearing or rod failure. No way to determine bearing or rod was cause of oil consumption without tearing the motor apart. Knocking noise from engine and experienced Engine Failure, resulted in being stranded in middle of highway with my kids 1 yr after oil consumption test. Hyundai rejecting engine replacement due to low compression from cylinders. Not willing to honor their warranty after an obvious lemon of a motor.

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine Failure due to the rod bearing recall How was your safety or the safety of others put at risk? Could of caused an accident as the car stopped and I was unable to move it - luckly we were able to pull to the should on the carpool lane. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, we had the tow truck take the vehicle to the dealership. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, Lindon Hyundai Dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, check engine light came on the day before the engine failed. Other - Driving down the interstate...

My 2016 Hyundai sonata is burning a lot of oil. I have to constantly put more oil in it. I went to the dealership and they said there is an engine recall to replace the engine but I have to wait until it fails. I don't want to be on the road and my engine seize up and an accident to happen. They said they can't do anything until something happens. That sounds extremely dangerous

The 2016 hyundai sonata keeps losing oil within about 500-800 miles after changing the oil the dipstick shows that the oil needs filled. I have never had to refill the oil so quick after changing on any car I have had. I ended up adding an additive to seal whatever leak or malfunction that the sonata has. I have looked it up and my car does not seam to be the only one with this issue. I never know when its gonna be too low and hurt my engine.

I tried numerous times last year to get my car into the Beaverton Hyundai dealership to address the engine recall each time the service date they would call and cancel due to lack of proper equipment to diagnose. July 19th the vehicle was at the Nampa Hyundai dealership service department for the open recalls. I informed the service department of the loss of power I was experiencing and that no warning lights had come on. Upon completion they stated the engine passed and the smartbox was replaced and car passed the 32 point inspection. On July 22nd the car suffered complete engine failure and had to be towed to the dealership on July 23rd the car was then transferred to the Boise dealership on the 28th on the 29th I was informed they couldn’t diagnose in Nampa that’s why Boise was going to try. On Monday August 1st the service...