2002 FORD FOCUS Unknown Or Other Problems

Sunroof Exploded. Empty Road, temp low 40s. No warning. I have owned the car since 2004. Though older car, <120,000 miles.

The drivers door will not open. It is stuck shut. Turning the key in the lock does not work. Broke outer handle trying to open door to assist elderly party out of drivers seat. Power lock fuse is fine. Took door panel off partly to expose cable, cannot push or pull cable to force open. Safety issue because owner is elderly. Cannot reasonably crawl in and out through passenger side. Emergency personnel would not be able to reach occupants in case of an accident.

ANTITHEFT HAS CAR LOCKING UP WHILE DRIVING

IGNITION KEY WILL NOT TURN! THEY HAVE KNOWN (FORD) ABOUT THIS ISSUE AND ARE REFUSING TO ISSUE A RECALL.

WAS DRIVING MY CAR WHEN PASSENGER SIDE WINDOW SHATTERED AND COVERED MY PASSENGER WITH GLASS.WINDOW WAS IN HALFWAY BETWEEN UP AND DOWN POSITION. NO EVIDENCE OF ANYTHING THROWN AT WINDOW AND PASSENGER WAS NOT MESSING WITH WINDOW IN ANY WAY. NO INJURY TO THIS PASSENGER. ALMOST CAUSED AN ACCIDENT. WINDOW WAS REPAIRED AND REPLACED AT MY EXPENSE AND A MONTH LATER IT HAPPENED A SECOND TIME IN A DRIVE-THRU. MY WINDOW SHATTERED AGAIN WHEN THE PASSENGER WENT TO ROLL UP THE WINDOW WITH THE AUTOMATIC SWITCH AND IT COVERED HIM IN GLASS AND HIS HAND WAS CUT. *TR

AFTER 2 COMPLAINTS TO DEALER ABOUT REAR BRAKE VIBRATION/NOISE, THEY FOUND NOTING WRONG. ON OUR TRIP GOING DOWN INTERSTATE 40 AT 70 MPH THE BACK WHEEL COMES OFF MY CAR. THE WHEEL AND HUB ARE BROKEN,CUTS THE BRAKE LINE AND I LOSE MY BRAKE FLUID. NO BRAKES AND TRYING TO KEEP IT OUT OF THE DITCH. IF THERE WOULD OF BEEN A CAR ON THE SIDE OF ME. I AM POSITIVE THERE WOULD HAVE BEEN INJURY/DEATH. HAD EXTENDED WARRANTY. FORD PAID 0. SAID I HIT SOMETHING IN ROAD. NOW AT THE REPAIR SHOP AGAIN. THE WHEEL BEARINGS ON THE REAR ARE FROZEN . I HAVE TO BUY NEW DRUMS FOR BOTH SIDE AGAIN. *TR

2002 FOCUS, STALLING OUT AT HIGH SPEED WITH NO WARNING. WHEN IT HAPPENS IT'S LIKE TRYING TO DRIVE A CAR WITHOUT A BATTERY. NOTHING WORKS. HAPPENED 10 TIMES IN A CAR WITH LESS THAN 70K MILES. WE REPLACED FUEL PUMP, FUEL FILTERS, COIL, SPARK PLUGS AND WIRES, AND CAR WILL NOT STAY RUNNING. KEEPS STALLING. HOW MANY COMPLAINTS BEFORE THIS MODEL IS RECALLED. SOMEONE IS GOING TO DIE AT SOME POINT SINCE THE CAR CANNOT BE CONTROLLED BY THE DRIVER WHEN THIS PHENOMENOM OCCURS. FORD SAYS THERE IS NO KNOWN PROBLEM WITH THIS MODEL. I SHOULDN'T HAVE TO REPLACE A FUEL PUMP ON A CAR WITH LESS THAN 70KON IT. FORD DID CHANGE THE FUEL DELIVERY MODULE FOR OTHER YEARS BUT SAYS THE PROBLEM WAS NOT ON 2002 MODEL. OBVIOUSLY THEY CHANGED IT FOR A REASON. THIS MODEL NEEDS TO BE RECALLED AND HAVE THE "NEW" FUEL DELIVERY MODULE INSTALLED....

