2017 HONDA PILOT Engine Problems

I feel the engine is failing

I believe my vehicle is impacted by the Honda/Acura related to recall 23V751000(Engine Damage from Connecting Rod Bearing Wear A damaged engine may run improperly or stall while driving). Ticking noise in engine. 2017 Honda Pilot 40,028 miles on it. Dealership has advised that this is not part of the VIN recall, the connecting rod bearing is spun and I now need to replace the engine.

The engine developed bottom end knock. We brought it into the Honda dealership and they opened the engine from the oilpan to conduct an inspection. The dealership confirmed that the crankshaft bearings have scoring and the engine short block or whole engine needs to be replaced. This is the same issue that is being investigated under NHTSA Action Number: RQ24013. There is a recall for this exact same issue for Honda Pilots model years 2016, 2018, 2019, but ours is a 2017 -- the active recall is Part 573 Safety Recall Report 23V-751. The dealership contacted Honda, who is only willing to issue a courtesy discount, so that the cost to fix is $8,000 to $9,000. The car only has 115,000 miles and has been regularly serviced by the dealership for oil changes and all other recommended repairs and service when due, so this is likely a defect with the...

Connecting rod bearing failure at 118,000 miles. Followed all recommended Honda service schedules at authorized Honda dealerships. Need to replace crankshaft, main bearings, #2 cylinder connecting rod and connecting rod bearings and all related gaskets, o-rings, seals, etc. Could have been major safety issue if I was driving when the engine failed. Vehicle is at a Honda dealership and Honda corporate told me, sorry, but out of warranty. Worse customer service experience in my lifetime. No vehicle regardless of manufacturer and regular servicing should require this type of repair, ever at this mileage. There is a manufacturing defect since model years on both sides of the 2017 model are currently involved with engine recalls per the information below. Quite the coincidence that my Pilot experienced the exact same failure. No warning lights became illuminated. Engine and engine cooling: Engine: Hard parts internal/mechanical Recall date 2023-11-12 Recall no. 23V751000 Honda (American...

There was a knocking noise from the engine. I took it in for repairs and I was told that it is due to an abnormally worn rod bearing. I looked into this problem and found that there is an open investigation for the Honda Pilot 3.5L V-6 and abnormally worn rod bearings leading to possible engine failure. I mentioned this to the Honda dealership and he informed me that it does apply to my vehicle because there is not a recall on my vehicle. The gentleman in the service department is now denying that he said that the rods are worn, but now he’s stating the rods are bent. I have the text message from yesterday where he was explaining what’s wrong with my vehicle and that the rods are abnormally worn. The Honda dealership in Enterprise, AL is the dealership that I’m working with. They informed me today that...

Engine failure due to connecting rod bearings wearing prematurely.

I owned the referenced 2017 Honda Pilot vehicle. I was having transmission issues, which there were recalls for. I went to an authorized dealer to have the recall addressed. 6-8 months later same issue or I thought. Honda Dealer told me that the car was no longer in warranty, now I had to pay. What tripe! 6 months later engine blows up. Took car to a non-Honda repair shop. They tell me that there was an issue with the crankshaft and that the rod bearing went through the engine block. NICE. I pay for a used Honda engine over $8,000, NICE! I pick up the car now they tell me the transmission is shot. I take the car back to another Honda dealer complaining about a blown engine and previous trips to the other Honda dealer about transmission issues. Now after a new engine, which this dealer tells me there...

Honda’s Auto Idle Stop (AIS) system fails to restart the engine from a complete stop at traffic lights, road intersection or when stopped in traffic when the Auto Start/Stop function is engaged. This has required the driver to shift the transmission to park to allow the engine to restart, once this did not work requiring a jump start in the middle of a busy intersection. Honda service has stated that a battery replacement was need, which was done, but a new battery has had no effect on the auto start/stop issue. The engine continues to struggle to restart when the AIS system is engaged. The vehicle headlights can be seen flickering when the engine struggles to restart. This is an extremely dangerous defect that puts the occupants of the vehicle in repeatedly dangerous situations. For example when AIS is engaged and making a turn into oncoming traffic, the vehicle will...

On [XXX] I was driving my 2017 Honda Pilot [XXX], 11 miles south of Mammoth Lakes, CA. about [XXX]. Suddenly, simultaneously, my Pilot’s engine light began to blink, the entire instrument panel lit up, and my steering wheel began to lock up as the vehicle was losing power. I was able to get the vehicle onto the shoulder without hitting the guardrail that was inches from where I stopped. Smoke began to pour out from under the hood, and liquid began to empty out from underneath. We needed to get towed to our vacation destination spot, which was 12 miles from where we broke down. Since this happened on the weekend, needed to get towed again on Monday April 14 to the Honda dealer in Bishop, 44 miles from where we were staying. The service manager took photos. There is a GIANT hole in the engine, none of which was...

