2015 HYUNDAI SONATA Steering Problems

The steering column locks up. When start vehicle and make turn to get on road the steering locks up and cannot turn the wheel. This is safety concern and not safe to drive.

While driving a EPS light came in and the steering was extremely hard to drive. I was on the highway so I had to pull over to turn off the car and then turn it on. After turning it on it worked ok for a little and then messed up again and I couldn’t turning the steering wheel again. While driving in the highway my safety was at risk because I could have crashed into another car and hurt my self or other people driving. The car can be inspected at any point in time because it is at a Hyundai dealership where it got fixed a few months before. The problem was confirmed by the dealer. The vehicle has not been impounded and a selected dealer. The EPS warning light and key not detected light came on. Hyundai has multiple issues with their staring and wiring with multiple different...

The contact owns a 2015 Hyundai Sonata. The contact stated while her son was driving the vehicle at approximately 65 MPH, the steering wheel became difficult to steer. The contact stated that the driver pulled to the side of the road. The contact stated after the driver turned off and restarted the vehicle several times, the steering wheel responded as needed. The contact stated that the message "Power Steering Fault" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the loss of power steering assist was related to NHTSA Campaign Number: 14V325000(Steering, Electrical System). The contact was referred to the dealer for assistance. The contact stated that the failure recurred intermittently. The vehicle was taken to the dealer, where it was diagnosed that the electric power steering assist motor and unknown related parts needed to be replaced. The contact related the failure...

My steering rack had to be replaced at less than 55,000 miles. I asked the dealer if this was covered under warranty and they said no. I was charged $4,800 for this repair. I contacted Hyundai USA and they refused to cover the repair. I then realized that I had received a letter from Hyundai stating my car had the extended warranty of 15 years/150m miles for this exact repair. I am on the phone with Hyundai now and they are still refusing to cover this repair, even though they sent me the letter stating my car has this extended warranty. My car is available for inspection upon request. Yes, my safety and the safety of others was put at risk, my power steering would intermittently go out while turning. Yes, my car was inspected twice, once in 2023 and again in May of 2025. Repairs were done in May....

Power steering failed, car diagnosed with code C2412 & Hyundai refuses to take accountability

For about a month now the power steering was going in and out and then just the other day, the power steering went completely out, I am now having it towed to the dealership today 02/11/2025. I've also had oil consumption problems to the point where there is only 1 quart of oil left in the engine when getting the oil changed, had the combustion cleaning done and no help. Hyundai said no to a new engine, car only has 102,000 miles on it, only 10 years old and Hyundai hasn't helped a bit, said that I would have to come out of pocket but I ended up having to spend $600 on the cleaning, which is absurd.

The contact owns a 2015 Hyundai Sonata. The contact stated while driving at approximately 35 MPH, several unknown warning lights illuminated on the instrument panel and the contact observed that the steering wheel had become very difficult to turn. The contact stated that the vehicle lost power steering functionality. The contact stated that before the power steering failure, the engine had been replaced by a dealer. The contact pulled over, turned off, and restarted the vehicle, and the power steering functionality returned. The contact stated that the failure was intermittent and occurred at various speeds. The contact took the vehicle back to the same dealer who was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The manufacturer was informed of the failure. The failure mileage was approximately 92,000.

Steering wheel locked with skid slip lines and red steering wheel and exclamation mark lights on. Steering wheel locked up while driving. The car will no turn and is not drivable because the wheel will not turn.

WHEEL LOCKED UP WHILE DRIVING, RED LIGHT CAME ON THE DASHBOARD. ONCE I TURNED CAR OFF AND BACK ON IT WAS FIXED, THIS IS THE SECOND TIME THIS HAS HAPPENED. ANY IDEA WAHT IT COULD BE?

The wheel of my car as I would turn literally locked on me and the car went off to the other side of roadand engine shuts off .this seems to only happen when I make a right turn quickly it is random and I never. Know when this will occur it hurt my hand because the wheel snapped out of my hand as to keep straight . So it's very scary I am looking for help to get itfixed . But I won't feel safe driving it until then I had to buy another car so that I could drive meanwhile I see what I can do about this car

Steering Column making Clicking sound. Steering Wheel completely locked during a turn.

While driving, I was in the middle of a left turn and had a reduction of the power steering assist system. I had to hit the brakes before entering the opposing traffic. I had to muscle the steering wheel to get out of the middle of the road.

