2015 HYUNDAI SONATA Power Train Problems

Component/System Failed: Engine – connecting rod bearing failure consistent with Hyundai Theta II engine defect subject to federal recalls and Consent Orders. The vehicle previously received Recall Campaign 953 (KSDS software update), intended to detect premature rod bearing wear. The engine is currently knocking and has been diagnosed as requiring replacement. The vehicle and engine are available for inspection upon request. Safety Risk: Rod bearing failure can cause sudden engine seizure or stall while driving, creating a significant crash risk due to loss of power steering and braking assist. Engine failure DID occurr despite prior recall software update, indicating potential recall remedy ineffectiveness. Sudden stalling in traffic placed myself and others at risk of collision. Dealer Confirmation: Hyundai of North Charleston confirmed through warranty history a prior engine replacement request (PA) was submitted by a previous owner but denied. The recall repair was never performed. Current diagnostic findings indicate engine...

The engine/powertrain on my 2015 Hyundai Sonata (VIN: [XXX] ) has failed due to extremely low compression in all four cylinders, causing severe misfires, hard starting, loss of power, and intermittent rattling noises, and the vehicle is currently available for inspection at the Hyundai dealership. This failure created a safety risk because the engine hesitates, struggles to start, and can stall or lose power during driving, which could lead to a loss of control or an inability to accelerate in traffic. The problem has been confirmed by both an independent mechanic and the Hyundai dealership, who documented low compression across all cylinders. The vehicle has been fully inspected by the dealership on Hyundai’s behalf after I opened a case with the manufacturer. Prior to the complete failure, the car showed warning symptoms such as repeated cylinder 4 misfires, rough starting, reduced power, rattling noises on startup, and the check engine...

Our 2015 Sonata has experiencing Engine failure several times due to excessive and irregular oil consumption. Our family’s safety and the safety of others on the roadway were put at risk as the engine slows, shudders and stalls without prior warning and the check engine light does not come on until the vehicle slows and stalls. The vehicle was inspected at a local Hyundai dealership, and they indicated that this is not covered under warranty. Summary of Engine Issues and Failures: 1.May 3, 2022 – 68,671 miles (local Hyundai dealer) Check engine light on, shudder; oil change performed. No cause identified. Paid out-of-pocket. 2.August 23, 2022 – 75,527 miles (retail shop) Car engines failed on highway, towed to service shop. Valve cover gaskets replaced. Paid out-of-pocket in part and extended warranty paid part of the invoice. 3.April 29, 2024 – 109,229 miles (local Hyundai dealer) Excessive oil consumption noted; valve...

While traveling on local roads and highways the vehicle transmission randomly down-shifts one or two gears. This has occurred when traveling in any gear from gears 3 through 6. It probably doesn't happen in 2nd gear because that is a transitory gear and not a cruising gear. After quickly moving the shifter from automatic mode into manual mode and then back into automatic mode the transmission returns to the proper gear. However sometimes it has down shifted again in as little as 30 to 60 seconds after resetting the shifter. This has been happening for years. The dealership has been unable to fix it. Because it is random, the issue is not readily reproducible by the repair shop. Sometimes it has happened several times within a 15 minute period. Sometimes it has occured multiple consecutive days. Other times a week or two has passed with no incident.

My transmission literally went out once on me the SECOND DAY after I financed it. Now, less than a year later, it says I need to replace the transmission again. This is ridiculous.

UNKNOWN, car was driving fine on the highway, then all RPMS were lost and the car couldn't accelerate past 40mph. At the same time a loud knocking started and when i was able to park and pop the hood, the engine was clearly vibrating and the source of the knocking is undetermined. there are recall's for improperly welded rods in the 2013/14 model sonatas and the 2016 so i find it hard to believe that Hyundai doesn't know that this year and make would have the same known issue and those models have all had recalls already except for mine...