TWO NIGHTS AGO I DROVE MY 2002 FORD FOCUS ZX3 TO A NEARBY BANK TO USE THE WALK-UP ATM. SINCE IT WAS AFTER BUSINESS HOURS, I PARKED ALONG A CURB, BUT NOT IN A PARKING SPACE. I USED THE ATM AND UPON RETURNING TO THE CAR, MY KEY REFUSED TO TURN IN THE IGNITION CYLINDER. IT WAS AS IF ALL OF THE SUDDEN MY KEY WAS THE WRONG KEY FOR THE VEHICLE. SINCE I WAS NOT IN A PARKING SPOT, I PUT ON MY HAZARD LIGHTS AND RAN A HALF MILE TO MY HOME TO RETREIVE MY SPARE KEY. UPON RETURNING, I FOUND THAT IT DID NOT WORK EITHER. NO MATTER WHAT I TRIED, THE KEY WOULD NOT TURN IN THE IGNITION CYLINDER. I WANTED TO GET THE CAR TO A PARKING SPACE SO I PUT THE CAR (A MANUAL TRANSMISSION) INTO NEUTRAL AND BEGAN PUSHING IT FORWARD. THE STEERING...

I BOUGHT A 2002 FORD FOZUS ZX3 WITH AUTOMATIC TRANSMISSION IN THE FALL OF 2010. I FOUND MYSELF HAVING TROUBLE WITH THE IGNITION KEY NOT TURNING ONCE INSERTED INTO THE IGNITION CYLINDER. THIS OCCURRED QUITE FREQUENTLY (APPROXIMATELY ONCE EVERY TWO WEEKS) AND I HAD TO PLAY WITH THE STEERING WHEEL AND THE KEY FOR AT LEAST FIVE MINUTES EVERY TIME. I DID NOT CONSIDER IT TO BE A SUBSTANTIAL PROBLEM UNTIL LAST NIGHT. I WAS AT MY FRIEND'S APARTMENT AND AROUND 1:30 AM I DECIDED TO LEAVE. I GOT IN MY CAR, INSERTED THE KEY IN THE IGNITION AND COULD NOT TURN IT AT ALL AND THE STEERING WHEEL WAS LOCKED. I WAS IN MY FRIEND'S DRIVEWAY FOR ABOUT A HALF HOUR, TRYING EVERYTHING I COULD POSSIBLY THINK OF TO GET THE STEERING WHEEL TO UNLOCK AND THE KEY TO TURN. I ENGAGED THE GEAR RELEASE AND MANUALLY PUT THE...

1. 2002 FORD FOCUS IGNITION SWITCH PROBLEMS. FOR A WHILE MY 2002 FOCUS HAS BEEN GIVING ME IGNITION SWITCH PROBLEMS. EITHER THE KEY IS STUCK IN THE IGNITION SWITCH AND WON'T COME OUT, OR THE KEY WILL NOT BE ABLE TO TURN THE IGNITION SWITCH. I BOUGHT THE CAR WHEN IT HAD 48,000 MILES ON IT, IT NOW HAS AROUND 67,000. 2. IT HAPPENS ON A FAIRLY REGULAR BASIS. ALTHOUGH USUALLY THE KEY WILL EVENTUALLY TURN, SIMPLY BY REMOVING IT AND PUTTING IT BACK IN THE OPPOSITE WAY. IF THEY KEY IS STUCK IN THE SWITCH, USUALLY RESTARTING IT OR REVERSING AND GOING BACK INTO DRIVE WILL ALLOW YOU TO GET THE KEY OUT. 3. NOW I AM CURRENTLY STUCK AT WORK BECAUSE THE KEY WILL NOT TURN IN MY FOCUS AT ALL! AFTER RESEARCHING THE PROBLEM ONLINE, I HAVE SEEN MANY COMPLAINTS ABOUT THE SAME THING. REFERENCED HERE: HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/FORD-FOCUS/FORD_FOCUS_IGNITION_CYLINDER_BREAKS_FOR_SECOND_TIME...