The power steering went out on two different occasions. The power steering assist light came on (red steering wheel light in the lower left corner of panel). The car was extremely difficult to drive. Once the car was shut off the system reset and the steering was normal. I brought the car to the dealership twice and they told me they could not duplicate the problem and could not repair the car unless they could duplicate the problem. Hyundai USA basically told me the same thing; even though there must be a known issue because they have extended the warranty on the power steering assist system. The dealership and Hyundai's only solution was to have the car inspected at another dealership. This is a ridiculous solution since the problem seems to be an intermittent issue. Having the car inspected by another dealership will not solve anything. I believe this issue...

While turning in an intersection on a highway, car displayed check hybrid system and shut down. power steering could not engage so braking and turning was almost impossible. Car had to be towed, was not able to be restored

The electric power steering suddenly failed while making a turn on a neighborhood road shortly after beginning a drive. The incident also triggered warning lights for the Forward Collision Warning System, Lane Departure Warning System, and Smart High Beam System. I was able to return the car to a safe location and turn it off. When I turned the car back on later, power steering and other systems worked normally. The service center was unable to recreate the issue. They recommended replacing the steering column for a cost of $3,000+ but did not perform the service due to the issue not recurring. Approximately 10 days later, the electric power steering failed again while backing out of a parking space. It worked normally again after turning the car off and back on. It is unclear if this issue is connected to the known problem with the steering coupler in this vehicle....

Engine failure due to a problem with the type of engine. Hyundai denied warranty and class action settlement claim, due to exceptional neglect. All oil changes etc were accounted for. the car with no warning, had been driving great, lost all power and left me and my two grandchildren on the side of the road. The Hyundai dealership confirmed that the engine was blown. There were no warnings

My steering wheel locked up and I had to turn the car off and back on again in order to steer.

As I was driving down a highway going 65 my steering wheel pretty much locked up. I got a red steering wheel light and traction control light came on to and I could barely turn. I looked this up and a lot of people are saying it's the wiring with the power steering. How is this not a recall? Me and my kids could of died or I couldn't of hit someone else also. Now it's not doing it. But then today as I was driving the kids to school it happened again.

The contact owns a 2015 Hyundai Sonata. The contact stated while driving at various speeds and turning the steering wheel to the center position, the steering wheel independently turned to left, causing the vehicle to veer to the left. Additionally, the contact stated while attempting to make a right turn, the failure recurred, causing the vehicle to go to the opposite direction. The contact stated that she used physical force to manually turn the steering wheel to the right as the steering wheel was resistant. The steering warning light and the traction control warning light were illuminated. The contact stated that the failure had been reoccurring, and the steering wheel was making abnormal clicking sounds while driving. The vehicle was taken to an independent mechanic, where it diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of...

Steering wheel hardens as vehicle picks up speed, making it difficult to turn the steering wheel.

After driving for 15 or more minutes, the power steering fails. The warning light for the power steering and stability control turn on at that moment, as well. This failure occurs while driving and the wheel jerks a bit if the car is in a turn. There was a power steering recall for other Hyundais of the same era, which is very coincidental.

As Im driving the ((electric power steering)) goes out. Its happened 4 or 5 times and when you turn your car off for a period of time the errors go off and dont come back till it does it again. It gets to you cant hardly turn the steering wheel. I'm a big guy and struggle to steer the car when this happens. If this happens when youre driving you could kill yourself or someone else by not being able to turn the steering wheel to avoid another vehicle or person. I was at a dealership and because the icons werent on they couldnt trouble shoot the issue. There was an icon with EPS! in red and an icon with skid marks

The power steering started malfunctioning and then caused all warning lights on the dash to illuminate including check engine, power steering, abs, and after coming to a stop and waiting several minutes the lights went off but power steering was still not operating correctly

The contact owns a 2015 Hyundai Sonata. The contact stated that the TPMS warning light illuminated. The contact then stated that the steering wheel became difficult to maneuver. The contact stated that she had to use the shift release button to shift gear. The contact then stated that all the lights on the instrument panel failed to illuminate. Additionally, the contact stated that the vehicle was taken to the dealer where it was diagnosed that the hub sensor needed to be replaced. The vehicle was repaired however, the failure recurred. The vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 14V325000 (Steering, Electrical System). The manufacturer was notified of the failure and the contact was informed that her vehicle was not included in the recall. The failure mileage was approximately 129,000.