I have had my car serviced twice by the Hyundai dealership for the same exact issue. I believe I was told it was a knock sensor. A refurbished engine ended up being put in. The car is still having the same issues as when I first got it serviced in 2021/2022. My car is sputtering, loses power when accelerating and stalling. My car has always had an oil consumption issue and is causing additional issues with spark plugs.

While driving our vehicle (Hyundai 2015 Sonata Hybrid) around 25 MPH speed in city road... the vehicle stopped completely by itself in few seconds. Got the message "Hybrid System Warning! Safely Stop and Do not Drive" in dashboard and beep beep sounds. Thank god, no accident, the vehicles behand able to stop and avoid the collision. This is serious SAFETY issue, as this could cause accidents if vehicle stops by itself while driving. This is 3rd time in last few years with this vehicles. The recent incident happened was on 5/1/2024 morning around 8.00 am. We went to the Hyundai Service Center and they did looked at the codes and ran some scans and they found nothing wrong. And they said it could be some wrong system warning and can be ignored, as they can't reproduce the issue. And told us to report if this happens, but the worry is...

The car has been having problems with oil consumption. The problem became known in 2022, but the dealer/service department (Frank Hyundai, National City, CA 91950) did not take care of the issue and did not care about safety. The dealer told me, "Your car is OK." On 7/3/2023, the engine light came on. A second round of oil consumption tests began along with a 90,000-mile service, including replacements of filter assy and gasket, four new tires and front and rear brakes, spark plugs, suspension/steering repair, shaft assy, engine repair, cooling system service, and fuel induction service. Shortly after, the car slows down even when my foot is on the accelerator. It feels as though the vehicle will stop. I can see the rpm gauge erratically going up and down. The car lurches or jerks. I reported the jerky problem to the dealer at the second 1000-mi oil consumption test, but...

The car has been having problems with oil consumption. The problem became known in 2022, but the dealer/service department (Frank Hyundai, National City, CA 91950) did not care for the issue or safety. The dealer told me, "Your car is OK." On 7/3/2023, the engine light came on. A second round of oil consumption tests began along with a 90,000-mile service, including replacements of filter assy and gasket, four new tires and front and rear brakes, spark plugs, suspension/steering repair, shaft assy, engine repair, cooling system service, and fuel induction service. Shortly after, the car slows down even when my foot is on the accelerator. It feels like the vehicle will stall/stop (while driving in the middle of the road). I can see the rpm gauge erratically going up and down. The car lurches or jerks. I reported the jerky problem to the dealer at the second 1000-mi oil consumption...

When I press on the brake the vehicle accelerate before it slows down. Sometime the car accelerates for no reason. This has been a recent problem for the past few months. The engine has been replaced from a prior recall.

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the car stalled and struggled to remain running. The contact stated two days later the vehicle was parked and while hitching the RV to the trailer hitch, the vehicle independently moved and collided with a dolly. The contact stated that the dolly was used to load the RV to the hitch. The vehicle was towed to the dealer. The vehicle was being repaired. The dealer informed the contact that the vehicle could not be diagnosed until the vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

Hybrid system warning comes up often and everytime I take it to get assessed, something different is getting fixed. These repairs are all expensive out of pocket repairs. The problems continues to happen and I’m constantly repairing something different.

Car stalls intermittently. When at a stop sign or red light, then when my turn to go I step on gas peddle, car starts to go, then stalls. I have to let off gas pedal and step on it again to get car going. This is dangerous as it leaves me in intersection and vulnerable to oncoming traffic. I had a mechanic check it out and they cleaned Throttle body, but that did not fix problem. No trouble codes showing up apparently.

Hybrid car with various hybrid system failures that results in sudden loss of power while driving. this has occurred 3 times to me while on the highway (I-75 in South FL). Car suddenly loses power, could not accelerate but I was able to get off the highway safety. This has been reproduced at the dealer and they first replaced the hybrid generator then the hybrid battery and ECM and now it occurred again yesterday while I had 2 children with me and now they blame the transmission. This is a dangerous car that should be recalled and investigated for the true cause of sudden and unpredictable power loss.