I HAVE A 2002 FORD FOCUS AND MY IGNITION WON'T TURN. IT JUST FROZE. IT WAS OK. ALL OF A SUDDEN, I HAD AN INTERVIEW TO GET TO AND GOT IN MY CAR AND IT WOULDN'T START. THE KEY JUST WOULDN'T TURN. I AM VERY GRATEFUL THAT I WAS AT HOME WHEN IT HAPPENED. I THINK IT IS A DISGRACE THAT FORD KNOWS THERE IS A PROBLEM AND WON'T DO A RECALL. A RECALL SHOULD NOT BE COMPLETELY ABOUT A SAFETY ISSUE BUT ABOUT PROVIDING THE PUBLIC WITH QUALITY IN THE CARS. OBVIOUSLY, THE CONSUMER IS OF NO IMPORTANCE TO FORD. I THINK THIS WHOLE EXPERIENCE HAS MADE ME DECIDE TO NEVER TRUST A FORD AGAIN. I TOOK THE CAR IN TO TWO MECHANICS WHICH TOLD ME IT WOULD BE A FEW DAYS TO GET THE DEALER PARTS AND THE REPAIR WILL COST OVER $400.00. IT IS A DISGRACE THAT...

1. I WAS DRIVING MY 2002 FORD FOCUS WAGON BACK FROM A CAMPING TRIP AND I WAS GOING ABOUT 60 MPH ON THE FREEWAY 2. ALL OF A SUDDEN THERE WAS A "CRACK"/"BANG" FROM THE BACK OF THE CAR, DRIVERS SIDE, THE CAR CONTINUED WITHOUT JOLTING/SWERVING (I.E. NO AFFECT TO THE DRIVING OF THE VEHICLE), HOWEVER, AFTER ANOTHER FEW MILES THE REAR DRIVERS SIDE WHEEL WAS MAKING A HIGH PITCHED SOUND, PLUS CRACKING, PLUS SOME JOLTING AS THE BEARING REALIGNED ITSELF AT TIMES. I STOPPED THE CAR AND THE HEAT FROM THE WHEEL WAS INCREDIBLE, ONE COULD HAVE FRIED AN EGG ON IT (THIS WHEEL WAS MUCH HOTTER THAN THE OTHERS). UNFORTUNATELY THIS HAPPENED ON A STRETCH OF ROAD WHERE THERE ARE NO TOWNS, NO CELL PHONE SIGNAL, ETC, I WAS FORCED TO DRIVE THE CAR TO A TOWN, MAX OF 40 MPH ON A 60 MPH STRETCH OF ROAD,...

PAINT CRACKING UNDERNEATH CLEAR COAT. *JB

MAYBE ONE YEAR OR SO AFTER I BOUGHT MY BRAND NEW 2002 FORD FOCUS ZTS THERE WAS A REALLY BAD STORM ONE NIGHT AND THE NEXT DAY MY FLOOR BOARD ON THE PASSENGER SIDE WAS SOAKED IN WATER ALMOST LIKE A PUDDLE. THEN THE PAST COUPLE OF YEARS IT'S HAPPENED AGAIN AT LEAST FIVE MORE TIMES. AFTER TAKING OUT THE FLOOR MAT AN ACTUAL PUDDLE OF WATER GATHERS ON MY FLOOR BOARD WHEN IT STORMS. IT DOESN'T SEEM TO HAPPEN EVERY SINGLE TIME IT STORMS BUT IT'S HAPPENED QUITE A FEW TIMES ALREADY. MY CAR IS ONLY GOING ON FOUR YEARS OLD (AND I KEEP IT CLEAN ALL THE TIME AS I'M THE ONLY ONE IN MY CAR, I DON'T HAVE ANY CHILDREN NOR AM I MARRIED AND THEREFORE I AM THE ONLY ONE IN MY CAR AND TAKE REALLY GOOD CARE OF IT) BUT IT SMELLS LIKE IT'S REALLY...

