2002 FORD FOCUS Suspension Problems

I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to...

VEHICLE HAS ABOUT 108,000 MILES. I DID REPLACE THE TIE RODS CONTROL ARMS AND SWAY BAR OF THE FRONT SUBFRAME. THE MECHANIC SAID THAT THE SUBFRAME IS VERY RUSTED AND THE ENGINE COULD FALL OF IF THE VEHICLE IS NOT SERVICED IMMEDIATELY. I BOUGHT THE CAR AROUND 90,000 MILES AND HAVE ALREADY REPLACED FUEL PUMP AND OTHER PARTS UNDER THE CAR.

AT SPEED OF 40+MPH AND UNEVEN HIGHWAY OR WHEN ENCOUNTERING A MANHOLE COVER THE REAR OF THE CAR SWAYS AND SHIMMIES LEFT TO RIGHT IN AN EXTREME MANNER. NOTICED MUCH WORSE WITH NEW TIRES THAT GRIP WELL. HAVE HAD IT INSPECTED BY A PROFESSIONAL WHO SAYS ALL VITAL PARTS LOOK OKAY. 4 WHEEL ALIGNMENT DID NOT REMEDY. I SEE REFERENCES TO A DESIGN ISSUE WITH THE UPPER CONTROL MEMBERS THAT MAKE IT IMPOSSIBLE TO REACH A CORRECT CAMBER SETTING. I DON'T TRUST MUCH ON THE INTERNET THOUGH, AND WOULD LIKE NHTSA GUIDANCE OR FURTHER INFORMATION. THANKS FOR ANY HELP YOU CAN PROVIDE, I APPRECIATE IT.

OK SO I'VE HAD MY FORD FOCUS FOR ABOUT 3 MONTHS NOW I FELL IN LOVE WITH THIS LITTLE THING RECENTLY GOT STRUTS CHANGED IN FRONT AND BALL JOINTS BUSHINGS AND TIRES SO I KNEW IT WOULD NEED AN ALIGNMENT SO GOT THAT DONE NOW AT SPEEDS FROM 50-60 MPH THIS CAR STARTS FISHTAILING OUT OF CONTROL I DONT HAVE ALOT OF MONEY I AM NOT WORKIN AT PRESENT SO I CANT AFFORD TO TAKE MY USED CAR TO DEALER MUCH LESS TO ANOTHER AUTO SHOP. I TRAVEL 50 -70 MILES EACH DAY TO WORK AND I'M SCARED ITS GONNA FISHTAIL ME INTO A WRECK. MILEAGE 134000 APPLKE VALLEY CALIF.

TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING 50 TO 60 MPH, THE SUSPENSION SPRING ON THE FRONT DRIVER SIDE SNAPPED IN HALF. THE FAILURE CAUSED A SHARP POINT AND SHREDDED THE FRONT DRIVER SIDE TIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE TIRE AND SPRING WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 120. UPDATED 08/17/16*LJ THE CONSUMER HAS SINCE SOLD THE VEHICLE. UPDATED 08/22/16.*JB

2002 FORD FOCUS ZX5. BRAKES WERE REPLACED AND FIRST TIME IT WAS DROVE THERE WAS A NOISE FROM FRONT PASSENGER WHEEL AREA. FOUND THE COIL SPRING IS MOVING AND MAKING POPPING NOISE. I GOOGLED THE PROBLEM AND FOUND A LOT OF COMPLAINTS ABOUT THESE SPRINGS BREAKING AND DAMAGING TIRES OR CAUSING ACCIDENTS AND THAT THERE HAD BEEN A RECALL? TRYING TO FIND OUT FOR MY MOM. THIS IS HER CAR BUT I AM GIVING MY CONTACT INFO. *TR

LAST INSPECTION IT WAS REPORTED TO INSPECT THIS YEAR THE CROSSMEMBER/SUBFRAME NEEDED TO BE REPLACED OR CAR WOULD NOT PASS INSPECTION RESEARCHING THIS I'VE FOUND SEVERAL PEOPLE COMPLAINED ABOUT THIS ALSO I SAW RECALL OF MORE SUSPENSION ISSUES OCCURRING NOW.. 40 K MILEAGE IT HAS LAST YEAR HAD TO REPLACE SWAY BAR BECAUSE IT LET LOOSE WHEN I DROVE HOME PUNCTURING MY TIRE ALMOST WENT INTO THE RIVER THIS NIGHT . *TR