I would like to write about my experience with New Port Richey Hyundai. I have owned a Hyundai Sonata Hybrid Limited since 2015. I take immaculate care of my car and it only has 65,000 miles. All maintenance has been done regularly and on time. For the last six months I have had a warning light and alarm going off for a few seconds once in a while, which shuts off my cruise control. I took the car in, in the spring of 2023 to have the codes read and no problems were found. Finally, In July of 2023, while my wife was in traffic it started again and totally shut off the car. Unfortunately, the brakes did not work as well. She was going up a slight incline and was able to come to a stop. The brake pedal went completely to the floor. The warning was about a...

The contact’s daughter owns a 2015 Hyundai Sonata. The contact stated that while the vehicle was idling, the vehicle hesitated. The contact stated that his daughter had to depress the accelerator pedal to rev the engine. The contact then stated that on a separate occasion while driving at an undisclosed speed, the vehicle hesitated and stalled. Additionally, the contact stated that on another separate occasion while his daughter was driving at an undisclosed speed, the vehicle unintendedly accelerated. The contact’s daughter was able to regain control of the vehicle and depressed the brake pedal to stop the vehicle. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic where the vehicle remained. The cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,000.

The engine and yes it is. Because my car turned off in the middle of the loop on the highway when there was a lot of traffic and we could have gotten hit. No it has not been. No it has not been. We were driving on the highway then the engine started sputtering and it wouldn’t go faster then 40 when I tried pulling off to the side that’s when the engine ,battery ,and oil light turned on and after that the car just shut off and wouldn’t want to turn back on.

City driving and the bells and warning message on the dash stated the electrical system was being evaluated for causes why the engine/electric drive failed

can't use eco sport motor is accelerate and the car can't read the sensors a/c stop working brakes hard to press

2015 Hybrid Sonata, milages at 82,000 km, owned for 8 years. "Hybrid system warning, do not drive" message occurred, car lost 100% of its power, went into complete stop without any warnings on the middle of the highway. Hazard lights do not work and unable to warn incoming traffic that the car has completely stalled in the highway. The car is unsafe to drive. Went to Hyundai (here in Canada) several times, being charged every time for diagnostic and repair works, been told that the issues were fixed via software update. Problem persists. There are compelling evidences from different car forums, websites and NHTSA own database (28 reports under Unknown, 22 reports under Electrical sys. categories...) on the hybrid system failure or/and 100% power lost lead to complete stalled car. Although all these reports did not site any injury, major or death events, NHTSA should compel Hyundai to take appropriate...

When I am driving car starts shaking a little I stop at a light and when I want to accelerate all of a sudden I step on gas and it wont drive i in middle of intersection it started shaking like it was going to turn off but didn't the check engine light came on but it never turned off i slowly accelerated and it kept driving I got to work turned it off when I turned back on the check engine light was no longer on .i have no idea what happened or why . And my brakes always make noise i had my breaks done in November they don't need replaced yet

In September 2022, we noticed a noise coming from under the car hood. Sounded like a thump as we accelerated. We took it to the Hyundai’s service department and was told that they couldn’t hear anything or find a problem. They changed my oil. We continued to hear a noise but thought it wasn’t a concern. In February, a fairly new tire went flat and we returned to the Hyundai service department. I received a call later and was told that they could hear a noise and they checked, and my oil was extremely low. They topped it off and told me to return in a thousand miles to see if it was still burning oil. If it was burning significant oil at that point, they would seal it and begin the Hyundai oil consumption test. At about 600 miles, I could smell a strong plastic burning odor and we...