My power steering light came on last night when I arrived from work on Saturday night. Was hoping to take it in to be looked at but the dealership I bought it from is closed till Monday at 10. Woke up Sunday for work decided to see if the light was still on but it was off but about 7 minutes into the the light came back on along with the abs light, engine light, and oil light. I believe a couple more lights came on but not sure which ones but the car stopped working and starting completely

My vehicle experienced a sudden loss of power steering a few days ago, with approx 52,000 miles on the odometer. At the time it happened, two warning lights came on and remained on: a red steering wheel with an exclamation point, and an orange ESC control (icon: car with squiggles underneath) light. For a few days if I turned the car off and back on, the power steering would return and the warning lights would turn off. However today the car started with the lights on and no power steering and it appears to be permanently failed at this time. There is a recall issued for 2015 Sonatas for a power steering issue that sounds identical but my VIN does not appear to be included. My local dealership has no appointments available until November 8th and I have been informed that new power steering components will cost over $2500.

Power steering stopped working. 2 icons came up on instrument panel. A red steering wheel with an exclamation point and a car skidding. I was making a turn and was unable to turn the car back straight. Luckily I was going slow and was able to get stopped. I was able to get the car home without power steering. After restarting the car the power steering came back. Now I can't trust the car.

Driving at 55 and the engine blew. No warning, no check engine light, no sign of anything wrong. Power steering loss, limo mode activation. Almost rear ended during catastrophic failure. 111,000 miles

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at various speeds, the steering wheel would suddenly become extremely difficult to turn in either direction. During the failure, the steering fault warning light was illuminated. After turning off and restarting the vehicle, the vehicle operated as intended. The vehicle was taken to the local dealer who was unable to duplicate the failure; no service was performed. The manufacturer was notified of the failure but no assistance was offered. The VIN was not available. The failure mileage was 80,000.

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at various speeds, the power steering assist would intermittently fail as the reduction in power steering assist would illuminate on the instrument panel. The contact also stated that his vehicle would shut off while driving at various speeds without warning. The contact also stated that the vehicle would independently accelerate as the check engine and oil warning lights illuminated on the instrument panel. The contact had to depress the brake pedal to stop the acceleration. The dealer had yet to be notified of the failure. The manufacturer had been notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 56,000.

Steering Assist Problem Hyundai Sonata 2015 Sport 2.0T The car was purchased in Dec 2015 in California. We have had repeated occurrences of sudden power steering assist problems with the car, which typically happens after driving the car for 10-15 miles, and would go away after turning off the car for a few hours. The issue was first reported in Aug 2017 (case number 2017082505369). The power steering assist abruptly stopped functioning while driving, making it very difficult to steer, and a safety hazard (mileage 18,723). The dashboard had the steering wheel error light on. The dealer replaced the steering rack-gear+linkage. The same problem reoccurred in June 2020 (case number 2020043003513, mileage 46,915). The dealer ran diagnostics and again replaced the steering rack assembly. Between Aug 2021 to Feb 2022, the same problem has occurred again multiple times, and each time we left the car with the dealer to run...

Power steering assist failed upon making a right hand turn. Steering failure led to an injury accident. Vehicle was inspected by Green Light Auto and EDR codes retrieved. No codes specific to steering was found. Vehicle was inspected by insurance adjustor. No warning lights or other indications of steering loss was present before the accident caused by the steering loss. Issue seems similar to NHTSA Campaign Number: 14V325000

The contact owns a 2015 Hyundai Sonata. The contacts son stated while driving approximately 40 mph when the vehicle's steering wheel became hard to turn. The power steering warning light was illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V325000 (STEERING, ELECTRICAL SYSTEM) however the VIN was not included. The vehicle was taken to a dealer where it was diagnosed with being an electrical issue. The vehicle was repaired but continued to experience the same issues. The manufacturer was informed of failure and filed a complaint. The failure mileage was approximately 47,000.

steering wheel locked up while driving causing vehicle to run off the Hwy. vehicle flipped causing injuries

Steering column made gravelly noise and felt wrong after service checkup. Finally acknowledged and fixed (no charge: paid $1600 for extended warranty on purchase 5 years ago) a month later. Horn honks briefly and intermittently sometimes after stop after service checkup. Not yet acknowledged or fixed. Tried to charge an exorbitant amount for service, despite our having an extended free warranty, and refused us a loaner car. Service horrible.