IN 2004 FORD ISSUED A WARRANTY EXTENSION ON THE FRONT COIL SPRINGS. THIS WAS CALLED: CUSTOMER SATISFACTION PROGRAM 03M02. THEY KNEW THE PART HAS BEEN INCORRECTLY MANUFACTURED AND THE COIL SPRING WOULD BREAK DUE TO CORROSION. THE WARRANTY WAS EXTENDED TO 150,000 MILES OR 10 YEARS. MY COIL SPRING BROKE ON JULY 26 2013 WHEN MY CAR ONLY HAD 56,193 MILES BUT IT WAS 11 YEARS OLD. THE FORD DEALER TOLD ME THAT THE COMPANY WOULD NOT PAY FOR THIS REPAIR. MY COMPLAINT IS THAT I THINK THE FORD MOTOR COMPANY SHOULD PAY FOR THIS REPAIR AND FOR THE OTHER FRONT COIL SPRING SINCE THE PROBLEM SHOULD HAVE BEEN A RECALL SINCE THE COMPANY KNEW THE PART HAD NOT BEEN MANUFACTURED CORRECTLY. *TR

THIS IS OUR FIRST YEAR DRIVING THIS FOCUS IN THE SNOW, WE BOUGHT IT IN 2011. WE HAD A SNOW FALL ON 11/1/2012 AND WE TOOK THE CAR OUT FOR A DRIVE. ANY SPEED ABOVE 35 MPH AND THE REAR OF THE CAR FLOATS (WIGGLES) BACK AND FORTH UP TO A FOOT. IT IS COMPLETELY UNSTABLE ON SNOW OR ICE. I DID SOME RESEARCH ONLINE, AND FORD APPARENTLY KNOWS THE PROBLEM,: DEFECTIVE REAR UPPER CONTROL ARMS, SINCE THEY DID A SILENT RECALL ON THESE IN 2006. NHTSA SHOULD INVESTIGATE THIS SINCE THERE ARE MANY MORE FOCUS OUT THERE LIKE OURS, AND FORD SHOULD HAVE TO RECALL AND REPLACE THE CONTROL ARMS ON ALL OF THESE UNITS FROM 2000-2004. I HAVE OVER 35 YEARS OF WINTER DRIVING EXPERIENCE AND I HAVE NEVER HAD A VEHICLE (EVEN THE OLD REAR WHEEL DRIVE MODELS) BEHAVE SO DANGEROUSLY ON SNOW AND ICE, EVEN WITH...

THE FRONT SUB FRAME ON MY 2002 FORD FOCUS ZTS WAS COMPLETELY RUSTED THROUGH AND UNABLE TO SUPPORT THE FRONT SUSPENSION. I ALSO HAD MY CAR INSPECTED BY A FORD DEALER WHO PASSED IT AND TOLD ME NOTHING ABOUT HOW DESTROYED MY SUB FRAME WAS. WHEN I TOOK IT TO A MECHANIC THEY TOLD ME IT WAS SO BAD I SHOULDN'T BE DRIVING THE VEHICLE. THE BOLTS WHERE EVEN RUSTED OUT OF THE SUB FRAME. ITS BELIEVED THAT THIS ALSO CAUSED MY MOTOR MOUNTS TO HAVE TO BE REPLACED. CAUSE SUCH BAD VIBRATION THAT IT RUINED ALL MY SHOCKS, STRUTS, AND ALL 4 OF MY TIRES. THE TIRES WHERE ONLY 5 MONTHS OLD AND ARE DESTROYED. *TR

THE FRONT SUBFRAME STRUCTURE ON MY 2002 FORD FOCUS IS RUSTED SO BADLY THAT IT NO LONGER SUPPORTS THE FRONT SUSPENSION IT WAS DESIGNED TO SUPPORT NO OTHER IT ON THIS VEHICLE IS AS RUSTED AS THE VERY IMPORTANT PART. *TR

TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT DROVE OVER A SPEED BUMP AND HEARD A POPPING SOUND COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND NOTICED THAT THE FRONT DRIVER AND PASSENGER SIDE COIL SPRINGS WERE FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE COIL AND STRUT ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 113,800.

TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A POPPING NOISE ON THE FRONT PASSENGER SIDE OF THE VEHICLE. AFTER COMING TO A STOP THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER SIDE COIL SPRING WAS FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. IN ADDITION, THE CONTACT MENTIONED A MANUFACTURER'S RECALL FOR THE FAILURE. THE MANUFACTURER STATED THAT THE RECALL HAD ALREADY EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,900.

WHILE USING A HIGHWAY ON RAMP, I HEARD A POPPING SOUND. I'VE BEEN GETTING A RATTLE FOR A FEW WEEKS. I LOOKED UNDERNEATH TODAY. THE PASS SIDE REAR COIL SPRING IS BROKEN AT THE TOP. THE DR. SIDE REAR COIL SPRING IS BROKEN OFF AT THE BOTTOM. I DRIVE MOSTLY HIGHWAY, 10 MILES A DAY BACK AND FORTH TO WORK, SO I DON'T UNDERSTAND HOW BOTH REAR COIL SPRINGS WOULD BREAK. MY FRONTS WERE REPLACED A FEW YEARS AGO BY FORD DEALER WHEN THEY BROKE. THIS SEEMS LIKE A PROBLEM IF ALL 4 COIL SPRINGS BREAK OFF THE SAME VEHICLE. *TR

MY 2002 FORD FOCUS WAGON NEEDED BRAKES BECAUSE THE FRONT END WOULD SHAKE WHEN I APPLIED BRAKES. ALSO NOTICED A WHIRLING NOISE FROM THE BACK OFF CAR BUT DID NOT MENTION THAT TO MY MECHANIC. HE TOOK IT FOR A TEST DRIVE AND ASKED IF I NOTICED THE WHIRLING NOISE TOO. HE SAID HE WAS CONCERNED AND CHECKED THAT 1ST. MY RIGHT REAR TIRE WAS FROZEN AND NOT TURNING, THAT'S WHERE THE NOISE WAS COMING FROM. IT HAD TO BE CUT OFF IN ORDER TO BE REPLACED. HE TOLD ME THAT THE WHEEL COULD HAVE BROKE OFF WHILE DRIVING AND COULD HAVE KILLED ME, I HAD THAT REPAIRED, ALONG WITH FRONT END BRAKES AND REPLACED WARPED ROTORS. THEN JUST 2 DAYS LATER BACKED OUT OF MY DRIVEWAY AND BROKE A FRONT RIGHT COIL SPRING. A YEAR LATER REPLACED THE ALTERNATOR. AND LAST WEEK JUST HAD TO PAY FOR A REBUILT...

TL*THE CONTACT OWNS A 2002 FORD FOCUS LS. WHILE DRIVING 35 MPH, THE CONTACT STATED THAT THE VEHICLE WOULD NOT STEER AND THE STEERING WHEEL LOCKED. AFTER STOPPING THE VEHICLE AND INSPECTING THE PROBLEM, HE NOTICED THE LEFT STRUT SPRING COLLAPSED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED. THE FAILURE MILEAGE WAS 38,000.

MY FORD FOCUS LEFT TIRE FELL OFF BECAUSE OF THE WHEEL BEARING BREAKING. WITH NO WARNING OR NOISE MY TIRE DETACHED DURING DRIVING. MY TIRE WAS FOUND 40 YARDS AWAY WITH THE LUGS NUTS STILL ATTACHED TO THE OUTSIDE OF THE DRUM BRAKE. POLICE REPORT WAS FILED. *TR

MY 2002 FORD FOCUS HAS ONLY 41,000 MILES ON IT AND THE FRONT RIGHT COIL SPRING BROKE ON ME LAST WEEK. FORTUNATELY I DID NOT CRASH OR LOOSE MY BRAKES BUT IT HAS POTENTIAL FOR A CATASTROPHIC EVENT. I AM HOPING FORD WILL RECALL THESE AS THEY DID WITH THE EARLIER MODELS. *TR

THE 2002 FORD FOCUS SE COMFORT WAGON HAS BEEN A CONTINUAL PROBLEM OF NOT STAYING IN ALIGNMENT (NAMED THE REAR WHEELS WORST THAT THE FRONT) FOR MORE THAN 5000 MILES BEFORE NEEDING ADDITION ADJUSTMENTS. TIRES HAVE LASTED LESS THAN 20,000 MILES (REGARDLESS OF MANUFACTURER) BEFORE TOTALLY WORN OUT AND NEEDING REPLACEMENT. *TR