Honda error code P0369 upon engine start, vehicle goes into safe mode to prevent engine damage

I noticed an oil leak in December before a holiday break. After noticing this leak I took the car to the mechanic. Upon inspection, the mechanic discovered the leak originated from the head gasket on the rear head. Initial thoughts were to replace the head gasket. Upon further inspection - completely removing the entire engine - they discovered significant damage they had not seen before. They note the bolts in the head simply spin uncontrolled, they cannot be removed, and the entire engine is rendered useless. This issue was a complete shock to us. This failure occurred well before reaching the expected life of the vehicle, yet outside the warranty window and having NO symptoms before the sudden failure. After doing some research on Pilot owner online forums, as well as, the NHTSA website, it seems similar complaints have been well reported and a recall has been issued for some...

The contact stated that the 2017 Honda Pilot. The contact stated that while the vehicle parked, the contact attempted to start the vehicle, there was a rattling sound coming from the engine compartment. The check engine warning light was illuminated. The contact stated that a certified mechanic nearby inspected the vehicle and advised the contact to no longer drive the vehicle. The vehicle was towed to the dealer who diagnosed that the rod bearing had fractured causing the engine to fail and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 113,178.

I was told by my local Honda Dealer (Autofair Honda Manchester NH) that my very well maintained 2017 Honda Pilot, which I bought new, needed a new engine. After doing some research, I discovered that Honda has already recalled 249000 vehicles in the US with a 3.5 liter V6 engine that had manufacturing defects in the crankshaft that could cause connecting rod bearings to prematurely wear and seize leading to engine failure. NHTSA also said it was probing the severity of the issue to determine if the vehicles not included in the 2023 recall should be covered. My 2017 Pilot falls into the "investigation period" and has characteristics consistant with those addressed in the 2023 recall. Therefore, I wanted to add my information to your database. Thank you

The contact owns a 2017 Honda Pilot. The contact stated while driving at an undisclosed speed, the vehicle stalled, and the engine was misfiring with several unknown warning lights illuminated. The vehicle was able to be restarted. The vehicle was taken to an independent mechanic where it was diagnosed that the camshaft had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 117,000.

The stop/start feature will randomly not restart after a stop at a stop sign in traffic. The defect is totally random so it cannot be replicated by the dealer. I have struggled with this problem for years and have not had a crisis because I usually shut off the stop start feature to avoid this system failure. There are no warning lights or symptoms that indicate a failure is eminent. On February 9, 2025 as my wife and I were driving home from the airport at 2:30 AM on a below zero temperature day in the middle of desolate countryside, my Pilot would not restart after I stopped at a stop sign. I had forgotten to turn off the stop start feature. There was no other traffic on the road to help and no houses or other warm places to find refuge so I hoped that I could figure out...

Hi NHSTA! My mechanic has diagnosed the 2017 Honda Pilot engine problem as a rod knock. Currently, the vehicle is undrivable. The mechanic was surprised that the engine was NOT covered under the 2016-2020 Honda Pilot recall. Relevant links: [XXX] [XXX] I also contacted Honda to report the issue, but they offered no further help. Besides contacting a consumer protection attorney, what other options do I have? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Honda Pilot. The contact stated that while driving on several occasions at various speeds, the vehicle stalled. The contact stated that the vehicle restarted 12 minutes later and after five attempts during the first occasion. The contact stated the vehicle restarted each time, but the time increased to an hour on the final attempt to restart. The vehicle was towed to a dealer where it was diagnosed that the engine rod bearing had failed, and the engine needed to be replaced. The vehicle was not diagnosed. The vehicle was taken to a dealer where the same diagnoses was provided. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 75,000.

The engine shut off when I when I went from a stopped position and attempted to accelerate. All power was lost to the vehicle, the engine died, the dashboard lost power and the radio turned off. The auto-stop feature also causes the engine to briefly cut out and the check engine light to illuminate on the dashboard. I replaced the year old battery, but the car still does this with a brand new battery.