Powering steering seems get harder when i stop at lights and when i turn then car back on from getting grocery.

When driving at low speed straight ahead, steering locked up and was unable to turn left, steering wheel could not be turned from straight ahead position. Stopped vehicle and then started again, tried series of left/right turns to try and duplicate problem, steering would then randomly lock up when attempting to turn, more in left turns than in right. Occasionally was able to make full lock turn to left or right, however steering wheel would "catch" and wheel could not be turned to full lock unless vehicle was stopped and started again. At this point vehicle is not safe to drive and will need to be towed to Hyundai dealer, however Hyundai dealer says it will be at least 2 weeks before they can look at it, so vehicle is completely out of service.

EVERY TIME IT'S BAD WEATHER I HAVE THIS TERRIBLE SHACKING AND DON'T KNOW WHAT IT IS

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE LOSS POWER STEERING ASSIST AND THE STEERING WHEEL BECAME HARD TO MANEUVER. THE CONTACT PULLED OVER AND THE VEHICLE REGAINED POWER STEERING FUNCTIONALITY HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS FIRST TOWED TO THE RESIDENCE AND THEN TOWED TO HYUNDAI INLAND EMPIRE (25072 REDLANDS BOULEVARD, LOMA LINDA, CA 92354, (909)-796-1600) TO BE DIAGNOSED. THE DEALER PERFORMED A DIAGNOSTIC TEST THAT LOCATED A FAILURE CODE AT THE POWER STEERING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 135,000.

WHILE DRIVING THE CAR, THE POWER STEERING LOCKED WHILE I WAS ON 55M/H. THE DASHBOARD HAD THE STEERING SIGN ON. THE CAR WAS EVENTUALLY TOWED HOME BECAUSE IT WAS UNSAFE TO DRIVE. I TRIED THE CAR THE FOLLOWING DAY AND THE CAR WAS FINE AND NO SIGN ON THE DASHBOARD. I TOOK THE CAR ON AN ERRAND AND FEW MINS LATER, THE SAME INCIDENT OCCURRED. THE CAR WAS TOWED TO AN AUTO WORKSHOP WHO DATAMINED IT IS A MANUFACTURE SAFETY ISSUE WITH SENSOR. AS AT THIS MOMENT, THE CAR IS UNSAFE AND VERY DANGEROUS TO DRIVE. I AM REALLY CONCERNED ON WHY THE PUBLIC HAVE NOT BEEN NOTIFIED

SUDDEN LOSS OF POWER STEERING WHILE ON THE INTERSTATE. NEARLY HAD SEVERAL ACCIDENTS TRYING TO GET HOME. I AM A 100% DISABLED VETERAN SUFFERING END STAGE KIDNEY FAILURE A% DAY/WEEK DIALYSIS. I CAN NOT SAFELY DRIVE THIS VEHICLE WITHOUT THE POWER STEERING AND AM ALARMED AT ALL THE WARNING LIGHT ON THE DASH THAT HAVE ILLUMINATED. THE DEALERSHIP SERVICE MGR 1ST TOLD ME THERE WERE NO RECALLS ON MY VEHICLE. I REMINDED HIM OF THE PANORAMIC ROOF RECALL THEY DID. NOW HE SAYS MY CAR HAS NO RECALLS FOR THE POWER STEERING ISSUE CAUSE IT WAS MANUFACTURED IN JULY OF 2014. I PURCHASED IT NEW IN 2015 WITH ONLY 13 MILES ON THE ODOMETER. PLEASE HELP ME SORT OUT THE TRUE RECALL STATUS AND I WISH TO FILE THIS AS A COMPLAINT ALSO. [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN TURNED THE VEHICLE ON, THE POWER STEERING LIGHT CAME ON AND THE POWER STEERING HAD STOPPED WORKING.