KEY DOES NOT WANT TO COME OUT OF STEERING COLUMN. YOU HAVE TO WRIGGLE THE STEERING WHEEL AND THE KEY. YOU NEVER KNOW WHEN THIS IS GOING TO HAPPEN. IT HAS HAPPENED FROM DAY 1. IT HAS BEEN INTO PARR FORD IN BREMERTON WASHINGTON 4 TIMES FOR THIS PROBLEM, THEY CAN NOT FIND IT. THEY HAVE VERIFIED THAT IT STICKS.

OTHER - LOSE FENDER WHEELSHIELD/TOLD PART ON RECALL AS DEFECTIVE BODY - DINGS IN FENDER PANEL/TOLD PART DEFECTIVE REPLACED UNDER WARRANTY

1)EARLIER THIS YEAR WE TOOK OUR FOCUS IN TO THE DEALER TO CHECK THE POWER STEERING. THEY SAID IT JUST NEEDED POWER STEERING FLUID. I HAVE BEEN PUTTING PS FLUID IN EVERY TWO TO THREE WEEKS. 2)WE HAVE HAD DIFFICULTIES WITH OUR BRAKES, THE LIGHTS STAYING ON AND THEN THE FUSES BURNING OUT. 3)THEN TODAY(8-5-03) THE GEAR SHIFT INTERLOCK GOT STUCK AND IT ONLY WORKS IF IT IS PUSHED IN TO RELEASE.

I BOUGHT THIS CAR BRAND NEW IN SEPTEMBER. THE FIRST PROBLEM THE CAR HAD WAS THAT THE POLLEN FILTER BECAME BLOCKED AND IT HAD BEEN RAINING OUT SO ALL THE WATER FROM OUTSIDE CAME RIGHT INTO MY CAR AND I GOT ABOUT AN INCH OF WATER IN THE PASSENGER SIDE OF MY CAR ALL OVER THE FLOOR. THE ENXT THING THAT HAPPENED WAS MY DRIVER SIDE FRONT TIRE BLEW WHILE DRIVING DOWN A ROAD, THERE WERE NO POTHOLES AND NO CURBS THAT I COULD HAVE HIT FOR THIS TO HAPPEN. ABOUT A MONTH AFTER THIS I NOTICED THAT THE PLASTIC HAD STARTED BUBBLING UP AND PEELING ON THE LOWER B PILLAR ON THE PASSENGER SIDE OF THE CAR, ALSO THE CARPET HAD COME UNGLUED (FROM WHEN MY CAR FLOODED) AND HAD NOW PULLED AWAY FROM THE SILL. ALSO, THE WETHERSTRIPPING HAD COME UNGLUED FROM THE WINDSHIEL AND YOU CAN NOW...

I HAVE HAD THE CAR. FOR ONLY 4 MONTHS. I HAD PROBLEM WITH IT IN OCTOBER IT WAS THE CAR MOVING WHEN I AM DRIVING IT MOVES LIKE A SWERVING MOTION AND THEN IN DECEMBER 13, 2002. I TOOK IT BACK IN WITH THE SAME PROBLEM OF THE BACK SWAYS WHEN HITTING BUMPS AND THE TIRE ROD WAS LOOSE. THE REPAIR WAS 1,140 ON A NEW CAR. I HAD WATER COMING IN THE PASSENGER SIDE AND THEY SAID THEY FIXED THE PROBLEM. ON DEC 31, 2002 IT RAINED AND MY WHOLE FLOOR IS WET. I AM VERY DISCUSSED WITH THIS CAR. BECAUSE IT IS A BRAND NEW CAR. AND I HAVE THE SAME PROBLEM OUT OF IT GOING ON TWO TIMES WITH THE WATER, TWO TIMES WITH THE HITTING OF BUMPS AND THE CAR MOVING SIDE WAYS ALMOST INTO ANOTHER LANE ,AND ONE MORE THING I TOOK THE CAR IN...

THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MORE AND KNOWS OF ALL THE TIMES REPORTED. I HOPE THIS IS JUST NOT A EASY FIX OR THIS NOW HASN'T CAUSED ANY DAMANGE TO THE INSIDE OF THE ENGINE ITSELF, AS THE ENGINE HAS BEEN IN THE SHOP FOR RIDING ROUGH. THEY TOLD ME LAST TIME THAT THE PART OF THE TRANSMISSION THAT WAS FIXED WOULD FIX THIS. I THINK IT IS DUE TO THE OIL LEAK ON THE TOP OF THE ENGINE CASE SINCE IT WAS NEW. A NEW CAR SHOULD NEVER HAVE A OIL...

I BOUGHT THE CAR ON OCT 29, 2002. SINCE DAY ONE THE CAR HAS CONSUMED WAY TOO MUCH GAS. IT IS OUTRAGEOUS! IT HAS BECOME A MORTGAGE PMT! MY CAR PMT IS $344 A MONTH I PAY THE SAME IN GAS A MONTH. I USE TO OWN A 1993 FORD ESCORT,STICK,4 CYC AND NEVER DID I EVER SPEND SO MUCH GAS. I AM 49 YRS OLD, DON?T SPEED, AND KNOW THE DIFFERENCE. I HAVE ALSO OWNED MANY STICK,4 CYL CARS AND NONE HAVE EVER SPEND SO MUCH GAS. THERE HAS GOT TO BE A PROBLEM WITH THE CAR IN THAT RESPECT. SECOND: A COUPLE OF MONTHS AGO THE &#34;CHECK ENGINE&#34; LIGHT CAME ON, EVER SINCE THEN, MY CAR WON'T START IN THE MORNINGS, AND WHEN IT HAS BEEN SITTING FOR A AWHILE. I HAVE BROUGHT MY CAR TO THE DEALER 4 TIMES ALREADY, THEY HAVE CHANGED THE FUEL PUMP 3...

ALL FOUR STUDS ON THE RIGHT FRONT BROKE OFF AND CAUSED DAMAGE TO THE BRAKES, FRONT BUMPER, ALONG WITH A FEW OTHER THINGS. THE DEALER SAID IT WAS MY FAULT BECAUSE I HAD A MECHANIC BESIDES THEM CHANGE THE BRAKES ON IT. I HAD MY 2 MONTH BABY NIECE IN THE BACK ALONG WITH 3 OTHER PEOPLE. THE OTHER PROBLEM I HAVE IS THE SEAL ON THE WINDSHIELD IS COMING OUT NEAR THE ROOF.

REAR TIRES TRACTION FAILED. AS A RESULT, VEHICLE BECAME UNCONTROLLABLE. *AK THE CONSUMER STATED WHEN THE ROADS WERE WET, THE VEHICLE WAS HARD TO CONTROL. THE VEHICLE WAS TAKEN TO THE DEALER AT LEAST 6 TIMES FOR THE SAME PROBLEM, THREE OF THE SIX TIMES THE DEALER REPLACED THE TIRES, HOWEVER THAT DID NOT RESOLVE THE PROBLEM. *JB

2002 FORD FOCUS SE WAGON NOTICED RAIN WATER LEAKING INTO PASSENGER COMPARTMENT VIA HEATING/COOLING COWLING ON PASSENGER SIDE WETTING FLOOR MAT SIGNIFICANTLY TILL THE POINT IT WAS COMPLETELY SOGGY. CHECKED GRILL BETWEEN HOOD AND WINDSHIELD AND NOTED NO LEAVES BLOCKING DRAINS. NOTED RUBBER DAM NOT CONTINUOUS, AND WATER APPEARED TO BE LEAKING INTO ENGINE COMPARTMENT VIA ONE OF THESE GAPS AND THEN INTO THE HEATING/COOLING COWLING ALONG TOP SURFACE OF REAR OF ENGINE COMPARTMENT. THE FIT BETWEEN THE COWLING AND THE 'FIREWALL' AT THE BACK OF THE ENGINE COMPARTMENT IS NOT GOOD, AND THERE ARE GAPS ALONG THE ENTIRE TOP SURFACE ALLOWING WATER TO DRAIN IN. *LA