I have been keeping up with regular repairs and oil changes on my vehicle; so I was surprised when the oil light flashed once or twice in the past week, specifically when I took a turn tightly. The oil was low when I checked it so I added a quart and didn't think much of it except "I should get into a shop soon and have that checked out." Two days later, my RPMs red-lined past 6-7k and the car was revving up but was not accelerating at all. I pulled over and checked the engine again and without showing any kind of leaks (no spots in my driveway/parkingspot) the engine had consumed the oil I added and then some. Moreover, the problem with the engine revving up but not accelerating was not fixed when I added the oil. It could have been very dangerous if I were on the...

When automatic headlights are on there are time that the headlamps will turn off when engaging the turn signals until turn signals are disengaged.

I was driving on the freeway and all the sudden the check engine light started flashing. At the same time the engine slowed down and would not accelerate past 60 mph. I took the first freeway exit and drove to the nearest auto parts store. The store clerk hooked up a code reader and it came back with a P1326 code, Power Train System. Is it a real problem or just another bad sensor?

This is yet another incident of a Sonata Hybrid hybrid flashing a warning to the driver and the the engine shutting down. This time it was Sep 7, 2022 in Morristown, TN. A brief internet search led to this: https://www.tsbsearch.com/Hyundai/17-HC-003-1 indicating that the issue is known to Hyundai. This is definitely a safety issue, this is a known problem, why was no recall issued?

2 recalls were found on my car and a service campaign. After taking my car to a couple auto shops, within 2 years my car has had the same repair issue involving P010 & P011 codes. After researching and finding there was a service campaign and 2 recalls, I decided to take my car to the dealership due to address the recalls. I took my car in on 8/1 and had a full inspection done on my car. Outside of the normal wear & tear, I was advised that the ECVVT cap was installed incorrectly, that it was leaking oil. I was told that cleaning the oil & reinstalling the cap would correct the problem, it didn’t and I’m out of additional money ($562) and the problem is reoccurring. I’ve called several times recently, as well as one of my mechanics, hadn’t received a return call not until I filed...

Multiple times, when the car start up and is put in to reverse, there is no throttle response. Simultaneously, it can not be put into the manual gear select mode and the car lurches into second gear.

The vehicle is slow to accelerate and as its accelerating it often will jerk or hesitate roughly. There have also been times when accelerating, such as getting on a highway, that the whole (what I assume to be) throttle system will almost stop and it feels like the car is just going to stop right there on the highway. It's very dangerous as cars behind me are also accelerating and not expecting my vehicle to just stop. The vehicle is available for inspection. There are no warning lights, messages, or symptoms prior to the issue. It has not been inspected by anyone yet.

My ABS lights came on and then minutes later my check engine light kept blinking while my car kept stalling or not let me accelerate in the middle of traffic. It’s like the engine dies but the car is on. It only stalls for a second then accelerates then stalls again and accelerates. Almost caused an accident. Seems that this is a problem for a lot of these models. It’s just crazy how it all happened back to back. My car has been running fine otherwise till that happened.

Was driving with cruise control on and driving close to 70mph and the RPMs shot up passed 5 then the car jerked and my speed had went from 70 down to 50 and 40 the cruise controle turned off on its own and the car lost power but was still on but it just wouldn't drive passed 2 rpms and the check engine light was flashing so I turned around and headed the opposite direction so I could get the car off the road then it made this loud noise sounded like throwing metal inside a metal bladed fan and then the car shut off and hasn't started since. The car did not over heat or have any smoke coming from it.

Major oil consumption going on for years. Took in to dealer two years ago, they know there is a problem. They told me I could spend thousands of dollars to tear it apart to find out what is going on, and also told me to call corporate. I got no where with either, even though they recalled the engine in other Sonata cars, just not our ECO model. Slowly started having throttle issues at 4 to 5 year mark. Informed dealer service center that it wasn't moving like it should when gas was pressed. Now, the car is having major problems with acceleration. Barely would go in reverse, drove 1.5 blocks, speed not matching to throttle, press on gas, barely moving from a stop, going really slow, had to turn around and take back home. Our problem with the car is the same that others are complaining about. The car...

