2002 FORD FOCUS Exterior Lighting Problems

I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to...

TAIL LIGHT CONNECTION MELTS DUE TO BULB GETTING TOO HOT. IMPOSSIBLE TO REMOVE CONNECTOR TO REPLACE BULB. HAVE TO REPLACE ENTIRE LENS. MANY, MANY REPORTS ONLINE OF THIS HAPPENING. FORD DENIES AND REFUSES TO REPLACE. EXPENSIVE REMEDIES FOR CUSTOMERS. THIS HAPPENS ON FOCUS WAGONS AND MANY OTHER FORDS.

WHILE WAITING AT A CONSTRUCTION SITE THE ENGINE DIED AND WOULD NOT START (THE ENGINE INDICATOR LIT). THE BRAKE LIGHTS, POWER WINDOWS, AND REAR HATCH RELEASE ALSO FAILED TO FUNCTION. THE VEHICLE WAS TOWED AND THE PERSONAL MECHANIC REPORTED THE ELECTRICAL HARNESS TO THE REAR HATCH HAD FAILED WHERE IS PASSED BETWEEN THE BODY AND THE HATCH DOOR. THE HARNESS ELECTRICAL INSULATION WAS CRACKED ON THE ENTIRE BUNDLE OF WIRES AND SHEDDING FRAGMENTS CAUSING SOME WIRES TO SHORT, THE 15 AMP FUSE FOR THE BRAKE LIGHTS HAD EVIDENCE OF HEATING, BUT DID NOT BLOW, RATHER, WIRES LEADING TO THE BRAKE PEDAL SENSOR, THE 15 AMP FUSE, AND ALONG THE HARNESS BACK TO THE SHORT IN THE REAR WIRING HARNESS NEAR THE CENTER BRAKE LIGHT HAD DISCOLORED AND WERE MELTED IN SOME SEGMENTS. FORD CUSTOMER SERVICE SAID TO CONSULT A FORD SERVICE CENTER TO DETERMINE IF THERE WAS A MANUFACTURING DEFECT....

REAR DOOR WONT LATCH RIGHT AND DRIVER SIDE TAIL LIGHT WONT WORK. *TR

DRIVER SIDE TAIL LIGHT AND BRAKE LIGHT. THE HOUSING IS SHAPED SO THAT YOU CAN'T TAKE THE LIGHTBULB OUT W/O BREAKING IT. I TOLD THEM TO DO WHATEVER TO MAKE IT WORK CAN'T AFFORD $118.00 TO REPLACE A MANUF DEFECT PART. *TR

A YEAR AGO, THE DRIVER'S SIDE TURN SIGNAL LIGHT ON MY 2002 FORD FOCUS WAGON BURNED OUT. IN TRYING TO REPLACE IT AT A LOCAL AUTO PARTS PLACE. THE SOCKET WAS SO TIGHT IN THE LENS/REFLECTOR ASSEMBLY THAT IT COULD NOT BE REMOVED. I TOOK IT TO MY DEALER, KAIN FAMILY FORD IN LONDON. I LEARNED THAT THE PROBLEM WAS THAT THE FITTING FOR THE SOCKET HAD WARPED FROM EXCESSIVE HEAT, APPARENTLY. THE DEALER SEARCHED TO SEE IF THERE WAS A TECHNICAL BULLETIN AND FOUND ONE INSTANCE IN WHICH A PIZZA DRIVER IN A SIMILAR VEHICLE HAD A SIMILAR PROBLEM. THEY WERE ABLE TO PULL THE LIGHT OUT AND WITH A POCKET KNIFE MAKE THE NEW SOCKET FIT IN THE ASSEMBLY, AND CHARGED ME THE HOURLY RATE FOR THE WORK. I SUSPECT THIS IS A MANUFACTURER'S DEFECT, BECAUSE I'VE HEARD OF TWO OTHER INSTANCES IN THE SAME TYPE OF VEHICLE...

THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MORE AND KNOWS OF ALL THE TIMES REPORTED. I HOPE THIS IS JUST NOT A EASY FIX OR THIS NOW HASN'T CAUSED ANY DAMANGE TO THE INSIDE OF THE ENGINE ITSELF, AS THE ENGINE HAS BEEN IN THE SHOP FOR RIDING ROUGH. THEY TOLD ME LAST TIME THAT THE PART OF THE TRANSMISSION THAT WAS FIXED WOULD FIX THIS. I THINK IT IS DUE TO THE OIL LEAK ON THE TOP OF THE ENGINE CASE SINCE IT WAS NEW. A NEW CAR SHOULD NEVER HAVE A OIL...

I HAVE A 2002 FORD FOCUS ZX5 4 DR HATCHBACK MY PROBLEMS STARTED ON 7/21/03 WHEN MY BRAKES LIGHTS, HEADLIGHTS, TURN SIGNAL AND RADIO STOPPED WORKING. I TOOK IT INTO THE DEALERSHIP AND IT WAS REPAIRED HOWEVER NOW THE RADIO WILL NO LONGER RESPONSE TO ME TURNING THE VOL. UP OR DOWN AS WELL AS I ONLY ONLY SET THE TIME ON MILITARY TIME. NOW ON 9/7 MY BRAKES HAVE STARTED TO GRIND. ON 9/11 MY CAR NOW VIBRATES WHEN I ACCERATE AT 60 MPH +. IN THE PAST WEEK I HAVE ALSO NOTICED THAT MY CAR WILL ACCELLERATE AND HESITATE WHEN IN MOTION. IN THE LAST THREE MONTHS MY GAS MILEAGE HAS SLOWLY DECLINED AS WELL. I AM TAKING IT INTO THE DEALERSHIP TONIGHT - BUT THOUGHT I NEED TO REPORT. SEEMS THERE ARE MANY OTHERS LIKE ME.