2002 FORD FOCUS ZTS FIRESTONE TIRES WITH FLAT SPOTS. CUSTOMER STATES THAT THE FLAT SPOTS WOULD MAKE A NOISE AT CERTAIN SPEEDS. MECHANIC TOLD THE CONSUMER THAT THEY NO LONGER CARRIED FIRESTONE TIRES AND THEY COULDN'T HELP HIM. *KB THE CONSUMER WAS ABLE TO GET THE TIRE PRO-RATED, HOWEVER THE NEW TIRES STARTED TO EXPERIENCE CUPPING. THE REAR VIEW MIRROR WAS LOOSE, THE SWAY BAR BUSHINGS, FRONT LINK PINS, REAR SUSPENSION BAR, REAR SIDE BRACKET AND FRONT STRUTS WERE ALL REPLACED. *JB

IN LATE OCTOBER 2006 I TOOK MY 2002 FORD FOCUS FOR VIBRATION/GRINDING NOISE COMING FROM FRONT END. FORD WALKER IN CLEARWATER, FLORIDA SAID THAT MY ENGINE/TRANS. MOUNT WERE WORKING PROPERLY. FORD KEPT MY CAR FOR 1 WEEK AND I STILL HAD THE SAME PROBLEM. I TOOK THE CAR BACK TO FORD THE VERY NEXT DAY BECAUSE OF THE SAME PROBLEM. AGAIN THEIR SERVICE MANAGER AND REGIONAL MANAGERS TOLD ME THAT NOTHING WAS WRONG WITH MY CAR. FORD CHARGED ME $100 FOR MY DEDUCTIBLE AND DIDN'T FIXED MY PROBLEM. I THEN TOOK MY CAR TO ANOTHER PLACE WHERE THEY REPLACED MY RIGHT SIDE ENGINE MOUNT WHICH WAS COMPLETELY BROKEN. THE VERY SAME PIECE FORD WALKER LIED TO ME STATING IT WAS WORKING PROPERLY. *JB

1. I WAS DRIVING MY 2002 FORD FOCUS WAGON BACK FROM A CAMPING TRIP AND I WAS GOING ABOUT 60 MPH ON THE FREEWAY 2. ALL OF A SUDDEN THERE WAS A "CRACK"/"BANG" FROM THE BACK OF THE CAR, DRIVERS SIDE, THE CAR CONTINUED WITHOUT JOLTING/SWERVING (I.E. NO AFFECT TO THE DRIVING OF THE VEHICLE), HOWEVER, AFTER ANOTHER FEW MILES THE REAR DRIVERS SIDE WHEEL WAS MAKING A HIGH PITCHED SOUND, PLUS CRACKING, PLUS SOME JOLTING AS THE BEARING REALIGNED ITSELF AT TIMES. I STOPPED THE CAR AND THE HEAT FROM THE WHEEL WAS INCREDIBLE, ONE COULD HAVE FRIED AN EGG ON IT (THIS WHEEL WAS MUCH HOTTER THAN THE OTHERS). UNFORTUNATELY THIS HAPPENED ON A STRETCH OF ROAD WHERE THERE ARE NO TOWNS, NO CELL PHONE SIGNAL, ETC, I WAS FORCED TO DRIVE THE CAR TO A TOWN, MAX OF 40 MPH ON A 60 MPH STRETCH OF ROAD,...

I PURCHASED MY 2002 FORD FOCUS IN JANUARY OF 2005. I LOVE MY CAR, HAVE FOUND OUT ABOUT OF THINGS THAT COULD GO WRONG LATER. RIGHT NOW I AM HAVING TROUBLE WITH MY FRONT WHEELS. I HAVE PUT SIX USED TIRES ON THE FRONT SINCE I PURCHASED THE FOCUS. IN NOVEMBER I HAD TWO BRAND NEW TIRES PUT ON PLUS IN MAY I HAVE HAD A WHEEL ALIGNMENT DONE. THE CAR STILL SHAKES VERY BAD. FOUND OUT I NEED MY WHEEL HUB BEARING REPLACE, PLUS I FOUND OUT THERE MAY BE A RECALL ON THE REAR BEARING WHICH I HAVE NOT RECEIVED ANYTHING. I SHOULD NOT HAVE TO PAY FOR THESE THINGS TO BE DONE. *JB