While driving in city traffic, 45 mph zone, my car suddenly lost power, engine RPMs dropped, engine off, power steering impaired, I had to drift into turnout and assess. Car restarted, and I could drive, but RPMs would not exceed 1700, car wouldn't shift gears, speed would not exceed about 15 mph. No engine warning lights, no oil pressure indicator, no excess heat. I found I could drive at low rpms and manually shift gears to increase speed. I got the car to the local Hyundai dealer (Taylor hyundai, Augusta GA) and it has been there 8 weeks. They are telling me the engine has failed because I failed to change the oil for 14 months. They said my oil pan was empty. They asked me for maintenance records and said they were inadequate, and the engine needs to be replaced, may cost $6000 or more, warranty invalid. The car...

This is a follow-up to former Complaint #11450586 (05-Feb-2022) and confirms that both my local Hyundai Dealer -and- Hyundai Corporation (USA) are aware of this diagnosable- and fixable problem—but they fail to issue a recall. In fact, a Service Advisor at my dealer expressly vocalized that 1) he himself [excluding his colleagues] has seen at least -2- of the same incident recently; and that 2) Hyundai Corporation (USA) issued a “(service) bulletin” about the problem. PROBLEM: The vehicle: 1) has a high idle; 2) shows a solid-illuminated CEL/emissions light; 3) severely resists braking—my vehicle would even slide through stop signs; 4) fails to “pick up” normally; and 5) drives unsteadily. This is at minimum and is my experience from both last week and from the original report on 05-Feb-2022. As explained to me today (28-Mar-2022) by my Service Advisor, there is a known fault with a component within the engine...

My car has been stalling, hesitating and sometimes I feel the engine shake when using the gas. I brought my car to the dealer to have the most recent recall fixed and asked them to diagnosed what else was going on with my car. They told me the stalling was just due to the recall. However, the very next day my car was acting up again. Additionally, the car at times will accelerate when I am not pressing on the gas. I don't think I need to go into detail about how my safety and the safety of others is compromised when you have a car that accelerates on its own. Lastly, there is no check engine light on. This has been ongoing for several weeks.

Car has been consuming an excessive amount of oil (1-2 quarts per week). While driving down the highway the oil pressure light came on and the engine started clicking and knocking. The engine died and all the dash lights came on. The car was coasted to the side of the road and towed into a local mechanic. The engine had seized and presumably dumped all the oil at the time of the engine failure since the engine had no oil when diagnostic was run. Car was taken to Hyundai dealership and is awaiting diagnostic and repair.

At low idle (stopping) car stalls out when stepping on gas. The RPMs run extremely high and very low at idle causing panic. The vehicle also stalled at full speed on highway but all electrical was still working. Car tends to sputter and jump while shifting.

The vehicle's transmission seems to be slipping or something. As you begin to come to a stop, the vehicle bogs down and you can not accelerate. There is a long hesitation and then suddenly it kicks in and jars the car. This happens on a daily basis. The vehicle is also burning through oil at an unprecedented rate.

This 2015 Hyundai Sonata LTD ([XXX]) falsely indicates CEL/emissions light. When the vehicle is started and the temperature is appx. 20*F or lower, the indicator immediately displays. It is solid and does not blink. This happened on -3- days this week, over approximately 7 of -9- total ignitions in that time. Various forums show the same issue. Hyundai must recall this because it is either a false warning or else is a component within their control with which they failed to manufacture safely (thus contributing to the problem(s) and CEL). INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Sonata started having problems with less than 50,000 total miles. The accelerator is flawed and the vehicle cannot keep speed when traveling uphill or get to speed efficiently. The vehicle jerks for a few seconds when pressing the gas and the engine revs but the vehicle does not accelerate like it should. This has almost caused me to have accidents multiple times when pulling out into traffic. The check engine light came on when this started occurring and has been on ever since. I'm having the hyundai dealership take a look at the vehicle and see if there is anything that can be done.