WHILE DRIVING ON A BUSY FOUR LANE I ENTERED A TURN LANE TO CROSS TRAFFIC. IMMEDIATELY AFTER I ENGAGED THE ACCELERATOR THE VEHICLE LOST ALL POWER AND STEERING, WITH A ALARM STATING 'HYBRID SYSTEM WARNING-DO NOT DRIVE'. ONE VEHICLE NARROWLY MISSED HITTING MY CAR, (AS IT COMPLETELY LOST ALL POWER AND STEERING AND LEFT ME STUCK IN THE MIDDLE OF ON COMING TRAFFIC). RESEARCHING TODAY I SEE THIS IS COMMON BETWEEN 2012-2016 ESPECIALLY. THIS IS A VERY DANGEROUS SITUATION THAT WAS NARROWLY AVOIDED.

STERLING IS LOCKING UP

STEERING GETS HARD AND YOU ARE NOT ABLE TO TURN THE STEERING WHEEL. WHILE YOU ARE DRIVING.

MY 2015 HYUNDAI SONATA HAS A PROBLEM OF STEERING LOCK FOR 1 SECOND WHILE DRIVING ON ROAD WHEN TURNING LEFT /RIGHT. ON MARCH 3RD I WAS DRIVING ON GA-317 S AND WANT TO TAKE RIGHT TURN ON GA-120.AS SOON AS I TOOK THE TURN AND WAS ABOUT TO MERGE IN THE LANE THEN SUDDENLY MY CAR'S STEERING GOT LOCKED FOR A WHILE (AROUND 1 SECOND) AND UNLOCKED AGAIN AUTOMATICALLY AND MY CAR'S COMPUTER SYSTEM ALSO RESTARTEDBLUETOOTH DISCONECTED AND RADIO STARTED LOKE WHEN YOU START THE CAR .ANY FURTHER DELAY IN UNLOCKING THE STEERING COULD CAUSE SERIOUS ACCCIDENT. THANKS TO GOD FOR SAVING ME . THIS PROBLEM IS VERY DENGEROUS FOR THOSE DRIVING THE 2015 HYUNDAI SONATA BECAUSE OF STEERING LOCKS WHILE TAKING TURN. NOW I SCARE TO DRIVE,HYUNDAI COMPANY SHOULD TAKE THIS ISSUE VERY VERY SERIOUSLY AND SHOULD RECALL THESE VEHICLE. WHILE CONTACTING THE ONE OF THE AUTHORISED DEALER IN...

ELECTRONIC STEERING CONTROL COMPLETELY FAILED WHILE ACTIVELY DRIVING ON STATE HIGHWAY AT 65 MPH.. WARNING LIGHT DID COME ON BUT STEERING WAS VERY DIFFICULT AS THE STEERING WHEEL WAS VERY DIFFICULT TO MANEUVER. WORSE THEN HAVING MANUAL STEERING. ODOMETER READING AT THE TIME WAS 49504 MILES

ON 11/5/2019 WHILE DRIVING STEERING WHEEL LOCKS UP THROWING A EPS CODE. HAD TO PULL OVER IN 55 MPH TRAFFIC. LUCKY I WAS ABLE TO GET OFF THE ROAD. TURNED OFF THE CAR AND RESTARTED IT AND THE EPS LIGHT WAS GONE. I MADE IT HOME. ON 11/7/2019 ON THE WAY TO DEALERSHIP WHEN I LOST ALL POWER STEERING AND HAD TO HAVE THE CAR TOWED TO HYUNDAI OF VALDOSTA, WHERE IT CURRENTLY SITS. THIS IS REALLY DANGEROUS.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL CLICKING NOISE DETECTED FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO STEVENSON HYUNDAI OF JACKSONVILLE (2325 N MARINE BLVD, JACKSONVILLE, NC 28546, (910) 455-1555) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE COUPLER NEEDED TO BE REPLACED AT THE CONTACT'S EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS INVALID.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED, LOST POWER, AND WENT INTO LIMP MODE. THE CONTACT ALSO MENTIONED THAT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE HESITATED TO MOVE. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO GETTEL HYUNDAI OF CHARLOTTE COUNTY (1950 TAMIAMI TRAIL, PUNTA GORDA, FL 33950, (941) 347-6626) WHERE THE DOWN STREAM SENSOR, PCM, VCM, FUEL PUMP MODULE, AND KNOCK SENSOR WERE REPLACED. THE CONTACT ALSO MENTIONED THAT THE THROTTLE WAS UNCLOGGED; HOWEVER, THE FAILURES RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO WAIT UNTIL IT RECURRED. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 67,308. *PM CONSUMER STATED VEHICLE WAS REPAIRED 12 TIMES.*JB