PROBLEMS WITH 2002 FORD FOCUS STEERING AND SUSPENSION.*MR *CB

MY 2002 FORD FOCUS STARTED HAVING PROBLEMS AFTER 5000 MILES. IT STARTED WITH A NOISE COMING FROM THE FRONT LEFT WHEEL AREA. FROM THERE THE STEERING SEEMED SHAKEY AT TIMES AT HIGHWAY SPEEDS. ONCE, THE CAR PULLED TO THE LEFT SUDDENLY ON THE HIGHWAY. THE DEALERSHIP HAS CHANGED THE TRANSMISSION, FRONT BEARING, AND KNUCKLE, ON THE CAR IN THE PAST TWO MONTHS. THE CAR IS STILL NOT FIXED. THE MOST NOTICEABLE PROBLEM IS THE HOWLING GRINDING NOISE COMING FROM THE FRONT LEFT WHEEL. IT CAN BE HEARD MOSTLY AROUND 50 TO 60 MPH. IT IS STILL UNKNOWN WHAT IS WRONG WITH THE CAR.

FUEL PUMP WAS REPLACED TWICE FROM JANUARY TO JUNE STERRING WHEEL AND CAR SHAKE WHILE STOPPING AND DRIVING AT 50 MPH OR ABOVE BRAKES HAVE BEEN CHECKED 3 TIMES FINALLY HAD REPLACED AND ROTORS, NO CHANGE IN PERFORMANCE

THIS PROBLEM JUST HAPPENED YESTERDAY. MY DAUGHTER WAS MAKING A TURN, AND THE CVC JOINT COMPLETELY FELL APART. SHE LOST ALL STEERING CAUSING HER TO HIT A CURB. WE HAD THE CAR TOWED TO THE DEALER WHERE WE BOUGHT IT ONLY A MONTH AGO. THEY ARE REFUSING TO FIX THE CAR SAYING THAT SHE WAS IN AN ACCIDENT CAUSING THE JOINT TO FALL APART. THIS IS NOT THE CASE. WE ARE NOT SURE WHAT TO DO, AND NEED HELP. THIS IS A TERRIBLE DEFECT, AND IF SHE HADN'T HAVE BEEN GOING SLOW, SHE COULD HAVE BEEN KILLED. IS THERE ANYONE WHO CAN HELP US, AS WERE NOT SURE WHAT STEPS TO TAKE TO GET THE PUBLIC ATTENTION ABOUT A POSSIBLE KILLER.

ON NOVEMBER 23 2002 I WAS IN A ACCIDENT WHERE I BROKE MY NOSE AND HAD NUMEROUS BURISES. THE REASON I GOT INTO AN ACCIDENT WAS BECAUSE MY WHEEL AND SUSPENSION BROKE & SEEM TO COME APART. I HAD COMPLAINED TO FORD THAT MY WHEEL HAD BEEN SHAKING AND THAT THERE WAS SOMETHING WRONG WITH IT. I HAD TAKEN IT BACK 4 TIMES TO GET FIXED BUT EVERYTIME I GOT IT BACK AND IT WOULD SHAKE JUST AS BAD. ALSO WHEN I GOT INTO THE ACCIDENT MY AIRBAGS DIDNT DEPLOY AT ALL I RECEIVED A BROKEN NOSE FROM HITTING MY HEAD ON THE STEERING WHEEL. THE CAR WAS SHAKING REALLY BAD AND IT SEEM TO PULL ME OFF THE ROAD THEN ALL OF A SUDDEN IT WAS LIKE A SNAP AND IT WENT THE OTHER DIRECTION. I FLEW SIDEWAYS UP IN THE AIR AND HIT TWO OAK TREES LUCKLY I...