AT LEAST TWICE A WEEK MY CAR TAKES 2-5 TRIES TO START. AFTER IT STARTS, IT RUNS VERY ROUGH AND FEELS LIKE IT'S GOING TO STALL...SOMETIMES IT DOES IF I'M AT A LIGHT. I HAVE A STICK SHIFT AND THERE'S NO INDICATION ON THE IDLE THAT IT'S RUNNING LOW. MY CAR HAS BEEN IN THE SHOP MORE THAN I'VE HAD IT FOR THE LAST SIX MONTHS. FORD TELLS ME THEY HAVEN'T RECEIVED ANY COMPLAINTS LIKE THIS AND THE DEALERSHIP HAS TOLD FORD THEY CAN'T REPLICATE THE PROBLEM...EVEN THOUGH THEY'VE TOLD ME ON A COUPLE OF OCCASIONS THAT THEY HAVE. USUALLY THEY DON'T REPLACE ANYTHING BUT SO FAR THEY'VE REPLACED MY EGR VALVE, FUEL PUMP, AND GAS TANK. THE DEALERSHIP HAS BEEN INCONSISTENT ON HOW THEY DOCUMENT THE TIME MY CAR'S BEEN IN THE SHOP AND WITH A ONE YEAR OLD AND A FOUR YEAR OLD...I CAN NO LONGER TAKE TIME...

FORD FOCUS ZX5 2002 - DRAMATICALLY POOR HANDLING ON SLIPPERY ROAD SURFACE. ? FAULTY BRAKING SENSOR / ? POOR SUSPENSION / ?? CAUSED LOSS OF CONTROL NUMEROUS TIMES ON FLAT EVEN HIGHWAY SURFACE. ON PATCHES OF ICE - BACK END OF CAR VEERS BADLY TO LEFT (SIDEWAYS NOT FRONT END). IN SNOW COVERED SECTIONS BACK END FISHTAILS EXCESSIVELY EVEN AT LOW SPEEDS (20 MPH). FORD SERVICE DEPARTMENT STATED THAT THERE WAS NO CAUSE FOR THIS PROBLEM. THEY WERE UNABLE TO REPRODUCE THE BEHAVIOUR ON DRY CLEAR ROAD SURFACE.

KEY DOES NOT WANT TO COME OUT OF THE STEERING COLUMN WHEN COLD. YOU HAVE TO WRIGGLE THE STEERING WHEEL AND THE KEY. IT HAS BEEN INTO THE DEALER AND THEY HAVE NOTED THE PROBLEM 4 TIMES BUT CAN NOT FIGURE IT OUT.

CONSUMER REQUESTED INFORMATION REGARDING THE FORD FOCUS.*DT *JB

AT APPROX THREE HOURS AFTER PURCHASING OUR NEW FOCUS, WE WHERE DRIVING ON THE FREEWAY. THE VEHICLE BEGAN TO JERK, AND THE SPEEDOMETER WENT FROM 60 TO 140, AND RETURNED TO ZERO. THE VEHICLE THEN CAME TO A STALL. WE THEN NOTICED THAT THE CHECK ENGINE LIGHT CAME ON, THE FUEL CAP, AND THE ENGINE SERVICES SOON. WE WERE ABLE TO RESTART THE VEHICLE, BUT APPROX 5 MINUTES LATER, THE ENGINE SHUT OFF. WE THEN RETURN THE VEHICLE TO THE DEALER FOR REPAIRS. THE SERVICES DEPARTMENT STATED THAT THE CAUSES WAS A LOOSE GROUNDS, AND INCOMPLETE CIR. THE SERVICES DEPARTMENT CORRECTIONS WERE DIAG. LED TO LOOSE GROUND CONNECTIONS NEAR BATTERY. A FEW DAYS LATER THE VEHICLE DID NOT WANT TO START, AND IT TOOK 2 ATTEMPT'S TO START THE VEHICLE.*AK