The contact owns a 2017 Honda Pilot. The contact stated while driving at approximately 65 MPH, the check engine warning light illuminated, and the vehicle started to lose motive power. The contact was able to pull over to the shoulder of the highway and stop the vehicle. The contact turned off and restarted the vehicle several times and was able to regain vehicle functionality however, the vehicle was unable to accelerate above 40 MPH. The vehicle was taken to a local dealer to be diagnosed. The dealer retrieved DTC: P2638 (Throttle body). The dealer determined that the engine was damaged and needed to be replaced. The vehicle was not repaired. The vehicle was taken back to the residence. The contact stated that while starting the vehicle, there was an abnormal knocking sound coming from the engine compartment. The contact stated that the sound was a metal-on-metal knocking sound. The manufacturer...

All of the warning lights come on the dashboard, the D for Drive flashes. While driving the vehicle downshifts and stalls and loses power and 75% of the time when you come to a complete stop the car completely stalls, loses power and you have to manually turn the engine off and restart the vehicle.

Bent rod in the engine. It has been recalled for other VINS but not ours. Clearly the same issue that the recall is for

My 2017 Honda Pilot in 4/2023 I was driving the belt way my hood was bouncing as if it was going to fly off an kill us all and who was behind us in rush hour traffic. I called made appointment with dealer. My son went on line there was a recall for 2017 Pilot for hood problem, but not my Vin # I was very very upset. I was told it was fixed when I was there last. I told the dealer if they didn't fix it put it in writing. So my family will know what happen to us if that hood came off. Now my Pilot has been jerking sputtering when I take off it's been going on about a year. I keep putting it off until. I was almost hit in the back trying to get on the beltway, everyone screaming. So I check the recall...

Rod bearings failed causing metal fragments to enter causing engine failure. Inspected by local Honda dealership. They recommended that we place a claim with Honda Corporate. Claim was denied. We ended up paying to replace the engine out of pocket.

The vehicle has stalled and had poor acceleration since we purchased it in 2018. The fuel injectors were replaced within the first two years, but continued to have the same problem with stalling and poor acceleration. Additionally, the catalytic converter starting giving error codes. Honda finally attributed the problems to faulty fuel injectors and fuel pump. The fuel injectors have been replaced for the second time and after waiting over a year for a fuel pump, parts have finally become available, and it is scheduled to be replaced next week. In the meantime, the catalytic converter has had to be replaced. I have heard that others have had similar issues with catalytic converters going bad earlier than they should and have had mechanics say that these fuel injector/fuel pump problems could be causing the issue, or possibly that the catalytic converters are faulty.

My car started sputtering and lost power on the interstate and the dash lit up with warnings while driving. I brought the vehicle home and the code is for a bad camshaft position sensor after only 78,000 miles. That is absurd. The neglect for safety here is astonishing by Honda.

Emissions system error repeatedly produced leading to ultimate engine failure. The initial error was fixed by a mechanic. Within 6 months the light was back on accompanied by a loud knocking in the engine. The check engine light indicated a misfire on cylinder one, the ignition coil was replaced, and the problem persisted. The vehicle was taken to the mechanic where they determined the lower part of the engine was failing and that it would need complete replacement. Vehicle is still in my possession as I'm not sure what to do with it. The vehicle has 135k miles on it.

The cars RPM continuously os ul and down while driving causing the car the continously jerk while driving. Which has been to the shop two times for the same issue. The car hesitates a lot when pressing the gas as if it's lost power.

The contact owns a 2017 Honda Pilot. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that when the accelerator pedal was depressed, the vehicle lost motive power. The contact stated that the failure occurred while on a four-lane highway. The contact stated that later, several unknown warning lights were illuminated. In addition, the contact's minor child was an occupant of the vehicle when the failure occurred. The contact and a nearby driver pushed the vehicle to the shoulder of the roadway. The vehicle was towed to the residence. The contact was informed by the tow truck driver that the failure was engine failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the vehicle was scheduled for diagnostic testing. The manufacturer was made aware...

Late 2023 our Honda Pilot Touring had all lights and dash display systems come on while driving in town. The vehicle became extremely jerky and wouldn’t drive more than 15mph. Major engine vibration and systems failures. Had this happened while on the freeway it could have been a catastrophic accident. There were no symptoms prior to this issue happending. We towed the vehicle to Honda and they told us the cam shaft had worn out and needed to be replaced. The vehicle had just over 100k miles. Cam shaft and the cover were replaced as Honda admitted to poor tolerances in the manufacturing and this being a know issue. They never recalled only made the issue a service notice to dealerships. Well, about a year later and our Honda Pilot experiences the same issue. We have it towed to Honda and they say the engine is a complete loss. Needs...