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at various speeds, the vehicle would suddenly fail to accelerate above 25 MPH with the check engine warning light illuminated. The cause of the failure was not determined. The local dealer was informed of the failure, but no assistance was offered. The manufacturer was not notified of the failure. The failure mileage was 69,000.

The contact owns a 2015 Hyundai Sonata. The contact stated while driving approximately 75 MPH, the vehicle began to vibrate violently. The contact pulled over and had the vehicle towed to a local dealer where it was diagnosed with needing a new transmission. The contact stated that the check engine warning light was illuminated. The manufacturer was not informed of the failure. The failure mileage was approximately 124,000.

My car keeps stalling while I am driving and sometimes when I turn to a street and is consuming motor oil with in a mile or less. It has been inspected by a Hyundai dealership and no leaks were found, consumption test has been done and they said that they can’t do nothing about it because I am the second owner. Hyundai needs to extend warranties to second owners as well if the car was bought through a certified dealership. I trusted their brand and dealership. I have been going back and forth with the dealership. My car is in the Napoleon Hyundai dealership in Carmel, Indiana. I have a video explaining the situation and showing my engine measuring stick with very low oil.

Had an Engine recall for the 2015 recall, was told that Transmission was the reason for the Engine failure, but the dealership would not fix the Transmission. Shortly following the replacement of the Engine, the problems that reside in the transmission are now costly up to $3000 or more for this issue. After extensive research found that the 2015 sonata has had plenty of issues with its Transmission. Responsibility for the Faulty Transmission causing engine to completely shut down and not work (happened while on highway) should fall on the dealership.

Transmission shudder, reverse gear not working, stuck in 3rd gear.

The contact owns a 2015 Hyundai Sonata. The contact stated while driving 40 mph, the vehicle stalled with an abnormal knocking sound coming from the engine. There was oil leaking from vehicle. The check engine warning light was illuminated. The vehicle was taken to the local dealer and diagnosed that the CVT transmission seal needed to be replaced. The vehicle was repaired however, the failure recurred on July 20, 2021. The vehicle was taken to the same local dealer but was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,000.

My Sonata Eco is a 2015 model with less than 46,000 miles. I take it for scheduled maintenance at least twice every year since I purchased it. The vehicle was experiencing stuttering, vibrations and lack of acceleration, most frequently when turning, moving uphill or early after startup. The stuttering would vary in it's intensity, from barely noticeable to strong enough to shake passengers. Sometimes when performing a turn, my car would not be able to accelerate, leaving me in the path of oncoming traffic until it would start working again. This would also occur when travelling uphill. No warning lights or other messages were given by the car. After taking it to the Hyundai dealership they informed me that my transmission was faulty and would require a full replacement. They specifically mentioned it was a mechanical issue with the dual clutch not engaging properly. All electronic/software in the vehicle was...

2015 sonata intermittent problem which involves loss of acceleration when taking off from a stop. One has the accelerator to the floor and vehicle goes to 10 to 12 miles/hour until it gets to about the 3rd or 4th gear. This car has done this 5-6 times since the 20th of May. Took car to dealer; they hooked it up to the computer and got no codes, so I was told it was OK. I told them the car was unsafe to drive. This car has a duel-clutch automatic transmission which I believe has a major problem. Not sure what I can do about it. It has 71,000 miles and should be under warranty.

I WAS DRIVING TO WORK AT LIKE 4:00 IN THE MORNING IT WAS STILL DARK OUTSIDE THE LIGHT TURNED GREEN AND AS I HIT THE GAS PEDAL THE CAR STALL IT WAS MOVING SLOW SO ON MY RIGHT HAND SIDE THERE WAS A BUILDING SO I TRY TO MAKE IT TO THE PARKING LOT THE CAR STARTED TO POWER DOWN IN A KNOCKING NOISE STARTED IT WAS A BUSY MORNING IN THE MORNING WORK TRAFFIC