PROBLEM I'M STILL HAVING AND WAS REPORTED TO DEALERSHIP IS CAR PULLS TO LEFT, ( NOT CORRECTED) BACK END OF CAR OR TIRES BOUNCE ON ROAD AND ESPECIALLY WHEN HITTING A BUMP, CANNOT STAY ON ROAD IN SLUSH OR SNOW, BACK END IS ALL OVER ROAD, ( NOTHING DONE) TIRES ARE COMPLETELY GROVED IN MANY SPOTS ON THE TIRES, CAUSED BY REAR END BOUNCING ON ROAD, FIRESTONE WON'T REPLACE THEY SAY IT IS FOCAS'S REAR END AND IT WEARS OUT THE TIRES, DEALER OR FORD WON'T DO ANYTHING ABOUT REAR END OR TIRES, CAR VIBRATES BADLY, REAR DOORS BARLEY OPEN ARE SO STIFF, LOOKS LIKE DOOR LOCKS ARE COROADED NOTHING WAS DONE BY DEALERSHIP EVEN THOUGH THEY SAID THEY LUBRICATED, NOTHING IS ON THE LOCKS TO SHOW LUBRICATION OF LOCKS.

THE FRONT DRIVER'S WHEEL BEARING AND HUB WENT OUT AT ABOUT 7,000. THE CAR MADE A VERY LOUD NOISE. FORD REPAIRED THIS PROBLEM. CAR HAD TO HAVE BRAKE PADS AT 28,000 MILES. THE WEAR ON THE DRIVER'S SIDE FRONT WAS MUCH WORST THAN THE OTHERS. REPAIR PERSON SAID THAT THE CALIPERS WERE DEFECTIVE. COST 100. DOLLARS. THE FRONT PASSENGER'S SIDE WHEEL BEARING AND HUB WENT OUT AT 29,000. I PAID FOR REPAIR OF WHEEL $150. I WAS TOLD THAT THE DRIVER'S SIDE WAS GOING OUT AGAIN. THERE IS OBVIOUSLY A PROBLEM WITH THE FRONT SUSPENSION OF THIS CAR. I AM NOW FACED WITH REPAIRS OF THE OTHER SIDE FOR A SECOND TIME AND THE CAR IS ONLY 18 MONTHS OLD. I AM WORRIED THAT THE WHEELS WILL COME OFF.

THE MILEAGE ON MY FOCUS WAS 47000 KM AND THE COST WAS $5500.00. THE DATE WAS JULY BUT I AM AT WORK AND NOT SURE OF EXACTLY WHAT DAY. MY FOCUS WAS MAKING A CLUNKING SOUND SIMILAR IN NATURE TO TRACTION CONTROL KICKING IN. IT WAS IN TO BE SERVICED ON A FRIDAY AND THEY SAID THEY COULD NOT REPEAT THE SOUND. ALSO AT THAT TIME IT WAS HAVING REGULAR MAINTENANCE TIRE ROTATION AND OIL CHANGE. ON THE FOLLOWING TUESDAY DRIVING IN THE TOWN I LIVE IN (LUCKILY THE SPEED LIMIT IS ONLY 30 KM/HR) I EXPERIENCED THE STEERING WHEEL PULL TO THE RIGHT AND I HAD HIT A PARKED CAR. HAD I BEEN ON THE HIGHWAY ME AND MY 2 CHILDREN WOULD HAVE BEEN A FATALITY. THE COST QOUTED TO YOU OF 5500.00 IS NOT INCLUDING THE COST TO FIX THE OTHER VEHICLE. AS WELL FORD MOTOR CO. IS...

ABNORMAL TIRE WEAR

TIRES WEAR OUT EVERY 10,000 MILES HAVE REPLACED TIRES 5 TIMES NOW WAS TOLD IT WAS BECAUSE WE DIDN'T ROTATE. 3 LINE UPS DONE AND ROTATED EVERY 5000 MILES WE ARE NOW ON SET NUMBER 6 OF TIRES AND THE DEALER CAN NOT EXPLAIN WHY WE CANT GET EVEN 1/2 THE LIFE OF THE TIRE. *JB

I HAVE HAD MY A/C WORKED ON AT LEAST 3 TIMES. ALSO HAVE HEAVY VIBRATIONS WHEN I JUST HAD IT ALIGNED 5/04/03. AND STILL HAVING HEAVY VIBRATIONS.AK