I purchased my 2017 Pilot new from Honda. Around 10,000 miles a code appeared and said Emissions problem and a picture of my engine. I immediately called Honda and took in to service dept. They said my fuel injectors need to be replaced and gave me an extended 150,000 warranty on injectors. Everything ok for awhile…until I hit around 60,000 to 80,000. The emissions engine light came on suddenly then after a few drives/ turning off then on engine it went away. I talked to Honda about this concern they said if light not staying on could be nothing more than a misfire or need to do a tune up. I did the required tuneup …. Emissions engine light still appearing off and on. Now the emissions engine light hardly goes off and has been doing this since around 117,000 miles and I just recently having issues with key faub...

Engine fails to restart after the engine idle stop shuts off the engine when stopped. It is difficult to restart the engine from this state and creates a safety hazard with the car being disabled for a period of time. It does not happen every time. The battery in this vehicle was replaced 18 months ago and the vehicle has no trouble starting normally.

with approx 65,000 miles the engine died. While driving on the freeway the engine all of a sudden was making a sound sound then the vehicle stalled. It was towed off the freeway. Honda determined that the engine was destroyed because somehow oil was prevented from getting to the engine. There was oil in the vehicle. The oil level was good but the engine had no oil. Although the 2016, 2018 and 2019 Honda Pilot engines were recalled but not 2017. They told us that they could not really determine why there wasn't any oil in the engine. We had to replace the engine. The original quote was $18,000. After reviewing our service records and speaking to upper management the offered to replace it for $4,062. (we assume they made the offer because the problem was similar to the recalled engine problems). We accepted the offer even we believe that...

Rod Bearings failed on the vehicle. No indication that were going bad. we were driving on the interstate and all of a sudden heard major "clunking" and safety system lights on the dash flashing. The vehicle was towed to a private auto shop and inspected to find it was the rod bearings. there are recalls on the same motor for model years 2016, 2018, and 2019. The vehicle is available for inspection.

My car for a long time has had the errors/emissions engine light on and when Honda has performed the diagnostic testing they say it could be the oxygen sensor or catalytic converter or fuel injectors or many other things...I've replaced the oxygen sensor recently and the light still on and doesn't go off. I think my car issue needs to be investigated and a recall performed. I see other recalls for my year and make of vehicle but when I enter my VIN its not saying no recall at this time. I feel like Honda doesn't know what is wrong with my car and of course at this point my car's is not under warranty and the fuel injectors they had replaced when I had around 10,000 or 20,000 miles on my car that also is now not covered on any warranty. Please help , all I want is my...

2017 honda pilot brought the car to the dealer ship because I heard the engine nocking but there was no code for the engine at the moment. They told me it was the torque converter. And they told me that nocking noise was my timing belt. Fixed the torque converter and on my way home from the dealership car brakes down on the side of the highway… engine replacement at 154,000 miles, was well taken care of. Dealership told me cylinder 2 rod bearing failed. Replaced the engine with a 60,000 mile engine. And this just sucks because I had to pay outa pocket for this engine replacement. It was very expensive to replace this engine. It wasn’t easy at at the dealership trying to pick your first car to make payments on. And everyone telling you to get a honda because it’s reliable. And your engine blows less then...

Car shut down while driving on highway. After 10 Seconds, restarted but engine was sputtering along.

The contact owns a 2017 Honda Pilot. The contact stated while driving 40-45 MPH, several unknown warning lights and sensor lights were illuminated. The vehicle lost motive power and stalled. Additionally, the contact stated that the vehicle made an abnormal chirping and knocking sound while starting. The contact stated that the failure was related to NHTSA Action Number: RQ24013 (Engine). The vehicle was towed to the local dealer, where it was determined that the engine had misfired, and the dealer replaced the spark plugs. Additionally, the dealer also diagnosed the vehicle with a fractured rod bearing in cylinder #1 and a crankshaft failure. The dealer determined that the engine assembly needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 154,000.

My engine has a rod knock and apparently needs replacement. It is at only about 50,000 miles. The technician estimated the repair at $21,911.47.

What component or system failed or malfunctioned, and is it available for inspection upon request? - Our call has stalled 3 times within a month. I looked online to see what could be the issue. It states there is a recall for a fuel pump issue but I looked online and it is saying our VIN isn't effected? I don't see how that would be the case if we are having the issue many others have noted. How was your safety or the safety of others put at risk? - It has stalled while trying to pull out of a parking lot and shuts off. Has the problem been reproduced or confirmed by a dealer or independent service center? - Not yet. It is random. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - I have an appointment with them in a couple...

