2002 FORD FOCUS — Problems, Recalls & Safety Data
N/A
Safety Rating
1,198
Owner Complaints
8
Recalls
50
Service Bulletins
1
Investigation
Overview of the 2002 FORD FOCUS
The 2002 FORD FOCUS has received a total of 1,198 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 8 recall campaigns affecting this vehicle, covering issues with EQUIPMENT, EXTERIOR LIGHTING:HEADLIGHTS, EXTERIOR LIGHTING. 50 technical service bulletins have been issued by Ford Motor Company for this model year. The most commonly reported problems involve the Electrical Systemignition (124 complaints), Electrical System (76 complaints), and Tires (52 complaints).
Recalls for the 2002 FORD FOCUS
NHTSA has recorded 8 recalls for the 2002 FORD FOCUS, potentially affecting up to 808,429 vehicles.
Recall 12E007000 — EQUIPMENT
| 10,006 vehicles affected
Defect: RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A...
Consequence: IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
View full details →Recall 09E025000 — EXTERIOR LIGHTING:HEADLIGHTS
| 42,540 vehicles affected
Defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
View full details →Recall 09E012000 — EXTERIOR LIGHTING
| 16,270 vehicles affected
Defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
View full details →Recall 08E050000 — EXTERIOR LIGHTING:HEADLIGHTS
| 1,921 vehicles affected
Defect: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
View full details →Recall 06E056000 — FUEL SYSTEM, GASOLINE
| 58,640 vehicles affected
Defect: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
View full details →Recall 06E049000 — EXTERIOR LIGHTING
| 27,176 vehicles affected
Defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
View full details →Recall 06E026000 — EXTERIOR LIGHTING
| 61,944 vehicles affected
Defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
View full details →Recall 05V030000 — LATCHES/LOCKS/LINKAGES:DOORS:LATCH
| 589,932 vehicles affected
Defect: CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH...
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS...
View full details →Owner Complaints for the 2002 FORD FOCUS
1,198 complaints have been filed with NHTSA for the 2002 FORD FOCUS. Below is a breakdown by vehicle component.
Most Recent Complaints
Break lights won't work and was almost hit by another car, changed break lights changed light break switch checked fuses and wiring everything is good
Sunroof Exploded. Empty Road, temp low 40s. No warning. I have owned the car since 2004. Though older car, <120,000 miles.
The drivers door will not open. It is stuck shut. Turning the key in the lock does not work. Broke outer handle trying to open door to assist elderly party out of drivers seat. Power lock fuse is fine. Took door panel off partly to expose cable, cannot push or pull cable to force open. Safety issue because owner is elderly. Cannot reasonably crawl in and out through passenger side. Emergency personnel would not be able to reach occupants in case of an accident.
I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers cannot be switched off when it is at the highest position because it will not return in the downward position.
I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers cannot be switched off when it is at the highest position because it will not return in the downward position.
Safety Rating for the 2002 FORD FOCUS
NHTSA has not yet tested the 2002 FORD FOCUS in its New Car Assessment Program.
Technical Service Bulletins for the 2002 FORD FOCUS
Ford Motor Company has issued 50 technical service bulletins (TSBs) for the 2002 FORD FOCUS. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TSB-14-0162 — STRUCTURE:BODY:DOOR
FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO CATCH, WHEN OPERATED IN AREAS CAUSING HIGH CORROSION. MODEL 2000-05 FOCUS. *PE
0581 — POWER TRAIN:MANUAL TRANSMISSION
DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR. *TT
18581 — ELECTRICAL SYSTEM
ERRATIC INSTRUMENT CLUSTER GAUGES AND/OR WARNING INDICATORS - SERVICE TIP. *TT
18463 — POWER TRAIN:AXLE ASSEMBLY
VENT LEAK. *EH
042119 — POWER TRAIN:AXLE ASSEMBLY
TRANSAXLE NOISE AT IDLE IN NEUTRAL WITH CLUTCH PEDAL RELEASED PREMATURE CLUTCH. *EH
17918 — VEHICLE SPEED CONTROL
INOPERATIVE SPEED CONTROL SYSTEM. *TT
17842 — POWER TRAIN
2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR. *TT
17256 — POWER TRAIN:CLUTCH ASSEMBLY
PREMATURE CLUTCH WEAR. *TT
0456 — FUEL SYSTEM, GASOLINE:DELIVERY
FUEL DELIVERY MODULE (FDM) REPLACEMENT PROCEDURE. *TT
17652 — POWER TRAIN
2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR. *TT
Showing 10 of 50 technical service bulletins.
NHTSA Investigations for the 2002 FORD FOCUS
NHTSA has opened 1 investigation into potential safety defects in the 2002 FORD FOCUS.
Investigation EA02023 — SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Closed
Opened:
FRONT SUSP COLLAPSE/WHEEL SEPARATION
Other Model Years of the FORD FOCUS
- 1999 FORD FOCUS — 15 complaints
- 2000 FORD FOCUS — 5,152 complaints
- 2001 FORD FOCUS — 2,361 complaints
- 2002 FORD FOCUS (current)
- 2003 FORD FOCUS — 1,224 complaints
- 2004 FORD FOCUS — 499 complaints
- 2005 FORD FOCUS — 599 complaints
- 2006 FORD FOCUS — 269 complaints
- 2007 FORD FOCUS — 524 complaints
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints
- FORD MUSTANG — 11,551 total complaints