WHILE DRIVING 50-60 MPH THE VEHICLE VIBRATES VIOLENTLY. *NLM

THE VEHICLE SWAYED FROM LEFT TO RIGHT AND THERE WAS A POPPING NOISE COMING FROM THE REAR ALSO. *JB

WHEN DRIVING THE VEHICLE THERE'S A LOUD NOISE COMING FROM THE REAR OF VEHICLE. TOOK TO FORD AND THEY STATES THAT THE REAR WHEEL BEARINGS ARE WOBBLING. PLEASE PROVIDE ANY FURTHER INFORMATION. *NLM

THE VEHICLE IS EXPERIENCING SEVERE WHEEL/TIRE THUMP, WHICH CAUSES A VIBRATION IN THE STEERING AND A LOUD AUDIBLE NOISE IN THE CABIN, THE MANUFACTURER IS AWARE OG THE PROBLE BUT A SOLUTION WAS NOT AVAILABLE FOR SOME MONTHS, THE FACT THAT THE CONSUMERS VEHICLE HAD HIGH MILEAGE THE MANUFACTURER WOULD NOT REPAIR THE VEHICLE FREE OF CHARGE ALTHOUGH THE VEHICLE WAS ONLY 12 WEEKS OLD. *SCC

WHILE DRIVING THE SUSPENSION BROKE. NLM

INSIDE CORNER OF REAR TIRE, APPROXIMATELY THREE INCH STRIP ON EACH TIRE, WEARS EXCESSIVELY. TIRES HAVE BEEN REPLACED AT 9,000, AND AT 20,000. STILL BELT TREAD IS SHOWING. CONSUMER MAINTAINS PROBLEM IS VEHICLE AND NOT TIRE. CONTACTED MANUFACTURER AND DEALER. PROBLEM HAS NOT BEEN RESOLVED.*AK *SLC

WHILE TRAVELING AT 45 TO 50 MPH VEHICLE JERKS BACK AND FORTH. TOOK TO DEALER ,AND THEY COULDN'T DUPLICATE THE PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

FRONT WHEELS SQUEAL WHEN EVER THE CONSUMER WILL START TO DRIVE FASTER THEN 30 MPH. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING. PLEASE PROVIDE FURTHER INFORMATION. *AK

CONSUMER TOOK VEHICLE TO DEALER DUE TO SUSPENSION'S ERRATIC BEHAVIOR WHICH CAUSED VEHICLE TO BOUNCE AROUND. DEALER FIXED 4 WHEEL ALIGNMENT. PROBLEM REOCCURRED. *AK

THE ORIGINAL FIRESTONE TIRES (205/50R16) WEAR OUT PREMATURELY. THE VEHICLE BECOMES UNSTEADY ON BUMPY, WET OR SNOW COVERED ROADS, CAUSING THE DRIVER TO LOSE CONTROL. THE REAR TIRES VIBRATE AND CHATTER WHEN DRIVING ON WIND ROADS AND ON OPEN ROADS AT HIGHWAY SPEEDS, ALSO THE REAR TIRES WERE SHOWING IRREGULAR AND PREMATURE WEAR. THE MANUFACTURER REPRESENTATIVES STATED THAT IMPROPER FACTORY ALIGNMENT SPECIFICATION WERE THE CAUSE OF THE PROBLEMS. AUTO DOOR LOCKS MALFUNCTIONS. THE REAR HATCH DOOR WAS MISALIGNED AND WOULD NOT CLOSE PROPERLY, THE REAR WINDOW WASHER WOULD NOT SPRAY PROPERLY AND THE REAR WINDOW WASHER NOZZLE FAILED, THERE WAS AN ODOR COMING FROM HEATING OR A/C SYSTEM, THE POWER STEERING LINE WAS LEAKING. THE TRANSMISSION WAS DIFFICULT TO SHIFT INTO 2ND GEAR AND REVERSE WHEN IT WAS COLD, THE CHILD RESTRAINT BRACKETS WAS PUTTING DENTS IN THE REAR SEAT *YH

WHILE DRIVING, IT BECOMES VERY UNSTABLE WHEN MOVING OVER BUMPY ROADS, MANHOLES. IT ALSO BECOMES VERY ERRATIC WHEN ROADS ARE WET. TOOK TO DEALER SEVERAL TIMES. THE PROBLEM HAS NOT BEEN RESOLVED. NLM VEHICLE STARTS AND THEN STALLS IN AM. DEALER COULD NOT DUPLICATE CUSTOMER CONCERN. *TT