Over the course of two week, my engine went from light engining knocking to violent knocking with limited acceleration. My dashboard started flashing multiple errors messages. Fortunately, no one was hurt given my daughter was in the vehicle. I took my vehicle to the Honda Dealership. The dealership informed me my engine has a bad rod knock and will likely fail soon. My miles are 99,009.

engine misfires, rough idling, decreased fuel economy, and a check engine light due to potential clogging or wear within the injectors, sometimes caused by debris from the high-pressure fuel pump

On May 1, 2022, While driving on the thruway, numerous alert lights lit up on the dashboard. The engine began to knock and thump and lost power. I coasted through traffic to the side of the thruway and shut the engine off (dangerous). Upon restarting the knocking noise restarted and I shut it down and had it towed to the Honda dealership. Diagnosis: Blown engine. I had the tech disassemble the engine to determine cause, which was identified as the "number 1 connecting rod wore journal on side of crank". Pieces of the engine internals were found in the oil drip pan. Since then, I have read of: Honda is recalling certain 2016-2022 Acura MDX, 2015-2020 Acura TLX, 2018-19 Honda Odyssey, 2016 and 2018-19 Honda Pilot, and 2017 and 2019 Honda Ridgeline models. These vehicles all use the same 3.5L engine. My Pilots model was excluded from this recall. In...

The car engine was revving up intermittently, with rough shifting of gears, poor acceleration and 3 of the dashboard malfunction indicator lights activating - emission system, transmission system, and blind spot information system. Car still at dealer.

At around 134,000 miles our Pilot started making a knocking noise on startup and during acceleration. The check engine light never came on, nor did any other dashboard warnings, and we had not experienced any troubling symptoms prior to this. Our Honda dealership diagnosed the problem as connecting rod failure requiring full engine replacement. Due to the significant cost of a new engine (>$10k) we opted to have a used engine put in ($8k). I contacted Honda corporate to make them aware of our situation since there is a recall for this exact issue on 2016 and 2018 Pilots but not 2017.

I was told it developed a rod knock at 87500 miles and needed a total engine replacement. This occurred 1 month past my extended warranty period, and I was responsible for the total engine replacement. This was completed 11/04/24 at my mechanic with a cost of over $7000.

While driving with my family in our 2017 Honda pilot On the way to our niece 15th party going about 65MPH all check engine lights turned on and heard a knock on the engine and engine lost power car shut down in the middle of the road almost causing an accident. Attempted to turn car back on but it begin to rattle make all sorts of noises and all the engine lights turned on, at that point I shut the car off and got it towed after waiting on the side of the road for an hour. Had to rent a car and made it extremely late to this event we’ve planned all year. Vehicle has been up-to-date with maintenance all its life. My brother, who is a certified mechanic, determine engine failure due to rod bearings. Vehicle has 112,265 miles. After looking online a lot of people have reported...

Honda Pilot 2017 with 67.000 miles started having a tapping noise that grew increasingly worse within days until check engine light came on flashing and vehicle was no longer drivable. Fortunately main issue happened at Walmart parking lot in safe situation. Honda Service Center then recommended tow to their location. The diagnostics report claims the engine failure is due to multiple cylinders failing and tapping noise could be a rod bearing issue that led the engine failure. The engine is a 3.5l V6 installed in Honda between 2016-2020 vehicles currently under investigation by NHTSA [XXX] ). The total cost of repair is north of 10k. Estimate attached. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving my 2018 Honda Pilot. Which has less than 80k miles on it. While driving the engine temporarily stopped, then the car felt very sluggish, and every safety light came on. The car is not drivable. I currently have it at a Honda Dealership. They are saying the camshaft and timing belt are part of the problem. They are taking the engine out tomorrow to check. My car is not on the recall list, but I think it should be. It could also be impacted by the latest issues that have been reported. I contacted Honda today, and they said the dealership has to report it. My VIN is [XXX] . The engine stalls repeatedly while driving, luckily there was no accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle started making loud banging noises. Took to local independent mechanic. He said the engine rod bearing is bad and vehicle is unsafe to drive and could cause an accident if completely fails while driving. The car is available at my house. Called Honda of Bartlesville when engine light initially came on with code for engine problem and when I showed up, the one I talked to on phone acted like I never called about it then hid in the back room and wouldn't come out. The car was 150 miles from end of warranty. To drive it there it was over warranty, and this was discussed on phone call. The car was inspected by local mechanic. The first sign was around 50K miles and periodically come on. The dealership wouldn't do anything about it and ignored it when I discussed it. Car now has about 100 miles and is...

Engine Failed